Shurflo 134-0132-CP Installation Manual
INSTALLATION INSTRUCTIONS
OEM Version
Attention Manufacturers
Please include this Installation
Instruction sheet with your Owner’s
Documentation.
1
(1) Turn off the water supply to your existing faucet (this procedure will vary depending on the
specific plumbing system installed on your boat).
(2) Unscrew the lock nut, metal washer and one gasket off the back of the valve body and slide off
over the copper pipes. You may need to very gently bend the copper pipes closer together to
2
allow the lock nut and mental washer to slide over the fittings.
:
134-0132-CP
Stasis
Single Handle Shower
Chrome
(3) Ensure that when the handle is in the off position (straight down) it lines up with the marking on
the wall plate. If adjustment is needed, slightly loosen the escutcheon, adjust the wall plate and
re-tighten.
3
A
p
p
r
o
x
.
4
5
D
e
g
r
e
e
s
s
e
e
r
g
e
D
5
4
.
x
o
r
p
p
A
(4) From the front side of the bulkhead, slide the valve assembly with the handle still attached
through the hole in the bulkhead.
4
(5) From the back side of the bulkhead, secure shower mixer by sliding the gasket, metal washer and
lock nut back on over the copper pipes. Tightening against the back side of the bulkhead.
(6) Connect hot/cold water supply lines (not provided) to the inlet tubes. The inlet tubes are the 1/2”
NPT-Male copper tubes on the left and right sides of the valve, which are curved downward to
5
approx 90 degrees. This procedure will vary depending on the specific plumbing system installed
on your boat. Using an swivel elbow fitting (not included), connect 1/2” NPT water line from the
shower head or bulkhead elbow (not included) to the shower head (straight) port. Wrap all fittings
with Teflon (Plumber’s) tape.
(7) After installation is complete, turn the water supply back on and allow both hot and cold water to
6
run for at least one full minute. While water is running, check all connections for leaks.
Connections may need re-tightening.
13
12
11
10
Parts
1) Blue/Red Cap
2) Handle Screw
3) Stasis Handle
4) Cap
5) Retainer Nut
6) Ceramic Disk Cartridge
7) Escutcheon
8) O-Ring
9) Wall Plate
10) Gasket
11) Metal Washer
12) Lock Nut
13) Valve Body
9
8
7
6
5
134-0132-CP
Stasis
Single Handle Shower
Chrome
7"
4"
4
1
/
2
3
"-14 NPS-M
3
3/
4
"
2
1
PROPER FINISH CARE:
Your new faucet is protected by a clear-coat. To clean it, you only need to wipe it with a damp, soft cloth. NEVER
use any abrasive cleaners, steel wool, or chemicals, as they will harm the finish and void your warranty. If the
faucet will be installed in a salt-air environment (boat exterior), regular cleaning with gentle soap and carnauba wax
will prolong the life of the finish.
LIMITED WARRANTY
SHURflo Marine Grade Faucets & Accessories a re guaranteed to be free from m aterial and workmanship defects under norm al use and service for a
period of three (3) years from the date of manufactured vessel for al l ind oor applicat ions an d t wo (2) years from t he date of m anufactured vessel for a l l
outdoor applications. This lim ited wa rrant y will not apply to faucets or accessories that were improperly installed, misapplied, or incompatible with
components not manufactured by SHURflo. Faucet failure due to foreign debris is not covered under the terms of this limited warranty. SHURflo
will not warrant any faucet that is physically damaged, or altered outside the SHURflo factory. Warranty claims may be resolved by a SHURflo
service center. All returns are to be shipped with charges pre-paid. Package all returns carefully. SHURflo will not be responsible for freight
damage incurred during shipping to a service center. SHURflo's obligation under this warranty policy is limited to the repair or replacement of the
faucets & accessories. Faucets or accessories found not defective (under the terms of this limited warranty) are subject to charges to be paid by the
returnee for the testing and packaging of "tested good" units. Warranty returns will be shipped on a freight allowed basis. SHURflo reserves the
right to choose the method of transportation. SHURflo is not responsible nor will it reimburse for labor necessary to remove and reinstall a faucet or
accessory, if found defective. Thi s w a r r a n t y i s o n l y a r e p resent a t ion of t h e c o m p l e t e M a r i n e P r o d u c t s Limi t e d W a r r a n t y o u t l i n e d by Service Bulletin #1050.
SHURflo reserves the right to update specifications, prices, or make substitutions.
SHURflo*
5900-A Katella Ave.
Cypress, CA 90630
(562) 795-5200 (800) 854-3218
FAX (562) 795-7564
Shipping: 5900-C Katella Ave.
Cypress, CA 90630
SHURflo East
52748 Park Six Court
Elkhart, IN 46514-5427
(574) 262-0478 (800) 762-8094
FAX (574) 264-2169
http://www.shurflo.com
SHURflo Ltd.*
Unit 5 Sterling Park
Gatwick Road, Crawley
West Sussex, RH10 2QT
United Kingdom
+44 1293 424000
FAX +44 1293 421880
134-0132-CP
Rev. 2/07
© 2007, SHURflo
Loading...