Manufacturer
Simoniz, USA
201 Boston Turnpike
Bolton, CT 06043
Safety Data Sheet
SDS
Simoniz Instant Spray Release Agent S3327012
Revision Date: 4/6/2015SDS Number: 5246-AP5246
1 8
Page of
PRODUCT AND COMPANY IDENTIFICATION1
Phone:
Product Name:
Revision Date:
Version:
SDS Number:
Common Name:
Product Use:
(800) 227-5536
Simoniz Instant Spray Release Agent S3327012
4/6/2015
2
5246-AP5246
Silicone Aerosol
Release Agent
HAZARDS IDENTIFICATION2
Skin - Yes Eyes - Yes Inhalation - Yes Ingestion - UnlikelyRoute of Entry:
Target Organs: Skin; Eyes; Gastrointestinal tract; Respiratory system;
Inhalation: May cause respiratory tract irritation. This product may be aspirated into the lungs and cause chemical pneumonitis.
Skin Contact: May cause irritation.
Eye Contact: May cause irritation.
Ingestion: Ingestion is not an applicable route of entry for intended use. Harmful: may cause lung damage if swallowed.
NFPA:
HMIS III:
Health = 1, Fire = 4, Reactivity = 0
H1/F4/PH0
4
1 0
1
4
0
Cas # | Percentage | Chemical Name
-------------------------------------------------------------------------------------------------------
68476-86-8 | 60-90% | Propane/ Isobutane
67-64-1 | 10-20% | 2-Propanone
64742-47-8 | 10-20% | Distillates, petroleum, hydrotreated light
Safety Data Sheet
SDS
Simoniz Instant Spray Release Agent S3327012
Revision Date: 4/6/2015SDS Number: 5246-AP5246
2 8
Page of
GHS Signal Word:
DANGER
GHS Hazard Pictograms:
GHS Classifications:
Physical, Flammable Aerosols, 1
Health, Acute toxicity, 4 Oral
Health, Skin corrosion/irritation, 2
Health, Serious Eye Damage/Eye Irritation, 2 A
Health, Acute toxicity, 5 Inhalation
Health, Specific target organ toxicity - Single exposure, 3
GHS Phrases:
H222 - Extremely flammable aerosol
H229 - Pressurized container: may burst if heated
H302 - Harmful if swallowed
H315 - Causes skin irritation
H319 - Causes serious eye irritation
H333 - May be harmful if inhaled
H336 - May cause drowsiness or dizziness
GHS Precautionary Statements:
P102 - Keep out of reach of children.
P211 - Do not spray on an open flame or other igntion source.
P251 - Pressurized container: Do not pierce or burn, even after use.
P281 - Use personal protective equipment as required.
P301+330+331 - IF SWALLOWED: Rinse mouth. Do NOT induce vomiting.
P302+352 - IF ON SKIN: Wash with soap and water.
P305+351+338 - IF IN EYES: Rinse continuously with water for several minutes. Remove contact lenses if present and easy to do.
Continue rinsing.
P341 - If breathing is difficult, remove victim to fresh air and keep at rest in a position comfortable for breathing.
P410+412 - Protect from sunlight. Do not expose to temperatures exceeding 50 °C/122 °F
P340 - Remove victim to fresh air and keep at rest in a position comfortable for breathing.
COMPOSITION/INFORMATION ON INGREDIENTS3
Ingredients:
Use personal protection recommended in Section 8. Isolate the hazard
area and deny entry to unnecessary and unprotected personnel. Eliminate sources of ignition.
Ruptured cylinders may rocket.
Many gases are heavier than air and will spread along ground
and collect in low or confined areas (sewers, basements, tanks). This material is a water
pollutant. Keep out of drains, sewers, ditches, and waterways. Minimize use of water to prevent
environmental contamination.
Contain and/or absorb spill with inert material (e.g. sand,
vermiculite), then place in a suitable container. Do not flush to sewer or allow to enter
waterways. Use appropriate Personal Protective Equipment (PPE).
Vacuum or sweep material and place in a disposal container. Allow
gas to dissipate harmlessly into the atmosphere.
Safety Data Sheet
Page of
SDS
Simoniz Instant Spray Release Agent S3327012
Revision Date: 4/6/2015SDS Number: 5246-AP5246
3 8
4
Inhalation:
Skin Contact:
Eye Contact:
Ingestion:
FIRST AID MEASURES
Move to fresh air and keep at rest. Call a physician if symptoms develop and persist.
Remove contaminated clothing and shoes. Rinse skin with water. If irritation develops and persists, get medical
attention.
Immediately flush eyes with large amounts of water for at least 15 minutes, lifting eyelids occasionally to facilitate
irrigation.
Rinse mouth. Do not induce vomiting without advice from poison control center. If vomiting occurs, keep head low to
avoid getting into the lungs. Call a poison control center if large amounts are ingested.
FIRE FIGHTING MEASURES5
Flammability: Extremely Flammable per Flame Projection Test
Flash Point: 1°F (-17°C) (Concentrate)
Flash Point Method: Estimated
Burning Rate: Not available.
Autoignition Temp: Not available.
LEL: Not available.
UEL: Not available.
Means of Extinction:
Suitable Extinguishing Media: Powder, water spray, foam, carbon dioxide.
Unsuitable Extinguishing Media: Not available.
Products of Combustion: May include, and are not limited to: oxides of carbon.
Explosion Data:
Sensitivity to Mechanical Impact: Not available.
Sensitivity to Static Discharge: Not available.
Protection of Firefighters: Containers may explode when heated. Keep upwind of fire. Wear
full fire fighting turn-out gear (full Bunker gear) and respiratory protection (SCBA).
ACCIDENTAL RELEASE MEASURES6
Personal Precautions:
Environmental Precautions:
Methods for Containment:
Methods for Clean-Up:
EXPOSURE LIMITS
Propane/ Isobutane Not established 1000 ppm
2-Propanone 1000 ppm 500 ppm (750 ppm STEL)
Distillates, petroleum, Not established Not established
Mixture packaged in pressurized aerosol spray can.
0.83 - 0.84g/ml
< 5 cSt
>100°F
Flammable
Not established
Not applicable
>1.00 (BuAc=1)
Safety Data Sheet
Page of
SDS
Simoniz Instant Spray Release Agent S3327012
Revision Date: 4/6/2015SDS Number: 5246-AP5246
4 8
HANDLING AND STORAGE7
Handling Precautions:
Storage Requirements:
Contents under pressure. Keep out of reach of children. Read label cautions carefully. Follow label
directions to avoid injury. Use with adequate ventilation. Do not use in confined areas. Keep away from
heat, sparks or open flames. Wash hands thoroughly after each use. Do not smoke while using. Avoid
contact with skin and eyes. Avoid breathing vapor or mist. Do not puncture container.
Keep out of reach of children. Do not store near heat, sparks, or open flames. Do not expose to
temperatures above 120°F as container may vent, rupture or burst. Do not puncture or incinerate
container. Do not store in direct sunlight. Store in a cool, dry, well-ventilated area away from
incompatible materials.
Store in accordance with NFPA 30B for LEVEL 3 AEROSOL.
EXPOSURE CONTROLS/PERSONAL PROTECTION8
Engineering Controls:
Personal Protective Equip:
INGREDIENTS OSHA-PEL ACGIH-TLV
hydrotreated light
Maintain adequate ventilation.
Respiratory Protection not required for normal use.
Chemical resistant gloves;
Usage of safety glasses/ goggles is recommended.
PHYSICAL AND CHEMICAL PROPERTIES9
Appearance: clear slightly yellow liquid
Physical State:
Spec Grav./Density:
Viscosity:
Boiling Point:
Flammability:
Vapor Pressure:
pH:
Evap. Rate:
Odor:
Solubility:
Percent Volatile:
Heat Value:
Flash Point:
Vapor Density:
VOC:
Auto-Ignition Temp:
UFL/LFL:
STABILITY AND REACTIVITY10
Stability:
Conditions to Avoid:
Materials to Avoid:
Hazardous Decomposition:
Hazardous Polymerization:
Product is stable under normal conditions.
heat, sparks, open flames and temperatures above 120°F
Strong Oxidizing Agents.
CO, CO2, and hydrocarbons.
Will not occur.
fruity-solvent
Insoluble
72%
Not established
1°F (-17°C) (Concentrate)
Not established
33% (1.50 MIR)
Not established
Not established
marked redness and swelling of the conjunctiva.
Skin Effects: May cause skin irritation. Handling can cause dry skin.
chemical pneumonitis.
Chronic Effects: Not Hazardous by WHMIS/OSHA criteria.
Carcinogenicity: Not Hazardous by WHMIS/OSHA criteria.
Mutagenicity: Not Hazardous by WHMIS/OSHA criteria.
Teratogenicity: Not Hazardous by WHMIS/OSHA criteria.
May cause long-term adverse effects in the aquatic environment
Not available.
Not available.
Safety Data Sheet
Page of
SDS
Simoniz Instant Spray Release Agent S3327012
Revision Date: 4/6/2015SDS Number: 5246-AP5246
5 8
TOXICOLOGICAL INFORMATION11
Toxicity Data:
Eye Effects: May cause eye irritation. Symptoms may include discomfort or pain,excess blinking and tear production, with
Accute Inhalation Effects: May cause respiratory tract irritation. This product may be aspirated onto the lungs and cause
ECOLOGICAL INFORMATION12
Ecotoxicity:
Persistence / Degradability:
Bioaccumulation / Accumulation:
Mobility in Environment: Not available.
DISPOSAL CONSIDERATIONS13
Do not allow into drains or water sourses. Waste and empty containers should be disposed of in accordance with regulations made under
the Control of Pollution Act and the Enviromental Protection Act. Using information provided in this data sheet advice should be obtained
from the Waste Regulation Authority, weather special waste regulations apply.
DOT
UN Number UN1950
UN proper shipping name Aerosols, flammable
Transport Hazard Class(es)
Class 2.1
Subsidiary risk ---
Label(s) 2.1
Packing group Not applicable
IATA
UN Number UN1950
UN proper shipping name Aerosols, flammable
Transport Hazard Class(es)
Class 2.1
Subsidiary risk ---
Label(s) 2.1
Packing group Not applicable
Environmental hazards No
Other information
Passenger and cargo aircraft Allowed
Cargo aircraft only Allowed
IMDG
UN Number UN1950
UN proper shipping name Aerosols, flammable
Transport Hazard Class(es)
Class 2.1
Subsidiary risk ---
Label(s) 2.1
Packing group Not applicable
Environmental hazards No
Simoniz Instant Spray Release Agent S3327012
Page of
SDS
TRANSPORT INFORMATION14
DOT Class: Flammable Gas (2.1) #2.1
UN #: UN 1950, Class: 2, Proper Shipping Name: Aerosols, flammable
Safety Data Sheet
Revision Date: 4/6/2015SDS Number: 5246-AP5246
6 8
*Propane/ Isobutane (68476868 60-90%) TSCA
TXHWL
*Distillates, petroleum, hydrotreated light (64742478 10-20%) TSCA
REGULATORY KEY DESCRIPTIONS
----------------------------------------------------------------
TSCA = Toxic Substances Control Act
MASS = MA Massachusetts Hazardous Substances List
NJHS = NJ Right-to-Know Hazardous Substances
OSHAWAC = OSHA Workplace Air Contaminants
PA = PA Right-To-Know List of Hazardous Substances
TXAIR = TX Air Contaminants with Health Eects Screening Level
SARA313 = SARA 313 Title III Toxic Chemicals
CERCLA = Superfund clean up substance
HAP = Hazardous Air Pollutants
TOXICRCRA = RCRA Toxic Hazardous Wastes (U-List)
TXHWL = TX Hazardous Waste List
- California Safe Drinking Water and Toxic Enforcement Act of 1986
Proposition 65 at levels which would be subject to the proposition.
Safety Data Sheet
Page of
SDS
Simoniz Instant Spray Release Agent S3327012
Revision Date: 4/6/2015SDS Number: 5246-AP5246
7 8
REGULATORY INFORMATION15
*2-Propanone (67641 10-20%) CERCLA, HAP, MASS, NJHS, OSHAWAC, PA, SARA313, TOXICRCRA, TSCA, TXAIR,
Proposition 65
This product is not known to contain any chemicals currently listed as carcinogens or reproductive toxins under California
to be
and
Safety Data Sheet
Page of
SDS
Simoniz Instant Spray Release Agent S3327012
Revision Date: 4/6/2015SDS Number: 5246-AP5246
8 8
OTHER INFORMATION16
The information provided herein was believed to be accurate at the time of preparation and prepared from a compilation of sources believed
reliable, but it is the responsibility of the user to investigate and understand other pertinent sources of information, to comply with all laws
procedures applicable to the safe handling and use of this product, and to determine the suitability of the product for its intended use.
Publication Date: 4/6/2015
Revision No.: 2
Loading...