Shoprider Solares FS777 User Manual

Solares

Model – FS777

USER MANUAL

Please ensure that this manual is read and understood before using

the scooter.

December 2015

Rev 1

KB&S - XXXXX

Contents Page

Introduction 3

Intended Use 3

Technical Specification 3

Feature Guide 4

Safety Advice 5

Adjustments

 Tiller angle 6

Tiller Controls 7

Brake Release / Freewheel Operation 8

Starting to Drive

 Getting Started 9
 Moving Off 9
 Steering 9
 Reversing 9
 Ramps / Slopes 10
 Surfaces 10
 Transferring 10

Storage 10

Batteries and Battery Charger 10 - 11

Folding & Unfolding 12 - 15

Maintenance 16

Troubleshooting

 Fuses 16
 Check List 16

Further Information 17

Warranty

2

Introduction

Congratulations on your purchase of the SHOPRIDER Solares scooter. This scooter
incorporates the latest innovative designs. The SHOPRIDER Solares can be used in
confined spaces both indoors and out. A direct drive rear transaxle and
electromagnetic brake give a safe and efficient ride.

Intended Use

The SHOPRIDER Solares is intended for indoor or outdoor use in pedestrian areas by a
single individual with limited mobility up to a maximum weight of 90kg (14st). It is
intended to be used by those suffering from some disability or impairment which
prevents a normal level of personal mobility.
The acute manoeuvrability prohibits the use by persons who are severely physically
impaired or those who have balance difficulties. Your assessor / healthcare professional
will determine the suitability of the scooter for each individuals’ intended use.

Note: Persons with lower body amputations should not use this device unless evaluated
with artificial limbs fitted, as stability may be compromised due to an irregular centre of
gravity.

Technical Specification

Class 1 Medical Device

Class 2 Indoor/Outdoor Vehicle

Overall Size Seat

Dimensions

Length 1110mm / 44” Width 390mm / 15”

Width 445mm / 17.5” Depth 320mm / 12.5”

Height

(Max to top of seat)

880mm / 34” Seat to floor pan 360mm / 14”

Battery 2 x 10Ah

Backrest height

(Incl headrest)

320mm / 12.5”

Height (folded)

750mm / 29.5” Range 14-16km / 8-10m*

Maximum user

weight

90kg / 14st Seat to floor 470mm / 18.5”

Safe working slope 6º/ 10% Battery charger

(off board)

2 Amp

Weight with

batteries

27.6kg / 60.7lbs Turning Radius 915mm / 36”

Max. Speed

(up to)

6kmph / 3.8mph

Ground

clearance

89mm / 3.5”

*Passenger weight in excess of 90kg, rough ground conditions, low temperatures and

battery condition can affect maximum range.
Folded dimensions – 500 x 445 x 750 (L x W x H)mm

3

Feature Guide

‘Solares’

1. Tiller control head

2. Padded seat with fold down back

3. Carry / pull handle

4. Seat release knob

5. Frame release ring

6. Puncture proof non-marking wheels

7. Tiller angle adjustment lever

2

3

4

5

6

7

1

4

Safety Advice

DO:

 Read this manual carefully before using your scooter.
 Turn the power off when transferring to and from the scooter.
 Select a slow speed when going down gradients (max 6°) or over uneven ground.
 Keep your feet on the scooter whilst driving.
 Ensure the seat is in a fixed position facing forwards before driving.
 Ensure the tiller is secure.
 Ensure the batteries are fully charged before your journey.
 Avoid rough or soft terrain and long grass wherever possible.
 Be aware of other road users and pedestrians.
 Turn the power off when not in use.
 Follow the maintenance guide to ensure safe operation of the scooter.
 Always remove the keys or switch off power if leaving the scooter unattended.

Unauthorised persons/children may use the scooter resulting in injury.

DO NOT:

 Carry passengers.
 Exceed inclines over 6°.
 Traverse inclines.
 Attempt inclines if the surface is slippery.
 Turn sharply at full speed.
 Exit or enter the scooter unless the power is switched off.
 Switch off the power whilst driving – this will cause the scooter to stop abruptly

(see emergency procedures – page 17).

 Use the scooter where you cannot safely or legally walk.
 Attempt to climb or descend kerbs except drop down kerbs.
 Use the scooter if under the influence of alcohol or any medication.
 Use a mobile phone whilst driving.
 Attempt to negotiate steps or escalators.
 Sit on the scooter if being transported in a vehicle.
 Attempt to tow any other devices.
 Exceed the stated weight limit.
 Connect any other devices to the batteries as this could cause permanent

damage and void your warranty.

 Use any other batteries/charger other than those supplied by SHOPRIDER.
 Travel through water or over soft terrain (mud, sand etc.)
 Lift the scooter by the shroud assembly or any plastic part.
 Sharply shift your centre of gravity as this could make the scooter unstable.
 Freewheel down hills. This will damage the motor and brake and void the

warranty,

 Tow the scooter with any other vehicle in the event of a breakdown.

Every care has been taken to ensure that your scooter will give you safe, reliable service
provided you adhere to the advice given above.

5

Adjustments

Tiller Angle Adjustment

At the bottom of the tiller stem is the red release lever. To adjust the tiller angle lift the
lever away from the scooter. This will allow the tiller to be adjusted or folded away for
transportation. DO NOT lift the scooter by the tiller as this can cause damage. Use the

handles as outlined later in the user manual.

Tiller release lever

6