SOLE S03GBK, S03GRD, S04GBK, S04GRD, S04GSS Owner's Manual

LP

Gas Grill Owner's Guide

gourmet

S03GBK,

S03GRD

S04GBK,S04GRD,S04GSS

YOU

MUST

A WARNING

Follow all leak-check procedures carefully
even

if

A WARNING

Do

not

manual.

A

DANGER
IF

YOU SMELL GAS:

1.

Shut off gas

2. Extinguish any open flame.

3.

Open lid.

4. If

odor
appliance and immediately
supplier

READ

the grill was dealer-assembled.

try to light this appliance without reading the

THIS

OWNER'S

GUIDE

in

BEFORE

this manual prior to grill operation. Do this

A WARNING

1. Do

to

the appliance.

continues, keep

or

your fire department.

away

caU

from the

your gas

2. An LP cylinder

WUghting

flammable liquids
of

shall
or any other

OPERATING

InstructionsH section

not

store

this

or

any other appliance.

not

be

YOUR

or

use gasoline

or

vapors

not

connected for use

stored in the vicinity

appliance.

GAS

of

or

in

the vicinity

GRILL

this

other

of

this

NOTICE TO INSTALLER

These

instructions must

THIS

GAS

APPLIANCE

be

left with the

owner

IS

DESIGNED

and the owner should keep them for future use.

FOR

OUTDOOR

USE

ONLY

2

.1>

DANGER
Failure to

serious bodily injury

.1>

WARNINGS

.&.

After a period
obstructions before use . See instructions

.&.

Accessible parts

.&.

Combustible materials should never
grill. If this information

.&.

Combustion byproducts produced when using this product contain chemicals known to the state
cause cancer, birth defects,

&.

Do not store a spare or disconnected liquid propane cylinder under

&.

Do not operate the Sole Gourmet gas grill if there is a gas leak present.

&.

Do not use a flame to check for gas leaks. Follow the instructions

&.

Do

&.

Do

&.

Do not enlarge valve orifices or burner ports when cleani

&.

Do not attempt to disconnect any gas fitting while your grill is

&.

Do not use this grill unless all parts are

&.

Do not build this model
that can damage property and cause serious bodily injury or death.

&.

Improper assembly may be dangerous. Please follow the assembly instructions carefully supplied with this manual.

&.

Keep any electrical supply cord and the fuel supply hose away from any heated surfaces.

&.

Liquid propane gas
unit

&.

Never lean over open grill or place hands

&.

Proposition 65 Warning: Handling the brass material on this product exposes you to lead , a chemical known to
the state
(Wash hands after

&.

Should a grease fire occur , turn off all burners and leave lid closed until fire

&.

Should the burners go out while
attempting to

&.

The unit must be properly assembled according to the assembly instructions.

&.

Use heat-resistant gloves when operating your grill.

&.

Your Sole Gourmet gas grill should never

&.

You should exercise reasonable care when operating your Sole Gourmet gas grill. It will be hot during cooki
or cleaning and should never be left unattended,

&.

Your Sole Gourmet gas grill should

follow the Dangers, Warnings and Cautions contained in this Owner's Manual may result

of

storage, and/or nonuse, the Sale Gourmet gas grill should be checked for gas leaks and

of

not put a grill cover
not use charcoal

or

liquid propane gas

of

California to cause cancer , birth defects

handling this product.)

relight. Follow the lighting instructions

WARNINGS FOR YOUR GAS GRIL L

or

death, or

the grill may

is

not followed exactly , a fire causing death

or

anything flammable

or

lava rock

of

grill

is

not natural gas . The conversion

in

in

a fire

or

an explosion causing damage to property .

in

this manual for correct procedures .

be

very hot, so keep young children away while it

be

within 24 inches

or

other reproductive harm.

in

the storage area under the grill.

in

your Sole Gourmet gas grill.

in

place.

in

any built-in or slide

a natural gas unit

in

operation, turn all gas valves off. Open the lid and wait five minutes before

be

thoroughly cleaned on a regular basis.

is

dangerous. This will void your warranty.

or

fingers on the front edge of the cooking surface.

be

used by children.

or

(61

em)

ng

the valves or burners.

in

operation .

in

construction. This could cause a fi

or

attempted use

or

other reproductive harm.

in

this manual.

moved while

is

of

the back or sides

or

serious injury may occur.

or

near this gas grill.

in

this manual.

of

natural gas

is

out.

in

operation .

in

in

use .

of

your Sale Gourmet

of

California

re

or

an explosion

in

a liquid propane

burner

gas.

ng

to

LIQUID PROPANE GAS UNI

&.

A dented

&.

Although your liquid propane cylinder may feel empty, gas may still be present. The gas cylinder should be
moved and stored accordingly.

&.

Do not attempt to disconnect the hose and regulator or any gas fitting whi

&.

Do

&.

If you see, smell

1. Move away from liquid propane cylinder.

2. Do not attempt

3. Call your fire department or

&.

Use the hose and regulator that

or

rusty liquid propane cylinder may be dangerous. Check with

not use a liquid propane cylinder with a damaged valve.

or

hear the hiss

to

correct the problem yourse lf.

TS

ONLY

of

escaping gas from the liquid propane cylinder:

911

.

is

supplied with your Sole Gourmet gas grill.

by

your liquid propane supplier.

le

your griff is

in

operation.

GENERAL INSTRUCTIONS FOR YOUR GAS GRILL

3

Your Sale Gourmet gas grill is a portable cooking appliance for the outdoors, so you can easily change its location
yard, balcony or on your patio. Portability

liquid

Propane (LP) gas supply is easy to

1.

These instructions will assist

Sale Gourmet gas grill. Improper assembly can

your

2. Not

for use by children.

3.

If

there are local codes that apply to portable gas grills, you
codes or, in the absence
Propane
Vehicles,

4. The pressure regulator supplied with the
column (pressure).

5.

This Sole Gourmet gas grill is designed for use with liquid propane (LP) gas only. Do not use with natural (piped

The

6.

Do

7.

Check that the area under the control panel and the bottom tray are free from debris thai might obstruct the flow

combustion or ventilation air.

a.

The areas around the LP cylinder must be free and clear from debris.

9. Replacement pressure regulators and hose assemblies must be those

FOR INSTALLATION IN

These instructions, whi le generally acceptable, do not necessarily comply with the Canadian Installation codes, particularly
with piping above and bel
Standard CSA-8149.2 (Propane

Installation Code, CSA

ANSI A

valves, orifices, hose and regulator are for LP gas onl

not use with charcoal fuel.

119

.2/NFPA 1192, and CSA Z240 RV Serie

in

assembling your Sole Gourmet gas grill. Please read the instructions carefully before using

of

local codes, with either the National Fuel Gas Code, ANSI Z223 .1/ NFPA 54, Natural Gas and

CANADA

ow

ground. In Canada the installation of this appliance must comply with local codes and/or

also means you can lake your Sale Gourmet gas grill with you when you move.

use

and gives you more cooking

be

dangerous.

will

have to conform to them. Installation must conform with local

8149

.1, or Propane Storage and Handling Code, 8149.2 , or the Standard for Recreational

s,

Recreational Vehicle Code, as applicable.

Sole Gourmet gas grill must be used.This regulator is set for

y.

Siorage and Handling Code

).

conlrollhan

specified by Sale Gourmet.

charcoal fuel .

11

inches

in

your

of

water

in

city) gas.

of

OPERATING WARNINGS

& Only

& Keep venti lation openings for cylinder enclosure free and clear from debris.
& Your Sole Gourmet gas grill shall not be used under overhead combustible cons truction.
& Your Sole Gourmet gas grill is
&
& The entire cooking box gets hot when
& Keep any electric
& Keep the cooking area clear
.&.
.&.

STORING YOUR GAS

1. The gas must be turned off at the liquid propane cylinder when the Sale Gourmet gas grill is not

2. When the

3.

4. Disconnected

5.

6. The

7. Check that the areas under the control panel and the slide out grease tray are free from debris.

8. The Spider !Insect Screens should also

use

this grill outdoors in a wellventilated area.

area.

not

intended to

Do not

Never store an extra (spar

The
(CGA81

The cylinder must

When the LP cylinder is still disconnected to the Sale Gourmet gas grill. the appliance and LP lank must be kept outdoors
in

use the gri

LP

cylinder used wi

0) cylinder connection. The cylinder connection must

Sole Gourmet gas grill is stored indoors. the gas supply must be disconnected from the gas cylinder.

a well-ventilated space.

Sale Gourmet gas grill should be checked for gas leaks. Check for any obstructions in the burner tubes before using.

ll

within 24 inches

al

supply cord and the fuel supply hose away from any heated surface.

of

e)

LP cylinde r under or near the Sole Gourm

th

your grill must be with a listed OPD (Overfilling Prevention Device) and a

GRILL

be stored outdoors

LP

cylinders must not

of

combustible materials to the back or sides

in

use. Do not leave unattended.

flammable vapors and liquids such as gasoline, alcohol, etc, and combustible materials .

in

a well - ventilated area out

be

stored

Do

not use

be

installed

in

a building, garage or any other enclosed area.

in

a garage, building, breezeway or any other enclosed

in

or on recreational vehicles and/or boat

of

the grill.

et

gas grill.

be

compatible with the grill connection.

of

reach

of

childr

en.

in

s.

aCCl

use.

or Type 1

be checked for any obstructions.

COOKING ON YOUR GAS
PREHEATING
Preheat.
P

re

PREPARING THE
Apply a light coat
Cooking oil

lighllhe

heating to between 500'-550' F (260'·290' C) will take around 10 minutes depending on temperature or air .

burners, close the hood and turn all burners to HI position.

COOKING SURFACE

of

cooking oil using a long handled brush to the cooking plates prior to lighting each burner.

will keep the food from sticking to the grills, hotplates or griddle .

GRILL

4 GENERAL INSTRUCTIONS FOR YOUR GAS GRILL

DRIPPING/GREASE FLARE - UP CONTROL

• Flare-ups

• Flare-ups and smoke are what give meal and fish their smoky flavour so expect and encourage this.

• Excessive flaring can be caused by cooking extra fatly foods or
flare-ups will need to be controlled by adjus ling the heal

• To prevent, trim off excess fat from your meat or fish before cooking on the grill.

• Cook particularly fatty meal

•

Throw baking soda or spray a small amount

• Always position the flame tamer beneath the open grill plates as opposed to the solid hot plates.
COOKI

When cooking with the hood down it's advisable to use the 2 outside burners only.

Position the flame tamers and

Check the temperature periodically and ensure you don't exceed

USING THE REAR BURNER (IF SUPPLI ED)

• The location
Do not operate the rear burner during strong winds.

• For best results perform rotisserie style cooking with the roasting hood down.

GENERAL CLEANING

Allow your grill to continue burning for 5 minutes after cooking has ceased. Allow for excess fats and grease to burn

can block the flame ports to the burners. To prepare you
cooking surface with a long handled brush to remove excess oils and food scraps. Use heal-protective gloves
brush to avoid any burns from hot surfaces.

CLEANING THE

•

Allow the grill to cool down.
Remove & wash grills

• Rinse off with water and allow to dry.
CLEAN ING THE FLAME TAMER

• Periodically wash

• Use a wire brush to remove stubborn residue.

• Allow to dry before returni
VOLCANIC ROCK

If

your grill contains volcanic rock,

CERAMIC

your grill contains ceramic tiles, allow to cool and simply turn over.

• If
Residue

GRILL BODYIFRAME

The frame
SAND

• Sand trays MUST be emptied and cleaned after Sand trays MUST

• If this is ignored, a build up

• This will void your warranty.
THE

After long cooking sessions , excess fat
Clean by washing
Ensure burner ports are free from obstruction.

• Rinse in water, dry and return to your grill.

•

Ught

To

prevent rust and corrosion

LOCATION
Keep gas grill area clear and free from combustible materials, gasoline & other flammables.
Protect
Proper care and maintenance

will occur every time you cook with an open flame due to natural juices from meat or fish.

by

cooking on too high a temperature -Ihese types

of

the burner or your food will burn.

on

a solid hotplate as opposed to the open grill plale.

of

water directly on the flame tamer to reduce excessive flaring.

NG

WITH ROASTING HOOD DOWN

grill over the center burn.

480' F1250' C as this can damage the grill.

of

the rear burner makes it more susceptible to wind that will decrease its performance.

grill for the next time you cook, turn all the burners off and brush the

SURFACES

in

warm soapy solution.

in

warm soapy solulion .

ng

10

grill plates.

be

sure to replace it every year with annual cleaning.

TILES

will burn off when you next use grill.

of

the grill should be cleaned on a regular basis with a warm soapy solution.

TRAY

be

emptied and cleaned after each use.

of

fats and grease may cause a fire to the grill.

BURNERS

s,

juices and marinades can clog the burners. Remove them and:

in

hot water and

immediately to burn off excess water.

& PROTECTION

your

grill

by

using a weather proof cover to avoid rain

detergent

10

cast iron burners, brush lightly with cooking oil.

or

sun damage.

will keep your grill

in

top condition and prolong its use.

10

hold

off

that

Ihe

GENERAL GAS INSTRUCTIO

IMPORTANT LP CYLINDER INFORMATION
Follow these DANGER statements exactly or failure to do so may result in a fire causing death or serious injury

NS

" DANGER

NEVER store a spare LP Cylinder under or near this gril
NEVER fill the tank beyond 80% ful
If this informatio n is not followed exactl

WARNINGS

~

Only use this grill outdoors

.1!.

Do nol use indoors, such as a garage, building, breezeway or any other enclosed area.

&.

Ensure your gas grill is 24 inches (61cm) from any combustible materials , If this information is not followed exactly,
a fire causing death or serious injury may occur.

in

a well·ventilaled area .

l.

y, a fi

re causing death or serious injury may occur.

l.

5

FILLING THE LP
The proper filling methods for the filling of your cylinder are by weight or volume, as described
your authorized gas dealer
the

filling instructions on the LP cylinder before attempting to fill

LEAK

CHECK PREPARATION

Check that all the burners are

lhevalves

Check by pushing down and turning clockwise.
If they do not turn, they are off.

If

they do turn continue turning them clockwise until they stop, then they are off.

CONNECTING THE LIQUID PROPANE CYLINDER
All Sale
ANSI
This
coupling
chance of leaks due to a
coupling is fully engaged into the coupling.

WARNING' Make sure that the LP cylinder valve is closed by turning valve clockwise

are transported in the ·OFF- position. You should check to

Gourmet liquid propane gas grill regulators are equipped with a cylinder connection as per the latest edition of

Z21

.58.

will require a liquid propane cylinder that is similarly equipped with a Type 1 connection in the tank valve. This Type 1

allows you to make a fast and totally safe hookup between your gas grill and your LP cylinder. It eliminates the

2

--..[

1

~

GAS

CYLINDER

L U

F'\;/

~

\\\\1

fills your LP cylinder by weight or volume. Ask your authorized gas dealer

it.

in

the OFF position.

be

sure that they are turned off.

POL filti

ng

that

3

.t

~~

f::

~

is

not properly tightened. Gas will not

,

4

r--I

yS

1

2

3

I---,

4

How

from the cylinder unless the Type 1

Type I Cylinder Connection

Type 1 Valve

Hand Wheel

External Thread

Thermally Sensitive Nut

in

NFPA 58.Please make sure

to

verify they understand

Device

CONNECTI

All Sole

Ensure you use the appropriate

the valve

lift and place the LPG gas cylinder into the base panel

must be secured so it does not come displaced.

NG

THE HOSE & REGULATOR TO THE

Gourmet gas grills are provided with

20 pound gas cylinde r compatible with the gas grill. Turn the cylinder so that the opening

is

visible from the front of the grill and ensure the valve is closed by turning clockwise.

CSA

approved hose and regulator.

5

LP

CYLINDER

of

the cabinet. Secure

Propane Regulator

by

tightening the screw provided. The cylinder

of