DVP-S535D
CD/DVD
Laser Semiconductor laser
Signal format system
NTSC/PAL
Audio characteristics
Frequency response
DVD (PCM 96 kHz): 2 Hz to 44 kHz
(±1 dB)
DVD (PCM 48 kHz): 2 Hz to 22 kHz
(±0.5 dB)
CD: 2 Hz to 20 kHz (±0.5 dB)
Signal-to-noise ratio
More than 110 dB (AUDIO OUT connectors
only)
Harmonic distortion
Less than 0.003 %
Dynamic range
More than 100 dB (DVD)
More than 97 dB (CD)
Wow and flutter
Less than detected value
(±0.001 % W PEAK)
Outputs
AUDIO OUT
(1, 2) (R, L)
DIGITAL OUT
(OPTICAL)
DIGITAL OUT
(COAXIAL)
VIDEO OUT
(1, 2)
S VIDEO OUT
(1, 2)
COMPONENT
VIDEO OUT
(Y, CB/B-Y,
C
R
/R-Y)
Jack
type
Phono
jacks
Optical
output
connector
Phono
jack
Phono
jack
4-pin
mini DIN
Phono
jacks
Output
level
2 Vrms
(at 50 kilohms)
–18 dBm
0.5 Vp-p
1.0 Vp-p
Y: 1.0 Vp-p
C: 0.3 Vp-p
(PAL)
C: 0.286 Vp-p
(NTSC)
Y: 1.0 Vp-p
CB/B-Y,
C
R
/R-Y:
0.7 Vp-p
Load impedance
Over 10 kilohms
Wave length: 660 nm
75 ohms terminated
75 ohms,
sync negative
75 ohms,
sync negative
75 ohms terminated
75 ohms,
sync negative
75 ohms
RMT-D116O
SERVICE MANUAL
The Service Manual for this set contains only the points which differ is
bound together with the following Service Manual and therefore please
refer to them.
DVP-S535D: Australian → DVP-S735D: Australian
DVP-S535D: E → DVP-S735D: E
See page 3 for different parts.
• Main Unit
DVP-S335/S336/S345/S535D/S735D 9-921-754-11
Difference Manual
SPECIFICATIONS
E Model
Australian Model
Service Manual
– Continued on next page –
CD/DVD PLAYER
Outputs
Jack
5.1CH
OUTPUT
PHONES
Phono
jack
Phone
jack
General
Power requirements
220 to 240 V AC, 50/60 Hz
Power consumption
16 W
Dimensions (approx.)
430 × 69 × 260 mm
(w/h/d) incl. projecting parts
Mass (approx.)
2.9 kg
Operating temperature
5 °C to 35 °C
Operating humidity
25 % to 80 %
Output
2 Vrms
(at 50 kilohms)
12 mW
Load impedance
Over 10 kilohms
32 ohms
Supplied accessories
• Audio/video connecting cord (1)
• Remote commander (remote) (1)
• R6 (size AA) batteries (2)
• S video cord (1)
Design and specifications are subject to change without notice.
• Difference Tab le
Page DVP-S735D: E, Australian DVP-S535D: E, Australian
(2-4) Model Type
DVP-S535D (E) 1 9
DVP-S535D (Australian) 1 A
6-2
(2-4) Model Type
Model Type
DVP-S735D (E) 2 9
DVP-S735D (Australian) 2 A
Model Type
– 2 –
• DIFFERENT PARTS LIST
8-1. EXPLODED VIEWS
NOTE:
• -XX and -X mean standardized parts, so they may
have some difference from the original one.
• Items marked “*” are not stocked since they are
seldom required for routine service. Some delay
should be anticipated when ordering these items.
KNOB, BALANCE (WHITE) . . . (RED)
↑↑
Parts Color Cabinet's Color
8-1-2. CASE ASSEMBLY
60
62
• The mechanical parts with no reference number in
the exploded views are not supplied.
• Accessories and packing materials are given in the
last of the electrical parts list.
64
60
55
63
not
supplied
54
51
not
supplied
52
60
59
58
57
56
51 X-3950-734-1 PANEL ASSY, FRONT
52 3-059-349-11 CUSHION, FOOT
54 3-975-726-71 EMBLEM, DVD
55 3-061-719-31 COVER, TRAY
56 3-059-322-31 STICK, CURSOR
57 1-771-913-11 SWITCH, TACTILE
Ref. No. Part No. Description RemarkRef. No. Part No. Description Remark
58 3-970-608-51 SUMITITE (B3), +BV
59 3-059-389-01 CUSHION (REAR), FOOT
60 3-710-901-11 SCREW, TAPPING
62 1-418-991-51 COMMANNDER, STANDARD (RMT-D116O)
63 3-053-633-01 COVER, BATTERY (for RMT-D116O)
64 3-062-941-01 CASE
– 3 –
8-1-3. CHASSIS ASSEMBLY
(See Service Manual Page 8-4.)
DVP-S735D: E, Australian DVP-S535D: E, Australian
101 3-059-379-11 KNOB, VOLUME
* 104 A-6065-470-A HP-127 BOARD, COMPLETE
106 3-059-319-21 BUTTON, POWER
* 112 A-6065-484-A MB-86 BOARD, COMPLETE (E)
* 112 A-6065-486-A MB-86 BOARD, COMPLETE (Australian)
Ref. No. Part No. Description RemarkRef. No. Part No. Description Remark
101 3-059-379-01 KNOB, VOLUME
* 104 A-6065-513-A HP-127 BOARD, COMPLETE
106 3-059-319-31 BUTTON, POWER
* 112 A-6065-518-A MB-86 BOARD, COMPLETE (E)
* 112 A-6065-519-A MB-86 BOARD, COMPLETE (Australian)
113 4-966-267-11 BUSHING (FBS001), CORD
* 115 A-6065-482-A AI-17 BOARD, COMPLETE
120 3-059-326-61 PANEL, REAR
113 4-966-267-12 BUSHING (FBS001), CORD
* 115 A-6065-517-A AI-17 BOARD, COMPLETE
120 3-059-390-61 PANEL, REAR
8-2. ELECTRICAL PARTS LIST
NOTE:
• Items marked “*” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering
these items.
Page DVP-S735D: E, Australian DVP-S535D: E, Australian
Ref. No. Part No. Description RemarkRef. No. Part No. Description Remark
* A-6065-482-A AI-17 BOARD, COMPLETE
C205 1-106-343-00 MYLAR 1000PF 5% 200V
C206 1-106-343-00 MYLAR 1000PF 5% 200V
C212 1-130-472-00 MYLAR 0.0012uF 5% 50V
8-6
C213 Not used
C214 Not used
C215 1-128-200-11 ELECT 47uF 20% 63V
C216 1-128-200-11 ELECT 47uF 20% 63V
C217 1-106-351-00 MYLAR 2200PF 5% 200V
C218 1-106-351-00 MYLAR 2200PF 5% 200V
C221 1-126-052-11 ELECT 100uF 20% 16V
* A-6065-517-A AI-17 BOARD, COMPLETE
C205 Not used
C206 Not used
C212 Not used
C213 1-104-664-11 ELECT 47uF 20% 16V
C214 1-104-664-11 ELECT 47uF 20% 16V
C215 Not used
C216 Not used
C217 1-106-353-00 MYLAR 0.0039uF 5% 50V
C218 1-106-353-00 MYLAR 0.0039uF 5% 50V
C221 1-126-933-11 ELECT 100uF 20% 16V
8-7
8-8
C222 1-126-052-11 ELECT 100uF 20% 16V
C230 1-128-200-11 ELECT 47uF 20% 63V
C231 Not used
C232 Not used
C233 Not used
C238 1-128-202-11 ELECT 220uF 20% 63V
C242 1-130-472-00 MYLAR 0.0012uF 5% 50V
C247 1-130-467-00 MYLAR 470PF 5% 50V
C248 1-130-467-00 MYLAR 470PF 5% 50V
C252 1-136-850-11 MYLAR 0.1uF 5% 63V
C258 1-136-850-11 MYLAR 0.1uF 5% 63V
C259 Not used
C260 1-128-200-11 ELECT 47uF 20% 63V
C261 1-136-850-11 MYLAR 0.1uF 5% 63V
C262 1-136-850-11 MYLAR 0.1uF 5% 63V
C263 1-136-850-11 MYLAR 0.1uF 5% 63V
C264 1-136-850-11 MYLAR 0.1uF 5% 63V
C304 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25V
C305 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25V
C306 1-126-960-11 ELECT 1uF 20% 50V
C330 1-128-198-11 ELECT 22uF 20% 50V
C331 1-128-198-11 ELECT 22uF 20% 50V
C334 1-128-198-11 ELECT 22uF 20% 50V
C348 1-128-200-11 ELECT 47uF 20% 63V
C352 1-136-850-11 MYLAR 0.1uF 5% 63V
C222 1-126-933-11 ELECT 100uF 20% 16V
C230 1-124-584-00 ELECT 100uF 20% 10V
C231 1-163-021-91 CERAMIC CHIP 0.01uF 10% 50V
C232 1-163-021-91 CERAMIC CHIP 0.01uF 10% 50V
C233 1-104-665-11 ELECT 100uF 20% 10V
C238 Not used
C242 Not used
C247 Not used
C248 Not used
C252 Not used
C258 Not used
C259 1-109-982-11 CERAMIC CHIP 1uF 10% 10V
C260 Not used
C261 Not used
C262 Not used
C263 Not used
C264 Not used
C304 Not used
C305 Not used
C306 Not used
C330 1-126-965-11 ELECT 22uF 20% 50V
C331 1-126-965-11 ELECT 22uF 20% 50V
C334 1-126-965-11 ELECT 22uF 20% 50V
C348 1-104-664-11 ELECT 47uF 20% 16V
C352 Not used
– 4 –
Page DVP-S735D: E, Australian DVP-S535D: E, Australian
Ref. No. Part No. Description RemarkRef. No. Part No. Description Remark
C353 1-128-200-11 ELECT 47uF 20% 63V
C354 1-128-197-11 ELECT 10uF 20% 50V
C356 1-128-197-11 ELECT 10uF 20% 50V
C357 1-128-200-11 ELECT 47uF 20% 63V
C366 Not used
C353 1-126-935-11 ELECT 470uF 20% 6.3V
C354 Not used
C356 Not used
C357 1-126-964-11 ELECT 10uF 20% 50V
C366 1-163-275-11 CERAMIC CHIP 0.001uF 5% 50V
8-8
8-9
8-10
C368 Not used
C381 1-128-200-11 ELECT 47uF 20% 63V
C382 Not used
C383 1-136-850-11 MYLAR 0.1uF 5% 63V
C384 1-136-850-11 MYLAR 0.1uF 5% 63V
C390 1-136-850-11 MYLAR 0.1uF 5% 63V
C391 1-136-850-11 MYLAR 0.1uF 5% 63V
C404 Not used
C407 Not used
C408 1-163-021-91 CERAMIC CHIP 0.01uF 10% 50V
C409 1-163-021-91 CERAMIC CHIP 0.01uF 10% 50V
C450 1-128-201-11 ELECT 100uF 20% 63V
C493 1-128-201-11 ELECT 100uF 20% 63V
CN405 1-793-481-11 CONNECTOR, FFC/FPC 9P
D406 8-719-056-06 DIODE SLR-342DCT32 (JOG)
IC203 8-759-587-83 IC OPA2134UA/2K5
IC208 8-759-587-83 IC OPA2134UA/2K5
IC301 8-759-052-52 IC L78M05TLL-SONY-TL
IC303 8-759-587-83 IC OPA2134UA/2K5
IC305 8-759-587-83 IC OPA2134UA/2K5
J101 1-793-445-21 JACK, PIN 3P (COMPONENT VIDEO OUT)
J102 1-793-475-11 JACK, PIN 2P (VIDEO OUT)
J103 1-694-484-11 TERMINAL, S (2P.V) (S VIDEO OUT)
J201 1-793-526-11 JACK, PIN 4P (AUDIO OUT)
J301 1-785-489-11 JACK, PIN 6P (5.1CH OUTPUT)
C368 1-126-964-11 ELECT 10uF 20% 50V
C381 1-104-664-11 ELECT 47uF 20% 16V
C382 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25V
C383 Not used
C384 Not used
C390 Not used
C391 Not used
C404 1-104-664-11 ELECT 47uF 20% 16V
C407 1-104-664-11 ELECT 47uF 20% 16V
C408 Not used
C409 Not used
C450 Not used
C493 Not used
CN405 1-785-694-11 CONNECTOR, FFC/FPC 7P
D406 Not used
IC203 Not used
IC208 8-759-909-71 IC BA4558F-E2
IC301 Not used
IC303 8-759-909-71 IC BA4558F-E2
IC305 8-759-909-71 IC BA4558F-E2
J101 1-793-445-11 JACK, PIN 3P (COMPONENT VIDEO OUT)
J102 1-793-475-21 JACK, PIN 2P (VIDEO OUT)
J103 1-694-484-21 TERMINAL, S (2P.V) (S VIDEO OUT)
J201 1-793-526-21 JACK, PIN 4P (AUDIO OUT)
J301 1-785-536-11 JACK, PIN (6P) (5.1CH OUTPUT)
8-11
8-12
8-13
8-14
J303 1-784-432-11 JACK, PIN 1P (COAXIAL)
ND401 1-517-971-11 INDICATOR TUBE, FLUORESCENT
Q201 8-729-046-97 TRANSISTOR 2SD1938(F)-T(TX).SO
Q202 8-729-046-97 TRANSISTOR 2SD1938(F)-T(TX).SO
Q210 8-729-424-18 TRANSISTOR UN2113-TX
Q312 8-729-230-49 TRANSISTOR 2SC2712-YG-TE85L
Q314 8-729-216-22 TRANSISTOR 2SA1162-YG-TE85L
R212 1-216-041-00 METAL CHIP 470 5% 1/10W
R239 1-216-055-00 METAL CHIP 1.8K 5% 1/10W
R240 1-216-055-00 METAL CHIP 1.8K 5% 1/10W
R241 1-216-055-00 METAL CHIP 1.8K 5% 1/10W
R242 1-216-055-00 METAL CHIP 1.8K 5% 1/10W
R279 1-216-295-91 SHORT 0
R301 Not used
R321 Not used
R387 1-216-081-00 METAL CHIP 22K 5% 1/10W
R388 1-216-073-00 METAL CHIP 10K 5% 1/10W
R389 1-216-049-91 RES, CHIP 1K 5% 1/10W
R393 1-216-021-00 METAL CHIP 68 5% 1/10W
R394 Not used
R408 1-216-081-00 METAL CHIP 22K 5% 1/10W
R422 1-216-073-00 METAL CHIP 10K 5% 1/10W
R423 1-216-073-00 METAL CHIP 10K 5% 1/10W
R428 1-216-025-91 RES, CHIP 100 5% 1/10W
J303 1-793-446-21 JACK, PIN 1P (COAXIAL)
ND401 1-517-972-11 INDICATOR TUBE, FLUORESCENT
Q201 Not used
Q202 Not used
Q210 Not used
Q312 Not used
Q314 Not used
R212 Not used
R239 Not used
R240 Not used
R241 Not used
R242 Not used
R279 1-216-009-91 RES-CHIP 22 5% 1/10W
R301 1-216-049-91 RES-CHIP 1K 5% 1/10W
R321 1-216-295-91 SHORT 0
R387 Not used
R388 Not used
R389 Not used
R393 Not used
R394 1-216-033-00 RES-CHIP 220 5% 1/10W
R408 Not used
R422 Not used
R423 Not used
R428 Not used
– 5 –
Page DVP-S735D: E, Australian DVP-S535D: E, Australian
Ref. No. Part No. Description RemarkRef. No. Part No. Description Remark
8-14
R429 1-216-025-91 RES, CHIP 100 5% 1/10W
R443 1-216-027-00 METAL CHIP 120 5% 1/10W
R429 Not used
R443 Not used
8-15
8-17
R478 1-216-073-00 METAL CHIP 10K 5% 1/10W
R479 Not used
R482 Not used
R484 1-216-073-00 METAL CHIP 10K 5% 1/10W
R571 1-216-097-91 RES, CHIP 100K 5% 1/10W
R612 Not used
R613 1-216-295-91 SHORT 0
R614 Not used
R616 1-216-295-91 SHORT 0
S402 1-771-574-21 SWITCH, TACTILE (JOG)
S404 Not used
S407 Not used
S416 Not used
S417 1-771-574-21 SWITCH, TACTILE (OPEN/CLOSE A)
S418 1-771-574-21 SWITCH, TACTILE (PREV .)
S419 1-771-574-21 SWITCH, TACTILE (NEXT >)
* A-6065-470-A HP-127 BOARD, COMPLETE
D503 8-719-056-06 DIODE SLR-342DCT32 (HP-V)
J501 1-785-505-41 JACK, LARGE TYPE (PHONES)
R503 1-216-037-00 METAL CHIP 330 5% 1/10W
S501 1-771-574-21 SWITCH, TACTILE (HP-V)
R478 Not used
R479 1-216-073-00 RES-CHIP 10K 5% 1/10W
R482 1-216-073-00 RES-CHIP 10K 5% 1/10W
R484 Not used
R571 Not used
R612 1-216-295-91 SHORT 0
R613 Not used
R614 1-216-295-91 SHORT 0
R616 Not used
S402 Not used
S404 1-771-574-21 SWITCH, TACTILE (PREV .)
S407 1-771-574-21 SWITCH, TACTILE (NEXT >)
S416 1-771-574-21 SWITCH, TACTILE (OPEN/CLOSE A)
S417 Not used
S418 Not used
S419 Not used
* A-6065-513-A HP-127 BOARD, COMPLETE
D503 Not used
J501 1-785-505-31 JACK, LARGE TYPE (PHONES)
R503 Not used
S501 Not used
8-19
8-20
8-21
8-23
* A-6065-484-A MB-86 BOARD, COMPLETE (E)
* A-6065-486-A MB-86 BOARD, COMPLETE (Australian)
C801 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C802 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C803 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C804 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C805 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C806 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
FB117 1-414-226-21 INDUCTOR CHIP 0uH
FL801 1-234-177-21 FILTER, CHIP EMI
IC101 8-759-668-01 IC BR9040F-D-E2
IC801 8-759-670-52 IC CXD9547Q-TE-B
IC802 8-759-641-58 IC KM29W16000AT-T
R124 1-216-076-00 METAL CHIP 13K 5% 1/10W
R126 1-216-105-91 RES, CHIP 220K 5% 1/10W
R128 1-216-093-91 RES, CHIP 68K 5% 1/10W
R801 1-216-833-91 RES, CHIP 10K 5% 1/16W
R808 1-216-809-11 METAL CHIP 100 5% 1/16W
* A-6065-518-A MB-86 BOARD, COMPLETE (E)
* A-6065-519-A MB-86 BOARD, COMPLETE (Australian)
C801 Not used
C802 Not used
C803 Not used
C804 Not used
C805 Not used
C806 Not used
FB117 Not used
FL801 Not used
IC101 8-759-667-21 IC BR9160F-E2
IC801 Not used
IC802 Not used
R124 1-216-047-91 RES-CHIP 820 5% 1/10W
(E)
R126 1-216-089-91 RES-CHIP 47K 5% 1/10W
R128 1-216-089-91 RES-CHIP 47K 5% 1/10W
(E)
R801 Not used
R808 Not used
(E)
(E)
– 6 –
Page DVP-S735D: E, Australian DVP-S535D: E, Australian
Ref. No. Part No. Description RemarkRef. No. Part No. Description Remark
8-23
MISCELLANEOUS
**************
58 1-418-097-11 ENCODER, ROTARY
63 1-418-989-41 COMMANNDER, STANDARD (RMT-D120O)
57 Not used
62 Not used
57 1-771-913-11 SWITCH, TACTILE
62 1-418-991-51 COMMANNDER, STANDARD (RMT-D116O)
MISCELLANEOUS
**************
Not used
Not used
8-24
ACCESSORIES & PACKING MATERIALS
*******************************
1-418-989-41 COMMANNDER, STANDARD (RMT-D120O)
1-575-334-41 CORD, CONNECTION
(STEREO AV CABLE 1.5m)
1-776-078-31 CORD, CONNECTION
(S-VIDEO CABLE 1.5m)
3-055-539-01 COVER, BATTERY (for RMT-D120O)
3-061-776-11 MANUAL, INSTRUCTION (ENGLISH)
(E, Australian)
3-061-776-51 MANUAL, INSTRUCTION (FRENCH) (E)
ACCESSORIES & PACKING MATERIALS
********************************
1-418-991-51 COMMANNDER, STANDARD (RMT-D116O)
1-575-334-11 CORD, CONNECTION
(STEREO AV CABLE 1.5m)
1-575-335-21 CORD, CONNECTION
(S-VIDEO CABLE 1.5m)
3-053-633-01 COVER, BATTERY (for RMT-D116O)
3-062-060-11 MANUAL, INSTRUCTION (ENGLISH)
(E, Australian)
3-062-060-21 MANUAL, INSTRUCTION (ARABIC) (E)
– 7 –
DVP-S535D
9-921-771-11
Sony Corporation
Network Entertainment Group
– 8 –
2000F0530072-1F
Printed in Japan © 2000. 6
Published by Quality Assurance Dept.
Loading...