Shoprider Valencia GK10 User Manual

Valencia

GK10

USER MANUAL

Please ensure that this manual is read and understood before using the scooter.

Nov 2011

Contents Page

Introduction 3

Intended Use 3

Technical Specification 3

Feature Guide 4

Safety Advice 5

Adjustments

 Tiller angle 6
 Folding the tiller (for transportation) 6
 Seat swivel / removal 7
 Seat height 7
 Arm width adjustment 8

Tiller Controls 9

Brake Release / Freewheel Operation 10

Starting to Drive

 Getting Started 11
 Moving Off 11
 Steering 11
 Reversing 11
 Ramps / Slopes 11

Transport and Storage 12

Batteries and Battery Charger 12 & 13

Maintenance 13 & 14

Troubleshooting

 Circuit Breaker 15
 Fuses 15
 Check List 15

Further Information 16 - 19

Warranty

2

Introduction

Congratulations on your purchase of the Shoprider®

Valencia

scooter. This scooter incorporates

the latest innovative designs. The V

alencia

can be used in confined spaces both indoors and out.
Direct drive rear transaxles and electromagnetic brakes give a safe and efficient ride. The scooter
can be easily disassembled without tools and will fit into the boot of most vehicles for easy
transport. The detachable battery pack allows convenient charging wherever necessary.

Intended Use

The

alencia

was carefully designed for indoor or outdoor use in pedestrian areas by a single
individual with limited mobility up to a maximum weight of 136kg (21st). The acute
manoeuvrability prohibits the use by persons who are severely physically impaired or those who
have balance difficulties. Your assessor/healthcare professional will determine the suitability of the
scooter for each individuals intended use.

Note: Persons with lower body amputations should not use this device unless evaluated with
artificial limbs fitted, as stability may be compromised due to an irregular centre of gravity.

Technical Specification

Class 1 Medical Device
Class 2 Indoor/Outdoor Vehicle

Overall Size Seat

Dimensions

Length 1170mm Width 460mm

Width 585mm Depth 410mm

Height 960mm Seat to floor pan 480-555mm

Battery 2 x 34/36Ah Backrest height 360mm

Height (Folded) 630mm Range 32km (20m)*

Maximum user weight 136kg / 21st Seat to floor 580-655mm

Safe working slope 8º Battery charger (off

board)

4 amp

Weight with batteries 75kg

Max. Speed 6km/h (4mph)

*Passenger weight, rough ground conditions, low temperatures and battery condition can affect

maximum range.

3

Feature Guide

‘Valencia’

1. Tiller control head

2. Detachable padded swivel seat with fold down back

3. Detachable basket

4. Detachable battery pack

5. Tiller angle adjustment lever

6. Tiller lock

7. Anti-tip wheels

8. Pneumatic non-marking wheels

1

2

3

4

5

6

7

8

4

Safety Advice

DO:

 Read this manual carefully before using your scooter
 Turn the power off when transferring to and from the scooter
 Select a slow speed when going down gradients (max 8°) or over uneven ground
 Keep your feet on the scooter whilst driving
 Ensure the seat is in a fixed position facing forwards before driving
 Ensure the tiller is not in the ‘locked’ position
 Ensure the batteries are fully charged before your journey
 Avoid rough or soft terrain and long grass wherever possible
 Be aware of other road users and pedestrians
 Turn the power off when not in use
 Follow the maintenance guide to ensure safe operation of the scooter
 Always remove the keys if leaving the scooter unattended. Unauthorised persons/children

may use the scooter resulting in injury.

DO NOT:

 Carry passengers
 Exceed inclines over 8°
 Traverse inclines
 Attempt inclines if the surface is slippery
 Turn sharply at full speed
 Exit or enter the scooter unless the power is switched off
 Switch off the power whilst driving – this will cause the scooter to stop abruptly (see

emergency procedures – page 16)

 Use the scooter where you cannot safely or legally walk
 Attempt to climb kerbs except drop down kerbs.
 Use the scooter if under the influence of alcohol or any medication
 Use a mobile phone whilst driving
 Attempt to negotiate steps or escalators
 Sit on the scooter if being transported in a vehicle
 Attempt to tow any other devices
 Exceed the stated weight limit
 Connect any other devices to the batteries as this could cause permanent damage and void

your warranty

 Use any other batteries/charger other than those supplied by ROMA
 Travel through water or over soft terrain (mud, sand etc.) Avoid cobbles.
 Travel on the road except when crossing between pavements
 Lift the scooter by the shroud assembly or any plastic part
 Sharply shift your centre of gravity as this could make the scooter unstable

Every care has been taken to ensure that your scooter will give you safe, reliable service provided
you adhere to the advice given above.

5

Adjustments

Tiller Angle Adjustment

At the base of the tiller is a red lever. Push the lever toward the tiller stem to release the locking pin.
Select the desired tiller angle and pull the lever outwards. Ensure the locking pin is fully located
before using the scooter.

Folding the Tiller Assembly
(For transport purposes)

Release the locking mechanism as above and fold the tiller down fully until the locking pin locates
into one of the positions on the transport locking bracket.

The tiller can only be locked when the front wheels are pointing straight ahead. Do not carry
the scooter by the tiller stem.

Locking the Tiller Assembly
(For transport purposes)

To lock the wheels in the ahead position
for transportation lift the yellow lever and
turn clockwise as illustrated opposite. To
unlock simply reverse the procedure.

Never attempt to drive the scooter with
the tiller locked as this may cause injury
to the user or other persons.

6