Page: 1/9
Safety Data Sheet
acc. to OSHA HCS (29CFR 1910.1200) and WHMIS 2015 Regulations
Printing date: January 09, 2018 Revision: January 09, 2018
1 Identification
·
Product identifier
·
Trade name: Slime Tire Sealant
·
Product code:
10007, 10008, 10009, 10010/60, 10011, 10011/35, 10012, 10016, 10017, 10019, 10020, 10022, 10022-M,
10023, 10024, 10024-M, 10031, 10033, 10040, 10047, 10054, 10088, 10105SL, 10113, 10123, 10124,
10125, 10129, 10136, 10142, 10149, 10163, 10164, 10167, 10178, 50001, 50024, 50036, 50063, 50107,
100027, 400011, 500362, 500472, 70004, CRK0305-IN, SDS-500/02-3A, SDS-500/06-IN, SDS-500/30-IN,
SDSB-1G/02-IN, SDSB-5G, SDSB-5G-IN, SDSB-55G, SDS-TIRE
·
Other means of identification:
Tire Sealant
Slime TPMS Sealant
·
Recommended use and restriction on use
·
Recommended use:
·
Restrictions on use:
·
Details of the supplier of the Safety Data Sheet
·
Manufacturer/Supplier:
ITW Global Tire Repair, Inc.
125 Venture Drive, Suite 210, San Luis Obispo, CA 93401
Tel (805) 489-0490
·
Emergency telephone number:
ChemTel Inc.
(800)255-3924 (North America)
+1 (813)248-0585 (International)
Sealant
No relevant information available.
2 Hazard(s) identification
·
Classification of the substance or mixture
The product is not classified as hazardous according to the Globally Harmonized System (GHS).
·
Label elements
·
GHS label elements
·
Hazard pictograms:
·
Signal word:
·
Hazard statements:
·
Additional information:
·
Other hazards
Not regulated.
Not regulated.
Not regulated.
Not regulated.
Contains natural rubber latex. May produce an allergic reaction.
There are no other hazards not otherwise classified that have been identified.
3 Composition/information on ingredients
·
Chemical characterization: Mixtures
·
Components:
56-81-5 glycerol 20-40%
9004-34-6 cellulose <5%
9006-04-6 natural rubber latex
·
Additional information:
For the listed ingredient(s), the identity and/or exact percentage(s) are being withheld as a trade secret.
Skin Sens. 1B, H317
(Cont'd. on page 2)
<1%
46.0.4
Page: 2/9
Safety Data Sheet
acc. to OSHA HCS (29CFR 1910.1200) and WHMIS 2015 Regulations
Printing date: January 09, 2018 Revision: January 09, 2018
Trade name:
For the wording of the listed Hazard Statements, refer to section 16.
Slime Tire Sealant
4 First-aid measures
·
Description of first aid measures
·
After inhalation:
·
After skin contact:
Immediately remove any clothing soiled by the product.
Do not pull solidified product away from the skin.
Immediately wash with water and soap and rinse thoroughly.
If skin irritation or rash occurs: Get medical advice/attention.
·
After eye contact:
Remove contact lenses if worn.
Rinse opened eye for several minutes under running water. If symptoms persist, consult a doctor.
·
After swallowing:
Rinse out mouth and then drink plenty of water.
Do not induce vomiting; immediately call for medical help.
·
Most important symptoms and effects, both acute and delayed:
Gastric or intestinal disorders
Slight irritant effect on skin and mucous membranes.
Slight irritant effect on eyes.
Allergic reactions
·
Indication of any immediate medical attention and special treatment needed:
Contains natural rubber latex. May produce an allergic reaction.
Treat skin and mucous membrane with antihistamine and corticoid preparations.
Supply fresh air; consult doctor in case of complaints.
(Cont'd. of page 1)
5 Fire-fighting measures
·
Extinguishing media
·
Suitable extinguishing agents:
CO2, extinguishing powder or water spray. Fight larger fires with water spray.
·
For safety reasons unsuitable extinguishing agents:
·
Special hazards arising from the substance or mixture
Formation of toxic gases is possible during heating or in case of fire.
·
Advice for firefighters
·
Protective equipment:
Wear self-contained respiratory protective device.
Wear fully protective suit.
None.
6 Accidental release measures
·
Personal precautions, protective equipment and emergency procedures
Use personal protective equipment as required.
Ensure adequate ventilation.
·
Environmental precautions
·
Methods and material for containment and cleaning up
Allow to solidify. Pick up mechanically.
Avoid release to the environment.
(Cont'd. on page 3)
46.0.4
Page: 3/9
Safety Data Sheet
acc. to OSHA HCS (29CFR 1910.1200) and WHMIS 2015 Regulations
Printing date: January 09, 2018 Revision: January 09, 2018
Trade name:
Send for recovery or disposal in suitable receptacles.
·
Reference to other sections
See Section 7 for information on safe handling.
See Section 8 for information on personal protection equipment.
See Section 13 for disposal information.
Slime Tire Sealant
7 Handling and storage
·
Handling
·
Precautions for safe handling:
Keep out of reach of children.
Open and handle receptacle with care.
Use only in well ventilated areas.
·
Information about protection against explosions and fires:
·
Conditions for safe storage, including any incompatibilities
·
Requirements to be met by storerooms and receptacles:
Avoid storage near extreme heat, ignition sources or open flame.
·
Information about storage in one common storage facility:
·
Further information about storage conditions:
Store in cool, dry conditions in well sealed receptacles.
Protect from frost.
·
Specific end use(s)
No relevant information available.
(Cont'd. of page 2)
No special measures required.
Store away from foodstuffs.
8 Exposure controls/personal protection
·
Control parameters
·
Components with limit values that require monitoring at the workplace:
56-81-5 glycerol
PEL (USA) Long-term value: 15* 5** mg/m³
mist; *total dust **respirable fraction
TLV (USA) TLV withdrawn-insufficient data human occup. exp.
EL (Canada) Long-term value: 10* 3** mg/m³
*mist; **mist, respirable
EV (Canada) Long-term value: 10 mg/m³
LMPE (Mexico) Long-term value: 10 mg/m³
9004-34-6 cellulose
PEL (USA) Long-term value: 15* 5** mg/m³
*total dust **respirable fraction
REL (USA) Long-term value: 10* 5** mg/m³
*total dust **respirable fraction
TLV (USA) Long-term value: 10 mg/m³
EL (Canada) Long-term value: 10* 3** mg/m³
*total dust, **respirable fraction
EV (Canada) Long-term value: 10 mg/m³
(Cont'd. on page 4)
46.0.4
Page: 4/9
Safety Data Sheet
acc. to OSHA HCS (29CFR 1910.1200) and WHMIS 2015 Regulations
Printing date: January 09, 2018 Revision: January 09, 2018
Trade name:
Slime Tire Sealant
paper fibre, total dust
LMPE (Mexico) Long-term value: 10 mg/m³
9006-04-6 natural rubber latex
TLV (USA) Long-term value: 0.0001* mg/m³
Skin; DSEN, RSEN;* inh. fraction
EL (Canada) Long-term value: 0.001 mg/m³
inhalable, Skin; S(D), S(R)
EV (Canada) Long-term value: 0.001 mg/m³
as total proteins, inhalable, Skin
LMPE (Mexico) Long-term value: 0.0001* mg/m³
SEN, PIEL, *fracción inhalable
·
Exposure controls
·
General protective and hygienic measures:
The usual precautionary measures for handling chemicals should be followed.
Wash hands before breaks and at the end of work.
Avoid contact with the eyes and skin.
Avoid breathing mist, vapors, or spray.
·
Engineering controls:
·
Breathing equipment:
Provide adequate ventilation.
Not required under normal conditions of use.
Use suitable respiratory protective device in case of insufficient ventilation.
For spills, respiratory protection may be advisable.
·
Protection of hands:
(Cont'd. of page 3)
Protective gloves
Material: Nitrile
Thickness:≥4 mil
Breakthrough time: 2 hours
·
Eye protection:
Safety glasses
·
Body protection:
·
Limitation and supervision of exposure into the environment
Protective work clothing
No relevant information available.
·
Risk management measures
No relevant information available.
9 Physical and chemical properties
·
Information on basic physical and chemical properties
·
Appearance:
Form:
Color:
Liquid
Green
(Cont'd. on page 5)
46.0.4
Page: 5/9
Safety Data Sheet
acc. to OSHA HCS (29CFR 1910.1200) and WHMIS 2015 Regulations
Printing date: January 09, 2018 Revision: January 09, 2018
Trade name:
·
Odor:
·
Odor threshold:
·
pH-value:
·
Melting point/Melting range:
·
Boiling point/Boiling range:
·
Flash point:
·
Flammability (solid, gaseous):
·
Auto-ignition temperature:
·
Danger of explosion:
·
Explosion limits
Lower:
Upper:
·
Oxidizing properties:
·
Vapor pressure:
·
Density:
Relative density:
Vapor density:
Evaporation rate:
·
Solubility in / Miscibility with
Water:
·
Partition coefficient (n-octanol/water):
·
Viscosity
Dynamic:
Kinematic:
·
Other information
Slime Tire Sealant
(Cont'd. of page 4)
Characteristic
Not determined.
Not determined.
Not determined.
Not determined.
Not determined.
Not applicable.
Not determined.
Product does not present an explosion hazard.
Not determined.
Not determined.
Non-oxidizing.
Not determined.
Not determined.
Not determined.
Not determined.
Fully miscible.
Not determined.
Not determined.
Not determined.
No relevant information available.
10 Stability and reactivity
·
Reactivity:
·
Chemical stability:
·
Thermal decomposition / conditions to be avoided:
No decomposition if used and stored according to specifications.
·
Possibility of hazardous reactions
·
Conditions to avoid
Excessive heat.
Prevent from drying out.
·
Incompatible materials
·
Hazardous decomposition products
No relevant information available.
Reacts with strong acids and oxidizing agents.
No relevant information available.
Carbon monoxide and carbon dioxide
11 Toxicological information
(Cont'd. on page 6)
46.0.4
Page: 6/9
Safety Data Sheet
acc. to OSHA HCS (29CFR 1910.1200) and WHMIS 2015 Regulations
Printing date: January 09, 2018 Revision: January 09, 2018
Trade name:
·
Information on toxicological effects
·
Acute toxicity:
·
LD/LC50 values that are relevant for classification:
·
Primary irritant effect:
·
On the skin:
·
On the eye:
·
Sensitization:
Contains natural rubber latex. May produce an allergic reaction.
Sensitizing effect by skin contact is possible with prolonged exposure.
·
IARC (International Agency for Research on Cancer):
Present in trace quantities.
14808-60-7 quartz 1
·
NTP (National Toxicology Program):
14808-60-7 quartz K
·
OSHA-Ca (Occupational Safety & Health Administration):
None of the ingredients are listed.
·
Probable route(s) of exposure:
Ingestion.
Eye contact.
Skin contact.
·
Germ cell mutagenicity:
·
Carcinogenicity:
·
Reproductive toxicity:
·
STOT-single exposure:
·
STOT-repeated exposure:
·
Aspiration hazard:
Slime Tire Sealant
(Cont'd. of page 5)
Based on available data, the classification criteria are not met.
None.
Slight irritant effect on skin and mucous membranes.
Slight irritant effect on eyes.
Based on available data, the classification criteria are not met.
Based on available data, the classification criteria are not met.
Based on available data, the classification criteria are not met.
Based on available data, the classification criteria are not met.
Based on available data, the classification criteria are not met.
Based on available data, the classification criteria are not met.
12 Ecological information
·
Toxicity
·
Aquatic toxicity
·
Persistence and degradability
·
Bioaccumulative potential:
·
Mobility in soil:
·
Additional ecological information
·
General notes:
·
Results of PBT and vPvB assessment
·
PBT:
Not applicable.
·
vPvB:
·
Other adverse effects
Not applicable.
No relevant information available.
No relevant information available.
No relevant information available.
Avoid release to the environment.
No relevant information available.
13 Disposal considerations
·
Waste treatment methods
·
Recommendation:
No relevant information available.
(Cont'd. on page 7)
46.0.4
Page: 7/9
Safety Data Sheet
acc. to OSHA HCS (29CFR 1910.1200) and WHMIS 2015 Regulations
Printing date: January 09, 2018 Revision: January 09, 2018
Trade name:
The user of this material has the responsibility to dispose of unused material, residues and containers in
compliance with all relevant local, state and federal laws and regulations regarding treatment, storage and
disposal for hazardous and nonhazardous wastes.
·
Uncleaned packagings
·
Recommendation:
·
Recommended cleansing agent:
Slime Tire Sealant
(Cont'd. of page 6)
Disposal must be made according to official regulations.
Water, if necessary with cleansing agents.
14 Transport information
·
UN-Number
·
DOT, ADR, IMDG, IATA
·
UN proper shipping name
·
DOT, ADR, IMDG, IATA
·
Transport hazard class(es)
·
DOT, ADR, IMDG, IATA
·
Class
·
Packing group
·
DOT, ADR, IMDG, IATA
·
Environmental hazards
·
Marine pollutant:
·
Special precautions for user
·
Transport in bulk according to Annex II of
MARPOL73/78 and the IBC Code
Not regulated.
Not regulated.
Not regulated.
Not regulated.
No
Not applicable.
Not applicable.
15 Regulatory information
·
Safety, health and environmental regulations/legislation specific for the substance or
mixture
·
United States (USA)
·
SARA
·
Section 302 (extremely hazardous substances):
None of the ingredients are listed.
·
Section 355 (extremely hazardous substances):
None of the ingredients are listed.
·
Section 313 (Specific toxic chemical listings):
None of the ingredients are listed.
·
TSCA (Toxic Substances Control Act)
All ingredients are listed.
·
Proposition 65 (California)
·
Chemicals known to cause cancer:
46.0.4
(Cont'd. on page 8)
Page: 8/9
Safety Data Sheet
acc. to OSHA HCS (29CFR 1910.1200) and WHMIS 2015 Regulations
Printing date: January 09, 2018 Revision: January 09, 2018
Trade name:
Slime Tire Sealant
(Cont'd. of page 7)
Reference to chemical component(s) listed below are based on unbound respirable particles and are not
generally applicable to product as supplied.
Present in trace quantities.
14808-60-7 quartz
·
Chemicals known to cause reproductive toxicity for females:
None of the ingredients are listed.
·
Chemicals known to cause reproductive toxicity for males:
None of the ingredients are listed.
·
Chemicals known to cause developmental toxicity:
None of the ingredients are listed.
·
EPA (Environmental Protection Agency):
None of the ingredients are listed.
·
IARC (International Agency for Research on Cancer):
Reference to chemical component(s) listed below are based on unbound respirable particles and are not
generally applicable to product as supplied.
Present in trace quantities.
14808-60-7 quartz 1
·
NIOSH-Ca (National Institute for Occupational Safety and Health):
Present in trace quantities.
14808-60-7 quartz
·
Canadian Domestic Substances List (DSL):
All ingredients are listed.
16 Other information
This information is based on our present knowledge. However, this shall not constitute a guarantee for any
specific product features and shall not establish a legally valid contractual relationship.
·
Date of preparation / last revision
·
Abbreviations and acronyms:
ADR: European Agreement concerning the International Carriage of Dangerous Goods by Road
IMDG: International Maritime Code for Dangerous Goods
DOT: US Department of Transportation
IATA: International Air Transport Association
CAS: Chemical Abstracts Service (division of the American Chemical Society)
LC50: Lethal concentration, 50 percent
LD50: Lethal dose, 50 percent
PBT: Persistant, Bio-accumulable, Toxic
vPvB: very Persistent and very Bioaccumulative
NIOSH: National Institute for Occupational Safety and Health
OSHA: Occupational Safety & Health Administration
Skin Sens. 1B: Skin sensitisation – Category 1B
·
Sources
Website, European Chemicals Agency (echa.europa.eu)
Website, US EPA Substance Registry Services (ofmpub.epa.gov/sor internet/registry/substreg/home/
overview/home.do)
Website, Chemical Abstracts Registry, American Chemical Society (www.cas.org)
Patty's Industrial Hygiene, 6th ed., Rose, Vernon, ed. ISBN: 978-0-470-07488-6
Casarett and Doull's Toxicology: The Basic Science of Poisons, 8th Ed., Klaasen, Curtis D., ed., ISBN:
January 09, 2018 / -
(Cont'd. on page 9)
46.0.4
Page: 9/9
Safety Data Sheet
acc. to OSHA HCS (29CFR 1910.1200) and WHMIS 2015 Regulations
Printing date: January 09, 2018 Revision: January 09, 2018
Trade name:
Slime Tire Sealant
978-0-07-176923-5.
Safety Data Sheets, Individual Manufacturers
SDS Prepared by:
ChemTel Inc.
1305 North Florida Avenue
Tampa, Florida USA 33602-2902
Toll Free North America 1-888-255-3924 Intl. +01 813-248-0573
Website: www.chemtelinc.com
(Cont'd. of page 8)
46.0.4
Loading...