Shurflo 136-0000-CP Installation Manual
INSTALLATION INSTRUCTIONS
OEM Version
Attention Manufacturers
Please include this Installation
Instruction sheet with your Owner’s
Documentation.
:
136-0000-CP
Universal
Recessed Shower
Chrome
1
2
3
(1) Check desired position to make sure there is enough room for the hose to gather under the
deck or inside the wall without getting caught on anything. Drill 2
location.
(2) Place the recessed cup and lid into the hole.
Wall Mount—Place into the hole with the hinge pointing DOWN. This will allow the lid to
fall out of the way of the hose when in use. Please note
the back hole when the sprayer is resting in the recessed cup. It is important to ensure
there is ample clearance for the trigger, in order to prevent accidental discharge. Secure
recessed cup and lid using the provided four (4) screws.
Deck Mount—Place into the hole with the hinge pointing in the desired direction for the
lid to easily lay open when in use. Please note
hole when the sprayer is resting in the recessed cup. It is important to ensure there is
ample clearance for the trigger, in order to prevent accidental discharge. Secure
recessed cup and lid using the provided four (4) screws.
(3) Slide hose/sprayer assembly through the appropriate hole in the recessed cup, as illustrated.
: The trigger will stick out through the side
7
/8” to 3” hole in the desired
: The trigger will stick out through
4
5
(4) Connect to desired 1/2” NPT-Male water source or valve. Make sure rubber washer is in
place in the female hose fitting.
(5) This sprayer has two functions: intermittent and continuous. For intermittent spray, simply
press down on the trigger. For continuous spray, lift up on the trigger until it locks. To
release, simply press the trigger back down. If you wish the remove the hook from the
sprayer, unscrew the face. Slide the hook ring off the sprayer and remove the large, black,
flat washer from inside the face. Replace the face.
136-0000-CP
Universal
Recessed Shower
Parts
1) Small Sprayer
2) Washer
3) 72” Hose
1
2
4) Washer
5) Recessed Cup
6) Lid
7) Mounting Screws (4x)
3
1/
8
" 2
5/
8
"
Chrome
3
3
/
8
" 4
2
1
/
4
"
2
7
/
8
"
7
6
5
1
/
4
"
4
3
4
1/
8
"
1
1
/
8
"
1
/
8
"
1
/
2
"-14 NPSF
72"
PROPER FINISH CARE:
Your new accessory is protected by a clear-coat. To clean it, you only need to wipe it with a damp, soft cloth.
NEVER use any abrasive cleaners, steel wool, or chemicals, as they will harm the finish and void your warranty. If
the accessory will be installed in a salt-air environment (boat exterior), regular cleaning with gentle soap and
carnauba wax will prolong the life of the finish.
LIMITED WARRANTY
SHURflo Marine Grade Faucets & Accessories are guaranteed to be free from material and workmanship defects under normal use and service for a
period of three (3) years from the date of manufactured vessel for all indoor applications and two (2) years from the date of manufactured vessel for all
outdoor applications. This limited warranty will not apply to faucets or accessories that were improperly installed, misapplied, or incompatible with
components not manufactured by SHURflo. Faucet failure due to foreign debris is not covered under the terms of this limited warranty. SHURflo
will not warrant any faucet that is physically damaged, or altered outside the SHURflo factory. Warranty claims may be resolved by a SHURflo
service center. All returns are to be shipped with charges pre-paid. Package all returns carefully. SHURflo will not be responsible for freight
damage incurred during shipping to a service center. SHURflo's obligation under this warranty policy is limited to the repair or replacement of the
faucets & accessories. Faucets or accessories found not defective (under the terms of this limited warranty) are subject to charges to be paid by the
returnee for the testing and packaging of "tested good" units. Warranty returns will be shipped on a freight allowed basis. SHURflo reserves the
right to choose the method of transportation. SHURflo is not responsible nor will it reimburse for labor necessary to remove and reinstall a faucet or
accessory, if found defective. This warranty is only a representation of the complete Marine Products Limited Warranty outlined by Service Bulletin #1050.
SHURflo reserves the right to update specifications, prices, or make substitutions.
SHURflo*
5900-A Katella Ave.
Cypress, CA 90630
(562) 795-5200 (800) 854-3218
FAX (562) 795-7564
Shipping: 5900-C Katella Ave.
Cypress, CA 90630
(574) 262-0478 (800) 762-8094
SHURflo East
52748 Park Six Court
Elkhart, IN 46514-5427
FAX (574) 264-2169
http://www.shurflo.com
SHURflo Ltd.*
Unit 5 Sterling Park
Gatwick Road, Crawley
West Sussex, RH10 2QT
United Kingdom
+44 1293 424000
FAX +44 1293 421880
911-xxx-136-0000-CP
Rev. 7/04
© 2004, SHURflo
Loading...