Southbend Range P18N-F Parts Manual
IMPORTANT FOR FUTURE REFERENCE
Please complete this information and retain this
___________________________
___________________________
_____________________
manual for the life of the equipment:
Model #:
Serial #:
Date Purchased:
Platinum Series Ranges
Parts Manual
Flush Open Burner Models
Step-Up Open Burner Models
Combination Open-Burner Hot-Top Models
Combination Open-Burner Griddle Models
Model P32N-PPP
Graduated Hot-Top Models
Uniform Hot-Top Models
Plancha Models
French Top Models
Model P32A-XX
Charbroliler Models
Standard Griddle Models
Thermostatic Griddle Models
Wood Smoker
Model P32N-BBB
Model P32N-HH
Model P32N-GRAD
PARTS MANUAL 1199791
REV 0 (1/15)
Model P32N-CC
Model P48W-CCCC
Model P32N-TT
Model P18N-F
1100 Old Honeycutt Road Fuquay-Varina, North Carolina 27526 USA
www.southbendnc.com
PLATINUM SECTIONAL RANGE
MANUAL SECTION SR
PLATINUM SERIES RANGE PARTSPARTS
Replacement parts may be ordered either through a Southbend Authorized Parts Distributer or a Southbend Authorized
Service Agency. It is recommended to verify parts numbs with a Southbend Authorized Parts Supplier or the Southbend
Parts/Service Department prior to ordering parts.
PARTS
The following tables and gures list serviceable parts. For parts that are not listed, contact a Southbend Authorized Parts
Distributor or a Southbend Authorized Service Agency.
Table of Contents
Page Number Description
3 33K-Open-Burner External and Structural Parts
5 33K-Open-Burner Gas Train Parts
7 45K-Open-Burner Parts
9 Charbroiler External and Structural Parts for 16” and 32” Models
11 Charbroiler External and Structural Parts for 12”, 24”, 36”, and 48” Models
13 Wood Smoker External and Structural Parts for 36”, 48”, 60” and 72” Models
15 Charbroiler and Standard-Griddle Gas Train Parts
16 Gas Connection Parts
17 Griddle External and Structural Parts
19 Thermostatic Griddle Gas Train Parts
21 Uniform Hot-Top Parts
23 Graduated-Hot-Top Parts
25 Oven Base Parts
27 Convection Oven Blower Parts
28 Modular-Countertop Base Parts
29 Cabinet-Base Parts
31 Flue Riser Parts
32 Front-Rail Parts
33 Shelf Parts
34 Side Panel and Battery-Assembly Parts
35 Leg and Caster Parts
Copyright © 2014 by Southbend. All rights reserved. Published in the United States of America.
2
PAGE
OF 47
PARTS MANUAL 1199791 REV 0 (1/15)
PLATINUM SERIES RANGE PARTS PARTS
33K-Open-Burner External and Structural Parts
See drawing on following page
Key Part Number Description
1 Service TRAY ASSEMBLY
2 1189600 KNOB
3 Service VALVE PANEL
4 Service BURNER REST
5 Service SUPPORT, PILOT (for ush-top models)
6 Service BRACKET, PILOT SUPPORT (for ush-top models)
7 Service TRIM, FLUE RISER
8 Service TRIM, 42 DEEP FLUE RISER
9 1183500 CAST IRON GRATE, SECTIONAL 12”
10 1173385 CAST IRON GRATE, BBB 32”
11 Service SUPPORT W/A, STEP-UP GRATE
12 Service BURNER REST, STEP-UP
13 Service BRACKET, REAR BURNER REST (for step-up models)
14 Service BRACKET, ORIFICE (for rear burners of step-up models)
15 Service BRACKET, REAR PILOT (for rear pilots of step-up models)
16 Service BRACKET, STEP-UP PILOT (for front pilots of step-up models)
* Quantity of part used may depend on width of section (12”, 24”, 32”, 36”, or 48”)
* Service means call a Southbend Parts/Service Department (919-762-1000)
PARTS MANUAL 1199791 REV 0 (1/15)
PAGE
3
OF 47
Figure 1
33K-Open-Burner External and Structural Parts
9
Flush 33K-Open-Burner Models
6
PLATINUM SERIES RANGE PARTSPARTS
10
8
7
4
5
4
2
3
4
12
13
15
11
14
PAGE
4
1
OF 47
16
Step-Up 33K-Open-
Burner Models
32"-Wide Models Shown
PARTS MANUAL 1199791 REV 0 (1/15)
PLATINUM SERIES RANGE PARTS PARTS
33K-Open-Burner Gas Train Parts
See drawing on following page
Key Part Number Description
1 Service MANIFOLD W/A
2 1179222 NIPPLE, EXTENSION
3 1178202 VALVE, HI-OFF, NAT/LP
4 1179188 EXTENSION, ORIFICE
** 1008741 ORIFICE, NAT GAS (if appliance will operate above 2000 ft, contact Southbend for appropriate orice size)
** 1008751 ORIFICE, PROPANE (if appliance will operate above 2000 ft, contact Southbend for appropriate orice size)
5 1182193 BURNER ASSEMBLY, OPEN TOP
** 1182195 FITTING, 1/2" COMP 1/4" NPT (connects rear-burner gas tube to valve)
6 1182192 TUBE, REAR BURNER
7 1182191 ORIFICE FITTING
8 1166004 FITTING, DOUBLE PILOT, 3/16" TUBE
9 1183605 PILOT TUBE W/A REAR
10 1183603 PILOT TUBE W/A FRONT
11 1177106 TUBE ASM, REAR BURNER PILOT (for rear pilots of step-up models)
12 1184646 TUBE, REAR BURNER STEP-UP (for left rear and center rear burner of step-up models)
13 1184647 TUBE, REAR BURNER STEP-UP (for right rear burner of step-up models)
* Quantity of part used may depend on width of section (16”, 18”, 32”, or 36”)
* Service means call a Southbend Parts/Service Department (919-762-1000)
** Not shown on drawing
PARTS MANUAL 1199791 REV 0 (1/15)
PAGE
5
OF 47
Figure 2
33K-Open-Burner Gas Train Parts
Flush 33K-Open-Burner Models
1
6
8
PLATINUM SERIES RANGE PARTSPARTS
7
2
5
9
10
3
1
2
3
4
12
8
12
4
10
5
Step-Up 33K-Open-Burner Models
7
13
11
PAGE
6
32"-Wide Models Shown
OF 47
PARTS MANUAL 1199791 REV 0 (1/15)
PLATINUM SERIES RANGE PARTS PARTS
45K-Open-Burner Parts
See drawing on following page
Key Part Number Description
1 1189600 KNOB
2 Service VALVE PANEL
3 Service TRAY ASSEMBLY, CRUMB
4 Service BURNER SUPPORT
5 1179229 SUPPORT, PILOT
6 Service TRIM 36 DEEP FLUE RISER
7 Service TRIM 42 DEEP FLUE RISER
8 1179247 CAST IRON GRATE
9 Service MANIFOLD W/A
10 1179222 NIPPLE, EXTENSION
11 1178202 VALVE, HI-OFF, NAT/LP
** 1008735 ORIFICE, NAT GAS (if appliance will operate above 2000 ft, contact Southbend for appropriate orice size)
** 1008750 ORIFICE, PROPANE (if appliance will operate above 2000 ft, contact Southbend for appropriate orice size)
12 1165742 VENTURI (for front burners)
13 1165741 VENTURI (for rear burners)
14 1179230 BURNER HEAD, 40
15 1177043 COVER, BURNER DRIP
16 1166004 FITTING, DOUBLE PILOT, 3/16" TUBE
17 1179246 PILOT W/A, REAR
18 1179244 PILOT W/A, FRONT
19
* Quantity of part used may depend on width of section (12”, 18”, 32”, or 36”)
* Service means call a Southbend Parts/Service Department (919-732-1000)
** Not shown on drawing
1179240 BURNER (for front)
1179241 BURNER (for rear)
PARTS MANUAL 1199791 REV 0 (1/15)
PAGE
7
OF 47
Figure 3
45K-Open-Burner Parts
PLATINUM SERIES RANGE PARTSPARTS
PAGE
8
OF 47
PARTS MANUAL 1199791 REV 0 (1/15)
PLATINUM SERIES RANGE PARTS PARTS
Charbroiler External and Structural Parts for 16” and 32” Models
See drawing on following page
Key Part Number Description
1 1189600 KNOB
2 Service VALVE PANEL
3 1184773 COVER, VALVE SHIELD
4 Service BRACKET, ORIFICE
5 Service SHIELD, VALVE HEAT
6 Service SHIELD, CHARBROILER HEAT
7 Service TRAY W/A, CHARBROILER CRUMB
8 1185654 SHIELD, CHAR HEAT DEFLECTOR
9 Service SUPPORT, CHAR REAR GRATE
10 Service TRIM, CHAR/GRI FLUE RISER
11 Service CHARBROILER W/A
12 1183541 SHIELD, LEFT DRIP
13 1183542 SHIELD, RIGHT DRIP
14 Service SUPPORT, CHARBROILER GRATE
15 Service SHIELD, REAR DRIP
16 1185647 RADIANT W/A 32
17 1182657 GRATE, LAVA ROCK
** 1173193 LAVA ROCK BRIQUETTES, BAG
18 1178976 CHARBROILER GRID
** 1182838 PLATED FISH GRID
* Quantity of part used may depend on width of section (16”, or 32”)
* Service means call a Southbend Parts/Service Department (919-762-1000)
** Not shown on drawing
PARTS MANUAL 1199791 REV 0 (1/15)
PAGE
9
OF 47
PLATINUM SERIES RANGE PARTSPARTS
Figure 4
Charbroiler External and Structural Parts for 16” and 32” Models
18
17
16
15
14
12
13
10
9
11
7
6
5
4
3
8
PAGE
10
OF 47
1
2
PARTS MANUAL 1199791 REV 0 (1/15)
PLATINUM SERIES RANGE PARTS PARTS
Charbroiler External and Structural Parts for 12”, 24”, 36”, and 48” Models
See drawing on following page
Key Part Number Description
1 1189600 KNOB
2 Service VALVE PANEL
3 1184773 COVER, VALVE SHIELD
4 Service SHIELD, VALVE HEAT
5 Service BURNER REST, CHAR/GRI
6 Service SHIELD, CHARBROILER HEAT
7 Service TRAY W/A, CHARBROILER CRUMB
8 1184994 BRACKET, RADIANT STOP
9 Service TRIM, CHAR/GRI FLUE RISER
10 Service TRIM, 42 DEEP CHAR/GRI FLUE RISER
11 1183541 SHIELD, LEFT DRIP
12 1183542 SHIELD, RIGHT DRIP
13 Service SUPPORT, CHRBRLR GRATE
14 Service SHIELD, REAR DRIP
15 Service CHARBROILER W/A, 24
16 1183676 RADIANT W/A
17 1182657 GRATE, LAVA ROCK
** 1173193 LAVA ROCK BRIQUETTES, BAG
18 1178976 CHARBROILER GRID
** 1182838 PLATED FISH GRID
* Quantity of part used may depend on width of section (12”, 24”, 36”, or 48”)
* Service means call a Southbend Parts/Service Department (919-729-3129)
** Not shown on drawing
PARTS MANUAL 1199791 REV 0 (1/15)
PAGE
11
OF 47
PLATINUM SERIES RANGE PARTSPARTS
Figure 5
Charbroiler External and Structural Parts for 12”, 24”, 36”, and 48” Models
18
17
16
14
15
11
6
5
4
3
13
12
8
7
10
9
PAGE
12
1
OF 47
2
PARTS MANUAL 1199791 REV 0 (1/15)
Loading...