Sevylor HUI 100 User Manual

®

I NFLATABLE BOATS

Including the following Model Series:

Fish Hunter™, Super Caravelle, Caravelle,

Colossus™ and HUI

INFLATABLE BOATS

®

INSTRUCTIONS AND WARNINGS TO AVOID

READ THE FOLLOWING

DROWNING OR SERIOUS INJURY

WARNING:

• Not a life saving device.

• Not for use by children without adult supervision.

• Always wear an approved Personal Flotation Device
(Life Preserver).

• Do not overload.

• Never tow from another boat or vehicle.

• Use only in water away from debris and obstructions.

• Do not use in high wind, strong currents, open water or
dangerous tides.

• Be familiar with the area you intend to use the boat.

• Never allow diving into or from these boats.

• Never leave in or near water when not in use.

• Know and follow local water safety rules and boating
regulations.

• Use only in protected waters.

• Do not use this product under the influence of alcohol
or drugs.

• Do not over inflate.

• Follow inflation sequence on the product.

IMPORTANT INFORMATION

The warnings below relate to various situations. Please observe them.

CAUTION!

Denotes a imminent hazard which will result in severe injury if you
do not comply with the instructions.

WARNING!

Reminds you of safety measures which must be observed. Also
denotes unsafe practices which could result in personal injury or

INFLATABLE BOATS

®

damage to the product or property, if you do not comply with the
instructions.

CAUTION!

It is the owner's responsibility to make sure all users carefully
read and follow the instructions for safe operation of this
product. Observe all local and national laws. Always wear a
Personal Flotation Device approved by the proper authorities.
Please carefully observe the Capacity Plate information which
is printed on the product.

WARNING!

These boats are not meant for towing because the extreme
pressure of the water while towing can tear the eyelets and/or
handles. These boats are not meant to be used in whitewater.

These boats are made of the highest quality materials and comply
with NMMA (National Marine Manufacturers Association) regulations.

CAUTION!

Altering the construction of these boats could jeopardize the safety
of the occupants and will void the limited warranty.

CAUTION!

Keep boat away from gasoline, battery acid, solvents, etc., as they
can damage the boat.

2

INFLATION INSTRUCTIONS

CAUTION!

Do not over inate. Pressurize product to "Ination Pressure"
stated in the chart for your specic product.

WARNING!

Never use a compressor, CO2 or compressed air to inate the boat.
Do not let your boat come into contact with sharp, pointed objects.

INFLATABLE BOATS

®

To inate using any Sevylor® QuickPump™ unit:

To begin inflation,
open external
stopper and pull to
extend out.

Attach adapter hose
to inflation end of
QuickPump™ unit.
Insert hose and
turn on.

When fully inflated,
seal valve by
pushing in the pump
nozzle to maintain
seal. Gently back
pump out of valve.

To inate using the Sevylor
ination device:

To begin inflation,
open external
stopper and pull to
extend out.

To close valve:
Push in with
inflation device until
stopper has been
depressed, sealing
internal stopper.

Fully remove adapter
and close external
stopper. Valve should
appear depressed
into itself.

®

Dual Action Hand Pump or other

Insert nozzle of
inflation device into
the extended valve
and turn on or begin
pumping.

Fully remove adapter
and close external
stopper.

Valve should appear
depressed into itself.

3

IMPORTANT! Inate the boat chambers in the following order:

1. Inate the inside all-around safety chamber.

2. Inate the oor chamber(s).

3. Inate the bottom tunnel chambers. (These tubular chambers are
only found on Super Caravelle and Fish Hunter™ models.)

4. Inate the bustle chamber. (This support chamber positioned at
the stern is found only on the large Super Caravelle models.)

5. Inate the outside main chamber.

The chambers on the boat will be numbered to indicate order of
ination also. This order of ination will ensure the proper volume and

INFLATABLE BOATS

buoyancy of the safety chamber.

®

Note: To inate the mini double lock valve, which is used on some of
the Sevylor boat oors and seat bottoms, follow the same ination
instructions above, using the mini double lock valve adapter. The mini
Double Lock™ valve adapter is included with all Sevylor

®

adapter can be purchased from Customer Service by calling 1-800­835-3278 (Part Number 5010000707).

CAUTION!

Water temperature and weather does affect the pressure in
inatable products. In cold weather your product will lose some
pressure due to the fact the air will contract. If this occurs, you
may want to add a little air to improve your products performance.
However, in hot weather, the air will expand. You must let some air
out to prevent your product from failing due to overpressure. You
should avoid exposing your product to extreme temperatures (hot
or cold).

pumps. The

DEFLATION INSTRUCTIONS

Deation instructions using
any

Sevylor

unit:

Remove adapter hose from inflation end and attach to opposite deflation

end of pump. Repeat same steps as inflation. This will draw the air out

quickly.

4

®

QuickPump™

Deation instructions using
the Sevylor® Dual Action

Hand Pump:

Remove adapter hose from inflation port and attach to deflation port

on pump handle. Repeat same steps as inflation. This will draw the air

out quickly.

Your boat is NMMA certied using the ABYC standard.

WARNING!

Do not exceed the certied maximum capacities under any circumstances!

®

INFLATABLE BOATS

NMMA (ABYC

Standard)

Model # Persons Only

HUI 100

HUI 200

HUI 400

Persons

Capacity

1 Pers. or 190

lbs.

2 Pers. or 370

lbs.

4 Pers. or 650

lbs.

Maximum Pay-

load Capacity

Persons, Gear,

Motor

(if applicable)

190 lbs. N/A 0.4 PSI 0.4 PSI

370 lbs. N/A 0.4 PSI 0.4 PSI

650 lbs. N/A 0.4 PSI 0.4 PSI

Engine

Max. HP Engine

Inflation

Pressure

Main

Chamber(s)

WARNING!

Do not exceed the certied maximum capacities under any circumstances!

NMMA (ABYC

Standard)

Model # Persons Only

Colossus™

2 Person Boat

Colossus™

3 Person Boat

Colossus™

4 Person Boat

Persons

Capacity

2 Pers. or

435 lbs.

3 Pers. or

680 lbs.

4 Pers. or

840 lbs.

Maximum Pay-

load Capacity

Persons, Gear,

Motor

(if applicable)

435 lbs. N/A 0.5 PSI 0.5 PSI

680 lbs. N/A 0.5 PSI 0.5 PSI

840 lbs. N/A 0.5 PSI 0.5 PSI

Engine

Max. HP Engine

Inflation

Pressure

Main

Chamber(s)

WARNING!

Do not exceed the certied maximum capacities under any circumstances!

Inflation

Pressure

Floor

Chamber(s)

Inflation

Pressure

Floor

Chamber(s)

NMMA (ABYC

Standard)

Model # Persons Only

Caravelle

2 Person Boat

Caravelle

3 Person Boat

Caravelle

4 Person Boat

Caravelle

5 Person Boat

Persons

Capacity

2 Pers. or

300 lbs.

3 Pers. or

550 lbs.

4 Pers. or

600 lbs.

5 Pers. or

800 lbs.

Maximum Pay-

load Capacity

Persons, Gear,

Motor

(if applicable)

360 lbs. N/A 0.9 PSI 0.9 PSI

600 lbs.

700 lbs. 3.0 * 0.9 PSI 0.9 PSI

900 lbs. 3.0 * 0.9 PSI 0.9 PSI

* Requires 2000004146 Motor Mount Kit (sold separately)

for motors other than Sevylor 12 Volt Motor, Model
2000004144

Engine

Max. HP Engine

12V Electric

Motor (Sevylor

2000004144)

Inflation

Pressure

Main

Chamber(s)

0.9 PSI 0.9 PSI

Inflation

Pressure

Floor

Chamber(s)

5

WARNING!

Do not exceed the certied maximum capacities under any circumstances!

®

INFLATABLE BOATS

NMMA (ABYC

Standard)

Model # Persons Only

Fish Hunter™ 3

Person Boat

Fish Hunter™ 4

Person Boat

Fish Hunter™ 6

Person Boat

Fish Master™ 4

Person Boat

Persons

Capacity

3 Pers. or

450 lbs.

4 Pers. or

650 lbs.

6 Pers. or

900 lbs.

4 Pers. or

800 lbs.

Maximum Pay-

load Capacity

Persons, Gear,

Motor

(if applicable)

600 lbs. 2.0 * 0.9 PSI 0.9 PSI

700 lbs. 4.0 * 0.9 PSI 0.9 PSI

1200 lbs. 3.0 * 0.9 PSI 0.9 PSI

900 lbs. 3.0 * 1.5 PSI N / A

* Requires 2000004146 Motor Mount Kit (sold separately)

for motors other than Sevylor 12 Volt Motor, Model
2000004144

Engine

Max. HP Engine

Inflation

Pressure

Main

Chamber(s)

WARNING!

Do not exceed the certied maximum capacities under any circumstances!

NMMA (ABYC

Standard)

Model # Persons Only

Super Caravelle

2 Person Boat

Super Caravelle

3 Person Boat

Super Caravelle

4 Person Boat

Super Caravelle

6 Person Boat

Persons

Capacity

2 Pers. or

300 lbs.

3 Pers. or

550 lbs.

4 Pers. or

600 lbs.

6 Pers. or

900 lbs.

Maximum Pay-

load Capacity

Persons, Gear,

Motor

(if applicable)

360 lbs.

600 lbs. 2.0 * 0.9 PSI 0.9 PSI

700 lbs. 3.5 * 0.9 PSI 0.9 PSI

1,100 lbs. 3.5 * 0.9 PSI 0.9 PSI

* Requires 2000004146 Motor Mount Kit (sold separately)

for motors other than Sevylor 12 Volt Motor, Model
2000004144

Engine

Max. HP Engine

12V Electric

Motor (Sevylor

2000004144)

Inflation

Pressure

Main

Chamber(s)

0.9 PSI 0.9 PSI

Inflation

Pressure

Floor

Chamber(s)

Inflation

Pressure

Floor

Chamber(s)

WARNING!

Do not attempt to mount a motor on any boat that does not state a
Max. HP Engine rating.

6