Shurflo 132-0204-CP Installation Manual

INSTALLATION INSTRUCTIONS

OEM Version

Attention Manufacturers

Please include this Installation

Instruction sheet with your Owner’s

Documentation.

:

132-0204-CP

Trinidad

Angled

Galley / Wet Bar Faucet

Chrome

1

2

3

4

(1) Turn off the water supply to your existing faucet (this procedure will vary depending on the

specific plumbing system installed on your boat). Cover the sink drain to prevent any small
parts or debris from falling in. Remove your existing faucet, taking care not to damage your
existing water lines. Clean sink area in preparation for new faucet.

(2) Screw mounting bolt into the bottom of the faucet. One end of the bolt is slotted to allow

the use of a screwdriver to secure. Screw both connector hoses into the bottom of faucet
(note: it is NOT necessary to use Teflon (Plumber’s) tape on this connection as the o-rings
will prevent leaks). Use a wrench or pliers on the hex nut molded into the brass shaft
portion of the hoses. Do NOT attempt to tighten by turning the hose itself.

(3) Place your ne w faucet through the hole in your sink. Make sure the black gasket properly

lines up with the bottom of the faucet. From under the sink, slide the rubber horseshoe
washer then the metal horseshoe washer onto the mounting bolt. Adjust faucet position on
the sink as desired. Thread the lock nut onto the mounting bolt and tighten. It may be
necessary to re-adjust the faucet position by slightly loosening the lock nut, adjusting to
desired location, then re-tightening the lock nut.

(4) Connect water supply lines (not provided) to the connector hoses. Wrap the brass fittings

on the connector hoses with Teflon (Plumber’s) tape. Follow the appropriate steps
depending on your water supply lines. If you have pre-assembled water supply hoses with
threaded connectors, simply screw on supply hose. If you have plastic water lines with
formed ends, water lines will seat partially up into the brass fittings. Connect by tightening
the coupling nuts. We do NOT suggest using sweat fittings as they are prone to blow-outs.

5

(5) After installation is complete, remove the aerator. Be careful not to scratch the finish. Turn

the water supply back on and allow both hot and cold water to run for at least one full
minute. While water is running, check all connections for leaks. Replace aerato r.
Connections may need re-tightening.

Parts

1) Blue/Red Cap

2) Handle Screw

3) Trinidad Handle

4) Ceramic Disc Cartridge

5) Aerator

6) Spout

7) Spout Bonnet

8) Spout C-Clamp

9) Spout O-Rings

10) Body

11) Gasket

12) Rubber Horseshoe Washer

13) Metal Horseshoe Washer

14) Mounting Bolt

15) Lock Nut

16) Connector Hoses

132-0204-CP

Trinidad

Angled

Galley / Wet Bar Faucet

Chrome

PROPER FINISH CARE:

Your new faucet is protected by a clear-coat. To clean it, you only need to wipe it with a damp, soft cloth. NEVER
use any abrasive cleaners, steel wool, or chemicals, as they will harm the finish and void your warranty. If the
faucet will be installed in a salt-air environment (boat exterior), regular cleaning with gentle soap and carnauba wax
will prolong the life of the finish.

LIMITED WARRANTY

SHURflo Marine Grade Faucets & Accessories a re guaranteed to be free from m aterial and workmanship defects under norm al use and service for a
period of three (3) years from the date of manufactured vessel for al l ind oor applicat ions an d t wo (2) years from t he date of m anufactured vessel for a l l
outdoor applications. This lim ited wa rrant y will not apply to faucets or accessories that were improperly installed, misapplied, or incompatible with
components not manufactured by SHURflo. Faucet failure due to foreign debris is not covered under the terms of this limited warranty. SHURflo
will not warrant any faucet that is physically damaged, or altered outside the SHURflo factory. Warranty claims may be resolved by a SHURflo
service center. All returns are to be shipped with charges pre-paid. Package all returns carefully. SHURflo will not be responsible for freight
damage incurred during shipping to a service center. SHURflo's obligation under this warranty policy is limited to the repair or replacement of the
faucets & accessories. Faucets or accessories found not defective (under the terms of this limited warranty) are subject to charges to be paid by the
returnee for the testing and packaging of "tested good" units. Warranty returns will be shipped on a freight allowed basis. SHURflo reserves the
right to choose the method of transportation. SHURflo is not responsible nor will it reimburse for labor necessary to remove and reinstall a faucet or
accessory, if found defective. Thi s w a r r a n t y i s o n l y a r e p rese n t a t i o n o f t h e c o m p l e t e M a r i n e P r o d u c t s L i m i t e d W a rran t y o u t l i n e d by Service Bulletin #1050.

SHURflo reserves the right to update specifications, prices, or make substitutions.

SHURflo*

5900-A Katella Ave.

Cypress, CA 90630

[phone] [phone]

FAX [phone]

Shipping: 5900-C Katella Ave.

Cypress, CA 90630

[phone] [phone]

SHURflo East

52748 Park Six Court

Elkhart, IN 46514-5427

FAX [phone]

http://www.shurflo.com

SHURflo Ltd.*

Unit 5 Sterling Park

Gatwick Road, Crawley

West Sussex, RH10 2QT

United Kingdom

[phone]

FAX [phone]

132-0204-CP

Rev. 7/05

© 2005, SHURflo