Southbend GCX-16 User Manual

Two ComparTmenT

16 Pan Steamer

SPECIFICATIONS:
Shall be a Model GCX-16 convection steamer with gas steam

boiler. The steamer shall be constructed of satin nish stainless

steel, type 304, with a cooking chamber of one piece all welded
316 stainless steel. The doors shall have a removable inner
liner of stainless steel with full perimeter gasket seal, an outer
liner of one-piece all welded stainless steel and a positive lock
and seal mechanism. The door opening shall be 14” x 26.5”
(356 x 673mm).

The steamer shall be provided with removable stainless steel
pan supports and a stainless steel drip trough connected to the
drain to collect condensate when door is opened.

The control housing shall be constructed of stainless steel with
a full access removable panel. The timing of each cooking
compartment shall be independently controlled by a “60” minute
timer, a green ready pilot light and a red cook pilot light. At the
end of the cooking cycle an audible signal is sounded. Steam

ow to the cooking chamber shall be interrupted when the door

is opened during the cooking cycle and shall be reactivated
when the door is closed.

The convection steamer shall be mounted on a cabinet base
with full perimeter angle frame, reinforced counter, and boiler
mountings, gas boiler with controls, all stainless steel exterior,
hinged doors and 6” (152mm) stainless steel legs with adjustable

bullet feet for securing to the oor.

with

ComPartment Pan CaPaCity

model

GCX-16 8 4

OPERATION SHALL BE BY:

Gas heated steam boiler, operating at 15 psi (103kPa)
rated at 300,000 BTU.

The gas boiler shall be equipped to operation on:

 Natural gas
 Propane gas

The controls shall be equipped for operation on:
 115 VAC, 1 Phase, 60 Hz

OPTIONAL ITEMS AT EXTRA COST:

 Automatic boiler blow down
 220 or 240 VAC, 1 Phase, 50 Hz
 Two water lines (boiler feed and condensate)
 De-lime piping assembly (DPA-1)
 Stainless steel frame
 Stainless steel back on cabinet
 California State boiler code requirement
 CSD-1
 Electronic ignition
 Load compensate timer

ACCESSORIES:

 Spray and rinse assembly
 Adjustable anged feet
 Ball oat trap
 Water in strainer
 Steam take off kit

2-1/2” 4” 4” & 1” 4” & 2-1/2”

Pan dePth

Cabinet baSe

2 x 4”
2 x 1”

2 x 4”

1 x 2-1/2”

Job Item#

Form GCX-16 Rev 5 (March/2015)

www.yatesgd.com www.yatesgraphicdesign.com

Models:

 GCX-16

24” (610)

8.75” (222)

13.5” (343)

REAR FLANGED FOOT DETAIL
2 EQUALLY SPACED
∅ 7/16” (11MM) HOLES
ON 2.5’ (63MM) B.C.

S

G

C

D

5.75” (146)

6.25” (159)

C

4.75” (121)

2.5” (64)

10” (254)

62” (1575)

28” (711)

6” (152)

SERVICE CONNECTIONS

model

GCX-16 990 lbs. [449 kg]

3” (76)

ShiPPinG weiGht

(36” Cabinet)

D

29.75” (756)

36” (914)

26.75” (679)

8” (203)

6.75” (171)

S

G

SIDES

BACK

m

inimum ClearanCe

33” (838)

24.75” (629)

IN (MM)

0
0

– GENERATOR: COLD WATER: 3/8” (10 mm) O.D. tubing at 25-50 psi (170-345 kPa).

– CONDENSATE: COLD WATER: 3/8” (10 mm) O.D. tubing at 25-50 psi (170-345 kPa).

– DRAIN: 2” (51 mm) IPS piped to open oor drain. No solid connection.

– ELECTRICAL CONNECTION: 1/2” (13 mm) conduit connection to controls. 2 Amps per compartment, 120-60-1 or 220-50-1.

– STEAM TAKE-OFF CONNECTION: 3/4” (19 mm) optional to operate adjacent equipment.

– GAS CONNECTION: 3/4” (19 mm) IPS.

UTILITIES

model

GCX-16

min 4” (102 mm)

water Column PreSSure btu/hr kw/hr

Natural

Propane

min 11” (279 mm)

WATER QUALITY STATEMENT

Water quality is the major factor affecting the performance of your appliance. If you are unsure of water quality, consult a local water
treatment specialist and have the water analyzed. Your water supply must be within these general guidelines:

Total dissolved solids ....................Less than 60 PPM

Total alkalinity ................................Less than 20 PPM

Silica ...............................................Less than 13 PPM

Chlorine .........................................Less than 1.5 PPM

pH Factor ......................................7.0 - 8.5

Water which fails to meet these standards should be treated by installation of water conditioner.

GaS SuPPly

250,000 73.3

300,000 87.9

FAILURE OR MALFUNCTION OF THIS APPLIANCE DUE TO POOR WATER QUALITY IS NOT COVERED UNDER WARRANTY.
CONTACT SOUTHBEND FOR WATER QUALITY SOLUTIONS.

INTENDED FOR COMMERCIAL USE ONLY.

NOT FOR HOUSEHOLD USE

1100 Old Honeycutt Road, Fuquay-Varina, NC 27526

[phone] www.southbendnc.com

Form GCX-16 Rev 5 (March/2015)

.