Parts Manual fo
r
S
2" STEEL DECK WALK BEHIND MOWER
MODEL
NS2265 (7800228)
NSP2265 (7800229)
S2265 (7800189)
SP2265 (7800165)
Briggs & Stratton Yard Power Products Group
535 Macon Road
McDonough, GA, 30253 U.S.A.
800-935-2967
Revision IR,
Manual No. 7006258
TP 400-5393-IR-WB-N4/7/2008
s
PAGE GROUP
4
6
8
10
14
16
18
Handles & Controls (Push)
Handles & Controls (Self-Propelled)
Deck Assembly (Push)
Deck Assemby (Self-Propelled)
Height-of-Cut Assemblies
Engine, Blade & Front Cover
Decals
Table Of Content
22" STEEL DECK WALK BEHIND MOWERS
Manual No. 7006258
3
TP 400-5393-IR-WB-N
Handles & Controls (Push)
Manual No. 7006258
TP 400-5393-IR-WB-N
22" STEEL DECK WALK BEHIND MOWERS
4
Handles & Controls (Push)
p
y
Part No Descri
1 7101405 1 UPPER HANDLE, Plastic, Snapper Push
2 7101321 1 BAIL, Plastic Handle, WBM
3 7090015 2 BOLT, 1/4-20 x 1-3/4” Round Head Square Neck, GR 2, YZ
4 2860694 3 NUT, 1/4-20, Hex Flange (Esna) YZ
5 7300649 2 HANDLE, Connecting, 21”/22” WBM
6 7101410 1 ROPE GUIDE (1/4-20 thread)
7 7035744 2 KNOB, 5/16-18 Wing (5/16-18 thread) (Black)
8 7091189 2 BOLT, 5/16-18 x 2” Curved Head Square Neck, GR 2
9 7090391 2 WASHER, 5/16” Internal Tooth Lock
10 7300628 1 HANDLE, Lower, 22” WBM
11 7101395 1 CABLE, Bail, 22” WBM
12 7101202 2 KNOB, Quick Release
13 7101199 2 BUSHING, Handle Pin
14 7101200 2 SPRING, Compression
15 7101198 2 PIN, Handle Adjust
16 7091303 2 BOLT, 5/16-18 x 1-1/2” Round Head Short Square Neck, GR 5 was 7090958
17 7090951 2 NUT, 5/16-18 Large Flange Center Lock
18 7101246 1 GRASS BAG, 22” Rear Discharge
19 7101230 1 BAG FRAME, 22” WBM (Weldment)
20 7024649 3 WIRE TIE,11” Standard Black Nylon
21 7026421 1 GRIP, Rectangular (Black)
tionItem Qt
Note
Footnotes:
Manual No. 700625822" STEEL DECK WALK BEHIND MOWERS
5
TP 400-5393-IR-WB-N
Handles & Controls (Self-Propelled)
Manual No. 7006258
TP 400-5393-IR-WB-N
22" STEEL DECK WALK BEHIND MOWERS
6
Handles & Controls (Self-Propelled)
p
y
Part No Descri
1 7101312 1 UPPER HANDLE, Plastic, WBM
2 7101417 1 ASSY, Control Head, 22” WBM, Single Speed (incl.Clutch Lever, Box, & Drive
3 7101321 1 BAIL, Plastic Handle, WBM
4 7090015 2 BOLT, 1/4-20 x 1-3/4” Round Head Square Neck, GR 2, YZ
5 2860694 3 NUT, 1/4-20, Hex Flange (Nyloc) YZ
6 7300670 1 PLATE, Control Panel
7 7100225 4 SCREW, #8-16 x 5/8” Recessed Pan Head Twin Helix (Torx)
8 7300649 2 HANDLE, Connecting, 21”/22” WBM
9 7101410 1 GUIDE, Rope (1/4-20 thread)
10 7035744 2 KNOB, 5/16-18 Wing (5/16-18 thread) (Black)
11 7091189 2 BOLT, 5/16-18 x 2” Curved Head Square Neck, GR 2
12 7090391 2 WASHER, 5/16” Internal Tooth Lock
13 7300628 1 HANDLE, Lower, 22” WBM
14 7101395 1 CABLE, Bail, 22” WBM
15 7101202 2 KNOB, Quick Release
16 7101199 2 BUSHING, Handle Pin
17 7101200 2 SPRING, Compression
18 7101198 2 PIN, Handle Adjust
19 7091303 2 BOLT, 5/16-18 x 1-1/2” Round Head Short Square Neck, GR 5 was 7090958
20 7090951 2 NUT, 5/16-18 Large Flange Center Lock
21 7101246 1 GRASS BAG, 22” Rear Discharge
22 7101230 1 BAG FRAME, 22” WBM (Weldment)
23 7026421 1 GRIP, Rectangular (Black)
24 7024649 3 WIRE TIE, 11” Standard Black Nylon
tionItem Qt
Note
Cable)
Footnotes:
Manual No. 700625822" STEEL DECK WALK BEHIND MOWERS
7
TP 400-5393-IR-WB-N
Deck Assembly (Push)
Manual No. 7006258
TP 400-5393-IR-WB-N
22" STEEL DECK WALK BEHIND MOWERS
8
Deck Assembly (Push)
p
y
Part No Descri
1 7300401 1 DECK, 22” Walk
2 722848 3 SCREW, 1/4-20 x 11/16” Pan Head Self-Tap (Torx)
3 7091020 4 PUSHNUT, 1/4”
4 726768 1 BRACKET, Chute
5 726766 1 PLATE, Mulch, 22” RB Scott's
6 722507 1 SPRING, Chute (Torsion)
7 7101067 1 ROD, Pivot (1/4” Dia. x 5.55”)
8 721682 1 COVER, Mulch, Plastic, Black
9 721681 1 SIDE CHUTE, Plastic, Black
10 721685 1 GUARD, Rear
11 7091286 4 SCREW, #10-24 x 1/2” Hex Washer Self-Tap (Sems)
12 7091619 4 NUT, 3/8-16 Hex Flange Lock, YZ
13 7501056 1 * ASSY, Height-Of-Cut, Right Rear, 22” WBM, Push & Propelled
14 7501055 1 * ASSY, Height-Of-Cut, Left Rear, 22” WBM, Push & Propelled
15 7501074 1 * ASSY, Height-Of-Cut, Left Front, 22” WBM, Push
16 7501073 1 * ASSY, Height-Of-Cut, Right Front, 22” WBM, Push
17 7100633 4 GRIP, Height Latch
18 7500540 4 ASSY, Wheel & Bearing, 8 x 2 Idle, DW Tread incl. two 1-1/8” O.D. Flanged
19 7300440 1 BAFFLE, Front, 22” WBM
20 722604 4 WASHER, 1” O.D. x .387 I.D. Flat
21 7091585 4 NUT, 3/8-16 Hex Center Lock, YZ
22 7101350 4 HUBCAP, Black
23 725105 1 BAFFLE, Rear, 22” Deck
24 7101243 1 DOOR, 22” Rear
25 7101070 1 ROD, Pivot, Rear Door (1/4” Dia. X 17-1/2”)
26 7101461 1 SPRING, Torsion, Rear Door, 22” WBM
27 7300668 1 BRACKET, Lower Handle, RH, 22” WBM
28 7300669 1 BRACKET, Lower Handle, LH, 22” WBM
29 7091811 2 BOLT, 5/16-18 x 5/8” Hex Flange Lock, YZ
30 7091601 2 NUT, 5/16-18 Flange Lock, YZ
tionItem Qt
Note
Ball Bearings (p/n 7101380)
Footnotes:
Note: * This assembly is also shown on Height-of-Cut Assemblies page.
Manual No. 700625822" STEEL DECK WALK BEHIND MOWERS
9
TP 400-5393-IR-WB-N
Deck Assemby (Self-Propelled)
Manual No. 7006258
TP 400-5393-IR-WB-N
22" STEEL DECK WALK BEHIND MOWERS
10
Deck Assemby (Self-Propelled)
p
y
Part No Descri
1 7300400 1 DECK, 22” Walk, 3 N 1
2 722848 3 SCREW, 1/4-20 x 11/16” Pan Head Self-Tap (Torx)
3 7091020 4 PUSHNUT 1/4”
4 726768 1 BRACKET, Chute
5 726766 1 PLATE, Mulch, 22” RB Scott's
6 722507 1 SPRING, Chute (Torsion)
7 7101067 1 ROD, Pivot (1/4” Dia. x 5.55”)
8 721682 1 COVER, Mulch, Plastic, Black
9 721681 1 SIDE CHUTE, Plastic, Black
10 721685 1 GUARD, Rear
11 7091286 4 SCREW, #10-24 x 1/2” Hex Washer Self-Tap (Sems)
12 7091619 10 NUT, 3/8-16 Hex Flange Lock, YZ
13 7501056 1 * ASSY, Height-Of-Cut, Right Rear, 22” WBM
14 7501055 1 * ASSY, Height-Of-Cut, Left Rear, 22” WBM
15 7501058 1 * ASSY, Height-Of-Cut, LF, 22” WBM, Propelled
16 7501057 1 * ASSY, Height-Of-Cut, RF, 22” WBM, Propelled
17 7100633 4 GRIP, Height Latch
18 7500540 2 ASSY, Wheel & Bearing, 8 x 2 Idle, DW Tread incl. two 1-1/8” O.D. Flanged
19 7500542 2 ASSY, Drive Wheel & Bearing, 8 x 2, DW Tread incl. two 1-1/8” O.D. Flanged
20 722604 4 WASHER, 1” O.D. x .387 I.D. Flat
21 7091585 4 NUT, 3/8-16 Hex Center Lock, YZ
22 7101350 4 HUBCAP, Black
23 720508 SPACER
24 7101243 1 DOOR, 22” Rear
25 7101070 1 ROD, Pivot, Rear Door (1/4” Dia. X 17-1/2”)
26 7101461 1 SPRING, Torsion, Rear Door, 22” WBM
27 7300668 1 BRACKET, Lower Handle, RH, 22” WBM
28 7300669 1 BRACKET, Lower Handle, LH, 22” WBM
29 7091811 2 BOLT, 5/16-18 x 5/8” Hex Flange Lock, YZ
30 7091601 3 NUT, 5/16-18 Flange Lock, YZ
31 7014341 4 RING, External Retaining (Waldes 5133-50)
32 7101207 2 GEAR, Pinion, 22” WBM, Front Wheel Drive
33 7101402 2 DUST SHIELD, Forward, 22” WBM
34 7900054 4 SCREW, 3/8-16 x 3/4” Hex Head Cap, GR 5, YZ
35 7101206 1 TRANSMISSION, 22” WBM Single Speed, Front Wheel Drive used on SP2265 & NSP22656
36 7101270 2 DRIVE PIN, 22” WBM, Front Wheel Drive
37 725105 1 BAFFLE, Rear, 22” Deck
tionItem Qt
Note
Ball Bearings (p/n 7101380)
Ball Bearings (p/n 7101380)
Footnotes:
Note: * This assembly is also shown on Height-of-Cut Assemblies page.
Manual No. 700625822" STEEL DECK WALK BEHIND MOWERS
11
TP 400-5393-IR-WB-N
Deck Assemby (Self-Propelled)
Manual No. 7006258
TP 400-5393-IR-WB-N
22" STEEL DECK WALK BEHIND MOWERS
12
Deck Assemby (Self-Propelled)
p
y
Part No Descri
38 7300440 1 BAFFLE, Front, 22” WBM
39 722410 1 SPRING, Compression
tionItem Qt
Note
Footnotes:
Note: * This assembly is also shown on Height-of-Cut Assemblies page.
Manual No. 700625822" STEEL DECK WALK BEHIND MOWERS
13
TP 400-5393-IR-WB-N
Height-of-Cut Assemblies
Manual No. 7006258
TP 400-5393-IR-WB-N
22" STEEL DECK WALK BEHIND MOWERS
14
Height-of-Cut Assemblies
p
y
Part No Descri
1 7501056 1 * ASSY, Height-Of-Cut, Right Rear, 22” WBM, Push & Propelled
2 7501055 1 * ASSY, Height-Of-Cut, Left Rear, 22” WBM, Push & Propelled
3 7501057 1 * ASSY, Height-Of-Cut, RF, 22” WBM, Propelled
4 7501058 1 * ASSY, Height-Of-Cut, LF, 22” WBM, Propelled
5 7501073 1 * ASSY, Height-Of-Cut, Right Front, 22” WBM, Push
6 7501074 1 * ASSY, Height-Of-Cut, Left Front, 22” WBM, Push
7 7091497 1 SCREW, 3/8-16 x 1-1/2” Hex Head Cap, GR 5, YZ
8 7900047 1 WASHER, .391 x 1” x 14 Ga. Flat
9 7900046 1 WASHER, .76 x 1.25 x .180 Flat
10 7101205 1 LEVER, Height-Of-Cut, 22” WBM
11 7500409 1 ASSY, Rear Axle, RH 22” WBM
12 7500408 1 ASSY, Rear Axle, LH 22” WBM
13 722611 1 WASHER, 1” I.D. x 1.64 O.D. Bellville
14 7300529 1 INDEX PLATE, Height-Of-Cut, Rear
15 721899 1 SPACER, Height Adjust
16 7013847 1 RETAINER, 3/8” Bolt
17 720118 1 RING, .906 I.D. x .078 Thick, External Retaining
18 7500404 1 ASSY, Front Axle 22”, Propelled
19 7101212 1 LEVER, Height-Of-Cut, 22” WBM
20 7300528 1 INDEX PLATE, Height-Of-Cut, Front Right, 22” WBM
21 7300527 1 INDEX PLATE, Height-Of-Cut, Front Left, 22” WBM
22 720685 1 RETAINER, Bearing
23 720761 1 BALL BEARING, 1/2 I.D. x 1-1/8” O. D. Flanged w/seal
24 7500476 1 ASSY, Front Axle, 22” WBM, Push
tionItem Qt
Note
Footnotes:
Note: * This assembly is also shown on Deck Assemby page.
Manual No. 700625822" STEEL DECK WALK BEHIND MOWERS
15
TP 400-5393-IR-WB-N
Engine, Blade & Front Cover
Manual No. 7006258
TP 400-5393-IR-WB-N
22" STEEL DECK WALK BEHIND MOWERS
16
Engine, Blade & Front Cover
p
y
Part No Descri
1 -- 1 * ENGINE, B&S, 650 Ser, (124T02-0650-B3) used on S2265 & SP2265
1 -- 1 * ENGINE, B&S, 650 Ser, (124L02-0650-F3) used on NS2265 & NSP2265
2 7101449 1 ASSY, Engine Spacer, 22” WBM, Self-Propelled includes 7101209 (spacer) &
3 7101195 1 FRONT COVER, Deck, 22” Front Wheel Drive
4 7101310 1 FRONT COVER, Rear Discharge Push WBM
5 7900018 2 SCREW, 4.8 x 1.59 x 13mm, Round Washer Head Hi-Lo (Torx)
6 7101302 2 SPACER, BELT GUIDE, 22” VS
7 7101024 2 BELT GUIDE, Engine, 22” VS
8 7101451 2 HWST, 3/8-16 X 3.00
9 720351 1 BOLT, 3/8-16 NS x 2-1/2”
10 7091214 1 KEY, #HP-506 HI-PRO
11 7100763 1 PULLEY, Engine, 22” Deck, Single Speed
12 7101193 1 ** BELT, Drive (3L Section; 33.75” effective length) used on SP2265
13 7092086 1 SET SCREW, 5/16-18 x 1/2” Hex Recess
14 7100740 1 BLADE HUB, 22” Deck, Self Propelled
15 7100862 1 BLADE HUB, 22” Deck, Push
16 7100851 1 BLADE, 22”, Walk Mower
17 721890 1 WASHER, .38” I.D. x 1.183 O.D. Bellville
18 7090824 1 SCREW, 3/8-24 x 1-1/4” Hex Head Cap, GR 5
tionItem Qt
Note
7101448 (3) (bushings)
Footnotes:
NOTE: * Purchase engine parts from engine manufacturer dealer.
Note: ** Part number appears on belt
Manual No. 700625822" STEEL DECK WALK BEHIND MOWERS
17
TP 400-5393-IR-WB-N
Decals
Manual No. 7006258
TP 400-5393-IR-WB-N
22" STEEL DECK WALK BEHIND MOWERS
18
Decals
p
y
Part No Descri
1 7101537 1 DECAL, Front Cover, 22” Snapper, Push
2 7101538 1 DECAL, Front Cover, 22” Snapper, Single Speed
3 7101429 1 DECAL, Control Head, MY 08
4 7100984 1 DECAL, Warning/Danger WBM
5 7013010 1 DECAL, Danger, Cut Finger
6 7029782 1 DECAL, OPC Bail International Symbol
7 7101394 1 DECAL, Warning, Rear Discharge Door
1 DECAL, OPEI Walk/Ride not shown; not a service part
tionItem Qt
Note
Footnotes:
Manual No. 700625822" STEEL DECK WALK BEHIND MOWERS
19
TP 400-5393-IR-WB-N
Parts Manual fo
r
22" STEEL DECK WALK BEHIND MOWERS
IT IS THE POLICY OF BRIGGS & STRATTON CORP. TO IMPROVE ITS
PRODUCTS WHENEVER IT IS POSSIBLE AND PRACTICAL TO DO SO.
WE RESERVE THE RIGHT TO MAKE CHANGES OR ADD
IMPROVEMENTS AT ANY TIME WITHOUT INCURRING ANY OBLIGATION
TO MAKE SUCH CHANGES ON PRODUCTS MANUFACTURED
Briggs & Stratton Yard Power Products Group
535 Macon Road
McDonough, GA, 30253 U.S.A.
800-935-2967
www.snapper.com
Copyright © 2008
Milwaukee, WI USA. All Rights Reserved
Briggs & Stratton Corporation
Manual No. 7006258
Revision IR,
TP 400-5393-IR-WB-N
4/7/2008
Loading...