1287-4298 Rev 1
Sony Mobile Communications AB – Company Internal
Component Replacement
- electrical -
Xperia Z1
TM
C6902, C6903, C6906,C6943, LT39h
1287-4298 Rev 1
Sony Mobile Communications AB – Company Internal
2(11)
CONTENTS
1 Replaceable Components ............................................................. 3
2 Component Placing ........................................................................ 5
3 Additional Repair info .................................................................... 6
4 Revision History ........................................................................... 11
For general information about electrical repair related issues, refer to
1220-1336: Generic Repair Manual - electrical
Test after electrical replacement: refer to 1273-1772 Mechanical Test Instruction
Do not remove shield can lids (Heat pasta are added and RF performance will be damaged)
1287-4298 Rev 1
Sony Mobile Communications AB – Company Internal
3(11)
1 Replaceable Components
EXPLANATION OF ABBREVIATIONS USED IN THE COLUMN ‘COMMENTS’ BELOW
COMPONENT LOCATION
P = Primary side
S = Secondary side
REPAIR METHOD
HA = Hot Air (removal & mounting)
ST = Soldering Tool (removal & mounting)
HA/ST = Hot Air for removal - Soldering Tool for mounting
BGA = BGA Station
BH = Bottom Heater
ADDITIONAL INFORMATION
1 (2,3,4, etc.) = Proceed to ‘Additional Repair Info’ for further instructions in the indicated section(s).
1287-4298 Rev 1
Sony Mobile Communications AB – Company Internal
4(11)
Position
Component
Part no.
Comments
L5101
Ferrite B 1.8 kOhm
1237-6064
S HA+BH 1
L5102
Ferrite B 1.8 kOhm
1237-6064
S HA+BH 1
R1301
Resistor 0.0 Ohm +/-50m 63.0 mW K0603
1000-0257
S HA+BH 2
R1304
Resistor 0.01 Ohm +/-1% 200.0 mW (1.6x0.
1238-2147
S HA+BH 3
R1310
Resistor 0.0 Ohm +/-50m 63.0 mW K0603
1000-0257
S HA+BH 2
V7800
LED White 1.63 x 2.03 x 0.75 mm Flash LE
1267-1941
S HA+BH 4
X1300
Conn BtB Plug 4p HIROSE/BM22
1264-8491
S HA+BH 5
X1301
Conn BtB Receptacle 4p HIROSE/BM22
1264-6156
S HA+BH 6
X2200
Conn USB B Receptacle 5p
1268-3388
P HA+BH or BGA 7
X2201
Conn Leaf Spring Plug 1p
1271-9649
P HA+BH 8
X2801
Conn Coax Receptacle 1p
1237-5326
S HA+BH 9
X2804
Conn Coax Receptacle 1p
1237-5326
S HA+BH 10
X2810
Conn Leaf Spring Receptacle 1p Antenna/G
1238-5879
P HA+BH 11
X2811
Conn Leaf Spring Receptacle 1p Antenna/G
1238-5879
P HA+BH 8
X2812
Conn Leaf Spring Receptacle 1p Antenna/G
1238-5879
P HA+BH 8
X4000
Card Conn SIM
1271-9742
P HA+BH or BGA 12
X5120
Conn WtB Receptacle 2p
1206-4855
S HA+BH 13
X8001
Conn Coax Receptacle 1p
1237-5326
S HA+BH 14
X8002
Conn Leaf Spring Plug 1p
1271-9649
P HA+BH 15
X8003
Conn Coax Receptacle 1p
1261-3585
S HA+BH 16
X8400
Conn Coax Receptacle 1p
1261-3585
S HA+BH 17
1287-4298 Rev 1
Sony Mobile Communications AB – Company Internal
5(11)
2 Component Placing
To access the Component Placing document, double-click the icon below.
Applicable for on-screen viewing only – icon not shown on hard-copies.
Primary side
Secondary side
1287-4298 Rev 1
Sony Mobile Communications AB – Company Internal
6(11)
1
L5101, L5102
Replace if open circuit (Vibrator not working)
Protect the BtB connector with capton tape!
2
R1301, R1310
Replace if open circuit (Magnet charger not working)
Protect the BtB connector with capton tape!
3
R1304
Replace if open circuit (Phone Dead)
Protect the BtB connector with capton tape!
4
V7800
Replace if Flash LED not working
3 Additional Repair info
1287-4298 Rev 1
Sony Mobile Communications AB – Company Internal
7(11)
5
X1300
Replace if mechanical damaged. (Phone dead or power
off)
6
X1301
Replace if mechanical damaged. (Magnet charger not
working)
7
X2200
Replace if mechanical damaged (USB charger or data
transfer not working)
8
X2201, X2211, X2212
Replace if mechanical damaged (Grounding Pins)
Protect the SD and USB connectors with capton tape!
Repair Actions: Additional Repair Info
1287-4298 Rev 1
Sony Mobile Communications AB – Company Internal
8(11)
9
X2801
Replace if open circuit 1-2 (No or bad network, main
antenna)
Protect the BtB connector with capton tape!
10
X2804
Replace if open circuit
Protect the BtB connector with capton tape!
11
X2810
Replace if mechanical damaged (Grounding Pin)
Protect the SIM card and BtB connectors with capton
tape!
12
X4000
Replace if mechanical damaged (No network, restart, No
SIM card inserted)
Protect the BtB connector with capton tape!
Repair Actions: Additional Repair Info
1287-4298 Rev 1
Sony Mobile Communications AB – Company Internal
9(11)
13
X5120
Replace if mechanical damaged (Vibrator not working)
14
X8001
Replace if open circuit 1-2 ( no or bad WLAN/ BT)
Protect the USB and Coax connectors with capton tape!
15
X8002
Replace if mechanical damaged (No or bad GPS)
Protect the SD connector with capton tape!
16
X8003
Replace if mechanical damaged (No or bad network,
main antenna)
Protect the BtB and Coax connectors with capton tape!
Repair Actions: Additional Repair Info
1287-4298 Rev 1
Sony Mobile Communications AB – Company Internal
10(11)
17
X8400
Replace if mechanical damaged ( no or bad WLAN/ BT)
Protect the USB and Coax connectors with capton tape!
Repair Actions: Additional Repair Info
1287-4298 Rev 1
Sony Mobile Communications AB – Company Internal
11(11)
Rev.
Date
Changes / Comments
1
2014-04-16
Initial release
4 Revision History
Loading...