Southbend P36W-CCC User Manual
Wood Smoker
Full-Width Charbroiler
Standard Features
• Standard (2) years limited parts and labor warranty
(reference http://www.southbendnc.com/#SBvservice.html
for limited warranty details).
• 36", 48", 60", 72"-wide sectional range with full-width
charbroiler with smoker base.
• 16,000 BTU burners with high/low control knobs
• Removable cast iron grates with adjustable front-to-back
slope that ip over for either 1/8" or 1/4" grid width
• 600°F even surface temperature on high setting
• Stainless steel burner radiants
• 9-1/4" front rail
• Removable drip tray
• Stainless steel front and sides
• 1-1/4" front gas manifold and 1" rear gas connection
• 5" high stainless steel ue riser
• Free battery-design assistance
Standard Features of Smoker-Base Models
• Heavy duty stainless steel construction
• Stainless steel or black powder coated handle
• Available with adjustable legs or casters
• Stationary wood rack standard.
• “Insta-On” thermostat ranging from 150°F to 500°F
P36W-CCC
P48W-CCCC
P60W-CCCCC
P72W-CCCCCC
Job Item#
STANDARD CONSTRUCTION SPECIFICATIONS
Exterior Finish: Front and sides constructed of #3
polished 430 and 304 stainless steel.
Range: 36", 48", 60", and 72" -wide front-manifold sectional
range with 16,000 BTU burners. Full-width charbroiler with
removable cast iron grates and operating surface
temperature of up to 600°F (315°C).
Front Rail: 9-1/4" front rail.
Form Wood Smoker Rev 1 (January/2014)
www.yatesgd.com www.yatesgraphicdesign.com
(P36W-CCC shown with optional casters)
Flue Riser 5" high stainless steel ue riser
Battery: Unit can be in any position in a battery. If the unit is
at the end of the battery, the end side will be solid (rather
than have a coverplate over the end of the front manifold).
Legs: 6" stainless steel adjustable legs standard.
Printed in USA
Models:
FRONT VIEW
B
TOP VIEW
SIDE VIEW
36"
(914)
A
17”
(432)
34”
(864)
37.5”
(953)
33”
(838)
P36W-CCC P48W-CCCC P60W-CCCCC P72W-CCCCCC
P36W-CCC
P48W-CCCC
P60W-CCCCC
P72W-CCCCCC
Dimensions shown in inches and (millimeters)
Dimensions
moDel A B
36"
27.5"
(914)
(699)
48"
39.5"
(1219)
(1003)
60"
51.5"
(1524)
(1308)
72"
63.5"
(1829)
(1612)
UTILITY INFORMATION
moDel
P36W-CCC 96,000 84,000
P48W-CCCC 128,000 112,000
P60W-CCCCC 160,000 140,000
P72W-CCCCCC 192,000 168,000
GAS: Each unit has a 1-1/4" front manifold that couples to the
adjacent sectional unit(s), and a 1" rear gas connection with a
male NPT connector. Minimum gas supply pressure is 7" W.C. for
natural gas and 11" W.C. for propane. All sectional units require a
regulated gas supply (a pressure regulator must be ordered
separately). If using a exible-hose gas connection, the inside
diameter of the hose must not be smaller than the connector on
the unit and must comply with ANSI Z21.69, providing an adequate
means of restraint to prevent undue strain on the gas connection.
GAs (BTU/hoUr)
n
ATUrAl ProPAne
OPTIONS and ACCESSORIES
External pressure regulator
Front rail options:
Cutouts in front rail for sauce pans
7-1/4" deep front rail (to match old
style sectional)
Square belly bar mounted on
7-1/4" deep front rail
Casters (front two casters lock)
Cable restraint kit (to restrict
movement when on casters)
24" or 36" high ue riser
Open-frame base with casters for
battery
MISCELLANEOUS
• If casters are used with a exible-hose gas connection, a
restraining device should be used to prevent undue strain
on the hose.
• Minimum clearance from noncombustible construction
is zero (except there must be 2" clearance behind the
blower motor of convection-oven models). For use in
noncombustible locations only.
• Installation under a vented hood is recommended.
• Check local codes for re and sanitary regulations.
NOTICE:
Southbend has a policy of continuous product research and
improvement. We reserve the right to change specications and
product design without notice. Such revisions do not entitle the buyer
to corresponding changes, improvements, additions or replacements
for previously purchased equipment.
Extra-deep rear-extending ue riser
Stainless steel oven interior
Removable shelf inside cabinet
Plated sh grids
Form Wood Smoker Rev 1 (January/2014)
INTENDED FOR COMMERCIAL USE ONLY.
NOT FOR HOUSEHOLD USE.
1100 Old Honeycutt Road, Fuquay-Varina, NC 27526
(919) 762-1000 www.southbendnc.com
Loading...