Safety Data Sheet
1 – PRODUCT IDENTIFICATION
PRODUCT NAME: .................... Swell Stainless Steel Cleaner
PRODUCT TYPE: ..................... Solvent Based Cleaning Compound
PRODUCT NUMBER: ............... EP415012 (Last 3 characters vary with the packaging)
CONTROL NUMBER: ............... S5415XXX
COMPANY: ............................... Simoniz USA, Inc.
201 Boston Turnpike
Bolton, CT 06043
1-800-227-5536
www.simoniz.com
EMERGENCY PHONE:............. (800) 255-3924 (CHEM-TEL)
2 – HAZARDS IDENTIFICATION
CLASSIFICATION OF SUBSTANCE/MIXTURE: ..... Flammable Liquids (3) Eye Irritation (2B)
Aspiration Toxicity (1)
SYMBOLS: ................................
SIGNAL WORD: ........................ DANGER!
HAZARD STATEMENT: ............ Flammable liquid and vapour. Causes eye irritation. May be
PRECAUTIONARY STATEMENTS:
PREVENTION: Keep away from heat/sparks/open flames/hot surfaces – No
RESPONSE: ................ IF ON SKIN (or hair): Remove/Take off immediately all
STORAGE: .................. Store in a well ventilated place. Keep cool. Store locked up.
DISPOSAL: ................. Dispose of container and contents in accordance with local
fatal if swallowed and enters airways
smoking. Keep container tightly closed. Ground/bond container
and receiving equipment. Use explosion-proof
electrical/ventilating/light/…/equipment. Use only non-sparking
tools. Take precautionary measures against static discharge.
Wear protective gloves/protective clothing/eye protection/face
protection. Wash hands thoroughly after handling.
contaminated clothing. Rinse skin with water/shower. In case of
fire: Use dry sand, dry chemical or alcohol-resistant foam for
extinction. IF IN EYES: Rinse cautiously with water for several
minutes. Remove contact lenses if present and easy to do –
continue rinsing. If eye irritation persists get medical
advice/attention. IF SWALLOWED: Immediately call a POISON
CENTER or doctor/physician Do NOT induce vomiting
regulations.
PAGE 1 of 5
Safety Data Sheet
INGREDIENT
C.A.S. NUMBER
CONCENTRATION (%)
Hydrotreated Light Distillates
64742-47-8
50-90
Light Mineral Oil U.S.P.
8042-47-5
10-40
3 – COMPOSITION / INFORMATION ON INGREDIENTS
Percentages of ingredients are being withheld as trade secret information. This information will be
disclosed as necessary to authorized individuals.
4 – FIRST-AID MEASURES
BREATHING (INHALATION): ... If victim shows signs of discomfort or irritation, remove to fresh
air. If symptoms persist, get immediate medical attention.
SWALLOWING (INGESTION): . DO NOT INDUCE VOMITING! Drink a large quantity of water or
milk. Do not attempt to give liquids to an unconscious person.
Get immediate medical attention!
EYES: ........................................ Flush eyes with a large quantity of fresh water for at least 15
minutes. If irritation persists, consult a physician.
SKIN (DERMAL): ...................... Flush from skin and clothing with large amounts of fresh water. If
irritation persists, consult physician. Wash contaminated clothing
before wearing.
5 – FIRE-FIGHTING MEASURES
FLASHPOINT: ........................... >180 degrees F.
EXTINGUISHING MEDIA: ......... Water fog or fine spray. Carbon dioxide, Dry chemical or Alcohol
resistant foam.
SPECIAL FIRE FIGHTING PROCEDURES: ............ Firefighters working in areas where this
product is present should be equipped with an approved, fully
enclosed SCBA.
UNUSUAL FIRE AND EXPLOSION HAZARDS: ...... None known.
6 – ACCIDENTAL RELEASE MEASURES
SPILL PROCEDURES: ............. When used according to label instructions, this product will not
harm normal sewer systems. If a large unexpected spill occurs,
dike to prevent spillage into streams or sewer systems and
consult local, state and federal authorities.
WASTE DISPOSAL: ................. As recommended by local, state and federal authorities.
PAGE 2 of 5
Safety Data Sheet
INGREDIENT
C.A.S. NUMBER
PEL
Hydrotreated Light Distillates
64742-47-8
500 ppm PEL
Light Mineral Oil U.S.P.
8042-47-5
5 mg/m3 (mist)
7 – HANDLING and STORAGE
STORAGE: ................................ Store in a cool, well ventilated area. Avoid overheating or
freezing.
HANDLING: ............................... Under normal use according to label instructions, special
protection should not be necessary. Wear eye protection if
product is likely to splash.Do not place this product in an
unmarked container! Keep away from children! Spilled material is
slippery.
8 – EXPOSURE CONTROLS / PERSONAL PROTECTION
RESPIRATORY PROTECTION: Not usually needed in well-ventilated areas. If needed, use a
NIOSH approved respirator.
PROTECTIVE CLOTHING: ....... Nitrile or PVC gloves, and chemical splash goggles.
ADDITIONAL MEASURES: ...... Under normal use according to label instructions, special
protection should not be necessary. Wear eye protection if
product is likely to splash.Do not place this product in an
unmarked container! Keep away from children! Spilled material is
slippery.
9 – PHYSICAL / CHEMICAL PROPERITES
APPEARANCE & ODOR: ......... Transparent liquid, spearmint scented.
ODOR THRESHOLD: ............... N/A
pH: ............................................. N/A
MELTING POINT: ..................... N/A
FREEZING POINT: ................... N/A
BOILING POINT:....................... 210 degrees F.
BOILING POINT RANGE: ......... N/A
FLASHPOINT: ........................... >180 degrees F.
EVAPORATION RATE: ............. N/A
FLAMMABILITY (solid/gas):.... N/A
EXPLOSION LIMITS: ................ N/A
VAPOR PRESSURE: ................ .0005 PSIA@ 68 F
VAPOR DENSITY (AIR=1): ....... Greater than 1.
SPECIFIC GRAVITY: ................ Less than 1.
SOLUBILITY IN WATER: ......... Insoluble.
PARTITION COEFFICIENT: ..... N/A
AUTO-IGNITION TEMPERATURE: .......................... N/A
DECOMPOSITION TEMPERATURE: ...................... N/A
VISCOSITY: .............................. Water thin
PAGE 3 of 5
Safety Data Sheet
10 – STABILITY and REACTIVITY
STABILITY: ............................... Stable under normal conditions.
HAZARDOUS DECOMP.: ......... This product not known to polymerize.
INCOMPATIBILITY: .................. Do not mix with other chemicals.
11 – TOXICOLOGICAL INFORMATION
ROUTE(S) OF ENTRY: ............. Inhalation, skin absorption, or ingestion.
LISTED CARCINOGEN: ........... None over 0.1%.
MEDICAL CONDITION AGGRAVATED: .................. May aggravate pre-existing dermatitis.
INHALATION: ............................ Not likely to be inhaled in hazardous amounts. Avoid exposure to
mists or vapors. Maintain adequate ventilation in the work area.
INGESTION: .............................. Swallowing even small amounts may be harmful. Effects may be
nausea, headache, vomiting and central nervous system depression.
EYES: ........................................ May cause severe eye irritation.
SKIN (DERMAL): ...................... This product may cause irritation if not removed from the skin.
Prolonged exposure may cause central nervous system depression.
ACUTE TOXICITY* (ORAL):…… ............................. >2000 mg/kg
ACUTE TOXICITY* (DERMAL):.. ............................. >2000 mg/kg
ACUTE TOXCITY* (INHALATION): .......................... >20,000 ppm V (Gas), >20 mg/l (Vapor), >5
mg/l (Dust)
*Determined using the additivity formula for mixtures (GHS Purple Book, 3.1.3.6)
12 – ECOLOGICAL INFORMATION
ENVIRONMENTAL FATE AND DISTRIBUTION: N/A
13 –DISPOSAL CONSIDERATIONS
WASTE DISPOSAL: ................. As recommended by local, state and federal authorities.
14 – TRANSPORTATION INFORMATION
PROPER SHIPPING NAME: ..... Not D.O.T. regulated in these container sizes.
HAZARD CLASS: ......................
UN/NA NUMBER: .....................
PACKAGING GROUP : .............
15 - REGULATIONS
Contents of this MSDS comply with the OSHA Hazard Communication Standard 29CFR
1910.1200
PAGE 4 of 5
Safety Data Sheet
16 – OTHER INFORMATION
NFPA HEALTH: ........................ 1
NFPA FLAMMABILITY: ............ 1
NFPA REACTIVITY: .................. 0
NFPA OTHER: .......................... None
ADDITIONAL: ............................ The information contained in this SDS is based on the data
available to us from sources we believe to be reliable. No
warranty or guaranty expressed or implied is made regarding the
accuracy of this data or the results obtained from the reliance on
this data. The manufacturer assumes no responsibility for injury
from the use of this product. Be safe- read this product safety
information and pass it on to all persons who may be exposed to
this product. Federal law requires it. This product and/or all of its
components are either included on or exempt from the TSCA
Inventory of Chemical Substances.
REVISION DATE: ...................... 05/28/15
PAGE 5 of 5
Loading...