Shoprider FS777 User Manual

FS777

ATTENTION

Please read your

owner’s manual before

driving your scooter.

Owner’s Manual

CONTENTS

INTRODUCTION ..................................................................................................... 3

FEATURE GUIDE .................................................................................................... 3

SAFETY ADVICE .................................................................................................... 4

EMI Warning ........................................................................................................... 6

ADJUSTMENT ........................................................................................................ 8

SCOOTER TILLER CONTROLS ............................................................................. 10

FREE WHEEL OPERATION ................................................................................... 12

STARTING TO DRIVE YOUR SCOOTER ................................................................. 13

EXTRA GUIDELINES IN THE CONTROL OF YOUR SCOOTER ........................... 14

BATTERIES AND BATTERY CHARGER ............................................................... 15

MAINTENANCE ...................................................................................................... 16

TROUBLE SHOOTING GUIDE ............................................................................... 17

WARRANTY TERMS & CONDITIONS .................................................................... 18

TECHNICAL SPECIFICATIONS ............................................................................... 20

DISCLAIMER ............................................................................................................ 21

NOTES ..................................................................................................................... 22

INTRODUCTION

Congratulations on your purchase of the Shoprider® scooter. This scooter incorporates the latest innovative designs patented and only available on a Shoprider® scooter. This scooter can be used in confined spaces both indoors and outdoors. Direct drive transaxles and electromagnetic brakes give a safe and efficient ride. This Shoprider® scooter is designed for persons with limited mobility.

Please read this manual carefully and thoroughly before using your scooter and make sure you understand all the instructions.

FEATURE GUIDE

1. Tiller Handle Bar

2. Tire

3. Footplate

4. Seat

5. Rear Pull Wheel

SAFETY ADVICE

• Do not carry passengers.

• This mobility Product is intended to assist you. For your own safety, please read the

Owner’s Manual before using the Scooter. If in any doubt, contact your supplier directly for advice.

• Do not exceed inclines over 6 degrees (10% grade).

• Driver weight may exceed weight of the unit, speed must be reduced when turning.

• Do not get on or off the scooter unless the brake is on and the scooter is switched off.

• Do not switch off the scooter while the scooter is moving.

• Do not drive the scooter where you can not safely or legally walk.

• Do not attempt to drive over curbs greater than 15mm in height. Doing so could cause

your scooter to turn over, causing personal injury or damage to the scooter. For curbs less than 15mm, always approach them at an angle of 90 degrees and at a low speed.

• Do not drink or use a mobile phone when driving your scooter.

• Do not exceed the suggested user weight limit to use the product. Doing so, could cause

personal injury and invalidate the warranty.

• Always keep your feet on the scooter when moving.

• Please make sure that you are physically fit to operate this unit. Consult your

dealer/doctor for advice.

• Always slow down and proceed carefully when traveling over rough or uneven ground.

• For individuals with balance problems, practice getting on the scooter with the assistance

of a qualified healthcare professional.

• Do not operate the scooter without anti-tip wheels installed.

• Do not use an escalator to move a scooter between floors or serious injury could occur.

• Do not drive the scooter on an incline that has oil, water or ice film on it.

• Do not try to lift the scooter by its seat, tiller, rear chassis cover, or any removable parts.

Any of these could cause injury to the user or damage to the scooter.

• Do not use parts or accessories that are not authorized by the original manufacturer of the scooter.

• Before sitting in or exiting the scooter, turn scooter switch to off position. This will insure

the POWER is off and the scooter can not move under its own power. As a general precaution, always turn scooter off while the scooter is not in use. This will prevent the use by untrained and unauthorized persons.

• Do not connect any foreign device to the scooter battery or charging port. This could cause failure of the device, the scooter and personal injury.

• Make sure the tiller is properly adjusted and locked to the user or damage and injury could

result.

• It is not allowed to have any person sitting in the scooter when transported by a vehicle,

otherwise any injury or damage that might result.

• Do not use the scooter in the rain, near a shower or in a damp bathroom. Direct exposure

to rain or dampness could cause the scooter to electrically malfunction and prematurely rust.

• Do not lean against or pull forward on the tiller while mounting or dismounting the scooter.

Otherwise, injury may occur.

• Do not operate the unit or turn the switch on while charging.

• Whenever a center bolt of the wheel assembly has been loosened, please replace a

specified new bolt from authorized dealers and secure with a torque of 240 ± 5 kg-cm together with Loctite 271 adhesive (or equivalent).

• Charge batteries daily after use.

• Charging plug has to be removed from the scooter after charging.

• Battery cables must be securely fastened onto battery terminals by the authorized dealers

before using the unit.

• Batteries must be tied down correctly and securely.

• Always secure any loose cables prior to driving the unit.

• Always verify how much battery charge is remaining before operating the unit.

• Always charge the batteries of the unit in a well ventilated area.

• If the unit went over or sank into deep water, please switch off power of the unit and

consult with your authorized dealer for help right away.

• Switch off power of the unit while not in use or before charging, removing and installing

the batteries. Otherwise, injury and/or damage to the unit or surrounding property may occur.

• Do not operate the unit in the way of exceeding to the product’s specification listed in this

owner’s manual.

• Do not press the Throttle lever before the key switch is turned on, or the operation will be

prohibited until the key is switched off and then on again.

• Always use low speed when traveling downhill.

• Do not attempt to cross railroad crossings as the surface may be uneven, find an alternate

route.

EMI Warning

Shoprider® scooters may be susceptible to electromagnetic interference (EMI), which is a kind of interfering electromagnetic energy (EM) emitted from sources such as radio stations, TV stations, amateur radio (HAM) transmitters, two-way radio, and cellular phones. The interference (from radio wave sources) can cause the scooter to release its brakes, move by itself, or move in unintended directions. It can also permanently damage the scooter’s control system. The sources of radiated EMI can be broadly classified into three types:

1. Hand-held portable transceivers (transmitters-receivers) with the antenna mounted

directly on the transmitting unit. Examples include: citizens band (CB) radios, “walkie talkie”, security, fire and police transceivers, cellular telephones, and other personal communication devices.

NOTE! Some cellular telephones and similar devices transmit signals while they are ON, even when not being used.

2. Medium-range mobile transceivers, such as those used in police cars, fire trucks,

ambulances, and taxis. These usually have the antenna mounted on the outside of the vehicle.

3. Long-range transmitters and transceivers, such as commercial broadcast transmitters

(radio and TV broadcast antenna towers) and amateur (HAM) radios.

NOTE! Other types of hand-held devices, such as cordless phones, laptop computers, AM/FM radios, TV sets, CD players, and cassette players, and small appliances, such as electric shavers and hair dryers, so far as we know, are not likely to cause problems to the scooter.

Scooter Electromagnetic Interference (EMI)

Because EM energy rapidly becomes more intense as one moves closer to the transmitting antenna (source), the EM fields from hand-held radio sources (transceivers) are of special concern. It is possible to unintentionally bring high levels of EM energy very close to the scooter’s control system while using these devices. This can affect scooter movement and braking. Therefore, the warnings listed below are recommended to prevent possible interference with the control system of the scooter.

+ 11 hidden pages