Smeg PV750SD, PV630S User Manual

Contents

@

1. INSTRUCTIONS FOR USE .............................................................. 30

2. SAFETY PRECAUTIONS ................................................................. 32

3. ENVIRONMENTAL CARE................................................................. 34

4. DESCRIPTION OF THE CONTROLS .............................................. 35

5. USING THE HOB.............................................................................. 36

6. CLEANING AND MAINTENANCE.................................................... 41

7. MOUNTING ONTO FURNITURE ..................................................... 44

8. GAS CONNECTION ......................................................................... 47

9. ADAPTATION TO DIFFERENT TYPES OF GAS ............................ 49

10. ELECTRICAL CONNECTION........................................................... 54

THESE INSTRUCTIONS ARE VALID ONLY FOR THE DESTINATION COUNTRIES
WHOSE IDENTIFYING SYMBOLS ARE INCLUDED ON THE COVER OF THIS
MANUAL.
THIS IS A CLASS 3 BUILT IN HOB.

INSTRUCTIONS FOR THE USER: these contain user advice, the
description of the controls and the correct procedures for cleaning and
maintenance of the appliance.

INSTRUCTIONS FOR THE INSTALLER: these are intended for the qualified
technician who must install the appliance, set it functioning and carry out
an inspection test.

Further information about the products can be found at www.smeg.com

29

General instructions

1. INSTRUCTIONS FOR USE

This manual is an integral part of the appliance. It must be kept in its entirety
and in an accessible place for the whole working life of the appliance. We
recommend reading this manual and all information it contains carefully before
using the appliance. Installation must be carried out by qualified personnel in
accordance with the standards in force. This appliance is intended for domestic
use and conforms to the EC directives currently in force. The appliance has
been built to carry out the following functions: cooking and heating up food; all
other uses are considered unsuitable.
The manufacturer declines all responsibility for uses other than those indicated.

If the appliance is installed on caravans or boats, it must not be used to heat
rooms.

Do not use this appliance for heating rooms.

This appliance is marked according to European directive 2002/96/EC on Waste
Electrical and Electronic Equipment (WEEE).
This directive defines the standards for the collection and recycling of waste
electrical and electronic equipment applicable throughout the European union.

30

Before the appliance is put into operation, all protective films must be removed.

Suitable heat-proof gloves should be worn for all operations.

Do not use metallic sponges or sharp scrapers as they will damage
the surfaces.
Use normal non-abrasive products and a wooden or plastic tool if
necessary. Rinse thoroughly and dry with a soft cloth or a microfibre
cloth.

Do not leave the appliance unattended during cooking operations where fats or
oils could be released. Fats and oils may catch fire.

Always check that the control knobs are in the O (off) position when you finish
using the hob.

General instructions

Never place saucepans with bases which are not perfectly flat and smooth on
the hob.

Never use cookware which extends beyond the external perimeter of the hob.

31

General instructions

2. SAFETY PRECAUTIONS

Consult the installation instructions for safety standards on electrical or gas
appliances and for ventilation functions. In your interests and for your safety the
law requires that the installation and servicing of all electrical and gas
appliances be carried out by qualified personnel in accordance with the
standards in force. Our approved installers guarantee a satisfactory job.
Gas or electrical appliances must always be uninstalled by suitably skilled
people.
Before connecting the appliance to the power grid, check the data on the plate
against the data for the grid itself.
The identification plate, with technical data, serial number and brand name is
clearly visible under the casing.
Do not remove the plate on the casing for any reason.
Before connecting the appliance, make sure that it is set to the type of gas that it
will be supplied with, checking the label applied under the casing.

Before carrying out installation/maintenance work, make sure that the appliance
is disconnected from the power grid.

The plug to be connected to the power supply cable and its socket must be of
the same type and conform to the standards in force. The socket must be
accessible after the appliance has been installed. Never disconnect the plug by
pulling on the cable.

32

If the power supply cable is damaged, contact the technical assistance centre
immediately and they will replace it.

The appliance must be connected to earth in compliance with electrical system
safety standards.

Immediately after installation, carry out a quick test on the appliance following
the instructions provided later in this manual. Should the appliance not function,
disconnect it from the power supply and call the nearest technical assistance
centre.
Never attempt to repair the appliance.

The appliance becomes very hot during use. Take care never to touch the
heating elements.

General instructions

This appliance may be used by children from the age of 8 and by people of
reduced physical and mental ability or lacking in experience and knowledge,
provided they are supervised or instructed on the safe use of the appliance and
if they understand the associated risks.
Do not allow children to play with the appliance.
Do not allow unsupervised children to perform cleaning or maintenance
operations.

Do not let children go near the appliance when it is in operation or play with it at
any time.

Do not insert pointed metal objects (cutlery or utensils) into the slots in the
appliance.

Do not use steam jets for cleaning the appliance.
The steam could reach the electronics, damaging them and causing short­circuits.

Do not modify this appliance.
Never attempt to repair the appliance. All repairs must be carried out by an
authorised technician or at an authorised service centre. The improper use of
tools can cause hazards.

Do not spray any spray products near the household appliance while it is in
operation. Do not use spray products while the appliance is still hot. The gases
contained in spray cans may catch fire.

The manufacturer declines all responsibility for damage to persons or things
caused by non-observance of the above prescriptions or by tampering with any
part of the appliance or by the use of non-original spare parts.

33

Instructions for disposal

3. ENVIRONMENTAL CARE

3.1 Our environmental care

Pursuant to Directives 2002/95/EC, 2002/96/EC and 2003/108/EC relating to
the reduction of the use of hazardous substances in electrical and electronic
appliances, as well as to the disposal of refuse, the crossed out bin symbol on
the appliance indicates that the product, at the end of its working life, must be
collected separately from other refuse. Therefore, the user must consign the
product that has reached the end of its working life to the appropriate selective
collection centres for electrical and electronic refuse, or deliver it back to the
retailer when purchasing an equivalent product, on a one for one basis.
Adequate selective collection for the subsequent forwarding of the
decommissioned product to recycling, treatment and ecologically compatible
disposal contributes to avoiding possible negative effects on the environment
and on health and promotes the recycling of the materials of which the
appliance consists. Illicit disposal of the product by the user will lead to the
application of administrative sanctions.

The product does not contain substances in quantities sufficient to be
considered hazardous to health and the environment, in accordance with
current European directives.

3.2 Your environmental care

34

Our product's packaging is made of non-polluting materials, therefore
compatible with the environment and recyclable. Please help by disposing of the
packaging correctly. You can obtain the addresses of collection, recycling and
disposal centres from your retailer or from the competent local organisations.

Do not discard the packaging or any part of it, or leave it unattended. It
can constitute a suffocation hazard for children, especially the plastic
bags.

Your old appliance also needs to be disposed of correctly.
Important: hand over your appliance to the local agency authorised for the
collection of electrical appliances no longer in use. Correct disposal enables
intelligent recovery of valuable materials.
Before disposing of your appliance it is important to remove doors and leave

shelves in the same position as for use, to ensure that children cannot
accidentally become trapped inside during play. It is also necessary to cut the
connecting cable to the power supply network, removing it along with the plug.

Instructions for the user

4. DESCRIPTION OF THE CONTROLS

4.1 Control zone

All the hob controls are grouped together on the front panel.

CONTROL ZONE

3-burner hob 4-burner hob

5-burner hob

KNOB DESCRIPTION

To light the flame, press the knob and, at the same time, turn it

anti-clockwise to the minimum flame symbol .

To adjust the flame, turn the knob to the zone between the

maximum ( ) and minimum ( ) settings.

To turn off the burner, turn the knob to the position.

ARRANGEMENT OF BURNERS AND DESCRIPTION OF SYMBOLS

Front left
Burner

Rear left
Burner

Front right
Burner

Rear right
Burner

Central
Burner

Central left
Burner

35

Instructions for the user

5. USING THE HOB

Make sure that the fastening plates E,
the burners, the crowns and the pan
stands are assembled correctly.
The notches A of the flame-spreader
crowns must be inserted into the
housings B of the burner. The holes C
in the burner should be slid over the
igniters and thermocouples D on the
hob.

5.1 Positioning the pan stands

The pan stands are provided unassembled on the hob. There are three types of
pan stands you must be familiar with in order to position them correctly.

36

3-burner pan stand Resting pan stand
(3-burner hob only) (4-burner hob only)

Central pan stand Support pan stand

(5-burner hob only) (4 and 5-burner hobs)