Page 1
马杰
SERVICE MANUAL
6M61E CHASSIS
Design and specifications are subject to change without prior notice. (Only Referrence)
Description: SERVICE MANUAL
6M61E
MODEL. Brand Name:
JOB NO.
Engineering Dept:
SIZE:A5
Artwork By:
Checked By: Date:
Approved By: Date:
Date: 2013-8-8
Page 2
CONTENT
CONTENT ------------------------------------------------------------------------2
Technical Specification-------------------------------------------------------3-14
Block Diagram -----------------------------------------------------------------15
List of key parts-----------------------------------------------------------------16
IC BLOCK Diagram--------------------------------------------------------------17-31
MAIN PCB-TOP------------------------------------------------------------------32
MAIN PCB-BOT------------------------------------------------------------------33
Circuit Diagrams-----------------------------------------------------------------34-42
Page 3
Technical Specification
1. Application Area:
This product standard is use for LED 6M61E chassis.
2. Specification:
All the standard are measured under following conditions without other specification.
2.1 Ambient Temperature: 20+/-5
2.2 Relative Humidity: 65+-10％
2.3 Power Supply Voltage: Standard Input Voltage(100～240V AC 50/60HZ)
2.4 Adjust after 20 minutes warm-up.
3. Test and check method:
3.1 Capability: According to nation test standard
3.2 Safety:______________________________standard
3.3 EMC:________________________________standard
℃
Page 4
Ω
％
％
％
％
％
％
Technical Specification
4. Safety and Regulation
NO. Item Min Typ Max Unit Remark
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
11.
12.
13.
14.
15.
16.
17.
18.
19.
Force Stability-Inclineplane Tip Test 10 deg
Force Stability-Level Tip Test 100 N
Isolation Gap AC-AC/AC-DC 3 mm
Isolation Gap 6 mm
W
Power consumtion Max
Power consumtion Standby 1 W
Dielectric Voltage 3 kV
Isolation Resistance 4
Leakage Current 5 mApp
Power cord captivity 40 N
Flammability—Back Cover PAS S
Sharp edge PAS S
UL Compliance NO
FCC Compliance NO
CDRH Radiation Compliance NO
CSA Compliance NO
CEB Compliance NO
CE Compliance
CB Compliance YES
W
W
W
M
Base on different order
5. Video
NO. Item Min Typ Max Unit Remark
1. Linearity Distortion,Verticl 1
2. Linearity Distortion,Horizontal 1
3. Trapezoidal Distortion,Verticl 1
4. Trapezoidal Distortion, Horizontal 1
5. Over scan, Verticl 93 95 97
6. Over scan, Horizontal 93 95 97
7. Brightness Maximum 280
8. Video Noise Limited
Sensitivity(@S/N=30dB) VHF
51 dBuV
Page 5
％
％ THD
Technical Specification
9. Video Noise Limited
Sensitivity(@S/N=30dB) UHF
10. Selectivity -1.5M 35 dB
11. Selectivity +8M 40 dB
12. Tuning Range -0.7 MHz
13. Resolution Horizontal 1366 Lines
14. Resolution Vertical 768 Lines
6. Chroma
NO. Item Min Typ Max Unit Remark
1. White Balance, X axis
2. White Balance,Y axis
3. White Balance,Color Temperature 6500 9800 12500 kdeg 12500(266,276)
4. Color Sensitivity 30 dB
5. Color Burst Lock-in Range +/-300 Hz
6. Color Killer Sensitivity 30 dBuV
54 dBuV
9800(280,290)
6500(313,329)
7. Audio
NO. Item Min Typ Max Unit Remark
1. Audio Noise Limited Sensitivity,VHF-L 25 dBuV
2. Audio Noise Limited Sensitivity,VHF-H 25 dBuV
3. Audio Noise Limited Sensitivity,UHF 28 dBuV
4. Buzz(S/N Ratio) 40 dB
5. Distortion 3
6.
7. Audio ouput,Center 6 W
8. Stereo Separation 21 dB
9. Speaker Impedance 8 ohm
10. Speaker Power rating 8 W
Audio ouput,L/R,at 10
6 W
8. Power
NO. Item Min Typ Max Unit Remark
1. DC Voltage, Audio 12 V
2. DC Voltage, Tuner 3.3 V
Technical Specification
Page 6
％
％
VPP
VPP
pixel
pixel
kHz
Hz
9. External Interface
NO. Item Min Typ Max Unit Remark
1. Video Input Level 1 Vpp 75 ohm
2. Video Input Frequency Response 4.5 MHz
3. Video Input S/N 40 dB
4. Audio Input Level 0.5 Vrms
5. Audio Input Frequency Response 15 kHz
6. Audio Input S/N 40 dB
7. Audio Input Distortion 3
8. Audio Input Dynamic Range 2 V
9. Video output Level 1 Vpp
10. Video ouput Frequency Response 4.2 MHz
11. Video output S/N 50 dB
12. Audio output Level 0.5 Vrms
13. Audio output Frequency Response 80 12000 Hz
14. Audio output S/N 50 dB
15. Audio output Distortion 6
16. Video Input Level,R/G/B 0.7
17. V ideo Input
Level,Component(Y,Pb,Pr)
18. RGB Input Resolution,Vertical 768
19. RGB Input Resolution,Horizontal 1366
20. RGB Input Horizontal Frequency 68
21. RGB Input Frame Rate 60
0.7
10. The Others
NO. Item Min Typ Max Unit Remark
1. Search sensitivity 40 dBuV
2. Clock,real time gain or loss(sec per
day)
3. Software Funcitonality Test YES
4. REMOCON Working
sensitivity,Straight
5. REMOCON Working
sensitivity,T/B/L/R
6. Close caption sensitivity 46 dBuV
7. Teletext sensitivity 46 dBm
8. Resonance of unit(sweep
freq:50~1000)
NO sec
8 m
6 m
NO
Page 7
％
％
％
Technical Specification
11. Customer Menu Setup(as shipped condition)
NO. Item Specification Remark
1. PSM Standard
2. SSM Standard
3. Volum 20
4. Mute off
5. Input Mode RF
6. Customer menu language Traditional Chinese Base on different order
7. AVL off
8. Sleep Timer off
9. Auto sleep off
10. Blue back NO
11. Surround off
12. Caption off
13. Noise Reducer Middle
12. Reliability
NO. Item Min Typ Max Unit Remark
1. ESD 4 kV IEC-1000-4-2
2. EFT/Burst kV IEC-1000-4-4
3. Surge Immunity kV IEC-1000-4-5
4. Voltage Dip Test,10ms
5. Voltage Dip Test,100ms
6. Operation Temperature deg
7. Operation Humidity
8. Storage Temperature deg
9. MTBF(confidence Level:90%) hour
IEC-1000-4-11
IEC-1000-4-11
Page 8
Technical Specification
DTV-Productions Specification
Model # 32”
Country( West Eu./East
Eu./Russia/AP/US/S.A./Japan/…)
Brand ODM/Skyworth
Category (Monitor/TV/Combo/Portable TV…) TV
Panel technology (LCD / PDP) D-LED
Market Position (High/Mid/Access,,,) Class
Cabinet Design (Example: 01,23 series ) 32E36
Product Nb -
Chassis solution MSD6306PUN
Chassis name 6M61E
Chassis PCB Standard Skyworth RGB New Standard
Predecessor (replace) -
MP date requested (ETD) 2013.8
MP date confirmed by supplier (ETD/E TA) -
Status( Pre./Finish ) -
Regional requirement
Homologation
(Gostandard/CE/MPTT/CB/…)
RoHS Yes
Power supply(100-240V AC +/-10%/...) 100-240V AC (-20%,+10%)
Power consumption working / Annual -
Power consumption standby <1W
Power plug(VDE/UL/BS/…) VDE/2pins
Picture display
Screen size : diagonale (inch) 32
Aspect ratio (16/9 // 4/3 // 15/9) 16:9
1st panel supplier : panel suppliers Skyworth
1st panel supplier : panel reference Skyworth
Panel Display Type(MVA/PVA/IPS/…) TFT LCD
1st panel supplier : resolution 32”1366X768
Dynamic contrast ratio >10000:1
Video signal process
Comb Filter (2D/3D) 3D
Noise Reduction (adaptative/3D/…) 3D
West Eu
VDE
Picture improvement
( LTI/CTI,BLE,WLE,...)
LTI/CTI
Page 9
Technical Specification
Color process (Gama correction/Skin
correction /... )
Colour preset (Cool/Neutral/Warm) Cool/Neutral/Warm
Picture control
( Bright/Con./Sharpness/Color/Tint/…)
Picture presets :
Normal/Bright/Soft/Personal
Picture freeze Yes
Multi picture : PIP ( AV )/POPAV NO
Dynamic Backlight Control NO
LED Backlight D-LED
Deinterlacer (No/linerar/motion
adaptive/motioncompensative)
Film mode / reverse 3:2/2:2 pull down Yes / Yes
Full HD support ( 1080P ) Yes
Single scan / Dual scan ( 120HZ ) Single scan
Zoom type : 4/3 format YES
Zoom type : 14/9 Zoom NO
Zoom type : 16/9 Zoom YES
Zoom type : 16/9 Zoom up/down YES
Zoom type : Cinerama YES
Zoom type : 16/9 Format YES
Zoom type : Auto ( by SCART Pin8 and
WSS )
Picture Auto adjustment (PC mode) YES
3D Panel Type(PR / SG) NO
3D Mode NO
3D To 2D (Y/N) NO
2D To 3D (Y/N) NO
Left / Right Swap (For PR Panel) NO
Sound
Sound type ( Mono/AV stereo/Stereo ) stereo
Music Power (Watt)/RMS Power (Watt) 32”:2X6W
Tone control ( Bass&Treble / Graphic
Equalizer )
Special sound effect ( AVL / WIDE /
Pseudo /… )
Suround system ( Dolby / VD / SRS / BBE
/ … )
Normal/Bright/Soft/Personal
Follow main IC
Yes
3D motion adaptive
YES
Bass&Treble
AVL
Built-in Surround
Page 10
～
Technical Specification
Sound control ( Volume , Balance , Mute ) Volume, Balance, Mute
Sound presets
(Personal/Music/Film/News/Standard)
Headphone volume control ( Separated /
linked )
Sound quality ( High / Mid / Low )
Reception and Decoding capability
RF rangeATV
RF rangeDTV VHF 177-213 MHZ, UHF 473-803 MHZ
Color System (PAL/SECAM/NTSC/PAL
M,N )
Audio Standard ( B/G/H/D/K/K'/I/L/L' ) PAL/SECAM/NTSC DK/I/BG/M
Stereo audio system ( Nicam,MTS,A2,….) Nicam ,A2
Video standard NTSC 3.58 / 4.43 (AV)/PAL
60
DTV SD support (DVB-T/S/C , ATSC ,
QAM , … )
DTV HD Support MPEG2,MPEG4,H.264
MHEG5 NO
HD capability with YPbPr Yes (720p; 1080i; 1080p@24/50/60Hz;
PC capability (up to maximum format) 32”:1366X768Hz 60Hz
HDMI capability AV/PC Format) Up to 1080P 24/50/60HZ
Compatible video format if DVD/USB:
DviX/VCD/SVCD/JPEG/AVI/MPEG2/WMV-
HD/SD
Compatible audio format if
DVD/USB:MP3/WMA/AAC/MPEG1/…
Playable Discs
(CD/CD-R(RW)/CD-ROM/DVD+R/+RW/-R/-RW)
Card reader format compatibility NO
Macrovision Yes
PVR Yes
Network NO
User convenience
OSD Language* English/TBD
OSD Positioning No
OSD Transparency Adjust No
OSD Timeout Adjust No
Customer Brand name(LOGO) Yes
Personal/Music/Film/News/Standard
Yes(Linked)
45MHz
PAL/SECAM/NTSC DK/I/BG/M
NTSC 3.58/4.43 , PAL
480i/p; 576i/p)
JPEG/MPEG2/MPEG4/H.264/DivX
(depending on license)
MP3/WMA(depending on license)
866MHz
DVB-T
NO
Page 11
Technical Specification
IB languages English
ATV Program Numbers (example: 99+3AV
input )
DTV Program Numbers 200
Program edit ( naming , sorting , skip ,
swap …. )
Auto Naming/Auto Sorting No
TV Guide(DTV EPG) EPG(next Seven-day)
Favorite program Yes
Number of buttons on cabinet (Power;
Vol+/-; Pr+/-,Menu )
Main switch button (yes/No) No
CCD(Closed Caption)/V-CHIP No /No
Text Standard: (Top, FLOF,,,) No
Teletext Level: 2.5 / 1.5 Yes
Pages for teletext Yes
Teletext character sets **** Yes
DVB-T teletext Ye s
Real clock From DTV
Sleep timer 10-240 Min
Timer Turn On / Off, Program Switch
Parent Control -Source and Channel lock
(Input code forcertain channel)
Parent Control - Child lock (set the lock of
the keyboard,only the RCU can control the TV)
Parent Control - Kid pass (preset the
ontime, channel foreach day of the week)
Parent Control - Channel lock (For digital
transmissionand DVD program, to filter some
programms)
Calendar / Games No
No program auto switch off Yes
Hotel mode (Y/N) Yes
DVD player (No/slot/tray) No
Tuner FM (yes/No) No
software download(RS232/CI/USB/OAD) USB
Factory reset Yes(in factory menu,reset the setting to
Screen saver Yes
Vol+/-; Pr+/-, Menu ,Source,Power
Naming / Skip / Swap
shipment state )
100+7AV
Yes
Yes
No
Yes
Page 12
Technical Specification
Blue Back Yes
LED indicator(Power on/Standby) Blue / Red
Connectors -Rear
RF Input (Antenna): Air/ Cable/ 2in1 Antenna
Scart : CVBS in&out / RGB / S-VIDEO No
CINCH video in / outAV1 1/ 0
CINCH audio in / out (No volumpe control
on Audioout/can be jack 3,5mm)
S-video in No
Component Video Input (YCrCb/YPrPb) 1
Component Audio Input (YCrCb/YPrPb) 1
VGA in / Audio L/R in / Jack audio in
3.5mm
HDMI 2
DVI No
Audio input for DVI No
CINCH subwoofer out / Coaxial out
(S/PDIF)
Headphone output connector (mm) 1
RS232 ( Y/N , VGA or DB9 port …) No
Card Readers No
USB slot (No/1.1/2 .0) 2
DVB-CI (common interface) No
External power converter input No
Connectors -Side
HDMI 1
AV-IN 1
AV-OUT NO
Component Video Input (YCrCb/YPrPb) 1
Component Audio Input (YCrCb/YPrPb) 1
Headphone output connector (dia.mm) 1
CINCH subwoofer out / Coaxial out
(S/PDIF)
USB slot (No/1.1/2) 1
DVB-CI (common interface) NO
DLNA NO
RF Input (Antenna): Air/ Cable/ 2in1 Antenna
VGA in / Audio L/R in / Jack audio in
3.5mm
VGA + dia. 3.5mm for audio
VGA + dia. 3.5mm for audio in
1/1
No
NO
Page 13
Technical Specification
UI/RC
UI design (font/pixel, 2D/3D graphic
engine..)
RC Model Commend RCU
RC system RGB Standard
RC # of keys
Accessories included
Carton
IB
Circuit diagram No
Batteries No
Product registration Card Yes (Traditional Chinese)
AC Cable Length 1.8m
Audio Cord (Jack 3.5mm) No
VGA Cord No
Wallmount frame Optional
Antenna Cable No
6 in 1( YPbPr & CVBS) cable adapter No
3D Glasses YES(If have 3D mode)
General Data
Size (W x H x D, with stand) in mm
Size (W x H x D, without stand) in mm
Package Size (W x H x D, without stand)
in mm
Net Weight in kg
Gross Weight in Kg
Design / Mechanical
Wallmount VESA compatible (standard
reference)
Adaptor for VESA wallmount
compatibility
Desktop Stand (included/optionnal +
ref/No)
Panel Tilt (Fowards/Backwards/Rotation) No
Swivel function desktop stand (yes/No) +
motorized?
Docking station (yes/No) No
Floor Stand (included/optionnal + ref/No) No
Glass shield (yes/No) No
Finish on Front -
SOD Standard
Traditional Chinese
Traditional Chinese
Yes
Yes
included
No
Page 14
Technical Specification
Finish on side -
Finish on back -
Finish on stand -
number of colors on carton box
Brand logo Customer Inlet
Other logo No
External AC/DC Power with DC power
cord (yes/No)
Handle (yes/No) No
Detachable speaker (yes/No) No
Rating Label langages English
No
Page 15
机型 备注
NO 名称 位号 生产厂家 厂家型号 规格 P/N (参考)
1 接收头
2 扬声器 SPEAKER 中山声力 SL411-01F 5631-108104-0180
3 晶振 Y1/ Y 2 陕西壹加壹 HC-49U/S 4900-124053-R000
4 高频头 U10 Silicon lab SI2157 471J-SI2150-0280
所有
5
IC
IR1 海格科技 SDR138 5300-147438-0S00
U6 芯智 MSD6306PUN 475C-M63061-1280
U7 CFEON EN25Q32B 471R-N25323-0080
U1 唯隆 AOZ3015PI 4786-A30151-0080
U12 新晔电子 TPA3113
U13 帕太 BH3544F-E2
U5/U11 A1 半导体 AS1117L-3 . 3/ T R -HF
U4 A1 半导体 AS1117L-3 . 3/ ADJ
U3 亿思达国际 MP1470GJ-Z 476A-M14700-0060
4722-T31130-0280
4740-B35440-0080
47B6-A11170-03
47B6-A11174-0300
认证标
记
QA1 沛裕电子 AP2181DWG-7 47C5-A21810-0050
Page 16
IC Block Diagram
1. AOZ3015PI
Page 17
Page 18
2. ME9435A
Page 19
3. ME4953
Page 20
4. MSD6306PUN
SPI FLASH
32M bit
HDMI input
YUV input
VGA input
CVBS input
音频 input
USB input
HDMI1
YUV
VGA
CVBS1
L/R1
L/R2
USB
MSD6306PUN
CONNECTOR LVDS CONNECTOR
L/R
IF RF
L/R
CVBS
AMP TDA3113
TUNER
EAR OUTPUT
Page 21
5. EN25Q64-104HIP
Page 22
Page 23
Page 24
PVCC
PVCC
GAIN1
6
AVCC
7
8
AGND
9
GVDD
OUTNL
BSNL
BSNR
OUTNR
23
22
21
20
TPA3113D2
FAULT
2
LINP
3
4
LINN
5
GAIN0
PVCCL
BSPL
OUTPL
PGND
27
26
25
24
PLIMIT
10
RINN
11
12
RINP
13
NC
PGND
OUTPR
BSPR
PVCCR
19
18
17
16
PBTL
14
PVCCR
15
GND
29
PowerPAD
SD
1
PVCCL
28
PVCC
100 μF 0.1 μF
1000 pF
100 μF
0.1 μF
1000 pF
Audio
Source
Control
System
100 kΩ
10 Ω
1 kΩ
FB
FB
0.22 μF
1000 pF
0.22 μF
1000 pF
1 Fm
1 Fm
0.22 μF
FB
FB
1000 pF
1000 pF
0.22 μF
10 kΩ
10 kΩ
1 Fm
1 Fm
1 Fm
1 Fm
1 Fm
TPA3113D2
SLOS650B–AUGUST 2009 –REVISED SEPTEMBER 2009 ...........................................................................................................................................
APPLICATION INFORMATION
www.ti.com
Figure 33. Stereo Class-D Amplifier with BTL Output and Single-Ended Inputs
18 Submit Documentation Feedback Copyright © 2009, Texas Instruments Incorporated
Product Folder Link(s) :TPA3113D2
Page 25
TPA3113D2
www.ti.com
NAME
SD 1 I
FAULT 2 O
LINP 3 I Positive audio input for left channel. Biased at 3V.
LINN 4 I Negative audio input for left channel. Biased at 3V.
GAIN0 5 I Gain select least significant bit. TTL logic levels with compliance to AVCC.
GAIN1 6 I Gain select most significant bit. TTL logic levels with compliance to AVCC.
AVCC 7 P Analog supply
AGND 8 Analog signal ground. Connect to the thermal pad.
GVDD 9 O
PLIMIT 10 I
RINN 11 I Negative audio input for right channel. Biased at 3V.
RINP 12 I Positive audio input for right channel. Biased at 3V.
NC 13 Not connected
PBTL 14 I Parallel BTL mode switch
PVCCR 15 P
PVCCR 16 P
BSPR 17 I Bootstrap I/O for right channel, positive high-side FET.
OUTPR 18 O Class-D H-bridge positive output for right channel.
PGND 19 Power ground for the H-bridges.
OUTNR 20 O Class-D H-bridge negative output for right channel.
BSNR 21 I Bootstrap I/O for right channel, negative high-side FET.
BSNL 22 I Bootstrap I/O for left channel, negative high-side FET.
OUTNL 23 O Class-D H-bridge negative output for left channel.
PGND 24 Power ground for the H-bridges.
OUTPL 25 O Class-D H-bridge positive output for left channel.
BSPL 26 I Bootstrap I/O for left channel, positive high-side FET.
PVCCL 27 P
PVCCL 28 P
........................................................................................................................................... SLOS650B– AUGUST 2009 – REVISED SEPTEMBER 2009
PIN FUNCTIONS
PIN
Pin
Number
I/O/P DESCRIPTION
Shutdown logic input for audio amp (LOW = outputs Hi-Z, HIGH = outputs
enabled). TTL logic levels with compliance to AVCC.
Open drain output used to display short circuit or dc detect fault status. Voltage
compliant to AVCC. Short circuit faults can be set to auto-recovery by connecting
FAULT pin to SD pin. Otherwise, both short circuit faults and dc detect faults must
be reset by cycling PVCC.
High-side FET gate drive supply. Nominal voltage is 7V. Also should be used as
supply for PLIMIT function
Power limit level adjust. Connect a resistor divider from GVDD to GND to set
power limit. Connect directly to GVDD for no power limit.
Power supply for right channel H-bridge. Right channel and left channel power
supply inputs are connect internally.
Power supply for right channel H-bridge. Right channel and left channel power
supply inputs are connect internally.
Power supply for left channel H-bridge. Right channel and left channel power
supply inputs are connect internally.
Power supply for left channel H-bridge. Right channel and left channel power
supply inputs are connect internally.
Copyright © 2009, Texas Instruments Incorporated Submit Documentation Feedback 5
Product Folder Link(s) :TPA3113D2
Page 26
PWM
Logic
Gate
Drive
Gate
Drive
PVCCL
PVCCL
GVDD
PVCCL
PVCCL
BSPL
PGND
OUTPL
OUTNL
PGND
GVDD
BSNL
PWM
Logic
Gate
Drive
Gate
Drive
PVCCL
PVCCL
GVDD
PVCCL
PVCCL
BSNR
PGND
OUTNR
OUTPR
PGND
GVDD
BSPR
LINP
LINN
RINP
RINN
UVLO/OVLO
SC Detect
DC Detect
Thermal
Detect
Startup Protection
Logic
Biases and
References
FAULT
SD
GAIN0
PLIMIT
AGND
AVCC
GAIN1
Gain
Control
TTL
Buffer
Ramp
Generator
AVDD
GVDD
GVDD
LDO
Regulator
Gain
Control
PLIMIT
PLIMIT
Reference
PBTL
Gain
Control
TTL
Buffer
PBTL
Select
PBTL Select
PBTL Select
OUTPL FB
OUTNL FB
OUTNN FB
OUTNP FB
OUTPR FB
OUTNR FB
OUTNL FB
OUTPL FB
PLIMIT
TPA3113D2
SLOS650B–AUGUST 2009– REVISED SEPTEMBER 2009 ...........................................................................................................................................
FUNCTIONAL BLOCK DIAGRAM
www.ti.com
6 Submit Documentation Feedback Copyright © 2009, Texas Instruments Incorporated
Product Folder Link(s) :TPA3113D2
Page 27
7 BH3544F-E2
Page 28
Page 29
Page 30
8 TDST-G070D
Page 31
Page 32
Page 33
Page 34
Main PCB Top
6M61E Factory Adjust Menu
(V0.0)
1. Description
Enter factory mode：
Open source menu，and then press digital button “3”, “1”, “9” , “5” in
turns to enter the factory menu. Press ↑ and ↓ button to choose the
item, press OK button enter the submenu,
press MENU to ruturn to
Page 35
upper menu , press ← and → button to adjust the value,
Leave factory mode:
Press menu button to back to upper menu until leave factory mode。
Software information:
Enter factory mode, you can get the software information from the
bottom of
the menu.
Panel information:
Enter factory mode, enter “
panel information from the bottom of
Panel SETTING” item, you can get the
this menu.
Aging mode:
You can press the shortcut key in the factory remote control to open
or close the aging mode.
ADC adjusts:
YPBPR source ADC:
Switch to YPBPR source, input 100% color bar pattern, enter
factory, select “
AUTO ADC” item in the “ADC CALIBRATION”
menu, press → button to begin auto adjust. When it is finish, it will
show “OK” or “FAILE”. If “FAILE” is showed, you need to try
again.
NOTE: YPBPR ADC need to do twice by use 576P and 720P
signal separate.
Page 36
VGA source ADC:
Switch to PC source, input tessellated white and black signal,
enter factory, select “
AUTO ADC” item in the “ADC CALIBRATION”
menu, press → button to begin auto adjust. When it is finish, it will
show “OK” or “FAILE”. If “FAILE” is showed, you need to try again.
White balance:
Enter factory mode, enter “
balance in this menu.
W/B ADJUST” item, you can adjust white
Page 37
Over scanning:
Enter factory mode, enter “
“OVERSCAN”
submenu, you can adjust the over scan in these menu.
Panel SETTING” submenu, enter
OutFactory reset:
Enter factory mode, enter “
SYSTEM SETTING” item, select “OUT
FACTORY SET” item and press OK button to reset the flash memory.
TV set will restart when it is finish.
INIT EEPROM：
Enter factory mode, enter “
SYSTEM SETTING” item, select “FAC
RESET DEFAULT” item and press OK button to reset the EEPROM.
TV set will restart when it is finish.
Update software (by USB):
Copy the new software (name by “MERGE.bin”) to the root directory
of USB drive. Plug the drive to the
USB2 socket (if there are two USB
socket, make sure you use the socket 2). Enter factory, select “Software
Update (USB)” item and press OK button to begin update. TV set will
restart when finish. Note, you need to restart the TV set again by AC
power.
We suggest you need to do “INIT EEPROM” and “Factory reset”
after software update
Page 38
Page 39
Page 40
Page 41
Page 42
5
4
3
2
1
Connetor
D D
C C
B B
CN1
1
2
3
4
5
6
7
8
9
10
11
12
13
14
CON14/PIN=2.5MM
+12V_PWR
FB6
0R/1206/5%/NC
Power Switch
STANDBY
STANDBY
STANDBY
STANDBY
22K/0402/5%
22K/0402/5%
BL-ON/OFF
BL-ADJUST
FB7 0R/0402/5%/NC
FB5
0R/1206/5%/NC
R15
R24
+12V_NORMAL
+5V_Standby
R12
100K/0402/5%
1
2 3
+12V_PWR
R21
100K/0402/5%
1
2 3
+5V_Standby
+12V_PWR
R13
100K/0402/5%
Q3
3904/SOT-23
R23
100K/0402/5%
Q4
3904/SOT-23
STANDBY
C10
0.1uF/0402/16V
C20
0.1uF/0402/16V
1
2
3
4
5V Standby Power(option) 3A
+12V_PWR
C4
0.1uF/0402/16V
C2
C3
10uF/16V/0805
10uF/16V/0805
C9
0.1uF/0402/16V/NC
U2
4953/SOP8
8
S1
G1
S2
G2
C11
0.1uF/0402/16V/NC
+5V_Normal
D1
7
D1
6
+12V_NORMAL
D2
5
D2
U1
AOZ3015PI/SOP8
2
VIN
LX
7
R1 100K/0402/5%
R3 27K/0402/5%/NC
1nF/0402/16V/NC
R7
20K/0402/5%
C8
2.2nF/0402/16V
C5
C6
0.1uF/0402/16V
EN
Vo
6
FB
COMP
4
PGND
VCC
AGND
3
Standby controller
STANDBY
9
L7 22uH_3A
8
5
R1
1
R5 51K/0402/1%
C7
0.1uF/0402/16V/NC
R2
R10 9.1K/0402/1%
Vout=0.8V*(1+R1/R2)
+3.3V_Standby
R16
R19
200R/0402/5%
4.7K/0402/5%
STANDBY
H :Power on
L :Power off
470uF/16V/EC3.5
PWR-ON/OFF
+5V_Standby
0R/1206/5%
+
CA3
+5V_Normal
FB1
0R/1206/5%
C1
0.1uF/0402/16V
FB2
If POWER BOARD IS 5stb ONLY ,P L NOT PATCH THESE GUY.
1.5V/1.8V Power_Normal
4
U4
ADJ
OUT
AMS1117-Adj
IN
R1
220R/0402/5%/470R/0402/5%
R26
R2
R27
100R/0402/5%
A A
321
0.1uF/0402/16V
C23
C22
0.1uF/0402/16V
C24
2.2uF/0603/16V
+5V_Normal
2.2uF/0603/16V
输入加大滤波电容解决插入个别硬盘重启
+1.8V_DDR2
C25
3.3V Power
4
ADJ
OUT
+5V_Standby
C26
0.1uF/0402/16V
IN
321
C27
U5
AMS1117-3.3
+3.3V_Normal
C28
2.2uF/0603/16V
+3.3V_Standby
C29
0.1uF/0402/16V
2.2uF/0603/16V
Test Point & MARK
H1
1
5
4
3
2
NC
1
1
H5
NC
H2
1
5
9
8
7
6
1
H6
NC
NC
9
4
8
3
7
2
6
NC
H7
H3
1
5
4
3
2
NC
H4
1
5
9
8
7
6
9
4
8
3
7
2
6
NC
Inverter controller
MUTE_EAR
MUTE_EAR
D5
1N4148
BL-ON/OFF
R159
BL-ADJUST
10K/0402/5%
C104
0.1uF/0402/16V/NC
C85
1nF/0402/16V
1.15V Core Power
+5V_Standby
+12V_PWR
FB9
FB8
0R/1206/5%
0R/1206/5%
10uF/16V/0805
C17
C18
10uF/16V/0805
R17
10K/0402/5%
3
5
1
Vout=0.8V*(1+R1/R2)
NOTICE:
H9
1
5
9
4
8
3
7
2
6
NC
解决耳机冲击声
+5V_Normal
R4
R200
4.7K/0402/5%
200R/0402/5%
R8
100R/0402/5%
22K/0402/5%
U3
MP1470
IN
EN
GND
3904/SOT-23
R11
Q2
1
3904/SOT-23
R193
2 3
10K/0402/5%/NC
6
BST
2
SW
4
FB
C21
10pF/0402/16V
If chip is 3393,The R2 Value is 10K 1%
If chip is 6306,The R2 Value is 8.2K 1%
R6
10K/0402/5%/NC
Q1
1
R9
10K/0402/5%
2 3
R199
4.7K/0402/5%
R14
20R/0402/5%
C12
1uF/0402/16V
L2
22uH_3A
R20
100K/0402/5%
Resistors close to the DC-DC
增加
100UF
电解电容，删除
R1
R2
R18
4.7K/0402/1%
R22
10K/0402/1% or 8.2K/0402/1%
VBL_CTRL
BRI_ADJ
C15/C16,
C13
10uF/16V/0805
R25
470R/0402/5%
Max :1.0A
VDDC
改善纹波
0.1uF/0402/16V
C19
C14
10uF/16V/0805
10uF/16V/0805
C15
10uF/16V/0805
C16
Vout=1.25V*(R1+R2)/R1
NOTICE:
If chip is 3393,The R1 Value is 220R 5% Vout=1.8V
If chip is 6306,The R1 Value is 470R 5% Vout=1.5V
5
4
Title
Title
Title
Size Document Number Rev
Size Document Number Rev
Size Document Number Rev
Custom
Custom
Custom
Date: Sheet of
Date: Sheet of
3
2
Date: Sheet
MSD3393
MSD3393
MSD3393
System power
System power
System power
1
1.0
1.0
1.0
of
1 9Sunday, July 14, 2013
1 9Sunday, July 14, 2013
1 9Sunday, July 14, 2013
Page 43
HDMI Interface
HDMI0-RX0P
HDMI0-RX0P
HDMI0-RX0N
HDMI0-RX0N
HDMI0-RX1P
HDMI0-RX1P
HDMI0-RX1N
HDMI0-RX1N
HDMI0-RX2P
HDMI0-RX2P
HDMI0-RX2N
HDMI0-RX2N
HDMI0-CLKN
HDMI0-CLKN
HDMI0-CLKP
HDMI0-CLKP
HDMI0-SCL
HDMI0-SCL
HDMI0-SDA
HDMI0-SDA
HDMI0-HPDIN
HDMI0-HPDIN
HDMI1-RX0P
HDMI1-RX0P
HDMI1-RX0N
HDMI1-RX0N
HDMI1-RX1P
HDMI1-RX1P
HDMI1-RX1N
HDMI1-RX1N
HDMI1-RX2P
HDMI1-RX2P
HDMI1-RX2N
HDMI1-RX2N
HDMI1-CLKN
HDMI1-CLKN
HDMI1-CLKP
HDMI1-CLKP
HDMI1-SCL
HDMI1-SCL
HDMI1-SDA
HDMI1-SDA
HDMI1-HPDIN
HDMI1-HPDIN
HDMI2-RX0P
HDMI2-RX0P
HDMI2-RX0N
HDMI2-RX0N
HDMI2-RX1P
HDMI2-RX1P
HDMI2-RX1N
HDMI2-RX1N
HDMI2-RX2P
HDMI2-RX2P
HDMI2-RX2N
HDMI2-RX2N
HDMI2-CLKN
HDMI2-CLKN
HDMI2-CLKP
HDMI2-CLKP
HDMI2-SCL
HDMI2-SCL
HDMI2-SDA
HDMI2-SDA
HDMI2-HPDIN
HDMI2-HPDIN
MHL_CABLE-DET
MHL_CABLE-DET
D D
C C
HDMI-ARC
HDMI-ARC
HDMI-CEC
HDMI-CEC
PC & YPBPR Interface
R28 3 3R/04 02/5%
VGA-Rin
R29 6 8R/04 02/5%
R30 3 3R/04 02/5%
VGA-Gin
R31 3 3R/04 02/5%
VGA-Bin
VGA_HSYNC
VGA_VSYNC
R32 3 3R/04 02/5%
YPbPr_PR
R33 6 8R/04 02/5%
R34 3 3R/04 02/5%
YPbPr_Y
R35 3 3R/04 02/5%
YPbPr_PB
R36 0 R/040 2/5%
CVBS IN & OUT
R38 1 50R/0 402/5%
AV1
R39 1 80R/0 402/5%
CVBS1_OUT
AUDIO IN
VGA-Lin_AU
C61 2.2uF/0603/1 6V
VGA-Lin_AU
VGA-Rin_AU
C63 2.2uF/0603/1 6V
VGA-Rin_AU
AV1-Lin
C64 2.2uF/0603/1 6V
AV1-Lin
AV1-Rin
C65 2.2uF/0603/1 6V
AV1-Rin
DIF IN
IFP
IFN
USB & SPDIF_OUT
USB2_DUSB2_D+
USB1_DUSB1_D+
SPDIF_OUT
RESET
+5V_Standby
3
D1
R49
BAV99
100K/0402/5 %
C75
1
2
R50
2.2uF/0603/16 V
1
Q5
10K/0402/5%
3906/SOT-23
R52
3 2
1K/0402/5%
C78
2.2uF/0603/16 V
R54
100K/0402/5 %
DEBUG
+5V_Standby
MUST pull high to 5VSTB
R65
R64
ISP AND VGA EDID
4.7K/0402/5%
4.7K/0402/5%
UART-TX
R66 100R/0402 /5%
UART-RX
R67 100R/0402 /5%
C48 4 7nF/04 02/16V
C49 4 7nF/04 02/16V
C50 4 7nF/04 02/16V
C51 4 7nF/04 02/16V
C52 4 7nF/04 02/16V
C53 4 7nF/04 02/16V
C54 4 7nF/04 02/16V
C55 4 7nF/04 02/16V
C56 1 nF/040 2/16V
C58 47nF/0402/16V
C60 47nF/0402/16V
C67
0.1uF/0402/16 V
C68
0.1uF/0402/16 V
C77
1nF/0402/16 V
5
TP4
HDMI2-RX0N
HDMI2-CLKN
HDMI2-CLKP
HDMI2-RX0P
HDMI0-RX1P
HDMI0-RX2N
HDMI0-RX2P
1
128
129
121
123
124
122
126
127
125
130
131
132
U6
Test
MARK
MARK
E-PAD
RX0P_B
RX2P_D
RX1P_D
RX0N_B
RX2N_D
RXCP_B
RXCN_B
1
HDMI2-RX1N
RX1N_B
2
HDMI2-RX1P
RX1P_B
3
HDMI2-RX2N
RX2N_B
4
HDMI2-RX2P
RX2P_B
5
+3.3V_Norma l
AVDD_MOD
6
HDMI1-CLKN
RXCN_A
7
HDMI1-CLKP
RXCP_A
8
HDMI1-RX0N
RX0N_A
9
HDMI1-RX0P
RX0P_A
10
HDMI1-RX1N
RX1N_A
11
HDMI1-RX1P
RX1P_A
12
HDMI1-RX2N
RX2N_A
13
HDMI1-RX2P
RX2P_A
14
VGA_HSYNC
HSYNC0
15
RGB0_B+
BIN0P
16
RGB0_G+
GIN0P
17
RGB0_G-
GIN0M
18
RGB0_R+
RIN0P
19
VGA_VSYNC
VSYNC0
20
+3.3V_Norma l
AVDD3P3_ADC
21
RGB1_B+
RGB0_R+
RGB1_SOG
RGB0_G-
RGB1_G+
RGB0_G+
RGB1_G-
RGB0_B+
RGB1_R+
RGB1_GRGB1_G+
RGB1_B+
RGB1_SOG
CVBS0+
CVBS_VCOM
CVBS1_OUT
LINEIN_L1
LINEIN_R1
LINEIN_L4
LINEIN_R4
2.2uF/0603/16 V
L6
XTAL
XTALO
XTALI
FLASH
+3.3V_Standby
C81
0.1uF/0402/16 V
RGB1_R+
CVBS0+
CVBS_VCOM
CVBS1_OUT
VDDC
+3.3V_AU
LINEIN_R1
LINEIN_L1
AU_VAG
AU_VRM
AU_VRM
AU_VAG
C71
C69
C70
0.1uF/0402/16 V
2.2uF/0603/16 V
0R/0603/5%
R51
C76
0R/0402/5%
33pF/0402/1 6V
Y1
3
R53
1M/0402/5%
24.000MHz
C79
33pF/0402/1 6V
U7
MX25L3205
8
VDD
7
HOLD#
6
SPI_SCK
SCK
5
SPI_SDI
VGA_HSYNC
VGA_VSYNC
VIFP
VIFM
USB2_DUSB2_D+
USB1_DUSB1_D+
SPDIF_OUT
System-RST
UART_TX
UART_RX
BIN1P
22
SOGIN1
23
GIN1P
24
GIN1M
25
RIN1P
26
VSYNC1
27
CVBS1
28
CVBS0
29
VCOM
30
CVBS_OUT1
31
VDDC
32
AVDD_AU33
33
AUR0
34
AUL0
35
AUR1
36
AUL1
37
VAG
38
VRM
MSD3393LU
+3.3V_TU
R43
10K/0402/5%
IFAGC
CHIP_CONFIG
{IPAD_PWM1, PAD_PWM0}
B51_NO_EJ
PWM1
PWM0
1
SPI_CSN
CE#
2
SPI_SDO
SO
3
#F_WP
WP#
VSS4SI
MSD3393LU
AUR440AUOUTL341AVDD_MOD52GPIO3/GPIO 4758GPIO4/GPIO 4859LVA3P61GPIO2/GPIO 46
AUOUTL043AUOUTR3
AUL4
42
39
LINEIN_L4
LINEIN_R4
IFAGC
LINE3OUT_L
LINE3OUT_R
LINE0OUT_L
LINE0OUT_R
Close to Mstar IC
R46
C72
0R/0402/5%
22nF/0402/1 6V
4'h00
R57 4.7K/0402/5%
R58 4.7K/0402/5%
+3.3V_Standby
R63
10K/0402/5%
HDMI0-RX1N
VIFP
HDMI0-RX0P
120
RX1N_D
VIFP46VIFM47AUOUTR044IFAGC45XIN50AVDD3P3_DMP LL49Xout
VIFM
VDDC
VDDC
+1.8V_DDR2
AVDD5V_MHL
ARC_DET
HDMI1-SCL
HDMI1-SDA
MHL_CABLE-DET
HDMI2-SDA
HDMI2-SCL
HDMI2-HPDIN
HDMI0-SDA
HDMI0-SCL
HDMI0-RX0N
HDMI0-CLKN
HDMI0-CLKP
112
111
113
114
115
105
106
104
109
116
110
107
108
117
118
119
103
SAR2
RX0P_D
RX0N_D
RXCP_D
RXCN_D
AVDD_5V
MHL_DET
DDCDB_CL
DDCDA_CL
DDCDB_DA
DDCDC_CL
DDCDA_DA
DDCDC_DA
HOTPLUG_B
GND_EFUSE
VDDIO_DATA
102
KEY1-SAR1
SAR1
101
KEY0-SAR0
SAR0
VDDC/AVDDL_ DVI
AVDD3P3_DAD C
53
51
48
+1.8V_DDR2
+3.3V_ADC
+3.3V_PLL
+3.3V_Normal
XTALO
XTALI
IFAGC-T
100
+3.3V_Norma l
AVDD_MOD
99
USB1_D+
DP_P1
98
USB1_D-
DM_P1
97
USB2_D+
VDDC/DVDD_D DR_DATA
DP_P0
96
USB2_D-
DM_P0
95
System-RST
RESET
94
PANEL_ON/OFF
INT/GPIO64
93
IR-in
IRIN
92
HDMI-CEC
CEC
91
TEST
90
UART-RX
DDCA_CK
89
UART-TX
DDCA_DA
88
HDMI-ARC
ARC
87
SPI_SCK
SPI_CK
86
SPI_CSN
SPI_CZ
85
SPI_SDI
SPI_DI
84
SPI_SDO
SPI_DO
83
BRI_ADJ
PWM0
82
VBL_CTRL
PWM1
81
HDMI1-HPDIN
HOTPLUG_A
80
HDMI0-HPDIN
HOTPLUG_C/D
79
R7_RXO0-
LDE/LVB0M
78
R6_RXO0+
LCK/LVB0P
77
R5_RXO1-
LVB1M
76
R4_RXO1+
LVB1P
75
R3_RXO2-
LVB2M
74
R2_RXO2+
LVB2P
73
+3.3V_Norma l
AVDD_MOD
72
G7_RXO3-
LVB3M
71
G6_RXO3+
LVB3P
70
G3_RXE0-
LVA0M
69
G2_RXE0+
LVA0P
68
G1_RXE1-
LVA1M
67
G0_RXE1+
LVA1P
66
B7_RXE2-
LVA2M
65
B6_RXE2+
LVA2P
GPIO0/GPIO 4455LVACKM64VDDC/DVDD_D DR_CMD54VDDIO_CMD
LVA3M62LVACKP
GPIO1/GPIO 45
GPIO5/GPIO 49
63
57
56
60
VDDC
TUNER_SDA
TUNER_SCL
B3_RXE3-
B2_RXE3+
B4_RXEC+
B5_RXEC-
MHL_VBUS-EN
AMP-MUTE
PWR-ON/OFF
SPDIF_OUT
IR-in
KEY0-SAR0
KEY1-SAR1
PWR-ON/OFF
PWR-ON/OFF
PWM0
BRI_ADJ
PWM1
VBL_CTRL
MHL_VBUS-EN
MHL_VBUS-EN
AMP-MUTE
AMP-MUTE
PANEL_ON/OFF
PANEL_ON/OFF
ARC_DET
ARC_DET
TUNER_SCL
TUNER_SCL
TUNER_SDA
TUNER_SDA
R7_RXO0-
R7_RXO0-
R6_RXO0+
R6_RXO0+
R5_RXO1-
R5_RXO1-
R4_RXO1+
R4_RXO1+
R3_RXO2-
R3_RXO2-
R2_RXO2+
R2_RXO2+
G7_RXO3-
G7_RXO3-
G6_RXO3+
G6_RXO3+
G3_RXE0-
G3_RXE0-
G2_RXE0+
G2_RXE0+
G1_RXE1-
G1_RXE1-
G0_RXE1+
G0_RXE1+
B7_RXE2-
B7_RXE2-
B6_RXE2+
B6_RXE2+
B5_RXEC-
B5_RXEC-
B4_RXEC+
B4_RXEC+
B3_RXE3-
B3_RXE3-
B2_RXE3+
B2_RXE3+
4
VDDC 1.15V
VDDC
C30
C32
C31
0.1uF/0402/16 V
0.1uF/0402/16 V
2.2uF/0603/16 V
DDR2 1.8V
2.2uF/0603/16 V
3.3V
+3.3V_Norma l
2.2uF/0603/16 V
+1.8V_DDR2
0.1uF/0402/16 V
3.3V audio
+3.3V_Norma l
C38
C35
C36
0.1uF/0402/16 V
0.1uF/0402/16 V
0.1uF/0402/16 V
0.1uF/0402/16 V
C40
C42
C41
C43
0.1uF/0402/16 V
0.1uF/0402/16 V
Audio Line Out
LINE0OUT_L
LINE0OUT_R
LINE3OUT_L
LINE3OUT_R
R37
C165
200K/0402/5 %
1nF/0402/16 V
R40
C57
200K/0402/5 %
1nF/0402/16 V
C62
R41
200K/0402/5 %
1nF/0402/16 V
R42
C66
200K/0402/5 %
1nF/0402/16 V
Close to Mstar IC
IR&KEYB
+5V_Standby
CN3
CON20W-J20 -12
1
2
KEY0-in KEY1-in
3
KEY1-in
4
5
6
7
IR_in
8
9
LED_R
10
11
LED_G
12
+3.3V_Standby
+5V_Standby
R60
10K/0402/5%
IR_in
IR-in
R62
100R/0402 /5%
D53
C80
33pF/0402/1 6V
ESD/NC
1 2
C33
C34
0.1uF/0402/16 V
3.3V MPLL
+3.3V_Norma l
+3.3V_AU
+3.3V_PLL
L4
L3
0R/0603/5%
0R/0603/5%
C37
C39
0.1uF/0402/16 V
0.1uF/0402/16 V
+3.3V_ADC
L5
0R/0603/5%
C46
C45
C47
C44
0.1uF/0402/16 V
0.1uF/0402/16 V
2.2uF/0603/16 V
HEAT SINK
AV_AUOUTL1
AV_AUOUTR1
LINEOUT_APML
LINEOUT_APMR
+3.3V_Standby
R44
8.2K/0402/5%
KEY0-in
C74
0.1uF/0402/16 V
STANDBY
D54
ESD/NC
Standby :H :Pow er on Green Led
L :Pow er off Red Led
H8
1
2
CON2/NC
R45
8.2K/0402/5%
KEY0-SAR0 KEY1-SAR1
R47
1K/0402/5%
C73
D51
0.1uF/0402/16 V
ESD/NC
1 2
+3.3V_Standby
R55
2K/0402/5%
LED_R
R59
4.7K/0402/5%
Q7
1
R61
4.7K/0402/5%
3904/SOT-23
2 3
1 2
+3.3V_Standby
KEY1-SAR1
R48
1K/0402/5%
D52
ESD/NC
1 2
+3.3V_Norma l
R56
4.7K/0402/5%
LED_G
Q6
1
2 3
3904/SOT-23
3
2
1
B B
A A
Title
Title
Title
MSD3393
MSD3393
MSD3393
Size Document Numbe r Rev
Size Document Numbe r Rev
Size Document Numbe r Rev
MAIN CHIP
MAIN CHIP
MAIN CHIP
E
E
E
Date: Sheet of
Date: Sheet of
5
4
3
2
Date: Sheet of
1
2 9Saturday, June 0 8, 2013
2 9Saturday, June 0 8, 2013
2 9Saturday, June 0 8, 2013
1.0
1.0
1.0
Page 44
5
4
LVDS CONNECTOR ( 1 DIP + 2 SMT OPTIONAL )
HI CONNECTOR
3
2
1
D D
VCC-Panel
CA6
100uF/16V
C C
M_SDA
B B
C103
+
0.1uF/0402/1 6V
B2_RXE3+
B4_RXEC+
B6_RXE2+
G0_RXE1+
G2_RXE0+
DCR-IN
G6_RXO3+
R0_RXOC+
R2_RXO2+
R4_RXO1+
R6_RXO0+
R481 NC/100R/0402/5%
CN35
1
CON03
2
3
CN2
VCC1VCC
VCC3VCC
GND5GND
GND7GND
A4P9A4M
A3P11A3M
ACKP13ACKM
A2P15A2M
A1P17A1M
A0P19A0M
GND21GND
IO23MODE
PWM25DCRO
GND27GND
B4P29B4M
B3P31B3M
BCKP33BCKM
B2P35B2M
B1P37B1M
B0P39B0M
GND41GND
SDA43SCL
GND45GND
NC/CON22X2_2.0
3D_SOCKET SG_SYNC
2
4
6
8
10
12
14
16
18
20
22
24
26
28
30
32
34
36
38
40
42
44
46
+5V_Normal
B3_RXE3B5_RXECB7_RXE2G1_RXE1G3_RXE0SG_SYNC
8_10BIT_SEL
DCR-OUT
G7_RXO3R1_RXOCR3_RXO2R5_RXO1R7_RXO0-
M_SCL
R488 NC/100R/0402 /5%
BRI_ADJ
D347
NC
1 2
TUNER_SCLTUNER_SDA
R168NC/100
+3.3V_Normal
R70
0/NC
100R/0402/5% /NC
100R/0402/5% /NC
R73
10K/0402/5% NC
R72
NC/0
R74
R75
DCR-OUT
DCR-IN
Power for panel
+5V_Normal
+12V_NORMAL
PANEL_ON/OFF
FB3 0R/1206/5%/NC
FB4 0R/1206/5%
PANEL_ON/OFF
0.1uF/0402/1 6V/NC
R71
4.7K/0402/5%
R2
4.7K/0402/5%
VPANEL_IN
U8 9435/S OP8
1
S
2
C82
100K/0402/5 %
1
3904/SOT-23
R68
Q9
2 3
R69
100K/0402/5 %
3
4
C83
AO3401A/SOT-23/NC
1uF/0402/16 V/NC
0.1uF/0402/1 6V/NC
Net to other page
R7_RXO0R6_RXO0+
R5_RXO1R4_RXO1+
R3_RXO2R2_RXO2+
G7_RXO3G6_RXO3+
R7_RXO0R6_RXO0+
R5_RXO1R4_RXO1+
R3_RXO2R2_RXO2+
G7_RXO3G6_RXO3+
D
S
D
S
D
G
D
Q8
C84
G3_RXE0G2_RXE0+
G1_RXE1G0_RXE1+
B7_RXE2B6_RXE2+
B5_RXECB4_RXEC+
B3_RXE3B2_RXE3+
R1_RXOC- B5_RXECR0_RXOC+ B4_RXEC+
5
6
7
8
VCC-Panel
G3_RXE0G2_RXE0+
G1_RXE1G0_RXE1+
B7_RXE2B6_RXE2+
B5_RXECB4_RXEC+
B3_RXE3B2_RXE3+
A A
Title
Title
Title
Size Document Nu mber R ev
Size Document Nu mber R ev
Size Document Nu mber R ev
B
B
B
Date: Sheet of
Date: Sheet of
5
4
3
2
Date: Sheet of
MSD3393
MSD3393
MSD3393
LVDS Interface
LVDS Interface
LVDS Interface
1.0
1.0
1.0
3 9Saturday, June 08, 2013
3 9Saturday, June 08, 2013
3 9Saturday, June 08, 2013
1
Page 45
5
4
3
2
1
VIDEO OUT
+5V_Normal
D D
C C
AV IN
P1
12
34
56
RCA-3P
R209
75R/0402/5%
AV1
220pF/0402/ 16V/NC
C87
C86
220pF/0402/ 16V/NC
R76 10K/0402/5%
R77 10K/0402/5%
R79
12K/0402/5%
AV1-Rin
AV1-Lin
R80
12K/0402/5%
AVOUT-V
TP1
3906/SOT23
R155
75R/0402/5%
Q17
R78
470R/0402/5%
3904/SOT23
R206
75R/0402/5%
Q18
R154
75R/0402/5%
SPDIF OUT
CN42 RCA1_180D
C102
0.1uF/0402/1 6V
R208
20K/0402/5%
1
C97
R207
12K/0402/5%
10uF/0603/1 6V
2 3
FOR ATV/AV DEBUG
CVBS1_OUT
YPBPR
P2
PHONEJACK STEREO 180 D
B B
1
2
3
4
YPbPr_PR
YPbPr_PB
YPbPr_Y
21
SPDIF_O
3
R81 330R/ 0402/5%
R82 100R/0 402/5%
Closed to IC
C88
33pF/0402/1 6V
SPDIF_OUT
Close to Mstar IC
R84
75R/0402/5%
75R/0402/5%
R85
Title
Title
Title
Size Document Nu mber R ev
Size Document Nu mber R ev
Size Document Nu mber R ev
B
B
B
Date: Sheet of
Date: Sheet of
4
3
2
Date: Sheet of
MSD3393
MSD3393
MSD3393
Video Interface
Video Interface
Video Interface
1.0
1.0
1.0
4 9Saturday, June 08, 2013
4 9Saturday, June 08, 2013
4 9Saturday, June 08, 2013
1
R83
75R/0402/5%
A A
5
Page 46
5
4
3
2
1
VGA
P4
D D
C C
R92
10K/0402/5%
1617
11
12
13
14
15
VGA/15 PIN
R93
10K/0402/5%
1
6
2
7
3
8
4
9
5
10
DDC_SCL_D
DDC_SDA_D
R90100R/0402/5%
R91100R/0402/5%
VGA-Rin
VGA-Gin
VGA-Bin
UART_RX
UART_TX
VGA_VSYNC
VGA_HSYNC
VGA AUDIO IN
PHONEJACK STEREO 90D
1
2
3
P5
4
R86 10K/0402/5%
R87 10K/0402/5%
R88
12K/0402/5%
R89
12K/0402/5%
VGA-Lin_AU
VGA-Rin_AU
C89
220p/0402/16V
VGA-Lin_AU
VGA-Rin_AU
C90
220p/0402/16V
B B
VGA-Bin
VGA-Gin
VGA-Rin
R94
75R/0402/5%
R96
R95
75R/0402/5%
75R/0402/5%
VGA-Bin
VGA-Gin
VGA-Rin
Close to Mstar IC
A A
Title
Title
Title
MSD3393
MSD3393
MSD3393
Size Docum ent Number Rev
Size Docum ent Number Rev
Size Docum ent Number Rev
A
A
A
Date: Sheet of
Date: Sheet of
5
4
3
Date: Sheet of
VGA Interface
VGA Interface
VGA Interface
2
5 9Saturday, June 08, 2013
5 9Saturday, June 08, 2013
5 9Saturday, June 08, 2013
1
1.0
1.0
1.0
Page 47
5
4
3
2
1
USB INTERFACE
D D
C C
5
6
5
6
P6
USB_A
5
6
5
6
1
1
2
3
4
P7USB_A
1
2
3
4
USB1_D1-_in
USB1_D1+_in
USB2_D1-_in
USB2_D1+_in
2
3
4
1
2
3
4
+5V_USB0
+5V_USB0
R97 5.1/0402/5%
R98 5.1/0402/5%
R99 5.1R
R100 5.1R
USB2_D+
Note:5.1R
USB ESD
USB1_DUSB1_D+
USB2_D-
电阻靠近端子,减小
分布电容要求
USB2_D-
USB2_D+
<2pF
USB1_DUSB1_D+
ESD.
USB POWER
D2
+5V_USB0
2.2uF/0603/16V
C91
0.1uF/0402/16V
Note:
Note:
电容靠近
电容靠近
USB(CN600)端子,提供usb
C93
0.1uF/0402/16V
USB(CN601)端子,提供usb
C94
2.2uF/0603/16V
+5V_Normal5V_USB
5V_USB
C92
读写稳定性
5V_USB+5V_USB0
读写稳定性
B B
A A
Title
Title
Title
MSD3393
MSD3393
MSD3393
Size Docum ent Number Rev
Size Docum ent Number Rev
Size Docum ent Number Rev
A
A
A
Date: Sheet of
Date: Sheet of
5
4
3
Date: Sheet of
USB Interface
USB Interface
USB Interface
2
6 9Saturday, June 08, 2013
6 9Saturday, June 08, 2013
6 9Saturday, June 08, 2013
1
1.0
1.0
1.0
Page 48
5
P8
20
GND
21
GND
22
GND
23
GND
18
+5V
17
CEC/DDC GND
15
DDC SCL
16
DDC SDA
13
CEC
19
HPD
2
Dat2 shield
5
Dat1 shield
8
Dat0 shield
11
clk shield
D D
7
DAT0+
9
DAT0-
4
DAT1+
6
DAT1-
1
DAT2+
3
DAT2-
10
clk+
12
clk-
14
ARC1
HDMI
P9
20
GND
21
GND
22
GND
23
GND
18
+5V
17
CEC/DDC GND
15
DDC SCL
16
DDC SDA
13
CEC
19
HPD
2
Dat2 shield
5
Dat1 shield
8
Dat0 shield
11
clk shield
7
DAT0+
9
DAT0-
4
DAT1+
6
DAT1-
1
DAT2+
3
DAT2-
10
clk+
12
clk-
C C
14
ARC1
HDMI
P10
20
GND
21
GND
22
GND
23
GND
18
+5V
17
CEC/DDC GND
15
DDC SCL
16
DDC SDA
13
CEC
19
HPD
2
Dat2 shield
5
Dat1 shield
8
Dat0 shield
11
clk shield
7
DAT0+
9
DAT0-
4
DAT1+
6
DAT1-
1
DAT2+
3
DAT2-
10
clk+
12
clk-
14
ARC1
B B
HDMI
HDMI3_RX0P
HDMI3_RX0N
HDMI3_RX1P
HDMI3_RX1N
HDMI3_RX2P
HDMI3_RX2N
HDMI3_CLKP
HDMI3_CLKN
HDMI3/5V
HDMI_ARC
HDMI3-DDC-SCL
HDMI3-DDC-SDA
HDMI3-HPD
HDMI1/5V
HDMI1-DDC-SCL
HDMI1-DDC-SDA
CEC
HDMI1-HPD
HDMI1_RX0P
HDMI1_RX0N
HDMI1_RX1P
HDMI1_RX1N
HDMI1_RX2P
HDMI1_RX2N
HDMI1_CLKP
HDMI1_CLKN
HDMI2-DDC-SCL
HDMI2-DDC-SDA
CEC
HDMI2-HPD
MHL_CD_SENSE
HDMI2_RX0P
HDMI2_RX0N
HDMI2_RX1P
HDMI2_RX1N
HDMI2_RX2P
HDMI2_RX2N
HDMI2_CLKP
HDMI2_CLKN
CEC
HDMI2/5V
CEC & ARC
HDMI_ARC HDMI-ARC
根据
CEC
HDMI3/5V
ARC
C95
2.2uF/0603/16V
R144 200R/0402/5%
所放的
HDMI
R148 4.7K/0402/5%
定
HDMI-CEC
R150
10K/0402/5%
HDMI-ARC
HDMI-CEC
ARC_DET
HDMI3_RX2P
HDMI3_RX2N
HDMI3_RX1P
HDMI3_RX1N
HDMI3_RX0P
HDMI3_RX0N
HDMI3_CLKP
HDMI3_CLKN
靠近端子放置
HDMI1_RX2P
HDMI1_RX2N
HDMI1_RX1P
HDMI1_RX1N
HDMI1_RX0P
HDMI1_RX0N
HDMI1_CLKP
HDMI1_CLKN
R101 5.1R/0402/5%
R103 5.1R/0402/5%
R107 5.1R/0402/5%
R108 5.1R/0402/5%
R109 5.1R/0402/5%
R111 5.1R/0402/5%
R113 5.1R/0402/5%
R115 5.1R/0402/5%
靠近端子放置
R116 5.1R/0402/5%
R117 5.1R/0402/5%
R119 5.1R/0402/5%
R121 5.1R/0402/5%
R123 5.1R/0402/5%
R125 5.1R/0402/5%
R126 5.1R/0402/5%
R130 5.1R/0402/5%
靠近端子放置
HDMI2_RX2P
HDMI2_RX2N
HDMI2_RX1P
HDMI2_RX1N
HDMI2_RX0P
HDMI2_RX0N
HDMI2_CLKP
HDMI2_CLKN
MHL
HDMI2/5V
HDMI3-RX2P
HDMI3-RX2N
HDMI3-RX1P
HDMI3-RX1N
HDMI3-RX0P
HDMI3-RX0N
HDMI3-CLKP
HDMI3-CLKN
HDMI1-RX2P
HDMI1-RX2N
HDMI1-RX1P
HDMI1-RX1N
HDMI1-RX0P
HDMI1-RX0N
HDMI1-CLKP
HDMI1-CLKN
R131 0R/0402/5%
R132 0R/0402/5%
R133 0R/0402/5%
R134 0R/0402/5%
R137 0R/0402/5%
R139 0R/0402/5%
R141 0R/0402/5%
R143 0R/0402/5%
+5V_Standby
R145 0R/0402/5%
D3
2
1
HDMI0-RX2P
HDMI0-RX2N
HDMI0-RX1P
HDMI0-RX1N
HDMI0-RX0P
HDMI0-RX0N
HDMI0-CLKP
HDMI0-CLKN
HDMI2-RX2P
HDMI2-RX2N
HDMI2-RX1P
HDMI2-RX1N
HDMI2-RX0P
HDMI2-RX0N
HDMI2-CLKP
HDMI2-CLKN
AVDD5V_CD
3
BAT54C/SOT23/NC
HDMI1-RX2P
HDMI1-RX2N
HDMI1-RX1P
HDMI1-RX1N
HDMI1-RX0P
HDMI1-RX0N
HDMI1-CLKP
HDMI1-CLKN
HDMI3-DDC-SCL
HDMI3-DDC-SDA
HDMI2-RX2P
HDMI2-RX2N
HDMI2-RX1P
HDMI2-RX1N
HDMI2-RX0P
HDMI2-RX0N
HDMI2-CLKP
HDMI2-CLKN
HDMI2/5V
HDMI1-DDC-SCL
HDMI1-DDC-SDA
R152 10R/0402/5%
更新为此
R104
10K/0402/5%
HDMI3/5V
R105
10K/0402/5%
10K/0402/5%
MHL,
HDMI2-DDC-SCL
HDMI2-DDC-SDA
不需要
AVDD5V_MHL
4
R110 33R/0402/5%
R112 33R/0402/5%
HDMI1/5V
R124
R122
10K/0402/5%
R127 33R/0402/5%
R129 33R/0402/5%
上拉电压必须为此
AVDD5V_CD
R135
47K/0402/5%
MHL
功能，
R709/R710
HDMI0-SCL
HDMI0-SDA
R136
10K/0402/5%
R140 33R/0402/5%
R142 33R/0402/5%
的上拉可为
MHL_CD_SENSE
HDMI1-SDA
,SCL
HDMI2/5V,
C96
47nF/0402/16V
电阻必须
HDMI3-HPD
上拉电阻
HDMI2-SCL
HDMI2-SDA
电阻值为
R146 100R/0402/5%
R149
300K/0402/5%
平台不需要
300K
HDMI1-HPD
10K
HDMI3/5V
47K
R102
1K/0402/5%
Q10
3904/SOT-23
2 3
HDMI1/5V
R106
10K/0402/5%
1
HDMI0-HPDIN
R114 4.7K/0402/5%
R118
R120
1K/0402/5%
10K/0402/5%
Q11
1
HDMI1-HPDIN
R128 4.7K/0402/5%/NC
3904/SOT-23
2 3
HDMI2-HPD HDMI2-HPDIN
R138 33R/0402/5%
IC内置hotplug
MHL_CABLE-DET
MHL_VBUS-EN
MHL
功能，此部分电路不需要
+5V_Normal
R151
10K/0402/5%
HDMI0-HPDIN
HDMI1-HPDINHDMI1-SCL
电路
R147 10K/0402/5%/NC
5
QA1
AP2181DWG-7
HDMI2-HPDIN
VOUT14/EN
GND
2
3
2
1
HDMI3
HDMI1
HDMI2/5V
/OC3VIN
HDMI2 With MHL
A A
Title
Title
Title
MSD3393
MSD3393
MSD3393
Size Document Number Rev
Size Document Number Rev
Size Document Number Rev
HDMI Interface
HDMI Interface
HDMI Interface
D
D
D
Date: Sheet of
Date: Sheet of
5
4
3
2
Date: Sheet of
1
7 9Saturday, June 08, 2013
7 9Saturday, June 08, 2013
7 9Saturday, June 08, 2013
1.0
1.0
1.0
Page 49
Silicon TUNER
5
4
3
2
1
+3.3V_TU
D D
CON43RCA1_6
3
4
5
6
7
16
17
C C
120pF/0402/50V/NC
1
2
C100
AGND
C98
47nF/0402/16V/NC
AGND
C101
120pF/0402/50V
AGND
10
12
11
C1
C2
1
VDD
9
GND
GND
2
8
RF1
RF2
3
7
GND
GND
GND
RFC
GND
5
6
4
PE42750DS/NC
U9
AGND
R157
0R/0402/5%
AGND
DIF IN&OUT
B B
C120
C122
56pF/0402/16V
100pF/0402/16V
L10 0R/0603/5%
L12 0R/0603/5%
C132
100pF/0402/16V
C123
33pF/0402/16V/NC
C121 0.1uF/0402/16V
R164
510R/0402/5%/NC
C126
IF-IN- VIFM
L9 0R/0603/5%
BPF_IN
L11 0R/0603/5%
C99
0.1uF/0402/16V/NC
AGND
AGND
VIFPIF-IN+
0.1uF/0402/16V
R153
100R/0402/5%/NC
R158
0R/0402/5%
IFN
IFP
C1
C172
270nH/0402/ 5%
+3.3V_TU
C166
C167
1nF/0402/16V
1nF/0402/16V
C168
1nF/0402/16V
AGC RC Filter &I2C
SDA-T
SCL-T
IF_AGC
47pF/0402/16V
L22
180nH/0603/ 5%
20pF/0402/16V/NC
R165 100R/0402/5%
C133
0.1uF/0402/16V
1.2nF/0402/16V
C174
L24
C173 100pF/0402/16V
0R/0402/5%
L23
C183
180pF/0402/16V
+1.8V_TU
C170
1nF/0402/16V
+3.3V_Normal
R16010K/0402/5%
R16110K/0402/5%
R162 100R/0402/5%
R163 100R/0402/5%
C124
C125
20pF/0402/16V/NC
Close MSD IC
IFAGC-T
Close Tuner
2158 FOR LOW SINGER WATER WAVE
2157 CAN CANCLE
L28
L26
270nH/0603/ 5%
270nH/0603/ 5%
C175 180pF/0402/16V
C176 180pF/0402/16V
L25 270nH/0603/ 5%
L29
270nH/0603/ 5%
C171
1nF/0402/16V
TUNER_SDA
TUNER_SCL
IFAGC-T
C178
68pF/0402/16V
+3.3V_TU
L27
600R/0402/500mA
12pF/0402/16V/NC
RF_REF
RF_IP
RF_IN
RF_SHIELD
ADDR
RSTB
AGC1
GND_EPAD
close 20pin
21
+3.3V
GPIO1
1
C1
C169
1nF/0402/16V
22
23
24
25
26
27
28
29
TUNER POWER
U11
ASM1117-3.3_1A
ADJ1OUT2OUT
IN
10uF/0805/16V
3
C1280.1uF/0402/16V
C127
+5V_Normal
24 MHz /ESR< 120 , CL=8pF
C177
C180
C179
68pF/0402/16V
0.1uF/0402/16V
18
19
20
GND
+3.3V
XTAL_O
Si2158
U10
SCL
GPIO22AGC2
4
3
R202
0R/0402/5%
0R/0402/5%
SCL-T
IF_AGC
4
3
Y2
24.000MHz
17
XTAL_I/RCLK
SDA
5
R201
SDA-T
12pF/0402/16V/NC
C181
15
16
XOUT
+1.8V
LDO_ADJ
ALIF_P
ALIF_N
DLIF_P
+3.3V
DLIF_N
+1.8V
GND
+3.3V
7
6
+3.3V_TU
+3.3V_TU
C1290.1uF/0402/16V
C130
10uF/0805/16V
+3.3V_TU
1
14
13
12
11
10
9
8
C131
10uF/0805/16V
R205
3.3R/0402/1%
Q16
+1.8V_TU
3906/SOT-23
3 2
C182
2.2uF/0402/16V
+1.8V_TU
R203 100R/0402/5%
R204 100R/0402/5%
+3.3V_TU
+1.8V_TU
IF-IN+
IF-IN-
A A
Title
Title
Title
Size Document Number Rev
Size Document Number Rev
Size Document Number Rev
C
C
C
Date: Sheet of
Date: Sheet of
5
4
3
2
Date: Sheet of
MSD3393
MSD3393
MSD3393
Tuner
Tuner
Tuner
1
1.0
1.0
8 9Thursday, June 20, 2013
8 9Thursday, June 20, 2013
8 9Thursday, June 20, 2013
1.0
Page 50
5
4
+12V_NORMAL
3
2
1
C161
C143
220nF/0603/50V
C146
220nF/0603/50V
C153
220nF/0603/50V
C158
220nF/0603/50V
CA1
+
100uF/35V/ECS-5M
L13
0R/1206/5%
VCC-AMP
L14
22uH/2.7A/NC
L15 0R/1206/5%
L16
22uH/2.7A/NC
L17 0R/1206/5%
L18
22uH/2.7A/NC
L19 0R/1206/5%
L20
22uH/2.7A/NC
L21 0R/1206/5%
21
C137
220nF/0805/50V
21
C145
220nF/0805/50V
21
C152
220nF/0805/50V
2
1
21
2X2.5MM
C160
220nF/0805/50V
P3
PHONEJACK STEREO 180D
1
2
3
4
1
2
CON3
CON2
2X2.0MM
+5V_Normal
R198
100K
U13
PH-Lout
CA24 100uF/16V
+
AV_AUOUTL1
AV_AUOUTL1
PH-Lout
PH-Rout
MUTE_AMP
MUTE_EAR PH-Rout
C311 2.2uF
R211 100
C59
2.2uF
1
OUT1
2
MUTE
3
IN1
GND4IN2
BH3544
OUT2
8
VCC
7
6
BIAS
5
CA18
47uF/16V
D198
1N4148
+
CA25 1 00uF/16V
AV_AUOUTR1
C312 2.2uF
R210 100
+
+
CA19
47uF/16V
AV_AUOUTR1
PVCCL
PVCCL
OUTPL
PGND
OUTNL
BSNR
OUTNR
PGND
OUTPR
PVCCR
PVCCR
BSPL
BSNL
BSPR
C135
28
27
26
25
24
23
22
21
20
19
18
17
16
15
VCC-AMP
0.1uF/0402/16V
0.1uF/0402/16V
D D
LINEOUT_APML
LINEOUT_APMR
C C
B B
R246
100K
A A
R166 150R/0402/ 5%
R189 150R/0402/ 5%
1N4148
D4
+
100uF/16V
AU. AMP
2.2nF/0402/50V/NC
2.2nF/0402/50V/NC
+5V_Normal+12V_NORMAL
R285
NC\0
R248
470
R247
Q22
0
MMBT3906
CA55
AMP-MUTE
2
C164
0.1uF/0402/16V
R171
C138
47K/0402/5%
C136
0.1uF/0402/16V
C156
R185
47K/0402/5%
R284
0\NC
R283
470
PWD_MT MUTE_EAR
+5V_Standby
4.7K/NC
R310
H: MUTE, L: UN-MUTE
L1
R1
D6
1N4148
D7
BAV70
R287 10K
R299
47K
R179
22K/0402/5%/NC
VCC-AMP
R183
R186
R184
22K/0402/5%
22K/0402/5%/NC
R286 10K
R293
47K
MUTE_AMP
1
2 3
R190
1uF/0603/16V
22K/0402/5%
10R/0402/5%
Q25
3904
C154
1uF/0603/16V
R172 1K/0402/5%
MUTE_AMP
R175 150R/0402/ 5%
R187 4.7K/0402/5%
R191
C157
3K/0402/5%
1uF/0603/16V
1
Q24
3904
2 3
C163
L1
R192
150R/0402/5%
C144
C155
1uF/0603/16V
+12V_NORMAL
R169
100K/0402/5%
220nF/0402/10V
C159
220nF/0402/16V
R1
TPA3110
R167
100K/0402/5%
U12
1
1
PVCCL
SD
2
FAULT
3
LINP
4
LINN
5
GAIN0
6
GAIN1
7
AVCC
8
AGND
9
GVDD
10
PLMIT
11
RINN
12
RINP
13
NC
14
PBTL
GVDD
29
IC-TPA3121D2_0
Title
Title
Title
Size Doc ument Number Rev
Size Doc ument Number Rev
Size Doc ument Number Rev
Custom
Custom
Custom
Date: Sheet of
Date: Sheet of
5
4
3
2
Date: Sheet of
MSD3393
MSD3393
MSD3393
Amplifier
Amplifier
Amplifier
1
1.0
1.0
9 9Thursday, June 20, 2013
9 9Thursday, June 20, 2013
9 9Thursday, June 20, 2013
1.0
Loading...