Shurflo 133-0216-SS Installation Manual

INSTALLATION INSTRUCTIONS

Your new SHURflo Marine Grade Faucet will
give you years of trouble-free performance.
Thank you for choosing SHURflo Marine
Grade Faucets. Please read these instructions
carefully before installing your new faucet. If
you have any additional questions about the
installation of this faucet, please feel free to
contact one of our friendly customer service
representatives at 1-800-854-3218.

(1) Hold spigot on the wall where desired. Make sure to leave enough room for your

1

hose to hang freely. Drill 1” hole in the wall in the desired location.

(2) Make sure male nipple is tight into the spigot. Slip nipple through the hole in the

wall. Make sure gasket properly lines up with the back of the spigot. From the
back side of the wall, slide the rubber and metal washers onto the nipple. Thread
the lock nut onto the brass nipple and tighten.

2

133-0216-SS

Trinidad

Washdown Spigot

Stainless Steel

(3) Connect water supply lines (not provided) to the nipple. Wrap the end of the nipple

with Teflon (Plumber’s) tape. Follow the appropriate steps depending on your water
supply lines. If you have a pre-assembled water supply hose with a threaded
connector, simply screw on supply hose. If you have plastic water lines with formed
ends, water line will seat partially up into the brass nipple. Connect by tightening
the coupling nut. We do NOT suggest using sweat fittings as they are prone to

3

blow-outs.

(4) Attach your garden hose to the bib. Turn the water supply on. While water is

running, check all connections for leaks. Connections may need re-tightening.

4

11

10

133-0216-SS

Trinidad

Washdown Spigot

Parts

1

1) Blue Cap

2

3

4

9

8

7

5

6

2) Handle Screw

3) Trinidad Handle

4) Compression Cartridge

5) Body

6) Hose Bib

7) Gasket

8) 1/2” Nipple

9) Rubber Washer

10) Metal Washer

11) Lock Nut

Stainless Steel

PROPER FINISH CARE:

Your new faucet is protected by a clear-coat. To clean it, you only need to wipe it with a damp, soft cloth. NEVER
use any abrasive cleaners, steel wool, or chemicals, as they will harm the finish and void your warranty. If the
faucet will be installed in a salt-air environment (boat exterior), regular cleaning with gentle soap and carnauba wax
will prolong the life of the finish.

LIMITED WARRANTY

SHURflo Marine Grade Faucets & Accessories are guaranteed to be free from material and workmanship defects under normal use and service for a period of
five (5) years from the date of purchase. This limited warranty will not apply to faucets or accessories that were improperly installed, misapplied, or
incompatible with components not manufactured by SHURflo. Faucet failure due to foreign debris is not covered under the terms of this limited warranty.
SHURflo will not warrant any faucet that is physically damaged or altered outside the SHURflo factory. Warranty claims may be resolved by a SHURflo
service center. All returns are to be shipped with charges pre-paid. Package all returns carefully. SHURflo will not be responsible for freight damage
incurred during shipping to a service center. SHURflo's obligation under this warranty policy is limited to the repair or replacement of the faucets &
accessories. Faucets or accessories found not defective (under the terms of this limited warranty) are subject to charges to be paid by the returnee for the
testing and packaging of "tested good" units. Warranty returns will be shipped on a freight allowed basis. SHURflo reserves the right to choose the method
of transportation. SHURflo is not responsible nor will it reimburse for labor necessary to remove and reinstall a faucet or accessory if found defective. This
warranty is only a representation of the complete Marine Products Limited Warranty outlined by Service Bulletin #1050.

SHURflo reserves the right to update specifications, prices, or make substitutions.

SHURflo*

5900-A Katella Ave.

Cypress, CA 90630

[phone] [phone]

FAX [phone]

Shipping: 5900-C Katella Ave.

Cypress, CA 90630

[phone] [phone]

SHURflo East

52748 Park Six Court

Elkhart, IN 46514-5427

FAX [phone]

http://www.shurflo.com

SHURflo Ltd.*

Unit 5 Sterling Park

Gatwick Road, Crawley

West Sussex, RH10 2QT

United Kingdom

[phone]

FAX [phone]

© 2004, SHURflo