PARTS LIST
GAS TILTING SKILLET MODELS GMTS-30
GMTS-40
1100 Old Honeycutt Road
Fuquay-Varina. NC 27526
(919) 552-9161 FAX (919)
552-9798 (800) 348-2558
PARTS LIST
HYDRAULIC OIL
AWM32 OR EQUIVALENT
(4.54 L)
HYDRAULIC CYLINDER LOWER CONN
PARTS LTST
FROM FIGORE 1
ITEM PART NDMBER DESCRIPTION GMTS30 GM3S40
1 2428-1 Flue 1
2472-1 Flue 1
2 9-3227 Cover Assy. 1
9-3227/1 Cover Assy.
3** 4-PL07 Pilot-Red (Temp) 120V 1 1
4-PL07-1 Pilot Red (Temp) 240V 1 1 OPT
4 4-PL04/2 Pilot Green (Ignition) 1 1
5** 4-PL06 Pilot-Amber (Power) 120V 1 1
4-PL06-1 Pilot-Amber (power) 240V 1 1 OPT
6 4-TK08 Dial 1 1
4-TB05 Bezel 1 1
7 4-MS 03 Up/Down Switch 1 1
8 4-S101 Power Switch 1 1
9 5-MC02 Magnetic Catch 2 2
10 9-3056 Ignition Module 1 1
11** 9-3011 Temp. Controller c/w pot 120V 1 1
9-3011-1 Temp. Controller 240V 1 1 OPT
12 4-T266 Transformer 120V/240V PR. 1 1
24V SEC.
13 4-35ED Ground Lug 1 1
14 4-22TB Terminal Block 2 2
4-22ES End Section
15** 9-3048
9-3049
Thermal Overload
Relay Heater
1
1
16 9-3009 Gas Solenoid Valve 1 1
17** 9-3008 Pressure Regulator NAT 1 1
9-3008-1 Pressure Regulator LP 1 1
18 9-2007 Manual Shut Off Valve 1 1
19 9-3035 Clevis 1 1
9-3036 Pin 1 1
20 4112-1 Hyd. Cylinder 1 1
9-3318 Cylinder Kit
21 4109-1 Street Elbow 1 1
1
1
1
ITEM PART NUMBER DESCRIPTION GMTS30 GMCS40
22 9-3039 Pin 1 1
23* 9-3057 Wire Harness for 9-3056 1 1
24* 9-3016 . Glow Coil 1 1
25* 9-3017-1 Sensor 1 1
26* 9-3021 Hi-Limit Thermostat 1 1
27* 9-3058 Thermocouple 1 1
28* 3202-1 Side Panel 2 2
29* 9-3393 Control Panel Label 1
30* 9-3394 Control Panel Label 1
31* 3684-1 Control Box Cover 1 1
32* 2573-1 RH Door Assy 1
2573-2 RH Door Assy
33* 3209-1 LH Door Assy 1
3596-1 LH Door Assy
34* 8-1308 Adj. Flanged Feet 2 2
35* 5-FS64 Adj. Foot 2 2
36* 9-3303 Strainer 1 1
37* 3895-1 Faucet Bracket 1 1
* NOT SHOWN
* * SELECT AS REQUIRED
* * * NOT USED ON ALL MODELS MOTOR MAY
HAVE THERMAL OVERLOAD BUILT IN
1
1
PARTS LIST
PARTS LIST
FROM FIGURE 2
ITEM PART NUMBER DESCRIPTION GMTS 30 GMT3 40
1* * 4101-1 1/2 H.P. Motor 1 1
115/208/230/240
4101-2 1/2 H.P. Motor 380/480V 1 1 OPT
4101-3 1/2 H.P. Motor 220V 50HZ 1 1 OPT
2* * 4106-1 Directional Control Valve 1 1
3 9-3032 Gear Pump 1 1
4 9-3042 Bolt Kit 1 1
5 9-3033 Tank 1 Gallon 1 1
6 9-3034 Filler Breather 1 1
7 4107-1 Flow Control 1 1
8 4108-1 Hose Assy. 1 1
9 4108-1 Hose Assy. 1 1
10 4110-1 Elbow 1 1
11 4109-1 Street Elbow 1 1
12 . 4111-1 Nipple 1 1
13 9-3046 Sub Plate 1 1
14** 9-3018 Manifold Assy. 1
9-3018-1 Manifold Assy. 1
15 9-3025 Orifice Nipple 4 6
16** 9-3351-44 Burner Orifice NAT 4
9-3351-47 Burner Orifice NAT
9-3351-55 Burner Orifice LP 4
9-3351-56 Burner Orifice LP
17 9-3020 Burner 4 6
18 9-3027 Sub Manifold Assy 1 1
(Alternate)
9-3027-1 Sub Manifold Assy 1 1
19** 9-3335-56 Lighter Orifice NAT 1 1
9-3335-65 Lighter Orifice LP 1
9-3335-72 Lighter Orifice LP
20** 9-3019 Lighter Tube 1
9-3019-1 Lighter Tube 1
** SELECT AS REQUIRED
6
6
1
PARTS LIST
HINGE ASSY.
ITEM NUMBER PART NUMBER DESCRIPTION 24 & 30 GAL OTY
9-3184 Small Hinge Assy. 1
1 8-2029 Lock Pin 1
2 8-2035 End Lock Plate 1
3 8-2036 Stationary Disc 1
4 8-2025S Core 2
5 8-2026S Spring 1
6 8-2037 Rotary Disc 1
7 8-2034 End Stop Plate 1
8 1-56S6 Cap Screws 4
40 GALLON
9-3185 Large Hinge Assy. 1
1 8-2029 Lock Pin 1
2 8-2035L End Lock Plate 1
3 8-2023 Stationary Disc 1
4 8-2025 Core 2
5 8-2026 Spring 1
6 8-2024 Rotary Disc 1
7 8-2021 End Stop Plate 1
8 1-66S6 Cap Screws 4
Loading...