Parts Manual fo
r
HYDRO DRIVE ELECTRIC CLUTCH
LAWN TRACTOR
LT-100 SERIES
MODEL
CSLT23460 (7800344)
CSLT24520 (7800345)
LT23460 (7800207)
LT23460 (7800315)
LT24520 (7800212)
LT24520 (7800317)
SLT23460 (7800342)
SLT24520 (7800343)
Briggs & Stratton Yard Power Products Group
535 Macon Road
McDonough, GA, 30253 U.S.A.
800-935-2967
Manual No. 7102341
Revision E, TP 400-5400-E-TC-N6/2/2008
s
PAGE GROUP
4
8
10
14
18
20
22
24
28
32
34
36
38
40
42
Hood / Seat Group
Steering Group
Main Frame Group
Motion Drive Group
Fuel Tank Group
Engine Group
Housing Suspension Group
46" Mower Housing Assembly
46" Mower Deck Group
52" Mower Housing Assembly
52" Deck Blade Drive Assembly
52" Deck Housing Suspension Assembly
Decals
Electrical Group (23 & 24 H.P.)
Wiring Schematic (7101446)
Table Of Content
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
Manual No. 7102341
3
TP 400-5400-E-TC-N
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
TP 400-5400-E-TC-N
4
LT-100 SERIES
Hood / Seat Group
p
y
Part No Descri
1 7091016 4 SCREW, 1/4-20 x 5/8” Hex Washer Self-Tap w/loose captured washer
2 721487 1 BEARING, Steering
3 7101355 1 CONSOLE, Tractor
4 1929477 2 SCREW, #10-24 x 1/2” Hex Washer Head (Taptite) or 1960392
5 1732031 1 HOOD GUIDE, RH
5 1732030 1 HOOD GUIDE, LH (not shown)
7 1933896 2 NUT, #10-24 Hex Nyloc, BZ
8 7090952 4 SCREW, 1/4-20 Thread Cutting
9 7101493 1 CUTTING HEIGHT INDICATOR
10 7101770 1 POD, W/ DETENT
11 7101771 1 POD, W/ COMPARTMENT
12 725181 1 CONTAINER, Battery
13 722858 16 CAPSCREW, 5/16-18 Hex Washer Face
14 722411 2 SPRING, Compression 2.43 Length
15 7300677D 1 SEAT DECK
16 1727294D 1 PANEL, Hood RH Side
17 1727295D 1 PANEL, Hood LH Side
18 1722110D 1 HOOD, w/ Louvers
19 7102326 1 AIR DUCT, Plastic or 1731891
20 1960295 12 SCREW, 1/4-20 x 5/8” Hex Whiz Lock Flange, Black
21 1930641 12 NUT, 1/4-20 Large Hex Flange Lock, Black
22 7102076 1 LINK, Cruise Rod
23 7400261 1 WELDMENT, Latch Arm or 7300820
24 7101894 1 ROD, Pivot Cruise
25 7300805 1 CHANNEL, CRUISE
26 7101891 1 ACTUATOR, CRUISE
27 7102074 1 PULL KNOB, 1/4-20 Thread
28 7300696Z 1 BRACKET, Dash Support, RH
29 7300697Z 1 BRACKET, Dash Support, LH
30 7300810Z 1 BRACKET, Support Cruise
31 7400252Z 1 WELDMENT, Clutch Rod Support
32 7101860 1 SEAT, Hi Back
33 7300875D 1 SUPPORT, Seat
34 720102 2 BOLT, 5/16-18 Shoulder
35 720360 2 CAP, Push On (for .375 dia. Stud)
36 721259 1 ROD, Pivot
37 721214 1 SPRING, Leaf
tionItem Qt
Note
Footnotes:
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
5
TP 400-5400-E-TC-N
Hood / Seat Group
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
TP 400-5400-E-TC-N
6
LT-100 SERIES
Hood / Seat Group
p
y
Part No Descri
38 722851 4 SCREW, 1/4-14 x 3/8” Hex Washer Self-Tap
39 720163 2 WASHER, .34 x .62 x 16 GA Flat
40 721425 2 WING BOLT, 5/16-18 UNC 2A
41 720101 1 BOLT, 1/4-20 x 3.652 2A Shoulder
42 721258 1 WASHER, Cup, 1.50 OD x 0.344 ID
43 727614 1 SPRING, Compression, 4.57 Free Length
44 7300794D 1 BRACKET, Seat Pivot
45 7091298 3 NUT, 5/16-18 Hex Nyloc
46 720146 1 NUT, 1/4-20 Hex Flange Lock
47 7300865Z 1 PLATE, Index
48 720182 12 FASTENER, Panel
49 7101772 1 MAT, Left
50 7101773 1 MAT, Right
51 7300818Z 1 STIFFENER, Steering
52 7300772Z 1 BULKHEAD
53 7300658Z 1 HOOD, Pivot LH
54 7300657Z 1 HOOD, Pivot RH
55 720097 2 BOLT, 3/8-16 Shoulder or 7101657
56 720142 2 NUT, 3/8-16 Hex Flange Lock, NC
57 7101458 1 HARNESS, Headlight, TCT, 1/4 Terminals
58 1727296 1 HEADLIGHT ASSY, (Includes #'s 59, 60, 61, & 62)
59 1728973 1 REFLECTOR, Headlight
60 1728974 1 LENS, Headlight
61 1723451 2 SOCKET, Light
62 1677371 2 BULB, 12.8V (1141)
63 1728059D 1 GRILLE, Snapper
64 7101810 1 INSERT, Light Bar
65 1732007 1 HOLE PLUG, Plastic for 7/8” dia. Hole
66 7102404 1 STRIP, Trim
tionItem Qt
Note
Footnotes:
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
7
TP 400-5400-E-TC-N
Steering Group
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
TP 400-5400-E-TC-N
8
LT-100 SERIES
Steering Group
p
y
Part No Descri
1 729275 1 COVER, Integra
2 727628 1 STEERING WHEEL, (Soft Rim)
3 720973 1 BELLOWS, Steering Post
4 7101525 1 STEERING POST, 24.56 Long
5 722867 2 CAPSCREW, 5/16-18 Hex Washer Face
6 721242 1 BEARING, Lower
7 725138 1 GEAR PINION
8 720119 1 SNAP RING, 0.543 ID
9 722620 2 FLAT WASHER, 1.862 x .765 x 16 GA
10 721318 2 HUB CAP
11 7101563 2 WHEEL & TIRE ASSY, 20 x 10-8 used on 46” Deck (Calif.)
11 7101566 2 WHEEL & TIRE ASSY, 18 x 6.50-8 used on 52” Deck (Domestic 49-
12 720042 1 SCREW, 1/4-20 x 1” Hex Washer Self-Tap
13 722593 1 WASHER, .34 - 1.2 Flat
14 722598 2 WASHER, .76 - 1.2 Flat
tionItem Qt
Note
State & Calif.)
Footnotes:
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
9
TP 400-5400-E-TC-N
Main Frame Group
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
TP 400-5400-E-TC-N
10
LT-100 SERIES
Main Frame Group
p
y
Part No Descri
1 7300869Z 1 RAIL, Frame LH
2 7300870Z 1 RAIL, Frame RH
3 722858 54 CAPSCREW, 5/16-18 Hex Washer Face
4 7091286 5 SCREW, #10-24 x 1/2” Hex Washer Self-Tap SEMS or 729075
5 7300876Z 1 TOP, Rear Plate
6 7300866Z 1 PLATE, Rear
7 7300864Z 1 PLATE, Hitch
8 7300689 1 PLATE, Idler Pulley Hydro Gear
9 7300741Z 1 BRACKET, Battery Support
10 722616 1 WASHER, .406 x 2.25 Plain
11 7300819Z 1 BRACKET, Pivot
12 720099 1 BOLT, 3/8-16 x 1.563 Shoulder
13 7300877Z 1 LINK, Handle Lift
14 7091809 5 PIN, 1/8 x 1-1/4” Cotter, YZ
15 7091619 6 NUT, 3/8-16 Hex Flange Lock, YZ
16 722603 2 WASHER, .391 ID x 1-1/4” OD or 7013866
17 725131 2 SPACER, Lifter Pivot
18 7500525Z 1 WELDMENT, Lifter
19 7300868Z 2 PLATE, Stiffening
20 721221 3 PIN, Threaded Shoulder (3/8-16)
21 7300863Z 1 PLATE, Engine
22 7300817Z 1 BRACKET, Muffler Mounting
23 7300830Z 1 BRACKET, Transaxle LH
24 7091008 2 BOLT, 3/8-16 x 2-1/2” Round Head Short Square Neck
25 7500601Z 1 ASSY, Idler Brkt (Secondary)
26 7300831Z 1 BRACKET, Transaxle RH
27 7400237Z 1 WELDMENT - Brake Lever
28 7092081 4 NUT, 5/16-24 Hex Flange Lock, BZ
29 7300751Z 1 BRACKET, Hanger Rear
30 725130 4 BEARING, SPINDLE
31 7010935 4 WASHER, .77 x 1.13 x .06
32 729160Z 1 GT AXLE, Cast Iron
33 7400232Z 1 WELDMENT, Spindle LH
34 7400231Z 1 WELDMENT, Spindle RH
35 720142 2 NUT, 3/8-16 Hex Flange, NC
36 720166 2 FLAT WASHER, .41 x .82 x 16 GA
37 720192 2 BOLT, 3/8-16 x 1-1/2” Hex, GR 5
tionItem Qt
Note
Footnotes:
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
11
TP 400-5400-E-TC-N
Main Frame Group
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
TP 400-5400-E-TC-N
12
LT-100 SERIES
Main Frame Group
p
y
Part No Descri
38 722580 2 FLAT WASHER, 25/64 ID x 1” OD x 14 GA.
39 7300861Z 1 HANGER, Deck RH
40 7300860Z 1 HANGER, Deck LH
41 7300742Z 1 HANGER, Axle
42 720211 2 BOLT, 5/16-24 x 2-3/4” Hex Head
43 7500524 1 ASSY, Sector Gear (Gear Drive - LT)
44 7090585 5 NUT, 5/16-18 Hex Flange Lock, BZ
45 720103 2 BOLT, 3/8-16 Shoulder
46 7300867Z 1 PLATE, Steering Mount
47 721293 2 SCREW, Guide (5/16-18)
48 721240 1 GEAR, Sector
49 721241 1 BEARING, Sector Gear
50 7027168 1 SCREW, 5/16-18 x 1” Hex Head Cap, GR 5, YZ
51 7101805Z 1 DRAG LINK, LH
52 7101806Z 1 DRAG LINK, RH
53 7091619 2 NUT, 3/8-16 Hex Flange Lock, YZ
54 721095 2 FITTING, Lubrication (1/4-28 Self-Tap)
55 7300796Z 1 BRACKET, Bellcrank
56 720353 2 SCREW, 3/8-16 x 3/4 Hex Washer Self-Tap
57 7300960 1 GUIDE, Hydro Belt
58 720018 1 BOLT, 5/16-18 x 5/8 Hex Head, GR 5
59 7090951 1 NUT, 5/16-18 Hex Flange Center Lock or 720139
60 7091601 4 NUT, 5/16-18 Hex Flange Lock, GR 5
tionItem Qt
Note
Footnotes:
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
13
TP 400-5400-E-TC-N
Motion Drive Group
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
TP 400-5400-E-TC-N
14
LT-100 SERIES
Motion Drive Group
p
y
Part No Descri
1 7101332 1 TRANSAXLE, Hydro Gear #310-0510 used on 23 HP models
1 7101669 1 TRANSAXLE, Hydro Gear #310-0610 used on 24 HP models
2 7101569 2 ASSY, Wheel & Tire, 22 x 9.50-12 (incl. next 3 items) used on 24 HP models
7101568 1 TIRE, 22 x 9.50-12 2 Ply K358
7101567 1 RIM, 12x x7 Int W/3 5 Lg Hub Silver
7012234 1 VALVE STEM, TR 412
3 7101563 2 ASSY, Wheel & Tire, 20 x 10-8 (incl. next 3 items) used on 23 HP models
7101562 1 TIRE, 20 x 10-8 2 Ply K358
7101558 1 RIM, 8 x 7 Broached Hub Wheel Silver
7012234 1 VALVE STEM, TR 412
4 720215 4 BOLT, 5/16-18 x 2-1/2” Hex Head, GR 5
5 727761 1 BOLT, 3/8-16 x 2 Square Neck Carriage
6 722440 1 SPRING, Extension Lift
7 721204 1 STUD, Spring Mounting (5/16-18)
8 725137 1 STUD, Swivel (3/8-16)
9 720145 4 NUT, 5/16-18 Hex Flange Lock, NC or 7091601
10 722620 2 FLAT WASHER, 1.862 x .765 x 16 GA
11 720010 2 E-RING, .750D x .050 T
12 721318 2 HUB CAP
13 720142 1 NUT, 3/8-16 Hex Flange, NC
14 2860694 2 NUT, 1/4-20 Hex Flange Lock (Nyloc) or 722393, 1/4-20 Hex Nyloc Nut
15 7300888Z 1 PLATE, Forward Stop
16 7091495 2 SCREW, 1/4-20 x 3/4 Hex Head Cap, GR 5
17 7900057 3 SCREW, #12-24 x 1/2” Hex Washer Self-Tap
18 7101653 1 FAN, 7.0 (Ten Blade)
19 7035500 1 BELT, Dual Spindle Brake HA Sect.; 85.4 Effective Length
20 720258 2 KEY, 3/16” Square x 2” long - Rear Wheels
21 720139 8 NUT, 5/16-18 Hex Flange Ser YZ
22 720018 4 BOLT, 5/16-18 x 5/8 Hex Head, GR 5 or 7091811
23 7300684Z 1 TORQUE BRACKET, Hydro
24 7300701Z 1 BRACKET, Roll Release
25 7101542 1 LEVER, Roll Release
26 720069 5 HAIR PIN, .092 Dia.
27 7101453 1 ROD, Rear Drive
28 7102053 1 ROD, Pivot Drive
29 7046451 1 SWIVEL, Adjustment (3/8-24)
30 7300682Z 1 BRACKET, Support
tionItem Qt
Note
Footnotes:
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
15
TP 400-5400-E-TC-N
Motion Drive Group
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
TP 400-5400-E-TC-N
16
LT-100 SERIES
Motion Drive Group
p
y
Part No Descri
31 7200130 2 SPACER, Axle
32 722598 4 WASHER, 3/4 I.D. x 1-1/4 Flat
33 7400248Z 1 WELDMENT, Foot Control
34 1721675 1 PAD, Forward Foot
35 720049 3 BOLT, 5/16-18 x 5/8” Square Neck Carriage, GR 5
36 727933 1 SPRING, Extension
37 7101454 1 ROD, Front Drive (3/8-24)
38 7500602Z 1 WELDMENT, Idler Arm
39 722451 1 SPRING, Clutch
40 721419 1 PIVOT BUSHING
41 725178 1 IDLER PULLEY, 3 Dia.
42 725167 1 SPACER, 1/2 to 17mm
43 725177 1 IDLER PULLEY, 2.75 Dia.
44 720148 2 NUT, 3/8-16 Hex Flange, Zinc Plated
45 721420 1 NUT-Tee, (3/8-16)
46 7300934 1 LINK, Clutch
47 720100 1 SHOULDER BOLT, 1/4-20 x 3-3/4”
48 7101801 1 SPRING, Hydro Brake
49 720164 2 WASHER, .390 ID x .75 OD Flat
50 720387 1 PIN, .090 x 3/4 Cotter
51 7300940 1 LATCH - Parking Brake
52 7101489 1 ROD, Clutch Drive (3/8-16)
53 7101455 1 ROD, Parking Brake
54 720870 1 GRIP
55 720257 1 PEDAL, Clutch/Brake
56 7300960 1 GUIDE, Hydro Belt, Black Gloss
tionItem Qt
Note
Footnotes:
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
17
TP 400-5400-E-TC-N
Fuel Tank Group
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
TP 400-5400-E-TC-N
18
LT-100 SERIES
Fuel Tank Group
p
y
Part No Descri
1 7101521 1 FUEL TANK, Tractor w/Cap (Snapper)
2 727333 1 FUEL CAP or 721049
3 7300653Z 1 BRACKET, Tank
4 7091016 2 SCREW, 1/4-20 x 5/8” Hex Washer Self-Tap
5 7091579 2 SCREW, 1/4-20 x 1/2” Hex Washer Self-Tap or 722866
6 721403 2 HOSE CLAMP, Yellow
7 1734981 1 HOSE, Fuel, Low Perm, 1/4” I.D. x 17” long
tionItem Qt
Note
Footnotes:
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
19
TP 400-5400-E-TC-N
Engine Group
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
TP 400-5400-E-TC-N
20
LT-100 SERIES
Engine Group
p
y
Part No Descri
1 -- 1 * ENGINE, 23HP B&S ELS V-Twin (Calif.) Mod. 44L777-0125-G1 used on LT23460 (Calif.) &
1 -- 1 * ENGINE, 23HP B&S ELS V-Twin Mod. 44L777-0125-B1 used on LT23460 (Domestic 49-
1 -- 1 * ENGINE, 24HP B&S ELS V-Twin (Calif.) Mod. 44M777-0130-G1used on CSLT24520 & LT24520
1 -- 1 * ENGINE, 24HP B&S ELS V-Twin Mod. 44M777-0113-B1 used on SLT24520 & LT24520
2 7027972 1 ASSEMBLY, Oil Valve
3 1731214 2 GASKET, Exhaust B&S Reg. (No Chre.)
4 720663 4 SCREW, 5/16-18 x 5/8” Torx Head, YZ
5 7102402 1 EXHAUST TUBE RH
6 7102403 1 EXHAUST TUBE LH
7 1727817 1 THROTTLE ASSY, Dual Lever
8 720045 4 SCREW, 3/8-16 x 1-1/4” Hex Head Self-Tap
9 7101543 1 ADAPTER - Electric PTO
10 1736105 1 CLUTCH, Electric (Ogura GT-EH13) or 7101323
11 7091807 1 WASHER, .468 ID x 1.38 OD x .25 Flat or 722605
12 7091301 1 WASHER, 7/16 Split Lock or 720183, 7/16 (External Lock
13 7102075 1 HHCS, 7/16-20 X 5.00
14 7091000 2 SCREW, 5/16-18 x 7/8” Pan Head Self-Tap, Torx, BP
15 1921332 1 SCREW, 5/16-18 x 3/4” Hex Head Cap
16 7101706 1 ANCHOR PAD, Clutch
17 7090188 1 WASHER, .34 x .69 x .08 Flat
18 7091298 2 NUT, 5/16-18 Hex Nyloc
19 7500533Z 1 ASSY - Heat Shield
20 722871 1 SCREW, 5/16-18 x 1/2” Hex Washer Head
21 722851 4 SCREW, 1/4-14 x 3/8” Hex Washer Self-Tap
22 7300760Z 1 BRACKET - Muffler
23 721180 1 MUFFLER, Twin
24 722866 3 SCREW, 1/4-20 x 5/8” Hex Washer Self-Tap
1736106 1 HARNESS, Jumper Ogura Clutch (not shown) used on LT23460 (Calif.) &
tionItem Qt
Note
CSLT23460
State)
(Calif.)
(Domestic 49-State)
Washer)
LT24520 (Calif.)
Footnotes:
NOTE: * Purchase engine parts from engine manufacturer dealer.
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
21
TP 400-5400-E-TC-N
Housing Suspension Group
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
TP 400-5400-E-TC-N
22
LT-100 SERIES
Housing Suspension Group
p
y
Part No Descri
1 7101769 1 GRIP, Handle
2 725213 1 HANDLE, Lift
3 722579 1 WASHER, .550 ID x 1” OD Flat
4 722509 1 SPRING, Torsion
5 720069 1 HAIR PIN, .092 Dia.
tionItem Qt
Note
Footnotes:
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
23
TP 400-5400-E-TC-N
46" Mower Housing Assembly
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
TP 400-5400-E-TC-N
24
LT-100 SERIES
46" Mower Housing Assembly
p
y
Part No Descri
1 7300671D 1 HOUSING, 46 Mower Deck
2 722397 3 NUT, 9/16-18 Nylock Ring (Pulley)
3A 726069 2 S.S. PULLEY
3B 7101744 2 PULLEY
4 721447 3 ASSY, Jackshaft Housing
5 726958 1 SHAFT, Splined (9/16-18 thread both ends) (per Jackshaft Housing
6 726957 2 BALL BEARING, Jackshaft (per Jackshaft Housing
7 726959 1 HOUSING, Jackshaft (per Jackshaft Housing
8 721095 1 FITTING - Lubrication (1/4-28 Self-Tap) (per Jackshaft Housing
9 720097 2 SHOULDER BOLT, 3/8-16 x 1-1/16”
10 7300862D 2 PLATE, Suspension
11 722511 1 SPRING, Torsion RH
12 720049 19 BOLT, 5/16-18 x 5/8” Round Head Square Neck, GR 5
13 7300823D 1 BRACKET, Right Rear
14 720139 3 NUT, 5/16-18 Hex Flange Lock
15 720142 2 NUT, 3/8-16 Hex Flange Center Lock
16 722485 1 SPRING, Extension
18 720045 15 SCREW, 3/8-16 x 1-1/4” Hex Washer Self-Tap
19 7300801D 1 BRACKET, R.H. Pulley Cover
20 7400226D 1 ASSY, Idler Arm, 46, RH
21 720091 5 BOLT, 3/8-16 Shoulder
22 720989 1 GUIDE, Belt
23 7300798D 1 BRACKET, Brake Mtg 46'
24 7300799D 1 BRACKET, Brake Plate
25 722858 4 SCREW, 5/16-18 Hex Washer Self-Tap
26 720145 6 NUT, 5/16-18 Hex Flange Lock
27 7300806D 1 BRACKET, Left Gage Wheel
28 7300943D 1 BRACKET, L.H. Pulley Cover
29 7300814D 1 BRACKET, Left Lifter
30 722512 1 SPRING, Torsion RH
31 7300811D 1 BRACKET, Hinge
32 721446 2 SPACER, Pulley
33 725179 3 BLADE ADAPTER
34 720658A 3 BLADE 46” Mulching (15.68”)
35 722601 3 WASHER, Belleville 1.0 x .625 x .200
36 722600 3 WASHER, Hardened 1.0 OD x .625ID x .188
37 722382 3 NUT, 9/16-18 Hex Zinc Plate Yellow Chromate
tionItem Qt
Note
Assembly)
Assembly)
Assembly)
Assembly)
Footnotes:
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
25
TP 400-5400-E-TC-N
46" Mower Housing Assembly
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
TP 400-5400-E-TC-N
26
LT-100 SERIES
46" Mower Housing Assembly
p
y
Part No Descri
38 720908 2 GUIDE, Screw (5/16-18 Thread)
39 7300809D 1 BRACKET, Right Gage Wheel
40 7300920D 1 BRACKET, Front Deck
41 720053 1 BOLT, 5/16-18 x 3/4” Short Square Neck
42 720372 1 RETAINER, 5/16-18 Bolt
tionItem Qt
Note
Footnotes:
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
27
TP 400-5400-E-TC-N
46" Mower Deck Group
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
TP 400-5400-E-TC-N
28
LT-100 SERIES
46" Mower Deck Group
p
y
Part No Descri
1 721222 2 KNOB, (5/16-18 thread)
2 720161 2 WASHER, Flat, 1.0 x .328 x 16 GA
3 721250 2 FRICTION PAD
4 721402 2 PIN, Hanger 3/8-16 x 1-1/4”
5 7300749D 2 LINK, Lift
6 722579 3 WASHER, Flat, 1.0OD x 0.550”
7 720069 2 HAIR PIN, .092 Dia.
8 720098 2 SHOULDER BOLT, 3/8-16 x .600 OD x .95 L
9 7300826D 2 BRACKET, Rear Suspension
10 720142 6 NUT, 3/8-16 Hex Flange Lock, NC
11 7300773D 1 COVER, Left Pulley
12 722871 3 SCREW, 5/16-18 x 1/2” Hex Washer Head
13 7300857D 1 COVER, Right Pulley
14 729075 2 SCREW, #10-24 Thread Forming (.340 Min Threads)
15 1727869 1 V-BELT, (83.10” HA) 46 Mower No Logo
16 720404 1 BELT, Secondary (47.10” HA) 46 Mower
17 720148 2 NUT, 3/8-16 Hex Flange, Zinc Plated
18 720920 1 PULLEY, Idler, (4.0 OD, straight edges) R.H. side
19 720091 3 BOLT, 3/8-16 Shoulder
20 7300858A 1 DEFLECTOR, Inside or 720983
21 720982 1 DEFLECTOR, Chute
22 720163 1 WASHER, .34 x .62 x 16 GA Flat
23 720387 1 PIN, .090 x 3/4 Cotter
24 722441 1 SPRING, Extension (15.33 free length) or 722431 (14.11 free length)
25 720360 2 CAP, Push On (for .375 dia. Stud)
26 722504 1 SPRING, Torsion
27 725171 1 PULLEY, Idler, (4.0 OD, flared edges) L.H. side or 725225
28 725167 2 SPACER, 1/2 To 17mm
29 7400227D 1 ASSY, Idler Arm, 46 Deck
30 721017 1 ROD, Deflector
31 720392 2 CLIP, Hair Pin
32 720173 2 WASHER, Flat, .81 x .550 x 16 Ga
33 721118 2 WHEEL, Gage
34 721197 2 BOLT, Axle, 3/8-16 x 3.0
35 721376 2 ROD, Deck Suspension
36 721263 1 ROD, Hanger
37 722858 2 CAPSCREW, 5/16-18 Hex Washer Face
tionItem Qt
Note
Footnotes:
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
29
TP 400-5400-E-TC-N
46" Mower Deck Group
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
TP 400-5400-E-TC-N
30
LT-100 SERIES
46" Mower Deck Group
p
y
Part No Descri
38 7300767D 1 BRACKET, Front Suspension
39 7300871D 1 STIFFENER
40 720390 1 COTTER PIN, 1/8 x 1-1/4”
41 721453 1 ROLLER
tionItem Qt
Note
Footnotes:
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
31
TP 400-5400-E-TC-N
52" Mower Housing Assembly
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
TP 400-5400-E-TC-N
32
LT-100 SERIES
52" Mower Housing Assembly
p
y
Part No Descri
1 7300937D 1 HOUSING, 52” Mower Deck
2 722858 4 CAPSCREW, 5/16-18 Hex Washer Face
3 720049 26 BOLT, 5/16-18 x 5/8” Square Neck Carriage, GR 5
4 720139 20 NUT, 5/16-18 Hex Flange Ser YZ
5 720145 3 NUT, 5/16-18 Hex Flange Lock, NC
6 7300808D 1 BRACKET, Gage Wheel RH Rear
7 720097 2 BOLT, 3/8-16 Shoulder
8 7300862D 2 PLATE, Suspension
9 722511 1 SPRING, Torsion RH
10 722512 1 SPRING, Torsion LH
11 7300815D 1 BRACKET, Lifter RH
12 720142 2 NUT, 3/8-16 Hex Flange Lock, NC
13 7300811D 1 BRACKET, Hinge
14 7300936D 1 BRACE, LH Lifter
15 7300755D 1 BRACKET, Lifter LH
16 7300807D 1 BRACKET, Gage Wheel LH Rear
17 7300746D 2 BRACKET, Gage Wheel 52 Deck
18 7300802D 1 BRACKET, Front Deck
19 7300729D 1 BAFFLE, RH Bottom
20 7300800D 1 BRACKET, Chute Support
21 7300935 1 BAFFLE, RH 52” Deck
22 7300728 1 BAFFLE, 48/52 LH Bottom
tionItem Qt
Note
Footnotes:
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
33
TP 400-5400-E-TC-N
52" Deck Blade Drive Assembly
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
TP 400-5400-E-TC-N
34
LT-100 SERIES
52" Deck Blade Drive Assembly
p
y
Part No Descri
1 721447 3 ASSY, Jackshaft Housing
2 7300943D 1 BRACKET, L.H. Pulley Cover
3 721446 1 SPACER, Pulley (per Jackshaft Housing Assy)
4 726957 2 BALL BEARING, Jackshaft (per Jackshaft Housing Assy)
5 726958 1 SHAFT, Splined (9/16-18 thread both ends) (per Jackshaft Housing Assy)
6 726959 1 HOUSING, Jackshaft (per Jackshaft Housing Assy)
7 721095 1 FITTING - LUBRICATION (1/4-28 self-Tap) (per Jackshaft Housing Assy)
8 720142 1 NUT, 3/8-16 Hex Flange Center Lock
9 725179 3 BLADE ADAPTER
10 721334A 3 BLADE, (17.66”) 52” Deck
11 722600 6 WASHER, Hardened 1.0 OD x .625ID x .188
12 722382 3 NUT, 9/16-18 Hex Zinc Plate Yellow Chromate
13 720192 1 BOLT, 3/8-16 x 1-1/2” Hex, GR 5
14 7090122 1 WASHER, 3/8 Flat SAE
15 721385 1 PULLEY, Backside Idler
16 7300924D 1 ARM, Idler
17 720148 1 NUT, 3/8-16 Hex Flange, Zinc Plated
18 720139 2 NUT, 5/16-18 Hex Flange Ser YZ
19 720049 2 BOLT, 5/16-18 x 5/8” Square Neck Carriage, GR 5
20 7300923D 1 BRACKET, Brake Mounting
21 720093 2 BOLT, 3/8-16 Shoulder
22 7046926 1 BELT, Secondary (50.65 HA)
23 1734048 1 V-BELT, A Wedge (103.10” HA)
24 726069 4 S.S. PULLEY
25 726507 3 LOCKNUT, Pulley (9/16-18) or 722397 (9/16-18 Hex Nyloc
26 7300773D 1 COVER, Left Pulley
27 722871 3 SCREW, 5/16-18 x 1/2” Hex Washer Head
28 722859 2 SCREW, #10-16 Thread Forming
29 7300857D 1 COVER, Right Pulley
30 720045 15 SCREW, 3/8-16 x 1-1/4” Hex Head Self-Tap
31 7300801D 1 BRACKET, Cover
32 7073992 1 SPRING, Extension or 722438
33 7400265D 1 ASSEMBLY, Idler Arm
34 725167 1 SPACER, 1/2 To 17mm
35 720920 1 PULLEY, Backside Idler
tionItem Qt
Note
nut)
Footnotes:
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
35
TP 400-5400-E-TC-N
52" Deck Housing Suspension Assembly
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
TP 400-5400-E-TC-N
36
LT-100 SERIES
52" Deck Housing Suspension Assembly
p
y
Part No Descri
1 721380 2 WINGNUT (5/16-18 thread)
2 720161 2 WASHER, Flat, 1.0 x .328 x 16 GA
3 721402 2 PIN, Hanger 3/8-16 x 1-1/4”
4 7300921D 2 LINK, Lift
5 720142 8 NUT, 3/8-16 Hex Flange Lock, NC
6 720098 2 SHOULDER BOLT, 3/8-16 x .600 OD x .95 L
7 7300826D 2 BRACKET, Rear Suspension
8 721197 4 BOLT, Axle, 3/8-16 x 3”
9 721118 4 WHEEL, Gage
10 722579 6 WASHER, Flat, 1.0OD x 0.550”
11 720392 4 CLIP, Hair Pin
12 720360 2 CAP, Push On (for .375 dia. Stud)
13 721017 1 ROD, Deflector
14 720982 1 DEFLECTOR, Chute
15 721453 1 ROLLER
16 722858 4 SCREW, 5/16-18 Hex Washer Self-Tap
17 7300767D 1 BRACKET, Suspension, Front
18 720390 1 COTTER PIN, 1/8 x 1-1/4”
19 721376 2 ROD, Deck Suspension
20 720069 2 HAIR PIN, .092 Dia.
21 721263 1 ROD, Hanger
22 7300871D 1 STIFFENER
23 720185 4 NUT, 5/16-18 Hex Flange Lock, NC
24 722504 1 SPRING, Torsion
tionItem Qt
Note
Footnotes:
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
37
TP 400-5400-E-TC-N
Decals
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
TP 400-5400-E-TC-N
38
LT-100 SERIES
Decals
p
y
Part No Descri
1 7102191 1 DECAL, Snapper Name Plate, RH
2 7102192 1 DECAL, Snapper Name Plate, LH
3 7102198 1 DECAL, 23 hp
3 7102199 1 DECAL, 24 hp (not shown)
4 7102211 1 DECAL, Snapper Logo, Steering Wheel
5 7102196 1 DECAL, Snapper Logo, Rear
6 7102247 1 DECAL, Snapper Dash Panel Manual PTO
7 7102248 1 DECAL, Snapper Dash Panel
8 7101938 1 DECAL, Height of Cut
9 7102193 1 DECAL, 46 Deck (not shown)
9 7102195 1 DECAL, 52 Deck
10 724026 1 DECAL, Gage Wheel Leveling
11 7101936 1 DECAL, Drive Pedal
12 7101937 1 DECAL, Deck Level
13 7101935 1 DECAL, Roll Release
14 7101664 1 DECAL, No Step
15 7101939 1 DECAL, Belt/Clutch
16 7101663 1 DECAL, Umber
17 7101665 1 DECAL, Danger Do Not Operate w/o Deflector
18 724023 1 DECAL, Deck Level
19 7101940 1 DECAL, Weight Limitation
20 724017 1 DECAL, Gage Wheel Instruction
21 277802 1 LABEL, Emissions, Small Volume Exemption
tionItem Qt
Note
Footnotes:
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
39
TP 400-5400-E-TC-N
Electrical Group (23 & 24 H.P.)
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
TP 400-5400-E-TC-N
40
LT-100 SERIES
Electrical Group (23 & 24 H.P.)
p
y
Part No Descri
1 7101446 1 HARNESS, Wiring, Hydro TCT, Elec PTO
2 721516 1 SWITCH, Limit, NO, Snap-In
3 721249 1 SWITCH, Limit, NO/NC, Snap-In
4 2816622 2 NUT, 1/4-20 NC-2B Hex
5 2816964 2 LOCKWASHER, 1/4”
6 2821319 2 WASHER, 1/4” Flat
7 2823341 2 BOLT, 1/4-20 x 3/4” Hex Head Cap, GR 5 or 720057
8 720588 1 BOOT, Battery, Positive
9 720348 1 CABLE, Battery 8GA 18.00L - Red
10 7060618 1 BATTERY, 12 Volt, 230 CCA (Shipped dry) replaces 7100449
11 720349 1 CABLE, Battery 8GA 12.00L - Black
12 7023354 1 SWITCH, Seat NC
13 1717163 1 KEY, Ignition (set of 2)
14 7100330 1 CAP, Ignition Switch
15 7100329 1 NUT, 5/8-32 E-Start
16 7026343 1 SWITCH, Ignition-Afterfire Solenoid
17 721615 1 SOLENOID, 3 Pole
18 722393 2 NUT, 1/4-20 Hex Nyloc, BZ
19 722851 3 SCREW, 1/4-14 x 3/8” Hex Washer Self-Tap
20 1722887 1 SWITCH, PTO, Yellow, Vertical Symbols
21 1726556 1 SWITCH, Rev Mow Option Module only w/Key (RMO)
22 1726557 1 KEY, (RMO)
729323 1 HARNESS, RR GR (Seat Switch Wire) (not shown)
1727185 1 KEY, (RMO w/Hang Tag) (not shown)
tionItem Qt
Note
Footnotes:
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
41
TP 400-5400-E-TC-N
Wiring Schematic (7101446)
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
TP 400-5400-E-TC-N
42
LT-100 SERIES
Wiring Schematic (7101446)
p
y
Part No Descri
7101446 1 Wiring Schematic for Harness # 7101446
tionItem Qt
Note
Footnotes:
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
43
TP 400-5400-E-TC-N
Parts Manual fo
r
HYDRO DRIVE ELECTRIC CLUTCH
LAWN TRACTOR
LT-100 SERIES
IT IS THE POLICY OF BRIGGS & STRATTON CORP TO IMPROVE ITS
PRODUCTS WHENEVER IT IS POSSIBLE AND PRACTICAL TO DO SO.
WE RESERVE THE RIGHT TO MAKE CHANGES OR ADD
IMPROVEMENTS AT ANY TIME WITHOUT INCURRING ANY
OBLIGATION TO MAKE SUCH CHANGES ON PRODUCTS
Briggs & Stratton Yard Power Products Group
535 Macon Road
McDonough, GA, 30253 U.S.A.
800-935-2967
www.snapper.com
Copyright © 2008
Milwaukee, WI USA. All Rights Reserved
Briggs & Stratton Corporation
Manual No. 7102341
Revision E,
TP 400-5400-E-TC-N
6/2/2008
Loading...