Parts Manual fo
r
Z
HYDRO DRIVE ZTR
350Z/400
SERIES 1
MODEL
ZT18441KHC (5900608)
ZT19441KWV (5900609)
ZT20501BV (5900610)
EZT20501BV (5901166)
400ZB2450 (5900706)
Briggs & Startton Yard Power Products Group
Copyright © 2007
Milwaukee, WI USA. All Rights Reserved
Briggs & Startton Corporation
Revision F,
McDonough, GA, 30253 U.S.A.
10/15/2007
Manual No. 7006937
TP 400-5132-F-HZ-N
s
PAGE GROUP
4
6
8
10
12
14
16
18
20
24
26
28
30
32
34
36
38
40
42
44
48
50
54
56
58
60
62
64
Wheel & Tire Group
Main Frame & Front Suspension Group
Seat & Kickplate Group
Seat & Kickplate Group - 24 HP Models
Fuel Tank Group
Control Group Upper
Control Group Lower
Drive Group
Brake Group
Hydraulic Group (270HYD1)
Hydraulic Pump SERVICE PARTS - BDP/PG Series
Engine & PTO Group - BRIGGS & STRATTON
Engine & PTO Group - 24 HP Briggs & Stratton
Engine & PTO Group - KAWASAKI
Engine & PTO Group - KOHLER
Bumper Group
Decals Group - Brand & Model
Decals Group - Safety & Common
Export Decals Group - Safety & Common
Lift Group
44" & 50" Mower Deck - Belt & Idler Group
44" & 50" Mower Deck - Housing, Arbors & Blades Group
44" & 50" Mower Deck Roller Group
Control Group Panel
Electrical Group
Wiring Schematic 18hp
Wiring Schematic 20hp
Wiring Schematic - 24 HP Briggs & Stratton
Table Of Content
SERIES 1
Manual No. 7006937HYDRO DRIVE ZTR
3
TP 400-5132-F-HZ-N
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
4
SERIES 1
Wheel & Tire Group
p
y
Part No Descri
1 5022433S 2 WHEEL & TIRE ASSEMBLY, 11 X 4.0 - 5, COMPLETE (Includes Ref No. 2 - 6)
2 5022433X1 2 TIRE, FRONT, 11 X 4.0 - 5
3 5022433S2 2 WHEEL ASSEMBLY, COMPLETE (Includes Ref No. 4 & 5)
4 2172353 4 VALVE STEM & CAP ASSEMBLY
5 5021042 4 BEARING, ROLLER (2 Per Tire)
6 5021043 4 BEARING RETAINER (2 Per Tire)
7 5045996 2 AXLE, FRONT CASTER
8 5025017X52 2 BOLT, 1/2-13 X 6-1/2
9 5025056 2 NUT, HEX NYLON LOCK, 1/2-13
10 5023095 2 WHEEL & TIRE ASSEMBLY, 20 X 8.0 - 10, COMPLETE (Includes Ref No. 4, 11 & 12)
11 5023095X1 2 TIRE, REAR, 20 X 8.0 X 10
12 5023095X2 2 WHEEL ASSEMBLY, FOR 20 X 8.0 X 10 TIRE
13 5020601 8 LUG NUT, 1/2-20
14 5025158 4 WASHER, SAE, 1/2
tionItem Qt
Note
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
5
TP 400-5132-F-HZ-N
Main Frame & Front Suspension Group
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
6
SERIES 1
Main Frame & Front Suspension Group
p
y
Part No Descri
1 5025057 8 NUT 5/16-18 HEX NYLON LOCK
2 5025265X56 1 3/4-16 X 7” GD 8 BOLT TZ
3 5025160 1 WASHER, 3/4” SAE
4 5025284 1 NUT, 3/4-16 HEX NYLON LOCK
5 5025303 8 SCREW 5/16-18 X 1 FLAT HD SC
6 5020095 2 GREASE FITTING, 1/4-28 STR
7 5022852 1 PIVOT BEARING,1.00” X 1.125” OD X 1.50”
8 5047489 1 SPACER, .75 X 1.00 X 2.38
9 5400756 1 SPACER, .75 X 1.50 X .785
10 5023214 2 CAP, VINYL 1.687 X 1-1/2
11 5045990 2 PLATE, FRICTION REDUCER
12 5021541 4 BUSHING, FLANGE
13 5020602 2 COLLAR, 1” SPLIT
14 5048775D 2 WELD, CASTER YOKE
15 5400405D 1 WELD, PIVOTING FRONT END
16 5400350D 1 WELD, MAIN FRAME, SNAPPER ZT
17 5100358 1 BEARING, PIVOT, 1.00 X 1.25 X .50
18 5025392 4 NUT, 5/16-18 HEX NYLOCK FLANGE
19 5401053D 2 PLATE, DECK STOP - SNAPPER RED
20 5025155 4 WASHER, 5/16" SAE
21 5025011X6 4 BOLT, 5/16-18 X 3/4" GD5
22 5403499D 1 WELD, MAIN FRAME, SNAPPER 400Z (24 HP Models Only)
tionItem Qt
Note
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
7
TP 400-5132-F-HZ-N
Seat & Kickplate Group
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
8
SERIES 1
Seat & Kickplate Group
p
y
Part No Descri
1 7078299 2 SPRING, SEAT SUPPORT
2 5025394 8 NUT, 3/8-16 HEX NYLOCK FLANGE
3 5025013X8 6 BOLT, 3/8-16 X 1” GD5
4 5025392 6 NUT, 5/16-18 HEX NYLOCK FLANGE
5 5025011X8 6 BOLT, 5/16-18 X 1” GD5
6 5025292 6 WASHER, 5/16” GD.9 FLAT
7 5025057 4 NUT, 5/16-18 HEX NYLON LOCK
8 5025013X40 1 BOLT, 3/8-16 X 5” GD5
9 5025156 8 WASHER 3/8” SAE
10 5025013X32 1 BOLT, 3/8-16 X 4” GD5
11 5400528D 1 WELD, SEAT PLATE - RED
12 5061599 1 SEAT
13 5400361D 1 MOUNT, OIL FILTER
14 5049979 1 SAFETY WALK, FLOOR REST
15 5049978 1 SAFETY WALK, FLOOR PLATE
16 5400918D 1 PLATE, FLOOR DETAIL
tionItem Qt
Note
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
9
TP 400-5132-F-HZ-N
Seat & Kickplate Group - 24 HP Models
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
10
SERIES 1
Seat & Kickplate Group - 24 HP Models
p
y
Part No Descri
1 5400361D 1 MOUNT, OIL FILTER- RED
2 5025011X8 8 BOLT, 5/16-18 X 1 GD 5 YZ
3 5025292 8 WASHER, 5/16 GD. 9 FLAT
4 5025392 6 NUT, 5/16-18 HEX NYLOCK FLANGE
5 7078299 2 SPRING, SEAT SUPPORT
6 5025156 2 WASHER, 3/8 SAE
7 5100999 1 SAFETY WALK, FLOOR PLATE, 17.38 X 11.50
8 5101007 1 SAFETY WALK, FLOOR REST, 17.38 X 6.00
9 5061599 1 SEAT, XB-180, NO LOGO, BLACK
10 5025057 4 NUT, 5/16-18 HEX NYLON LOCK
11 5025394 4 NUT, 3/8-16 HEX NYLOCK FLANGE
12 5403488D 1 WELD, SEAT PLATE - RED
13 5403665D 1 PLATE, FLOOR, CONSUMER Z - RED
14 5403044D 1 PLATE, FLOOR, FRONT, CONS Z - RED
15 35097 6 MOUNT, VIBRATION, 30 DURO
16 197546 4 MOUNT, VIBRATION, RUBBER
17 5025481 6 BOLT, 3/8-16 X 5/8, SERRATED UNDER HEAD
18 5025013X28 2 BOLT, 3/8-16 X 3-1/2 GD5 YZ
19 5044617 2 WASHER, .34 X 1.25 X 10 GA
20 5025128 8 NUT, 3/8-18 HEX SERRATED FLANGE
21 5403372D 1 PLATE, SUPPORT, FRONT FLOOR - RED
22 5025155 1 WASHER, 5/16 SAE
23 5025011X6 1 BOLT, 5/16-18 X 3/4 GDS
24 5025480 6 WASHER, 3/8" ID, INTERNAL TOOTH
25 1686907 1 ARM REST, SET OF TWO (SV)
26 5100636 1 SPRING, SEAT ADJUSTMENT (SV)
27 5061599X1 1 KIT, SEAT RAILS. COMPLETE (SV)
tionItem Qt
Note
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
11
TP 400-5132-F-HZ-N
Fuel Tank Group
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
12
SERIES 1
Fuel Tank Group
p
y
Part No Descri
1 5025011X6 16 BOLT, 5/16-18 X 3/4” GRD5
2 5025155 10 WASHER, 5/16” SAE
3 5025392 8 NUT, 5/16-18 HEX NYLOCK FLANGE
4 5025299X4 2 SCREW, ALLEN HEAD, 1/4-20X1/2
5 5025386 6 SCREW, Allen Head, #10-24 x 3/8”
6 5025170 10 WASHER, 5/16” LOCK
7 5025011X8 4 BOLT, 5/16-18 X 1” GD5
8 5048751 1 FUEL TANK ASSEMBLY (Includes Ref. 17 - 23)
9 5048909D 2 PLATE, FUEL TANK BADGE - RED
10 5048763D 1 BRACKET, REAR SUPPORT - RH - RED
11 5400836D 1 BRACKET, REAR SUPPORT - LH - RED
12 5022158 1 CAP, FUEL TANK, 3-1/2” NECK
13 5048752 1 TANK, FUEL - RH
14 5400919D 1 PLATE, SUPPORT, REAR TANK - RED
15 5023345 1 TANK, 2QT HYDRAULIC
16 5023191 1 CAP, HYDRAULIC RESERVOIR
17 5023061 1 ELBOW FITTING Not Shown
18 5600050 1 GROMMET Not Shown
19 5050925X20 1 HOSE, 20” Not Shown
20 5023069 2 HOSE CLAMP Not Shown
21 5023067 1 SCREEN FITTING Not Shown
22 5023197 1 FUEL GAUGE Not Shown
23 5022917X1 1 GROMMET Not Shown
24 5025292 10 WASHER, GR. 9 FLAT
25 5300046 1 ASSM, FUEL HOSE Not Shown (Includes Ref. 17 -
26 5020835 2 CLAMP, HOSE, RED
27 5050831X20 1 HOSE, 1/4" FUEL LINE, 20" LONG
tionItem Qt
Note
21)
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
13
TP 400-5132-F-HZ-N
Control Group Upper
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
14
SERIES 1
Control Group Upper
p
y
Part No Descri
1 5021098 2 BEARING, BRONZE FLANGE, 3/4”
2 5021499 2 BEARING, FLANGE
3 5025013X14 4 BOLT, 3/8-16 X 1-3/4” GD5
4 5025394 6 NUT, 3/8-16 HEX NYLOCK FLANGE
5 5025179X4 4 10-24 X .5 SCREW
6 5025029 4 NUT, HEX, #10-24
7 5025013X8 2 BOLT, 3/8-16 X 1” GD5
8 5025096 4 NUT, 3/8-16 HEX NYLON LOCK
9 5025327 4 3/8-16 x 1-1/4 SOCKET HD CAPSCR
10 5025055X16 2 BOLT, 5/16-18 X 2” GD 5 TFL
11 5025139 4 NUT, 5/16-18 HEX LG SERR FLG.
12 5025055X14 2 BOLT, 5/16-18 X 1.75” GD 5 TFL
13 5025011X20 8 BOLT, 5/16-18 X 2-1/2” GD5
14 5025155 12 WASHER, 5/16” SAE
15 5025392 8 NUT, 5/16-18 HEX NYLOCK FLANGE
16 5025170 4 WASHER, 5/16” LOCK
17 5025011X8 4 BOLT, 5/16-18 X 1” GD5
18 5401020D 1 WELD, CONTROL SHAFT- RH
19 5401017D 1 WELD, CONTROL SHAFT- LH
20 5022068 2 GRIP, FOAM, 3/4” ID, 16” LONG
21 5047004 2 MOUNT, CONTROL ARM
22 5401096D 1 WELD, HANDLE MOTION CONTROL-LH
23 5401097D 1 WELD, HANDLE MOTION CONTROL-RH
24 5048264 8 SPACER, .63 X .39 X 1.50
25 5048169D 2 WELD, NEUTRAL PLATE
26 5022095 2 SWITCH, PLUNGER, N.O. / N.C.
tionItem Qt
Note
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
15
TP 400-5132-F-HZ-N
Control Group Lower
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
16
SERIES 1
Control Group Lower
p
y
Part No Descri
1 5010546 2 COLLAR, 3/8” SET
2 5025214X8 2 PIN, CLEVIS, 3/8” X 1”
3 5025211 2 PIN, HAIR, .0585 X 1-1/8
4 5023242 2 SPRING, CONTROL ROD
5 5023260 2 BUSHING, FLANGE 3/8ID X 7/8 LONG
6 5025057 4 NUT 5/16-18 HEX NYLON LOCK
7 5025011X10 2 BOLT, 5/16-18 X 1-1/4” GD5
8 5025155 6 WASHER, 5/16” SAE
9 5025033 2 NUT, HEX 5/16-24
10 5025045 2 NUT 5/16-24 HEX NYLON LOCK
11 5025011X8 2 BOLT, 5/16-18 X 1” GD5
12 5023212 2 NUT, 5/16 HEX LH
13 5025335 4 BOLT, M8-1.25 x 35MM
14 5025354 4 NUT, M8-1.25 Hex Nylon Lock
15 5025355 4 NUT, M8-1.25 Hex Serrated Flange
16 5022645 2 SPRING, COMPRESSION
17 5020047 2 SET COLLAR, 5/16”
18 5021171 2 CLEVIS, 3/8-24, PLASTIC
19 5049969 2 ROD, NEUTRAL CONTROL, 8”
20 5022978 2 DAMPENER
21 5022628 2 BALL JOINT, 5/16-24 Female LH
22 5021146 2 BALL JOINT, 5/16-24 Female
23 5048921 2 CONTROL ROD, ADJ. SPRING
24 5048923 2 ROD ASSEMBLY, SLIDER
25 5025035 2 NUT, 3/8-24 HEX
tionItem Qt
Note
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
17
TP 400-5132-F-HZ-N
Drive Group
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
18
SERIES 1
Drive Group
p
y
Part No Descri
1 5025013X32 1 BOLT, 3/8-16 X 4” GD5
2 5025305 2 WASHER, .41 X 1.75 X .14
3 5025013X16 1 BOLT, 3/8-16 X 2” GD5
4 5025156 3 WASHER 3/8” SAE
5 5025394 5 NUT, 3/8-16 HEX NYLOCK FLANGE
6 5025013X20 1 BOLT, 3/8-16 X 2-1/2” GD5
7 5025013X14 1 BOLT, 3/8-16 X 1-3/4” GD5
8 5044577 2 WASHER, .265 X 1.50 X .109, YZ
9 5025169 2 WASHER, 1/4” LOCK
10 5023215 2 BOLT, M6-1.0 X 14MM
11 5025013X8 1 BOLT, 3/8-16 X 1” GD5
12 5025034 2 NUT, 3/8-16 HEX
13 5022931 1 BELT, DECK DRIVE
14 5023497 1 EYE BOLT, 3/8-16 X 5”, 1” EYE
15 5021002 1 PULLEY, IDLER
16 5049184 1 SPACER, HYDRO IDLER PULLEY
17 5023254 2 KEY, 5MM SQ W/ RADIUS
18 5022157 2 BUSHING, BRASS, 1.25 X 1 X 1.25
19 5045135 1 SPACER, .39 X 1.00 X 2.55
20 5048219D 1 PLATE, ANCHOR, SPRING
21 5023251 2 PULLEY, PUMP DRIVE
22 1715435 1 SPRING, EXTENSION, 1.00
23 5022621 1 PULLEY, IDLER, SINGLE FLANGE
24 5046430D 1 WELD, ARM, PUMP DRIVE IDLER
25 5045200D 1 WELD, ANCHOR EYEBOLT
26 5023252 1 PULLEY, Crankshaft
27 5025061X2 4 SET SCREW, 5/16-18 X 1/2
tionItem Qt
Note
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
19
TP 400-5132-F-HZ-N
Brake Group
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
20
SERIES 1
Brake Group
p
y
Part No Descri
1 5021098 4 BEARING, BRONZE FLANGE, 3/4”
2 5025394 11 NUT, 3/8-16 HEX NYLOCK FLANGE
3 5025013X6 4 BOLT, 3/8-16 X 3/4” GD5
4 5025034 1 NUT, 3/8-16 HEX
5 5025126 2 NUT, 1/4-20 HEX SERR. FLANGE
6 5025154 2 WASHER, 1/4” SAE
7 5025010X5 2 BOLT, 1/4-20 X 5/8” GD5
8 5048401D 2 WELD, MOUNT BRAKE LEVER
9 5025058X16 1 BOLT, 3/8-16 X 2” GD 5 TFL CZ
10 5025203X6 1 PIN, COTTER, 1/8" X 3/4"
11 5025214X8 1 PIN, CLEVIS, 3/8” X 1”
12 5025011X8 4 BOLT, 5/16-18 X 1” GD5
13 5025392 4 NUT, 5/16-18 HEX NYLOCK FLANGE
14 5025155 2 WASHER, 5/16” SAE
15 5025075X6 4 BOLT, 3/8-16 X 3/4", ALLEN BUTTON
16 5048163D 1 WELD, SHAFT BRAKE LEVER
17 5025010X12 4 BOLT, 1/4-20 X 1-1/2” GD5
18 5025287 4 NUT, 1/4-20 HEX SIDE LOCK
19 5025035 2 NUT, HEX 3/8-24
20 5025013X16 1 BOLT, 3/8-16 X 2” GD5
21 5025128 2 NUT, 3/8-16 HEX LG. SERR FLG
22 5023215 12 BOLT, M6-1.0 X 14MM
23 5025169 12 WASHER, 1/4” LOCK
24 5048166D 1 WELD, SHAFT, REAR BRAKE
25 5022182 2 SWITCH PLUNGER NO/NC SNAP IN
26 5045619D 1 HANDLE, BRAKE LEVER
27 5045618D 3 WELD, PIVOT LINKAGE MOUNT
28 5041930 2 SPACER, .38 X .50 X .27
29 5023094 2 DRUM, BRAKE, 4-BOLT
30 5021171 2 CLEVIS, 3/8-24 PLASTIC
31 5010546 4 COLLAR, 3/8” SET
32 5023106 1 BRAKE ASSEMBLY, RH (Not Shown)
33 5023188 1 BRAKE ASSEMBLY, LH
34 5045621D 1 BRACKET, SWITCH MOUNT
35 5100171 1 GRIP, BLACK FLEXIBLE
36 5022361 2 SPRING, BRAKE
37 5047091 2 ROD, BRAKE ADJUSTMENT
tionItem Qt
Note
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
21
TP 400-5132-F-HZ-N
Brake Group
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
22
SERIES 1
Brake Group
p
y
Part No Descri
38 5047084D 2 LINK, BRAKE LOCK
39 5042553 1 ROD, BRAKE ENGAGEMENT 36”
tionItem Qt
Note
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
23
TP 400-5132-F-HZ-N
Hydraulic Group (270HYD1)
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
24
SERIES 1
Hydraulic Group (270HYD1)
p
y
Part No Descri
1 5023191 1 CAP
2 5023345 1 HYDRAULIC TANK
3 5021164 1 CLAMP, #10 HOSE STAINLESS
4 5050860X8P 1 HOSE, 3/8 X 8.50” LONG
5 5022920 1 TEE FITTING
6 5050860X27 1 HOSE, 3/8 X 27” LONG
7 5022710 4 25.5” HOSE ASSEMBLY
8 5022634 4 FITTING, ADAPTER
9 5023091 2 WHEEL MOTOR
10 5023267 4 FITTING, 90 DEG. O-RING
11 5023268 10 CLAMP, HOSE
12 5100072 1 HYDRAULIC PUMP, LH (PG1HQQ-DV1X-XXXX) Was 5023092
13 5023338 4 FITTING, ADAPTER
14 1719168 1 FILTER
15 5023096 1 FILTER HEAD
16 5400707 1 HOSE, 5/8 X 12.5” LONG
17 5023266 1 FITTING, TEE
18 5050860X7P 3 HOSE, 3/8 X 7.5 “ LONG
19 5100073 1 HYDRAULIC PUMP, RH (PG1KQQ DV1X-XXXX) Was 5023093
20 5023091X1 2 KEY
21 5023091X2 2 NUT, CASTLE
22 5025203X10 2 PIN, COTTER, 1/8 X 1-1/4
23 5023346 1 ADAPTER, 90 DEG, 9/16-5/8 BARB
24 5061549 1 CLAMP, HOSE 7/8
25 5025013X8 8 BOLT, 3/8-16 X 1" GD5 YZ
26 5025171 8 WASHER, 3/8" SPLIT LOCK
27 5025013X10 4 BOLT, 3/8-16 X 1-1/4" GD5
28 5025128 4 NUT, 3/8-16 HEX SERRATED FLANGE
29 5025010X6 2 BOLT, 1/4-20 X 3/4" GD5 YZ
30 5025154 2 WASHER, 1/4" SAE
31 5025169 2 WASHER, 1/4" LOCK
tionItem Qt
Note
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
25
TP 400-5132-F-HZ-N
Hydraulic Pump SERVICE PARTS - BDP/PG Series
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
26
SERIES 1
Hydraulic Pump SERVICE PARTS - BDP/PG Series
p
y
Part No Descri
1 5023405 1 Housing Kit
2 5023406 1 End Cap Kit (W/ Poppets, Standard Charge) (Includes Ref. Nos.
66)
3 5023407 1 Straight Headless Pin
4 5023408 4 Hex Flange Bolt M8-1.25 X 60mm LG
5 5023409 1 Housing O-Ring
6 5023410 1 Charge Pump Kit (STD) (Includes Ref. Nos. 7 & 8)
7 -- 1 STD Gerotor Assy (11 cu. In/rev D-Drive) (Not a Serviceable
Part)
8 -- 1 O-Ring (Not a Serviceable Part)
10 5023411 2 Socket Head Screw M6 x 1.0-20mm Lg (STD Charge)
15 5023412 1 Bypass Valve Kit (Blank)
18 5023413 1 Pump Shaft Kit (Blind 15mm Keyway W/ Std Charge) (Includes
Ref. Nos. 19)
19 -- 1 Ball Bearing 17 x 40 x 12 (Not a Serviceable Part) Not a serviceable part.
20 5023414 1 Lip Seal 17 x 40 x 7 PTC
21 5023415 1 Spacer
22 5023416 1 Retaining Ring
25 5023417 1 Cylinder Block Kit
29 5023418 1 Block Spring
30 5023419 1 Block Thrust Washer
31 5023420 1 Valve Plate (Steel N-Tec:Black)
32 5023421 1 Swashplate
34 5023422 1 Ball Thrust Bearing
37 5023423 1 Trunnion Arm, Tapered Square
38 5023424 1 Slot Guide
42 5023425 2 Check Valve Kit (0.031”Orifice)
44 5023426 1 Charge Relief Valve Kit (1/4” Plastic Ball & Spring)
49 5023427 1 Trunnion Seal / Retainer Kit
56 5023428 1 Straight Thread Plug
66 -- 1 5/16” SAE Plug (Not a Serviceable Part) Not a serviceable part.
100 5023429 1 Overhaul Seal Kit Not Shown
101 -- 1 Spacer RTN (Not a Serviceable Part) Not a serviceable part.
102 -- 1 Spring, Extension (Not a Serviceable Part) Not a serviceable part.
103 -- 1 Screw, 5/16 x .875 (Patch) (Not a Serviceable Part) Not a serviceable part.
104 -- 2 Washer .34 x .88 x .06 (Not a Serviceable Part) Not a serviceable part.
105 -- 1 Washer, Nylon (Not a Serviceable Part) Not a serviceable part.
106 -- 1 Nut, Hex Lock 5/16-24 UNF (Not a Serviceable Part) Not a serviceable part.
107 -- 1 Spacer (Not a Serviceable Part) Not a serviceable part.
110 5023430 1 Kit, RTN, STD (Includes Ref. Nos. 94, 98, 100, 101, 102, 103,
104, 104, 105, 106 & 107)
tionItem Qt
Note
Not a serviceable part.
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
27
TP 400-5132-F-HZ-N
Engine & PTO Group - BRIGGS & STRATTON
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
28
SERIES 1
Engine & PTO Group - BRIGGS & STRATTON
p
y
Part No Descri
1 -- 1 * ENGINE, 20HP B&S Model 358777-0280-E1
2 5023187 1 MUFFLER
3 5025392 6 NUT, HEX NYLOCK FLANGE, 5/16-18
4 5025011X6 6 BOLT, 5/16-18 X 3/4
5 5025155 13 WASHER, SAE, 5/16
6 5048262D 2 BRACKET, MUFFLER SUPPORT
7 5025057 7 NUT, HEX NYLON LOCK, 5/16-18
8 5044617 3 WASHER, CLUTCH ANCHOR, 5/16
9 5043636 1 CLUTCH ANCHOR PAD
10 5050407X18 1 KEY, 1/4 SQ. X 2-1/4
11 5023100 1 CLUTCH, ELECTRIC
12 5042132 1 SPACER, .45 X 1.62 X .37
13 5023253 1 BOLT, CRANKSHAFT, 7/16 X 3-1/4
14 5021030 1 TIE WRAP
15 5048226D 1 CLUTCH ANCHOR
16 5025011X14 4 BOLT, 5/16-18 X 1-3/4
17 5025188 1 WASHER, 5/16 INT TOOTH LOCK
18 5025011X8 3 BOLT, 5/16-18 X 1
19 5401071D 1 PLATE, HEAT SHIELD
20 5048681 1 HOSE, OIL DRAIN (Not Shown)
21 5050833X6 1 WIRE LOOM, OIL DRAIN (Not Shown)
22 5021500 1 CLAMP, VINYL INSULATED (Not Shown)
tionItem Qt
Note
Footnotes:
Note: * See your local Briggs & Stratton distributor for parts & service.
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
29
TP 400-5132-F-HZ-N
Engine & PTO Group - 24 HP Briggs & Stratton
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
30
SERIES 1
Engine & PTO Group - 24 HP Briggs & Stratton
p
y
Part No Descri
1 -- 1 * ENGINE-24HP B&S, ELS #44M777-0113-E1
2 5023100 1 CLUTCH, ELECTRIC, 1" SHAFT
3 5043636 1 CLUTCH ANCHOR PAD
4 5044617 3 WASHER, .34 X 1.25 X 10GA
5 5023253 1 BOLT, CRANKSHAFT, 7/16-20 X 3-1/4" YZ
6 5042132 1 SPACER, .45 X 1.62 X .37
7 5025011X8 7 BOLT, 5/16-18 X 1" GD5
8 5025155 10 WASHER, 5/16" SAE
9 5025392 11 NUT, 5/16-18 HEX NYLOCK FLANGE
10 5050407X18 1 KEY, 1/4" SQ. X 3-1/2"
11 5025011X18 4 BOLT, 5/16-18 X 2-1/4" GD5
12 5025188 4 WASHER, 5/16" INT. TOOTH LOCK
13 5048681 1 HOSE, OIL DRAIN
14 5100907 1 MUFFLER, 22HP B&S - ELS - IS500Z
15 5100969 1 EXTENSION, TAILPIPE, 3"
16 5401071D 1 PLATE, HEAT SHIELD
17 5021500 1 CLAMP, VINYL INSULATED
18 5025010X6 1 BOLT, 1/4-20 X 3/4" GD5
19 5025391 1 NUT, 1/4-20 HEX NYLOCK FLANGE
20 5048226D 1 ANCHOR, CLUTCH
21 792105 1 AIR CLEANER W / PRE CLEANER (SV) (INCLUDES REF. NO. 22)
22 792303 1 PRE CLEANER (SV)
23 273485 2 GASKET, EXHAUST
24 94480 4 SCREW, SEM HEX HEAD
25 5021808X8 2 SCREW
tionItem Qt
Note
Footnotes:
NOTE* Purchase engine parts from engine manufacturer dealer.
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
31
TP 400-5132-F-HZ-N
Engine & PTO Group - KAWASAKI
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
32
SERIES 1
Engine & PTO Group - KAWASAKI
p
y
Part No Descri
1 -- 1 * ENGINE, 19HP KAWASAKI
2 5101125 1 MUFFLER
3 5025392 6 NUT, HEX NYLOCK FLANGE, 5/16-18
4 5025011X6 6 BOLT, 5/16-18 X 3/4
5 5025155 13 WASHER, SAE, 5/16
6 5044933 2 SPACER, .39 X .75 X .38
7 5025057 7 NUT, HEX NYLON LOCK, 5/16-18
8 5044617 3 WASHER, CLUTCH ANCHOR, 5/16
9 5043636 1 CLUTCH ANCHOR PAD
10 5050407X18 1 KEY, 1/4 SQ. X 2-1/4
11 5023100 1 CLUTCH, ELECTRIC
12 5042132 1 SPACER, .45 X 1.62 X .37
13 5023253 1 BOLT, CRANKSHAFT, 7/16 X 3-1/4
14 5021030 1 TIE WRAP
15 5048226D 1 CLUTCH ANCHOR
16 5025011X14 4 BOLT, 5/16-18 X 1-3/4
17 5025188 1 WASHER, 5/16 INT TOOTH LOCK
18 5025011X8 3 BOLT, 5/16-18 X 1
19 5400870D 1 PLATE, HEAT SHIELD
20 5048681 1 HOSE, OIL DRAIN (Not Shown)
21 5050833X6 1 WIRE LOOM, OIL DRAIN (Not Shown)
22 5021500 1 CLAMP, VINYL INSULATED (Not Shown)
23 5044960 2 SPACER, .39 X 1.00 X .38
tionItem Qt
Note
Footnotes:
Note: * See your local Kawasaki distributor for parts & service.
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
33
TP 400-5132-F-HZ-N
Engine & PTO Group - KOHLER
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
34
SERIES 1
Engine & PTO Group - KOHLER
p
y
Part No Descri
1 -- 1 * ENGINE, 18HP KOHLER Model SV540S, PS-552725
2 5025011X8 5 BOLT, 5/16-18 X 1
3 5025392 6 NUT, HEX NYLOCK FLANGE, 5/16-18
4 5025011X6 1 BOLT, 5/16-18 X 3/4
5 5025155 6 WASHER, SAE, 5/16
6 5025188 1 WASHER, 5/16 INT TOOTH LOCK
7 5025126 1 NUT, 1/4-20 HEX SERR. FLANGE
8 5044617 3 WASHER, CLUTCH ANCHOR, 5/16
9 5043636 1 CLUTCH ANCHOR PAD
10 5050407X18 1 KEY, 1/4 SQ. X 2-1/4
11 5023100 1 CLUTCH, ELECTRIC
12 5042132 1 SPACER, .45 X 1.62 X .37
13 5023253 1 BOLT, CRANKSHAFT, 7/16 X 3-1/4
14 5021029 1 TIE WRAP, 11" LONG
15 5048226D 1 CLUTCH ANCHOR
16 5025011X14 1 BOLT, 5/16-18 X 1-3/4" GD5 YZ
17 5048681 1 HOSE, OIL DRAIN
18 5050833X6 1 WIRE LOOM, OIL DRAIN
19 5021500 1 CLAMP, VINYL INSULATED
20 5100399 3 BOLT, 3/8-16 X 1", SELF-TAPPING
21 5023236 1 GROMMET, 3/4"
tionItem Qt
Note
Footnotes:
Note: * See your local Kohler distributor for parts & service.
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
35
TP 400-5132-F-HZ-N
Bumper Group
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
36
SERIES 1
Bumper Group
p
y
Part No Descri
1 5025394 6 NUT, 3/8-16 HEX NYLOCK FLANGE
2 5025156 6 WASHER 3/8” SAE
3 5025013X8 6 BOLT, 3/8-16 X 1” GD5
4 5400356D 1 WELD, BUMPER, SNAPPER Z (For Models with Kohler Engines)
5 5401074D 1 WELD, BUMPER, SNAPPER Z (For Models with 20 HP Briggs &
6 5023484 6 PLUG, PANEL, 1.25 BLACK
7 5403489D 1 WELD, BUMPER, SNAPPER Z (For Models with 24 HP Briggs &
tionItem Qt
Note
19 HP Kawasaki Engines)
Stratton Engines)
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
37
TP 400-5132-F-HZ-N
Decals Group - Brand & Model
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
38
SERIES 1
Decals Group - Brand & Model
p
y
Part No Descri
1 1731955 1 DECAL, SNAPPER, SILVER & BLACK, 8.5"
2 5100476 1 DECAL, STRIPE, LH, SNAPPER
3 5100477 1 DECAL, STRIPE, RH, SNAPPER
4 5101328 1 DECAL, 400Z 24HP (24 HP Models Only)
tionItem Qt
Note
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
39
TP 400-5132-F-HZ-N
Decals Group - Safety & Common
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
40
SERIES 1
Decals Group - Safety & Common
p
y
Part No Descri
1 5100252 1 DECAL, MAIN
2 5100280 1 DECAL, THROTTLE CONTROL
3 5048970 1 DECAL, IGNITION SWITCH
4 1725941 1 DECAL, CZT HYDRO RELEASE
5 5048907 1 DECAL, BELT & BLADE (Located Under Seat)
6 1725072 1 DECAL-TOUCH UP PAINT (Located Under Seat)
7 1725703 1 DECAL, HEIGHT OF CUT
8 -- 1 DECAL, US PATENT, ZTR Not a serviceable part.
9 -- 1 DECAL, ID PLATE Not a serviceable part.
10 5100136 1 DECAL, DANGER, MOWER
11 -- 1 DECAL-OPEI CERTIFIED ANSI B71.12003 GOLD Not a serviceable part.
12 1722789 1 DECAL-44”- SILVER ON BLACK W/STRIPE
12 1722790 1 DECAL-50”- SILVER ON BLACK W/STRIPE
13 5100137 1 DECAL, DANGER, MOWER DISCHARGE
tionItem Qt
Note
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
41
TP 400-5132-F-HZ-N
Export Decals Group - Safety & Common
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
42
SERIES 1
Export Decals Group - Safety & Common
p
y
Part No Descri
1 5061108 1 DECAL, MAIN CE
2 5100280 1 DECAL, THROTTLE CONTROL
3 5048970 1 DECAL, IGNITION SWITCH
4 1725941 1 DECAL, CZT HYDRO RELEASE
5 5048907 1 DECAL, BELT & BLADE (Located Under Seat)
6 1725072 1 DECAL-TOUCH UP PAINT (Located Under Seat)
7 1725703 1 DECAL, HEIGHT OF CUT
8 -- 1 DECAL, US PATENT, ZTR Not a serviceable part.
9 -- 1 DECAL, ID PLATE Not a serviceable part.
10 5061042 2 DECAL, CE DANGER
11 1704473 1 DECAL, HOT
12 1722789 1 DECAL-44”- SILVER ON BLACK W/STRIPE
12 1722790 1 DECAL-50”- SILVER ON BLACK W/STRIPE
13 1720389 2 DECAL-DANGER ROTATING BLADE SYMBOLS
14 5061217 1 DECAL, DANGER, CE
tionItem Qt
Note
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
43
TP 400-5132-F-HZ-N
Lift Group
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
44
SERIES 1
Lift Group
p
y
Part No Descri
1 5025203X6 1 PIN, Cotter, 1/8" X 3/4"
2 5100351 2 BUSHING, REAR QUICK TACH
3 5100144 4 SPACER, .53 X 1.00 X 1.44
4 5045947 2 ADJUSTER, BRAKE LINKAGE
5 5047125 2 SPACER, .39 X 1.00 X .88
6 5021812 2 EYE BOLT, 3/8-16 X 6” , 1” EYE
7 5025210 2 3/32 X 1-5/8 HAIR PIN CLIP N/A
8 5023174 2 CLEVIS , 1/2-20, STEEL
9 5025328X12 2 PIN CLEVIS 1/2” X 1-1/4”
10 5025096 2 NUT, 3/8-16 HEX NYLON LOCK
11 5023202 1 WASHER, WAVE, M10
12 5025018X20 2 BOLT, 1/2-20 X 2-1/2” GD5
13 5025394 20 NUT, 3/8-16 HEX NYLOCK FLANGE
14 5025305 4 WASHER, .41 X 1.75 X .14
15 5025013X12 2 BOLT, 3/8-16 X 1-1/2” GD5
16 5025098 4 NUT, 1/2-20 HEX NYLON LOCK
17 5025013X16 2 BOLT, 3/8-16 X 2” GD5
18 5025128 2 NUT, 3/8-16 HEX SERRATED FLANGE
19 5025156 6 WASHER 3/8” SAE
20 5025013X8 4 BOLT, 3/8-16 X 1” GD5
21 5100170 2 ROD, DECK LIFT, LINKAGE
22 5025155 4 WASHER, 5/16” SAE
23 5025011X8 4 BOLT, 5/16-18 X 1” GD5
24 5100177 1 SHAFT, HANGER
25 5100135 1 SHAFT, HANDLE, DECK SUPPORT
26 5400391D 1 WELD, DECK HANGER, LH
27 5400392D 1 WELD, DECK HANGER, RH
28 5400382D 1 PLATE, DECK HANGER SUPPORT
29 5044960 4 SPACER, .39 X 1.00 X .25
30 5044875 1 SAFETY WALK, 4.50 X 3.50
31 5048258 2 BUSHING, DECK SUPPORT
32 5025210 4 HAIRPIN
33 5021098 2 BEARING, BRONZE FLANGE 3/4”
34 5048711D 1 WELD, DECK LIFT HANGER REAR
35 5048733D 1 LINK, DECK LIFT SHAFT
36 5400872D 1 WELD, DECK HEIGHT SHAFT
37 5048884D 1 WELD, DECK LOCK
tionItem Qt
Note
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
45
TP 400-5132-F-HZ-N
Lift Group
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
46
SERIES 1
Lift Group
p
y
Part No Descri
38 5020639 1 SPRING, EXTENSION
39 5048264 2 SPACER, .63 X .39 X 1.50
40 5400370D 1 PLATE, INNER DECK HEIGHT
41 5048335 1 SPACER, .76 X 1.00 X 1.00
42 5046092 1 SPACER, .76 X 1.00 X .50
43 5100171 1 GRIP, BLACK FLEXIBLE
44 5100179 1 HITCH PIN, 1/2” X 2-1/2”
45 5023198 1 COVER, VINYL HANDLE
46 5400401D 2 WELD, QUICK RELEASE HANDLE, FRONT
47 5400839D 2 WELD, QUICK RELEASE HANDLE, REAR
48 5025013X6 4 BOLT, 3/8-16 X 3/4” GD5
49 5025356 2 SHOULDER BOLT, 3/8-16 X 1/2 X 3/8
50 5025011X6 2 BOLT, 5/16-18 X 3/4” GRD5
51 5025013X20 2 BOLT, 3/8-16 X 2-1/2” GD5
52 5025392 4 NUT, 5/16-18 HEX NYLOCK FLANGE
53 5021102 4 SPRING, COMPRESSION
54 5023497 2 EYE BOLT, 3/8-16 X 5", 1" EYE
55 5025089 2 NUT, 1/2-20 HEX JAM
56 5100561 2 BEARING, BRONZE FLANGE, 3/4"
tionItem Qt
Note
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
47
TP 400-5132-F-HZ-N
44" & 50" Mower Deck - Belt & Idler Group
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
48
SERIES 1
44" & 50" Mower Deck - Belt & Idler Group
p
y
Part No Descri
1 5023255 1 BELT (155" E. L. For 50" Deck)
1 5023256 1 BELT (151" E. L. For 44" Deck)
2 5044960 1 SPACER, .39 X 1.00 X .25
3 5044933 1 SPACER, .39 X .75 X .38
4 5023157 1 BOLT, 5/16-18 X 1-1/2” FLANGE
5 5025013X22 1 BOLT, 3/8-16 X 2-3/4” GD5
6 5025394 3 NUT, 3/8-16 HEX NYLOCK FLANGE
7 5025013X18 1 BOLT, 3/8-16 X 2-1/4” GD5
8 5025156 2 WASHER 3/8” SAE
9 5025013X28 1 BOLT, 3/8-16 X 3-1/2” GD5
10 5020095 1 FITTING, Grease
11 1676148 2 BUSHING, 5/8 X 3/4 X 13/32, POWDER METAL
12 5400398D 1 ASSM, IDLER ARM 44” SIMPLICITY
13 5047125 1 SPACER, .39 X 1.00 X .88
14 5400402 1 WELD, MOUNT, IDLER, TENSION
15 5049003 3 ASSM, PULLEY IDLER
16 1674669 1 Spacer
17 1715435 1 SPRING, EXTEN, 1.0 OD, 6” LG, .118
18 5025392 1 NUT, 5/16-18 HEX NYLOCK FLANGE
19 5048383D 1 ANCHOR, SPRING
20 5045023 1 SPACER, .52 X 1.00 X .44
tionItem Qt
Note
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
49
TP 400-5132-F-HZ-N
44" & 50" Mower Deck - Housing, Arbors & Blades Group
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
50
SERIES 1
44" & 50" Mower Deck - Housing, Arbors & Blades Group
p
y
Part No Descri
1 1714419 3 NUT, HEX FLANGE, 9/16-18
2 1713675 6 WASHER, BELLEVILLE, 9/16
3 1713161 3 PULLEY
4 1713613 3 HUB
5 1655729A 3 COVER, ARBOR HOUSING
6 2108202 3 BEARING, BALL, 3/4 X 1-3/4 X 5/8
7 1715724 3 SPACER, 21/32 X 3/4 X 5/8
8 1715723 3 SPACER, 11/16 X 5/32 X 2-11/16
9 1705897 3 BEARING, BALL, 11/16 X 1-9/16 X 15/32
10 1707335 3 SEAL, FOAM
11 1713338 3 ARBOR HOUSING ASSEMBLY (Includes Ref No. 12)
12 1704314 3 FITTING, GREASE
13 1664847 24 BOLT TAPTITE, 5/16-18 X 3/4
14 5400403D 1 COVER, ARBOR, LH
15 5022308 2 BODY CLIP, 5/16-18
16 1713619 3 WASHER, 9/16, BLACK
17 1713609 3 SHAFT, ARBOR
18 1713196 3 SHIELD, GRASS, LOWER
19 1704100A 3 BLADE, MOWER, 16-1/8 (For 44” Deck)
19 1708229A 3 BLADE, MOWER, 18-1/8 (For 50” Deck)
20 1713089 3 WASHER, HEX, 11/16 X 2
21 1656916 3 WASHER, SPRING, 15/32, BLACK
22 2923471 3 BOLT, 7/16-14 X 1-1/4
23 5600107 1 DECK SHELL W/DECALS, 44” MOWER (includes decals)
23 5600109 1 DECK SHELL W/DECALS, 50” MOWER (includes decals)
24 1931318 2 CARRIAGE BOLT, 1/4-20 X 7/8
25 1705115 1 PLUG, HOLE
26 5401091D 1 COVER, ARBOR, RH
27 1705449 1 DEFLECTOR, PLASTIC
28 1960353 2 WASHER, 1/4, BLACK
29 1704873 1 CLAMP
30 1919326 1 WASHER, 5/16, BLACK
31 1723938 1 SPRING
32 1723323 1 VINYL CAP
33 1916964 2 WASHER, LOCK, 1/4
34 1916622 2 NUT, HEX, 1/4-20
35 5049245A 1 ROD, DEFLECTOR
tionItem Qt
Note
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
51
TP 400-5132-F-HZ-N
44" & 50" Mower Deck - Housing, Arbors & Blades Group
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
52
SERIES 1
44" & 50" Mower Deck - Housing, Arbors & Blades Group
p
y
Part No Descri
36 5403498D 1 WELD, MOWER DECK, 50", 400Z MODELS (24 HP MODELS ONLY)
tionItem Qt
Note
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
53
TP 400-5132-F-HZ-N
44" & 50" Mower Deck Roller Group
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
54
SERIES 1
44" & 50" Mower Deck Roller Group
p
y
Part No Descri
1 1714760 4 GAUGE WHEEL
2 5025392 5 NUT, 5/16-18 HEX NYLOCK FLANGE
3 5025145X6 3 CARRIAGE BOLT, 5/16-18 X 3/4
4 5025394 4 NUT, 3/8-16 HEX NYLOCK FLANGE
5 5025145X8 2 CARRIAGE BOLT 5/16-18 X 3/4
6 1724538A 1 SHORT BLOWOUT BAFFLE
7 1960027 8 WASHER
8 2108765 4 BOLT, REAR WHEEL
9 5049017D 1 BRACKET, GAUGE WHEEL, LH - SNAPPER RED
10 5049018D 1 BRACKET, GAUGE WHEEL, RH - SNAPPER RED
11 5025145X6 10 BOLT, 5/16-18 X 3/4", CARRIAGE
12 5025057 10 NUT, 5/16-18 HEX NYLON LOCK
13 1716869A 1 BAFFLE-BLOWOUT RH 50” MWR - BLACK
14 1716870A 1 BAFFLE-BLOWOUT LH 50” MWR - BLACK
tionItem Qt
Note
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
55
TP 400-5132-F-HZ-N
Control Group Panel
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
56
SERIES 1
Control Group Panel
p
y
Part No Descri
1 5022665 1 BODY CLIP, 1/4-20 X .500 DEEP
2 5025299X6 1 SCREW, ALLEN HEAD, 1/4-20 X 3/4”
3 5047143 1 CHOKE CABLE
4 5047629 1 CABLE THROTTLE, 48”
5 5049022 1 BRACKET, LOCK
6 5022269 1 O-RING, 7/8” ID X 1/16” W
7 5400717A 1 PLATE, CONTROL TANK COVER
8 1709188 1 HOLE, PLUG DASH
9 5022222 1 RING, SWITCH RETAINER, PTO
10 5022180 1 SWITCH, BLADE ENGAGEMENT
11 5020927 1 SWITCH, IGNITION 6 POST (Includes Ref. 16 - 18)
12 5100978 1 HOUR METER-DIGITAL
13 5025095 2 NUT, Hex Nylon Lock, 1/4-20
14 5025010X6 2 BOLT, 1/4-20 x 3/4
15 5025035 1 NUT, 3/8-24 HEX
16 5022789 1 KEY, Ignition Molded (Set of 2)
17 5022790 1 COVER
18 5022791 1 PLASTIC NUT
tionItem Qt
Note
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
57
TP 400-5132-F-HZ-N
Electrical Group
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
58
SERIES 1
Electrical Group
p
y
Part No Descri
1 5020927 1 SWITCH, IGNITION, (Includes Ref No. 2-4)
2 5022789 1 KEY, Ignition Molded
3 5022790 1 COVER
4 5022791 1 PLASTIC NUT
5 1725523 1 HOUR METER, DIGITAL (Includes Retaining Ring)
6 5022180 1 SWITCH, PTO
7 5400371 1 MAIN HARNESS ASSEMBLY
8 5048756 1 CABLE, #6 X 15” LONG, RING TERMINAL
9 5100541 1 SWITCH, SEAT, GRAY, NC (Twist in)
9 5100540 1 SWITCH, SEAT (Screw in)
10 1960536 2 BOLT, HEX WASHER HEAD PLASTITE, 1/4 X 1/2
11 5021199 1 CABLE TIE, PUSH MOUNT
12 5023222 1 CIRCUIT BREAKER, 20A
13 5048938 1 CRICUIT BREAKER WIRE ASSEMBLY
14 5023216 2 NUT, HEX JAM, 5/16-24
15 5023217 2 WASHER, LIGHT LOCK, 5/16
16 1724815 1 SOLENOID
17 5025010X6 4 BOLT, 1/4-20 X 3/4
18 5025126 4 NUT, HEX SERRATED FLANGE, 1/4-20
19 5022182 2 SWITCH, PLUNGER, NO/NC, SNAP IN
20 5021406 1 CABLE, #6 X 22” LONG, RING TERMINAL
21 5020798 1 BATTERY, 12 VOLT
22 5021542 1 CABLE, #6 X 30” LONG, RING TERMINAL
23 1722009 1 STRAP, BATTERY, 14 LONG, RUBBER
24 5022095 2 SWITCH, PLUNGER, NO/NC
tionItem Qt
Note
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
59
TP 400-5132-F-HZ-N
Wiring Schematic 18hp
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
60
SERIES 1
Wiring Schematic 18hp
p
y
Part No Descri
-- -- 1 Wiring Schematic includes harness #5048640
tionItem Qt
Note
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
61
TP 400-5132-F-HZ-N
Wiring Schematic 20hp
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
62
SERIES 1
Wiring Schematic 20hp
p
y
Part No Descri
-- -- 1 Wiring Schematic includes harness #5048640
tionItem Qt
Note
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
63
TP 400-5132-F-HZ-N
Wiring Schematic - 24 HP Briggs & Stratton
Manual No. 7006937 HYDRO DRIVE ZTR
TP 400-5132-F-HZ-N
64
SERIES 1
Wiring Schematic - 24 HP Briggs & Stratton
p
y
Part No Descri
1 -- 1 WIRING SCHEMATIC INCLUDES HARNESS # 5402849
2 -- 1 WIRING SCHEMATIC INCLUDES HARNESS # 5402479 (CE / EXPORT MODELS ONLY)
tionItem Qt
Note
Footnotes:
Manual No. 7006937HYDRO DRIVE ZTR
SERIES 1
65
TP 400-5132-F-HZ-N
Parts Manual fo
r
Z
HYDRO DRIVE ZTR
350Z/400
SERIES 1
IT IS THE POLICY OF BRIGGS & STRATTON CORP TO IMPROVE ITS
PRODUCTS WHENEVER IT IS POSSIBLE AND PRACTICAL TO DO SO.
WE RESERVE THE RIGHT TO MAKE CHANGES OR ADD
IMPROVEMENTS AT ANY TIME WITHOUT INCURRING ANY
OBLIGATION TO MAKE SUCH CHANGES ON PRODUCTS
Briggs & Startton Yard Power Products Group
Copyright © 2007
Milwaukee, WI USA. All Rights Reserved
Briggs & Startton Corporation
Revision F,
McDonough, GA, 30253 U.S.A.
10/15/2007
Manual No. 7006937
TP 400-5132-F-HZ-N
Loading...