Smittybilt 900XX User Manual

Included Components:

through

Footman

Warning:

Installation Instructions

Outback Wind Breaker (#900XX)

1987-2006 Jeep Wranglers

1-Wind Breaker
2-Footman Loops
4-Sheet Metal Screws
3-Male Snaps with Captive Screws

1. All Smittybilt Windbreakers are pre-fit at the factory. Please note that in order to provide long term
fit, Smittybilt designs each top to fit very tight on the initial installation. Please make sure it is at
least 70 degrees F. when you first install this top or it will be very difficult to install. If you use a hair
dryer to warm the fabric, the install will be easier.

2. The top may seem wrinkled when first installed; this is caused by the fabric becoming wrinkled
during shipping. The fabric and the wrinkles will relax after a few days installed on the vehicle.

Installation Instructions

1. Place Wind Breaker inside of roll bar with the gray side (underside) facing forward (Figure 1). On the
top and sides of the roll bar, wrap straps with buckles around the roll bar. Bring straps without buckles
around the other side of the bar. Feed the straps through the buckles loosely (Figures 2, 3, & 4).
After all straps are attached to the roll bar, tighten all straps to prevent flapping.

Pass-

Port

Zipper

Loops

Figure 2

Figure 3 Figure 4 Figure 1

NOTE: Steps 2-5 (Optional) secure the bottom of the Wind Breaker for easy use of the Pass-through Port.

2. Center the Footman Loops on the floor below the Wind Breaker’s bottom straps (Figure 1).

3. Use the mounting holes in the Footman Loops as guides to drill 1/8” holes in the floor. Be careful not
to drill into fuel lines, brake wires, or other important connections.

4. Use the sheet metal screws to secure the Footman Loops down to the floor.

5. Feed the bottom straps through the Footman Loops to the buckles on the Wind Breaker; then
tighten.

NOTE: To open the Pass-through Port; unzip, roll it up, wrap the hanging strap under it, and snap to the
male snap on the other side. When the port is closed, the strap can be snapped to itself to quiet it.

!

you inside the vehicle in the event of an accident. Always fasten your seat belt

this top is designed to protect you from the elements only and is not designed to keep

.

For Technical Support/Warranty Information please call 310-762-9944

Smittybilt, 400 West Artesia Blvd, Compton, CA 90220

Installation Instructions

Outback Wind Breaker (#900XX)

1987-2006 Jeep Wranglers

LIMITED WARRANTY

Smittybilt (The Company) warrants to the original purchaser of this product that should the product or any part thereof,
under normal use and conditions, be proven defective in material or workmanship within the warranty period of 1 year from
the date of purchase, such defect(s) will be repaired or replaced (At the Company’s option) without charge for parts or labor.
To obtain repair or replacement within the terms of the warranty, the product is to be delivered with proof of warranty
coverage ( e.g. dated bill of sale, receipt), specification of defect, freight pre-paid with Returns Good Authorization Number
from Smittybilt to place of purchase. Items returned to Smittybilt Automotive without an Returns Authorization Number will
be refused and returned to sender at the senders expense.

This warranty does not apply to any product or part thereof which, in the opinion of the Company, has suffered or been
damaged through altercation, improper installation, mishandling, misuse, neglect accident or acts of nature. THE EXTENT

OF THE COMPANY’S LIABILITY UNDER THIS WARRANTY IS LIMITED TO THE REPAIR OR
REPLACEMENT PROVIDED ABOVE AND, IN NO EVENT, SHALL THE COMPANY’S LIABILITY EXCEED
THE PURCHASE PRICE PAID BY THE PURCHASER FOR THIS PRODUCT.

This warranty is in lieu of all expressed warranties and liabilities. ANY IMPLIED WARRANTIES, INCLUDING ANY

IMPLIED WARRANTY OF MERCHANTABILITY SHALL BE LIMITED TO THE DURATION OF THIS WRITTEN
WARRANTY. ANY ACTION FOR BREACH OF ANY WARRANTY HEREUNDER INCLUDING ANY IMPLIED
WARRANTY OF MERCHANTABILITY MUST BE BROUGHTH WITHIN A PERIOD OF 90 DAYS FROM DATE OF
ORIGINAL PURCHASE.IN NO CASE SHALL THE COMPANY BE LIABLE FOR ANY CONSEQUENTIAL OR
INCIDENTAL DAMAGES FOR BREACH OF THIS OR ANY OTHER WARRANTY, EXPRESSED OR
IMPLIED,WHATSOEVER. No person or representative is authorized to assume for the company any liability other than
expressed herein in connection with the sale of this product. Some states do not allow limitations on how long an implied
warranty lasts or the exclusion or limitation of incidental or consequential damage, therefore above limitations may not apply
to you. This warranty gives the purchaser specific legal rights. The purchaser may have additional rights, which vary from
state to state.

Some states do not allow limitations on how long an implied warranty lasts or the exclusion or limitation of incidental or
consequential damage, therefore above limitations may not apply to you. This warranty gives the purchaser specific legal
rights. The purchaser may have additional rights, which vary from state to state.

For Technical Support/Warranty Information please call 310-762-9944

Smittybilt, 400 West Artesia Blvd, Compton, CA 90220