Snapper LT2040 User Manual

Parts Manual fo

r

)

LAWN TRACTOR ELECTRIC CLUTCH

HYDRO DRIVE RMO & ACS

SERIES 0

MODEL

LT2040 (2690655

Briggs & Startton Yard Power Products Group
Copyright © 2007
Milwaukee, WI USA. All Rights Reserved

Briggs & Startton Corporation

McDonough, GA, 30253 U.S.A.

Revision IR,

5/30/2007

Manual No. 7006472

TP 400-5277-IR-TC-N

s

PAGE GROUP

4
6

8
10
14
18
20
24
30
32
34
36
40
42
46
48

Wheels & Tires Group
Hood, Grille & Dash Group
Steering Group - Manual Steering
Frame & Front Axle Group
Controls Group
Cruise Control Group
Transmission Group - Tuff Torq K-57
Transmission SERVICE PARTS - Tuff Torq K-57A
Seat & Seat Deck Group
Engine & Electric Clutch Group - 18HP & 20HP B&S, Vanguard
Lift Group - Manual Lift
40" Mower Deck - Housing, Arbors & Blades
40" Mower Deck - Belt, Idler Arm & Hitch
40" Mower Deck - Height Adjustment & Roller Bar
Decal Group
Electrical Group

Table Of Content

SERIES 0

Manual No. 7006472LAWN TRACTOR ELECTRIC CLUTCH

3

TP 400-5277-IR-TC-N

Wheels & Tires Group

Manual No. 7006472 LAWN TRACTOR ELECTRIC CLUTCH
TP 400-5277-IR-TC-N

4

SERIES 0

Wheels & Tires Group

p

y

Part No Descri

1 1732202 2 WHEEL & TIRE ASSEMBLY, Front, (Includes Ref. Nos. 2, 3, 4,

5, & 6)
2 1733882 1 TIRE, 15 x 6, Super Turf
3 1664090 1 TUBE, Tire, Front, 4.10/3.50
4 1717056 2 BEARING, Ball
5 1722837 1 WHEEL, 4-1/2" x 6"
6 2172353 4 VALVE STEM & CAP ASSEMBLY
7 1722726 2 WASHER, Special
8 1919394 4 WASHER, 1
9 2832577 2 RING, Retaining, External #98

10 1722676 4 CAP, Hub, Gray
11 1729279 2 KEY, Parellel, 3/16 x 3/16 x 1-1/2
12 2860202 8 WASHER, 3/4
13 1960114 2 WASHER, 3/4 x 1-1/16 x 5/64
14 1726491 2 WHEEL & TIRE ASSEMBLY, Rear, (Includes Ref. Nos. 6, 15, 16

& 17)

15 1727136 1 TIRE, 22 x 10, 10 Super Turf
16 2173477 1 TUBE, Tire, 20 x 8, Rear
17 1726492 1 WHEEL, 7 x 9.97 Dia. 3/4 ID, Hub
18 1722717 2 WASHER, Special
19 2827794 2 RING, "E" External

tionItem Qt

Note

Footnotes:

Manual No. 7006472LAWN TRACTOR ELECTRIC CLUTCH

SERIES 0

5

TP 400-5277-IR-TC-N

Hood, Grille & Dash Group

Manual No. 7006472 LAWN TRACTOR ELECTRIC CLUTCH
TP 400-5277-IR-TC-N

6

SERIES 0

Hood, Grille & Dash Group

p

y

Part No Descri

1 1728031D 1 HOOD, W/Scoop
4 1721804D 1 PANEL, R.H. Side
5 1721803D 1 PANEL, L.H. Side
6 1721810 1 HEADLIGHT ASSEMBLY (Includes Ref. Nos. 22, 23 & 24)
7 1721802D 1 GRILLE
8 1930641 12 NUT, Hex Flange 1/4-20 Whiz Lock
9 1726827 1 DASHBOARD (Used only on YT & LT models)

10 1726894 1 DASHBOARD, W/Hydraulic Lift Slot (Used only on GT models)
12 1721808A 1 HINGE, Hood L.H.
13 1721809A 1 HINGE, Hood R.H.
14 1723123 1 ROD, Dash Support
15 1933896 1 NUT, Hex Lock 10-24 w/Nylon Insert
16 1960392 1 SCREW, Pan Head Phillips #10-24 x 1
17 1960295 12 SCREW, Hex Whiz Lock Flange 1/4-20 x 5/8
18 1733457A 1 DUCT, Air Inlet
19 1726895 1 DASHBOARD, w/Buzzer Hole (Used only on Barons models)
20 1722285 1 COVER, Dash (Used only on Barons models)
21 1722607 1 SCREW, Pan Head Torx #8-16 x 1/2 Plastite (Used only on Barons models)
22 1677371 4 BULB, Headlight
23 1723451 4 SOCKET ASSEMBLY, Seal
24 1722902 1 REFLECTOR, Headlight

tionItem Qt

Note

Footnotes:

Manual No. 7006472LAWN TRACTOR ELECTRIC CLUTCH

SERIES 0

7

TP 400-5277-IR-TC-N

Steering Group - Manual Steering

Manual No. 7006472 LAWN TRACTOR ELECTRIC CLUTCH
TP 400-5277-IR-TC-N

8

SERIES 0

Steering Group - Manual Steering

p

y

Part No Descri

1 1722318 1 STEERING WHEEL, Straight, Shaft
2 1725024 1 CAP, Steering Wheel, Plain
3 1960540 1 PIN, Spring, 5/16 x 2-1/2
4 1722749 1 COVER, Rubber, Upper Steering Shaft
5 1960114 5 WASHER, 3/4
6 2176440 2 BUSHING, 15/32 x 7/8 x 7/8, Nylon
7 1960636 2 NUT, Hex KEPS 5/6-18
8 1721736A 1 PLATE, Mounting Steering
9 1933988 2 NUT, Push

10 1960655 2 CARRIAGE BOLT, 5/16-18 x 1-1/4
11 1724470A 1 GEAR & SHAFT ASSEMBLY, Steering
12 1960032 1 CAPSCREW, Hex Head, 3/8-16 x 1-1/4, Black
13 1930645 1 NUT, Hex Flange Two-Way Lock, 3/8-16
14 1664847 2 CAPSCREW, Hex Washer Head Taptite, 5/16-18 x 3/4
15 1721626 1 SHAFT & PINION ASSEMBLY, Steering Manual
16 1611710 1 RING, Clipring Extension
17 1722459 1 BEARING, 3/4 x 1-11/16 x 13/16, 3” Long Housing
18 1722461 1 SPACER, 3/4 x 1-1/16 x 3/8, Powder Metal
19 1931211 2 NUT, Hex Flange Whiz Lock, 3/8-16, Small
20 1933260 2 CAPSCREW, Hex Whiz Lock Flange, 3/8-16 x 3/4, Black
21 1919314 1 PIN, Cotter, 1-1/4, Black

tionItem Qt

Note

Footnotes:

Manual No. 7006472LAWN TRACTOR ELECTRIC CLUTCH

SERIES 0

9

TP 400-5277-IR-TC-N

Frame & Front Axle Group

Manual No. 7006472 LAWN TRACTOR ELECTRIC CLUTCH
TP 400-5277-IR-TC-N

10

SERIES 0

Frame & Front Axle Group

p

y

Part No Descri

1 1930645 7 NUT, Hex Flange Lock, 3/8-16
2 1960035 2 WASHER
3 2860646 1 NUT, Hex Flange, 5/8-11
4 1722212A 1 PLATE, Axle
5 1724081A 1 TOWER & SUPPORT ASSEMBLY
6 1923683 4 CAPSCREW, Hex Head Taptite, 3/8-16 x 3/4
7 1723528A 1 SUPPORT
8 1664847 4 CAPSCREW, Hex Head Taptite, 5/16-18 x 3/4
9 1726989A 1 FRAME ASSEMBLY

10 2860645 1 CAPSCREW, 5/8-11 x 3-1/2
11 1704314 2 FITTING, Grease for Wear Plate, 1/4-20, with Ball
12 1933260 4 CAPSCREW, Hex Head, Flange Lock, 3/8-16 x 3/4
13 1722541 1 LINK, Drag
14 1922755 1 WASHER
15 1960103 2 WASHER
16 1919262 1 NUT, Hex Jam, 1/2-20
17 1702779A 1 JOINT, Ball
18 1708236 1 SPACER
19 1931350 2 CARRIAGE BOLT, 3/8-16 x 1
20 1611705 2 SPACER
21 1722626A 1 ROD, Tie
22 1721682 6 BUSHING
23 1930650 2 NUT, Hex Flange Lock, 7/16-14
24 1704314 3 FITTING, Lube
25 1686985 1 SPINDLE REPLACEMENT KIT, LH (Includes Ref. Nos. 22, 26,

27, 28, 29 & 30)

26 2823485 1 CAPSCREW, 3/8-16 x 7/8, GR8
27 1663151 1 WASHER, Spring, 3/8
28 1725112 1 HUB & ARM ASSEMBLY
29 2830671 1 KEY, Woodruff
30 1724264 1 SPINDLE, LH
31 1722200A 1 AXLE ASSEMBLY, w/ LH Spindle, Complete (Includes Ref. Nos.

22, 24, 41, 42 & 43)

32 1931352 1 CARRIAGE BOLT, 3/8-16 x 1-1/2
33 1927531 2 CAPSCREW, Hex Head, 7/16-14 x 2, GR8
34 1721918A 1 HOOK, “J”
35 1721752 1 SPACER
36 1960086 4 SCREW, Torx Head, 5/16-18 x 7/8
37 1721805A 1 BUMPER, Black, Steel, Standard

tionItem Qt

Note

Footnotes:

Manual No. 7006472LAWN TRACTOR ELECTRIC CLUTCH

SERIES 0

11

TP 400-5277-IR-TC-N

Frame & Front Axle Group

Manual No. 7006472 LAWN TRACTOR ELECTRIC CLUTCH
TP 400-5277-IR-TC-N

12

SERIES 0

Frame & Front Axle Group

p

y

Part No Descri

37 1723502 1 BUMPER, Chrome, Optional
38 1930591 2 CAPSCREW, Hex Whiz Lock, 5/16-18 x 3/4
39 1724801A 1 PLATE, Axle Wear
40 1931277 2 NUT, Hex Falnge Whiz Lock, 5/16-18
41 1722199 1 SPINDLE, RH
42 1919394 1 WASHER
43 2832577 1 RETAINING RING

tionItem Qt

Note

Footnotes:

Manual No. 7006472LAWN TRACTOR ELECTRIC CLUTCH

SERIES 0

13

TP 400-5277-IR-TC-N

Controls Group

Manual No. 7006472 LAWN TRACTOR ELECTRIC CLUTCH
TP 400-5277-IR-TC-N

14

SERIES 0

Controls Group

p

y

Part No Descri

1 1721353 1 ROD, Brake Lock
2 1721891 1 KNOB, Push On, Red Plastic “P”
3 1930591 1 CAPSCREW, Hex Flange Whiz Lock, 5/16-18 x 3/4
4 1919326 2 WASHER, 5/16, Black
5 1721476 1 ROD, Brake
6 1931353 2 CARRIAGE BOLT, 3/8-16 x 1 3/4
7 1663114 2 BUSHING, 5/8 x 3/4 x 3/4, Nylon
8 2821133 1 FITTING, Lube, 1/4
9 1725250 1 SPRING, Extension

10 1722460 3 PIN, Quick
11 1724917 1 ARM & HUB ASSEMBLY, Idler
12 1960020 1 WASHER, 5/8
13 1704420 1 RING, Clipring Extension
14 1721134 1 PULLEY, w/Bearing
15 1924940 1 WASHER, 3/8
16 1960687 2 NUT, Hex Flange ESNA, 3/8-16
17 1721133 1 PULLEY, Idler
18 1723237 2 BUSHING, 1 x 1-1/8 x 5/8, Nylon
19 1722513 1 ARM, Brake
20 1726763 1 PEDAL ASSEMBLY, Foot
21 1931320 1 CARRIAGE BOLT, 1/4-20 x 1-1/4
22 1918447 1 PIN, Cotter, Black
23 1721354A 1 LATCH, Brake
24 1664847 3 CAPSCREW, Hex Washer Head Taptite, 5/16-18 x 3/4
25 1919438 1 NUT, Hex Lock ESNA Light, 5/16-18
26 1919381 1 WASHER, 5/16, Black
27 1927557 2 NUT, Hex Flange Whiz Lock Large, 5/16-18
28 1722535A 1 PEDAL, Brake
29 1721577 1 PAD, Brake Pedal
30 1931334 4 CARRIAGE BOLT, 5/16-18 x 7/8
31 1921333 2 CAPSCREW, 5/16-18 x 1
32 1722083A 1 ACTUATOR, Switch 2.53” Long
33 1923683 1 CAPSCREW, Hex Washer Head Taptite, 3/8-16 x 3/4
34 1722070A 1 PEDAL, Forward
35 1960636 4 NUT, Hex KEPS, 5/16-18
36 1721675 1 PAD, Foot Pedal Forward
37 1722071A 1 PEDAL, Reverse

tionItem Qt

Note

Footnotes:

Manual No. 7006472LAWN TRACTOR ELECTRIC CLUTCH

SERIES 0

15

TP 400-5277-IR-TC-N

Controls Group

Manual No. 7006472 LAWN TRACTOR ELECTRIC CLUTCH
TP 400-5277-IR-TC-N

16

SERIES 0

Controls Group

p

y

Part No Descri

38 1721674 1 PAD, Foot Pedal Reverse
39 1920397 1 NUT, Hex Lock ESNA Light, 1/4-20
40 1686612 1 CAM, Roller
41 1721995 1 SPRING, Extension

tionItem Qt

Note

Footnotes:

Manual No. 7006472LAWN TRACTOR ELECTRIC CLUTCH

SERIES 0

17

TP 400-5277-IR-TC-N

Cruise Control Group

Manual No. 7006472 LAWN TRACTOR ELECTRIC CLUTCH
TP 400-5277-IR-TC-N

18

SERIES 0

Cruise Control Group

p

y

Part No Descri

1 1723713 1 DECAL, Cruise & Lift
2 1960666 1 SCREW, Torque Head Plus Socket Head, 1/4-20 x 7/8
3 1722303 1 KNOB, Cruise
4 1920397 1 NUT, Hex Lock ESNA Light, 1/4-20
5 1722003 1 LEVER & BRACKET ASSEMBLY, Cruise
6 1960103 2 WASHER, 3/8, Black
7 1931333 1 CARRIAGE BOLT, 5/16-18 x 3/4
8 2826192 2 WASHER, 9/16 x 1-1/4 x 1/8
9 1709043 1 SPACER, w/Flange, 11/32 x 15/32 x 3/4

10 1931342 1 CARRIAGE BOLT, 5/16-18 x 2 3/4
11 1960273 1 CARRIAGE BOLT, 5/16-18 x 2-1/4
12 1722460 2 PIN, Quick
13 1722117 1 ROD, Cruise
14 1722481 1 ROD, Return
15 2159106 1 SPRING, Cruise Return to Frame
16 1960636 2 NUT, Hex KEPS, 5/16-18
17 1960001 2 CAPSCREW, Hex Washer Head Plastite, 10-14 x 5/8
18 1717050 1 SWITCH, Push, Neutral Start, Gray
19 1722080 1 SPACER, 11/32 x 5/8 x 1-13/32
20 1919326 1 WASHER, 5/16, Black
21 1919381 1 WASHER, 5/16, Black
22 1919438 1 NUT, Hex Lock ESNA Light, 5/16-18
23 1677746 1 SPRING, Compression
24 1918447 1 PIN, Cotter
25 1705928 1 DISC, Fricion

tionItem Qt

Note

Footnotes:

Manual No. 7006472LAWN TRACTOR ELECTRIC CLUTCH

SERIES 0

19

TP 400-5277-IR-TC-N

Transmission Group - Tuff Torq K-57

Manual No. 7006472 LAWN TRACTOR ELECTRIC CLUTCH
TP 400-5277-IR-TC-N

20

SERIES 0

Transmission Group - Tuff Torq K-57

p

y

Part No Descri

1 1960676 2 SCREW, Pan Head Torx Taptite, 1/4-20 x 1-1/4, Black
2 1722345 1 PAD, Footrest, LH, without Differential Lock
3 1722173 1 PAD, Footrest, RH
4 1960636 1 NUT, Hex KEPS, 5/16-18, Black
5 1704351 15 FASTENER, Panel
6 1960637 6 NUT, Hex KEPS, 3/8-16, Black
7 1931350 6 CARRIAGE BOLT, 3/8-16 x 1, Black
8 1960686 5 NUT, Hex Flange ESNA, 5/16-18, Black
9 1721728A 2 SUPPORT, Transmission

10 1724316 1 RING, Snap, Transmission
11 1724312 1 COLLOR, Spline, Transmission
12 1724315 2 LOCK WASHER, Transmission
13 1724314 1 FAN, 10 Blade, Transmission
14 1718076 1 RING, E Transmission
15 1960027 2 WASHER, 1/2
16 1721666 1 PULLEY & HUB ASSEMBLY
17 1726841 1 V-BELT, Drive
18 1726806 1 ROD, Transmission Release
19 1722460 3 PIN, Quick
20 1921332 1 CAPSCREW, Hex Head, 5/16-18 x 2
21 1919326 4 WASHER, 5/16, Black
22 1923141 4 CAPSCREW, Hex Head, 5/16-18 x 2-3/4, Black
23 1918267 1 WASHER, 15/32 x 15/16, Black
24 1918447 1 PIN, Cotter, Black
25 1726871 1 ROD, Brake
26 1722684 1 SPRING, Compression, 3-1/4” Long, Black
27 1729277 1 SPRING, Compression, 3-5/8” Long, Black
28 1960687 1 NUT, Hex FlangeESNA, 3/8-16, Black
29 1924940 3 WASHER, 3/8, Black
30 1722668 1 TRANSMISSION ASSEMBLY, K57, without Pulley
31 1726803 1 CONTROL ARM ASSEMBLY
32 1724423A 1 ARM, Control
33 1960636 2 NUT, KEPS Lock, 5/16-18
34 1721592A 1 STRAP, Torque
35 1931335 1 CARRIAGE BOLT, 5/16-18 x 1, Black
36 1960141 1 WASHER, 5/16, Black
37 1921978 1 CAPSCREW, Hex Head, 5/16-18 x 2, Black

tionItem Qt

Note

Footnotes:

Manual No. 7006472LAWN TRACTOR ELECTRIC CLUTCH

SERIES 0

21

TP 400-5277-IR-TC-N

Transmission Group - Tuff Torq K-57

Manual No. 7006472 LAWN TRACTOR ELECTRIC CLUTCH
TP 400-5277-IR-TC-N

22

SERIES 0

Transmission Group - Tuff Torq K-57

p

y

Part No Descri

38 1727215A 1 ACTUATOR, Switch
39 1924856 2 CAPSCREW, Hex Head Taptite, 5/16-18 x 1/2

tionItem Qt

Note

Footnotes:

Manual No. 7006472LAWN TRACTOR ELECTRIC CLUTCH

SERIES 0

23

TP 400-5277-IR-TC-N

Transmission SERVICE PARTS - Tuff Torq K-57A

Manual No. 7006472 LAWN TRACTOR ELECTRIC CLUTCH
TP 400-5277-IR-TC-N

24

SERIES 0

Transmission SERVICE PARTS - Tuff Torq K-57A

p

y

Part No Descri

2 1724951 1 HOUSING ASSEMBLY, UPPER
3 1724938 1 HOUSING, LOWER
7 1718052 1 VENT VALVE 15
8 1724279 2 MAGNET, K50
9 1724280 1 HOLDER, MAGNET

11 1708684 1 SPRING
12 1724281 1 SHAFT, BYPASS
13 1720418 1 LEVER, BYPASS
14 1718061 1 RING
15 1724282 1 SEALING CAP
16 1708650 1 RING 35
19 1708691 2 PACKING
20 1724283 1 SEAL TC
21 1707789 14 SCREW, TAPPING
22 1724284 2 SCREW, TAPPING
24 1724939 1 CASE, CENTER
25 1718070 1 PIN 3 x 9.8
26 1724954 1 FILTER
27 1720805 3 BOLT 10 x 75
28 1724286 2 VALVE, IDS 1.0
29 1724287 2 SPRING, IDS
30 1724288 2 BALL, 3/16
31 1724940 1 CYLINDER BLOCK ASSEMBLY
32 1724290 1 SPRING, PUMP
33 1724941 1 SHAFT, PUMP
34 1718076 3 RING E15
35 1708673 1 BEARING
36 1718077 1 HOUSING
37 1724942 1 BEARING, THRUST
38 1724289 1 BLOCK, CYLINDER
39 1718084 1 WASHER 12 x 24 x 1
40 1724943 1 SHAFT, MOTOR
41 1708672 1 RING 15
42 1724944 1 GEAR, MOTOR
43 1718083 1 BEARING 6202UC3
44 1718089 2 THRUST METAL
45 1720426 1 SWASH PLATE ASSEMBLY
46 1718088 1 THRUST PLATE B

tionItem Qt

Note

Footnotes:

Manual No. 7006472LAWN TRACTOR ELECTRIC CLUTCH

SERIES 0

25

TP 400-5277-IR-TC-N

Transmission SERVICE PARTS - Tuff Torq K-57A

Manual No. 7006472 LAWN TRACTOR ELECTRIC CLUTCH
TP 400-5277-IR-TC-N

26

SERIES 0

Transmission SERVICE PARTS - Tuff Torq K-57A

p

y

Part No Descri

47 1718086 1 BEARING K81105
48 1718087 1 THRUST PLATE A
49 1724343 1 SHAFT, CONTROL
50 1724344 1 FULCRUM, ECCENTRIC
51 1724345 1 SPRING, TORSION
52 1724346 1 LEVER, CONTROL
53 1724347 1 ARM, CONTROL
54 1724348 1 PLATE, JERK
55 1708689 1 WASHER
56 1724349 1 PIN, COTTER
57 1724296 1 PIN, SPRING
59 1707879 2 PACKING
58 1718100 1 PIN 6.0A x 4.0
60 1708692 1 NUT 12
61 1724955 1 GEAR & PINION ASSEMBLY
62 1724945 1 GEAR, FINAL CONTR TRAC
63 1724946 2 COLLAR, PINION
64 1724947 1 SHAFT, REDUCTION
65 1724948 2 WASHER, 12 x 32 x 3.2
66 1724949 1 GEAR, REDUCTION
67 1724950 1 PINION, FINAL
68 1724304 1 SHAFT, AXLE RH
69 1724303 1 SHAFT, AXLE LH
70 1718112 2 WASHER, THRUST
71 1718113 2 RING 17
72 1718111 2 SEAL 19 x 32 x 8
73 1718110 2 BUSHING 19 x 21
75 1724305 1 SHOE, BRAKE
76 1724306 1 ARM, BRAKE
77 1724307 1 SHAFT, BRAKE
78 1724308 1 SPRING, RETURN B
79 1724309 1 BRAKE, ACTUATOR
80 1724310 1 PIN
81 1708690 2 PACKING
82 1724311 2 PIN, SPRING
83 1724312 2 COLLAR, SPLINE
85 1724314 1 FAN

tionItem Qt

Note

Footnotes:

Manual No. 7006472LAWN TRACTOR ELECTRIC CLUTCH

SERIES 0

27

TP 400-5277-IR-TC-N

Transmission SERVICE PARTS - Tuff Torq K-57A

Manual No. 7006472 LAWN TRACTOR ELECTRIC CLUTCH
TP 400-5277-IR-TC-N

28

SERIES 0

Transmission SERVICE PARTS - Tuff Torq K-57A

p

y

Part No Descri

86 1724315 1 LOCKWASHER
87 1724316 1 RING, SNAP
90 1720421 1 PIN 3.0A x 20
91 1724318 1 OIL SEAL
95 1707839 1 PIN, ROLL
97 1724956 2 WASHER, THRUST DIFF
98 1724958 2 PIN, 3.0A x 18

99 1724957 1 SPRING, CHARGE
100 1724953 1 CHARGE PUMP CASE ASSEMBLY
200 1727542 1 K57 SMP SEAL KIT

tionItem Qt

Note

Footnotes:

Manual No. 7006472LAWN TRACTOR ELECTRIC CLUTCH

SERIES 0

29

TP 400-5277-IR-TC-N

Seat & Seat Deck Group

Manual No. 7006472 LAWN TRACTOR ELECTRIC CLUTCH
TP 400-5277-IR-TC-N

30

SERIES 0

Seat & Seat Deck Group

p

y

Part No Descri

1 1722129A 1 BRACKET, 1-5/8 x 1-3/4
2 1725019 1 SEAT, 15” Back
3 1722128A 1 SUPPORT, Seat
4 2172434 1 CLIP, Wire
5 1709256A 2 WASHER, Spring, 5/16 x 1-1/4
6 1714263 2 SPRING, Compression
7 1919438 10 NUT, Hex Lock, ESNA Light, 5/16-18
8 1717051 2 SPRING, Compression

9 1930591 8 CAPSCREW, Hex Flange Whiz Lock, 5/16-18 x 3/4
10 1931339 2 CARRIAGE BOLT, 5/16-18 x 2
11 1931350 2 CARRIAGE BOLT, 3/8-16 x 1
12 1722356 1 SLIDE, Seat
13 1935255 4 NUT, Speed, 5/16-18, Lug Type
14 1930601 4 CAPSCREW, Hex Washer Head Taptite, 5/16-18 x 5/8
15 1722309 2 PLUG, Plastic
16 1722109 1 POD, with Cup Holder, LH
17 2860664 8 CAPSCREW, Hex Washer Head, 1/4-20 x 5/8
18 1931277 4 NUT, Hex Flange Whiz Lock, 5/16-18
19 1715917 1 CAP, Gas
20 1726902 1 TUBE & ELBOW ASSEMBLY
21 1654930 1 BUSHING, 3/8 x 9/16 x 5/8, Rubber
22 1722432 1 TANK, Fuel
23 1960636 8 NUT, Hex KEPS, 5/16-18
24 1722106D 1 DECK, Seat, Red
25 1722108 1 POD, RH with 2 Slots
26 1729322D 1 TUNNEL, Red
27 1960667 8 CAPSCREW, Hex Flange Whiz Lock Dog Point, 5/16-18 x 1
28 1663752 2 SPACER, 25/64 x 5/8 x 3/16, Hardened
29 1930645 2 NUT, Hex Flange Two-Way Lock, 3/8-16
30 1924940 2 WASHER, 3/8

tionItem Qt

Note

Footnotes:

Manual No. 7006472LAWN TRACTOR ELECTRIC CLUTCH

SERIES 0

31

TP 400-5277-IR-TC-N

Engine & Electric Clutch Group - 18HP & 20HP B&S, Vanguard

Manual No. 7006472 LAWN TRACTOR ELECTRIC CLUTCH
TP 400-5277-IR-TC-N

32

SERIES 0

Engine & Electric Clutch Group - 18HP & 20HP B&S, Vanguard

p

y

Part No Descri

1 1723165 1 HOSE, Oil Drain, 10-1/2" Long, 3/8-18 Fittings

2 1 * ENGINE, 18HP Briggs & Stratton Vanguard Twin, Mod. 356777-

0113-E1

2 1 * ENGINE, 20HP Briggs & Stratton Vanguard Twin, Mod. 358777-

0110-E1
3 1722949 1 SEAL, Circle, 18HP & 20HP
4 1722388A 1 BULKHEAD
5 1925003 2 CAPSCREW, Hex Washer Head Taptite, 1/2-20 x 1/2, Black
6 1727223 1 CONTROL, Throttle Double 39" Long w/Knobs
7 1701011 2 TIE, Wire, 7-5/16" Long
8 2860112 2 CLAMP, Hose Type E
9 1718678 1 HOSE, Fuel, 59" Long

10 1722392A 2 SHIELD, Side
11 1929000 8 CAPSCREW, Hex Washer Head Taptite, 1/4-20 x 3/8
12 1722288 1 PULLEY & HUB ASSEMBLY
13 2832747 1 TIE, Self Locking, 3-5/8 Long
14 1708264 1 WASHER, Hex, 7/16, Black
15 1918199 1 LOCKWASHER, 7/16
16 1960649 1 CAPSCREW, Hex Head, 7/16-20 x 3-1/2, 20HP
16 1960648 1 CAPSCREW, Hex Head, 7/16-20 x 2-3/4, 20HP
17 1686883 1 CLUTCH, Electric, 18HP
17 1686880 1 CLUTCH, Electric, 20HP
18 1720463 1 KEY, HI PRO, 1/4 x 2 1/2
19 2830598 4 CAPSCREW, Hex Washer Head Taptite, 3/8-16 x 1-1/2
20 2820427 1 LOCKWASHER, External Tooth, 3/8
21 1722414A 1 SHIELD, Muffler Bottom
22 1960368 8 NUT, Speed, 1/4-20, Lug
23 1960295 4 CAPSCREW, Hex Flange Whiz Lock, 1/4-20 x 5/8
24 1935255 2 NUT, Speed, 5/16-18, Lug, Black
25 1722389A 1 DUCT, Muffler Top
26 2834683 2 CLIP, Wire 1/8
27 1722390A 1 DUCT, Muffler Extension
28 1924856 2 CAPSCREW, Hex Washer Head Taptite, 5/16-18 x 1/2, Black
29 1722625 1 MUFFLER, Briggs & Stratton, Vanguard Twin
30 1 * GASKET, Briggs & Stratton, Vanguard Twin
31 1917356 4 LOCKWASHER, 5/16
32 2860660 4 CAPSCREW, Hex Flange Whiz Lock, 5/16-18 x 7/8

tionItem Qt

Note

Footnotes:

Note* See your local Briggs & Stratton distributor for parts and service.

Manual No. 7006472LAWN TRACTOR ELECTRIC CLUTCH

SERIES 0

33

TP 400-5277-IR-TC-N

Lift Group - Manual Lift

Manual No. 7006472 LAWN TRACTOR ELECTRIC CLUTCH
TP 400-5277-IR-TC-N

34

SERIES 0

Lift Group - Manual Lift

p

y

Part No Descri

1 1722302 1 GRIP, Black Vinyl
2 1722024A 1 ROD, Lift Lever with Flats
3 1930645 1 NUT, Hex Flange Lock, 3/8-16
4 1924940 1 WASHER
5 1722460 2 PIN, Quick
6 2162085 1 SPRING, Compression
7 1723866 1 NUT, Push, 3/8
8 1923341 2 CAPSCREW, Hex Head, 1/4-20 x 3/4
9 1722313 1 PLUG, Lift Cover (Models without Cruise Control)

10 1722284A 1 QUADRANT
11 1920397 2 NUT, Hex Lock ESNA, 1/4-20
12 1923701 1 CAPSCREW, Hex Head, 3/8-16 x 2
13 1919438 4 NUT, ESNA Lock, 5/16-18
14 1960044 1 WASHER, Flat, 5/16 x 1-1/4
15 1722491 1 CAM ASSEMBLY, Lift
16 1704629 1 SPACER
17 1727083A 1 LINK, Lift Upper
18 1722607 1 SCREW, Torx Head, # 8-16 x 1/2
19 1722285 1 COVER, Dash
20 1921977 4 CAPSCREW, Hex Head, 5/16-18 x 1-1/4
21 1721789 1 ROD, Lift

tionItem Qt

Note

Footnotes:

Manual No. 7006472LAWN TRACTOR ELECTRIC CLUTCH

SERIES 0

35

TP 400-5277-IR-TC-N

40" Mower Deck - Housing, Arbors & Blades

Manual No. 7006472 LAWN TRACTOR ELECTRIC CLUTCH
TP 400-5277-IR-TC-N

36

SERIES 0

40" Mower Deck - Housing, Arbors & Blades

p

y

Part No Descri

1 1930584 1 CAPSCREW, Hex Head, 7/16-14 x 2-3/4 G8
2 1933263 1 WASHER, 7/16
3 1656916 3 WASHER, Spring
4 1714419 1 NUT, Hex Flange, 9/16-18
5 1713091 1 PULLEY, Drive 5"
5 1732123 1 PULLEY, Drive 6"
6 1719870 1 HUB
7 1687229 2 SPROCKET & FLANGE ASSEMBLY, w/Screws, 38 Tooth
8 1657969 2 SHIELD, Bearing Upper, Arbor
9 1655729A 2 HOUSING, Arbor Top

10 1707335 2 GASKET, Foam Poly
11 1722396 1 ARBOR SHAFT & BEARINGS ASSEMBLY
12 1703273A 2 HOUSING, Arbor Bottom with Lube Fitting
13 1664847 6 CAPSCREW, Taptite Hex Washer Head, 5/16-18 x 3/4
14 1724601 1 COVER, Arbor, LH
15 1687175 1 HOUSING ASSEMBLY, 40", Red
16 1719624A 1 BLADE, Mower, LH
17 1722258 2 PIN, Blade
18 1677274A 2 ADAPTOR, Arbor
19 1722257 2 WASHER, Spline
20 2827120 2 CAPSCREW, Hex Head, 7/16-14 x 2-1/4 G8
21 1960373 12 CAPSCREW, Taptite Hex Washer Head, 5/16-18 x 1
22 1700230 2 WASHER, Shim
23 1700229 2 SHIELD, Arbor Bearing, Lower
24 1655777 2 ADAPTER, Blade
25 1723453 1 DEFLECTOR, Discharge
26 1719623A 1 BLADE, Mower, RH
27 1931335 1 CARRIAGE BOLT, 5/16-18 x 1
28 1931318 1 CARRIAGE BOLT, 1/4-20 x 7/8
29 1960518 1 NUT, Push
30 1960353 2 WASHER, 1/4
31 1704873 1 CLAMP
33 1920397 1 NUT, Hex 1/4-20, ESNA
34 1719597 1 DOOR, Mulching, Black Plastic
35 1723938 1 SPRING, Torsion
36 1719617 1 ROD, Pivot

tionItem Qt

Note

Footnotes:

Manual No. 7006472LAWN TRACTOR ELECTRIC CLUTCH

SERIES 0

37

TP 400-5277-IR-TC-N

40" Mower Deck - Housing, Arbors & Blades

Manual No. 7006472 LAWN TRACTOR ELECTRIC CLUTCH
TP 400-5277-IR-TC-N

38

SERIES 0

40" Mower Deck - Housing, Arbors & Blades

p

y

Part No Descri

37 1919438 1 NUT, Hex 5/16-18, ESNA
39 1919381 1 WASHER, 5/16
40 1933988 1 NUT, Push
41 1721155 1 COVER ASSEMBLY, Arbor, RH (Includes Ref. Nos. 42 thru 46)
42 1724600 1 COVER, Arbor RH (Only used with 5" Pulley)
42 1732425 1 COVER, Arbor RH (Only used with 6" Pulley
43 1721259A 1 GUARD ASSEMBLY, RH
44 1721132A 1 GUARD, Extension
45 1675044 4 RIVIT, Pop
46 1960096 4 WASHER, 3/16 x 3/4 x 1/16
47 1713675 2 WASHER, Bellville
48 1726825 1 ARBOR SHAFT & BEARING ASSEMBLY
49 1732960 1 SHIM-Cover LH 7GA 40" Mower
50 1732691 1 SHIM-Cover RH 7GA 6.5 LG 40" Mower
51 1732693 1 SHIM-Cover RH 7GA 2.8 LG 40" Mower

tionItem Qt

Note

Footnotes:

Manual No. 7006472LAWN TRACTOR ELECTRIC CLUTCH

SERIES 0

39

TP 400-5277-IR-TC-N

40" Mower Deck - Belt, Idler Arm & Hitch

Manual No. 7006472 LAWN TRACTOR ELECTRIC CLUTCH
TP 400-5277-IR-TC-N

40

SERIES 0

40" Mower Deck - Belt, Idler Arm & Hitch

p

y

Part No Descri

1 1919439 1 NUT, Hex Lock Esna Light, 3/8-16
2 1924940 6 WASHER, 3/8
3 1725408 1 PULLEY, Idler
4 1723391 1 V-BELT, Arbor Drive
5 1722175A 1 BELT GUIDE
6 1960534 2 WASHER, 3/8
7 1724835 1 ARM ASSEMBLY, Idler with Bushings & Fitting, 38 Tooth
8 1931355 1 CARRIAGE BOLT, 3/8-16 x 2
9 1928957 1 CAPSCREW, Hex Head, 3/8-16 x 2-3/4 G8

10 1922755 6 WASHER, 3/8
11 1715435 1 SPRING, Extension, Idler Arm
12 1657242 1 SPACER, Hardened
13 1922130 1 CAPSCREW, Hex Head, 3/8-16 x 2-1/4
14 1723952 1 PULLEY
15 1667812 1 SPACER
16 1928352 4 NUT, Hex Flange Whiz Lock, Large, 3/8-16
17 1921968 2 CAPSCREW, Hex Head, 3/8-16 x 1-3/8
18 2172329 2 SPACER
19 1713578 1 ROD, Mower Hitch
20 2156302 1 SPRING, Extension, Hitch Release
21 1715759 1 ROD, Latch
22 1720044A 1 HITCH, Mower
23 1960519 1 NUT, Push
24 2860681 2 NUT, Hex Toplock Sprial Flange, 3/8-16
25 1721425 1 WASHER & NUT ASSEMBLY, 3/8 x 1-1/2
26 1674671 1 SPRING, Extension
27 1719923 1 ARM, Idler
28 1719221 2 HUB
29 1724802 2 PULLEY, Idler
30 1960315 2 CARRIAGE BOLT, 3/8-16 x 2
31 1930601 1 CAPSCREW, Taptite Hex Washer Head, 5/16-18 x 1/2
32 1666697 1 SPACER
33 1722182A 1 BELT GUIDE
34 1724625 1 BELT, Timing, 38 Tooth

tionItem Qt

Note

Footnotes:

Manual No. 7006472LAWN TRACTOR ELECTRIC CLUTCH

SERIES 0

41

TP 400-5277-IR-TC-N

40" Mower Deck - Height Adjustment & Roller Bar

Manual No. 7006472 LAWN TRACTOR ELECTRIC CLUTCH
TP 400-5277-IR-TC-N

42

SERIES 0

40" Mower Deck - Height Adjustment & Roller Bar

p

y

Part No Descri

1 1722661 1 ROD
2 1924940 8 WASHER, 3/8
3 1922606 1 CAPSCREW, Hex Head, 3/8-16 x 1 3/4
4 1917421 1 NUT, Hex Jam, 3/8-16
5 1960601 1 NUT, Hex Flange, 3/8-16 Black
6 1720704 1 ROD & WASHER ASSEMBLY, Adjust Handle
7 1651820 1 GRIP, Black Vinyl For Rod
8 1721257 1 ROD, Latch
9 1720599 1 LATCH, 5/16 WIRE

10 1920397 1 NUT, Hex Lock Esna Light, 1/4-20
11 1921159 1 CAPSCREW, Hex Head, 1/4-20 x 2 1/4
12 1723409A 1 BRACKET, Adjusting
13 1666697 1 SPACER
14 1960044 5 WASHER, 5/16
15 1921977 2 CAPSCREW, Hex Head, 5/16-18 x 1 1/4
16 1917372 3 NUT, Hex 5/16-18
17 1917356 3 LOCKWASHER, Spring 5/16
18 1720695A 1 HANDLE ASSEMBLY, Lift, 40” Munching
19 1723321 1 SPRING, Compression 3-7/8” Long
20 1960674 1 PUSH NUT, 1/4
21 1713995 1 GRIP, Black Soft for Rod
22 1723124 1 BUTTON, Red
23 1960236 4 SPACER
24 1924366 7 WASHER, 5/8
25 1722036 2 ROLLER
26 1668513 6 ROLLER
27 1717675 2 ROLLER
28 1602946 1 SPACER
29 1723305A 1 SHAFT & BAR ASSEMBLY
30 1723303A 1 SHAFT ASSEMBLY
31 2860643 2 NUT, Hex, 5/16-18
32 1920161 1 NUT, Hex Jam, 5/16-18
33 7028200 1 TRUNNION
34 1724959 1 ROD, Height Adjustment
35 1931352 1 CARRIAGE BOLT, 3/8-16 x 1-1/2
36 1915726 2 NUT, Hex, 5/8-11
37 2118053 1 PIN

tionItem Qt

Note

Footnotes:

Manual No. 7006472LAWN TRACTOR ELECTRIC CLUTCH

SERIES 0

43

TP 400-5277-IR-TC-N

40" Mower Deck - Height Adjustment & Roller Bar

Manual No. 7006472 LAWN TRACTOR ELECTRIC CLUTCH
TP 400-5277-IR-TC-N

44

SERIES 0

40" Mower Deck - Height Adjustment & Roller Bar

p

y

Part No Descri

38 1960074 2 CLIP, Hair Pin
39 1706645A 1 TRUNNION, Rod
40 1720659 2 UPSTOP
41 1931202 4 CAPSCREW, Hex Head Taptite, 5/16-18 x 1-1/4
42 1919381 6 WASHER, 5/16
43 1933988 4 NUT, Push, 5/16
44 1665374A 3 STRAP, Roller Support
45 1720919 1 DECAL, Height of Cut
46 1720931A 1 BRACKET, Height of Cut
47 1930651 1 NUT, Hex Centerlock 3/8-16
48 1935048 1 NUT, Hex Flange Lock, 5/16-18
49 1664847 8 CAPSCREW, Taptite Hex Washer Head, 5/16-18 x 3/4
50 1704082 1 NUT, Hex Adjusting
51 2860681 3 NUT, Toplock Spiral Flange, 3/8-16
52 1704073A 1 BAR
53 1677507 1 SLIDE
54 1924361 1 WASHER, 1/2
55 2172622 1 BOLT, Shoulder, 3/8-16 x 1-11/32
56 1960520 1 NUT, Push 5/8
57 1706644 1 SPACER
58 1918447 1 PIN, Cotter
59 2108512 1 PIVOT, 3/4 Hex
60 1931335 2 CARRIAGE BOLT, 5/16-18 x 1
61 2108241 1 GUIDE ASSEMBLY, Rod

tionItem Qt

Note

Footnotes:

Manual No. 7006472LAWN TRACTOR ELECTRIC CLUTCH

SERIES 0

45

TP 400-5277-IR-TC-N

Decal Group

Manual No. 7006472 LAWN TRACTOR ELECTRIC CLUTCH
TP 400-5277-IR-TC-N

46

SERIES 0

Decal Group

p

y

Part No Descri

1 1731931 2 DECAL, LT300-20HP
2 1725065 1 DECAL, Hood Stripe, Snapper, LH
2 1725066 1 DECAL, Hood Stripe, Snapper, RH
3 1722806 1 DECAL, Ignition Switch Symbols, White/Black
4 1718025 1 DECAL, Automatic Control Traction
5 1734027 1 DECAL, Tunnel Cover, Danger Slopes/Blades
6 1723296 2 DECAL, Protective Sticker
7 1 * DECAL, I.D. Plate
8 1720454 1 DECAL, Touch Up Paint
9 1 * DECAL, Patent

10 1723160 1 DECAL, Transmission Release Valve
11 1731955 1 DECAL, Snapper
12 1 * DECAL, OPEI Certified
13 1720389 2 DECAL, Danger Rotating Blades
14 1722788 1 DECAL, 40", Silver on Black with Stripe

tionItem Qt

Note

Footnotes:

Note* Not a serviceable part.

Manual No. 7006472LAWN TRACTOR ELECTRIC CLUTCH

SERIES 0

47

TP 400-5277-IR-TC-N

Electrical Group

Manual No. 7006472 LAWN TRACTOR ELECTRIC CLUTCH
TP 400-5277-IR-TC-N

48

SERIES 0

Electrical Group

p

y

Part No Descri

1 1721810 1 HEADLIGHT ASSEMBLY, 4 Bulb, (Includes Ref. Nos. 2 & 3)
2 1677371 4 BULB, Headlight, 12.8V
3 1723451 4 SOCKET ASSEMBLY, Headlight, Sealed
4 1722669 1 HARNESS, Headlight
5 1722887 1 SWITCH, PTO Push/Pull Symbols
6 1726556 1 MODULE, RMO (Includes Ref. No. 7)
7 1726557 1 KEY, RMO Module Plastic
8 1925003 2 CAPSCREW, Hex Washer Head Taptite, 1/4-20 x 1/2, Black
9 1665238 1 BREAKER, Circuit, 12 Volt 20 Amps

10 1665237 1 WIRE, 12GA 5-15/16 Long, Red
11 1722611 1 PLUG, Hole, Square
12 1731184 1 HOUR METER, (Includes Ref. Nos. 12)
13 1725524 1 PLUG, Dash
14 1725835 1 CLIP, Hour Meter (Service Only)
15 2820263 2 NUT, Hex, 5/16-24
16 2820426 3 LOCKWASHER, External Tooth, 5/16
17 1722739 1 SOLENOID
18 1686734 1 SWITCH ASSEMBLY, Ignition, 6 Pin, (Includes Ref. Nos. 17, 18,

19, 20 & 21)

19 1717163 1 KEYS, Set of 2
20 1717550 1 COVER, For Ignition Switch, Plastic
21 1717549 1 NUT, Hex Flange, 5/8-32, Ignition Switch
22 1960547 1 LOCKWASHER, Internal Tooth, 5/8, Thin
23 2101025 1 WASHER, Shim
24 1701011 3 TIE, Strap, 7-5/16 Long
25 1716951 1 SWITCH, Headlights , 2 Terminal
26 1713535 1 BOOT, Insulator Cable Terminal, 1-15/16 Long, Red
27 1721830 1 CABLE, #6 x 25" Long, Ring Terminals
28 1603618 1 CABLE, #6 x 8" Long, Ring Terminals
29 1677296 1 BOOT, Insulator Battery Terminal
30 2816622 3 NUT, Hex, 1/4-20
31 2816964 2 LOCKWASHER, 1/4
32 2821319 2 WASHER, 1/4
33 2823341 2 CAPSCREW, Hex Head, 1/4-20 x 3/4
34 1713163 1 CABLE, #6 x 26 Long, Ring Terminal
35 1685215 1 BATTERY, 12 Volt
36 1722009 1 STRAP, Battery, 14 Long, Rubber
37 1929000 2 CAPSCREW, Hex Head Taptite, 1/4-20 x 3/8

tionItem Qt

Note

Footnotes:

Manual No. 7006472LAWN TRACTOR ELECTRIC CLUTCH

SERIES 0

49

TP 400-5277-IR-TC-N

Electrical Group

Manual No. 7006472 LAWN TRACTOR ELECTRIC CLUTCH
TP 400-5277-IR-TC-N

50

SERIES 0

Electrical Group

p

y

Part No Descri

38 1726810A 1 BRACKET, Switch Mount
39 1732004 1 SWITCH, Reverse Pedal
40 1732006 1 SWITCH, Push Button, Foot Pedal
41 1717050 1 SWITCH, Cruise Control, Grey, NO
42 1960536 2 CAPSCREW, Hex Washer Head Plastite, 1/4 x 1/2
43 1716368 1 SWITCH, Seat, Grey, NC
44 1730192 1 HARNESS, Wiring
45 1734025 1 WIRING ASSEMBLY, All Conditions Shutdown (CE/Export)

tionItem Qt

Note

Footnotes:

Manual No. 7006472LAWN TRACTOR ELECTRIC CLUTCH

SERIES 0

51

TP 400-5277-IR-TC-N

Parts Manual fo

r

LAWN TRACTOR ELECTRIC CLUTCH
HYDRO DRIVE RMO & ACS
SERIES 0

IT IS THE POLICY OF BRIGGS & STRATTON CORP TO IMPROVE ITS

PRODUCTS WHENEVER IT IS POSSIBLE AND PRACTICAL TO DO SO.

WE RESERVE THE RIGHT TO MAKE CHANGES OR ADD

IMPROVEMENTS AT ANY TIME WITHOUT INCURRING ANY

OBLIGATION TO MAKE SUCH CHANGES ON PRODUCTS

Briggs & Startton Yard Power Products Group
Copyright © 2007
Milwaukee, WI USA. All Rights Reserved

Briggs & Startton Corporation

Revision IR,

McDonough, GA, 30253 U.S.A.

5/30/2007

Manual No. 7006472

TP 400-5277-IR-TC-N