Page 1
Installation Instructions
Parts Included Qty
Parts Included Qty
Gerry Can Spare tire
WWW.SMITTYBILT.COM
Part # D-8137, D-8149
Mount Adapter
Inner Tire Adapter (8137-1) 1
Outer tire Adapter (8137-2) 1
Can Support Plate (8137-3) 1
Hardware Pack (8137-HP) 1
3/8” x 3” Bolt 1
3/8” Lock Washer 1
3/8” Nut 1
Rubber End Cap 1
Step 1: Remove spare tire from vehicle.
Step 2: Place carrier adapter bracket over studs and re-install your spare tire. The adapter
bracket will slide through the center of your wheel.(Fig 1)
Step 3: Attach can carrier to outer adapter bracket with ¼” hardware. (Fig 2)
Step 4: Assemble lower adapter plate with 3” bolt and hardware with rubber end cap.
Attach lower plate onto can carrier with ¼’ hardware. (Fig 3)
Step 5: Slide outer adapter bracket into inner bracket that is sticking through the center of
your wheel and attach with 5/16” hardware ( Fig 4)
Step 6: Secure all hardware completely, adjust lower adjustment bolt to be sure there is no
Movement in the can carrier and then secure. (Fig 5)
Please read instructions entirely before installing this product.
5/16” x ¾” Bolt 2
5/16” Flat Washer 4
5/16” Lock Washer 2
5/16” Nut 2
¼” x ¾” Bolt 2
¼” Flat Washer 4
1/4” Lock Washer 2
¼” Nut 2
For Technical Support/Warranty Information please call 310-762-9944
Smittybilt, 400 West Artesia Blvd, Compton, CA 90220
Page 2
Installation Instructions
Gerry Can Spare tire
WWW.SMITTYBILT.COM
Part # D-8137, D-8149
Mount Adapter
For Technical Support/Warranty Information please call 310-762-9944
Smittybilt, 400 West Artesia Blvd, Compton, CA 90220
Page 3
Installation Instructions
Standard
Metric
M6 9 ft. lbs.
1/2” nuts 90 ft. lbs.
M12 75 ft. lbs.
5/8” nuts 175 ft. lbs.
M16 165 ft. lbs.
Gerry Can Spare tire
WWW.SMITTYBILT.COM
Part # D-8137, D-8149
Grade 8 nut torque specifications
5/16” nuts 20 ft. lbs.
Mount Adapter
3/8” nuts 35 ft. lbs.
7/16”nuts 60 ft. lbs.
9/16” nuts 160 ft. lbs.
Limited Warranties
Smittybilt’s products are covered under the following limited warranties only. Note that the duration of the limited
warranty differs according to the material and finish of the product purchased. Subject to the duration and conditions of
the limited warranty stated below, Smittybilt warrants to the original retail purchaser that its products are free from
defects in material and workmanship. All other warranties and representations express or implied, are hereby
disclaimed, including fitness for merchantability and buyer’s intended use or purpose. All parts are sold “AS IS” except
for the limited warranties granted herein. Buyer assumes all risks as to the selection, suitability and performance of all
goods and products selected. This limited warranty does not cover damage or impairment in any part due to misuse,
improper installation, accident or contact with on-road or off-road hazards, product modification, improper or inadequate
cleaning and/or maintenance. Smittybilt is not responsible for items damaged during shipping. This warranty is not
transferable from the original buyer. For the original Buyer to be eligible for the limited warranty coverage, the Buyer
must provide proof of purchase. Smittybilt strongly recommends returning the warranty registration card.
Customer’s remedy hereunder shall be limited only to repair or replacement (at Smittybilt’s option) of any defective
part(s) returned to Smittybilt at customer’s expense. The determination of whether or not a returned part is defective or
subject to coverage under the limited warranties stated herein shall be made at Smittybilt’s sole discretion.
To assure product quality, Smittybilt reserves the right to change product design, material, specification and finishes
without prior notice to customers. This limited warranty gives you specific legal rights and you may also have other
rights, which may vary from state to state. Some states do not allow limitations on how long an implied warranty lasts,
so the above limitations may not apply as to you. Also, some states do not allow the exclusion or limitation of incidental
or consequential damages, so the above limitations or exclusions may not apply to you. Smittybilt reserves the right to
discontinue product lines and substitute products, or provide other remedies than those listed in this limited warranty for
those discontinued products.
Rollover and other types of vehicle accidents may result in serious injury or death to you, your passengers and others
sharing the road. Smittybilt accessories are decorative and are not intended to reduce or avoid injury or damage in the
event of an accident. The weight and location of Smittybilt accessories may affect your vehicles’ handling, stability and
performance, creating an increased risk of accident or rollover. Before installing any accessory, check state laws and
assure that the accessory will not obscure any lights or interfere with proper operation on your vehicle’s safety
equipment. Consult your owner’s manual and the Smittybilt instructions, or additional safety information. Smittybilt
products, nor the warnings contained herein, are not a substitute for your safe driving. Don’t drink and drive, always use
seat belts and don’t drive faster than conditions permit.
M8 23 ft. lbs.
M10 45 ft. lbs.
M14 120 ft. lbs.
Warning
For Technical Support/Warranty Information please call 310-762-9944
Smittybilt, 400 West Artesia Blvd, Compton, CA 90220
Loading...