Snapper 84877, 7800650, 7085623, 84875, 7084941 User Manual
...
Parts Manual fo
r
K
5
3
8
3
5
0
7
5
7
5
2
Not for
Reproduction
30" STANDARD DEC
REAR ENGINE RIDER
SERIES 23
DescriptionModel No.
84873 301123BV
8487
7084941 3011523BV
780010
780064
84941 3011523BV
708562
780010
780065
85623 3012523BVE
8487
708562
780069
8562
8488
301123BVE
3011523BV
3011523BV
3012523BVE
3012523BVE
3012523BVE
301323BVE
3013523BVE
3013523BVE
3013523BVE
W301023BVE
Briggs & Stratton Yard Power Products Group
535 Macon Road
McDonough, GA, 30253 U.S.A.
800-935-2967
Manual No. 7006278
Revision: B 4/21/2010
Not for
Reproduction
PAGE GROUP
Not for
Reproduction
4 Wheels - Front & Rear
6 Front End, Steering
8 Main Case & L.H. Fender
10 Left Hand Fender & Bearing
12 Differential & R.H. Fender
14 Yoke Lift Components
16 Primary Chain Case & Smooth Clutch
18 Gear Shifter Assembly
20 Fuel Tank & Seat
22 Engine, Muffler & Drive Disc
24 30" Cutting Deck & Deflector
26 30" Deck Recycling Components
28 Belt, Brake & Interlock
30 Rails, Lift Arms & Cam Lift
32 Blade Stop Pedals
34 Spindle
36 Decals
38 Electrical System (Briggs magneto Ground)
40 Electrical System (10, 11 & 12.5HP Briggs)
42 Electrical System (11 & 11.5HP Briggs Recoil Start)
44 Electrical System (13 & 13.5HP Briggs)
46 Wiring Schematic (10, 11 & 12.5HP Briggs)
48 Wiring Schematic (11 & 11.5HP Briggs Recoil Start)
50 Wiring Schematic (13HP Briggs)
52 Wiring Schematic (13.5HP Briggs)
Table Of Contents
30" STANDARD DECK
SERIES 23
Manual No. 7006278
3
TP 400-5445-B-RE-N
Wheels - Front & Rear
Not for
Reproduction
Manual No. 7006278 30" STANDARD DECK
4
SERIES 23
Wheels - Front & Rear
p
Not for
Reproduction
Part No Descri
1 7058943 2 ASSEMBLY, Front Tire & Rim (11.0”) (Complete) (Includes items 2, 3, 4, 5 & 6)
2 7073563 1 TIRE, 11 x 4.00-4 (Kenda)
3 7017146 1 RIM (For 11.0 x 4.0 x 4 T ire)
4 7011807 2 BALL BEARING, Flange (3/4” I.D.)
5 7012234 1 VALVE STEM, Snap In
6 7014669 1 LUBE Fi tt i n g
7 7031038 2 CAP, Dust
8 7011032 2 SEAL, Felt
9 7010935 8 WASHER, .77 x 1.13 x .06 Flat
10 7011022 2 HUB CAP
11 7091516 2 COTTER PIN, 5/32 x 1”
12 7010821 2 INNER TUBE (For 4.10/3.50 x 4 Tire)
13 7058951 2 ASSEMBLY, Rear Tire & Rim (Includes Items 5, 14 & 15)
14 7073584 1 TIRE, 16 x 6.50-8 (Kenda)
15 7017147 1 RIM, Extra Wide (For 16/7.50 x 8 Tire)
16 7040434 1 HUB, Rear Wheel LH, 3 Hole 3/4" ID
17 7040433 1 HUB, Rear Wheel RH, 3 Hole 1" ID
18 7011035 1 AXLE BOLT, 5/16-24 x 1-5/8” Tapered (Left Hand)
19 7011201 2 NUT, Wheel Bolt 5/16-24 Hex Center Lock
20 7023522 1 CAP, Hub, L. H. (Long Axle)
21 7011013 1 WHEEL BOLT, 5/16-24 x 2” Tapered (Right Hand)
22 7023895 1 CAP, Hub
23 7012332 4 CLAMP, Right Hand (for 2” Hose)
24 7091502 6 BOLT, 1/2-20 x 3/4” Lug, GR 5
25 7031732 1 CAP, Seal RH 1.0” ID x 1.67” OD (8 & 10 HP)
26 7011817 1 SEAL, 1.22” ID x 1.875” OD
tionItem Qty
Footnotes:
SERIES 23
Manual No. 700627830" STANDARD DECK
5
Front End, Steering
Not for
Reproduction
Manual No. 7006278 30" STANDARD DECK
6
SERIES 23
Front End, Steering
p
Not for
Reproduction
Part No Descri
1 7058030 1 ASSEMBLY, Steering Wheel (for 5/8” shaft) Includes item 2
2 7023781 1 LOGO, Steering Wheel
3 7013862 1 ROLL PIN, 1/4 x 1-1/2”
4 7023667 1 FOAM COVER, Steering Shaft
5 7023671 1 COVER, Steering Shaft
6 7090296 1 PIN, 3 /16 x 1” Cotter
7 7090183 2 WASHER, .66 x 1.31 x .09 Flat
8 7046158 1 BUSHING, Nylon
9 7101192 1 CABLE, Brake (29” long)
10 7022449 1 CABLE, Clutch/Brake (54.32” long)
11 7090372 1 NUT, 1/4-20 Hex Center Lock, GR 5 or B
12 7034174 2 CONNECTOR, Cable
13 7091495 1 SCREW , 1/4-20 x 3/4” Hex Head Cap, GR 5
14 7054378 1 WELDMENT, Front Axle, Narrow
15 7074561 1 BOTTLE, Water
16 7074560 1 HOLDER, Bottle (Wire)
17 7090913 2 SCREW, #10-24 x 1/2” Hex Washer Self-Tap (Torx)
18 7011714 1 HAIR PIN 2-1/4”
19 7038243D 1 LATCH, Parking Brake
20 7015444 1 SPRING, Parking Brake Latch
21 7014049 2 FOOT PAD, Short (5.5” x 4.7”)
22 7010776 1 RING, 1/2” External Retaining (Heavy Duty)
23 7047888BM 1 WELDMENT, Clutch/Brake Pedal
24 7011815 1 PAD, Pedal
25 7010694 1 BUSHING, Nylon
26 7046232 1 WELDMENT, Steering Shaft
27 7091515 1 PIN, 3/16 x 1-1/2 ” Cot te r or 7090753
28 7010746 2 RING, 3/4” External Retaining
29 7010935 6 WASHER, .77 x 1.13 x .06 Flat
30 7010986 4 BEARING, Nylon
31 7091516 2 PIN, 5/32 x 1” Cotter or 7090364
32 7090122 4 WASHER, 3/8” Flat or 7091514
33 7013321 4 BUSHING, Tie Rod
34 7041687 1 KING PIN Weldment, Left Hand
35 7041688 1 KING PIN W eldment, Right Hand
36 7091598 2 PIN, 1/8 x 3/4” Cotter or 7090365
37 7013023 1 TIE ROD, Left Hand (7.41” long)
38 7012933 1 TIE RO D, Right Hand (7.41” long)
tionItem Qty
Footnotes:
SERIES 23
Manual No. 700627830" STANDARD DECK
7
Main Case & L.H. Fender
Not for
Reproduction
Manual No. 7006278 30" STANDARD DECK
8
SERIES 23
Main Case & L.H. Fender
p
Not for
Reproduction
Part No Descri
1 7028990 1 COVER, Battery
2 7028989 1 COVER, Switch
3 7073268 1 COVER, Solenoid
4 7074210 1 BRACKET, Belt Adjuster
5 7091198 2 SCRE W, 3/8-16 x 5/8” He x W a s he r Se l f - Tap
6 7090358 1 SCREW, 5/16-24 x 2-1/2” Hex Head Cap, GR 8
7 7031100 1 TUBE CLAMP
8 7010969 2 NUT, 5/ 16-24 F lange Lock (Large)
9 7074650 1 BUSHING, Pivot
10 7053697 1 WELDMENT, Main Case (Standard)
11 7034299 2 WING, Rear
12 7028200 2 SWIVEL, Adjustable
13 7091503 2 HAIR PIN, 3/32 x 1-1/2”
14 7090793 2 SCREW, 5/16-18 x 3/4” Hex Washer Self-Tap
15 7011791 4 RETAINER, 5/16” Bolt
16 7090188 4 WASHER, 34 x .69 x .08 Flat
17 7091315 7 WASHER, .32 x .58 x .08 Split Lock
18 7091297 7 NUT, 5/16-24 Hex, GR 5
19 7090595 2 BOLT, 5/16-18 x 3/4” Hex Flange Lock, GR 5
20 7073735 1 BRACKET, Switch
21 7011018 1 SHIFT LINK, Short (5/16-24 thread)
22 7090981 2 SCREW, #10-32 x 1/4” Hex Washer Self-Tap
23 7037285 1 FENDER, Left Hand (1.628” I. D. Hole)
24 7030798 2 BUMPER, Rear
25 7036367 1 BUMPER (1-Piece)
26 7091506 4 SCREW, 5/16-18 x 1-1/2” Hex Washer Self-Tap
27 7010153 2 CAP, Bumper
28 7090188 2 WASHER, 34 x .69 x .08 Flat
29 7091867 14 SCREW, 5/16-18 x 5/8” Hex Washer Self-Tap
30 7090391 1 WASHER, 5/16” Internal Tooth Lock
31 7012652 2 CLIP, Wire
32 7090206 1 SCREW, 5/16-18 x 3/4” Hex Head Cap, GR 5
33 7091513 4 SCREW, 5/16 -24 x 1-3/4” Hex Head Cap, GR 5
34 7091272 7 FASTENER, 1/4” Ratchet
35 7047189 1 BRACKET, Drive Support
36 7090585 6 NUT, 5/16-18 Hex Flange Lock, GR 5
37 7017653 1 BELT GUIDE
38 7033799 1 CROSS BRACE
39 7023676 1 SHIFT LINK, Long (5/16-24 both ends)
40 7041384 1 WELDMENT, Shift Arm
tionItem Qty
Footnotes:
SERIES 23
Manual No. 700627830" STANDARD DECK
9
Left Hand Fender & Bearing
Not for
Reproduction
Manual No. 7006278 30" STANDARD DECK
10
SERIES 23
Left Hand Fender & Bearing
p
Not for
Reproduction
Part No Descri
1 7012332 2 CLAMP, 2” ID
2 7075115 1 BOOT, Rear Axl e, Thick Flange
3 7011072 1 WASHER, Thrust
4 7011071 1 THRUST WASHER
5 7052827 1 ASSEMBLY, DX Bearing
6 7074182 2 BEARING, 3/4” I.D. DX
7 7074500 1 SEAL, .750 x 1.250 x .250 (Dust/Grease)
8 7075848 1 FITTING, Lube, 45 Degree, 3/16” w/Hex (long shank) or 7013324
9 7011070 1 TIE ROD, (5/16-24 thread- both ends)
10 7037285 1 FENDER, Left Hand (1.628” I. D. Hole)
11 7010969 1 NUT, 5/16-24 Flange Lock (Large)
12 7012271 1 WASHER, Shim or quantity as required
tionItem Qty
Footnotes:
SERIES 23
Manual No. 700627830" STANDARD DECK
11
Differential & R.H. Fender
Not for
Reproduction
Manual No. 7006278 30" STANDARD DECK
12
SERIES 23
Differential & R.H. Fender
p
Not for
Reproduction
Part No Descri
1 7090362 13 S C R E W, 1/4-20 x 5/8” He x W as h e r He a d S elf-Tap
2 7012296 1 BEARING, Axle (R. H. Fender)
3 7010969 1 NUT, 5/ 16-24 F lange Lock (Large)
4 7031079 1 WASHER, Thrust
5 7038067 1 PLATE, Differential
6 7022115 4 SPACER, Pinion
7 7021127 4 GEAR, Differential Pinion (12T 12P)
8 7011072 1 WASHER, Thrust
9 7051584 1 * ASSEMBLY, Drive Hex Tube
10 7010988 1 WASHER, Nylon
11 7200128 1 GEAR, 11 Tooth, 10 Pitch
12 7010941 1 CHAIN, 46 Pitch (#35 Endless)
13 7021129 1 SPROCKET, 34T, 3/8P
14 7010965 1 RING, 1-3/16” External Retaining
15 7021128 1 SPACER, Differential Case
16 7012332 2 CLAMP, 2” ID
17 7075115 1 BOOT, Rear Axle, Thick Flange
18 7011024 1 PLUG, 1/2” Cup Insert
19 7037279 1 CASE, Transmission
20 7028762 1 GASKET, Transmission Case
21 7037280 1 FENDER, Right Hand (1.62” Dia. Hole)
22 7021158 1 GEAR, 63 T ooth 10 Pitch
23 7075479 1 ASSEMBLY, Long Axle (Includes 23T Gear)
24 7074431 1 SPACER, Differential Case
25 7057398 1 ASSEMBLY, Short Axle (Includes 23T Gear)
26 7012333 4 BOLT, 5/16-24 x 1-5/8” Hex Special Lock (Vibresist)
27 7011156 2 5/16” O-RING
28 7011782 2 WASHER, 5/16” Belleville
29 7090395 1 WASHER, 5/16” External Tooth Lock
30 7090188 1 WASHER, 34 x .69 x .08 Flat
31 7011042 1 SCREW, 5/16-24 x 2-5/8” Hex Head Cap
32 7090361 11 SCREW, 5/16-18 x 5/8” Hex Washer Self-Tap
35 7061017 GREASE, “00" Transmission (24 oz. Required)
-- 7060411 1 KIT, Differential (4 Pinion) (Not Shown)
-- 7060662 1 KIT, Differential (8 Pinion w/DX Bearing) (Not Shown)
-- 7060412 1 KIT, Long & Short Axle (Includes items 23, 24 & 25) (Not Shown)
tionItem Qty
Footnotes:
SERIES 23
NOTE: * Assembly includes two bearings inside hex tube (p/n 7015140, not shown) & one nylon washer (p/n 7010988, item
10).
Manual No. 700627830" STANDARD DECK
13
Yoke Lift Components
Not for
Reproduction
Manual No. 7006278 30" STANDARD DECK
14
SERIES 23
Yoke Lift Components
p
Not for
Reproduction
Part No Descri
1 7013885 1 SPRING, Clutch & Brake
2 7014664 1 BOLT, 5/16-18 Shoulder
3 7091198 2 SCRE W, 3/8-16 x 5/8” He x W a s he r Se l f - Tap
4 7090187 1 WASHER, 5/16” S plit Lock
5 7090196 1 NUT, 5/16-18 Hex, GR 5 or B
6 7014663 2 SLIDE HALF
7 7047190 1 BRACKET, Slide
8 7090122 2 WASHER, 3/8” Flat
9 7015464 1 STUD, Clutch Link (3/8-24 thread)
10 7091597 1 PIN, 3/32 x 3/ 4” Cotter
11 7090390 1 WASHER, 3/8” Internal Tooth Lock
12 7090155 1 NUT, 3/8-24 Hex, GR 5 or B
13 7090539 2 SCREW, 1/4-20 x 1/2” Hex Washer Self-Tap
14 7059068 1 ASSEMBLY, Leaf Spring
15 7073733 1 ARM, Yoke
16 7046162 1 LIFT, Yoke
17 7011201 2 NUT, Wheel Bolt 5/16-24 Hex Center Lock
18 7011048 2 BEARING, Yoke
19 7011763 2 FENDE R WASHER, 5/16”
20 7090238 2 SCREW, 5/16-24 x 1” Hex Head Cap, GR 5
21 7033291 1 COLLAR, Yoke
tionItem Qty
Footnotes:
SERIES 23
Manual No. 700627830" STANDARD DECK
15
Primary Chain Case & Smooth Clutch
Not for
Reproduction
Manual No. 7006278 30" STANDARD DECK
16
SERIES 23
Primary Chain Case & Smooth Clutch
p
Not for
Reproduction
Part No Descri
1 7052683 1 ASSEMBLY, Primary Chain Case (Includes the following 16 items)
2 7041136 1 WELDMENT, Prima ry Chain Case Half , Right Hand
3 7028761 1 GASKET, Primary Chain Case
4 7011121 2 WASHER, 5/8” Belleville
5 7010756 2 BEARING, .625 x 1.37 x .435
6 7018963 1 WELDMENT, Sprocket & Shaft
7 7010614 1 KEY, #5 Woodruff
8 7039778 1 PRIMARY CHAIN CASE HALF, Left Hand
9 7010942 2 BEARING, Needle 1.355” ID x 1.6245” OD x .5” Wide
10 7011086 2 THRUST WASHER, Nylon
11 7040355 1 WELDMENT, Hub & Sprocket
12 7010941 1 CHAIN, 46 Pitch (#35 Endless)
13 7090307 10 SCREW, 10-24 x 1/2” Hex Washer Self-Tap
14 7022785 1 ROLLER, 1-3/8 Long
15 7010776 1 RING, 1/2” External Retaining (Heavy Duty)
16 7011024 1 PLUG, 1/2” Cup Insert
17 7091505 1 NUT, 5/8-18 Hex Nyloc
18 7019260 2 O-RING, 1/2 x 5/8”
19 7027981 1 WASHER, Shim .625 x .875
20 7053114 1 ASSEMBLY, Smooth Clutch (non-asbestos) (Includes the following 5 items)
21 7059443 1 HUB, Driven Disc (assembly) replaces 7054243 (voided)
22 7053103 1 DISC, Driven (rubber tire bonded to rim)
23 7014523 1 THRUST WASHER
24 7032331 1 PLATE, Drive Disc
25 7092081 4 NUT, 5/16-24 Hex Flange Lock or 7090480, center lock flange nut
26 7052497 1 ASSEMBLY, Brake Lever (Includes brake pad & rivet)
27 7012313 1 RING, 3/8” External Retaining
28 7090303 1 NUT, 1/4-28 Hex Top Lock
29 7091294 2 WASHER, .28 x .63 x .06 Flat, GR 5
30 7072593 1 SPACER, Brake Arm Pivot (.418/.403 long)
31 7091504 1 SCREW, 1/4-28 x 1” Hex Head Cap, (Wa s her Face) GR 5
32 7072406 1 SPRING, Torsional Brake Return
33 7061017 GREASE, "00" Transmission (Use 2 oz. maximum)
34 7032392 1 TOOL, Smooth Start Clutch (Recommended for Rubber Disc replacement & Drive Disc
adjustment)
tionItem Qty
Footnotes:
SERIES 23
Manual No. 700627830" STANDARD DECK
17
Loading...