Southbend GCX-2-10 User Manual

GAS COMPARTMENT STEAMER

WITH SOLID STATE CONTROLS

KETTLE

AND

Model Compartments Capacity

GCX-2-6 2 4-12 Pans

GCX-2-10 2 4-12 Pans

OPERATION SHALL BE BY:

Gas heated steam boiler operating at 15 psi (103 kPa)
and rated at:

❏ 200,000 BTU (standard)

❏ 250,000 BTU (optional at extra cost)

The steam boiler shall be equipped for operation on:

❏ Natural Gas

❏ Propane Gas

The controls shall be equipped for operation on:

❏ 115 VAC, 1 Phase, 60 Hz

Job Item#

SPECIFICATIONS:

Shall be a Model ___________________________________,
Convection Steamer complete with 6 or 10 Gallon Kettle on a

common base with gas steam generator. Solid State touch
control panel, one per compartment each with 99 minute
capacity digital timer. Compartments designed for ease of
cleaning, front drain to collect condensate from open doors.
Steamer, Kettle, cooking compartments, doors and table top
constructed of 304 stainless steel, exterior in a No. 4 finish.
Each cooking compartment is insulated, the doors have a
removable inner liner of stainless steel with full perimeter gasket
seal, an outer liner of one piece all welded stainless steel and
a positive lock and seal mechanism with spring release. The
door opening is 10 x 14 (254 x 356mm). Each compartment
has removable stainless steel pan supports.

Control housing is accessable through a fully removable side
panel. Controls consist of illuminated ON/OFF power switch,
99 minute timer which sounds an audible signal at end of
cooking cycle. Steam to the chamber is cut off when door is
open during the cooking cycle and reactivated when door is
closed. The Kettle is conveniently mounted beside compartment
cooker complete with let mounted steam control valve.

The cabinet base has a full perimeter angle frame, reinforced
counter & boiler mountings, gas boiler with controls, all stainless
steel exterior hinged doors and 6" stainless steel legs with
adjustable bullet feet.

OPTIONAL ITEMS AT EXTRA COST:

❏ 12" x 20" x 2-1/2" perforated stainless steel pan

❏ 12" x 20" x 4" perforated stainless steel pan

❏ 12" x 20" x 4" solid stainless steel pan

❏ Spray and rinse assembly

❏ Steam take-off kit

❏ Automatic boiler blowdown

❏ Kettle type 316 Liner

❏ 220 or 240 VAC, 1 Phase, 50 Hz

Form GCX-2-6/10

www.yatesgd.com www.yatesgraphicdesign.com

08/04 Printed in USA

Models:

 GCX-2-6  GCX-2-10

SERVICE CONNCETIONS

– COLD WATER: 1/2" (13 mm).

– DRAIN: 2" (51 mm) IPS piped to open floor drain. No solid connection.

– ELECTRICAL CONNECTION: 1/2" (13 mm) conduit connection to controls. 2 Amps per compartment, 120-60-1 or 220-50-1.

– STEAM TAKE-OFF CONNECTION: 3/4" (19 mm) optional to operate adjacent equipment.

– GAS CONNECTION: 3/4" (19 mm) IPS.

DIMENSIONS

MODEL UNITS A B C D E F G H J K L M N O P Q R S

GCX -2-6

GCX-2-10in(mm)

44"

(1100)

48"

(1200)

33"

(838 )

14"

(357 )6"(152)

28"

58"

(711)

(1479)6"(152 )8"(203 )

14"

22"

(357)

(559)2"(51)4"(102)6"(152 )2"(51)4"(102)5"(127)6"(152)

UTILITIES

MODEL BTU/HOUR KCAL/HOUR FUEL WATER COLUM N PRESSURE

GCX-2-6 200,000 50,632

GCX-2-10 250,000 63,291

Natural 4" (102 mm)

Propane 11" (279 mm)

Natural 4" (102 mm)

Propane 11" (279 mm)

Form GCX-2-6/10

INTENDED FOR COMMERCIAL USE ONLY.

NOT FOR HOUSEHOLD USE.

1100 Old Honeycutt Road, Fuquay-Varina, NC 27526

[phone] www.southbendnc.com

www.yatesgd.com www.yatesgraphicdesign.com