Shurflo 133-0209-CP Installation Manual

INSTALLATION INSTRUCTIONS

Your new SHURflo Marine Grade Faucet will
give you years of trouble-free performance.
Thank you for choosing SHURflo Marine
Grade Faucets. Please read these instructions
carefully before installing your new faucet. If
you have any additional questions about the
installation of this faucet, please feel free to
contact one of our friendly customer service
representatives at 1-800-854-3218.

133-0209-CP

Trinidad

Elite Folding Tap

Chrome

1

2

3

4

(1) Turn off the water supply to your existing faucet (this procedure will vary depending on the

specific plumbing system installed on your boat). Cover the sink drain to prevent any small
parts or debris from falling in. Remove your existing faucet, taking care not to damage your
existing water lines. Clean sink area in preparation for new faucet.

(2) Place your new faucet through the hole in your sink. From under the sink, thread the lock

nut onto the brass inlet tube and tighten. It may be necessary to re-adjust the faucet
position by slightly loosening the lock nut, adjusting to desired location, then re-tightening
the lock nut.

(3) Connect water supply line (not provided) to the inlet tube. Wrap the end of the inlet tube

with Teflon (Plumber’s) tape. Follow the appropriate steps depending on your water supply
line. If you have a pre-assembled water supply hose with threaded connectors, simply
screw on supply hose. If you have a plastic water lines with a formed end, water line will
seat partially up into the brass tube. Connect by tightening the coupling nut. We do NOT
suggest using sweat fittings as they are prone to blow-outs.

(4) Turn the water supply back on and allow the water to run for at least one full minute. While

water is running, check connections for leaks. Connections may need re-tightening.

14

15

16

17

11

13

133-0209-CP

Trinidad

Elite Folding Tap

Parts

1) Blue Cap

2) Handle Screw

3) Trinidad Handle

4) Ceramic Disc Cartridge

5) Valve

6) O-Ring

7) Inlet Tubes

1

2

3

4

5

9

6

10

8) Lock Nut

9) Packing Ring

10) O-Ring

11) O-Ring

12) Spool

13) Diffuser

14) Spout

15) Bonnet

16) C-Clamp

17) O-Ring

18) Spout Pivot

19) Packing Ring

20) End Cap

Chrome

12

7

18

19

8

20

PROPER FINISH CARE:

Your new faucet is protected by a clear-coat. To clean it, you only need to wipe it with a damp, soft cloth. NEVER
use any abrasive cleaners, steel wool, or chemicals, as they will harm the finish and void your warranty. If the
faucet will be installed in a salt-air environment (boat exterior), regular cleaning with gentle soap and carnauba wax
will prolong the life of the finish.

LIMITED WARRANTY

SHURflo Marine Grade Faucets & Accessories are guaranteed to be free from material and workmanship defects under normal use and service for a period of
five (5) years from the date of purchase. This limited warranty will not apply to faucets or accessories that were improperly installed, misapplied, or
incompatible with components not manufactured by SHURflo. Faucet failure due to foreign debris is not covered under the terms of this limited warranty.
SHURflo will not warrant any faucet that is physically damaged or altered outside the SHURflo factory. Warranty claims may be resolved by a SHURflo
service center. All returns are to be shipped with charges pre-paid. Package all returns carefully. SHURflo will not be responsible for freight damage
incurred during shipping to a service center. SHURflo's obligation under this warranty policy is limited to the repair or replacement of the faucets &
accessories. Faucets or accessories found not defective (under the terms of this limited warranty) are subject to charges to be paid by the returnee for the
testing and packaging of "tested good" units. Warranty returns will be shipped on a freight allowed basis. SHURflo reserves the right to choose the method
of transportation. SHURflo is not responsible nor will it reimburse for labor necessary to remove and reinstall a faucet or accessory if found defective. This
warranty is only a representation of the complete Marine Products Limited Warranty outlined by Service Bulletin #1050.

SHURflo reserves the right to update specifications, prices, or make substitutions.

SHURflo*

5900-A Katella Ave.

Cypress, CA 90630

[phone] [phone]

FAX [phone]

Shipping: 5900-C Katella Ave.

Cypress, CA 90630

SHURflo East

52748 Park Six Court

Elkhart, IN 46514-5427

[phone] [phone]

FAX [phone]

http://www.shurflo.com

SHURflo Ltd.*

Unit 5 Sterling Park

Gatwick Road, Crawley

West Sussex, RH10 2QT

United Kingdom

[phone]

FAX [phone]

© 2004, SHURflo