Soft Scrub 865 User Manual

Download

Page 1

D-122

Safety Data Sheet

Revision Number: 012.0

Issue Date: 03/25/2015

The Dial Corporation, a Henkel Company; 7201 E. Henkel Way; Scottsdale, AZ 85255-9672

Hard Surface Cleaner

Page 1 of 5

HAZARD CLASS

HAZARD CATEGORY

EYE IRRITATION

The hazards described in this OSHA Globally Harmonized System Safety Data Sheet (SDS) are not intended for consumers, and does not address consumer use of the product. For information regarding consumer applications of this product, refer to the product label.

1. IDENTIFICATION OF THE SUBSTANCE OR MIXTURE AND OF THE SUPPLIER

Product identifier used on the label: Soft Scrub® with Lemon Soft Scrub® Total All Purpose Bath & Kitchen Cleanser – Lemon Scent Soft Scrub® with Baking Soda

Other means of identification: 1432909, 1551126, 1775519, 1407931, 1563069 (SS Lemon); 1417184, 1563068, 1722708 (SS w/Baking

Recommended use of the chemical and restrictions on use: Cleansing Cream, Do not mix with other products. Name, address and telephone number of the chemical manufacturer:

Emergency telephone number: Medical Emergencies: 1-888-689-9082

The Dial Corporation, a Henkel Company 7201 E. Henkel Way Scottsdale, AZ 85255-9672 USA

CHEMTREC: 1-800-424-9300 (24 hours daily) Internet: www.henkelna.com

Soda)

2. HAZARD IDENTIFICATION

Classification of the substance or mixture in accordance with paragraph (d) of §1910.1200

Signal word, hazard statement(s), symbol(s) and precautionary statement(s) in accordance with paragraph (f) of §1910.1200

Signal word: WARNING Hazard Statement(s): Causes serious eye irritation.

Symbol(s): Precautionary Statements: Prevention: Wash thoroughly after handling.

Wear eye and face protection. Response: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to

remove. Continue rinsing. If eye irritation persists: Get medical attention.

Storage: Not prescribed Disposal: Not prescribed

Hazards not otherwise classified: Not available.

Classification complies with OSHA Hazard Communication Standard (29 CFR 1910.1200) and is consistent with the provisions of the United Nations Globally Harmonized System of Classification and Labeling of Chemicals (GHS).

See Section 11 for additional toxicological information.

3. COMPOSITION / INFORMATION ON INGREDIENTS

The following chemicals are classified as health hazards in accordance with paragraph (d) of § 1910.1200.

Page 2

The Dial Corporation, a Henkel Company; 7201 E. Henkel Way; Scottsdale, AZ 85255-9672

Hard Surface Cleaner

Page 2 of 5

Chemical Name*

CAS Number (Unique Identifier)

Concentration

Limestone

1317-65-3

30 - 60 %

Benzenesulfonic acid, sodium salts

68081-81-2

5 - 10%

Alcohols, C10-14, 8EO

66455-15-0

1 - 5%

Sodium chloride

7647-14-5

1 - 5%

*The specific chemical identity and/or exact percentage (concentration) of composition has been withheld because a trade secret is claimed in accordance with paragraph (i) of §1910.1200.

4. FIRST AID MEASURES

Description of necessary measures

Most important symptoms and effects, both acute and delayed

Indication of any immediate medical attention and special treatment needed

Inhalation: Remove from exposure area to fresh air. Treat symptomatically and supportively. Skin contact: Rinse affected area with large amounts of mild soap and water until no evidence of product remains. Get medical attention if

irritation persists. Eye contact: Rinse eyes immediately with plenty of water, occasionally lifting upper and lower lids, until no evidence of product remains. Get medical attention if pain or irritation develops. Ingestion: Dilution by rinsing the mouth and giving water or milk to drink is generally recommended. Do not induce vomiting. Contact physician or local poison control center.

After eye contact: Moderate to strong irritation of the eyes (redness, swelling, burning, watering eyes). After skin contact: Repeated or

prolonged excessive exposure can cause mild skin irritation or dermatitis. After Ingestion: Ingestion of large amounts may cause some gastrointestinal discomfort including nausea, vomiting, abdominal pain, diarrhea, and lethargy. Nausea and vomiting may occur. After

inhalation: Irritating, in high concentration, to the respiratory tract (nose, throat, and lungs).

After eye contact: Rinse eyes immediately with plenty of water, occasionally lifting upper and lower lids, until no evidence of product remains. After skin contact: Rinse affected area with large amounts of water until no evidence of product remains. After ingestion: Dilution by rinsing the mouth and giving a glass of water to drink is generally recommended. After inhalation: Remove from exposure area to fresh air.

5. FIRE FIGHTING MEASURES

Suitable (and unsuitable) extinguishing media

Specific hazards arising from the chemical

Oxides of carbon and oxides of nitrogen.

Special protective equipment and precautions for fire-fighters

In case of fire, wear a full-face positive-pressure self-contained breathing apparatus and protective suit. Move containers from fire area if you can do it without risk. Apply cooling water to sides of containers that are exposed to flames until well after fire is out. Avoid breathing hazardous vapors, keep upwind. Isolate area. Keep unnecessary personnel away.

Suitable extinguishing media: Dry chemical, carbon dioxide, water spray or regular foam. Unsuitable extinguishing media: None known

6. ACCIDENTAL RELEASE MEASURES

Personal precautions, protective equipment and emergency procedures Wear skin, eye and respiratory protection as recommended in Section 8. Stop leak if you can do it without risk. Spills present a slipping hazard. Keep unnecessary personnel away. Ventilate spill area if possible. Make sure area is slip-free before re-opening to traffic.

Environmental Precautions

Small or household quantities may be disposed in sewer or other liquid waste system. For larger quantities check with your local disposal authorities. Methods and materials for containment and cleaning up

SMALL SPILLS: Contain and absorb with sand or other absorbent material and place into clean, dry containers for later disposal. Wash site of spillage thoroughly with water. LARGE SPILLS: Dike far ahead of spill to prevent further movement. Recover by pumping or by using a suitable absorbent material and place into containers for later disposal. Dispose in suitable waste container.

7. HANDLING AND STORAGE

Precautions for safe handling

Do not get in eyes, on skin, on clothing. Do not take internally. Use with adequate ventilation. Keep the containers closed when not in use. Have emergency equipment (for fires, spills, leaks, etc.) readily available.

Conditions for safe storage, including any incompatibilities

Store in original containers in a cool dry area. Storage areas for large quantities (warehouse) should be well ventilated. Keep the containers tightly closed when not in use.

8. EXPOSURE CONTROLS / PERSONAL PROTECTION

Page 3

The Dial Corporation, a Henkel Company; 7201 E. Henkel Way; Scottsdale, AZ 85255-9672

Hard Surface Cleaner

Page 3 of 5

OSHA permissible exposure limit (PEL), American Conference of Governmental Industrial Hygienists (ACGIH) Threshold Limit Value (TLV),

Hazardous Component(s)

ACGIH

OSHA PEL

AIHA WEEL

OTHER

Limestone

10 mg/m3 TWA Total dust.

5 mg/m3 PEL Respirable fraction.

15 mg/m3 PEL Total dust.

None

Benzenesulfonic acid, sodium salts

None

Alcohols, C10-14, 8EO

None

Sodium chloride

None

and any other exposure limit used or recommended by the chemical manufacturer, importer, or employer preparing the safety data sheet, where available.

Appropriate engineering controls

Provide local exhaust or general dilution ventilation to keep exposure to airborne contaminants below the permissible exposure limits where mists or vapors may be generated.

Individual protection measures

Respiratory: Air contamination monitoring should be carried out where mists or vapors are likely to be generated, to assure that the

employees are not exposed to airborne contaminants above the permissible exposure limits.

Eye: Splash-proof safety glasses are required to prevent eye contact where splashing of product may occur. Hand/Body: Protective gloves are required where repeated or prolonged skin contact may occur.

Protective clothing is required where repeated or prolonged skin contact may occur.

9. PHYSICAL AND CHEMICAL PROPERTIES

Appearance: cream, white Odor: lemon Odor threshold: Not available. pH: 10.5 - 12.0 (25 °C) Melting point/ range: Not available. Boiling point/range: Not available. Flash point: > 93.3 °C (> 199.94 °F) Evaporation rate: Not available. Flammable/Explosive limits - lower: Not available. Flammable/Explosive limits - upper: Not available. Vapor pressure: Not available. Vapor density: Not available. Solubility in water: Not available. Partition coefficient (n-octanol/water): Not available. Autoignition temperature: Not available. Decomposition temperature: Not available. Viscosity: 5,000 - 12,000 mPa.s VOC content: Not available.

10. STABILITY AND REACTIVITY

Reactivity: This product reacts with acids. Chemical stability: Stable under normal ambient temperature (70°F, 21°C) and pressure (1 atm). Possibility of hazardous reactions: Hazardous polymerization has not been reported to occur under normal temperatures and pressures. Conditions to avoid: Avoid storing in direct sunlight and avoid extremes of temperature. Incompatible materials: Strong oxidizers, acids. Reacts with other household chemicals such as acid toilet bowl cleaners, rust

removers, acids, vinegar, and ammonia-containing products to produce hazardous gases, such as chlorine and other chlorinated compounds. Hazardous decomposition products: Thermal decomposition may produce irritating smoke, carbon monoxide, and carbon dioxide.

11. TOXICOLOGICAL INFORMATION

Likely routes of exposure including symptoms related to characteristics

Inhalation: Irritating, in high concentration, to the respiratory tract (nose, throat, and lungs). Skin contact: Repeated or prolonged excessive exposure can cause mild skin irritation or dermatitis. Eye contact: This product may cause moderate eye irritation. Ingestion: Ingestion of large amounts may cause some gastrointestinal discomfort including nausea, vomiting, abdominal pain, diarrhea, and

lethargy.

Physical/Chemical: The product is alkaline.

Page 4

The Dial Corporation, a Henkel Company; 7201 E. Henkel Way; Scottsdale, AZ 85255-9672

Hard Surface Cleaner

Page 4 of 5

Other relevant toxicity information:

Hazardous Component(s)

LD50s and LC50s

Immediate and Delayed Health Effects

Limestone

None

Nuisance dust

Benzenesulfonic acid, sodium salts

None

No Data

Alcohols, C10-14, 8EO

None

No Records

Sodium chloride

Oral LD50 (RAT) = 3.000 mg/kg

Irritant

Hazardous Component(s)

NTP Carcinogen

IARC Carcinogen

OSHA Carcinogen

Limestone

Benzenesulfonic acid, sodium salts

Alcohols, C10-14, 8EO

Sodium chloride

Hazardous substances

Result Value

Route of

application

Species

Method

Benzenesulfonic acid, mono-C10-16-alkyl derivs., sodium salts

readily biodegradable

aerobic

70 – 80 %

OECD Guideline 301

D (Ready

Biodegradability:

Closed Bottle Test)

Alcohols, C10-14, 8EO

readily biodegradable

No data

> 60 %

OECD 301 A - F

This product is a household product. The use of this product by consumers is safe under normal and reasonable foreseen use.

Numerical measures of toxicity, including delayed and immediate effect

Carcinogenicity information

Carcinogenicity None of the ingredients in this product are listed as carcinogens by the International Agency for Research on Cancer

(IARC), the National Toxicology Program (NTP) or the Occupational Safety and Health Administration (OSHA). Mutagenicity None of the ingredients in this product are known to cause mutagenicity Toxicity to reproduction None of the ingredients in this product are known as reproductive, fetal, or developmental hazards.

12. ECOLOGICAL INFORMATION

Aquatic Toxicity:

This product is anticipated to be safe for the environment at concentrations predicted in household settings under normal use conditions. The following toxicity information is available for the hazardous ingredient(s) when used as technical grade and is provided as reference for the occupational settings.

Toxicity to fish:

The aquatic toxicity profile of this product has not been determined.

Toxicity to aquatic invertebrates:

The aquatic toxicity profile of this product has not been determined.

Toxicity to algae:

The aquatic toxicity profile of this product has not been determined.

Persistence and Degradability:

Bioaccumulation Potential: The bioaccumulation potential of this product has not been determined. Mobility: The mobility of this product (in soil and water) has not been determined.

Waste Number and Description: Not regulated

Disposal Considerations: Disposal of products: This product is not a RCRA hazardous waste and can be disposed of in accordance with federal, state and local

Disposal of packages: Place in trash. Additional information: Observe all federal, state and local regulations when storing or disposing of this substance

The transport information provided in this section only applies to the material/formulation itself, and is not specific to any package/configuration.

U.S. Department of Transportation Ground (49 CFR)

Proper shipping name: Not regulated Hazard class or division: None Identification number: None Packing group: None

13. DISPOSAL CONSIDERATIONS

regulations.

14. TRANSPORT INFORMATION

Page 5

The Dial Corporation, a Henkel Company; 7201 E. Henkel Way; Scottsdale, AZ 85255-9672

Hard Surface Cleaner

Page 5 of 5

International Air Transportation (ICAO/IATA)

Water Transportation (IMO/IMDG)

Proper shipping name: Not regulated Hazard class or division: None Identification number: None Packing group: None

15. REGULATORY INFORMATION

Occupational safety and health act: Hazard Communication Standard, 29 CFR 1910.1200(g) Appendix D: The Occupational Safety and Health Administration (OSHA) require that the Safety Data Sheets (SDSs) are readily accessible to employees for all hazardous chemicals in the workplace. Since the use pattern and exposure in the workplace are generally not consistent with those experienced by consumers, this SDS may contain health hazard information not relevant to consumer use.

United States Regulatory Information:

Canada Regulatory Information:

Consumer Product Safety Commission (CPSC): This product is regulated as a consumer product under CPSC. TSCA: All components of this product are listed on U.S. Toxic Substances Control Act (TSCA) chemical substance inventory. EPA CERCLA/SARA TITLE III Superfund Amendment and Reauthorization Act: This product contains no CERCLA/SARA Title III materials CERCLA/SARA 311/312: This product contains no hazardous chemicals reportable under Sections 311/312. This product contains no hazardous chemicals reportable under Section 304. CERCLA/SARA 313: Not applicable - Consumer product California Proposition 65: No California Proposition 65 listed chemicals are known to be present.

CEPA DSL/NDSL Status: One or more components are not listed on, and are not exempt from listing on either the Domestic Substances List or the

Non-Domestic Substances List.

Worker Hazardous Materials Information System: WHMIS Classification: Toxic material causing other toxic effects

16. OTHER INFORMATION

DISCLAIMER: The data contained herein are furnished for information only and are believed to be reliable. However, Henkel Corporation and its

affiliates (“Henkel”) does not assume responsibility for any results obtained by persons over whose methods Henkel has no control. It is the user’s

responsibility to determine the suitability of Henkel’s products or any production methods mentioned herein for a particular purpose, and to adopt such

precautions as may be advisable for the protection of property and persons against any hazards that may be involved in the handling and use of any

Henkel’s products. In light of the foregoing, Henkel specifically disclaims all warranties, express or implied, including warranties of merchantability and fitness for a particular purpose, arising from sale or use of Henkel’s products. Henkel further disclaims any liability for consequential or incidental

damages of any kind, including lost profits.

This safety data sheet contains changes from the previous version in sections: 2, 3, 8, 11, 12 Prepared by: R&D Support Services Issue date: 03/25/2015 Supercedes: Rev. 11, 08/18/2014