SHARP 983 СТРОКА aaa, ddd, hhh, rrr, vvv Service manual & schematics

Page 1

Page 2

TABLE OF CONTENTS

1. INTRODUCTION...................................................................................................................... 5

1.1. General Block Diagram.................................................................................................. 6

1.2. MB60 Placement of Blocks............................................................................................ 7

1. TUNER(TU102)......................................................................................................................... 8

1.1. General description of Samsung DTOS403LH122X:.................................................... 8

1.2. Features of DTOS403LH122X: ..................................................................................... 8

1.3. Pinning: .......................................................................................................................... 9

2. SAW FILTER – Audio – Epcos K9656M(Z101) ...................................................................... 9

2.1. Standart........................................................................................................................... 9

2.2. Features ........................................................................................................................ 10

2.3. Pin configuration .......................................................................................................... 10

2.4. Frequency response ...................................................................................................... 10

3. SAW FILTER – Video – Epcos K3958M(Z102) .................................................................... 11

3.1. Standart......................................................................................................................... 11

3.2. Features ........................................................................................................................ 11

3.3. Frequency response ...................................................................................................... 12

4. AUDIO AMPLIFIER STAGE WITH AZAD2102(U163, U164) ........................................... 12

4.1. General Description...................................................................................................... 12

4.2. Features ........................................................................................................................ 13

4.3. Absolute Ratings .......................................................................................................... 14

4.3.1. Electrical Characteristics.......................................................................................... 14

4.3.2. Operating Specifications .......................................................................................... 15

4.4. Pinning ......................................................................................................................... 16

5. AUDIO AMPLIFIER STAGE WITH TPA3113(U168) ......................................................... 16

5.1. General Description...................................................................................................... 16

5.2. Features ........................................................................................................................ 17

5.3. Absolute Ratings .......................................................................................................... 17

5.3.1. Electrical Characteristics.......................................................................................... 17

5.3.2. Operating Specifications .......................................................................................... 18

5.4. Pinning ......................................................................................................................... 18

6. POWER STAGE ...................................................................................................................... 19

6.1. Power Management...................................................................................................... 22

7. MICROCONTROLLER – MSTAR(U157) ............................................................................. 23

7.1. General Descripction.................................................................................................... 23

7.2. General Features........................................................................................................... 24

7.3. MSTAR Block Diagram............................................................................................... 28

7.4. Reset Circuit................................................................................................................. 29

8. CI INTERFACE....................................................................................................................... 29

7.1 Block Diagram ............................................................................................................. 29

7.1 CI Interface Power Switch ........................................................................................... 30

9. T2 Demodulator CXD2820R (U167)....................................................................................... 30

9.1. General Description...................................................................................................... 30

9.2. Features ........................................................................................................................ 30

9.3. Pinning ......................................................................................................................... 32

10. USB INTERFACE ............................................................................................................... 35

11. DDR2 SDRAM 8M × 4 BANKS × 16 BIT (W9751G6JB) (U154, U155) ......................... 35

11.1. General Description...................................................................................................... 35

11.2. Features ........................................................................................................................ 36

Page 3

11.3. Electrical Characteristics.............................................................................................. 36

11.4. Pinning ......................................................................................................................... 37

12. SCALER AND LVDS SOCKETS....................................................................................... 39

12.1. LVDS sockets Block Diagram ..................................................................................... 39

12.2. Panel Supply Switch Circuit ........................................................................................ 39

13. NAND FLASH MEMORY - MX25L1005 (U158) ............................................................. 40

13.1. General Description...................................................................................................... 40

13.2. Features ........................................................................................................................ 40

13.3. Absolute Maximum Ratings......................................................................................... 41

13.4. Pinning ......................................................................................................................... 41

14. NAND FLASH MEMORY – NAND512XXA2C (U162) .................................................. 42

14.1. General Description...................................................................................................... 42

14.2. Features ........................................................................................................................ 42

14.3. Pinning ......................................................................................................................... 43

15. USB2.0 to Fast Ethernet – ASIX AX88X72A (U171) ........................................................ 44

15.1. General Description...................................................................................................... 44

15.2. Features ........................................................................................................................ 44

15.3. Block Diagram ............................................................................................................. 45

15.4. Pinning ......................................................................................................................... 46

16. LM1117(U175, U180, U181)............................................................................................... 46

16.1. General Description...................................................................................................... 46

16.2. Features ........................................................................................................................ 46

16.3. Applications ................................................................................................................. 47

16.4. Absolute Maximum Ratings......................................................................................... 47

16.5. Pinning ......................................................................................................................... 47

17. MP2012 (U176).................................................................................................................... 47

17.1. General Description...................................................................................................... 47

17.2. Features ........................................................................................................................ 47

17.3. Pinning ......................................................................................................................... 48

18. RTA8283A (U23, U173)...................................................................................................... 48

18.1. General Description...................................................................................................... 48

18.2. Features ........................................................................................................................ 49

18.3. Pinning ......................................................................................................................... 49

19. MP1583 (U174).................................................................................................................... 49

19.1. General Description...................................................................................................... 49

19.2. Features ........................................................................................................................ 50

19.3. Pinning ......................................................................................................................... 50

20. FDC642 ................................................................................................................................ 51

20.1. General Description...................................................................................................... 51

20.2. Features ........................................................................................................................ 51

20.3. Pinning ......................................................................................................................... 51

21. FDC604P.............................................................................................................................. 51

21.1. General Description...................................................................................................... 51

21.2. Features ........................................................................................................................ 51

21.3. Pinning ......................................................................................................................... 52

22. CONNECTORS ................................................................................................................... 52

22.1. SCART (SC1) .............................................................................................................. 52

22.2. HDMI (CN707,CN708) ............................................................................................... 52

22.3. VGA (CN132) .............................................................................................................. 53

Page 4

23.

SERVICE MENU SETTINGS ............................................................................................. 54

23.1. Video Settings .............................................................................................................. 55

23.2. Audio Settings .............................................................................................................. 56

23.3. Options ......................................................................................................................... 57

23.4. Tuning Settings ............................................................................................................ 59

23.5. Source Settings ............................................................................................................. 60

23.6. Diagnostic ..................................................................................................................... 61

23.7. USB Operations ............................................................................................................ 61

24.

SOFTWARE UPDATE ........................................................................................................ 62

25.

TROUBLESHOOTING ....................................................................................................... 63

25.1. No Backlight Problem .................................................................................................. 63

25.2. CI Module Problem ...................................................................................................... 64

25.3. Led Blinking Problem .................................................................................................. 66

25.4. IR Problem ................................................................................................................... 67

25.5. Keypad Touchpad Problems ........................................................................................ 67

25.6. USB Problems .............................................................................................................. 68

25.7. No Sound Problem ....................................................................................................... 69

25.8. No Sound Problem at Headphone ................................................................................ 69

25.9. Standby On/Off Problem .............................................................................................. 70

DVD Problems ......................................................................................................................... 70

25.10. No Signal Problem ................................................................................................... 71

26. PART LIST……………………………………………………………………………….. 72

Page 5

1. INTRODUCTION

17MB60 mainboard is driven by MStar SOC. This IC is capable of handling Video and audio processing, Scaling-Display processing, 3D comb filter, OSD and text processing, LVDS transmitting, channel and MPEG2/4 decoding, integrated DVB-T/C demodulator and media center functionality.

TV supports PAL, SECAM, NTSC colour standards and multiple transmission standards as B/G, D/K, I/I’, and L/L’ including German and NICAM stereo. Also DVB T, DVB-C are supported internal demoulators of Mstar IC and DVB-T2 is supported with externall demodulator.

Sound system output is supplying max. 2x2,5W ( less 10%THD at max output) with 4 speakers or 2x6W for stereo 8Ω speakers.

Supported peripherals are:

1 RF input VHF I, VHF III, UHF @ 75Ohm(Common) 1 Side AV (CVBS, R/L_Audio) 1 SCART socket(Common) 1 YPbPr (Optional) 1 PC input(Common) 2 HDMI 1.3 input(1 HDMI input is common, 1 input is optional) 1 S/PDIF output(Optional) 1 Headphone(Optional) 1 Common interface(Common) 1 USB(Common) 1 DVD(Optional) 1 iPod(Optional) 1 On-board Keypad(Optional) 1 External Keypad(Optional) 1 External TouchPad(Optional)

Ω

Page 6

1.1. General Block Diagram

Page 7

1.2. MB60 Placement of Blocks

(U171)

External Keyboard Touchboard

DVD Connector

CI Connector

Power Connector

Nand Flash (U162)

Connectors

DDR2 RAM (U154)

LVDS

USB

Saw Filters

Main IC

(U157)

DDR2 RAM (U155)

SPI Flash

Ethernet IC

Keypad

Tuner(TU102)

HDMI Connectors

Ethernet Connector or Adapter DC Input

YPbPr SAV HP

SCART Connector

VGA

SPDIF Out

Speaker Con.

Led Con

Inv. Con

Page 8

1. TUNER(TU102)

A horizontal mounted and Digital Half-Nim tuner is used in the product, which covers 3 Bands(From 48MHz to 862MHz for COFDM, from 45.25MHz to 863.25MHz for CCIR CH). The tuning is available through the digitally controlled I2C bus (PLL). Below you will find info about the tuner.

In active antenna option, the following circuit are used. ANT_CTRL pin is controlled by microcontroller. If ANT_CTRL is low, ANT_PWR will be low. If ANT_CTRL is high, ANT_PWR will be high.

OVER_CUR_DETECT pin is a monitor for short circuit in antenna. OVER_CUR_DETECT is low, ANT_CTRL will be low, so ANT_PWR will be low. Finally, short circuit protection is done by circuits and microcontroller.

1.1. General description of Samsung DTOS403LH122X:

The Tuner covers 3 Bands(from 48MHz to 862MHz for COFDM, from 45.25MHz to

863.25MHz for CCIR CH). Band selection and Tuning are performed digitally via the I2C bus.

1.2. Features of DTOS403LH122X:

 Receiving System: This TUNER is designed to cover the air channels in VHF and

UHF, compliant with DVB-T standard. and It covers all Analog channels from

48.25MHz to 863.25MHz

Page 9

 Receiving Channel (Digital, Center frequency):

Pin n

Name

Pin Description

Ant Power

Active Antenna Power

RF AGC

RF AGC (internal or external mode)

4CLI2C Serial Clock

6BP+5V, Supply Voltage (RF Amp, PLL, IF Amp)

BT(T.P)

+33V, within DC/DC circuit

8ASI2C Address Selection of the PLL

IF AGC

Control voltage for the IF AGC

IF OUT

Output 1 of the IF Amplifier

VHF Low CH. E2 ~ S10 ( 50.5MHz ~ 170.5MHz ) VHF High CH. E5 ~ S41 ( 177.5MHz ~ 466 MHz ) UHF CH. E21 ~ E69 ( 474 MHz ~ 858 MHz )

 Receiving Channel (PAL, Picture carrier frequency):

VHF Low CH. E2 ~ S10 ( 48.25MHz ~ 168.25MHz ) VHF High CH. E5 ~ S41 ( 175.25MHz ~ 463.25MHz ) UHF CH. E21 ~ E70 ( 471.25MHz ~ 863.25MHz )

 Intermediate Frequency:

Digital(center) DVB-T (36.167 MHz) Digital(center) DVB-C (36.125 MHz) Analog(picture) 38.9 MHz

 Input Impedance: 75Ω, Unbalanced  Band Change-Over System

PLL Control System

 Tuning System

Electronic Tuning System With PLL

 Internal(or External) RF AGC function

Built in wideband AGC detector with 6 programmable take-over points

1.3. Pinning:

Terminal

2 B+ +5V, Supply Voltage (Preamplifier, DC/DC)

5 DA I2C Serial Clock

10 IF OUT + Output 2 of the IF Amplifier

12 AIF Output IF output of the Analog BroadBand

2. SAW FILTER – Audio – Epcos K9656M(Z101)

2.1. Standart

 B/G  D/K  I  L/L’

Page 10

2.2. Features

 TV IF audio filter with two channels  Channel 1 (L’) with one pass band for sound carriers at 40,40 MHz (L’) and 39,75

MHz (L’- NICAM)

 Channel 2 (B/G,D/K,L,I) with one pass band for sound carriers between 32,35 MHz

and 33,40 MHz

2.3. Pin configuration

1 Input 2 Switching input 3 Chip carrier - ground 4 Output 5 Output

2.4. Frequency response

Page 11

3. SAW FILTER – Video – Epcos K3958M(Z102)

3.1. Standart

 B/G  D/K  I  L/L’

3.2. Features

 TV IF filter with Nyquist slopes at 33.90 MHz and 38.90 MHz  Constant group delay

Pin configuration:

1 Input 2 Input - ground 3 Chip - carrier ground 4 Output 5 Output

Page 12

3.3. Frequency response

4. AUDIO AMPLIFIER STAGE WITH AZAD2102(U163, U164)

4.1. General Description

17MB60 uses two 2,5W Class D Mono Audio Amplifers for from 16” to 24” TVs.

AZAD2102B is a 2.9 Watts (max. can offer 3.0 Watts @ Load = 3Ω,THD=10%,

AVdd=DVdd=5.5Volt)with high efficiency filter-free class-D audio power amplifier in a 1613 mm x 1613 mm wafer chip scale package (WCSP). AZAD2102B uses Currentswitch technology to achieve high performance class-d amplifier that features 0.03% THD, 85% efficiency, –70 dB PSRR, to improve RF-rectification immunity.

Page 13

AZAD2102B provide a Vibration-Spectrum modulation clock for PWM Output. This vibration frequency is around 10KHZ shift (+/- 5KHZ of Fpwm).

The advantage of the small size package (WCSP) makes AZAD2102B very suitable for mobile phone and PDA device application. And the Class-D amplifier structure let AZAD2102B to have highly efficiency power consumption than Class-AB amplifier. AZAD2102B can shrink the application board, reduce system cost, and external components.

ESD level protection I/O embedded in AZAD2102B. For general applications, doesn’t need to add extra ESD protection device (like Varistors) in application system for AZAD2102B’s I/O.

4.2. Features

 CMOS Technology  High Efficiency 85%  High PSRR 70dB at 217Hz  Differential OP-amp Input  AZAD2102B provides Vibration-Spectrum Modulation clock for reduce EMI  Provide Mute function(set Mute_B to GND will go into Mute status)  For the input stage AZAD2102B built-in a 10Kohm resistors (Gain setting=29.5dB)  Maximum Battery Life and Minimum Heat  Efficiency With an 8-Ω Speaker:  3.5 mA Quiescent Current  Output Power at 10% THD  2.85Watts at AVdd=DVdd=5.0Volt, Rload=4Ω  1.45Watts at AVdd=DVdd=3.6Volt, Rload=4Ω  0.30Watts at AVdd=DVdd=3.0Volt, Rload=4Ω  1.75Watts at AVdd=DVdd=5.5Volt, Rload=8Ω  0.87Watts at AVdd=DVdd=3.6Volt, Rload=8Ω  0.41Watts at AVdd=DVdd=3.0Volt, Rload=8Ω  Eliminate Power on and Power-off “Pop” noise  A Fewer External Components  Optimized PWM Output Stage Eliminates LC Output Filter  Internally generate 290 kHz Switching Frequency to eliminate Capacitor and

Resistor

 Improve PSRR (–70 dB) and Wide Supply Voltage (3.0 V to 5.5 V)  Fully Differential Design Reduces RF Rectification  This chip has been built-in a very strong ESD protection.  System level ESD 4KV (IEC 61000-4-2 ESD Contact Level)  Wafer Chip Scale Package (WCSP)  TSSOP Package with Exposed Pad

Page 14

4.3. Absolute Ratings

4.3.1. Electrical Characteristics

Page 15

4.3.2. Operating Specifications

Page 16

4.4. Pinning

5. AUDIO AMPLIFIER STAGE WITH TPA3113(U168)

5.1. General Description

17MB60 uses a 6W Class D Mono Audio Amplifers for from 26” to 32” TVs. The TPA3113D2 is a 6-W (per channel) efficient, Class-D audio power amplifier for driving bridged-tied stereo speakers. Advanced EMI Suppression Technology enables the use of inexpensive ferrite bead filters at the outputs while meeting EMC requirements. SpeakerGuard™ speaker protection circuitry includes an adjustable power limiter and a DC detection circuit. The adjustable power limiter allows the user to set a "virtual" voltage rail lower than the chip supply to limit the amount of current through the speaker. The DC detect circuit measures the frequency and amplitude of the PWM signal and shuts off the output stage if the input capacitors are damaged or shorts exist on the inputs.

The TPA3113D2 can drive stereo speakers as low as 4 TPA3113D2, 87%, eliminates the need for an external heat sink when playing music.

The outputs are also fully protected against shorts to GND, VCC, and output-to-output. The short-circuit protection and thermal protection includes an auto-recovery feature.

Ω. The high efficiency of the

Page 17

5.2. Features

 6-W/ch into an 8-Ω Loads at 10% THD+N From a 10-V Supply  12-W into a 4-Ω Mono Load at 10% THD+N From a 10-V Supply  87% Efficient Class-D Operation Eliminates Need for Heat Sinks  Wide Supply Voltage Range Allows Operation from 8 V to 26 V  Filter-Free Operation  SpeakerGuard™ Speaker Protection Includes Adjustable Power Limiter plus DC

Protection

 Flow Through Pin Out Facilitates Easy Board Layout  Robust Pin-to-Pin Short Circuit Protection and Thermal Protection with Auto

Recovery Option

 Excellent THD+N / Pop-Free Performance  Four Selectable, Fixed Gain Settings  Differential inputs

5.3. Absolute Ratings

5.3.1. Electrical Characteristics

Page 18

5.3.2. Operating Specifications

5.4. Pinning

Page 19

6. POWER STAGE

The DC voltages required at various parts of the chassis and panel are provided by a main power supply unit. MB60 chassis can operate with IPS60, IPS16, IPS17, PW26, PW27 as main power supply and also with 12V adaptor.

CN706 is used for IPS60, IPS16 and IPS17 and CN1 is used for PW26 and PW27.

JK9 is used for the adapter option and also CN705 inverter socket or DB32 chassis with CN706 is used to supply backlight.

The power supplies generate 18V, 12V, 5V, 3,3V and 12V, 5V, stand by mode DC voltages. Power stage which is on-chassis generates 5V, 3V3 stand by voltage and 12V, 8V, 5V, 3V3, 2.5V, 1,8V and 1,2V supplies for other different parts of the chassis. Chassis block diagram is indicated below.

Page 20

The blocks on power block diagram is using dependent to main supply. For PW26 and PW27 just common blocks are enough for proper operation.

For IPS16, IPS17, IPS60 below blocks must work properly.

For adopter case also below blocks are necessary.

Page 21

Short CCT Protection Circuit

Short circuit protection is necessary for protecting chassis and main IC against damages when any Vcc supply shorts to ground. Protect pin should be logic high while normal operation. When there is a short circuit protect pin shold be logic low. After any short detection, SW forces LEDs on LED card to blink.

Page 22

6.1. Power Management

Page 23

7. MICROCONTROLLER – MSTAR(U157)

7.1. General Descripction

The MSD9WB7PX-2 integrates DTV/multi-media all-purpose AV decoder, DVB-T demodulator, VIF demodulator, and Sound/Video processor into a single device. This allows the overall BOM to be reduced significantly making the MSD9WB7PX-2 a very

Page 24

competitive multi-media DTV solution. For ATV users, the MSD9WB7PX-2 provides multistandard analog TV support with adaptive 3D video decoding and VBI data extraction. The build-in audio decoder is capable of decoding FM, AM, NICAM, A2, BTSC and EIA-J sound standards. The MSD9WB7PX-2 supplies all the necessary A/V inputs and outputs to complete a receiver design including a multi-port HDMI receiver and component video ADC. All input selection multiplexed for video and audio are integrated, including full SCART support with CVBS output. The equipped MStar MACE-5 color engine is the latest masterpiece from MStar famous color engine series providing excellent video and picture quality in Full-HD and large-scale displaying system. To meet the increasingly popular energy legislative requirements without the use of additional hardware, the MSD9WB7PX-2 has an ultra low power standby mode during which an embedded MCU can act upon standby events and wake up the system as required.

7.2. General Features

MSD9WB9PX-2, an SOC solution that supports channel decoding, MPEG decoding, and media-centre functionality enabled by a high performance AV CODEC and CPU Key features include,

 Digital and Analog DVB Front-End Demodulator  A Multi-Standard A/V Format Decoder  The MACE-5 Video Processor  Home Theater Sound Processor  Peripheral and Power Management

Transport Stream De-multiplexer

 Supports parallel and serial TS interface, with or without sync signal  Supports TS input and output for external CI module  Maximum TS data rate is 104 Mb/sec for serial or 16 MB/sec for parallel  32 general purpose PID filters and section filters for each transport stream de-

multiplexer

 Supports additional audio/video/PCR filters  Supports TS DMA channel for time-shift  Supports 3DES/DES and AES encryption/decryption

MPEG-2 Video Decoder

 ISO/IEC 13818-2 MPEG-2 video MP@HL  Automatic frame rate conversion  Supports resolution up to HDTV (1080i, 720p) and SDTV

MPEG-4 Video Decoder

 ISO/IEC 14496-2 MPEG-4 ASP video decoding  Supports resolutions up to HDTV (1080p@30fps)  Supports DivX1 Home Theater & HD profilesOptional  Supports VC-1Optional, FLV video format decoding

H.264 Decoder

 ITU-T H.264, ISO/IEC 14496-10 (main and high profile up to level 4.1) video

decoding

Page 25

 Supports resolutions for all DVB, ATSC, HDTV, DVD and VCD  Supports resolution up to 1080p@30fps  Supports CABAC and CAVLC stream types  Processing of ES and PES streams, extraction and provision of time stamps  Up to 40 Mbits bitrate (Blu-ray spec.)

Hardware JPEG

 Supports sequential mode, single scan  Supports both color and grayscale pictures  Following the file header scan the hardware decoder fully handles the decode

process

 Supports programmable Region of Interest (ROI)  Supports formats: 422/411/420/444/422T  Supports scaling down ratios: 1/2, 1/4, 1/8  Supports picture rotation

NTSC/PAL/SECAM Video Decoder

 Supports NTSC-M, NTSC-J, NTSC-4.43, PAL (B, D, G, H, M, N, I, Nc), and

SECAM standards

 Automatic standard detection  Motion adaptive 3D comb filter  Five configurable CVBS & Y/C S-video inputs  Supports Teletext, Closed Caption (analog CC 608/ analog CC 708/digital CC

608/digital CC 708), V-chip and SCTE

Multi-Standard TV Sound Processor

 SIF audio decoding  Supports BTSC/A2/EIA-J demodulation  Supports NICAM/FM/AM demodulation  Supports MTS Mode Mono/Stereo/SAP in BTSC/EIA-J mode  Supports Mono/Stereo/Dual in A2/NICAM mode  Built-in audio sampling rate conversion (SRC)  Audio processing for loudspeaker channel, including volume, balance, mute, tone,

EQ, virtual stereo/surround and treble/bass controls

 Advanced sound processing options available, for example: Dolby, SRS, BBE,

QSound, Audyssey

 Supports digital audio format decoding:  MPEG-1, MPEG-2 (Layer I/II), MP3, Dolby Digital (AC-3), AAC-LC  Supports Optional Dolby Digital Plus, Dolby Pulse, and MS10 multistream

decoder, including Dolby Digital Encoder for transcoding streams to Dolby Digital

5.1 (DDCO)

 Supports MPEG Audio, Dolby Digital, Dolby Digital Plus format AD (Audio

Description)

 Supports PVR and time-shifting

Audio Interface

One SIF audio input interface with minimal external saw filters

Page 26

 Four L/R audio line-inputs including Mic. input  Two L/R outputs for main speakers and additional line-outputs  Supports stereo headphone driver  I2S digital audio input & output  S/PDIF digital audio output  HDMI audio channel processing  Programmable delay for audio/video synchronization

Analog RGB Compliant Input Port

 Three analog ports support up to 1080P  Supports PC RGB input up to SXGA@75Hz  Supports HDTV RGB/YPbPr/YCbCr  Supports Composite Sync and SOG Sync-on-Green  Automatic color calibration  AV-link support

Analogue RGB Auto-Configuration & Detection

 Auto input signal format and mode detection  Auto-tuning function including phasing, positioning, offset, gain, and jitter detection  Sync Detection for H/V Sync

DVI/HDCP/HDMI Compliant Input Port

 Three HDMI/DVI Input ports  HDMI 1.3 Compliant  HDCP 1.1 Compliant  225MHz @ 1080P 60Hz input with 12-bit Deep-color support  CEC support  Single link DVI 1.0 compliant  Robust receiver with excellent long-cable support

MStar Advanced Color Engine (MStarACE-5)

 10/12-bit internal data processing  Fully programmable multi-function scaling engine  Nonlinear video scaling supports various modes including Panorama  Supports dynamic scaling for VC-1  High-Quality DTV video processor  3D motion video deinterlacer with motion object stabilizer  Edge-oriented deinterlacer with edge and artifact smoother  Automatic 3:2/2:2/M:N pull-down detection and recovery  3D multi-purpose noise reduction for DTV or lousy air/cable input  MPEG artifact removal including de-blocking and mosquito noise reduction  Arbitrary frame rate conversion  MStar Professional Picture Enhancement:

o Dynamic brilliant and fresh color o Dynamic Blue Stretch o Intensified contrast and details o Dynamic Vivid Skin

Page 27

o Dynamic sharpened Luma/Chroma edges o Global and local dynamic depth of field perception o Accurate and independent color control o Supports sRGB and xvYCC color processing o Supports HDMI 1.3 deep color format

 Programmable 12-bit RGB gamma CLUT

Output Interface

 Single/dual link 8/10-bit LVDS output  Supports panel resolution up to Full-HD (1920x1080) @ 60Hz  Supports TH/TI format  Supports dithering options to 6/8-bit output  Spread spectrum output for EMI suppression

CVBS Video Encoder

 Supports all NTSC/PAL TV Standard  Stand-alone scaling engine  Programmable Hue, Contract, Brightness  Supports TTX/CC/WSS output

CVBS Video Output

 Allows CVBS output of all source inputs

2D Graphics Engine

 Hardware Graphics Engine for responsive interactive applications  Supports point draw, line draw, rectangle draw/fill, text draw and trapezoid draw  BitBlt, stretch BitBlt, trapezoid BitBlt, mirror BitBlt and rotate BitBlt  Raster Operation (ROP)  Support Porter-Duff

VIF Demodulator

 Compliant with NTSC M/N, PAL B, G/H, I, D/K, SECAM L/L' standards  Audio/Video dual-path processor  Stepped-gain PGA with 25 dB tuning range and 1 dB tuning resolution  Maximum IF gain of 37 dB  Programmable TOP to accommodate different tuner gain and SAW filter insertion

loss to optimize noise and linearity performance

 Multi-standard processing with single SAW  Supports silicon tuner low IF output architecture

DVB-T/DVB-C Demodulator

 Digital carrier frequency offset correction: ±500KHz  Optimised for SFN channels with pre/post-cursive echoes inside/outside the guard  Acquisition range ±857kHz includes up to 3x: ±1/6 MHz transmitter offset  Meets Nordig Unified 1.0.3, D-Book 5.0, EICTA E-Book/C-Book test requirement  ITU J.83 Annex A/C, DVB-C (EN 300 429) compliant  Supports DVB-C 0.7-7M Baud symbol rate

Page 28

 ±400kHz internal carrier offset recovery range  6.8 usecs echo cancellation at 7 Msym/s  Supports IF, low-IF, zero-IF inputs  Ultra-fast automatic blind UHF/VHF channel scan (constellations and symbol rate)

Connectivity

 Two USB 2.0 host ports  USB architecture designed for efficient suppor of external storage devices in

conjunction with off air broadcasting

Miscellaneous

 DRAM interface supporting two 16-bit DDR2 @ 1066MHz  Supports PVR  Supports Common Interface for conditional access support  Bootable SPI interface with serial flash support  Parallel interface for external OneNAND and NAND flash support  Power control module with ultra low power  MCU available in standby mode  523-ball LFBGA package  Operating Voltages: 1.26V (core), 1.8V (DDR2), 2.5V and 3.3V (I/O and analog)

7.3. MSTAR Block Diagram

Page 29

7.4. Reset Circuit

Reset circuit using for initiliazing main Mstar IC. Reset condition is high and nomal working condition is low for RESET pin.

8. CI INTERFACE

7.1 Block Diagram

Page 30

7.1 CI Interface Power Switch

It is used for CI module supply, when Module is inserted (it means CI detect is low) This circuit is opened or closed by CI_POWER_CTRL port of main uController

9. T2 Demodulator CXD2820R (U167)

9.1. General Description

This demodulator is optionall for support T2 reception. The Sony CXD2820R is a combined DVB-T2, DVB-T and DVB-C demodulator that conforms to the ETSI EN 302755 (second generation Terrestrial) ETSI EN 300-744 (Terrestrial) and ETSI EN 300-429 (Cable) standards.

9.2. Features

 Single, 41MHz crystal (can be shared with CXD2813Ranalogue demod IC)  High performance differential signal ADC  RF power level monitor ADC  Low IF and high IF (36MHz) mode input  Fast 400kHz I2C compatible bus interface

Page 31

 Quiet I2C interface for dedicated tuner control  Automatic IF AGC and optional programmable  RF AGC/GPIO functions  Configurable parallel and serial MPEG-2 TS outputs with smoothing buffer  3.3V, 2.5V, 1.2V supplies  Temperature range -20°C to +85°C  Supplied with full reference design, including software driver, PCB

schematic/layouts, GUI and documentation

 3.3V for VDD and 2.5V for VDDQ power supply  All inputs and outputs are compatible with SSTL_2 interface  JEDEC standard 400mil 66pin TSOP-II with 0.65mm pin pitch  Fully differential clock inputs (CK, /CK) operation  Double data rate interface  Source synchronous - data transaction aligned to bidirectional data strobe (DQS)  x16 device has 2 bytewide data strobes (LDQS, UDQS) per each x8 I/O  Data outputs on DQS edges when read (edged DQ) Data inputs on DQS centers

when write (centered DQ)

 Data(DQ) and Write masks(DM) latched on the both rising and falling edges of the

data strobe

 All addresses and control inputs except Data, Data strobes and Data masks

latched on the rising edges of the clock

 Write mask byte controls by LDM and UDM  Programmable /CAS latency 3 / 4 supported  Programmable Burst Length 2 / 4 / 8 with both sequential and interleave mode  Internal 4 bank operations with single pulsed /RAS  tRAS Lock-Out function supported  Auto refresh and self refresh supported  4096 refresh cycles / 32ms  Full, Half and Matched Impedance(Weak) strength driver option controlled by

EMRS

Page 32

9.3. Pinning

Page 33

Page 34

Page 35

10. USB INTERFACE

Main Concept IC has integrated 2 USB 2.0 interface. One of them is used for ethernet function, the other one is used for USB connectivity for last user. Last user can play video, picture and audio files. Also digital channels can be record to externall storage device by this interface. All SW files can be updated with interface.

USB circuit has 3 main parts

 Integrated USB 2.0 Host interface of D3 (U157)  Protection IC (U145)  Over Curent Protection IC (U149)

11. DDR2 SDRAM 8M × 4 BANKS × 16 BIT (W9751G6JB) (U154, U155)

11.1. General Description

The W9751G6JB is a 512M bits DDR2 SDRAM, organized as 8,388,608 words × 4 banks × 16 bits. This device achieves high speed transfer rates up to 1066Mb/sec/pin (DDR2-

1066) for general applications. W9751G6JB is sorted into the following speed grades: -18,

-25 and -3. The -18 is compliant to the DDR2-1066/CL7 specification. The -25 is

compliant to the DDR2-800 (5-5-5) or DDR2-800 (6-6-6) specification. The -3 is compliant to the DDR2-667 (5-5-5) specification. All of the control and address inputs are synchronized with a pair of externally supplied differential clocks. Inputs are latched at the cross point of differential clocks (CLK rising and CLK falling). All I/Os are synchronized with a single ended DQS or differential DQS- DQS pair in a source synchronous fashion.

Page 36

11.2. Features

 Power Supply: VDD, VDDQ = 1.8 V± 0.1 V  Double Data Rate architecture: two data transfers per clock cycle  CAS Latency: 3, 4, 5, 6 and 7  Burst Length: 4 and 8  Bi-directional, differential data strobes (DQS andDQS ) are transmitted / received

with data

 Edge-aligned with Read data and center-aligned with Write data  DLL aligns DQ and DQS transitions with clock  Differential clock inputs (CLK and CLK )  Data masks (DM) for write data  Commands entered on each positive CLK edge, data and data mask are

referenced to both edges of DQS

 Posted CAS programmable additive latency supported to make command and data

bus efficiency

 Read Latency = Additive Latency plus CAS Latency (RL = AL + CL)  Off-Chip-Driver impedance adjustment (OCD) and On-Die-Termination (ODT) for

better signal quality

 Auto-precharge operation for read and write bursts  Auto Refresh and Self Refresh modes  Precharged Power Down and Active Power Down  Write Data Mask  Write Latency = Read Latency - 1 (WL = RL - 1)  Interface: SSTL_18

11.3. Electrical Characteristics

Page 37

11.4. Pinning

Page 38

Page 39

12. SCALER AND LVDS SOCKETS

12.1. LVDS sockets Block Diagram

12.2. Panel Supply Switch Circuit

This switch is used to open and close panel supply of TCON. It is controlled by port of main ucontroller. Also with this circit panel sequency could be adjusted correctly. 3 panel supplys are connected to this circuit. All of them are optional according to panels.

Page 40

13. NAND FLASH MEMORY - MX25L1005 (U158)

13.1. General Description

MX25L1005 is a CMOS 1,048,576 bit serial Flash memory, which is configured as 131,072 x 8 internally.The MX25L1005 feature a serial peripheral interface and software protocol allowing operation on a simple 3-wire bus. The three bus signals are a clock input (SCLK), a serial data input (SI), and a serial data output (SO). SPI access to the device is enabled by CS# input. The MX25L1005 provide sequential read operation on whole chip. After program/erase command is issued, auto program/ erase algorithms which program/ erase and verify the specified page or sector/block locations will be executed. Program command is executed on page (256 bytes) basis, and erase command is executes on chip or sector(4K-bytes) or block(64K-bytes). To provide user with ease of interface, a status register is included to indicate the status of the chip. The status read command can be issued to detect completion status of a program or erase operation via WIP bit. When the device is not in operation and CS# is high, it is put in standby mode and draws less than 10uA DC current. The MX25L1005 utilize MXIC's proprietary memory cell, which reliably stores memory contents even after 100,000 program and erase cycles.

13.2. Features

 Serial Peripheral Interface (SPI) compatible -- Mode 0 and Mode 3  1,048,576 x 1 bit structure  32 Equal Sectors with 4K byte each, Any Sector can be erased individually  2 Equal Blocks with 64K byte each, Any Block can be erased individually  Single Power Supply Operation

Page 41

 2.7 to 3.6 volt for read, erase, and program operations  Latch-up protected to 100mA from -1V to Vcc +1V  Low Vcc write inhibit is from 1.5V to 2.5V

13.3. Absolute Maximum Ratings

RATING VALUE Ambient Operating Temperature Storage Temperature -55°C to 125°C Applied Input Voltage -0.5v to 4.6v Applied Output Voltage -0.5v to 4.6v VCC to Ground Potential -0.5v to 4.6v

0°C to 70°C

13.4. Pinning

8-PIN SOP (150mil)

SYMBOL DESCRIPTION CS# Chip select SI Serial Data Input SO Serial Data Output SCLK Clock Input HOLD# Hold, to pause the device without

deselecting the device VCC +3.3v Power Supply GND Ground

Page 42

14. NAND FLASH MEMORY – NAND512XXA2C (U162)

14.1. General Description

The NAND flash 528-byte/ 264-word page is a family of non-volatile flash memories that uses the single level cell (SLC) NAND technology. It is referred to as the small page family.

The NAND512R3A2C, NAND512R4A2C, and NAND512W3A2C have a density of 512 Mbits and operate with either a 1.8 V or 3 V voltage supply. The size of a page is either 528 bytes (512 + 16 spare) or 264 words (256 + 8 spare) depending on whether the device has a x8 or x16 bus width.

The address lines are multiplexed with the Data Input/Output signals on a multiplexed x8 or x16 input/output bus. This interface reduces the pin count and makes it possible to migrate to other densities without changing the footprint.

To extend the lifetime of NAND flash devices it is strongly recommended to implement an error correction code (ECC). The use of ECC correction allows to achieve up to 100,000 program/erase cycles for each block. A write protect pin is available to give a hardware protection against program and erase operations.

14.2. Features

 High density NAND flash memories

o 512-Mbit memory array o Cost effective solutions for mass storage applications

 NAND interface

o x8 or x16 bus width o Multiplexed address/ data

 Supply voltage: 1.8 V, 3 V  Page size

o x8 device: (512 + 16 spare) bytes o x16 device: (256 + 8 spare) words

 Block size

o x8 device: (16K + 512 spare) bytes o x16 device: (8K + 256 spare) words

 Page read/program

o Random access: 12 μs (3 V)/15 μs (1.8 V) (max) o Sequential access: 30 ns (3 V)/50 ns (1.8 V) (min) o Page program time: 200 μs (typ)

 Copy back program mode

 Fast block erase: 2 ms (typ)

Page 43

 Status register  Electronic signature  Chip Enable ‘don’t care’  Security features

o OTP area

 Serial number (unique ID) option  Hardware data protection

o Program/erase locked during power transitions

 Data integrity

o 100,000 program/erase cycles (with ECC) o 10 years data retention

 RoHS compliant packages  Development tools

o Error correction code models o Bad blocks management and wear leveling algorithms

14.3. Pinning

Page 44

15. USB2.0 to Fast Ethernet – ASIX AX88X72A (U171)

15.1. General Description

The AX88772A/AX88172A Low-pin-count USB 2.0 to 10/100M Fast Ethernet controller is a high performance and highly integrated ASIC which enables low cost, small form factor, and simple plug-and-play Fast Ethernet network connection capability for desktops, notebook PC’s, Ultra-Mobile PC’s, docking stations, game consoles, digital-home appliances, and any embedded system using a standard USB port.

The AX88772A/AX88172A features a USB interface to communicate with a USB Host Controller and is compliant with USB specification V1.1 and V2.0. The AX88772A/AX88172A implements 10/100Mbps Ethernet LAN function based on IEEE802.3, and IEEE802.3u standards with 24KB of embedded SRAM for packet buffering. The AX88772A/AX88172A integrates an on-chip 10/100Mbps Ethernet PHY to simplify system design.

The AX88172A provides an optional External Media Interface (EMI) for external PHY or external MAC for different application purposes. The EMI can be a media-independent interface (MII) for implementing 100BASE-FX Ethernet or HomePNA functions. The EMI can also be a Reverse-MII or Reverse Reduced-MII (Reverse-RMII) for glueless MAC-toMAC connections to any MCU with Ethernet MAC MII or RMII interface. In addition, the EMI can be configured to Dual-PHY mode allowing AX88172A to act as an Ethernet PHY or USB 2.0 PHY for external MAC device that needs Ethernet and USB interfaces in their system applications. The optional serial interface such as I2C, SPI, and UART are provided as a control channel from the USB Host Controller to communicate with the external MCU chip.

15.2. Features

Single chip USB 2.0 to 10/100M Fast Ethernet controller – AX88772A

USB Device Interface

 Integrates on-chip USB 2.0 transceiver and SIE compliant to USB Spec 1.1 and

2.0

 Supports USB Full and High Speed modes with Bus-Power or Self-Power

capability

 Supports 4 or 6 programmable endpoints on USB interface  High performance packet transfer rate over USB bus using proprietary burst

transfer mechanism

 Supports USB to Ethernet bridging or vice versa in hardware

Fast Ethernet Controller

 Integrates 10/100Mbps Fast Ethernet MAC/PHY  IEEE 802.3 10BASE-T/100BASE-TX compatible  Supports twisted pair crossover detection and auto-correction (HP Auto-MDIX)  Embedded 16KB SRAM for RX packet buffering and 8KB SRAM for TX packet

buffering

 Supports both Full-duplex with flow control and

Page 45

 Half-duplex with backpressure operation  Supports 2 VLAN ID filtering, received VLAN Tag (4 bytes) can be stripped off or

preserved MAC/PHY loop-back diagnostic capability

Support Wake-on-LAN Function

 Supports Suspend Mode and Remote Wakeup via Link-up, Magic packet, MS

wakeup frame and external pin

 Optional PHY power down during Suspend Mode

Versatile External Media Interface

 Optional MII interface in MAC mode allows AX88172A to work with external

100BASE-FX Ethernet PHY or HomePNA PHY

 Optional Reverse-MII or Reverse-RMII interface in PHY mode allows AX88172A to

work with external HomePlug PHY or glueless MAC-to-MAC connections

 Optional Reverse-MII interface in Dual-PHY mode allows AX88172A to act as an

Ethernet PHY or USB 2.0 PHY for external MAC device that needs Ethernet and USB in system application

 Supports 256/512 bytes (93c56/93c66) of serial EEPROM (for storing USB

Descriptors)

 Supports automatic loading of Ethernet ID, USB Descriptors and Adapter

Configuration from EEPROM after power-on initialization

 Provides optional serial interface, I2C, SPI and UART  Integrates on-chip voltage regulator and only requires a single 3.3V power supply  12MHz and 25Mhz clock input from either crystal or oscillator source  Integrates on-chip power-on reset circuit

15.3. Block Diagram

Page 46

15.4. Pinning

16. LM1117(U175, U180, U181)

16.1. General Description

The LM1117 is a series of low dropout voltage regulators with a dropout of 1.2V at 800mA of load current. It has the same pin-out as National Semiconductor’s industry standard LM317. The LM1117 is available in an adjustable version, which can set the output voltage from 1.25V to 13.8V with only two external resistors. In addition, it is also available in five fixed voltages, 1.8V, 2.5V, 2.85V, 3.3V, and 5V. The LM1117 offers current limiting and thermal shutdown. Its circuit includes a zener trimmed bandgap reference to as-sure output voltage accuracy to within ±1%. The LM1117 series is available in SOT- 223, TO-220, and TO-252 D-PAK packages. A mi tantalum capacitor is required at the output to improve the transient response and stability.

16.2. Features

 Available in 1.8V, 2.5V, 2.85V, 3.3V, 5V, and Adjustable Versions  Space Saving SOT-223 Package  Current Limiting and Thermal Protection  Output Current 800mA  Line Regulation 0.2% (Max)  Load Regulation 0.4% (Max)  Temperature Range  LM1117 0°C to 125°C  LM1117I -40°C to 125°C

nimum of 10μF

Page 47

16.3. Applications

 2.85V Model for SCSI-2 Active Termination  Post Regulator for Switching DC/DC Converter  High Efficiency Linear Regulators 15  32” TFT TV Service Manual 10/01/2005  Battery Charger  Battery Powered Instrumentation

16.4. Absolute Maximum Ratings

16.5. Pinning

17. MP2012 (U176)

17.1. General Description

The MP2012 is a fully integrated, internally compensated 1.2MHz fixed frequency PWM step-down converter. It is ideal for powering portable equipment that runs from a single cell Lithium-Ion (Li+) Battery, with an input range from 2.7V to 6V. The MP2012 can provide up to 1.5A of load current with output voltage as low as 0.8V. It can also operate at 100% duty cycle for low dropout applications. With peak current mode control and internal compensation, the MP2012 is stable with ceramic capacitors and small inductors. Fault condition protection includes cycle-by-cycle current limiting and thermal shutdown.

17.2. Features

 2.7-6V Input Operation Range  Output Adjustable from 0.8V to VIN  1μA Max Shutdown Current.  Up to 95% Efficiency

Page 48

 100% Duty Cycle for Low Dropout

Name

Description

 Applications  1.2MHz Fixed Switching Frequency  Stable with Low ESR Output Ceramic  Capacitors  Thermal Shutdown  Cycle-by-Cycle Over Current Protection  Short Circuit Protection  Available in 6-pin 3x3mm QFN

17.3. Pinning

1 FB Feedback input. An external resistor divider from

the output to GND, tapped to the FB pin sets the output voltage.

2 GND,

Exposed

Pad 3 SW Switch node to the inductor. 4 PVIN Input supply pin for power FET. 5 VIN Input Supply pin for controller. Put small

6 EN Enable input, “High” enables MP2012. EN is

Ground pin. Connect exposed pad to ground plane for proper thermal performance.

decoupling ceramic near this pin.

pulled to GND with 1Meg internal resistor.

18. RTA8283A (U23, U173)

18.1. General Description

The RT8283A is a high-efficiency, monolithic synchronous step-down DC/DC converter that can deliver up to 3A output current from a 4.5V to 23V input supply. The RT8283A's current mode architecture and external compensation allow the transient response to be optimized over a wide range of loads and output capacitors. Cycle-by-cycle current limit provides protection against shorted outputs and soft-start eliminates input current surge during start-up. The RT8283A also provides output under voltage protection and thermal shutdown protection. The low current (<3μA) shutdown mode provides output disconnect, enabling easy power management in batterypowered systems. The RT8283A is available in a SOP-8 package.

Page 49

18.2. Features

Pin No.

Description

 ±1.5% High Accuracy Feedback Voltage  Integrated N-MOSFET Switches  Current Mode Control  Fixed Frequency Operation : 340kHz  Output Adjustable from 0.8V to 20V  Up to 95% Efficiency  Thermal Shutdown Protection

18.3. Pinning

Name

1 BOOT

4, 9 (Exposed

Pad)

VIN Input Supply 4.5V to 23V. Must bypass with a suitably

SW Phase Node--Connect to external L-C filter..

GND Ground.

FB Feedback Input pin is connected to the converter output.

COMP Compensation Node. COMP is used to compensate the

EN Enable Input Pin. Logic high enables the converter; a

SS Soft-Start Control Input. SS controls the soft-start period.

Bootstrap for high-side gate driver. Connect a 0.1μF or greater ceramic capacitor from BOOT to SW pins.

large ceramic capacitor.

It is used to set the output of the converter to regulate to the desired value via an internal res divider. For an adjustable output, an external res divider is connected to this pin.

regulation Control loop. Connect a series RC network from COMP to GND. In some cases, an additional capacitor from COMP to GND is required.

logic low forces the RT8253A into shutdown mode. Attach this pin to VIN with a 100kΩ pull up resistor for automatic startup.

Connect a capacitor from SS to GND to set the soft-start

period. A 0.1

13.5ms.

μF capacitor sets the soft-start period to

19. MP1583 (U174)

19.1. General Description

The MP1583 is a step-down regulator with a built-in internal Power MOSFET. It achieves 3A of continuous output current over a wide input supply range with excellent load and line regulation. Current mode operation provides fast transient response and eases loop

Page 50

stabilization. Fault condition protection includes cycle-by-cycle current limiting and thermal

Description

shutdown. An adjustable soft-start reduces the stress on the input source at start-up. The MP1583 requires a minimum number of external components, providing a compact solution.

19.2. Features

 3A Output Current  Programmable Soft-Start  100mΩ Internal Power MOSFET Switch  Stable with Low ESR Output Ceramic Capacitors  Up to 95% Efficiency  20μA Shutdown Mode  Fixed 385KHz Frequency  Thermal Shutdown  Cycle-by-Cycle Over Current Protection  Wide 4.75V to 23V Operating Input Range  Output Adjustable from 1.22V to 21V  Under-Voltage Lockout

19.3. Pinning

No.

1 BOOT High-Side Gate Drive Bootstrap Input. BS supplies the drive for the

2 3

4 5

Name

high-side N-Channel MOSFET switch.

IN Power Input. Drive IN with a 4.75V to 23V power source.

SW Power Switching Out is the switching node that supplies power to the

output

GND Ground.

FB Feedback Input. FB senses the output voltage and regulates it. Drive

FB with a resistive voltage divider from the output voltage. FB threshold is 1.222V.

COMP Compensation Node is used to compensate the regulation control

loop.

EN Enable/UVLO. A voltage greater than 2.71V enables operation. For

complete low current shutdown the EN pin voltage needs to be at less than 900mV. When the voltage on EN exceeds 1.2V, the internal regulator will be enabled and the soft-start capacitor will begin to charge. The MP1583 will start switching after the EN pin voltage reaches 2.71V.

SS Soft-Start Control Input. SS controls the soft-start period.

Page 51

20. FDC642

20.1. General Description

This P-Channel 2.5V specified MOSFET is produced using Fairchild’s advanced PowerTrench and yet maintain low gate charge for superior switching performance.

These devices have been designed to offer exceptional power dissipation in a very small footprint for applications where the larger packages are impractical.

20.2. Features

 Max rDS(on) = 65 mΩ at VGS = -4.5 V, ID = -4.0 A  Max rDS(on) = 100 mΩ at VGS = -2.5 V, ID = -3.2 A  Fast switching speed  Low gate charge (11nC typical)  High performance trench technology for extremely low rDS(on)  SuperSOTTM-6 package: small footprint (72% smaller than standard SO-8);

 Termination is Lead-free and RoHS Compliant

® process that has been especially tailored to minimize on-state resistance

low profile (1 mm thick)

20.3. Pinning

21. FDC604P

21.1. General Description

This P-Channel 1.8V specified MOSFET uses Fairchild’s low voltage PowerTrench process. It has been optimized for battery power management applications.

21.2. Features

 –5.5 A, –20 V. RDS(ON) = 33 mΩ @ VGS = –4.5 V  RDS(ON) = 43 mΩ @ VGS = –2.5 V  RDS(ON) = 60 mΩ @ VGS = –1.8 V  Fast switching speed.  High performance trench technology for extremely low RDS(ON)(S)

Page 52

21.3. Pinning

22. CONNECTORS

22.1. SCART (SC1)

22.2. HDMI (CN707,CN708)

Page 53

22.3. VGA (CN132)

Page 54

23. SERVICE MENU SETTINGS

In order to reach service menu, First Press “MENU” Then press the remote control code two times, which is

In first screen following items can be seen:

“4725”.

Page 55

23.1. Video Settings

Page 56

23.2. Audio Settings

Page 57

23.3. Options

Options-1

Page 58

Options-2

Page 59

23.4. Tuning Settings

Page 60

23.5. Source Settings

Page 61

23.6. Diagnostic

23.7. USB Operations

USB operations option can not be used directly. It can be used for updating panel tool, hw congiguration etc.

Page 62

24. SOFTWARE UPDATE

In MB60 project there is only one software. From following steps software update procedure can be seen:

1. MB60_en.bin, mboot.bin and usb_auto_update_T4.txt documents should copy directly inside of a flash memory(not in a folder).

2. Put flash memory to the tv when tv is powered off.

3. Power on the and wait when the tv is opened.

4. If First Time Installition screen comes, it means software update procedure is succesful.

Page 63

25. TROUBLESHOOTING

25.1. No Backlight Problem

Problem: If TV is working, led is normal and there is no picture and backlight on the panel.

Possible couses: Backlight pin, dimming pin, backlight supply, stby on/off pin

Backlight pin should be high in open position. If it is low, please check Q181 and panel cables.

Dimming pin should be high or square wave in open position. If it is low, please check S16 for Mstar side and panel or power cables, connectors.

Backlight power supply should be in panel specs. Please check CN705 for MB60, related connectors for power supply cards.

Page 64

STBY_ON/OFF should be low for standby on condition, please check R1677.

25.2. CI Module Problem

Problem: CI is not working when CI module inserted.

Possible couses: Supply, suply control pin, detect pins, mechanical positions of pins CI supply shoul be 5V when CI module inserted. If it is not 5V please check CI_POWER_CTRL, this pin should be low.

Page 65

Please check mechanical positions of CI module.

Detect ports should be low. If it is not low please check CI connector pins, CI module pins and 3V3_VCC on MB60.

Page 66

25.3. Led Blinking Problem

Problem: LED blinking, no other operation

This problem indicates a short on Vcc voltages. Protect pin should be logic high while normal operation. When there is a short circuit protect pin will be logic low. If you detect logic low on protect pin, unplug the TV set and control voltage points with a multimeter to find the shorted voltage to ground.

Page 67

25.4. IR Problem

Problem: LED or IR not working Check LED card supply on MB60 chasis.

25.5. Keypad Touchpad Problems

Problem: Keypad or Touchpad is not working

Check keypad supply and KEYBOARD pin on MB60.

Page 68

25.6. USB Problems

Problem: USB is not working or no USB Detection.

Check USB Supply, It should be nearly 5V. Also USB Enable should be logic high.

Page 69

25.7. No Sound Problem

Problem: No audio at main TV speaker outputs.

Check supply voltages of VDD_AUDIO, 5V_VCC and 3V3_VCC with a voltage-meter. There may be a problem in headphone connector or headphone detect circuit (when headphone is connected, speakers are automatically muted). Measure voltage at HP_DETECT pin, it should be 3.3v.

25.8. No Sound Problem at Headphone

Problem: No audio at headphone output.

Check HP detect pin, when headphone is. Check 5V_VCC and 3V3_VCC with a voltagemeter.

Page 70

25.9. Standby On/Off Problem

Problem: Device cannot boot, TV hangs in standby mode.

There may be a problem about power supply. Check 12V_VCC, 5V_VCC and 3V3_VCC with a voltage-meter. Also there may be a problem about SW. Try to update TV with latest SW. Additionally it is goood to check SW printouts via hyper-terminal (or Teraterm). These printouts may give a clue about the problem.

DVD Problems

Problem: DVD is not working.

Check that DVD source is selected in Service menu. Check supply voltage of DVD namely 12V_VCC.

Page 71

25.10. No Signal Problem

Problem: No signal in TV mode.

Check tuner supply voltage; 5V_TUN. Check tuner options are correctly set in Service menu. Check AGC voltage at RF_AGC pin of tuner.

Page 72

PART LIST

LC22LE22E(CMO PANEL)

LC22LE22E(CPT PANEL)

LC-22D12E

Page 73

LC-22D12E PART LIST

No Part Code Description Detail Description

1 20545616 CHS.ASSY.17MB60-C1K1231H122221115B1 2 20520965 FRONT 22883(16/9)WO/FH(BCB/P-V)SHARP/S Front Panel 3 20535488 BC.AS.22880W-DV SB&46(WO/D&F(I(SHARP Back Cover 4 20531132 MD.ASY.17LD98-7-19-22880 (MB25(SHARP) Led Board 5 30064217 CNAS 5P/200 FLT W/C UL2468AWG26 ROHS Led Board Cable 6 40043425 LED IR LENS TFT XX856 (%3 MILKY) VER7. 7 30069931 CNAS 20P/60 SIS W/DC UL1007#24 SHARP RHS Cable, 8 20464600 CN.A.FFC 30P/300 P=1MM LVDS(2287545LG LVDS 9 30067598 TFT LCD 216W LG LC220WXE TBA1 (CN)RoHS 10 35027727 FR_22880_MB60_IPS17_DVD_VER1_V 11 20521139 ROC.SW.AS.(MB60_SHARP) 12 20542346 SPK.AS.19820/2/850(R/L(MB60-6P)B(WO/C(SH 13 30064691 CNAS 2P/150 SIS UL3239 AWG22 W/LOCK ROHS Inverter Cable 14 20529682 FOOT ASSY 19900W (GLOSSY-BL-PMMA)SHARP 15 20415732 POWER CORD AS.GR-(180-27(UK)FL WO/STR 16 20533781 MD.ASY.17IPS17-22"(CAB(60(WO/D(LTB(R(SH 17 40045321 BRACKET IO 17MB25/45 ROCK.V28(I(AB_V0(SH 18 35008088 SCREW P C ZN YSMB 4*16 RoHS Screw 19 50168123 LABEL BR.MB60 VER.3 20 35026325 SCREW P C ZN RYSB 4x12 ROHS Screw 21 35008081 SCREW P C ZN YFMB 3*9.5 R7 RoHS Screw 22 35026001 SCREW M 3*6 YFMBT TAPTITE (ROHS) Screw 24 20437497 SNOW BOX ASSY (R/L) 22820 16/9 23 50145606 PLASTIZOTE BAG (680mm*680mm)19"-22" TFT 26 50177069 CARTON BOX SHARP LC-22D12E 25 20533190 ARTWORK SHARP LC-22D12E

Page 74

Page 75

Page 76

Page 77

Page 78

Page 79

Page 80

Part Code

Description

20545616

CHS.ASSY.17MB60-C1K1231H122221115B1

30000588

RES SMD 1/10W 220R J 0805 ROHS

R124

30001457

TR NBJT BC848B 0.1A/30V SOT23 ROHS

Q119

Q170

Q171

Q178

Q181

Q185

Q188

Q189

Q190

Q191

Q194

Q204

Q205

Q207

Q208

Q186

30001458

TR BC858B SMD

Q146

Q173

Q174

Q180

Q193

Q195

30007800

TR NBJT BF799 0.35A/30V RF SOT23 RoHS

Q144

30010594

CAP ELCH 100UF 16V M 86mA 6.3x5.4 ROHS

C1168

C1169

30010733

TR NMOS 2N7002 0.1A/60V SOT23 ROHS

Q192

Q210

30012411

DIODE SMD BA782 0.1A 35V SOD123 ROHS

D145

30015406

CAP ELCH 22UF 16V M 30mA 4x5.4 ROHS

C1031

30016659

COIL SMD 1uH 50mA K 0R4 805 Ro

L114

30018060

TR PMOS FDC642P -4A/-20V SSOT6 ROHS

Q199

30019087

FERRIT SMD 60R/100MHz 0.025 M 3A 0805Roh

F181

F187

F270

F271

F272

F274

F275

F277

F291

F296

F297

F298

F299

F300

F303

30019996

DIODE BAV70 215mA/75V 4A SOT23 RoHS

D169

30020142

CAP SMD 1UF 25V Z Y5V (0805) RoHS

C1128

30020394

FERRIT SMD 330/100MHz 0.1R M 1.5A 805Ro

F179

F261

F266

F268

30020530

FERRIT SMD 600R/100MHz 0.5R M 0.2A 603Ro

F200

F201

F205

F206

F248

F259

F301

30021958

RES SMD 1/16W 47K J 0402 RoHS

R1201

R1862

R1863

30021960

RES SMD 1/16W 47R J 0402 ROHS

R1249

R1725

R793

30021977

RES SMD 1/16W 1.2K J 0402 RoHS

R483

R1957

R1662

R344

30021987

RES SMD 1/16W 4.7K J 0402 RoHS

R1149

R1158

R1165

R1166

R1171

R1172

R1177

R1182

R1183

R1524

R1527

R1529

R1601

R1614

R1615

R1617

R1618

R1660

R1661

R1663

R1671

R1672

R1678

R1748

R1896

R252

R809

R1198

R1951

R1952

R1953

R1959

R1357

R1358

30021989

RES SMD 1/16W 100K J 0402 ROHS

R1932

R1933

R1934

R209

R884

R1769

R1718

R1701

30021990

RES SMD 1/16W 4.7R J 0402 ROHS

R844

R845

30021991

RES SMD 1/16W 100R J 0402 ROHS

R1243

R1244

R1245

R1248

R1543

R1546

R1549

R1550

R1551

R1552

R1666

R1720

R1721

R1897

R1900

R1946

R1947

R1948

R1949

R222

R223

R221

R620

R1954

R6R7R8

R1679

R1677

30021996

RES SMD 1/16W 10K J 0402 ROHS

R1265

R1310

R1311

R1562

R1563

R1567

R1568

R1632

R1635

R1636

R1638

R1639

R1642

R1667

R1684

R1685

R1691

R1693

R1854

R1855

R1901

R1902

R1591

R1592

R1596

R1597

R1833

R1835

R1836

R1838

R1840

R1939

R1309

R1702

R1593

R1950

30021999

RES SMD 1/16W 10R J 0402 RoHS

R1870

R1871

R1872

R1873

R1874

R1875

R1876

R1881

R1882

R1883

R1884

R384

30022003

RES SMD 1/16W 470R J 0402 ROHS

R1423

R1505

30022024

RES SMD 1/16W 12K J 0402 ROHS

R1589

R1920

R1921

Pozition

Page 81

30022026

RES SMD 1/16W 150K J 0402 RoHS

R1770

30022040

RES SMD 1/16W 18K J 0402 RoHS

R1606

30022041

RES SMD 1/16W 1K F 0402 ROHS

R1356

R1365

R1768

R1955

R1941

30022042

RES SMD 1/16W 1K J 0402 RoHS

R1221

R138

R139

R1582

R1668

R1909

R1912

R1676

30022043

RES SMD 1/16W 1M J 0402 ROHS

R1533

30022051

RES SMD 1/16W 2.7K J 0402 ROHS

R1206

R1209

R231

30022053

RES SMD 1/16W 20K F 0402 ROHS

R1738

30022054

RES SMD 1/16W 20K J 0402 ROHS

R1928

R1929

30022055

RES SMD 1/16W 220K J 0402 ROHS

R1898

R1899

R1915

R1916

30022056

RES SMD 1/16W 220R J 0402 RoHS

R1233

R1569

R1570

R1571

R1572

R1858

R1859

R1958

30022057

RES SMD 1/16W 22K J 0402 RoHS

R1187

R1750

R594

30022068

RES SMD 1/16W 6.8K F 0402 ROHS

R473

R474

R1598

30022078

RES SMD 1/16W 3.9K J 0402 RoHS

R1495

R1496

R1710

30022083

RES SMD 1/16W 330R J 0402 ROHS

R1956

30022084

RES SMD 1/16W 33K J 0402 RoHS

R1605

R1727

R1913

R1914

R104

30022085

RES SMD 1/16W 33R J 0402 RoHS

R1173

R1401

R1402

R1424

R1425

R1426

R1427

R1512

R1513

R1514

R1942

S25

30022088

RES SMD 1/16W 680R F 0402 ROHS

R735

R1960

R1704

30022098

RES SMD 1/16W 390R J 0402 RoHS

R102

30022099

RES SMD 1/16W 39K J 0402 ROHS

R1686

30022112

RES SMD 1/16W 68K J 0402 RoHS

R103

30022118

RES SMD 1/16W 75R J 0402 RoHS

R1479

R1480

R1481

R1482

R1483

R1489

R1515

R1516

R1517

R1587

30022122

RES SMD 1/16W 82K J 0402 ROHS

R1926

R1927

30022132

RES SMD 1/16W 0R 0402 ROHS

R1580

R1857

S16

S49

S83

R1408

R1409

R1416

R1417

R1418

R1419

R1420

R1421

R1422

R1507

R1509

R1510

R1530

R1940

30022140

RES SMD 1/16W 22K F (0402) RoHS

R1924

R1925

R1736

30022165

CAP SMD 3.3PF 50V J COG (0402) RoHS

C968

30022167

CAP SMD 4.7PF 50V J COG (402) ROHS

C967

30022196

CAP SMD 470PF 50V J X7R (0402) ROHS

C1187

C1188

30022237

CAP SMD 27PF 50V J COG (0402) ROHS

C825

C826

C827

C949

30022238

CAP SMD 33PF 50V J COG (0402) ROHS

C951

C952

30022240

CAP SMD 47PF 50V J COG (0402) ROHS

C1205

C1206

C545

C860

R1961

R1962

30022244

CAP SMD 100PF 50V J COG (0402) ROHS

C1185

C1186

30022246

CAP SMD 150PF 50V J COG (0402) ROHS

C964

30022248

CAP SMD 220PF 50V J COG (0402) RoHS

C831

C832

C833

C835

C836

C838

C839

C840

30022336

CAP SMD 3.3NF 50V J X7R (0402) ROHS

C853

C854

30022338

CAP SMD 4.7NF 50V J X7R (0402) RoHS

C857

C858

C1183

C1184

30022339

CAP SMD 5.6NF 50V J X7R (0402) ROHS

C1131

30022342

CAP SMD 10NF 16V J X7R (0402) ROHS

C1113

C1172

C546

C547

C729

30022351

CAP SMD 47NF 16V J X5R (0402) ROHS

C796

C798

C806

C810

C882

C884

C959

C794

30024769

CAP ELCH 47UF 16V M 52mA 5x5.4 ROHS

C143

30024778

FERRIT SMD 60R/100MHz 0.1R M 0.5A 603Ro

F295

30025158

COIL SMD 4.7uH 0.14A M 0R4 805 Ro

L119

L120

30029775

TR NMOS BSN20 0.17A/50V SOT23 ROHS

Q140

30030097

CAP SMD 100NF 10V K X5R (0402) RoHS

C1015

C1035

C1042

C135

C14

C630

C653

C654

C656

C657

C658

C663

C664

C901

C902

Page 82

C903

C904

C907

C910

C971

C905

C906

30030099

CAP SMD 1NF 50V K X7R (0402) ROHS

C861

C862

C942

C943

C944

C945

30038478

DIODE SMD ZEN C15V SOD123 ROHS

D178

30038479

DIODE SMD ZEN C3V6 SOD123 ROHS

30038480

DIODE SMD ZEN C5.6V SOD123 ROHS

D203

30038502

DIODE SMD ZEN B5.1V SOD123 ROHS

D204

30038507

DIODE SMD 1N4148 0.15A/100V SOD123 RoHS

D189

D191

30038984

RES NET 1/32W 100R J 8P 0402 ROHS

R1588

R1761

R1379

30042066

DIODE SMDSCH1N5819 1A/40V/25A SOD123ROHS

D165

30042505

RES NET 1/32W 33R J 8P 0402 ROHS

R1382

R1383

R1384

R1385

R1388

R1389

R1390

R1392

R1393

R1394

R1395

R1396

R1397

R1398

R1399

30044848

CAP SMD 100NF 16V K X7R (0402) ROHS

C1001

C1004

C1174

C1016

C1034

C1213

C912

C913

30046140

CAP SMD 10UF 6.3V M X5R (0805) ROHS

C1028

C1029

C1030

C1081

30047296

CAP SMD 22UF 6.3V M X5R (0805) ROHS

C868

C970

30048473

DIODE DUALSMD BAW56 4A/75V/4A SOT23ROHS

D185

D186

D184

30050554

CAP SMD 1UF 6.3V M X5R (0402) RoHS

C1202

C1203

C974

C1107

30050558

CAP SMD 100NF 16V K X5R (0402) ROHS

C1005

C1007

C1008

C1009

C1014

C1022

C1024

C1025

C1058

C1070

C1177

C997

30051167

CAP SMD 220NF 10V X7R K (0402) ROHS

C683

C709

C710

C712

30053657

DIODE ARRAY ESD NUP4004M5 TSOP-5 RoHS

D173

D174

D175

D176

30055201

COIL SMD 2.2uH 15mA J 1R15 603 Ro

L104

30055434

RES SMD 1/16W 62R J 0402 ROHS

R1411

R1415

30057263

XTAL 24MHz 22pF 30ppm 25OhmHC49S SMDROHS

30057644

IC DOPAMP TL062 SO8 RoHS

U178

30058702

COIL SMD 10uH 2.5A M 0R4 7x7(SHL)Ro

L116

L117

30060344

IC LDO LM1117 ADJ/1A DPAK ROHS

U175

U180

U181

30060852

IC ANALOG 2:1SWITCH FSA3157 SC70 ROHS

30061154

CAP SMD 82PF 50V J C0G (0402) MXM ROHS

C1210

30062359

CAP SMD 47NF 16V K X7R (0402) ROHS

C795

C797

C802

C807

C808

C809

C885

30062763

IC STMPS2161 SOT23-5L ROHS

U149

30062776

DIODE ESD AZ1045-04S SOT23-6 ROHS

U145

30063686

CAP ELCH 100UF 16V M 105C 6.3x5.4 ROHS

C1079

C1080

C1214

30064117

CAP SMD 10UF 16V K X5R (0805) RoHS

C120

30064117

CAP SMD 10UF 16V K X5R (0805) RoHS

C1032

30064783

CAP SMD 1UF 6.3V K X6S (0402) ROHS

C1201

30066018

SOCKET HDMI 19P 0.5MM TOP ROHS

CN707

30066876

CAP SMD 4.7UF 10V K X7R (0805) ROHS

C1200

30066926

IC STEP DOWN MP2012 ADJ/1.5A QFN6 RoHS

U176

30067506

JACK HEADPHONE BLACK 3 POLE SIDE ROHS

JK6

30067595

CAP SMD 22UF 16V M X5R (1206) RoHS

C1084

C1085

C1093

C1094

C1098

C1101

C1212

C5C6C7

C782

C990

C1086

C1087

30067872

CAP SMD 10UF 10V M X5R (0805) ROHS

C1197

C1198

30067872

CAP SMD 10UF 10V M X5R (0805) ROHS

C1170

C1171

C1180

C1181

C1182

C378

C610

30067968

CAP SMD 10UF 10V M X7R (0805) ROHS

C1199

30068279

COIL SMD 120nH 0.4A J 0R51 805 Ro

L115

30068280

COIL SMD 150nH 0.15A J 2R8 402 Ro

L124

30068939

IC STEP DOWN RT8283A ADJ/3A SO8 RoHS

U173

Page 83

30069320

CAP SMD 22UF 6.3V M X7R (1206) RoHS

C1033

30069322

IC NAND 512Mb NAND512BW3D TSOP48 ROHS

U162

30069698

TR NMOS BSH103 0.85A/30V SOT23 ROHS

Q209

30070314

IC FLASH SPI 8Mb MX25L8006E SO8 ROHS

U158

30001457

TR NBJT BC848B 0.1A/30V SOT23 ROHS

Q133

Q160

30019087

FERRIT SMD 60R/100MHz 0.025 M 3A 0805Roh

F294

30021958

RES SMD 1/16W 47K J 0402 RoHS

R1699

30021987

RES SMD 1/16W 4.7K J 0402 RoHS

R613

R614

R623

R624

30021991

RES SMD 1/16W 100R J 0402 ROHS

R817

R818

30030097

CAP SMD 100NF 10V K X5R (0402) RoHS

C665

C666

30051167

CAP SMD 220NF 10V X7R K (0402) ROHS

C602

C608

C612

C617

30065929

CAP ELCH 220UF 10V M 150mA 8x6.5 ROHS

C615

C870

30067953

IC AAMP AZAD2102 1x2.9W WCSP-9 RoHS

U163

U164

30001457

TR NBJT BC848B 0.1A/30V SOT23 ROHS

Q182

Q183

30001734

RES SMD 1/10W 0R 0805 ROHS

S21

S24

30010560

CAP SMD 220NF 25V K X7R (0805) ROHS

C1048

C1049

30018060

TR PMOS FDC642P -4A/-20V SSOT6 ROHS

Q197

Q200

30019087

FERRIT SMD 60R/100MHz 0.025 M 3A 0805Roh

F286

F305

F273

30021960

RES SMD 1/16W 47R J 0402 ROHS

R1723

R1724

30021996

RES SMD 1/16W 10K J 0402 ROHS

R1689

R1692

R1697

R1730

30022014

RES SMD 1/16W 5.6K J 0402 RoHS

R1708

30022068

RES SMD 1/16W 6.8K F 0402 ROHS

30022084

RES SMD 1/16W 33K J 0402 RoHS

R1731

R1732

R1733

30022132

RES SMD 1/16W 0R 0402 ROHS

S95

S86

30022140

RES SMD 1/16W 22K F (0402) RoHS

R1735

30022336

CAP SMD 3.3NF 50V J X7R (0402) ROHS

C1129

30022342

CAP SMD 10NF 16V J X7R (0402) ROHS

C1114

30030097

CAP SMD 100NF 10V K X5R (0402) RoHS

C1036

30057938

COIL SMD 22uH 3.6A M 35R12x12(SHL)Ro

L123

30062423

FUSE SAFE SMD 4A/32VDC UF HMELT 1206RoHS

FS5

30064145

FUSE SAFE SMD 2A/63VDC UF 1206 RoHS

FS4

30067595

CAP SMD 22UF 16V M X5R (1206) RoHS

C1089

C1090

C1096

C1097

30068939

IC STEP DOWN RT8283A ADJ/3A SO8 RoHS

U23

30021977

RES SMD 1/16W 1.2K J 0402 RoHS

R1498

30021987

RES SMD 1/16W 4.7K J 0402 RoHS

R1528

30021996

RES SMD 1/16W 10K J 0402 ROHS

R1294

30022051

RES SMD 1/16W 2.7K J 0402 ROHS

R1497

30022060

RES SMD 1/16W 270R J 0402 ROHS

R1499

30020530

FERRIT SMD 600R/100MHz 0.5R M 0.2A 603Ro

F202

F203

30021996

RES SMD 1/16W 10K J 0402 ROHS

R1903

R1904

30022024

RES SMD 1/16W 12K J 0402 ROHS

R1918

R1919

30022118

RES SMD 1/16W 75R J 0402 RoHS

R1486

30022196

CAP SMD 470PF 50V J X7R (0402) ROHS

C1189

C1190

30022248

CAP SMD 220PF 50V J COG (0402) RoHS

C830

30022336

CAP SMD 3.3NF 50V J X7R (0402) ROHS

C855

C856

30038480

DIODE SMD ZEN C5.6V SOD123 ROHS

D171

30055434

RES SMD 1/16W 62R J 0402 ROHS

R1412

30062359

CAP SMD 47NF 16V K X7R (0402) ROHS

C799

30067872

CAP SMD 10UF 10V M X5R (0805) ROHS

C1195

C1196

30067216

JACK HEADPHONE YELLOW 3 POLE SIDE ROHS

JK3

30022132

RES SMD 1/16W 0R 0402 ROHS

S93

30001457

TR NBJT BC848B 0.1A/30V SOT23 ROHS

Q202

30021987

RES SMD 1/16W 4.7K J 0402 RoHS

R1889

R1890

30021991

RES SMD 1/16W 100R J 0402 ROHS

R1907

30022042

RES SMD 1/16W 1K J 0402 RoHS

R1908

30030097

CAP SMD 100NF 10V K X5R (0402) RoHS

C1175

C1176

Page 84

30063648

FERRIT SMD 120/100MHz 0.09R M1.2A 0402Ro

S92

30022003

RES SMD 1/16W 470R J 0402 ROHS

R1494

30022118

RES SMD 1/16W 75R J 0402 RoHS

R1619

R1620

R1621

30022132

RES SMD 1/16W 0R 0402 ROHS

R1405

R1406

R1407

R1506

R1508

R1511

30022237

CAP SMD 27PF 50V J COG (0402) ROHS

C823

C828

C829

30022351

CAP SMD 47NF 16V J X5R (0402) ROHS

C803

C883

30030099

CAP SMD 1NF 50V K X7R (0402) ROHS

C859

30053657

DIODE ARRAY ESD NUP4004M5 TSOP-5 RoHS

D177

30062359

CAP SMD 47NF 16V K X7R (0402) ROHS

C804

C805

C881

C886

30067217

JACK HEADPHONE GREEN 3 POLE SIDE ROHS

JK2

30022041

RES SMD 1/16W 1K F 0402 ROHS

R1355

R1364

30022058

RES SMD 1/16W 22R J 0402 ROHS

R1313

R1314

R1330

R1331

R1332

R1333

R1335

R1350

R1602

R1603

30041373

RES NET 1/16W 22R J 8P 0402 ROHS

R1366

R1367

R1368

R1369

R1370

R1380

R1609

R1610

R1613

30051167

CAP SMD 220NF 10V X7R K (0402) ROHS

C687

C711

C713

C714

C715

C716

C718

30068585

IC MSD9WA7PX BGA523 RoHS

U157

30069958

IC DDR2 64Mx16 K4T1G164QF-BCF7 BGA84 ROH

U155

30019087

FERRIT SMD 60R/100MHz 0.025 M 3A 0805Roh

F288

F289

30022057

RES SMD 1/16W 22K J 0402 RoHS

R1749

30022084

RES SMD 1/16W 33K J 0402 RoHS

R1734

30067872

CAP SMD 10UF 10V M X5R (0805) ROHS

C774

30022132

RES SMD 1/16W 0R 0402 ROHS

S14S3S99

30060746

CONN FFC 30P 1MM TOP LVDS ROHS

CN138

30022132

RES SMD 1/16W 0R 0402 ROHS

R1547

R1548

30001692

FILTER SAW OFWK3953MROHS

Z102

30012545

FILTER SAW K9656M ROHS

Z101

30044670

SOCKET USB SIDE RoHS

CN128

30059740

SOCKET D-SUB 15P TOP 11.9MM RoHS

CN132

30063090

CONN HEADER 5P 2.0MM SIDE W/LOCK RoHS

CN703

30067876

SOCKET PCMCIA S.DECK 4mm HEADERonly RoHS

CN141

40043122

SUPER THIN POWDER (20*20*2)Rohs

U157

30066601

SWITCH TACT LONG SIDE 10V 0.5A RoHS

SW1

SW2

SW3

SW4

30067985

CONN SCART 21P WO/SCREW ROHS

SC1

30066835

JACK RCA 1P BLACK TOP RoHS

JK10

30066828

CONN PINHEADER2x10P2.54W/PLASTICSIDEROHS

CN706

30069671

TUNER DIG. HALF-NIM DTOS403LH122E RoHS

TU102

30066919

CONN HEADER 6P 2.0MM SIDE W/LOCK RoHS

CN710

Page 85

Part Code

Description

20533781

MD.ASY.17IPS17-22"(CAB(60(WO/D(LTB(R(SH

30064715

IC SMPS STRW6253 TO220F-6L SHORTPIN ROHS

IC800

30048782

DIODE SCH STPS20H100CFP20A/100V TO220ROH

D811

30057295

DIODESCHSBR10U150 10A/150V/120ATO220RoHS

D827

30000084

CAP MKPSAFE 150NF 275V M AC15BOXTOSHROHS

C802

30005819

CAP EL 1000UF 16V M 105°1110mA 10x20ROHS

C820

C825

30007750

CAP EL 470UF 35V M 105°1400mA 10x20 ROHS

C144

30015087

IC SAFE OPTOCOUPLER TCET1102G

IC801

30016086

CAP EL 1000UF 25V M 105° 715mA 10x20RoHS

C822

C823

C826

30018085

CAP VAR SAFE 510V K MFCN14D511 ROHS

R805

30018122

Choke Coil 1.0uH 20A M 0.4R 15x10 Ro

L805

L810

30021165

CAP MKT SAFE 220NF 275V M AC P=15mm

C801

30031046

CONN HEADER SAFE 2P(V0)7.5MM TOP WHT TOS

PL801

30053327

CAP CER 4.7PF 3KV J SL ROHS

C130

30059224

RES MO 2W 91K J RoHS

R818

30062616

TRF INV. SAFE 22''-26'' 15mmRoHS

TR100

30062820

CONN HEADER SAFE 2P V0 7.5MM TOP BLK TOS

PL815

30062914

TRF SMT SAFE15''/19'' PQ3220 22mmRo

TR801

30063176

Line Filter Safe Hor.2x22mH%50 2A UF16Ro

L800

30064314

RES THE SAFE 10R/3A NTC SCK-103 BLK RoHS

TH3

30064604

CAP CER 2.7PF 3KV J ROHS

C124

30064690

CONN HEADER 2P 3.5MM SIDE(V0)HV W/LOCKRO

PL101

PL102

PL103

PL104

30065718

CONN HEADER 2x10P 2.54MM TOP W/LOCK ROHS

PL803

30069938

CAP CER SAFE 1NF 4KV M 3.5MMSHARP ROHS

C815

30069939

CAP CER SAFE 330PF 4KV M 3.5MMSHARP ROHS

C804

C841

C912

C913

30070056

CAP EL 68UF 450V M 105°400mA 25x21 ROHS

C812

40037051

PROTECT SHEET SAFE PVC.YP(35x15x0.56ROHS

TR801

30000452

RES CF 1/4W 10R J ROHS

R859

30000471

RES CF 1/4W 10K J.

R844

30000477

RES CF 1/4W 100K J ROHS

R100

R104

30000536

RES CF 1/4W 150K J ROHS

R137

30000723

RES CF 1/4W 47K J

R873

30000810

RES CF 1/4W 820R J ROHS

R120

R122

R123

R124

R854

30000843

RES MF 1/4W 10R J ROHS

R857

30001318

DIODE BA159 1A/800V 20A

D805

D807

30001319

DIODE RL207 2A/1000V 70A DO-15 ROHS

D800

D801

D802

D803

30001350

DIODE ZEN 12V 0.5W SOD27 ROHS

D806

30007200

RES MF 1/4W 10K F ROHS

R840

30066355

RES MG SAFE 1/2W 4.7M J NEW ROHS

R850

30008875

CAP MKT 100NF 63V J 5BOX RoHS

C816

30028356

FUSE SAFE 3.15A 250V (RADIAL) ROHS

F800

30044218

CAP EL 33UF 50V M 105 ROHS

C807

30062860

CAP CER 100PF 1KV J 125° ROHS

C852

30000189

CAP SMD 100PF 50V J COG (0805) ROHS

C108

30000289

CAP SMD 10NF 50V K X7R (0805) ROHS

C836

30000294

CAP SMD 100NF 50V K X7R (0805) ROHS

C103

C104

C107

C126

C131

30000332

CAP SMD 4.7NF 50V K X7R (0805) ROHS

C835

30000464

RES SMD 1/10W 100R J 0805 ROHS

R847

R871

30000475

RES SMD 1/10W 10K J 0805 ROHS

R103

R108

R110

R115

R117

R820

R828

R829

R833

R834

R838

30000480

RES SMD 1/10W 100K J 0805 ROHS

R858

30000567

RES SMD 1/10W 18K J 0805 ROHS

R127

R131

30000593

RES SMD 1/10W 2.2K J 0805 ROHS

R856

Pozition

Page 86

30000664

RES SMD 1/10W 3.3K J 0805 ROHS

R874

30000696

RES SMD 1/10W 39K J 0805 RoHS

R114

30000727

RES SMD 1/10W 47K J 0805 ROHS

R102

R106

30001457

TR NBJT BC848B 0.1A/30V SOT23 ROHS

Q100

Q104

Q800

Q802

Q806

Q871

30001458

TR BC858B SMD

Q102

Q103

Q105

Q106

Q803

30001734

RES SMD 1/10W 0R 0805 ROHS

J814

J827

J830

J832

J834

R125

R126

S810

S809

30001735

RES SMD 1/8W 0R 1206 ROHS

F101

30007021

RES SMD 1/10W 1K F 0805 ROHS

R129

R130

R133

R134

R823

R843

30007028

RES SMD 1/10W 82K F 0805 ROHS

R128

R132

R855

30007030

RES SMD 1/4W 1R J (1206) ROHS

R802

R899

30007169

DIODE DUALBAV99 0.215A/70V 4.5ASOT23ROHS

D127

D132

30008996

IC VREF TL431SAMF2 ADJ %1 SOT23 ROHS

D809

30010560

CAP SMD 220NF 25V K X7R (0805) ROHS

C110

30010566

CAP SMD 39NF 50V M X7R (0805) ROHS

C808

30013199

RES SMD 1/10W 2.4K F 0805 ROHS

R825

30014615

RES SMD 1/10W 240K J 0805 RoHS

R109

30015227

RES SMD 1/10W 1.2K F 0805 RoHS

R824

30019087

FERRIT SMD 60R/100MHz 0.025 M 3A 0805Roh

L880

30024632

TR NBJT PDTC144 0.1A/50V INTRES SOT323Ro

Q810

30030499

RES SMD 1/8W 100K F 0805 ROHS

R105

30033743

TR NMOS NTGS3446 5.1A/20V TSOP6 RoHS

IC871

30038480

DIODE SMD ZEN C5.6V SOD123 ROHS

D823

30038495

DIODE SMD ZEN C22V SOD123 ROHS

D804

30038507

DIODE SMD 1N4148 0.15A/100V SOD123 RoHS

D111

D113

D128

D133

D818

D825

30039196

RES SMD 1/4W 1M F 1206 ROHS

R800

R801

R803

R804

R809

R810

30047967

TR NPMOS FDS8962C 7-5A/30V SO8 ROHS

IC102

IC104

30050542

RES SMD 1/8W 270K F 0805 RoHS

R118

R113

30050543

RES SMD 1/8W 36K F 0805 RoHS

R116

30050633

TR PBJT PDTA124 -0.1A/-50V INTRESSOT323R

Q809

30059259

CAP SMD 2.2UF 25V K X7R (0805) ROHS

C840

30061026

CAP SMD 1UF 25V K X7R (0805) ROHS

C102

C109

C112

C143

C803

C824

C827

30061416

IC CCFL TL494 SOIC16 ROHS

IC100

30065572

CAP SMD 10UF 25V K X7R (1206) ROHS

C117

C118

C119

C121

C123

30068432

CAP SMD 1NF 1KV K X7R (1206) IPS ROHS

C809

C810

C811

C813

R875

Page 87

Part Code

Description

20531132

MD.ASY.17LD98-7-19-22880 (MB25(SHARP)

30047579

IC PREAMP TSOP58236 36kHz 5V ROHS

MD1

30064217

CNAS 5P/200 FLT W/C UL2468AWG26 ROHS

PL2

30064838

LED WHITE 3MM VWL-30933 RoHS

30000294

CAP SMD 100NF 50V K X7R (0805) ROHS

C4C5C6

30000464

RES SMD 1/10W 100R J 0805 ROHS

30006462

RES SMD 1/10W 22R J 0805 ROHS

30010555

CAP SMD 1UF 16V K X7R (0805) ROHS

C1C2C3

Pozition

Page 88

20542346

SPK.AS.19820/2/850(R/L(MB60-6P)B(WO/C(SH

35008081

SCREW P C ZN YFMB 3*9.5 R7 RoHS

20455877

SPEAKER 31x94 4R 5W ROHS(pha

40045322

BRACKET SPEAKER 31x94 (I) V0_SHARP

30067431

CNAS 6P/400+120 SPK SISW/C UL1007AWG24Ro

20529682

FOOT ASSY 19900W (GLOSSY-BL-PMMA)SHARP

20529681

COVER FOOT 19900 (GLOSSY-PC-ABS(I)V0_SH

40044341

FOOT RUBBER (PAH)(1STEP)

20533190

ARTWORK SHARP LC-22D12E

50177070

I/B SHARP LC-22D12E MB60/3902/E

20527505

R/C 3902 SHARP&3902 (GRAY/S)(BLACK/P)

20500048

CAB.AS.FAV+YPBPR SLIM LED(MB60)

30063603

BATTERY AAA ALKALINE R03 2006/66/EC ROHS

50177107

PAP.I/B QSG SHARP SHARP LC-22D12E

50165205

WARR.CARD SHARP "Aquos care plan"

50165208

WARR.CARD SHARP "Guarantee regisration"

50165209

WARR.CARD SHARP "Aguos regisration card"

20521139

ROC.SW.AS.(MB60_SHARP)

30069580

SWITCH ROCKER SAFE6A/250VAC SPSTSHARPROH

30066042

CNAS SAFE 2P(V0)/200(VDE) W/BLK C ROHS

40001898

MACARON (12cm.Isı ile daralan)

Page 89

LC22LE22E PART LIST ( CMO PANEL )

No Part Code Description Detail Description

1 20545638 CHS.ASSY.17MB60-C1K1231H122222115M1 Main Board 2 20533562 FRONT 22906-LED(H:4(BCBL/P-V)SHARP/S Front Plastic 3 20535298 BC.AS.22905-LE MB60&GR(WO/220&R(I(SHARP Back Cvr 4 20533592 FOOT ASSY 19740W (GLOSSY-BL-PMMA)WO/S(SH Foot Assy 5 20531132 MD.ASY.17LD98-7-19-22880 (MB25(SHARP) Led Board 6 20535361 MD.ASY.17IPS60-22"(CHM-FHD-LA1(SH Inverter+Power Supply 7 40045074 LENS COSM.LCD19-22906(AKR)DARK FUME HST 8 40043809 LENS PREAMFI D5X7.5 TFT-LCD15 MILK. 9 20519648 CN.A.FFC 12P/500(22915Led Backlight MB60 cable 10 20514254 CN.A.FFC 30P/300 P=1MM LVDS(22"MB60 LVSD 11 40045476 COVER GROMET 30x30 (I(V0(SHARP Power Plastic Cover 12 30069151 TFT LCD 21.5"FHD LEDCMO V215H1-LE1(CN)RH Panel 13 20542443 SPK.AS.19-22915-LED(R/L)(MB60-6P)(BL(SHA Speaker Assy 14 30064217 CNAS 5P/200 FLT W/C UL2468AWG26 ROHS Led Board cable 15 20506941 POWER CORD AS.GR-(180-7(UK)FL WO/STR 16 50168123 LABEL BR.MB60 VER.3 17 35027246 FR_22_LED_32_MB60_IPS60_CMO_LA1 Metal Frame 18 40046376 BRACKET IO MB60S VER1(I(ABSV0(SH 19 50167221 LABEL BRACKET IO SIDE FUNCTION 20 35027715 SCREW P C ZN YSMB 4*12 (znSY) RoHS Back Cover Screw 21 40046402 ISOLATION_PLATE_LED_19_22_S 22 35026001 SCREW M 3*6 YFMBT TAPTITE (ROHS) Main Board&Inv.+Power Supply Screw 23 50145606 PLASTIZOTE BAG (680mm*680mm)19"-22" TFT 24 20501660 SNOW BOX ASSY(T/B)22905 16/9 LED 25 20535091 ARTWORK SHARP LC-22LE22E 26 50177509 CARTON BOX SHARP LC-22LE22E

Page 90

Page 91

Page 92

Page 93

Page 94

Page 95

Page 96

Part Code

Description

QTY

20545638

CHS.ASSY.17MB60-C1K1231H122222115M1

30000588

RES SMD 1/10W 220R J 0805 ROHS

R124

30001457

TR NBJT BC848B 0.1A/30V SOT23 ROHS

Q119

Q170

Q171

Q178

Q181

Q185

Q188

Q189

Q190

Q191

Q194

Q204

Q205

Q207

Q208

Q186

30001458

TR BC858B SMD

Q146

Q173

Q174

Q180

Q193

Q195

30007800

TR NBJT BF799 0.35A/30V RF SOT23 RoHS

Q144

30010594

CAP ELCH 100UF 16V M 86mA 6.3x5.4 ROHS

C1168

C1169

30010733

TR NMOS 2N7002 0.1A/60V SOT23 ROHS

Q192

Q210

30012411

DIODE SMD BA782 0.1A 35V SOD123 ROHS

D145

30015406

CAP ELCH 22UF 16V M 30mA 4x5.4 ROHS

C1031

30016659

COIL SMD 1uH 50mA K 0R4 805 Ro

L114

30018060

TR PMOS FDC642P -4A/-20V SSOT6 ROHS

Q199

30019087

FERRIT SMD 60R/100MHz 0.025 M 3A 0805Roh

F181

F187

F270

F271

F272

F274

F275

F277

F291

F296

F297

F298

F299

F300

F303

30019996

DIODE BAV70 215mA/75V 4A SOT23 RoHS

D169

30020142

CAP SMD 1UF 25V Z Y5V (0805) RoHS

C1128

30020394

FERRIT SMD 330/100MHz 0.1R M 1.5A 805Ro

F179

F261

F266

F268

30020530

FERRIT SMD 600R/100MHz 0.5R M 0.2A 603Ro

F200

F201

F205

F206

F248

F259

F301

30021958

RES SMD 1/16W 47K J 0402 RoHS

R1201

R1862

R1863

30021960

RES SMD 1/16W 47R J 0402 ROHS

R1249

R1725

R793

30021977

RES SMD 1/16W 1.2K J 0402 RoHS

R483

R1957

R1662

R344

30021987

RES SMD 1/16W 4.7K J 0402 RoHS

R1149

R1158

R1165

R1166

R1171

R1172

R1177

R1182

R1183

R1524

R1527

R1529

R1601

R1614

R1615

R1617

R1618

R1660

R1661

R1663

R1671

R1672

R1678

R1748

R1896

R252

R809

R1198

R1951

R1952

R1953

R1959

R1357

R1358

30021989

RES SMD 1/16W 100K J 0402 ROHS

R1932

R1933

R1934

R209

R884

R1769

R1718

R1701

30021990

RES SMD 1/16W 4.7R J 0402 ROHS

R844

R845

30021991

RES SMD 1/16W 100R J 0402 ROHS

R1243

R1244

R1245

R1248

R1543

R1546

R1549

R1550

R1551

R1552

R1666

R1720

R1721

R1897

R1900

R1946

R1947

R1948

R1949

R222

R223

R221

R620

R1954

R6R7R8

R1679

R1677

30021996

RES SMD 1/16W 10K J 0402 ROHS

R1265

R1310

R1311

R1562

R1563

R1567

R1568

R1632

R1635

R1636

R1638

R1639

R1642

R1667

R1684

R1685

R1691

R1693

R1854

R1855

R1901

R1902

R1591

R1592

R1596

R1597

R1833

R1835

R1836

R1838

R1840

R1939

R1309

R1702

R1593

R1950

30021999

RES SMD 1/16W 10R J 0402 RoHS

R1870

R1871

R1872

R1873

R1874

R1875

R1876

R1881

R1882

R1883

R1884

R384

30022003

RES SMD 1/16W 470R J 0402 ROHS

R1423

R1505

30022024

RES SMD 1/16W 12K J 0402 ROHS

R1589

R1920

R1921

30022026

RES SMD 1/16W 150K J 0402 RoHS

R1770

30022040

RES SMD 1/16W 18K J 0402 RoHS

R1606

30022041

RES SMD 1/16W 1K F 0402 ROHS

R1356

R1365

R1768

R1955

R1941

30022042

RES SMD 1/16W 1K J 0402 RoHS

R1221

R138

R139

R1582

R1668

R1909

R1912

R1676

30022043

RES SMD 1/16W 1M J 0402 ROHS

R1533

30022051

RES SMD 1/16W 2.7K J 0402 ROHS

R1206

R1209

R231

30022053

RES SMD 1/16W 20K F 0402 ROHS

R1738

30022054

RES SMD 1/16W 20K J 0402 ROHS

R1928

R1929

30022055

RES SMD 1/16W 220K J 0402 ROHS

R1898

R1899

R1915

R1916

30022056

RES SMD 1/16W 220R J 0402 RoHS

R1233

R1569

R1570

R1571

R1572

Pozition

Page 97

R1858

R1859

R1958

30022057

RES SMD 1/16W 22K J 0402 RoHS

R1187

R1750

R594

30022068

RES SMD 1/16W 6.8K F 0402 ROHS

R473

R474

R1598

30022078

RES SMD 1/16W 3.9K J 0402 RoHS

R1495

R1496

R1710

30022083

RES SMD 1/16W 330R J 0402 ROHS

R1956

30022084

RES SMD 1/16W 33K J 0402 RoHS

R1605

R1727

R1913

R1914

R104

30022085

RES SMD 1/16W 33R J 0402 RoHS

R1173

R1401

R1402

R1424

R1425

R1426

R1427

R1512

R1513

R1514

R1942

S25

30022088

RES SMD 1/16W 680R F 0402 ROHS

R735

R1960

R1704

30022098

RES SMD 1/16W 390R J 0402 RoHS

R102

30022099

RES SMD 1/16W 39K J 0402 ROHS

R1686

30022112

RES SMD 1/16W 68K J 0402 RoHS

R103

30022118

RES SMD 1/16W 75R J 0402 RoHS

R1479

R1480

R1481

R1482

R1483

R1489

R1515

R1516

R1517

R1587

30022122

RES SMD 1/16W 82K J 0402 ROHS

R1926

R1927

30022132

RES SMD 1/16W 0R 0402 ROHS

R1580

R1857

S16

S49

S83

R1408

R1409

R1416

R1417

R1418

R1419

R1420

R1421

R1422

R1507

R1509

R1510

R1530

R1940

30022140

RES SMD 1/16W 22K F (0402) RoHS

R1924

R1925

R1736

30022165

CAP SMD 3.3PF 50V J COG (0402) RoHS

C968

30022167

CAP SMD 4.7PF 50V J COG (402) ROHS

C967

30022196

CAP SMD 470PF 50V J X7R (0402) ROHS

C1187

C1188

30022237

CAP SMD 27PF 50V J COG (0402) ROHS

C825

C826

C827

C949

30022238

CAP SMD 33PF 50V J COG (0402) ROHS

C951

C952

30022240

CAP SMD 47PF 50V J COG (0402) ROHS

C1205

C1206

C545

C860

R1961

R1962

30022244

CAP SMD 100PF 50V J COG (0402) ROHS

C1185

C1186

30022246

CAP SMD 150PF 50V J COG (0402) ROHS

C964

30022248

CAP SMD 220PF 50V J COG (0402) RoHS

C831

C832

C833

C835

C836

C838

C839

C840

30022336

CAP SMD 3.3NF 50V J X7R (0402) ROHS

C853

C854

30022338

CAP SMD 4.7NF 50V J X7R (0402) RoHS

C857

C858

C1183

C1184

30022339

CAP SMD 5.6NF 50V J X7R (0402) ROHS

C1131

30022342

CAP SMD 10NF 16V J X7R (0402) ROHS

C1113

C1172

C546

C547

C729

30022351

CAP SMD 47NF 16V J X5R (0402) ROHS

C796

C798

C806

C810

C882

C884

C959

C794

30024769

CAP ELCH 47UF 16V M 52mA 5x5.4 ROHS

C143

30024778

FERRIT SMD 60R/100MHz 0.1R M 0.5A 603Ro

F295

30025158

COIL SMD 4.7uH 0.14A M 0R4 805 Ro

L119

L120

30029775

TR NMOS BSN20 0.17A/50V SOT23 ROHS

Q140

30030097

CAP SMD 100NF 10V K X5R (0402) RoHS

C1015

C1035

C1042

C135

C14

C630

C653

C654

C656

C657

C658

C663

C664

C901

C902

C903

C904

C907

C910

C971

C905

C906

30030099

CAP SMD 1NF 50V K X7R (0402) ROHS

C861

C862

C942

C943

C944

C945

30038478

DIODE SMD ZEN C15V SOD123 ROHS

D178

30038479

DIODE SMD ZEN C3V6 SOD123 ROHS

2D2D7

30038480

DIODE SMD ZEN C5.6V SOD123 ROHS

D203

30038502

DIODE SMD ZEN B5.1V SOD123 ROHS

D204

30038507

DIODE SMD 1N4148 0.15A/100V SOD123 RoHS

D189

D191

30038984

RES NET 1/32W 100R J 8P 0402 ROHS

R1588

R1761

R1379

30042066

DIODE SMDSCH1N5819 1A/40V/25A SOD123ROHS

D165

30042505

RES NET 1/32W 33R J 8P 0402 ROHS

R1382

R1383

R1384

R1385

R1388

R1389

R1390

R1392

R1393

R1394

R1395

R1396

R1397

R1398

R1399

30044848

CAP SMD 100NF 16V K X7R (0402) ROHS

C1001

C1004

C1174

C1016

C1034

C1213

C912

C913

30046140

CAP SMD 10UF 6.3V M X5R (0805) ROHS

C1028

C1029

C1030

C1081

30047296

CAP SMD 22UF 6.3V M X5R (0805) ROHS

C868

C970

30048473

DIODE DUALSMD BAW56 4A/75V/4A SOT23ROHS

D185

D186

D184

30050554

CAP SMD 1UF 6.3V M X5R (0402) RoHS

C1202

C1203

C974

C1107

30050558

CAP SMD 100NF 16V K X5R (0402) ROHS

C1005

C1007

C1008

C1009

C1014

C1022

C1024

C1025

C1058

C1070

Page 98

C1177

C997

30051167

CAP SMD 220NF 10V X7R K (0402) ROHS

C683

C709

C710

C712

30053657

DIODE ARRAY ESD NUP4004M5 TSOP-5 RoHS

D173

D174

D175

D176

30055201

COIL SMD 2.2uH 15mA J 1R15 603 Ro

L104

30055434

RES SMD 1/16W 62R J 0402 ROHS

R1411

R1415

30057263

XTAL 24MHz 22pF 30ppm 25OhmHC49S SMDROHS

30057644

IC DOPAMP TL062 SO8 RoHS

U178

30058702

COIL SMD 10uH 2.5A M 0R4 7x7(SHL)Ro

L116

L117

30060344

IC LDO LM1117 ADJ/1A DPAK ROHS

U175

U180

U181

30060852

IC ANALOG 2:1SWITCH FSA3157 SC70 ROHS

30061154

CAP SMD 82PF 50V J C0G (0402) MXM ROHS

C1210

30062359

CAP SMD 47NF 16V K X7R (0402) ROHS

C795

C797

C802

C807

C808

C809

C885

30062763

IC STMPS2161 SOT23-5L ROHS

U149

30062776

DIODE ESD AZ1045-04S SOT23-6 ROHS

U145

30063686

CAP ELCH 100UF 16V M 105C 6.3x5.4 ROHS

C1079

C1080

C1214

30064117

CAP SMD 10UF 16V K X5R (0805) RoHS

C120

30064117

CAP SMD 10UF 16V K X5R (0805) RoHS

C1032

30064783

CAP SMD 1UF 6.3V K X6S (0402) ROHS

C1201

30066018

SOCKET HDMI 19P 0.5MM TOP ROHS

CN707

30066876

CAP SMD 4.7UF 10V K X7R (0805) ROHS

C1200

30066926

IC STEP DOWN MP2012 ADJ/1.5A QFN6 RoHS

U176

30067506

JACK HEADPHONE BLACK 3 POLE SIDE ROHS

JK6

30067595

CAP SMD 22UF 16V M X5R (1206) RoHS

C1084

C1085

C1093

C1094

C1098

C1101

C1212

C5C6C7

C782

C990

C1086

C1087

30067872

CAP SMD 10UF 10V M X5R (0805) ROHS

C1197

C1198

30067872

CAP SMD 10UF 10V M X5R (0805) ROHS

C1170

C1171

C1180

C1181

C1182

C378

C610

30067968

CAP SMD 10UF 10V M X7R (0805) ROHS

C1199

30068279

COIL SMD 120nH 0.4A J 0R51 805 Ro

L115

30068280

COIL SMD 150nH 0.15A J 2R8 402 Ro

L124

30068939

IC STEP DOWN RT8283A ADJ/3A SO8 RoHS

U173

30069320

CAP SMD 22UF 6.3V M X7R (1206) RoHS

C1033

30069322

IC NAND 512Mb NAND512BW3D TSOP48 ROHS

U162

30069749

TR NMOS BSH105 1.05A/30V SOT23 ROHS

Q209

30070314

IC FLASH SPI 8Mb MX25L8006E SO8 ROHS

U158

30001457

TR NBJT BC848B 0.1A/30V SOT23 ROHS

Q133

Q160

30019087

FERRIT SMD 60R/100MHz 0.025 M 3A 0805Roh

F294

30021958

RES SMD 1/16W 47K J 0402 RoHS

R1699

30021987

RES SMD 1/16W 4.7K J 0402 RoHS

R613

R614

R623

R624

30021991

RES SMD 1/16W 100R J 0402 ROHS

R817

R818

30030097

CAP SMD 100NF 10V K X5R (0402) RoHS

C665

C666

30051167

CAP SMD 220NF 10V X7R K (0402) ROHS

C602

C608

C612

C617

30065929

CAP ELCH 220UF 10V M 150mA 8x6.5 ROHS

C615

C870

30067953

IC AAMP AZAD2102 1x2.9W WCSP-9 RoHS

U163

U164

30001457

TR NBJT BC848B 0.1A/30V SOT23 ROHS

Q182

Q183

30001734

RES SMD 1/10W 0R 0805 ROHS

4S1S21

S24

30010560

CAP SMD 220NF 25V K X7R (0805) ROHS

C1048

C1049

30018060

TR PMOS FDC642P -4A/-20V SSOT6 ROHS

Q197

Q200

30019087

FERRIT SMD 60R/100MHz 0.025 M 3A 0805Roh

F286

F305

F273

30021960

RES SMD 1/16W 47R J 0402 ROHS

R1723

R1724

30021996

RES SMD 1/16W 10K J 0402 ROHS

R1689

R1692

R1697

R1730

30022014

RES SMD 1/16W 5.6K J 0402 RoHS

R1708

30022068

RES SMD 1/16W 6.8K F 0402 ROHS

30022084

RES SMD 1/16W 33K J 0402 RoHS

R1731

R1732

R1733

30022132

RES SMD 1/16W 0R 0402 ROHS

S95

S86

30022140

RES SMD 1/16W 22K F (0402) RoHS

R1735

30022336

CAP SMD 3.3NF 50V J X7R (0402) ROHS

C1129

30022342

CAP SMD 10NF 16V J X7R (0402) ROHS

C1114

30030097

CAP SMD 100NF 10V K X5R (0402) RoHS

C1036

30057938

COIL SMD 22uH 3.6A M 35R12x12(SHL)Ro

L123

30062423

FUSE SAFE SMD 4A/32VDC UF HMELT 1206RoHS

FS5

30064145

FUSE SAFE SMD 2A/63VDC UF 1206 RoHS

FS4

30067595

CAP SMD 22UF 16V M X5R (1206) RoHS

C1089

C1090

C1096

C1097

30068939

IC STEP DOWN RT8283A ADJ/3A SO8 RoHS

U23

Page 99

30021977

RES SMD 1/16W 1.2K J 0402 RoHS

R1498

30021987

RES SMD 1/16W 4.7K J 0402 RoHS

R1528

30021996

RES SMD 1/16W 10K J 0402 ROHS

R1294

30022051

RES SMD 1/16W 2.7K J 0402 ROHS

R1497

30022060

RES SMD 1/16W 270R J 0402 ROHS

R1499

30022041

RES SMD 1/16W 1K F 0402 ROHS

R1355

R1364

30022058

RES SMD 1/16W 22R J 0402 ROHS

R1313

R1314

R1330

R1331

R1332

R1333

R1335

R1350

R1602

R1603

30041373

RES NET 1/16W 22R J 8P 0402 ROHS

R1366

R1367

R1368

R1369

R1370

R1380

R1609

R1610

R1613

30051167

CAP SMD 220NF 10V X7R K (0402) ROHS

C687

C711

C713

C714

C715

C716

C718

30067874

IC MSD9WB7PX-2 BGA523 RoHS

U157

30069958

IC DDR2 64Mx16 K4T1G164QF-BCF7 BGA84 ROH

U155

20492263

MB.SMD.17MB60-W/SAV

30020530

FERRIT SMD 600R/100MHz 0.5R M 0.2A 603Ro

F202

F203

30021996

RES SMD 1/16W 10K J 0402 ROHS

R1903

R1904

30022024

RES SMD 1/16W 12K J 0402 ROHS

R1918

R1919

30022118

RES SMD 1/16W 75R J 0402 RoHS

R1486

30022196

CAP SMD 470PF 50V J X7R (0402) ROHS

C1189

C1190

30022248

CAP SMD 220PF 50V J COG (0402) RoHS

C830

30022336

CAP SMD 3.3NF 50V J X7R (0402) ROHS

C855

C856

30038480

DIODE SMD ZEN C5.6V SOD123 ROHS

D171

30055434

RES SMD 1/16W 62R J 0402 ROHS

R1412

30062359

CAP SMD 47NF 16V K X7R (0402) ROHS

C799

30067872

CAP SMD 10UF 10V M X5R (0805) ROHS

C1195

C1196

30067216

JACK HEADPHONE YELLOW 3 POLE SIDE ROHS

JK3

30022132

RES SMD 1/16W 0R 0402 ROHS

S93

30001457

TR NBJT BC848B 0.1A/30V SOT23 ROHS

Q202

30021987

RES SMD 1/16W 4.7K J 0402 RoHS

R1889

R1890

30021991

RES SMD 1/16W 100R J 0402 ROHS

R1907

30022042

RES SMD 1/16W 1K J 0402 RoHS

R1908

30030097

CAP SMD 100NF 10V K X5R (0402) RoHS

C1175

C1176

30063648

FERRIT SMD 120/100MHz 0.09R M1.3A 0402Ro

S92

30022003

RES SMD 1/16W 470R J 0402 ROHS

R1494

30022118

RES SMD 1/16W 75R J 0402 RoHS

R1619

R1620

R1621

30022132

RES SMD 1/16W 0R 0402 ROHS

R1405

R1406

R1407

R1506

R1508

R1511

30022237

CAP SMD 27PF 50V J COG (0402) ROHS

C823

C828

C829

30022351

CAP SMD 47NF 16V J X5R (0402) ROHS

C803

C883

30030099

CAP SMD 1NF 50V K X7R (0402) ROHS

C859

30053657

DIODE ARRAY ESD NUP4004M5 TSOP-5 RoHS

D177

30062359

CAP SMD 47NF 16V K X7R (0402) ROHS

C804

C805

C881

C886

30067217

JACK HEADPHONE GREEN 3 POLE SIDE ROHS

JK2

30019087

FERRIT SMD 60R/100MHz 0.025 M 3A 0805Roh

F288

F289

30022057

RES SMD 1/16W 22K J 0402 RoHS

R1749

30022084

RES SMD 1/16W 33K J 0402 RoHS

R1734

30060746

CONN FFC 30P 1MM TOP LVDS ROHS

CN139

30022132

RES SMD 1/16W 0R 0402 ROHS

R1547

R1548

30001692

FILTER SAW OFWK3953MROHS

Z102

30012545

FILTER SAW K9656M ROHS

Z101

30044670

SOCKET USB SIDE RoHS

CN128

30059740

SOCKET D-SUB 15P TOP 11.9MM RoHS

CN132

30063090

CONN HEADER 5P 2.0MM SIDE W/LOCK RoHS

CN703

30067876

SOCKET PCMCIA S.DECK 4mm HEADERonly RoHS

CN141

30066827

CONN FEMALE HEADER 2x10P 2.54 SIDE ROHS

CN706

30066601

SWITCH TACT LONG SIDE 10V 0.5A RoHS

SW1

SW2

SW3

SW4

30067985

CONN SCART 21P WO/SCREW ROHS

SC1

30066835

JACK RCA 1P BLACK TOP RoHS

JK10

30069671

TUNER DIG. HALF-NIM DTOS403LH122E RoHS

TU102

30066919

CONN HEADER 6P 2.0MM SIDE W/LOCK RoHS

CN710

Page 100

Part Code

Description

6 20535361 MD.ASY.17IPS60-22"(CHM-FHD-LA1(SH

30010603

CAP CER 47PF 2KV K Y5P ROHS

C734

30018085

CAP VAR SAFE 510V K MFCN14D511 ROHS

30028356

FUSE SAFE 3.15A 250V (RADIAL) ROHS

F700

30066237

CAP MKP 4.7NF 630Vdc/622Vpp K 7.5BOXROHS

C713

30066355

RES MG SAFE 1/2W 4.7M J NEW ROHS

R734

30066828

CONN PINHEADER2x10P2.54W/PLASTICSIDEROHS

PL3

30067693

CONN HEADER SAFE 2P V0 7.92MM SIDE ROHS

PL701

30067726

IC SMPS ICE3BR1765J 65KHz DIP8 ROHS

IC700

30067881

LINE FILTER SAFE 2*28mH 1A 0R19 10mm Ro

L700

30067936

TRF SMT SAFE 17IPS60 EFD33.7 10mm ROHS

TR700

30067937

Choke Coil 1uH 5A Axial M 0.7R 10x5.5 Ro

L702

30067959

CAP EL 1000UF 16V M 105C 8x20LEFTBENDROH

C1026

C722

C728

30067960

CAP EL 27UF 400V M 105C 8x50LEFTBENDROH

C729

C730

30067963

RES THE SAFE 10R/2.3A NTC 7mm RoHS

TH1

30068093

CAP MKT SAFE 56NF 275V K X2 AC10BOX ROHS

C1023

30068234

CAP MKP SAFE 100NF 275V M X2AC15BOX ROHS

C731

C703

30069938

CAP CER SAFE 1NF 4KV M 3.5MMSHARP ROHS

C700

C705

C725

C701

C706

40045273

SPACER SUPPORT DCBS-12 ROHS V0

PG1

30001734

RES SMD 1/10W 0R 0805 ROHS

S914

30022132

RES SMD 1/16W 0R 0402 ROHS

R828

30030097

CAP SMD 100NF 10V K X5R (0402) RoHS

C858

30001735

RES SMD 1/8W 0R 1206 ROHS

R711

R713

30001734

RES SMD 1/10W 0R 0805 ROHS

S930

30055933

RES SMD 1/16W 30K F 0402 ROHS

R16

R17

30001734

RES SMD 1/10W 0R 0805 ROHS

30022132

RES SMD 1/16W 0R 0402 ROHS

S100

S101

S102

S103

S104

S105

S106

S107

S108

S109

30047679

CONN SMD FPC 12P 0.5MM TOP ROHS

PL9

30010555

CAP SMD 1UF 16V K X7R (0805) ROHS

C11

30020394

FERRIT SMD 330/100MHz 0.1R M 1.5A 805Ro

L808

30021958

RES SMD 1/16W 47K J 0402 RoHS

30022046

RES SMD 1/16W 2.2K J 0402 RoHS

R940

R941

30022052

RES SMD 1/16W 200R J 0402 RoHS

S17

30022068

RES SMD 1/16W 6.8K F 0402 ROHS

30022132

RES SMD 1/16W 0R 0402 ROHS

S16

S30

30022200

CAP SMD 1NF 50V J X7R (0402) ROHS

C13

30023096

COIL SMD 10uH 4.3A M 0R3 10x10(SHL)Ro

30044848

CAP SMD 100NF 16V K X7R (0402) ROHS

30049062

RES SMD 1/16W 100K F 0402 RoHS

30049510

FUSE SAFE SMD 3A 32V DC (1206) ROHS

L906

30063686

CAP ELCH 100UF 16V M 105C 6.3x5.4 ROHS

30065633

RES SMD 1/16W 270K F 0402 RoHS

30066104

IC LED DRIVER MP3388 8CH 50V QFN24 RoHS

IC1

30066199

DIODE SCH SS16 1A/60V SMD DO214AC ROHS

30067872

CAP SMD 10UF 10V M X5R (0805) ROHS

C12

30068742

CAP SMD 1UF 50V K X7R (1206) ROHS

C17

C18

C19

30001734

RES SMD 1/10W 0R 0805 ROHS

L905

30010555

CAP SMD 1UF 16V K X7R (0805) ROHS

C23

C29

30020394

FERRIT SMD 330/100MHz 0.1R M 1.5A 805Ro

L811

30021958

RES SMD 1/16W 47K J 0402 RoHS

R11

R15

30022052

RES SMD 1/16W 200R J 0402 RoHS

S21

30022068

RES SMD 1/16W 6.8K F 0402 ROHS

R12

Pozition