Snapper GT255400 User Manual
Parts Manual fo
r
)
GARDEN TRACTOR ELECTRIC CLUTCH
HYDRO DRIVE RMO ACS
SERIES 0
MODEL
GT255400 (2690630
Briggs & Startton Yard Power Products Group
Copyright © 2007
Milwaukee, WI USA. All Rights Reserved
Briggs & Startton Corporation
McDonough, GA, 30253 U.S.A.
Revision IR,
5/23/2007
Manual No. 7006470
TP 400-5274-IR-TC-N
s
PAGE GROUP
4
6
8
10
14
18
20
24
32
34
36
40
42
46
50
52
Wheels & Tires Group
Hood, Grille & Dash Group
Steering Group - Power Steering
Frame Group - Power Steering
Controls Group
Cruise Control Group
Transmission Group
Transmission SERVICE PARTS - Tuff Torq K-71E without Diff Lock
Seat & Seat Deck Group
Engine & Electric Clutch Group - 25HP Kohler
Lift Group - Hydraulic Lift with Power Steering
54" Mower Deck - Belt, Idler Arm & Hitch Group
54" Mower Deck - Housing, Arbors & Blades Group
54" Mower Deck - Height Adjustment & Roller Bar Group
Decals Group
Electrical Group
Table Of Content
SERIES 0
Manual No. 7006470GARDEN TRACTOR ELECTRIC CLUTCH
3
TP 400-5274-IR-TC-N
Wheels & Tires Group
Manual No. 7006470 GARDEN TRACTOR ELECTRIC CLUTCH
TP 400-5274-IR-TC-N
4
SERIES 0
Wheels & Tires Group
p
y
Part No Descri
1 1722305 2 WHEEL & TIRE ASSEMBLY, Front, (Includes Ref. Nos. 2, 3, 4 &
5)
2 1727146 2 TIRE, 24 x 12 - 12, Front
3 2157638 2 TUBE, Tire 23 x 10-1/2 - 12, Front
4 1726490 2 WHEEL, 12 x 8-1/2, Front
5 2172353 4 VALVE STEM & CAP ASSEMBLY
6 1722726 4 WASHER, Special, 1 x 2-1/2
7 1919394 6 WASHER
8 2832577 2 RING, Shaft
9 1722676 4 CAP, Hub Grey, 2-23/64
10 2105337 2 KEY, HI PRO, 1/4 x 2
11 2860200 4 WASHER
12 1719172 2 WASHER, Axle Seal
13 1721400 2 PLATE & HUB ASSEMBLY, Rear Wheel w/Studs
14 1722766 2 WHEEL & TIRE ASSEMBLY, Rear 23" (Includes Ref. Nos. 5, 15,
16 & 17)
15 1722830 2 TIRE, 23 x 10-1/2 - 12 Super Turf, Rear
16 2157638 2 TUBE, Tire 23 x 10-1/2 - 12, Rear
17 1722831 2 WHEEL, 7 x 12, Rear
18 2834712 2 RING, Shaft
19 2177725 10 NUT, Hex 7/16-20, For Wheel Bolt
tionItem Qt
Note
Footnotes:
Manual No. 7006470GARDEN TRACTOR ELECTRIC CLUTCH
SERIES 0
5
TP 400-5274-IR-TC-N
Hood, Grille & Dash Group
Manual No. 7006470 GARDEN TRACTOR ELECTRIC CLUTCH
TP 400-5274-IR-TC-N
6
SERIES 0
Hood, Grille & Dash Group
p
y
Part No Descri
1 1728031D 1 HOOD, W/Scoop
4 1721804D 1 PANEL, R.H. Side
5 1721803D 1 PANEL, L.H. Side
6 1721810 1 HEADLIGHT ASSEMBLY (Includes Ref. Nos. 22, 23 & 24)
7 1721802D 1 GRILLE
8 1930641 12 NUT, Hex Flange 1/4-20 Whiz Lock
9 1726827 1 DASHBOARD (Used only on YT & LT models)
10 1726894 1 DASHBOARD, W/Hydraulic Lift Slot (Used only on GT models)
12 1721808A 1 HINGE, Hood L.H.
13 1721809A 1 HINGE, Hood R.H.
14 1723123 1 ROD, Dash Support
15 1933896 1 NUT, Hex Lock 10-24 w/Nylon Insert
16 1960392 1 SCREW, Pan Head Phillips #10-24 x 1
17 1960295 12 SCREW, Hex Whiz Lock Flange 1/4-20 x 5/8
18 1733457A 1 DUCT, Air Inlet
19 1726895 1 DASHBOARD, w/Buzzer Hole (Used only on Barons models)
20 1722285 1 COVER, Dash (Used only on Barons models)
21 1722607 1 SCREW, Pan Head Torx #8-16 x 1/2 Plastite (Used only on Barons models)
22 1677371 4 BULB, Headlight
23 1723451 4 SOCKET ASSEMBLY, Seal
24 1722902 1 REFLECTOR, Headlight
tionItem Qt
Note
Footnotes:
Manual No. 7006470GARDEN TRACTOR ELECTRIC CLUTCH
SERIES 0
7
TP 400-5274-IR-TC-N
Steering Group - Power Steering
Manual No. 7006470 GARDEN TRACTOR ELECTRIC CLUTCH
TP 400-5274-IR-TC-N
8
SERIES 0
Steering Group - Power Steering
p
y
Part No Descri
1 1733363 1 STEERING WHEEL
4 1724685A 1 PLATE, Steering Mounting
5 1960655 2 CARRIAGE BOLT, 5/16-18 x 1-1/4 G5
6 1725294 1 ADAPTER, Tilt
7 1723898 2 SPACER
8 1933988 2 NUT, Push Pal
9 1960636 2 NUT, Hex Keps 5/16-18
10 1733790 1 STEERING UNIT, Tilt
11 1686970 1 BELLOWS, Tilt Steering Unit w/Slot
12 1725024 1 CAP, Steering Wheel
13 1716518 2 DECAL, Power Steering
14 1924366 1 WASHER, 5/8
15 1960576 1 NUT, Hex Lock ESNA Light 5/8-18
tionItem Qt
Note
Footnotes:
Manual No. 7006470GARDEN TRACTOR ELECTRIC CLUTCH
SERIES 0
9
TP 400-5274-IR-TC-N
Frame Group - Power Steering
Manual No. 7006470 GARDEN TRACTOR ELECTRIC CLUTCH
TP 400-5274-IR-TC-N
10
SERIES 0
Frame Group - Power Steering
p
y
Part No Descri
1 1733765A 1 FRAME ASSEMBLY, Front & Rear
2 1733139A 1 TOWER & SUPPORT ASSEMBLY
3 1723528A 1 SUPPORT, Seat Deck
4 1722602A 1 BACKPLATE, Hitch
5 1722212A 1 PLATE, Axle Support
6 1721805A 1 BUMPER, 14GA
7 1732937A 1 AXLE, SPINDLES & BUSHINGS ASSEMBLY
8 1721918A 1 HOOK, "J"
9 1732759A 1 ROD, Tie, Flat Ends
10 1733044A 1 SUPPORT, Steering Unit
11 1721752 1 SPACER, Powdered Metal
12 1611705 2 SPACER
13 1702779 1 JOINT, Ball, 1/2-20 Thread
14 1719725 1 SPACER
15 1919262 1 NUT, Hex Jam, 1/2-20
16 1930645 4 NUT, Hex Flange, 3/8-16 Two-Way Lock
17 1732439 1 CYLINDER, Hydraulic Steering
18 1931350 2 CARRIAGE BOLT, 3/8-16 x 1 G5
19 1704314 3 LUBE FITTING, 1/4 Drive
20 1930650 2 NUT, Hex Flange 7/16-14 Two Way Lock
21 1732208 1 SPACER, Powdered Metal
22 1927531 2 CAPSCREW, Hex Head 7/16-14 x 2 G8
23 2860645 1 CAPSCREW, Hex Head 5/8-11 x 3-1/2 G5
24 1960035 2 WASHER, 5/8
25 1933260 4 SCREW, Hex Whiz Lock Flange 3/8-16 x 3/4
26 1664847 4 SCREW, Hex Washer Head Taptite 5/16-18 x 3/4
27 2860646 1 NUT, Hex Flange 5/8-11 Two Way Lock
28 1923683 4 SCREW, Hex Washer Head Taptite 3/8-16 x 3/4
29 2860668 2 NUT, Hex Flange 1/2-13 Whiz Lock
30 1928352 2 NUT, Hex Flange 3/8-16 Whiz Lock Large
31 1923114 2 CAPSCREW, Hex Head 1/2-13 x 1 G5
32 1921210 2 CAPSCREW, Hex Head 3/8-16 x 1 G5
33 1960086 4 SCREW, Truss Head Torx Drive 5/16-18 x 7/8
34 1724801A 1 PLATE, Axle "U" Form
35 1930591 2 SCREW, Hex Whiz Lock Flange 5/16-18 x 3/4
36 1931277 2 NUT, Hex Flange 5/16-18 Whiz Lock
37 2821133 2 FITTING, Lube 1/4 Drive
tionItem Qt
Note
Footnotes:
Manual No. 7006470GARDEN TRACTOR ELECTRIC CLUTCH
SERIES 0
11
TP 400-5274-IR-TC-N
Frame Group - Power Steering
Manual No. 7006470 GARDEN TRACTOR ELECTRIC CLUTCH
TP 400-5274-IR-TC-N
12
SERIES 0
Frame Group - Power Steering
p
y
Part No Descri
38 1924856 4 SCREW, Hex Washer Head Taptite 5/16-18 x 1/2
39 1733912A 1 SPACER
40 1924366 2 WASHER, 5/8
41 1960713 1 CAPSCREW, Hex Head
42 1960714 1 NUT, Hex Toplock
43 1960339 2 NUT, Hex Flange 3/8-16 Machine Lock
44 1733851 1 AXLE, Front Casting
45 1960355 1 NUT, Hex Lock ESNA Heavy 1/2-13
46 1732939 1 SPINDLE & ARM ASSEMBLY, R.H.
47 1721682 6 BUSHING, Axle
48 1919394 1 WASHER, 1
49 2832577 2 RING, Retaining, Extension
50 1734202 1 SPINDLE & ARM ASSEMBLY, L.H.
tionItem Qt
Note
Footnotes:
Manual No. 7006470GARDEN TRACTOR ELECTRIC CLUTCH
SERIES 0
13
TP 400-5274-IR-TC-N
Controls Group
Manual No. 7006470 GARDEN TRACTOR ELECTRIC CLUTCH
TP 400-5274-IR-TC-N
14
SERIES 0
Controls Group
p
y
Part No Descri
1 1721353 1 ROD, Brake Lock
2 1721891 1 KNOB, Push On, Red Plastic “P”
3 1930591 1 CAPSCREW, Hex Flange Whiz Lock, 5/16-18 x 3/4
4 1919326 2 WASHER, 5/16, Black
5 1721476 1 ROD, Brake
6 1931353 2 CARRIAGE BOLT, 3/8-16 x 1 3/4
7 1663114 2 BUSHING, 5/8 x 3/4 x 3/4, Nylon
8 2821133 1 FITTING, Lube, 1/4
9 1725250 1 SPRING, Extension
10 1722460 3 PIN, Quick
11 1724917 1 ARM & HUB ASSEMBLY, Idler
12 1960020 1 WASHER, 5/8
13 1704420 1 RING, Clipring Extension
14 1721134 1 PULLEY, w/Bearing
15 1924940 1 WASHER, 3/8
16 1960687 2 NUT, Hex Flange ESNA, 3/8-16
17 1721133 1 PULLEY, Idler
18 1723237 2 BUSHING, 1 x 1-1/8 x 5/8, Nylon
19 1722513 1 ARM, Brake
20 1726763 1 PEDAL ASSEMBLY, Foot
21 1931320 1 CARRIAGE BOLT, 1/4-20 x 1-1/4
22 1918447 1 PIN, Cotter, Black
23 1721354A 1 LATCH, Brake
24 1664847 3 CAPSCREW, Hex Washer Head Taptite, 5/16-18 x 3/4
25 1919438 1 NUT, Hex Lock ESNA Light, 5/16-18
26 1919381 1 WASHER, 5/16, Black
27 1927557 2 NUT, Hex Flange Whiz Lock Large, 5/16-18
28 1722535A 1 PEDAL, Brake
29 1721577 1 PAD, Brake Pedal
30 1931334 4 CARRIAGE BOLT, 5/16-18 x 7/8
31 1921333 2 CAPSCREW, 5/16-18 x 1
32 1722083A 1 ACTUATOR, Switch 2.53” Long
33 1923683 1 CAPSCREW, Hex Washer Head Taptite, 3/8-16 x 3/4
34 1722070A 1 PEDAL, Forward
35 1960636 4 NUT, Hex KEPS, 5/16-18
36 1721675 1 PAD, Foot Pedal Forward
37 1722071A 1 PEDAL, Reverse
tionItem Qt
Note
Footnotes:
Manual No. 7006470GARDEN TRACTOR ELECTRIC CLUTCH
SERIES 0
15
TP 400-5274-IR-TC-N
Controls Group
Manual No. 7006470 GARDEN TRACTOR ELECTRIC CLUTCH
TP 400-5274-IR-TC-N
16
SERIES 0
Controls Group
p
y
Part No Descri
38 1721674 1 PAD, Foot Pedal Reverse
39 1920397 1 NUT, Hex Lock ESNA Light, 1/4-20
40 1686612 1 CAM, Roller
41 1721995 1 SPRING, Extension
tionItem Qt
Note
Footnotes:
Manual No. 7006470GARDEN TRACTOR ELECTRIC CLUTCH
SERIES 0
17
TP 400-5274-IR-TC-N
Cruise Control Group
Manual No. 7006470 GARDEN TRACTOR ELECTRIC CLUTCH
TP 400-5274-IR-TC-N
18
SERIES 0
Loading...