Simplicity 1000 User Manual
Specifications and Main Features
- Engine:
- Make: Simmons
- Model Nmbr: 183032 (MFG. No. 112), 287701 (MFG. No. 154)
- Type: 0678-A
- Horse power: 7.5 @ 3600 RPM
- Cycles: 4
- Cylinders: 1
- Bore: 73mm
- Stroke: 64 mm
- Cubic Inches: 93.63 Cu. In.
- The following will be the components:
- Crankshaft: Vertical
- Ignition: Magneto
- - Starter: Automatic Rewind or Electric
- - Governor: Adjustable Mechanical Type (1800-3400 rpm range)
- - Air Cleaner: Sealed Housing, Reusable Oiled Foam Element
- - Choke: Chokematic
- - Crankcase Lubrication: Gear Impeller System
- - Oil Capacity: 2-1/4 Pints
- - Fuel Capacity: 3 Quarts
- - Muffler: Quiet Rear Discharge
- Transmission:
- Type: 2 Speed Range Shuttle Drive with Split Sheave
- Speeds: Two Forward, Two Reverse
- Speed Range (at 3400 rpm):
- Forward: Low: 2.52 mph, High: 3.92 mph
- Reverse: Low: 2.52 mph, High: 3.92 mph
- Differential Type: All gear, fully enclosed and lubricated
- Rotary Mower:
- Mounting: Suspended from and tilts with front axle
- Width of cut (Blade): 30 inches
- Height of cut: 1-1/2 to 3-1/2 inches
- Drive: Cushioning V-Belt with Lever Control
- Adjustment: Stepless Screw Controls Front and Rear Height
- Spindles: Sealed Rolling Contact Bearing Mounted
- Rear Support: Three Rollers (2 at 2-inch, 1 at 3-15/16 Wide)
- Housing: Drawn Steel
- Chassis:
- Frame: Heavy Gauge Steel - Front and Rear U-channel
- Rear Tires:
- Inflation Pressure: 10 psi
- Size: 16.00/6.50 x 8 Turf Tread
- Tread Width: 28 inches
- Front Tires
- Geometry: 4.10/3.50 x 4 Turf Tread Bearings: Powdered Iron with Grease Fittings Tread Width: 28 inches Pneumatic Inflation Pressure: 22-25 psi.
- Seating: Bucket Rubber Mounted Type Cover Leatherette on Bonded Foam.
- Inside Rear Tire Distance: 22 Inches.
- For enhanced stability, traction is installed onto the rear wheel weights.
- Control
- There is a steering control, which is centrally positioned at the steering wheel. The steering wheel has a 3.81 to 1 ratio with the rest of the system. The gears are located to the right side of the seat while the clutch and brake pedal are located in the front right side.
- The left side of the seat contains a mower clutch, while the throttle control and manual starter are on the front and back right sides of the seat respectively. An electric key is located under the right side of the seat.
- Dimensions: Overall Length 57-3/4 Inches; Overall Width Without Mower: 28-1/4 Inches; With 30 Inch Mower and Safety Shield: 40-1/4 Inches; Wire Weight: 44-3/8 Inches, Shipping Weight with 30 Inch Mower: 406 lbs (Manual) 416 lbs (Electric).
Frequently Asked Questions
Q: What type of gasoline should i use? Using regular grade gasoline of fresh is recommended.
- Q: At what intervals should an oil level be measured?
- A: The oil level within the crankcase should be checked after every addition of petrol or once every five work hours.
- Q: When the mower is in use, what is the highest point of cutting that it shall achieve?
- A: The highest point of cut by this mower is three and a half inches.
- Q: How is the engine typically ignited?
- A: In terms of an electric start model, one simply has to rotate the ignition key in a clockwise motion. In the case of manual start, this requires a sharp pull on the recoil starter.
- Q: Is there a recommended course of action, if the mower fails to start?
- A: In this case it is vital to first ensure that the throttle lever has been pushed forward fully, the gearshift lever is at the NEUTRAL position, and finally that the mower clutch lever’s position is still disengaged.
- Q: Is the use of this mower allowed for a child?
- A: No, children should never be allowed to operate a power mower or any riding vehicle.
- Q: Is there any checking on the air cleaner required? If yes, how frequently?
- A: An air cleaner must be serviced after twenty work hours or even less if the environment is dusty.
- Q: What is the recommended course of action in case there is a sensation of abnormal vibrations?
- A: The vibration in question is usually a sign of concern and could be a source of difficulty. Hence it is recommended to turn off the engine and trace the source of the vibration.
User Manual
Loading...