Southbend ECX-10 General Manual

SPECIFICATIONS:

Shall be a Model ECX-10 convection steamer with gas red
steam boiler. The steamer shall be constructed of #4 nish

stainless steel type 304, with a cooking chamber of one piece
all welded 316 stainless steel. The doors shall have a removable
inner liner of stainless steel with full perimeter gasket seal, an
outer shell of one piece all welded stainless steel, and a positive
lock and seal mechanism. The door opening shall be 14” W x

17.25” (356 mm x 438 mm). The steamer shall be provided
with removable stainless steel pan supports and a stainless
steel drip trough connected to drain to collect condensate when
door is opened.

Control housing shall be accessible through a full removable
side panel. Controls shall include a 60 minute mechanical timer
with ready pilot and cooking pilot light for each compartment
and a audible signal which will sound at the end of the cooking

cycle. Steam ow to the chamber shall be interrupted when the

compartment door is opened during cooking cycle and shall be
reactivated when the door is closed. The convection steamer
shall be mounted on a cabinet base with full perimeter angle
frame, reinforced counter and boiler mountings, gas boiler
with controls, all stainless steel exterior, hinged door(s) with
magnetic latch and 6” (152 mm) stainless steel legs tted with

adjustable bullet feet on the front and adjustable anged feet

on the rear. Standard boiler controls shall be automatic water
level control, pressure gauge, water gauge glass, pressure
control with pressure safety control, safety relief valve and
cathodic protector.

El E c t r i c co n v E c t i o n St E a m E r

o n ca b i n E t ba S E

Co m p a r t m e n t pa n Ca p a C i t y

mo d e l

ECX-10 20 10 6 4

OPERATION SHALL BE BY:

Electrically heated steam boiler operating at 15 psi
(103kPa) and rated at:

 30.0 kw
The steam boiler shall be equipped for operation on:

 208 VAC, 3 Phase, 60 Hz
 240 VAC, 3 Phase, 60 Hz

The controls shall be equipped for operation on 115
VAC, 1 Phase, 60 Hz

OPTIONAL ITEMS AT EXTRA COST:

 Automatic boiler blow down
 220 or 240 VAC, 1 Phase, 50 Hz
 Two water lines (boiler feed and condensate)
 De-lime piping assembly (DPA-1)
 Stainless steel frame
 Cabinet size (48" or 60")
 Stainless steel back on cabinet
 California State boiler code requirement
 CSD-1
 220 VAC, 3 PHASE, 60 Hz
 380 VAC, 3 PHASE, 60 Hz
 480 VAC, 3 PHASE, 60 Hz
 Load compensate timer

ACCESSORIES:

 Spray and rinse assembly
 12" x 20" x 2.5" perforated stainless steel pan
 12" x 20" x 2.5" solid stainless steel pan
 12" x 20" x 4" perforated stainless steel pan
 12" x 20" x 4" solid stainless steel pan
 Adjustable anged feet
 Ball oat trap
 Water in strainer
 Steam take-off kit

1” 2-1/2” 4” 6”

pa n de p t h

Job Item#

FormECX-10 Rev 0 (01/07)

www.yatesgd.com www.yatesgraphicdesign.com

Printed in USA

Models:

 ECX-10S

SERVICE CONNCETIONS

– COLD WATER: 1/2” (13 mm).

– DRAIN: 2 required, 1” male pipe thread piped to open oor drain. No solid connection.

– ELECTRICAL CONNECTION: Single point supply 1-1/8” (29mm) dia. (3/4” conduit)

– COLD WATER: Generator: 3/8” (10mm) tubing at 25-50 PSI (170-345 kPa).

– COLD WATER: Condensing: 3/8” (10mm) tubing at 25-50 PSI (170-345 kPa).

UTILITIES

mo d e l ph a s e

ECX-10 3 30 99.9 30 94.5 30 86.6 30 54.7 30 43.3

Water quality is the major factor affecting the performance of your appliance. If you are unsure of water quality, consult a local water
treatment specialist and have the water analyzed. Your water supply must be within these general guidelines:

Total dissolved solids ....................Less than 60 PPM

Total alkalinity ................................ Less than 20 PPM

Silica ...............................................Less than 13 PPM

Chlorine .........................................Less than 30 PPM

pH Factor ......................................7.0 - 8.5

208V 220V 240V 380V 480V

kW am p s kW am p s kW am p s kW am p s kW am p s

WATER QUALITY STATEMENT

Water which fails to meet these standards should be treated by installation of water conditioner.

FAILURE OR MALFUNCTION OF THIS APPLIANCE DUE TO POOR WATER QUALITY IS NOT COVERED UNDER WARRANTY.
WATER QUALITY STATEMENT

INTENDED FOR COMMERCIAL USE ONLY.

NOT FOR HOUSEHOLD USE.

FormECX-10 Rev 0 (01/07)

1100 Old Honeycutt Road, Fuquay-Varina, NC 27526

www.yatesgd.com www.yatesgraphicdesign.com

[phone] www.southbendnc.com