Page 1
BROADMOOR SERIES PARTS MANUAL
12.5H Mfg. No. 1692261
14H Mfg. No. 1692279
15G Mfg. No. 1692287
16H Mfg. No. 1692283
38" Mower Mfg. No. 1691704
44" Mower Mfg. No. 1691705
Page 2
Product Identification:
When ordering parts, keep your products serial number and manufacturer's number in mind. Variations may occur in a part between early & later model products, causing the product serial number to be listed in the parts description whenever these variations occur.
Record your I.D. numbers here for quick, future reference,
Product Mfg. No. ______ S/N _____ Mower Mfg. No. _____ S/N _____
Attention:
Standard torques appear in a chart at the end of the manual, while important individual torques are given on specific parts drawings.
CRETICAL and MAJOR notations point out important facts or instructions which relate to personal safety and proper machine operation. Any CRITICAL notation is which may appear in this book, pinpoints characteristics which, if not properly followed, can create a safety hazard. Any MAJOR notation is which may appear in this book, marks characteristics which, if not properly followed, followed, may result in operating failure, shortened product life, or greatly reduced quality of the unit. For your convenience, assembly notes are included in parts drawings to assist in repair and assembly of unit.
SIMPLICITY BRAND PRODUCTS
OILS - SPECIFICALLY BLENDED OF HIGH QUALITY BASE OILS & ADDITIVES.
Special Worm Gear OII: Required for protection of brass gears and mating parts.
Cold Weather Worm Gear Oil for snowthrowers with worm gear drive. 8 Oz. Bottle, Part #1704636, Case of 12-8 Oz. Bottles, Part #1685406.
Multi-Purpose Hydraulic/Transmission Oil for use in most hydraulic applications, and hydrostatic transmissions. Specific Simplicity applications: All hydrostatic transmissions, all bevel gear cases. Case of 12 Quarts, Part #1685516, 2-1/2 Gallon Container, Part #1685539.
SAE 5W-30 SF/CD Cold Weather Engine Oil for use in all four cycle and diesel engines at 30° temp. and under. Case of 12 quarts, Part #1685576.
SAE 15W-40 SF/CD Engine OII for gas and diesel engines, warm weather; see engine manufacturer recommendations. Case of 12 quarts, Part #1685554.
SAE 30W SG/CC Detergent Engine Oil for use in four cycle lawn and garden engines at operating temp. of 32° and abova. Also recommended for use in hydrostatic transmissions where 30W oil is specified. Case of 12 quarts. Part #1685659.
DEGREASER, DEGRIMER, PARTS CLEANER removes grease.
oil, dirt and grime without harming paint or decals.
| 1 Ouart w/Trigger Spray | 1685619 |
|---|---|
| 1 Gallon Bottle | 1685621 |
| Extension Sprayer for | |
| Gallon Bottle | 1685623 |
TOUCH-UP PAINT keeps equipment in showroom condition.
| Spray Саль | Quarts | Daubers-12 Per Ctn. |
|---|---|---|
| Far Products Built After 8 | V1/89. | |
|
"Deep Orange"
13 Oz. Can 1685811 Case 12 Cans 1685614 |
1685612 |
1685616 Mixed
6 Deep Or., 6 White 1/2 Oz. Bottles |
|
"Gloss Black"
13 Oz. Can 1685639 Case 12 Cans 1685640 |
1685641 | N/A |
|
"White"
13 Oz. Can 103049 Case 12 Cans 1685178 |
1685032 | See Above |
Consult decal on equipment for proper color.
AVAILABLE ACCESSORIES:
DESIGNER SEAT COVERS are double stitched, easy care vinyl. Keeps new seats new, makes worn seats look new.
Small Seat Cover w/Pocket, Part #1685540. Fits all Rear Engine Riders, FC, RT Series Tractors.
Large Seat Cover w/Pocket, Part #1685541. Fits all 12.5 & 16 LT and GT Series Tractors.
Seat Cover, Part #1685577. Fits all 18 & 20 GTH Tractors.
PNEUMATIC TIRE SEAL seals all leaks including bead leaks and punctures up to 3/16 inch diameters. Prevents flats for tread life of tire. Available in following amounts.
| Case of 12 -11 Oz. Tubes | 1685537 |
|---|---|
| Case of 24 -11 Oz. Tubes | 1685525 |
| 5 Gallon Pall | 1685527 |
HOUR METER KIT, Part #1685535.
GREASE GUN KIT has 12" flexible hose to get into tight spots with ease. Kit contains: gun and 1-8 Oz, tube of grease. Part #1685510. For replacement tube, order Part #103077.
CHROME "Moon" Hubcaps
| 4" Rìm | 163114 |
|---|---|
| 6" Füm | 156210 |
| 8" Rim | 156211 |
| 10° Rím | 1667782 |
| 12" Rim | 154505 |
Extend Equipment Life - Use Only Genuine Simplicity Parts & Accessories Available at Your Local Simplicity Dealer
Page 3
Table of Contents
Page 4
NOTE: Use standard hardware torque specifications chart unless otherwise noted.
Page 5
Frame & Front Axle Group
| Ref. | Part | ||
|---|---|---|---|
| No. | No. | Qty. | Description |
| 1 | 1704310 | 1 | PAD, Footrest, R.H. |
| 2 | 1934654 | 4 | CAPSCREW, Hex, Flange, Whizlock, 3/8-16 x 1 |
| 3 | 1703968 | 2 | SUPPORT, Seat |
| 4 | 1919439 | 4 | NUT, Hex, Esna Lock, 3/8-16 |
| 5 | 1707488 | 1 | PLUG |
| 6 | 1709883 | 1 | FRAME ASSY. |
| 7 | 1704351 | 12 | FASTENER, Panel (Qty. 12 on Hydro) |
| 8 | 1704311 | 1 | PAD, Footrest, L.H. |
| 9 | 176440 | 4 | BUSHING |
| 10 | 1704314 | 2 | GREASE, Fitting |
| 11 | 1704153 | 2 | WASHER, Special |
| 12 | 1703475 | 1 | AXLE ASSY., Front |
| 13 | 1704150 | 1 | AXLE PIVOT ASSY. |
| 14 | 1960270 | 1 | NUT, Hex, Fuli, Lock, 3/4-16 |
Page 6
Page 7
| All | Mod | eis |
|---|---|---|
Steering Group
|
Ref.
No. |
Part
No |
Otv | Description |
|---|---|---|---|
| Beachpilon | |||
| 1 | 1923362 | 1 | NUT, Hex, Lock, 5/16-18 |
| 2 | 1919326 | 2 | WASHER, Steering Wheel |
| 3 | 1657017 | 1 | CAP, Steering Wheel |
| 4 | 1701197 | 1 | STEERING WHEEL |
| 5 | 1925690 | 1 | CAPSCREW, 5/16-18 x 3-1/2 |
| 6 | 1707321 | 1 | SHAFT ASSY., Steering |
| 7 | 1919314 | 1 | COTTER PIN |
| 8 | 1960114 | 7 | WASHER, Plain, 49/64 |
| 9 | 173668 | 1 | WASHER, Plain |
| 10 | 1931350 | 2 | CARRIAGE BOLT, 3/8-16 x 1 |
| 11 | 1703508 | 1 | PLATE, Mounting, Steering |
| 12 | 176440 | 3 | BUSHING, Nylon |
| 13 | 1930645 | 2 | NUT, Hex, Flange, 3/8-16 |
| 14 | 1922755 | 3 | WASHER |
| 15 | 1928352 | 2 | NUT, Hex, Elange, Whizlock, 3/8-16 |
| 16 | 1673796 | 1 | SPACEB. Stop |
| 17 | 1921969 | 2 | CAPSCREW, Hex Hd. 3/8-16 x 1-1/2 |
| 18 | 1919438 | 1 | NUT Hex Esnal ock 5/16-18 |
| 19 | 1685478 | i | DBAG LINK ASSY. |
| • | (Incl. Bef Nos. 14, 13, 17, 20, 21 & 22) | ||
| 20 | 1702779 | 2 | BALL (OINT Flat |
| 21 | 1919262 | 2 | JAM NUT Hey 1/2-20 |
| 22 | 1708084 | 1 | DRAG LINK |
| 23 | 1707450 | , | SPINDLE ASSY Spliped |
| 24 | 1960373 | 2 | SCREW Tentite 5/16-18 v 1 |
| 25 | 1703813 | 1 | SECTOR MOUNTING PLATE |
| 26 | 1703513 | ÷ | GEAR ASSY Steering |
| 27 | 1921221 | i | CAPSCREW Hay 5/16-18 x 1-1/2 |
| 28 | 930670 | i | |
| 20 | 1706056 | ÷ | |
| 20 | 1021250 | ||
| 24 | 1611705 | 2 | |
| 30 | 1020645 | 2 |
SEAVEN
NUT Hey Lock Flance 2/8 18 |
| 32 | 1206006 | 2 |
NUT, NEX, LUCK, Flange, 3/0-10
ADM ASSY, Stearing D.H., Selfred |
| 24 | 100990 | 1 | |
|
94
95 |
1920721 | 2 |
SEISCHEW, SQ. HO., S/16-18 X 1/2
STEEDING ADM ACCV J. U. Colleged |
| 20 | 1700387 | DITAAN ADA ASSY. L.N., Spined | |
| 27 | 1703012 | FILMAN ARM ASSY. | |
| 20 | 170/320 | 1 | |
| 20 | 104420 | 2 | |
|
38
40 |
1300020 | 2 | |
| 40 | 1000230 | 2 |
JEAUER
MACHED |
| 41 | 1900114 | 2 | WADNEM Hubber |
| 42 | 1701435 | 2 | |
| 43 | 2 | ||
| 44 | 16/6519 | 2 | |
| 45 | 1960160 | 2 | WASHER, Special (Hydro models only) |
Page 8
Engine & Electric Clutch Group - 14 HP Single Cylinder Kohler
Page 9
Engine & Electric Clutch Group - 14 HP Single Cylinder Kohler
| Ret. | Part | ||
|---|---|---|---|
| No. | No. | Qty. | Description |
| 1 | 1713305 | 1 | CABLE. Throttle |
| 2 | 1930531 | 1 | SCREW, Trusshead, 10-32 x 1/2 |
| з | 1931338 | 1 | CARRIAGE BOLT, 5/16-18 x 1-3/4 |
| 4 | 1685699 | 1 | HANDLE. Throttle (Incl. Bef. No. 5) |
| 5 | 1708538 | 1 | KNOB. Throttle |
| 6 | 960171 | 2 | WASHER, Nylon |
| 7 | 158475 | 1 | CLIP Bowden Wire |
| 8 | 1704332 | ł | SPACER |
| 9 | 1928919 | í | NUT ASSY., 10-32 |
| 10 | 1921961 | ſ | CAPSCREW Hey 1/4-20 x 1-1/4 |
| 11 | 1960256 | á | SCREW Plastite 1/4-20 v 5/8 |
| 12 | 1704335 | ĩ | BBACKET. Throttle Mounting |
| 13 | 101025 | i | WASHER |
| 14 | 162085 | SPRING | |
| 15 | 1919381 | 5 | WASHER Plain 5/16 |
| 16 | 1917356 | 8 | LOCKWASHER 5/16 |
| 17 | 1917372 | 1 | NUT Full Hey 5/16-18 |
| 18 | 1916622 | 2 | NUT Full Hey 1/4-20 |
| 19 | 1916964 | 1 | LOCKWASHER 1/A |
| 20 | 1704333 | i | PLATE Soring |
| 21 | 1960112 | 2 | CI AMD Hosp |
| 22 | 1703956 | 1 | |
| 23 | 1676861 | ||
| 24 | * | - | ENCINE Value |
| 26 | 171041 |
Engine, Roher
Vev |
|
| 26 | 171241 | - | |
|
20
07 |
1704410 | 5 | |
| 28 | 1672452 | ~ | |
| 20 | 1060405 | ÷ | SOREN Territe M0.1.1/4 00 |
| 20 | 1702816 | 4 | |
| 21 | 1703010 | , i | ECEUTRIC OLUTION (INCL. RET. NOS, 51-53) |
| 20 | 060470 | 4 | CARCERSIA MICH (20 CO ana |
| 22 | 1019100 | ſ | |
| 20 | 1210135 | ſ | |
| 25 | 1000000 | 1 | |
|
30
90 |
1900300 | 4 | MUEELED ADDX |
| 07 | 1703971 | 1 | |
| 30 | 1930200 | 4 | |
|
30
20 |
1931342 | 1 | CAMMIAGE BUL 1, 5/16-18 X 2-3/4 |
| 40 | 10/0103 | 1 | |
| 40 | 1705047 | 1 | PIPE, Exnaust |
| 41 | 1919326 | 2 | WASHER, Plain, 5/16 |
| 42 | 1921333 | 1 | CAPSCREW, Hex, 5/16-18 x 1 |
| 43 | 1705440 | 1 | DUC1, Top, Mutter |
| 44 | 934683 | 2 | |
| 45 | 1960295 | 4 | SCHEW, Flange Whizlock, 1/4-20 x 5/8 |
| 46 | 173206 | 1 | FUEL FILTER |
| 4/ | 1667346 | 1 | |
| 48 | 1901491 | 1 | PIPE NIPPLE, 3/8 x 2 |
| 49 | 1705358 | 1 | FASTENER, Panel |
| 50 | 920426 | 1 | LOCKWASHER, External Tooth, 5/16 |
| 51 | 1679104 | 1 | SPHING & NUT KIT |
| 52 | 1679101 | 1 | FIELD ASSY., Clutch |
| 53 | 1685486 | 1 | ROTOR & ARMATURE ASSY, |
| 54 | 1919438 | 1 | NUT, Hex, Esna Lock, 5/16-18 |
*See your local Kohler Distributor for parts and service.
Page 10
Page 11
Engine & Electric Clutch Group - 15 HP Single Cylinder Briggs & Stratton
| Ref. | Part | ||
|---|---|---|---|
| No. | No. | Qty. | Description |
| 1 | 1713305 | 1 | CABLE, Throttle |
| 2 | 1930531 | 1 | SCREW, Trusshead, 10-32 x 1/2 |
| 3 | 1931338 | 1 | CARRIAGE BOLT, 5/16-18 x 1-3/4 |
| 4 | 1682699 | 1 | HANDLE, Throttle (Incl. Ref. No. 5) |
| 5 | 1708538 | 1 | KNOB, Throttle |
| 6 | 960171 | 2 | WASHER, Nylon |
| 7 | 158475 | 1 | CLIP, Bowden Wire |
| 8 | 1704332 | 1 | SPACER |
| 9 | 1928919 | 1 | NUT ASSY., 10-32 |
| 10 | 1922837 | 1 | CAPSCREW, Hex, 1/4-20 x 1-1/2 |
| 11 | 1960256 | 3 | SCREW, Plastite, 1/4-20 x 5/8 |
| 12 | 1704335 | 1 | BRACKET, Throttle Mounting |
| 13 | 101025 | 1 | WASHER |
| 14 | 162085 | 1 | SPRING |
| 15 | 1919381 | 1 | WASHER, Plain, 5/16 |
| 16 | 1930598 | 3 | SCREW, Hex, Washer Hd., Taptite, 3/8-16 x 1-1/2 |
| 17 | 1917372 | 1 | NUT, Hex, Full, 5/16-18 |
| 18 | 1916622 | 2 | NUT, Hex, Full, 1/4-20 |
| 19 | 1916964 | 1 | LOCKWASHER, 1/4 |
| 20 | 1704333 | 1 | PLATE, Spring |
| 21 | 1960112 | 2 | CLAMP, Hose |
| 22 | 1708405 | 1 | VALVE, Oil Drain |
| 23 | 1708549 | 1 | HOSE, Fuel, 38" Long |
| 24 | * | 1 | ENGINE, Briggs & Stratton |
| 25 | 171241 | 1 | KEY |
| 26 | 1705441 | 1 | PULLEY ASSY. |
| 27 | 1704419 | 2 | BELT STOP |
| 28 | 1917356 | 4 | LOCKWASHER, 5/16 |
| 29 | 1927187 | 1 | SCREW, Hex, Washer Hd., Taptite, 3/8-16 x 1 |
| 30 | 1703816 | 1 | ELECTRIC CLUTCH (Incl. Ref. Nos. 51-53) |
| 31 | 1708264 | 1 | WASHER, Hex |
| 32 | 1960370 | 1 | CAPSCREW, 7/16-20 x 2-1/2 |
| 33 | 1918199 | 1 | LOCKWASHER, 7/16 |
| 34 | 1704357 | 1 | DUCT, Lower Muffler |
| 35 | 1960368 | 4 | PAL NUT, 1/4-20 |
| 36 | 1703971 | 1 | MUFFLER ASSY. |
| 37 | 935255 | 1 | PAL NUT, 5/16-18 |
| 38 | 1931342 | 1 | CARRIAGE BOLT, 5/16-18 x 2-3/4 |
| 39 | 1676183 | 1 | CLAMP, Muffler |
| 40 | 1713302 | 1 | PIPE, Exhaust |
| 41 | 1919326 | 2 | WASHER, Plain, 5/16 |
| 42 | 1921333 | 1 | CAPSCREW, Hex, 5/16-18 x 1 |
| 43 | 1713300 | 1 | DUCT, Top, Muffler |
| 44 | 934683 | 2 | CLIP |
| 45 | 1960295 | 4 | SCREW, Flange Whizlock, 1/4-20 x 5/8 |
| 46 | 173206 | 1 | FUEL FILTER |
| 47 | 1924940 | 2 | WASHER, Plain, 3/8 |
| 48 | 1936228 | 2 | CAPSCREW, Soc. Hd., 5/16-18 x 3/4 |
| 49 | 1705358 | 1 | FASTENER, Panet |
| 50 | 920427 | 1 | LOCKWASHER, External Tooth, 3/8 |
| 51 | 1679104 | 1 | SPRING & NUT KIT |
| 52 | 1879101 | 1 | FIELD ASSY., Clutch |
| 53 | 1685486 | í | ROTOR & ARMATURE ASSY. |
| 54 | 1919438 | t | NUT, Hex, Esna Lock, 5/16-18 |
| 55 | 1650670 | 1 | GASKET, Muffler |
*See your local Briggs & Stratton Distributor for parts and service.
Page 12
Page 13
Mfg. Nos.1692261, 1692265 (12.5 HP); 1692283, 1692285 (16 HP)
Engine & Electric Clutch Group - 12.5 & 16 HP Twin Cylinder Briggs & Stratton
| Ref. | Part | ||
|---|---|---|---|
| No. | No. | Qty. | Description |
| 1 | 1666268 | 1 | |
| 2 | 1930531 | 1 | SCREW, Trusshead, 10-32 x 1/2 |
| 3 | 1931338 | 1 | CARRIAGE BOLT, 5/16-18 x 1-3/4 |
| 4 | 1685699 | 1 | HANDLE, Throttle (Incl. Ref. No. 5) |
| 5 | 1708538 | 1 | KNOB. Throttle |
| 6 | 960171 | 2 | WASHER, NMon |
| 7 | 158475 | 1 | CLIP, Bowden Wire |
| 8 | 1704332 | 1 | SPACER |
| 9 | 1928919 | 1 | NUT ASSY., 10-32 |
| 10 | 1704344 | 1 | CABLE, Choke Control |
| 11 | 1960256 | 3 | SCREW, Plastite, 1/4-20 x 5/8 |
| 12 | 1704335 | 1 | BRACKET, Throttle Mounting |
| 13 | 101025 | 1 | WASHER |
| 14 | 162085 | 1 | SPRING |
| 15 | 1919381 | 1 | WASHER, Plain, 5/16 |
| 16 | 1917356 | 2 | LOCKWASHER, 5/16 |
| 17 | 1917372 | 1 | NUT, Hex, Full, 5/16-18 |
| 18 | 1667346 | 1 | CAP, Dil |
| 19 | 1704343 | 1 | DRAIN, OIL |
| 20 | 930598 | 1 | SCREW. Taptite. 3/8-16 x 1-1/2 |
| 21 | 1960112 | 2 | CLAMP, Hose |
| 22 | 1703956 | 1 | SWITCH, Oil Pressure |
| 23 | 1676861 | 1 | HOSE, Fuel, 45-1/2° Long |
| 24 | * | 1 | ENGINE, Twin Cylinder, 16 HP (Bridgs & Stratton) |
| 1 | ENGINE, Twin Cylinder, 12.5 HP (Bridges & Stratton) | ||
| 25 | 171241 | 1 | KEY |
| 26 | 1704307 | 1 | PULLEY ASSY. |
| 27 | 1704419 | 2 | BELT STOP |
| 28 | 1703908 | 4 | SCREW, Metric |
| 29 | 1930598 | 3 | SCREW, Taplite, 3/8-16 x 1-1/2 |
| 30 | 1703816 | 1 | ELECTRIC CLUTCH (Incl. Ref. Nos. 48-50) |
| 31 | 1708264 | 1 | WASHER, Hex |
| 32 | 1960370 | 1 | CAPSCREW, 7/16-20 x 2-1/2 |
| 33 | 1918199 | 1 | LOCKWASHER, 7/16 |
| 34 | 1704357 | 1 | DUCT. Lower Muffler |
| 35 | 1960368 | 4 | PAL NUT. 1/4-20 |
| 36 | 1703971 | 1 | MUFFLER ASSY. |
| 37 | 935255 | 1 | PAL NUT. 5/16-18 |
| 38 | 1931342 | 1 | CARRIAGE BOLT, 5/16-18 x 2-3/4 |
| 39 | 1676183 | 1 | CLAMP. Muffler |
| 40 | 1703986 | 1 | MANIFOLD, Exhaust |
| 41 | 1919326 | 2 | WASHER, Plain, 11/32 |
| 42 | 1921333 | 1 | CAPSCREW, Hex. 5/16-18 x 1 |
| 43 | 1707334 | 1 | DUCT, Upper Muffler |
| 44 | 934683 | 1 | GLIP |
| 45 | 1960295 | 4 | SCREW, Flance Whizlock, 1/4-20 x 5/8 |
| 46 | 920427 | ĩ | |
| 47 | 1924940 | - 2 | WASHER Plain, 13/32 |
| 48 | 1679101 | 1 | FIELD ASSY., Clutch |
| 49 | 1685486 | 1 | BOTOR & ARMATURE ASSY |
| 50 | 1679104 | 1 | |
| 51 | 173206 | i | EUEL FILTER |
| 52 | 1919438 | 1 | NUT, Hex. Esna Lock 5/16-18 |
| - | - |
*See your focal Briggs & Stratton Distributor for parts and service.
Page 14
Page 15
Gear Transmission Group 1 - Peerless Model 801-059
| Ref. | Part | ||
|---|---|---|---|
| No. | No. | Qty. | Description |
| 1 | 1657044 | 1 | "V* BELT |
| 2 | 1705482 | ſ | PULLEY ASSY., Driven |
| 3 | 1928721 | 2 | SETSCREW, 5/16-18 x 1/2 |
| 4 | * | 1 | TRANSMISSION, 5-Speed, Peerless Model 801-059 |
| 5 | 1928352 | t | NUT, Flange Whizlock, 3/8-16 |
| 6 | 1924940 | 5 | WASHER, Plain, 3/8 |
| 7 | 1678924 | 1 | BELT STOP |
| 8 | 1709864 | 1 | BRACKET, Pulley |
| 9 | 1705462 | 2 | SUPPORT, Transmission |
| 10 | 1708029 | 1 | PULLEY, "V" |
| 11 | 1921971 | 1 | CAPSCREW, Hex. 3/8-16 x 1-3/4 |
| 12 | 8221042 | 2 | KEY, 3/16 Sq. x 1-1/2 |
| 13 | 1701435 | 2 | RETAINER, Hubcap |
| 14 | 927794 | 2 | "E" BING |
| 15 | 1676519 | 2 | HUB CAP |
| 16 | 1960114 | 2 | WASHER, Rear Axle (Use as required) |
| 17 | 1667191 | 2 | SPACER, Rear Axle |
| 18 | 1960160 | 2 | WASHER |
| 19 | 1935048 | 4 | NUT, Flange Lock, 5/16-18 |
| 20 | 1919326 | 4 | WASHER, Plain, 5/16 |
| 21 | 1921719 | 4 | CAPSCREW, Hex Hd., 5/16-18 x 2-1/2 |
| 22 | 905123 | 1 | KEY |
| 23 | 1930601 | 4 | SCREW, Taptite, 5/16-18 x 5/8 |
| 24 | 1927557 | 2 | NUT, Hex, Flange, 5/16-18 |
| 25 | 1930591 | 2 | SCREW, Whiz, 5/16-18 x 3/4 |
| 26 | 1930601 | 4 | SCREW, Taptite, 5/16-18 x 5/8 |
*Obtain repair parts from your authorized Peerless/Tecumseb Distributor. Refer to pages 54 - 57 for component parts.
Page 16
Page 17
Gear Transmission Group 2 - Peerless Model 801-059
|
Ref.
No. |
Part
No. |
Qty | Description | |
|---|---|---|---|---|
| 1 | 1921977 | 1 | CAPSCREW, Hex, 5/16-18 x 1-1/4 | |
| 2 | 1922234 | 1 | CAPSCREW, Hex, 1/4-28 x 5/8 | |
| 3 | 1919381 | 2 | WASHER | |
| 4 | 1916964 | 1 | LOCKWASHER, 1/4 | |
| 5 | 1960151 | ۴ | WASHER, Plain, 1/4 | |
| 6 | 1705500 | 1 | LEVER, Shift | |
| 7 | 159106 | 1 | SPRING, External | |
| 8 | 1918447 | 1 | COTTER PIN, 3/32 x 3/4 | |
| 9 | 1709865 | 1 | ROD, Brake | |
| 10 | 1709896 | 1 | GUIDE, Brake Rod | |
| 11 | 1919438 | 1 | NUT, Nylon Lock, 5/16-18 | |
| 12 | 1706553 | 1 | SPRING, External | |
| 13 | 1917372 | 1 | NUT, Hex, Full, 5/16-18 | |
| 14 | 1917356 | 1 | LOCKWASHER, 5/16 | |
| 15 | 1919326 | 2 | WASHER, Plain, 5/16 | |
| 16 | 1709866 | 1 | ROD, Shift | |
| 17 | 1703900 | 1 | SPACER | |
| 18 | 1930651 | 1 | JAM NUT, Centerlock, 3/8-16 | |
| 19 | 1916950 | 1 | NUT, Hex, 3/8-16 | |
| 20 | 1916965 | 1 | LOCKWASHER, Spring, 3/8 | |
| 21 | 1924940 | 1 | WASHER, 3/8 | |
| 22 | 167032 | 1 | BELT STOP | |
| 23 | 1921969 | 1 | CAPSCREW, Hex Hd., 3/8-16 x 1-1/2 | |
| 24 | 1918447 | 2 | COTTER PIN, 15/16 x 3/4 | |
| 25 | 1924361 | 2 | WASHER, 1/2 | |
| 26 | 1709097 | 1 | SPRING, Compression |
*Obtain repair parts from your authorized Peerless/Tecumseh Distributor. Refer to pages 54 - 57 for component parts.
Page 18
Page 19
Mfg. Nos. 1692261, 1692265, 1692279, 1692281, 1692283, 1692285
Hydrostatic Transmission Group 1 - Hydro Gear Model 311-0750
| Ref. | Part | ||
|---|---|---|---|
| No. | No | Qty. | Description |
| 1 | 1686614 | 1 | TRANSAXLE, Hydro Gear Model 311-0750 |
| 2 | 1933958 | 3 | SCREW, Taptite, 1/4-20 x 1-1/8 |
| з | 1707933 | 1 | FAN |
| 4 | 1919262 | 1 | JAM NUT, Hex, 1/2-20 |
| 5 | 1916966 | 1 | LOCKWASHER, 1/2 |
| 6 | 1709786 | 1 | PULLEY ASSY. |
| 7 | 1921319 | 3 | WASHER, Plain, 1/4 |
| 8 | 1921719 | 4 | CAPSCREW, Hex, 5/16-18 x 2-1/2 |
| 9 | 1919326 | 4 | WASHER, Plain, 5/16 |
| 10 | 1960509 | 1 | SCREW, Taptite, #10-24 x 1-1/4 |
| 11 | 1960151 | 1 | WASHER, 1/4 x 1-1/4 x 1/16 |
| 12 | 157127 | 1 | SPRING, Conical |
| 13 | 1922611 | 1 | WASHER, 13/32 x 1-1/4 x 1/16 |
| 14 | 1920397 | 1 | NUT, Hex, Full, Lock, 1/4-20 |
| 15 | 1709902 | 2 | LEVER |
| 16 | 1709901 | 1 | SPACER |
| 17 | 1676519 | 2 | HUB CAP |
| 18 | 927794 | 2 | E-RING, 3/4 |
| 19 | 960202 | 8 | WASHER, 3/4 x 1-5/8 x 1/8 |
| 20 | 1701435 | 2 | RETAINER, Hub Cap |
| 21 | 1667191 | 2 | SPACER |
| 22 | 1935048 | 4 | NUT, Hex, Flange Lock, 5/16-18 |
| 23 | 1927557 | 1 | NUT, Hex, Flange Whiz, 5/16-18 |
| 24 | 1926106 | 1 | CAPSCREW, Hex, 5/16-18 x 3-1/4 |
| 25 | 1931277 | 1 | NUT, Hex, Flange Whiz, 5/16-18 |
| 26 | 1917356 | 1 | LOCKWASHER, 5/16 |
| 27 | 1917372 | 1 | NUT, Hex, Full, 5/16-18 |
| 28 | 1930595 | 1 | CAPSCREW, Hex, Whiz, 5/16-18 x 1-1/4 |
| 29 | 1672135 | 1 | BELT, Drive |
| 30 | 1701011 | 1 | TIE, Cable |
| 31 | 8221042 | 2 | KEY |
Page 20
Page 21
Mfg. Nos. 1692261, 1692265, 1692279, 1692281, 1692283, 1692285
Hydrostatic Transmission Group 2 - Hydro Gear Model 311-0750
| Ref. | Part | ||
|---|---|---|---|
| NO. | NO. | City. | Description |
| 1 | 1917356 | 4 | LOCKWASHER, 5/16 |
| 2 | 1917372 | 4 | NUT, Hex, Full, 5/16-18 |
| 3 | 1930591 | 1 | SCREW, Hex, Whizlock, 5/16-18 x 3/4 |
| 4 | 1919381 | 5 | WASHER, 11/32 x 1 x 1/8 |
| 5 | 1935048 | 2 | NUT, Hex, Flange Lock, 5/16-18 |
| 6 | 1713440 | 1 | TORQUE STRAP |
| 7 | 159106 | 1 | SPRING, Brake Arm |
| 8 | 1709896 | 1 | GUIDE, Rod |
| 9 | 1919438 | 1 | NUT, Hex, Nylon Lock, 5/16-18 |
| 10 | 1709097 | 1 | SPRING |
| 11 | 1918447 | 3 | COTTER PIN |
| 12 | 1924361 | 2 | WASHER, 17/32 x 1-1/4 x 5/64 |
| 13 | 1709791 | 1 | ROD, Brake |
| 14 | 1960251 | 1 | JAMNUT, Hex, Lock, 3/8-16 |
| 15 | 1935159 | 1 | SCREW, Hex, Whizlock, 5/16-18 x 2-1/4 |
| 16 | 1709227 | 1 | SPACER |
| 17 | 1709226 | 1 | LEVER, Control |
| 18 | 1960223 | 2 | CARRIAGE BOLT, 5/16-18 x 1-1/4 |
| 19 | 1709893 | 1 | ROD, Shift, Front |
| 20 | 1920415 | 1 | CAPSCREW, hex, 3/8-16 x 1-1/4 |
| 21 | 1916965 | 1 | LOCKWASHER, 3/8 |
| 22 | 1919326 | 3 | WASHER, Plain, 5/16 |
| 23 | 1703900 | 3 | SPACER |
| 24 | 1709892 | 1 | ROD, Shift, Rear |
| 25 | 1916950 | 1 | NUT, Hex, Full, 3/8-16 |
| 26 | 1931335 | 1 | CARRIAGE BOLT, 5/16-18 x 1 |
| 27 | 1922127 | 1 | CAPSCREW, Hex, 5/16-18 x 1-3/4 |
Page 22
Page 23
Foot Controls Group - Gear Model
|
Ref.
No. |
Part
No. |
Qty. | Description | |
|---|---|---|---|---|
| 1 | 1704621 | - 1 | ||
| 2 | 1663114 | 4 | BUSHING Plastic | |
| 3 | 1704295 | 1 | BRAKE PEDAL ASSY | |
| 4 | 1704309 | 1 | PAD. Foot Pedal | |
| 5 | 1919326 | 3 | WASHER Plain 11/32 | |
| 6 | 1918447 | 2 | COTTER PIN | |
| 7 | 1704429 | 1 | CAM. Parkino Brake | |
| 8 | 1676374 | 1 | KNOB. Plastic | |
| 9 | 1704829 | 1 | ROD. Parking Brake | |
| 10 | 1921319 | 1 | WASHER, Plain, 9/32 | |
| 11 | 1709863 | 1 | BELT STOP | |
| 12 | 921133 | 1 | FITTING, Grease | |
| 13 | 1928352 | 2 | NUT, Flange, Whizlock, 3/8-16 | |
| 14 | 1709789 | 1 | ARM ASSY., Idler | |
| 15 | 1923360 | 1 | COTTER PIN | |
| 16 | 1950020 | 1 | WASHER, 5/8 | |
| 17 | 1704420 | 1 | KLIPRING, 5/8 | |
| 18 | 1924940 | 6 | WASHER, Plain, 13/32 | |
| 19 | 1708029 | 1 | PULLEY "V" | |
| 20 | 1931353 | 2 | CARRIAGE BOLT, 3/8-16 x 1-3/4 | |
| 21 | 1707289 | 1 | PULLEY, Idler | |
| 22 | 1919439 | ٢ | NUT, Hex Esna, 3/8-16 | |
| 23 | 1666759 | t | SPRING, Drive | |
| 24 | 1713303 | 1 | ROD, Clutch, 5/16 Dia. | |
| 25 | 1709951 | 1 | ARM, Foot Pedal | |
| 26 | 1922755 | 1 | WASHER | |
| 27 | 1960223 | 1 | CARRIAGE BOLT, 5/16-18 x 1-1/4 | |
| 28 | 1922611 | 1 | WASHER, Plain, 3/8 | |
| 29 | 1709950 | 1 | SWITCH, Adaptor | |
| 30 | 1705486 | 1 | SPACER | |
| 31 | 1709974 | 1 | SPRING, Torsion | |
| 32 | 1917356 | 1 | LOCKWASHER, 5/16 | |
| 33 | 1917372 | 1 | NUT, Hex, 5/16-18 |
Page 24
Page 25
Mfg. Nos. 1692287, 1692289
Hand Controls Group - Gear Model
|
Ref.
No |
Part | Obr | Description | |
|---|---|---|---|---|
| 1 | 1919438 | 2 | NUT, Hex, Esna, Lock, 5/16-18 | |
| 2 | 1919381 | 1 | WASHER, Plain, 5/16 | |
| 3 | 1705590 | 1 | SPACER, Special | |
| 4 | 1924356 | 1 | WASHER, Plain, 13/32 x 1-1/5 x 1/8 | |
| 5 | 1931337 | 2 | CARRIAGE BOLT, 5/16-18 x 1-1/2 | |
| 6 | 1708539 | 2 | KNOB, Plastic | |
| 7 | 1685701 | 1 | ROD, Lift Handle (Incl. Ref. No. 6) | |
| 8 | 1704623 | 1 | LINK, Lift, Upper | |
| 9 | 1704624 | 1 | LINK, LIft | |
| 10 | 1709236 | 1 | SPRING, Torsion | |
| 11 | 1918447 | з | COTTER PIN, 3/32 x 3/4 | |
| 12 | 1704756 | 1 | LINK, Lift, Upper Transport | |
| 13 | 1704825 | 1 | CAM , Lift Assy. | |
| 14 | 1960044 | 1 | WASHER, Plain, 21/64 x 1-1/4 x 5/64 | |
| 15 | 1685700 | 1 | LEVER, Shift (Inc. Ref. No. 6) | |
| 16 | 1919361 | 1 | WASHER, 5/16 | |
| 17 | 1678924 | 1 | BELT STOP | |
| 18 | 1705487 | 1 | SHIFT LEVER ASSY. | |
| 19 | 1924361 | 1 | WASHER, Plain, 17/32 | |
| 20 | 1960206 | 1 | WASHER, Plain, 33/64 | |
| 21 | 1704428 | 2 | BUSHING, Plastic | |
| 22 | 176440 | 1 | BUSHING, Nylon | |
| 23 | 1704629 | 1 | SPACER, Special |
Page 26
specifications chart unless otherwise noted.
Page 27
Foot Controls Group - Hydro Models
|
Ref.
No. |
Part
No. |
Qty. | Description | |
|---|---|---|---|---|
| 1 | 1704621 | 1 | CAM. Lift | |
| 2 | 1663114 | 2 | BUSHING, Plastic | |
| з | 1704295 | 1 | BRAKE PEDAL ASSY. | |
| 4 | 1704309 | 1 | PAD, Foot Pedal | |
| 5 | 1919326 | 3 | WASHER, Plain, 5/16 | |
| 6 | 1923360 | 1 | COTTER PIN | |
| 7 | 1704429 | 1 | CAM, Parking Brake | |
| 8 | 1676374 | 1 | KNOB, Plastic | |
| 9 | 1704829 | 1 | ROD, Parking Brake | |
| 10 | 1921319 | 1 | WASHER, Plain, 9/32 | |
| 11 | 1709898 | 1 | PIVOT ASSY., Shift | |
| 12 | 1709903 | 1 | IDLER ARM ASSY. | |
| 13 | 1928352 | 2 | NUT, Flange Whizlock, 3/8-16 | |
| 14 | 1960223 | 1 | CARRIAGE BOLT, 5/16-18 x 1-1/4 | |
| 15 | 1918447 | 2 | COTTER PIN | |
| 16 | 1960020 | 1 | WASHER, 5/8 | |
| 17 | 1704420 | 1 | KLIPRING, 5/8 | |
| 18 | 1924940 | 7 | WASHER, Plain, 13/32 | |
| 19 | 1708289 | 1 | PULLEY "V" | |
| 20 | 1931353 | 2 | CAPSCREW, 3/8-16 x 1-3/4 | |
| 21 | 1707289 | 1 | PULLEY, Idler, Flat | |
| 22 | 1709951 | 1 | ARM, Foot Pedal | |
| 23 | 1666759 | 1 | SPRING, Drive | |
| 24 | 1709895 | 1 | ROD, Clutch, 5/16 Dia. | |
| 25 | 1919439 | 1 | NUT, Hex , Esna, 3/8-16 | |
| 26 | 1922755 | 1 | WASHER | |
| 27 | 1709897 | 1 | LEVER, Lockout | |
| 28 | 1709863 | 1 | BELT STOP | |
| 29 | 1922611 | 1 | WASHER, 13/32 x 1-1/2 x 1/16 | |
| 30 | 1709950 | 1 | ACTUATOR, Switch | |
| 31 | 1705486 | 1 | SPACER | |
| 32 | 1709974 | 1 | SPRING, Tension | |
| 33 | 1663114 | 2 | BUSHING, Plastic | |
| 34 | 1917356 | 1 | LOCKWASHER, 5/16 | |
| 35 | 1917372 | 1 | NUT, Hex, 5/16-18 |
Page 28
Page 29
Mfg. Nos. 1692261, 1692265, 1692279, 1692281, 1692283, 1692285
Hand Controls Group - Hydro Models
|
Ref.
No. |
Part
No. |
Qty. | Description |
|---|---|---|---|
| 1 | 1960206 | 1 | WASHER 1/2 |
| 2 | 1924356 | 1 | WASHER Plain 13/32 x 1-1/2 x 1/8 |
| 3 | 1705590 | 1 | SPACER Special |
| 4 | 1704623 | 1 | |
| 5 | 1704624 | 1 | |
| 6 | 1931337 | 2 | CA88IAGE BOLT, 5/16-18 x 1-1/2 |
| 7 | 1704629 | 1 | SPACER, Special |
| 8 | 1918447 | 2 | COTTER PIN |
| 9 | 1704756 | 1 | LINK, Lift, Upper Transport |
| 10 | 1704825 | ł | CAM, Lift Assy. |
| 11 | 1960044 | з | WASHER, Plain, 21/64 x 1-1/4 |
| 12 | 1917356 | 2 | LOCKWASHER, 5/16 |
| 13 | 1917372 | 2 | NUT, Hex, 5/16-18 |
| 14 | 1709140 | 1 | WASHER, H.T. |
| 15 | 1919381 | 2 | WASHER, Plain, 5/16 |
| 16 | 1704620 | 1 | BRACKET, Tension |
| 17 | 1709211 | 1 | STUD, 5/16-18 x 3-1/4 |
| 18 | 1677746 | 1 | SPRING, Compression |
| 19 | 1919438 | 3 | NUT, Hex, Esna, Lock, 5/16-18 |
| 20 | 1709043 | 1 | SPACER |
| 21 | 1709978 | 1 | SHIFT LEVER ASSY. |
| 22 | 1924361 | 1 | WASHER, Plain |
| 23 | 1704428 | 2 | BUSHING, Plastic, 1/2 Dia. |
| 24 | 176440 | 1 | BUSHING, Nylon, 3/4 Dia. |
| 25 | 1713100 | 1 | SPRING, Torsion |
| 26 | 1685700 | 1 | LEVER, Shift (Ind. Ref. No. 27) |
| 27 | 1708539 | 2 | KNOB, Plastic |
| 28 | 1685701 | 1 | ROD, Lift Handle (incl. Ref. No. 27) |
| 29 | 1916622 | 2 | NUT, Hex, 1/4-20 |
| 30 | 1931317 | 2 | CARRIAGE BOLT, 1/4-20 x 3/4 |
| 31 | 1921319 | 2 | WASHER, Plain, 1/4 |
| 32 | 1916964 | 2 | LOCKWASHER, 1/4 |
Page 30
unless otherwise noted.
Page 31
All Models
Hood, Grille & Dash Group
|
Ref.
No. |
Part
No. |
Qty. | Description |
|---|---|---|---|
| 1 | 1704134 | 1 | |
| 2 | 1707325 | 1 | AIB DUCT (Hydro models only) |
| - | 1713301 | 1 | AIB DUCT (Gear models only) |
| 3 | 1707326 | 1 | MOLDING. Air Duct (Hydro models only) |
| • | 1713316 | 1 | MOLDING, Air Duct (Gear models only) |
| 4 | 1707004 | 1 | DASH ASSY. (Hydro models only) |
| 1705470 | 1 | DASH ASSY. (Gear models only) | |
| 5 | 960368 | 10 | PAL NUT. 1/4-20 |
| 6 | 1670675 | 2 | PLUG, Bumper (Gear models only) |
| 7 | 1921319 | 2 | WASHER, Plain, 1/4 |
| 8 | 1709238 | 1 | DASH, Lower |
| 9 | 176440 | 1 | BUSHING, Nylon |
| 10 | 1925003 | 8 | SCREW, Tapttie, 1/4-20 x 1/2 |
| 11 | 1960295 | 20 | CAPSCREW, Whizlock, 1/4-20 x 5/8 |
| 12 | 1704133 | 1 | SUPPORT, Bulkhead, L.H. |
| 13 | 1704879 | 1 | SIDE PANEL ASSY., L.H. |
| 14 | 171600 | 2 | STRAP, Hood |
| 15 | 1960096 | 2 | WASHER, Special |
| 16 | 1933896 | 2 | NUT, Hex, Nylon, Lock, #10-24 |
| 17 | 1920397 | 10 | NUT, Hex, Nylon, Lock, 1/4-20 |
| 18 | 1707580 | 1 | BULKHEAD |
| 19 | 1704927 | 1 | GROMMET, Wire Hamess |
| 20 | 1704342 | 2 | GROMMET, Bulkhead |
| 21 | 1703292 | 1 | GRILLE |
| 22 | 1704316 | 2 | HINGE, Hood |
| 23 | 1705249 | 2 | SPACER |
| 24 | 1960373 | 2 | SCREW, Taptite, 5/16-18 x 1 |
| 25 | 1704626 | 2 | SPACER, Hood |
| 26 | 1704628 | 2 | CLIP, Hairpin |
| 27 | 1930601 | 2 | SCREW, Taptite, 5/16-18 x 5/8 |
| 28 | 1705248 | 2 | PIVOT, Hood |
| 29 | 1704878 | 1 | SIDE PANEL ASSY., R.H. |
| 30 | 1703240 | 1 | HOOD |
| 31 | 1709187 | 1 | PLUG, Hole, Hourmster (Hydro models only) |
| 32 | 1709188 | 1 | PLUG, Hole, Electric Lift (Hydro models only) |
Page 32
**2330
30
Page 33
All Models
Seat, Deck & Fuel Tank Group
|
Ref.
No. |
Part
No. |
Qty. | Description |
|---|---|---|---|
| 1 | 1707492 | t | SEAT |
| 2 | 1709307 | i | SUPPORT, Seat Pivot |
| 3 | 1931339 | 2 | CARRIAGE BOLT, 5/16-18 x 2 |
| 4 | 935112 | 1 | CLIP, Speed |
| 5 | 1704299 | 2 | SPACER |
| 6 | 1704402 | 2 | SPRING, Compression |
| 7 | 1707101 | 1 | PLATE, Switch |
| 8 | 1704728 | 2 | SPRING, Compression |
| 9 | 1709256 | 2 | WASHER, Plain |
| 10 | 1707137 | 1 | SPRING, Extension |
| 11 | 1919438 | 2 | NUT, Hex, Nylon Lock, 5/16-18 |
| 12 | 1704724 | 2 | COVER, Spring |
| 13 | 1707084 | 1 | BRACKET, Seat Pivot |
| 14 | 1931350 | 2 | CARRIAGE BOLT, 3/8-16 x 1 |
| 15 | 1663752 | 2 | SPACER |
| 16 | 1924940 | 2 | WASHER, Plain, 13/32 |
| 17 | 1960459 | 2 | SCREW, Truss Hd., Torx drive, 3/8-16 x 1 |
| 16 | 1919439 | 2 | NUT, Hex, Nylon Lock, 3/8-16 |
| 19 | 1704366 | 1 | CAP, Fuel Gauge |
| 20 | 1708054 | 1 | TANK, Fuel |
| 21 | 1704108 | 1 | ELBOW & TUBE ASSY. |
| 22 | 1654930 | 1 | BUSHING |
| 23 | 1708361 | 1 | PLATE, Reinforcement |
| 24 | 1925003 | 4 | SCREW, Taptite, 1/4-20 x 1/2 |
| 25 | 1707487 | 1 | SEAT DECK |
| 26 | 1701229 | 1 | BUSHING, Snap |
| 27 | 1930601 | 2 | SCREW, Taptite, 5/16-18 x 5/8 |
| 28 | 1931648 | 4 | BOLT, Hex, Whizlock, 5/16-18 x 5/8 |
| 29 | 1928352 | 2 | NUT, Hex, Flange, Whizlock, 5/16-18 x 1/2 |
| 30 | 1707131 | 1 | BRACKET, Seat Slide |
| 31 | 1704723 | 1 | HANDLE, Grip |
| 32 | 1707133 | 1 | LEVER, Seat Release |
Page 34
Page 35
All Models
Electrical Group - Lower Harness
|
Ref.
No. |
Part
No. |
Qty. | Description |
|---|---|---|---|
| 1 | 1709359 | 1 | SWITCH, Seat, Operator Present |
| 2 | 1704877 | 1 | WIRE ASSY., Seat Switch |
| 3 | 1704377 | 1 | HARNESS ASSY., Lower |
| (12.5, 15 & 16 HP Briggs & Stratton) | |||
| 1705447 | 1 | HARNESS ASSY., Lower | |
| (14 HP Kohler)) | |||
| 4 | 1707232 | 1 | WIRE ASSY., Engline Ground |
| 5 | 1674358 | 1 | WIRE ASSY., Headlight |
| 6 | 1677370 | 2 | SOCKET, Bulb |
| 7 | 1703946 | 2 | HEAT SHIELD |
| 8 | 1703249 | 1 | BEZEL, Headlight |
| 9 | 1677371 | 2 | BULB, Headlight, 12.8V |
| 10 | 1703248 | 1 | LENS, Headlight |
| 11 | 1703945 | 1 | READLIGHT ASSY, (Incl. Ref. Nos. 6 - 10) |
| 12 | 1701011 | 2 | T/E, Cable |
| 13 | 1701229 | 3 | BUSHING, Snap, Small |
| 14 | 1705921 | 1 | BUSHING, Snap, Large (14 HP Kohler only) |
| 15 | 1713304 | 1 | WIRE ASSY., Jumper (15 HP Briggs & Stratton only) |
Page 36
34
Page 37
Electrical Group - Main Harness
| Ref. | Part | 01- | Basashutta a |
|---|---|---|---|
| NO. | Gaty. | Description | |
| 1 | 1703798 | 1 | SWITCH, PTO, Electric Clutch (Early style) |
| 2 | 1676130 | 5 | BULB, Indicator Light |
| 3 | 1960369 | 7 | SCREW, Plastite, #8-16 x 1/2 |
| 4 | 1665238 | 1 | CIRCUIT BREAKER |
| 5 | 1665237 | 1 | WIRE ASSY. |
| 6 | 1917356 | 2 | LOCKWASHER, 5/16 |
| 7 | 1679006 | 1 | SWITCH, Ignition |
| 8 | 1704347 | 1 | ADAPTER, Nut |
| 9 | 1704346 | 1 | COVER, Key Switch |
| 10 | 1704348 | 1 | KEYS |
| 11 | 1703972 | 1 | MODULE |
| 12 | 1685290 | 1 | SOLENOID |
| 13 | 1960256 | 2 | SCREW, Plastite, 1/4-20 x 5/8 |
| 14 | 1603618 | 1 | CABLE, Battery to Solenoid |
| 15 | 1701521 | 1 | SWITCH, Transmission, Neutral Start |
| 16 | 1703799 | 1 | SWITCH, Headlight |
| 17 | 1704614 | 1 | STRAP, Wire Retainer |
| 18 | 1677296 | 1 | BOOT, Insulator |
| 19 | 1704349 | 2 | NUT, Plastic, 1/4-20 |
| 20 | 1704112 | 1 | TRAY, Battery |
| 21 | 1685215 | 1 | BATTERY |
| 22 | 1709949 | 1 | WIRE ASSY, |
| 23 | 1612103 | 1 | HOSE, Battery, Drain |
| 24 | 1923341 | 2 | CAPSCREW, Hex, 1/4-20 x 3/4 |
| 25 | 1921319 | 6 | WASHER, Plain, 9/32 |
| 26 | 1713163 | 1 | CABLE, Battery to Ground |
| 27 | 1916964 | 2 | LOCKWASHER, 1/4 |
| 28 | 1916622 | 2 | NUT, Hex, Full, 1/4-20 |
| 29 | 1669831 | 1 | HOLD DOWN, Battery |
| 30 | 1920263 | 2 | NUT, Hex, 5/16-24 |
| 31 | 1704632 | 2 | ROD, Battery Hold Down |
| 32 | 122023 | 1 | COVER, Terminal |
| 33 | 1668819 | 1 | CABLE, Solenoid to Starter |
| 34 | 1709955 | 1 | HARNESS, Upper (Early style w/six-way PTO switch |
| connector) | |||
| 35 | 1709359 | 1 | SWITCH, Interlock, Clutch/Brake Pedal |
| 36 | 1713487 | 1 | SWITCH, PTO Electric Clutch (Later style) |
| 37 | 1713501 | 1 | HARNESS, Upper (Later style w/8-way PTO switch |
| connector) |
Note: Service kit 1686620 is available to service early style harness (Ref. No. 34) with later style PTO switch (Ref. No. 36). Kit includes later style PTO switch and 8-way connector. Wiring instructions and new safety decal are also included with the kit.
Page 38
**2035
Page 39
Wheels & Tires Group
|
Ref.
No. |
Part
No |
Qty. | Description |
|---|---|---|---|
| Front W | /heel Assembli | ės | |
| *1 | 1705376 | 2 | WHEEL & TIRE ASSY, 15 x 6.00-6, Beige |
| 1705378 | 2 | WHEEL & TIRE ASSY, 15 x 6.00-6, Silver | |
| 2 | 1713166 | 2 | TIRE, 15 x 6.00-6 |
| 3 | 1713167 | 4 | BEARING |
| 4 | 1713165 | 2 | WHEEL ASSY., Beige (Incl. Ref. No. 3) |
| _ | 1713168 | 2 | WHEEL ASSY., Silver (Incl. Ref. No. 3) |
| 5 | 172353 | 4 | VALVE STEM & CAP |
| 6 | 1664090 | 1 | TUBE, 4.10/3.50-6 (Service only) |
| 7 | 912808 | 2 | GREASE FITTING |
| Rear W | heel Assemblie | s | |
| ** 4 | 1708070 | ||
| 1709976 | 2 | WHEEL & TIRE ASSY., 20 x 8.00-10, Belge | |
| 1700077 | • | (Used on 15 HP Gear & 16 HP Hydro models) | |
| 1708877 | Z | WHEEL & TIRE ASSY., 20 x 8.00-10, Silver | |
| 1700955 | (Used on 15 HP Gear & 15 HP Hydro models) | ||
| 1709055 | 4 | WHEEL & HRE ASSY., 18 x 8.50-8, Beige | |
| 1700257 | 2 | (Used on 12.5 & 14 HP Hydro models) | |
| 1103037 | 2 | WINEEL & HIRE ASSY., 38 X 8.50-8 Silver | |
| 2 | 1709993 | 2 |
(USED VILLZ) & 14 HM Hydro Models)
TIRE 20 v 8 00 10 |
| - | 1712170 | 2 | |
| 3 | 173477 | 2 | |
| 164247 | 2 | TUBE, 7 of 20 X 0.00-10 THE (Service only) | |
| 4 | 1709994 | 2 | WHEEL ASSY 10" Dia Paiga |
| • | 1709995 | 2 | WHEEL ASSY 10" Dia Silver |
| 1713169 | 2 | WHEEL ASSY 8" Dia Balas | |
| 1713171 | 2 | WHEEL ASSY 8" Dia Silver | |
| 5 | 156305 | 2 | VALVE STEM & CAP Used on 10" Dia Wheele |
| - | 172353 | 2 | VALVE STEM & CAP, Used on 10 Dia, Wheels |
| 5 |
1713169
1713171 156305 172353 |
2
2 2 2 |
WHEEL ASSY., 8" Dia., Belge
WHEEL ASSY., 8" Dia., Silver VALVE STEM & CAP, Used on 10" Dia. W VALVE STEM & CAP, Used on 8" Dia. Wh |
* includes Ref. Nos. 2, 3, 4, 5 & 6. ** includes Ref. Nos. 2, 3, 4 & 5.
NOTE: Simplicity Tire Sealant can be used to repair tires in place of tubes. See inside front cover for part numbers.
Page 40
Page 41
38" Housing & Arbor Group
| Ref. | Part | ||
|---|---|---|---|
| No. | No. | Qty. | Description |
| 1 | 1930585 | 2 | CAPSCREW, Hex Hd., 7/16-14 x 3-1/2 |
| 2 | 1918199 | 2 | LOCKWASHER, 7/16 |
| 3 | 1933263 | 2 | WASHER, Plain |
| 4 | 1704120 | 1 | PULLEY ASSY., R.H. |
| 5 | 1657969 | 2 | SHIELD, Grass, Upper |
| 6 | 1655729 | 2 | HOUSING, Arbor, Top |
| 7 | 1665251 | 2 | ARBOR SHAFT ASSY, (Incl. Ref. Nos. 8 & 9) |
| 8 | 108202 | 4 | BEARING |
| 9 | 1685245 | 2 | ABBOR SHAFT KIT (Inc), Bef. No. 21) |
| 10 | 1703273 | 2 | HOUSING ASSY., Arbor, Bottom |
| _ | (Incl. Ref. Nos. 11 & 12) | ||
| 11 | 913958 | 2 | GBEASE FITTING |
| 12 | 1707335 | 2 | GASKET. Foram |
| 13 | 1919381 | 4 | WASHER, Flat 5/16 |
| 14 | 1917372 | 4 | NUT Hex 5/18-18 |
| 15 | 1917356 | 4 | |
| 16 | 1704099 | 2 | GUIDE (Inston Belt |
| 17 | 1924356 | 4 | |
| 18 | 1664241 | 2 | WASHER Shim |
| 19 | 1700229 | 2 | |
| 20 | 1655777 | 2 | ADADTOD Diado |
| 21 | 1672132 | 5 | |
| 22 | 1704101 | 1 | |
| 23 | 1656927 | 2 | |
| 24 | 1656916 | 2 | |
| 25 | 1923491 | 2 | |
| 26 | 1930600 | ~ | |
| 97 | 1704956 | - | |
| 28 | 1664947 |
,
A |
SCREW Have Tastita 5/10 - 1/1 |
| 29 | 1685411 | 1 | |
| 61685411 | 1 | ||
| 30 | 1031318 | ģ | |
| 31 | 1060518 | د | MITT Buch Co |
| 30 | 1060353 | 2 |
NOT, PUSA VII
WARVED, DIAL- |
| 33 | 1704000 | 2 | |
| 34 | 1010906 | ||
| 34 | 1705000 | WASHER, Plain, 5/16 | |
| 30 | 1705080 | 1 | SPRING |
| 30 | 1010004 | 1 | PLUG, Kole |
| 37 | 1916964 | 2 | LOCKWASHER, 1/4 |
| 38 | 1916622 | 2 | NUT, Hex Hd., 1/4-20 |
| 39 | 1706709 | 1 | ROD, Deflector, Front |
|
40
44 |
1705449 | 1 | DEFLECTOR, Plastic |
| 41 | 1704119 | 1 | PULLEY ASSY., L.H. |
Page 42
40
Page 43
44" Housing & Arbor Group
| Ref. | Part | ||||
|---|---|---|---|---|---|
| No. | No. | Qty. | Description | ||
| 1 | 1923471 | 2 | CAPSCREW, Hex Hd., 7/16-14 x 1-1/4 | ||
| 2 | 1918199 | Э | LOCKWASHER, 7/16 | ||
| 3 | 1933263 | з | WASHER, Plain | ||
| 4 | 1704123 | 2 | PULLEY ASSY., Deck Drive | ||
| 5 | 1657969 | 3 | SHIELD, Grass, Upper | ||
| 6 | 1655729 | 3 | HOUSING, Arbor, Top | ||
| 7 | 1685245 | 3 | ARBOR SHAFT KIT (Includes Ref. No. 21) | ||
| 8 | 108202 | 6 | BEARING | ||
| 9 | 1685251 | 3 | ARBOR SHAFT ASSY. (Incl. Ref. Nos, 7 & 8) | ||
| 10 | 1930585 | 1 | CAPSCREW, Hex Hd., 7/16-14 x 3-1/2 | ||
| 11 | 1704121 | 1 | PULLEY ASSY, | ||
| 12 | 1703273 | з | HOUSING ASSY., Arbor, Bottom | ||
| (Incl. Ref. Nos. 13 & 14) | |||||
| 13 | 1704314 | 3 | GREASE FITTING | ||
| 14 | 1705449 | i | DEFLECTOR, Plastic | ||
| 15 | 1664847 | 25 | SCREW, Hex, Taptite, 5/16-18 x 3/4 | ||
| 16 | 1704373 | t | COVER, Arbor | ||
| 17 | 1707335 | 3 | GASKET, Foam | ||
| 18 | 1700230 | 3 | WASHER, Shim | ||
| 19 | 1700229 | 3 | SHIELD, Grass, Bottom | ||
| 20 | 1655777 | 3 | ADAPTOR, Blade | ||
| 21 | 1672132 | 3 | COLLAR, Mower Arbor | ||
| 22 | 1704100 | 3 | BLADE, Mower | ||
| 23 | 1656927 | 3 | WASHER, Spline | ||
| 24 | 1656916 | 3 | WASHER, Spring | ||
| 25 | 1923491 | 3 | CAPSCREW, Hex Hd., 7/16-14 x 1 | ||
| 26 | 1685411 | 1 | MOWER HOUSING ASSY., Mower (Orange) | ||
| 61685411 | 1 | MOWER HOUSING ASSY., Mower (Black) | |||
| 27 | 1931318 | 2 | CARRIAGE BOLT, 1/4-20 x 7/8 | ||
| 28 | 1705115 | 1 | PLUG, Hole | ||
| 29 | 1703601 | 1 | COVER, Arbor | ||
| 30 | 1676436 | 1 | NUT, Push On | ||
| 31 | 1960353 | 2 | WASHER, Plain | ||
| 32 | 1704873 | 1 | CLAMP | ||
| 33 | 1919326 | 1 | WASHER, Plain, 5/16 | ||
| 34 | 1705080 | 1 | SPRING | ||
| 35 | 1916964 | 2 | LOCKWASHER, 1/4 | ||
| 36 | 1916622 | 2 | NUT, Hex, 1/4-20 | ||
| 37 | 1706709 | 1 | ROD, Deflector, Front | ||
Page 44
Page 45
38# Clutch & Support Group
| Ref. | Part | ||
|---|---|---|---|
| No. | No. | Qty. | Description |
| 1 | 1928957 | 2 | CAPSCREW, Hex Hd., 3/8-16 x 2-3/4 |
| 2 | 1677135 | 1 | GUARD, Spring |
| 3 | 1922755 | 4 | WASHER, Plain |
| 4 | 1685150 | 1 | IDLER PULLEY (Incl. Ref. No. 16) |
| 5 | 1665835 | 1 | GRIP, Lever |
| 6 | 1704520 | 1 | CLUTCH LEVER ASSY, (Incl. Ref. Nos. 23 & 24) |
| 7 | 1916965 | 1 | LOCKWASHER, 3/8 |
| 8 | 1916950 | i | NUT, Hex, Full, 3/8-16 |
| 9 | 1666786 | 1 | SPRING |
| 10 | 1919439 | 3 | NUT, Hex, Lock, 3/8-16 |
| 11 | 1924356 | 1 | WASHER |
| 12 | 1666698 | 1 | V-BELT |
| 13 | 1924940 | 2 | WASHER, Plain, 3/8 J.D. |
| 14 | 157081 | 2 | SPACER |
| 15 | 1657242 | 1 | SPACER |
| 16 | 1666294 | 1 | SPACER |
| 17 | 1960093 | 2 | NUT, Push On, 3/8 |
| 18 | 1704129 | 1 | ROD, Latch |
| 19 | 1707432 | 1 | HITCH ASSY, |
| 20 | 106681 | 1 | SPRING |
| 21 | 1930645 | 1 | NUT, Hex, Flange, 2-Way Lock, 3/8-16 |
| 22 | 1921969 | 2 | CAPSCREW, Hex, 3/8-16 x 1-1/2 |
| 23 | 912808 | t | FITTING, Grease |
| 24 | 1663114 | 2 | BUSHING |
Page 46
Page 47
44" Clutch & Support Group
| Ref. |
Part
No |
05. | |
|---|---|---|---|
| NU. | NO. | Gity. | Description |
| 1 | 1665835 | 1 | GRIP, Lever |
| 2 | 1916950 | 2 | NUT, Hex, 3/8-16 |
| 3 | 1916965 | 3 | LOCKWASHER, 3/8 |
| 4 | 1924940 | 14 | WASHER, 5/16 |
| 5 | 1601672 | 1 | V-BELT, Mower Drive |
| 6 | 1921969 | 2 | CAPSCREW, Hex Hd., 3/8-16 x 1-1/2 |
| 7 | 1656936 | i | SPRING |
| 8 | 1931352 | 1 | CARRIAGE BOLT, 3/8-16 x 1-1/2 |
| 9 | 1674669 | 2 | SPACER |
| 10 | 1676148 | 4 | BUSHING |
| 11 | 1666786 | 1 | SPRING |
| 12 | 1677135 | 1 | IDLER, Stop |
| 13 | 1685150 | 2 | PULLEY, Idler (Includes Ref. No. 23) |
| 14 | 1704658 | 1 | LEVER ASSY, Idler |
| (Incl. Qty. 1, Ref. No. 15; Qty 2, Ref. No. 10) | |||
| 15 | 912808 | 2 | GREASE FITTING |
| 16 | 1704659 | 1 | LEVER ASSY., Idler Arm |
| (Incl. Qty. 1, Ref. No. 15; Qty 2, Ref. No. 10) | |||
| 17 | 1924356 | 2 | WASHER |
| 18 | 1923938 | 1 | CAPSCREW, Hex Hd., 3/8-16 x 3-1/2 |
| 19 | 1919439 | 2 | NUT, Hex, Lock, 3/8-16 |
| 20 | 1607813 | 1 | V-BELT, Arbor Drive |
| 21 | 157081 | 2 | SPACER |
| 22 | 1930645 | 1 | NUT, Hex, Flange, Two-Way Lock, 3/8-16 |
| 23 | 1960315 | 1 | CARRIAGE BOLT, 3/8-16 x 2 |
| 24 | 1960093 | 2 | NUT, Push On |
| 25 | 1704129 | 1 | ROD, Latch |
| 26 | 1707432 | 1 | HITCH ASSY. |
| 27 | 106681 | 1 | SPRING |
| 28 | 1666294 | 2 | SPACER |
Page 48
Page 49
38" Height Adjusting & Roller Group
| 1 1930644 2 NUT, Hex, Flange, Lock, 1/2-13 2 1705058 1 SHAFT ASSY., Roller 3 1704073 1 BAR, Roller 4 1704082 1 NUT, Adjustor 5 916965 2 LOCKWASHER, 3/8 6 916950 2 NUT, Hex Hd., 3/8-16 7 1677507 1 SLIDE 8 1924361 1 WASHER, Plain, 1/2 9 172622 1 BOLT, Shoulder, 3/8-16 10 1924366 8 WASHER, Plain, 41/64 x 1-1/4 11 1668513 8 ROLLER 12 153124 1 RING, Retaining 13 1704104 1 ARM ASSY., Mower 14 1931352 1 CARRIAGE BOLT, 3/8-16 x 1-1/2 15 1685374 2 STRAP, Mower Arm Assy. 16 1684847 6 SCREW, Hex, Taptite, 5/16 x 3/4 | Description | |||
|---|---|---|---|---|
| 2 1705058 1 SHAFT ASSY., Roller 3 1704073 1 BAR, Roller 4 1704082 1 NUT, Adjustor 5 916965 2 LOCKWASHER, 3/8 6 916950 2 NUT, Hex Hd., 3/8-16 7 1677507 1 SLIDE 8 1924361 1 WASHER, Plain, 1/2 9 172622 1 BOLT, Shoulder, 3/8-16 10 1924366 8 WASHER, Plain, 41/64 x 1-1/4 11 1668513 8 ROLLER 12 153124 1 RING, Retaining 13 1704104 1 ARM ASSY., Mower 14 1931352 1 CARRIAGE BOLT, 3/8-16 x 1-1/2 15 1685374 2 STRAP, Mower Arm Assy. 16 1684847 6 SCREW, Hex, Taptite, 5/16 x 3/4 | . | |||
| 3 1704073 1 BAR, Roller 4 1704082 1 NUT, Adjustor 5 916965 2 LOCKWASHER, 3/8 6 916950 2 NUT, Hex Hd., 3/8-16 7 1677507 1 SLIDE 8 1924361 1 WASHER, Plain, 1/2 9 172622 1 BOLT, Shoulder, 3/8-16 10 1924366 8 WASHER, Plain, 41/64 x 1-1/4 11 1668513 8 ROLLER 12 153124 1 RING, Retaining 13 1704104 1 ARM ASSY., Mower 14 1931352 1 CARRIAGE BOLT, 3/8-16 x 1-1/2 15 1685374 2 STRAP, Mower Arm Assy. 16 1684847 6 SCREW, Hex, Taptite, 5/16 x 3/4 | ||||
| 4 1704082 1 NUT, Adjustor 5 916965 2 LOCKWASHER, 3/8 6 916950 2 NUT, Hex Hd., 3/8-16 7 1677507 1 SLIDE 8 1924361 1 WASHER, Plain, 1/2 9 172622 1 BOLT, Shoulder, 3/8-16 10 1924366 8 WASHER, Plain, 41/64 x 1-1/4 11 1668513 8 ROLLER 12 153124 1 RING, Retaining 13 1704104 1 ARM ASSY., Mower 14 1931352 1 CARRIAGE BOLT, 3/8-16 x 1-1/2 15 1685374 2 STRAP, Mower Arm Assy. 16 1684847 6 SCREW, Hex, Taptite, 5/16 x 3/4 | ||||
| 5 916965 2 LOCKWASHER, 3/8 6 916950 2 NUT, Hex Hd., 3/8-16 7 1677507 1 SLIDE 8 1924361 1 WASHER, Plain, 1/2 9 172622 1 BOLT, Shoulder, 3/8-16 10 1924366 8 WASHER, Plain, 41/64 x 1-1/4 11 1668513 8 ROLLER 12 153124 1 RING, Retaining 13 1704104 1 ARM ASSY., Mower 14 1931352 1 CARRIAGE BOLT, 3/8-16 x 1-1/2 15 1685374 2 STRAP, Mower Arm Assy. 16 1684847 6 SCREW, Hex, Taptite, 5/16 x 3/4 | ||||
| 6 916950 2 NUT, Hex Hd., 3/8-16 7 1677507 1 SLIDE 8 1924361 1 WASHER, Plain, 1/2 9 172622 1 BOLT, Shoulder, 3/8-16 10 1924366 8 WASHER, Plain, 41/64 x 1-1/4 11 1668513 8 ROLLER 12 153124 1 RING, Retaining 13 1704104 1 ARM ASSY., Mower 14 1931352 1 CARRIAGE BOLT, 3/8-16 x 1-1/2 15 1685374 2 STRAP, Mower Arm Assy. 16 1684847 6 SCREW, Hex, Taptite, 5/16 x 3/4 | ||||
| 7 1677507 1 SLIDE 8 1924361 1 WASHER, Plain, 1/2 9 172622 1 BOLT, Shoulder, 3/8-16 10 1924366 8 WASHER, Plain, 41/64 x 1-1/4 11 1668513 8 ROLLER 12 153124 1 RING, Retaining 13 1704104 1 ARM ASSY., Mower 14 1931352 1 CARRIAGE BOLT, 3/8-16 x 1-1/2 15 1685374 2 STRAP, Mower Arm Assy. 16 1664847 6 SCREW, Hex, Taptite, 5/16 x 3/4 | ||||
| 8 1924361 1 WASHER, Plain, 1/2 9 172622 1 BOLT, Shoulder, 3/8-16 10 1924366 8 WASHER, Plain, 41/64 x 1-1/4 11 1668513 8 ROLLER 12 153124 1 RING, Retaining 13 1704104 1 ARM ASSY., Mower 14 1931352 1 CARRIAGE BOLT, 3/8-16 x 1-1/2 15 1665374 2 STRAP, Mower Arm Assy. 16 1664847 6 SCREW, Hex, Taptite, 5/16 x 3/4 | ||||
| 9 172622 1 BOLT, Shoulder, 3/8-16 10 1924366 B WASHER, Plain, 41/64 x 1-1/4 11 1668513 8 ROLLER 12 153124 1 RING, Retaining 13 1704104 1 ARM ASSY., Mower 14 1931352 1 CARRIAGE BOLT, 3/8-16 x 1-1/2 15 1665374 2 STRAP, Mower Arm Assy. 16 1664847 6 SCREW, Hex, Taptite, 5/16 x 3/4 | ||||
| 10 1924366 B WASHER, Plain, 41/64 x 1-1/4 11 1668513 8 ROLLER 12 153124 1 RING, Retaining 13 1704104 1 ARM ASSY., Mower 14 1931352 1 CARRIAGE BOLT, 3/8-16 x 1-1/2 15 1665374 2 STRAP, Mower Arm Assy. 16 1664847 6 SCREW, Hex, Taptite, 5/16 x 3/4 | ||||
| 11 1668513 8 ROLLER 12 153124 1 RING, Retaining 13 1704104 1 ARM ASSY., Mower 14 1931352 1 CARRIAGE BOLT, 3/8-16 x 1-1/2 15 1685374 2 STRAP, Mower Arm Assy. 16 1664847 6 SCREW, Hex, Taptite, 5/16 x 3/4 | ||||
| 12 153124 1 RING, Retaining 13 1704104 1 ARM ASSY., Mower 14 1931352 1 CARRIAGE BOLT, 3/8-16 x 1-1/2 15 1685374 2 STRAP, Mower Arm Assy. 16 1664847 6 SCREW, Hex, Taptite, 5/16 x 3/4 | ||||
| 13 1704104 1 ARM ASSY., Mower 14 1931352 1 CARRIAGE BOLT, 3/8-16 x 1-1/2 15 1665374 2 STRAP, Mower Arm Assy. 16 1664847 6 SCREW, Hex, Taptite, 5/16 x 3/4 | ||||
| 14 1931352 1 CARRIAGE BOLT, 3/8-16 x 1-1/2 15 1685374 2 STRAP, Mower Arm Assy. 16 1664847 6 SCREW, Hex, Taptite, 5/16 x 3/4 | ||||
| 15 1665374 2 STRAP, Mower Arm Assy. 16 1664847 6 SCREW, Hex, Taptite, 5/16 x 3/4 | ||||
| 16 1664847 6 SCREW, Hex, Taptite, 5/16 x 3/4 | ||||
|
17 1705049 1 LINKASSY LI
|
||||
| 18 1924940 3 WASHER Plain 13/32 | ||||
| 19 176012 1 CLIP. Pin. Safety | ||||
| 20 1918448 1 COTTER PIN | ||||
| 21 118053 1 PIN Clevis | ||||
| 22 1913744 2 NIT Hey Jam 1/2-13 | ||||
| 23 1960170 3 WASHEB 33/64 | ||||
| 24 1704081 1 TRUNNION | ||||
| 25 1704093 1 BOD Adjustment | ||||
| 26 1928352 1 NIT Hey Whizlook 3/8-16 | ||||
| 27 1706644 1 SPACER | ||||
| 28 1922606 1 CAPSCREW Hey Hd. 3/8-16 x 1-3/4 | ||||
| 29 1921977 4 CAPSCREW Hey Hd 5/16-18 x 1-1/4 | ||||
| 30 1704115 1 PLATE Support | ||||
| 31 1917356 4 LOCKWASHER 5/16 | ||||
| 32 1917372 4 NUT Hex 5/16-18 | ||||
| 33 1919381 1 WASHER Flat 5/16 | ||||
| 34 1704114 1 INDICATOR Cutting Height | ||||
| 35 1960093 1 PAL NUT | ||||
| 36 1704077 1 STRAP Trunnion Betsiner | ||||
| 37 1918452 1 COTTER PIN | ||||
| 38 1704116 1 BRACKET Cultino Height | ||||
| 39 1704083 1 ARM Rear Mower R H | ||||
| 40 1916001 1 PIN Rolf 1* | ||||
| 41 1704097 1 WASHER Dotent | ||||
| 42 1704086 1 TRUNNION | ||||
| 43 1704087 1 TRUNNION Threaded | ||||
| 44 1704094 1 CRANK Cutting Height | ||||
| 45 1602946 2 SPACER | ||||
| 46 1668190 1 KNOB | ||||
Page 50
Page 51
44" Height Adjusting & Roller Group
| Ref. | Part | ||||
|---|---|---|---|---|---|
| NO. | NO, | QTY. | Description | ||
| 1 | 1685443 | 1 | SHAFT ASSY., Roller, 44" (Incl. Ref. Nos. 10, 11 & 48) | ||
| 2 | 1704082 | 1 | NUT, Adjuster | ||
| з | 916965 | 2 | LOCKWASHER | ||
| 4 | 916950 | 2 | NUT, Hex, 3/8-16 | ||
| 5 | 1677507 | 1 | SLIDE | ||
| 6 | 1924361 | 1 | WASHER, Plain, 1/2 | ||
| 7 | 172622 | 1 | BOLT, Shoulder, 3/8-16 | ||
| 8 | 1924366 | 12 | WASHER, Plain, 1-1/4 | ||
| 9 | 1668513 | 9 | ROLLER | ||
| 10 | 153124 | 2 | RING. Retaining | ||
| 11 | 1602946 | 2 | SPACER | ||
| 12 | 176012 | 1 | CLIP. Pin. Safety | ||
| 13 | 1924940 | 5 | WASHER, Plain | ||
| 14 | 1704103 | 1 | ARM ASSY., Mower | ||
| 15 | 1665374 | 3 | ST8AP. Mower Arm Assv | ||
| 16 | 1931352 | 1 | CARRIAGE BOLT 3/8-16 x 1-1/2 | ||
| 17 | 1664847 | 6 | SCREW Hex Taptile 5/18 v 3/4 | ||
| 18 | 1705049 |
-
1 |
|||
| 19 | 1918448 | ł | |||
| 20 | 1930644 | 2 | NIT Hex Flange Look 1/2-12 | ||
| 21 | 1704074 | 1 | RAR Boller | ||
| 22 | 1704116 | BBACKET Outling Holeby | |||
| 23 | 1917356 |
,
9 |
|||
| 24 | 1917372 | 2 | |||
| 25 | 1918452 | 1 | |||
| 26 | 118059 | i i | BIN Clavia | ||
| 27 | 1919744 |
י
י |
FRA, GIBYIS
NULT How Jam 100 to |
||
| 28 | 1980170 | 2 | |||
| 29 | 1704081 | ||||
| 20 | 1704002 | ||||
| 31 | 1706644 | - |
NOD, Adjustment
SDACCO |
||
| 20 | 1008950 | 1 |
SFAUER
NUT lieu Nikelerk an da |
||
| 22 | 1022002 | ||||
| 34 | 1704000 | 4 | |||
|
35
35 |
1060002 | ||||
| 28 | 1001093 | 1 | |||
| 47 | 1010001 | 4 | |||
|
30
90 |
1319301 | - | |||
| 20 | 1704114 | INDICATOR, Cutting Height | |||
| 40 | 1704080 | 1 | PLATE, Mower Support | ||
| 40 | 1704097 | 1 | WASHER, Detent | ||
|
41
40 |
916001 | 1 | PIN, Roll, 1" Long | ||
| 42 | 1704086 | 1 | |||
| 43 | 1704083 | 1 | ARM, Rear, Mower, R.H. | ||
| 44 | 1921977 | 2 | CAPSCREW, Hex, 5/18-18 x 1-1/4 | ||
| 45 | 1704087 | 1 | TRUNNION, Threaded | ||
| 46 | 1704094 | 1 | CRANK, Cutting Height | ||
| 47 | 1668190 | 1 | KNOB, Height Crank | ||
| 48 | 1960020 | 2 | WASHER, 5/8 x 1-1/4 x 1/16 | ||
Page 52
50
Page 53
Decal Group
| Ref. | Part | 0.5.4 | - |
|---|---|---|---|
| ND. | NO. | city. | Description |
| 1 | 1708608 | ĩ | DECAL, Hood, L.H., Broadmoor 16H |
| 1708610 | ٦ | DECAL, Hood, L.H., Broadmoor 14H | |
| 1708864 | 1 | DECAL, Hood, L.H., Broadmoor 12.5H | |
| 1709837 | 1 | DECAL, Hood, L.H., Broadmoor 15G | |
| 2 | 1708609 | 1 | DECAL, Hood, R.H., Broadmoor 16H |
| 1708611 | 1 | DECAL, Hood, R.H., Broadmoor 14H | |
| 1708865 | 1 | DECAL, Hood, R.H., Broadmoor 12.5H | |
| 1709838 | 1 | DECAL, Hood, R.H., Broadmoor 15G | |
| з | 1709061 | 1 | DECAL, Paint |
| 4 | 1713315 | 1 | DECAL, Belt, Blade |
| 5 | 1708280 | 1 | DECAL, Operating Inst. |
| 6 | 1668202 | 1 | DECAL, Simplicity Logo |
| 7 | 1708918 | 1 | DECAL, Release Valve (Hydrostatic Units only) |
| 8 | 1704131 | 1 | DECAL, Mower Height |
| 9 | 1704276 | 1 | DECAL, Danger (Hand Under Deck) |
| 10 | 1 | DECAL, OPEI (Not Serviced) | |
| 11 | 1704477 | 1 | DECAL, Cutting Width, 38" |
| 12 | 1704277 | 1 | DECAL, Danger (Chute in Place) |
| 13 | 1704478 | 1 | DECAL, Cutting Width, 44* |
| 14 . | 1708927 | 1 | DECAL, USA Logo |
| 15 | 1 | I.D. PLATE (Not Serviced) | |
| 16 | 1704466 | 1 | DECAL, Choke (Dash), 12.5 and 14 HP Kohler Only |
| Not Sho | wo: | ||
| 1 | DECAL, Battery (Not Serviced) | ||
| 1708995 | 1 | DECAL, Engine, 16 HP | |
| 1713306 | 1 | DECAL, Engine, 15 HP | |
| 1707948 | 1 | DECAL, Engine, 14 HP |
Ref. No 7 (Hydro Units)
Page 54
Page 55
AGCO Ailis Models
Decal Group
| Ref. | Part | ||
|---|---|---|---|
| No. | No. | City. | Description |
| 1 | 1708811 | 1 | DECAL, Hood, L.H., AGCO Allis, 16H |
| 1708941 | 1 | DECAL, Hood, L.H., AGCO Allis, 14H | |
| 1708814 | 1 | DECAL, Hood, L.H., AGCO Allis, 12.5H | |
| 1709835 | 1 | DECAL, Hood, L.H., AGCO Allis, 15G | |
| 2 | 1708812 | 1 | DECAL, Hood, R.H. AGCO Allis, 16H |
| 1708942 | 1 | DECAL, Hood, R.H. AGCO Allis, 14H | |
| 1708815 | 1 | DECAL, Hood, R.H. AGCO Allis, 12.5H | |
| 1709836 | 1 | DECAL, Hood, R.H., AGCO Allis, 15G | |
| 3 | 1709061 | 1 | DECAL, Paint |
| 4 | 1713315 | 1 | DECAL, Belt, Blade |
| 5 | 1708280 | 1 | DECAL, Operating Inst. |
| 6 | 1708927 | 1 | DECAL, USA Logo |
| 7 | 1708918 | 1 | DECAL, Release Valve (Hydrostatic Units only) |
| 8 | 1704131 | 1 | DECAL, Mower Height |
| 9 | 1704276 | 1 | DECAL, Danger (Hand Under Deck) |
| 10 | 1 | DECAL, OPEI (Not Serviced) | |
| 11 | 1704477 | 1 | DECAL, Cutting Width, 38 |
| 12 | 1704277 | 1 | DECAL, Danger (Chute in Place) |
| 13 | 1704478 | 1 | DECAL, Cutting Width, 44* |
| 14 | 1708926 | 1 | DECAL, AGCO Allis Badge |
| 15 | 1 | I.D. PLATE (Not Serviced) | |
| 16 | 1704466 | 1 | DECAL, Choke, Dash (15 HP Briggs & Stratten only) |
| Not Sho | wn: | ||
| 1 | DECAL, Battery (Not Serviced) | ||
| 1708995 | 1 | DECAL, Engine, 16 HP | |
| 1713319 | 1 | DECAL, Engine, 15 HP | |
| 1707948 | 1 | DECAL, Engine, 14 HP |
TRANSMISSION RELEASE VALVE LEVER PULL REARWARD TRACTOR MAY NOW BE MOVED BY MANUALLY PUSHING OR PULLING Ref. No 7 (Hydro Units)
Page 56
Page 57
Gear Transaxle Service Parts - Peerless Transaxle Model 801-059
| Ref. | Part | ||
|---|---|---|---|
| No. | No. | Qty. | Description |
| 1 | 770071A | 1 | CASE. Transaxle |
| 2 | 778136 | 1 | GEAR, Spur (15 Teeth) |
| 2A | 778145 | 1 | GEAR, Spur (12 Teeth) |
| 3 | 778128A | 1 | GEAR, Spur (20 Teeth) |
| 4 | 778127A | 1 | GEAR, Spur (25 Teeth) |
| 5 | 778128A | 1 | GEAR, Spur (28 Teeth) |
| 6 | 778129A | 1 | GEAR, Spur (30 Teeth) |
| 7 | 778121A | 1 | GEAR, Spur (20 Teeth) |
| 8 | 778122A | 1 | GEAR, Spur (22 Teeth) |
| 9 | 778123A | 1 | GEAR, Spur (25 Teeth) |
| 10 | 778124A | 1 | GEAR, Spur (30 Teeth) |
| 11 | 778146A | 1 | GEAR, Spur (37 Teeth) |
| 12 | 778137A | 1 | GEAR, Bevel (42 Teeth) |
| 13 | 784266 | 1 | COLLAR, Shift |
| 14 | 786060 | 1 | SPROCKET (14 Teeth) |
| 15 | 786061 | 1 | SPROCKET (10 Teeth) |
| 16 | 776204 | 1 | SHAFT, Counter |
| 17 | 778113A | 1 | SEVEL PINION, Input |
| 18 | 786074 | 1 | SPACER |
| 19 | 778138 | 1 | PINION, Output |
| 20 | 778139 | 1 | GEAR, Output |
| 21 | 790003 | 1 | DISK, Brake |
| 22 | 792089A | 4 | KEY |
| 25 | 788040 | 1 | RING, Retaining |
| 26 | 780105A | з | BUSHING, Flanged |
| 27 | 780118A | 1 | BUSHING, Flanged |
| 28 | 786062A | 1 | CHAIN, Roller (No. 41 Chain, 22 Links) |
| 29 | 780072 | 4 | WASHER, Thrust |
| 30 | 780122 | 2 | BEARING, Needle |
| 31 | 792077 | 1 | BALL, Steel |
| 32 | 780109 | 1 | WASHER, Thrust |
| 33 | 792078 | 1 | SCREW, Set, 3/8-16 x 3/8 |
| 34 | 792079 | 1 | SPRING |
| 35 | 792073 | 17 | SCREW, Hex Hd., Thread Forming, 1/4-20 x 1-1/4 |
| 36 | 760108 | 5 | WASHER, Thrust |
| 37 | 780121 | 1 | BEARING, Ball |
Ref. Nos. 38 - 74 on pages 55 & 57.
Order gear transaxle service parts through your authorized Tecumseh/Peerless distributor.
Page 58
Page 59
Gear Transaxle Service Parts - Peerless Transaxle Model 801-059
| Ref. | Part | ||
|---|---|---|---|
| No. | No. | Qty. | Description |
| 38 | 780113 | 1 | WASHER, Flat |
| 39 | 780119 | 2 | BEARING, Ball |
| 41 | 788051 | 2 | SEAL, Square Cut |
| 42 | 788057 | 1 | SEAL, Square Cut |
| 43 | 780112 | 2 | BEARING, Needle |
| 44 | 780114 | 1 | WASHER, Flat |
| 46 | 788053 | 2 | SEAL, Square Cut |
| 47 | 772082 | 1 | COVER, Transaxle |
| 48 | 784290 | 1 | ROD & FORK ASSY., Shift |
|
4
|
776135 | 1 | SHAFT, Input |
| 50 | 776184A | 1 | SHAFT, Brake |
| 51 | 790007 | 1 | PLATE, Brake Pad |
| 52 | 790006 | 2 | PAD, Brake |
| 53 | 786026 | 2 | PIN, Dowel |
| 54 | 792075 | 1 | LOCKNUT, 5/16-24 |
| 55 | 792076 | t | WASHER, Flat |
| 56 | 790056 | 1 | LEVER, Brake |
| 57 | 792073 | 1 | SCREW, Hex Hd., Thread Forming, 1/4-20 x 1-1/4 |
| 57A | 792085 | 1 | SCREW, Hex Hd., Thread Forming, 1/4-20 x 2-1/4 |
| 58 | 790025 | 1 | HOLDER, Brake Pad |
| 59 | 778175 | 1 | GEAR ASSY., Differential (Incl. 2 of Ref. No. 60) |
| 60 | 780064 | 2 | BUSHING |
| 60A | 780120 | 1 | BUSHING |
| 61 | 778166 | 2 | GEAR, Bevel |
| 62 | 778131 | 2 | PINION, Bevel |
| 63 | 786034 | 1 | PIN, Orive |
| 64 | 780065 | 2 | WASHER, Thrust |
| 65 | 792125 | 4 | RING, Retaining (Pkg. of 2) |
| 66 | 792040 | 1 | PIN, Roll |
| 67 | 780001 | 2 | WASHER, Thrust |
| 68 | 774891 | 1 | AXLE (14-3/8" Long) |
| 69 | 774644 | 1 | AXLE (12-1/2" Long) |
| 70 | 792035 | 1 | RING, Retaining |
| 71 | 788069 | 1 | SEAL, Square Cut |
| 72 | 786066 | 1 | SPACER |
| 73 | 786086 | 1 | BRACKET, Brake Lever |
| 74 | 792074 | t | PLUG, Threaded |
Ref. Nos. 1 - 37 on pages 54 & 55.
Order gear transaxie service parts through your authorized Tecumseh/Peerless distributor.
Page 60
Page 61
Mfg. Nos. 1692261, 1692265, 1692279, 1692281, 1692283, 1692285
Hydro Transaxle Service Parts - Hydro Gear Model 311-0750
|
Ref. Part
No. No. |
Qty. | Description | |||
|---|---|---|---|---|---|
| 1 | 1709907 | 1 | ARM, Sypass | ||
| 2 | 1709908 | 1 | SEAL | ||
| 3 | 1709909 | 1 | PUCK, Dampener | ||
| 4 | 1709910 | 1 | SET SCREW | ||
| 5 | 1709911 | 1 | ABM, Control | ||
| 6 | 1709914 | 1 | SCREW, Soc. Hd. | ||
| 7 | 1709915 | 2 | ACTUATOR PIN | ||
| 8 | 1713618 | 1 | ARM, Brake | ||
| 9 | 1709917 | 1 | WASHER, 7/16 x 7/8 x 1/16 | ||
| 10 | 1709918 | 1 | LOCKING STRAP | ||
| 11 | 1709919 | 1 | NUT, Hex, Lock, 5/16-24 | ||
| 12 | 1709920 | 1 | SEAL, Lip | ||
| 13 | 1709921 | 1 | SEAL, LIP | ||
| 14 | 1709922 | 1 | RING, Retaining | ||
| 15 | 1713323 | 1 | FITTING, Vent Plug | ||
| 16 | 1713322 | 1 | TUBE, Vent | ||
| 17 | 1713324 | 1 | VENT PLUG | ||
Page 62
Page 63
Page 64
Page 65
Page 66
Page 67
TORQUE SPECIFICATIONS FOR STANDARD MACHINE HARDWARE TOLERANCE ±20%
| SIZE | SAE GRADE #2 | SAE GRADE #5 | SAE GRADE #8 | |||
|---|---|---|---|---|---|---|
| 四 | \ € \> | |||||
| - | ||||||
|
III./Los.
Ft/Lbs |
Nm. | Ft/Lbs. | Nm. | Ft./Lbs. | Nm. | |
| 8.32 | 19 | 2.1 | 30 | 3.4 | 41 | 4.6 |
| 8-36 | 20 | 2.3 | 31 | 3.5 | 43 | 4.9 |
| 10-24 | 27 | 3.1 | 43 | 4.9 | 60 | 6.8 |
| 10-32 | 31 | 3.5 | 49 | 5.5 | 68 | 7.7 |
| 1/4-20 | 66 | 7.6 | 8 | 10.9 | 12 | 16.3 |
| 1/4-28 | 76 | 8.6 | 10 | 13.6 | 14 | 19. |
| 5/16-18 | 11 | 15. | 17 | 23.1 | 25 | 34. |
| 5/16-24 | 12 | 16.3 | 19 | 25.8 | 25 | 34. |
| 3/8-16 | 20 | 27.2 | 30 | 40.8 | 、45 | 61.2 |
| 3/8-24 | 23 | 31.3 | 35 | 47.6 | 50 | 68. |
| 7/16-14 | 30 | 40.8 | 50 | 68. | 70 | 95.2 |
| 7/16-20 | 35 | 47.6 | 55 | 74.8 | 80 | 108.8 |
| 1/2-13 | 50 | 68. | 75 | 102. | 110 | 149.6 |
| 1/2-20 | 55 | 74.8 | 90 | 122.4 | 120 | 163.2 |
| 9/16-12 | 65 | 88.4 | 110 | 149.6 | 150 | 204, |
| 9/16-18 | 75 | 102. | 120 | 163.2 | 170 | 231.2 |
| 5/8-11 | 90 | 122.4 | 150 | 204. | 220 | 299.2 |
| 5/8-18 | 100 | 136. | 180 | 244.8 | 240 | 326.4 |
| 3/4-10 | 160 | 217.6 | 260 | 353.6 | 386 | 525. |
| 3/4-16 | 180 | 244.8 | 300 | 408. | 420 | 571.2 |
| 7/8-9 | 140 | 190.4 | 400 | 544. | 600 | 816. |
| 7/8-14 | 155 | 210.8 | 440 | 598.4 | 660 | 897.6 |
| 1-8 | 220 | 299.2 | 580 | 788.8 | 900 | 1,224. |
| 1-12 | 240 | 326.4 | 640 | 870.4 | 1,000 | 1,360. |
NOTE:
- These torque values are to be used for all hardware excluding: locknuts, self-tapping screws, thread forming screws, sheet metal screws and socket head setscrews.
-
2. Recommended seating torque values for locknuts:
- a. For prevailing torque locknuts use 65% of grade 5 torques.
- b. For flange whizlock nuts (and screws) use 135% of grade 5 torques.
- Unless otherwise noted on assembly drawings all torque values must meet this specification.
BOLT HEAD MARKING S.A.E. GRADE:
Page 68
SIMPLICITY MANUFACTURING, INC. • 500 N. Spring Street, P.O. Box 997 • Port Washington, WI 53074-0997
TP-1223 5/94
Page 1
Page 2
Page 3
Page 4
Page 5
Page 6
Page 7
Page 8
Page 9
Page 10
Page 11
Page 12
Page 13
Page 14
Page 15
Page 16
Page 17
Page 18
Page 19
Page 20
Page 21
Page 22
Page 23
Page 24
Page 25
Page 26
Page 27
Page 28
Page 29
Page 30
Page 31
Page 32
Page 33
Page 34
Page 35
Page 36
Page 37
Page 38
Page 39
Page 40
Page 41
Page 42
Page 43
Page 44
Page 45
Page 46
Page 47
Page 48
Page 49
Page 50
Page 51
Page 52
Page 53
Page 54
Page 55
Page 56
Page 57
Page 58
Page 59
Page 60
Page 61
Page 62
Page 63
Page 64
Page 65
Page 66
Page 67
Page 68
Loading...