Component Replacement
Xperia
TM
Z5
TM
- electrical -
Xperia
E6603 and E6653
1300-1577 Rev 3
Sony Mobile Communications AB – Company Internal
E6633 and E6683
Z5 Dual
CONTENTS
1 Replaceable Components ............................................................. 3
2 Component Placing ........................................................................ 6
3 Additional Repair info .................................................................. 10
4 Revision History ........................................................................... 15
For general information about electrical repair related issues, refer to
1220-1336: Generic Repair Manual - electrical
Baking prior to repair is required, if the board have been exposed to air more than 12 hours from
PWB package opening. Too long exposure time increase the level of moisture in PWB and the
PWB could delaminate during repair process and result in direct or latent failures and reduce
reliability.
The boards shall be baked in 125°C ±5°C for 4 hours.
Test after electrical replacement: refer to 1273-1772 Mechanical Test Instruction
All Electrical components are RLC level B, Reversed Logistic Classification, See the Spare Part
Handling chapter in Mechanical/Generic Repair Manual 1220-1333.
Do not remove shield can lids (Heat pasta are added and RF performance will be damaged)
1300-1577 Rev 3
Sony Mobile Communications AB – Company Internal
2(16)
1 Replaceable Components
EXPLANATION OF ABBREVIATIONS USED IN THE COLUMN ‘COMMENTS’ BELOW
COMPONENT LOCATION
P = Primary side
S = Secondary side
REPAIR METHOD
HA = Hot Air (removal & mounting)
ST = Soldering Tool (removal & mounting)
HA/ST = Hot Air for removal - Soldering Tool for mounting
BGA = BGA Station
BH = Bottom Heater
ADDITIONAL INFORMAT ION
1 (2,3,4, etc.) = Proceed to ‘Additional Repair Info’ for further instructions in the indicated section(s).
1300-1577 Rev 3
Sony Mobile Communications AB – Company Internal
3(16)
1300-1577 Rev 3
Sony Mobile Communications AB – Company Internal
4(16)
Position
Component
Part no.
Comments
CN1300
Conn BtB Plug 4p HIROSE/BM22
1281-9973
S HA+BH 1
CN2600
Conn Leaf Spring Plug 1p
1289-4034
P HA+BH 2
CN2611
Conn Coax Receptacle 1p
1261-3585
S HA+BH 3
CN2612
Conn Leaf Spring Plug 1p
1289-4034
P HA+BH 2
CN2613
Conn Leaf Spring Plug 1p
1289-4034
P HA+BH 2
CN2631
Conn Leaf Spring Plug 1p WH : 0.8+-0.2
1294-8905
P HA+BH 2
CN2800
Conn Leaf Spring Plug 1p
1289-4034
S HA+BH 4
CN2801
Conn Leaf Spring Plug 1p
1289-4034
S HA+BH 4
CN2802
Conn Coax Receptacle 1p
1261-3585
S HA+BH 5
CN2803
Conn Coax Receptacle 1p
1287-3442
S HA+BH 6
CN4000
Card Conn SIM Dual nanoSIM connector
1295-4064
P HA+BH or BGA 7
CN4100
Card Conn Micro SD
1281-9124
P HA+BH or BGA 9
CN4751
Conn Leaf Spring Plug 1p
1289-4882
S HA+BH 10
CN4752
Conn Leaf Spring Plug 1p
1289-4882
S HA+BH 10
CN4753
Conn Leaf Spring Plug 1p
1289-4882
S HA+BH 10
CN4754
Conn Leaf Spring Plug 1p
1289-4034
P HA+BH 11
CN7900
Conn Leaf Spring Plug 1p
1289-4034
P HA+BH 12
CN7901
Conn Leaf Spring Plug 1p
1289-4034
P HA+BH 12
CN8003
Conn Coax Receptacle 1p
1287-3442
S HA+BH 14
CN8005
Conn Coax Receptacle 1p
1287-3442
S HA+BH 15
CN8009
Conn Leaf Spring Plug 1p
1289-4034
P HA+BH 16
CN8650
Conn Leaf Spring Plug 1p
1294-8163
S HA+BH 17
CN8651
Conn Leaf Spring Plug 1p
1294-8163
S HA+BH 17
D7800
LED White 1.63mm x 2.03mm
1278-5197
S HA+BH 18
FL2202
Filter Ceramic Lo-pass 50.0 MHz 1608
1269-0526
S HA+BH 19
R1306
Resistor 0.01 Ohm +/-1% 200.0 mW (1.6x0.
1238-2147
S HA+BH 20
UC7602
Fuse 0.25A 1.0*0.5mm
1265-7224
S HA+BH 21
Component Replacement (elect)
Note: Valid for E6633 and E6683
1300-1577 Rev 3
Sony Mobile Communications AB – Company Internal
5(16)
Position
Component
Part no.
Comments
CN1300
Conn BtB Plug 4p HIROSE/BM22
1281-9973
S HA+BH 1
CN2600
Conn Leaf Spring Plug 1p
1289-4034
P HA+BH 2
CN2611
Conn Coax Receptacle 1p
1261-3585
S HA+BH 3
CN2612
Conn Leaf Spring Plug 1p
1289-4034
P HA+BH 2
CN2613
Conn Leaf Spring Plug 1p
1289-4034
P HA+BH 2
CN2631
Conn Leaf Spring Plug 1p WH : 0.8+-0.2
1294-8905
P HA+BH 2
CN2800
Conn Leaf Spring Plug 1p
1289-4034
S HA+BH 4
CN2801
Conn Leaf Spring Plug 1p
1289-4034
S HA+BH 4
CN2802
Conn Coax Receptacle 1p
1261-3585
S HA+BH 5
CN2803
Conn Coax Receptacle 1p
1287-3442
S HA+BH 6
CN4000
Card Conn Other microSD and nanoSIM comb
1288-5918
P HA+BH or BGA 8
CN4751
Conn Leaf Spring Plug 1p
1289-4882
S HA+BH 10
CN4752
Conn Leaf Spring Plug 1p
1289-4882
S HA+BH 10
CN4753
Conn Leaf Spring Plug 1p
1289-4882
S HA+BH 10
CN4754
Conn Leaf Spring Plug 1p
1289-4034
P HA+BH 11
CN7900
Conn Leaf Spring Plug 1p
1289-4034
P HA+BH 12
CN7901
Conn Leaf Spring Plug 1p
1289-4034
P HA+BH 12
CN7998
Conn Leaf Spring Plug 1p
1289-4882
S HA+BH 13
CN8003
Conn Coax Receptacle 1p
1287-3442
S HA+BH 14
CN8005
Conn Coax Receptacle 1p
1287-3442
S HA+BH 15
CN8009
Conn Leaf Spring Plug 1p
1289-4034
P HA+BH 16
CN8650
Conn Leaf Spring Plug 1p
1294-8163
S HA+BH 17
CN8651
Conn Leaf Spring Plug 1p
1294-8163
S HA+BH 17
D7800
LED White 1.63mm x 2.03mm
1278-5197
S HA+BH 18
FL2202
Filter Ceramic Lo-pass 50.0 MHz 1608
1269-0526
S HA+BH 19
R1306
Resistor 0.01 Ohm +/-1% 200.0 mW (1.6x0.
1238-2147
S HA+BH 20
UC7602
Fuse 0.25A 1.0*0.5mm
1265-7224
S HA+BH 21
Component Replacement (elect)
Note: Valid for E6603 and E6653
2 Component Placing
To access the Component Placing document, double-click the icon below.
Applicable for on-screen viewing only – icon not shown on hard-copies.
E6633 and E6683 Primary side
1300-1577 Rev 3
Sony Mobile Communications AB – Company Internal
6(16)
E6633 and E6683 Secondary side
1300-1577 Rev 3
Sony Mobile Communications AB – Company Internal
7(16)
To access the Component Placing document, double-click the icon below.
Applicable for on-screen viewing only – icon not shown on hard-copies.
E6603 and E6653 Primary side
1300-1577 Rev 3
Sony Mobile Communications AB – Company Internal
8(16)
E6603 and E6653 Secondary side
1300-1577 Rev 3
Sony Mobile Communications AB – Company Internal
9(16)
3 Additional Repair info
1
CN1300
Replace if mechanical damaged. (Phone dead or power
off)
Protect the BtB connector with capton tape!
2
CN2600, CN2612, CN2613, CN2631
Replace if mechanical damaged (No or bad network,
main antenna)
3
CN2611
Replace if mechanical damaged (No or bad network,
main antenna)
Protect the BtB connector with capton tape!
4
CN2800, CN2801
Replace if mechanical damaged (No or bad network,
diversity antenna)
1300-1577 Rev 3
Sony Mobile Communications AB – Company Internal
10(16)
Repa ir A ctions: A dditional Rep air Info
5
CN2802
Replace if mechanical damaged (No or bad network,
main antenna)
6
CN2803
Replace if open circuit 1-4 (No or bad network, diversity
antenna)
7
CN4000 E6633 E6683
Replace if mechanical damaged (No network, restart, No
SIM card inserted, NFC SIM problem, reset problem)
Protect the SD connector and LED with capton tape!
8
CN4000 E6603 E6653
Replace if mechanical damaged (No network, restart, No
SIM card inserted, NFC SIM problem, reset problem, no
SD card)
Protect the LED with capton tape!
1300-1577 Rev 3
Sony Mobile Communications AB – Company Internal
11(16)
Repa ir A ctions: A dditional Rep air Info
9
CN4100 E6633 E6683
Replace if mechanical damaged (No SD card)
Protect the SIM connector with capton tape!
10
CN4751, CN4752, CN4753
Replace if mechanical damaged ( GND contact)
11
CN4754
Replace if mechanical damaged ( GND contact)
12
CN7900, CN7901
Replace if mechanical damaged (No or bad WLAN /BT,
Main antenna)
1300-1577 Rev 3
Sony Mobile Communications AB – Company Internal
12(16)
Repa ir A ctions: A dditional Rep air Info
13
CN7998 E6603 E6653
Replace if mechanical damaged (No or bad WLAN /BT,
Sub antenna )
Protect the RF connector with capton tape!
14
CN8003
Replace if open circuit 1-4 (No or bad WLAN / BT, Main
antenna)
Protect the LED with capton tape!
15
CN8005
Replace if open circuit 1-4 (No or bad WLAN / BT, Sub
antenna)
16
CN8009
Replace if mechanical damaged (No or bad WLAN / BT,
Sub antenna)
Protect the LED and SIM connector with capton tape!
1300-1577 Rev 3
Sony Mobile Communications AB – Company Internal
13(16)
Repa ir A ctions: A dditional Rep air Info
17
CN8650, CN8651
Replace if mechanical damaged (No or bad NFC)
Protect the RF connector with capton tape!
18
D7800
Replace if Flash LED not working.
Protect the RF connector with capton tape!
19
FL2202
Replace if open circuit (Not charging from USB
connector)
Protect the BtB connectors with capton tape!
20
R1306
Replace if open circuit (Phone dead or power off)
Protect the BtB connector with capton tape!
1300-1577 Rev 3
Sony Mobile Communications AB – Company Internal
14(16)
1300-1577 Rev 3
Sony Mobile Communications AB – Company Internal
15(16)
21
UC7602
Replace if backlight doesn’t come on.
Protect the BtB connectors with capton tape!
Component Replacement (elect)
Repair Actions: Additional Repair Info
1300-1577 Rev 3
Sony Mobile Communications AB – Company Internal
16(16)
Rev.
Date
Changes / Comments
1
2015-09-18
Initial release
2
2015-10-05
Additional repair info added
3
2016-01-29
Add new component UC7602
Component Replacement (elect)
4 Revision History
Loading...