Simplicity 1692975, 1692961, 1692959, 1692963, 1692973 User Manual

...

PERATOR

’

PECIAL

EDIT

EGENT

ANUAL

ION

“TEAM”

Vikings Regent Tractor

Mfg. No. 1692957 Mfg. No. 1692967

Steelers Regent Tractor Hawkeyes Regent Tractor

Mfg. No. 1692959 Mfg. No. 1692969

Panthers Regent Tractor Wolverines Regent Tractor

Mfg. No. 1692961 Mfg. No. 1692971

Chiefs Regent Tractor Spartans Regent Tractor

Mfg. No. 1692963 Mfg. No. 1692973

Colts Regent Tractor Nittany Lions Regent Tractor

Mfg. No. 1692965 Mfg. No. 1692975

With 38” Mower Decks

RACTORS

Badgers Regent Tractor

Mfg. No. 1692358

Trim Installation

Face Mask installation:

Position the face mask onto

the unit with the hook in the

middle grille slot, and line up with the holes on the

outside of the side panels

(note that the front of the face mask must be in the “V” position for proper fit.)

Insert one Carriage Bolt through each of the two

mounting holes at the rear of the face mask, and into the side panels.

Place one washer onto each Carriage Bolt from the

inside of the panel.

Thread one Nut onto each Carriage Bolt.

Check that the Face Mask is in the proper position and

orientation.

Tighten the Nuts securely.

Hook from Face Mask goes into middle

NOTE: “V” positioning

gri//e

s/o’\

-I\\-

Carriage Bolt

Decal 81 Paint Information

Tractor Description Mfg. No.

Vikings Regent Tractor 1692957

Steelers Regent Tractor 1692959 Panthers Regent Tractor Chiefs Regent Tractor Colts Regent Tractor 1692965 Badgers Regent Tractor

Hawkeyes Regent Tractor

Wolverines Regent Tractor 1692971

Spartans Regent Tractor

Nittany Lions Regent Tractor

NOTE ON PAINT COLORS: Standardized paint coding schemes are not given because the paint colors used on

your Special Edition Regent “Team” Tractor were matched directly (via a sophisticated color analysis system) to the

exact colors on team helmets. If it becomes necessary to repaint a scratched or damaged portion of your unit, your local paint service

NOTE ON DECALS: For a limited time, replacement decal sets may be ordered from your local Simplicity dealer.

will need to do a similar color analysis from a clean portion of a body panel or hood.

1692961 1692963

1692967 1692969

1692973 1692975

Base Color Accent Color Mask Color

Viking Purple Gloss Black

Panthers Silver Pro Blue Black Chiefs Red Chiefs White Chiefs White Colts White Colts Blue Colts Blue

Badger White Badger Red Badger Red Gloss Black Wolverine Blue Wolverine Yellow Wolverine Blue Spartan Green Spartan White Lions Blue Lions White

Viking White

Viking Purple

Steelers Yellow Black

Hawkeye

Yellow Gloss Black

Spartan White Lions Blue

FormNo.

0 Copylight ,996 simplici~ Man"f?.ti"ring,

AU Rights

TP LOO-20L3-03-RG-S

msened.

FIB". 3/w

Printed I" USA.

Inc.

(SM)

Table Of Contents

TRACTOR&MOWER IDENTIFICATION.. SAFETY RULES

DECALS.. ......................................................................

FEATURES & CONTROLS

Controls-Hydro Models.. .................................................... .6

Controls -Gear Models.. ....................................................... 6

OPERATION..

General.. .............................................................................. .7

Safety Interlock System.. ...................................................... 7

Mower Installation & Removal.. .......................................... .8

Adjusting Mower Height ......................................................

Checks Before Starting ........................................................

Clutch/Brake Pedal-Gear Models.. ....................................

Parking Brake.. ....................................................................

Starting The Engine..

Driving The Tractor

Stopping the Tractor.. ........................................................

Pushing the Tractor by Hand

............................................................3

...........................................

...............................................................

...........................................................

...............................................................

............................................

..................

.lO

.10

TROUBLESHOOTING&REPAIR..

General.. ............................................................................

Troubleshooting The Tractor ............................................. .18

Troubleshooting The Mower.. ............................................ .lQ

Checking the Battery .......................................................... 19

Q .Q .Q .Q

Charging A Completely

Discharged Battery.. .......................................................

Jump Starting with

Auxiliary (Booster) Battery.. ............................................ .20

ADJUSTMENTS21...........................................................

Seat Adjustment ................................................................ ,21

Brake Adjustment ............................................................. .21

Neutral Adjustment

Forward Speed Adjustment -Hydro .................................. .22

Neutral Adjustment-Gear.. ............................................... .23

Steering Gear Adjustment ................................................. .23

Mower Adjustments ...........................................................

Leveling The Mower........................................................ .23

Blade Brake Check........................................................... 24

Hydro ............................................... ,22

............................ .18

.I8

.23

MOWING PATTERN & TIPS

NORMAL CARE

Schedule.. .......................................................................... .13

Raising the Hood

Checking/Adding Gasoline ................................................

Checking Tire Pressure.. ................................................... .14

Checking the Fuel Filter.. ...................................................

Lubrication ......................................................................... .14

Transaxle-Hydro Models.. ................................................

Battery Maintenance.. ........................................................

Checking Battery Fluid.................................................... .15

Cleaning the Battery and Cables.. ................................... 15

Servicing the Mower Blades............................................... 16

STORAGE

Temporary Storage.. .......................................................... .17

Long TenStorage.. ..........................................................

Starting After Storage.. ........................ :..‘:.

......................................................... .13

& Seat ..................................................

..................................................................

.......................................

.......................

.I3 .I3

.I4

.I5

.I7

.I7 .I7

BELT REPLACEMENT.. .............................................

Tractor Drive Belt ...................................................25

Mower Deck Belt.. ..................................................25

SPECIFICATIONS.. .....................................................

PARTS&ACCESSORIES..

Replacement Pads ............................................................ .27

Maintenance Items ............................................................

Optional Accessories.. ....................................................... .27

Technical Literature ........................................................... .27

INTERNATIONAL SYMBOLS..

NOTE: In this manual, seen from the operating position.

Engine exhaust from this product contains chemi-

birth defects, or other reproductive harm.

........................................

....................................

“/eW

and “right” are referred to as

.25

.26

.27

TP L00-20L3-03-RG-SnA

Tractor & Mower Identification

IDENTIFICATION NUMBERS

Record your model name/number, tractor and mower deck manufacturer numbers and engine serial number in the space provided for easy reference.

The Tractor I.D. tag is located on the left-side, of the frame, as shown below.

The Mower Deck I.D. tag is also on the left side, on top of the mower deck.

For location of Engine Owner’s Manual.

Be sure to fill out and return the Warranty Registration

Card supplied with your tractor.

Engine Serial Number,

refer to the

Tractor M/N (Manufactureh

Mower Deck M/N (Man”m”rels N”nlW

Dealer Name

Number)

SIN

(Serial Number)

S/N

(Serial Number)

oaw Purchased

il~~~~~~~~~~~~~~~~~~~~~~~~~~~~~

Engine

Make/Model Engine Iwserial Number

Tractor

Identification Ta

Figure 1. Identification Tags Location

..-..-. -““..

Identification Tag

Safety Rules

Read these safety rules and follow them closely. Failure to obey these rules could result in loss of control of unit, severe personal injury or death to you, or bystanders, or damage to property or equipment. This mow-

ina deck is caDable of amoutatina hands and feet and throwina obiects. The triangle a in text signi-

fies important cautions or warnings which must be followed.

GENERAL OPERATION

l Read, understand, and follow all instructions in the

manual and on the unit before starting.

l Only allow responsible adults, who are familiar with

the instructions, to operate the unit.

l Clear the area of objects such as rocks, toys, wire,

etc., which could be picked up and thrown by the blade(s).

l Be sure the area is clear of other people before mow-

ing. Stop unit if anyone enters the area.

l Never carty passengers. l Do not mow in reverse unless absolutely necessary.

Always look down and behind before and while

elling in reverse.

l Be aware of the mower discharge direction and do

not

point it at anyone. Do not operate the mower

without either the entire grass catcher or the deflector

in place.

l Slow down before turning. l Never leave a running unit unattended. Always

disengage the PTO, set parking brake, stop engine, and remove keys before dismounting.

l Turn off the PTO switch to disengage the blades

when not mowing.

l Stop engine before removing grass catcher or

unclogging chute.

l Mow only in daylight or good artificial light. l Do not operate the unit while under the influence of

alcohol or drugs.

l Watch for traffic when operating near or crossing

roadways.

l Use extra care when loading or unloading the unit

into a trailer or truck.

trav-

WARNING

Never operate on slopes greater than 30 percent

SLOPE OPERATION

(16.7”) which is a rise of three feet vertically in 10 feet horizontally. When operating on slopes that are greater than 15 percent (6.5”) but less than 30 percent

use front counterweights and rear wheel weights (see your dealer). Select slow ground speed before driving onto slope. In addition to front and rear weights, use extra caution when operating on slopes with

mounted

never

orass

a&ss

catcher. Mow UP and DOWN the

the face, use caution when changing

rear-

slooe.

directions and DO NOT START OR STOP ON SLOPE.

l See your authorized dealer for recommendations of

wheel weights or counterweights to improve stability.

l Mow up and down slopes, not across. l Remove obstacles such as rocks, tree limbs, etc. l Watch for holes, ruts, or bumps. Uneven terrain could

overturn the unit. Tall grass can hide obstacles.

l Use slow speed. Choose a low gear so that you will

not have to stop or shift while on the slope.

l Use extra care with grass catchers or other attach-

ments. These can change the stability of the unit.

l Keep all movement on the slopes slow and gradual.

Do not make sudden changes in speed or direction.

Do Not

l Do notstart or stop on a slope. If tires lose traction,

disengage the blade(s) and proceed slowly straight down the slope.

l Do

notturn on slopes unless necessary, and then,

turn slowly and gradually downhill, if possible.

l Do not mow near drop-offs, ditches, or embank-

ments. The mower could suddenly turn over if a wheel is over the edge of a cliff or ditch, or if an edge caves in.

SLOPE OPERATION

l Do not mow on wet grass.-Redmed traction could

cause sliding.

Slopes are a major factor related to loss-of-con&l and

tip-over accidents, which can result in severe injury or

death. All slopes require extra caution. If you cannot back up the slope or if you feel uneasy on it, do not mow it.

l Do nottty to stabilize the unit by putting your foot on

the ground.

l Do not use grass catcher on steep slopes.

Safety Rules

CHILDREN

Tragic accidents can occur if the operator is not alert to the presence of children. Children are often attracted to the unit and the mowing activity. Never assume that chil-

dren will remain where you last saw them.

l Keep children out of the mowing area and under the

l Never run a unit in an enclosed area. l Keep nuts and bolts, especially blade attachment

watchful care of another responsible adult.

l Be alert and turn unit off if children enter the area. l Before and during reverse operation, look behind and

down for small children.

l Never carry children. They may fall off and be seri-

ously injured or interfere with safe unit operation.

l Never allow children to operate the unit. l Use extra care when approaching blind corners, shrubs,

l Never tamper with safety devices. Check their proper

l Keep unit free of grass, leaves, or other debris build-

l Stop and inspect the equipment if you strike an

l Never make adjustments or repairs with the engine

trees, or other objects that may obscure vision.

TRANSPORTING AND STORAGE

l Grass catcher components are subject to wear, dam-

A WARNING

When transporting this tractor on an open trailer, make sure unit is facing forward, toward the direction of travel. If tractor is facing backward, wind lift could cause damage to the hood.

l Always observe safe refueling and fuel handling prac-

tices when refueling the tractor after transportation or

storage.

l Always follow the engine manual instructions for

storage preparations before storing the tractor for

both short and long term periods.

l Always follow the engine manual instructions for

proper start-up procedures when returning the unit to

service.

l Never store the unit or fuel container inside where

there is an open flame or pilot light, such as in a water heater. Allow unit to cool before storing.

SERVICE AND MAINTENANCE

l Use extra care in handling gasoline and other fuels.

They are flammable and vapors are explosive.

a) Use only an approved container.

l Mower blades are sharp and can cut. Wrap the

l Check brake operation frequently. Adjust and service

l Use only factory authorized replacement parts when

l Always comply with factory specifications on all

l Only authorized service locations should be utilized

l Never attempt to make major repairs on this unit

b) Never remove gas cap or add fuel with the engine

running. Allow engine to cool before refueling. Do not smoke.

c) Never refuel the unit indoors.

bolts, tight and keep equipment in good condition.

operation regularly.

up. Clean up oil or fuel spillage.

object. Repair, if necessary, before restarting.

running unless specified otherwise in the engine manufacturer’s manual.

age, and deterioration, which could expose moving

parts or allow objects to be thrown. Frequently check

components and replace with manufacturer’s recom-

mended pans, when necessary.

blade(s) or wear gloves, and use extra caution when servicing them.

as required.

making repairs.

settings and adjustments.

for major service and repair requirements.

unless you have been properly trained. Improper ser-

vice procedures can result in hazardous operation,

equipment damage and voiding of manufacturers

warranty.

Never place hands near the hydro-pump cooling

fan when the tractor is running. Cooling fan is

located on top of transaxle on hydro models.

Safety Decals

GENERAL

This unit has been designed and manufactured to provide you with the safety and reliability you would expect from an industry leader in outdoor power equipment

manufacturing.

Although reading this manual and the safety instructions

it contains will provide you with the necessary basic knowledge to operate this equipment safely and effec-

tively, we have placed several safety labels on the unit to

remind you of this important information while you are operating your tractor.

All WARNING, CAUTION and instructional messages on your tractor and mower should be carefully read and obeyed. Personal bodily injury can result when these instructions are not followed. The information is for your safety and it is important! The safety decals below are on your tractor and mower.

If any of these decals are lost or damaged, replace them

at once. See your local dealer for replacements.

These labels are easily applied and will act as a constant

visual reminder to you, and others who may use the equipment, to follow the safety instructions necessary for safe, effective operation.

Decal - Danger Part No. 1704276 (top decal) Part No. 1704277 (bottom decal)

Decal - Hydro Release Valve Part No. 1706916

‘,

Decal - Operating Instructions Part No. 1716530

Features & Controls

CONTROLS

Steering Wheel

3. Engine Throttle Control

Parking Brake Knob

Ignition Key/Switch

Headlight Switch

PTO (Electric Clutch) Switch

Mower Height Adjustment Lever

Brake Pedal

Forward Direction Pedal

Rear Direction Pedal

HYDRO MODEL

Figure 2. Tractor & Mower Controls -

Hydra

CONTROLS - GEAR MODEL

A. Steering Wheel B. Engine Throttle Control C. Parking Brake Knob D. Ignition Key/Switch E. Headlight Switch F. PTO (Electric Clutch) Switch G. Mower Height Adjustment Lever H. Clutch/Brake Pedal

Gear Selector

Model

Figure 3. Tractor & Mower Controls

Gear Model

+ 22 hidden pages