BOI
R&D Department
Doc Name
Temp Tale Geo Eagle 3G US User Manual Rev.0
Rev
0
Page 1 of 11
Subject
User Manual to external lab TUV
Doc No
Author
Eunice Law
Created
CC
Michael, DY, KK Ma
Status
Initial Release
0
Initial Release
Eunice Law
15-Dec-2017
15th Dec, 2017
VizComm View TempTale
GEO Eagle 3G US
Real Time Tracking Temperature Monitor
User Manual
Rev.0
Rev No
Revision Details
By
Date
** BOI Confidential Proprietary Information **
BOI
R&D Department
Doc Name
Temp Tale Geo Eagle 3G US User Manual Rev.0
Rev
0
Page 2 of 11
Subject
User Manual to external lab TUV
Doc No
Author
Eunice Law
Created
CC
Michael, DY, KK Ma
Status
Initial Release
Food
7 days 15mins 15mins
Frozen Food
7 days 15mins 15mins
26 days 15mins 60mins
15th Dec, 2017
Operating Description
Temp Tale GEO Eagle 3G (US) is real-time tracking device to monitor health of perishable
goods product during transit period inside container truck or sea onboard ocean containers.
The tracking device reports remotely its temperature history and location information in
periodic intervals to a remote server.
The device are consist of temperature sensor, light sensor, status LED’s, 2push button
switches, battery level sensor, non-volatile storage EEPROM memory and 3G modem
module for internet connectivity to transmit data (no voice application required).
The application of cellular data transmission is active only when the device is within land
geographical areas with cellular towers. For ocean container condition, the tracking device
shall set to a timer mode with disabled cellular data transmission and device goes to sleep
mode, while the temperature recording is still active that wakes up in a specific time
intervals to record temperature data w/o cellular data transmission.
It was envisioned that this product will be used in a variety of transport situations, varying
from short parcel delivery trips. The rate at which the devices logs and reports data will
be variable in order to allow usage flexibility of battery and memory consumption to
accommodate different trip durations, but the following use cases were defined in some
transportation scenarios in the table below.
customers
customers
Ocean container
OTR
17 days
26 days
17 days
90 days
** BOI Confidential Proprietary Information **
Temperature Recording
Intervals
15mins 30mins
15mins 60mins
15mins 30mins
60mins 60mins
Tower Reporting
Intervals
Temperature range
- 20 to +85 °C ± 0.5C
- 30 to +85 °C ± 0.5C
- 20 to +85 °C ± 0.5C
BOI
R&D Department
Doc Name
Temp Tale Geo Eagle 3G US User Manual Rev.0
Rev
0
Page 3 of 11
Subject
User Manual to external lab TUV
Doc No
Author
Eunice Law
Created
CC
Michael, DY, KK Ma
Status
Initial Release
Below illustration is an activated real-time tracking device inside a container
truck transporting food stuffs in various domestic areas.
Internet
Cell Tower
TTGeoEagle 3G
** BOI Confidential Proprietary Information **
TCP data
Telecom central office
AT&T or T-Mobile
subscriptions
Location and Temperature data reports
Cell Tower
Sensitech CS Tracks
Server Command Center
15th Dec, 2017
BOI
R&D Department
Doc Name
Temp Tale Geo Eagle 3G US User Manual Rev.0
Rev
0
Page 4 of 11
Subject
User Manual to external lab TUV
Doc No
Author
Eunice Law
Created
CC
Michael, DY, KK Ma
Status
Initial Release
Applicant Information
Applicant Information
Company Name: SENSITECH Inc.
Address: 800 Cumming Center, Beverly MA, USA
Manufacturer Information
Company Name: SENSITECH Inc.
Address: 800 Cumming Center, Beverly MA, USA
Importer Information
15th Dec, 2017
Company Name: XXXXXXXXXXX
Address: XXXXXXXXXXXXXXXXXX
Product General Description
Product Name
VizComm View TempTale Geo Eagle 3G US
Model Name
T11012700
Operating Voltage:
Extreme Low: 4.8V
Typical: 6V
Extreme High: 7.5V
Operating Temperature:
Extreme Low: -30℃
Typical: 25℃
Extreme High: +55℃
** BOI Confidential Proprietary Information **
BOI
R&D Department
Doc Name
Temp Tale Geo Eagle 3G US User Manual Rev.0
Rev
0
Page 5 of 11
Subject
User Manual to external lab TUV
Doc No
Author
Eunice Law
Created
CC
Michael, DY, KK Ma
Status
Initial Release
Frequency of oscillator
Type of Antenna
Modem Module
Antenna frequency
Modem FCC ID
Modem IC
External RTC: 32.768kHz
Internal system clock (On-Chip-Osc) 32MHz
PCB Trace antenna
Quectel UC15-A
Manufacturer P/N: UC15AA-128-NCH-STD
UMTS850
UMTS1900
SRMT11012700
10224A-201410UC15
** BOI Confidential Proprietary Information **
15th Dec, 2017
BOI
R&D Department
Doc Name
Temp Tale Geo Eagle 3G US User Manual Rev.0
Rev
0
Page 6 of 11
Subject
User Manual to external lab TUV
Doc No
Author
Eunice Law
Created
CC
Michael, DY, KK Ma
Status
Initial Release
User Interface
Green LED:
1. Mode status
16 blinks – Un-configured device 8
blinks – Start-up delay Mode
4 blinks – Sleep Mode
2 blinks – Run Mode
1 blink – Stop Mode
2. Self-Test rapid blinking approx. 30s
3. Transmit Busy 5s blinking interval
for less than 2mins.
Status Button:
When pressed will activate
status LED.
** BOI Confidential Proprietary Information **
Light Sensor peephole:
Light status will be checked 30s
sampling interval. Response is
unnoticeable to user.
15th Dec, 2017
Red LED:
Error LED blinks when it comes true into
3 conditions:
1. Low Battery
2. No SIM card
3. Modem failed in self-test
Start/Stop Button:
Starting the device:
1. If device is not started, pressed START
button will activate device immediately
if Start Key option is disabled.
2. If device is not started, pressed hold
START button for 3s will activate device
if Start Key option is enabled.
Stopping the device:
1. If device had been started, pressed
START button will de-activate device
immediately if Stop Key option is enabled.
2. If device had been started, pressed hold
START button for 5s will de-activate device
if Stop Key delay option is enabled.
Sugarloaf Modem Manager
A. Device Identifier (1=Monadnock, 2=Greylock, 3=Sugarloaf)
No
a. Protocol Version
Time to
c. Message Type
d. Message Time stamp
C. Device Message
i.
Firmware Revision
Turn ON and
iii. Hardware ID
initialize modem
v. MSISDN
i.
RSSI value (dBm * -1)
c. Cell Information
Network
No
i.
Cell Info Timestamp
available?
ii.
0 - 6 Cell Sector information. Each sector should have:
1) MCC
3) LAC
Generate
5) Signal (dBm * -1)
protobuf message
i.
0 - TBD battery samples. Each sample should have:
Transmit message
1) Timestamp
iii. 0 - TBD temperature samples. Each sample should have:
2) Value
Protobuf Message Sequence after entering RUN mode:
Yes
1. Check In message
– Should be the first message sent.
No
2. Run Mode Start message
– Should be generated when device is started.
– Timestamp should be the same as start time.
interval
– Should be transmitted at the start of each transmit interval if
4. Stop Mode/End of Trip message
– Should be transmitted after all pending messages have been sent.
End
Start
Transmit?
Each Protobuf message should contain the following:
B. Header
b. Message Number
a. Device Information:
ii. Hardware Revision
iv. ICCID
b. Device Status:
d. Sensor Samples
ii. 0 - TBD light samples. Each sample should have:
2) MNC
4) CID
1) Timestamp
2) Value
2) Value
1) Timestamp
Increment retry count
Max retries?
Succesful Txmit?
Set next transmission
– Should be transmitted immediately after Check In message.
3. Sensor message
temperature sample is available.
– Should be generated when the device stopped because:
Turn OFF modem
– Timestamp should be the same as stop time.
– Should not contain temperature samples.
Reset Retry counter
a. Memory is full,
b. Trip length was met, OR
c. User pressed the STOP button for 3 seconds
BOI
R&D Department
Doc Name
Temp Tale Geo Eagle 3G US User Manual Rev.0
Rev
0
Page 8 of 11
Subject
User Manual to external lab TUV
Doc No
Author
Eunice Law
Created
CC
Michael, DY, KK Ma
Status
Initial Release
UMTS
850MHz
US,NA
869–894MHz
824–849MHz
128–251
UMTS
1900MHz
US,NA
1930–1990MHz
1850–1910MHz
512–810
1.2. Antenna Requirement
Type
Requirements
Frequency Range
VSWR
≤2
Max Input Power
50W
Frequency
Min
UMTS1900
+25dBm
Frequency
Min Receive Sensitivity
UMTS850
<–107dBm
UMTS1900
<–107dBm
RF Specifications
Note: mentioned specifications are in the Quectel’s UC15A 3G module as reference
1.1. Operating Frequencies
Dual-band UMTS operating frequencies 850/1900MHz
Band
Frequencies
Region
Receive
Transmit
ARCHN
UMTS850MHz/UMTS1900MHz
Input Impedance
50Ω
Polarization Vertical
1.3. TRP Requirements
UMTS850 +25dBm
1.4. TIS Requirements
15th Dec, 2017
** BOI Confidential Proprietary Information **
BOI
R&D Department
Doc Name
Temp Tale Geo Eagle 3G US User Manual Rev.0
Rev
0
Page 9 of 11
Subject
User Manual to external lab TUV
Doc No
Author
Eunice Law
Created
CC
Michael, DY, KK Ma
Status
Initial Release
Frequency
Max
Min
1
1.5. Module Conducted RF Power
UMTS850 +24dBm -56dBm
UMTS1900
+24dBm
-56dBm
15th Dec, 2017
** BOI Confidential Proprietary Information **
BOI
R&D Department
Doc Name
Temp Tale Geo Eagle 3G US User Manual Rev.0
Rev
0
Page 10 of 11
Subject
User Manual to external lab TUV
Doc No
Author
Eunice Law
Created
CC
Michael, DY, KK Ma
Status
Initial Release
FCC Warning
FCC Statements:
15th Dec, 2017
This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to Part 15 of
the FCC Rules. These limits are designed to provide reasonable protection against harmful interference in a
residential installation.
This equipment generates, uses and can radiate radio frequency energy. However, there is no guarantee that
interference will not occur in a particular installation. If this equipment does cause harmful interference to radio or
reception, which can be determined by turning the equipment off and on, the user is encouraged to try to correct the
interference by one or more of the following measures:
• Reorient or relocate the receiving antenna.
• Increase the separation between the equipment and receiver.
• Connect the equipment into an outlet on a circuit different from that to which the receiver is connected.
• Consult the dealer or an experienced technician for help.
This device complies with part 15 of the FCC Rules. Operation is subject to the following two conditions:
1) This device may not cause harmful interference, and
2) This device must accept any interference received, including interference that my cause undesired operation.
MODIFICATION: Any changes or modifications not expressly approved by the grantee of this device could void the
user’s authority to operate the device.
IC Statements:
-English:
This device complies with Industry Canada RSS standard(s). Operation is subject to the following two conditions: (1)
this device may not cause interference, and (2) this device must accept any interference, including interference that
may cause undesired operation of the device.
2. Changes or modifications not expressly approved by the party responsible for compliance could void the
user's authority to operate the equipment.
-French:
Leprésent appareil est conforme aux CNR d'Industrie Canada applicable aux appareils radio
Exempts de licence. L'exploitation est autorisée aux deux conditions suivantes :
(1) l'appareil ne doit pas produire de brouillage, et (2) l'utilisateur de l'appareil doit accepter tout brouillage
radioélectrique subi, meme si le brouillage est susceptible d'en compromettre le fonctionnement."
** BOI Confidential Proprietary Information **
BOI
R&D Department
Doc Name
Temp Tale Geo Eagle 3G US User Manual Rev.0
Rev
0
Page 11 of 11
Subject
User Manual to external lab TUV
Doc No
Author
Eunice Law
Created
CC
Michael, DY, KK Ma
Status
Initial Release
2. Safety Warning
2.1. Battery Warning Label
15th Dec, 2017
a) Risk of explosion if battery is replaced by an incorrect type
b) Dispose of used batteries according to the instructions
c) Use only the types of the batteries which are indicated in this manual
2.2. Safety Use Distance
7-10 meters
2.3. Antenna Safety Use Distance
To comply with FCC/IC/CE RF exposure limits for general population / uncontrolled exposure, under normal use
conditions, the antenna(s) used for this transmitter must be installed to provide a separation distance of at least 31 cm
from all persons
** BOI Confidential Proprietary Information **
Loading...