Sears Kenmore 13501 Series, Kenmore 13505 Series, Kenmore 13405 Series Operating Instructions Manual

^

•

.• ".• •• ••. ^^

:

*•>.

*

* • , -. • -t * •.*>•-•*••.*•..•"..** ."

*::\ " - * .'i' • •"•- • • •:

'"•.

• ''.'

* . •. - • * % • »

-"i."- """^•.'•".'•• .'••.•:•*;'••^'",'

• •„•

•.* ••' ,. *.

Table

Safety

... .

Compactor components
How the compactor compacts..
How to operate (he compactor

installing new compactor bag
Compactor Features

Extra Pac Cycle
Automatic Deodorizer System.
Solid

Air
BAG AWAY Bag Caddy
Tiit-Open Drawer
Rear Rollers and Front Leveling Legs

Removable Key-Knob
Step-On-lt Drawer Opener
Color

Panel

Closed Drawer Interlock Switches

How to change front panel color .......

Rules for safe operation
Service Checks
Cleaning and care
Warranty
Maintenance Agreement

of

Contents

..

...

.

Freshener System

Pack

....

,,

....

«.

,

.

•...

...

..

..

2

..

3

.

. 4

...

5

..

6

...

6

7-8-9

.,.

8

...

8

...

8

...

8

...

9

.,

a

.,

9

.

9

..

9

.

.10

...

11

12-13

...

14

...

15

...

15

7

9

•

.• . " • •, ""• • * * - . •" i"

•

mr Kenmore
Compactor are stamped on the plate shown in the
illustration on page 3. Copy the numbers in the
spaces provided for reference.

Operat

*!*.-.

MODEL NO ___
SERIAL NO.
DATE OF PURCHASE/
INSTALLATION DATE

Important Safety Instructions

AWARNING

To reduce the risk of
to persons when using your compactor, follow
basic precautions, including the following.

* Read these instructions for important use and safety

information before ysing your compactor.

• Close supervision of children is necessary when the
compactor is used near children.

• Do not allow compactor to be used as a
unattended at any time. Lock key switch when not in use
and store key out of reach of children.

* Do not touch moving parts.

• Have appliance examined, repaired or adjusted by an
authorized serviceman.

• Do not compact:

lighted

cigarettes,

- any container or aerosal can containing insecticide, hair
spray, paint, engine starting fluid or other poisonous,
toxic, or explosive products.

- Volatile flammable material such as oity rags, thinner,
etc., which would create a fire hazard.

• Do not take apart this appliance. Incorrect reassembly
can cause electric shock when subsequently used.

• Use only for intended use as described in this manual.
Do not use other than manufacturer's recommended
attachments.

• Never lift the bag by the sides. Broken glass or other
sharp objects in the bag can cause injury.

• This compactor is designed for household use only.

» Unplug compactor from electrical outlet before servicing.

• The compactor must be electrically
grounding instructions.

• Do not overload trash bag with heavy material
such as glass.

« Never operate the compactor if:

~ it is not working nght.

- it is damaged.

- parts are missing

- the cord set, plug or motor is damaged in any manner.

* See installation instructions.

fire,

electric shock, or injury

toy,

or to run

cigars or other hot or burning items.

grounded.

See the

AWARNING

Electrical Shock Hazard
Do not modify the power supply plug provided

with the compactor. If it will not fit the outlet, or

if you are in doubt as to whether the wall outlet
is properly grounded, check with a qualified

electrician.

Failure to do so could result in electric shock or
personal injury.

For Your Safety

• Do not handle front panels carelessly when changing,
metal edge could cause injury.

• Do not compact when drawer handle is removed.

• Always wipe off any broken glass before touching the
ram cover.

• Never use or store flammable fluids (dry cleaning
vents,

gasoline, kerosene, etc.) in or near your compac­tor. These substances give off vapors that can create a
fire hazard or explosion.

• Do not install or store compactor where it will be
exposed to the weather.

• Do not shove items down into the compactor with hands
or feet. Let the compactor do the compacting.

• Always place glass bottles, etc., on their sides in the
center of the drawer. The waste paper below and beside
the bottle can help keep broken glass near center of

bag.

• Do not use the compactor as a counter for electrical
cooking appliances nor as a cutting board.

• You are personally responsible for making sure that
your compactor:

- is used only for jobs normally expected of home
compactors.

- is properly installed and leveled on a floor that can
support its weight.

• Do not set hot pans, etc. on the compactor
spill any liquids on the compactor top.

lop.

sol-

Do not

Safety First

Do not permit children to operate or play with compactor

Save These Instructions

EXTRA PAC LIGHT

(13501 and 13505

MODEL SERIES)
EXTRA PAC CYCLE
CONTROL
(13501 and 13505
MODEL SERIES)
DRAWER PULL

"KEY-KNOB

AND LOCK

DEODORIZING LIQUID

(13501 AND 13505

MODEL SERIES)

MODEL AND SERIAL
NUMBER LABEL

REVERSIBLE COLOR
PANEL

(13501

and

13505 MODEL SERIES)
BAG RETAINER^

DRAWER SIDE UTCH

FLEXIBLE

TOE PLATE

STEP-ON DRAWER
OPENER

(13501 and 13505

MODEL SERIES)

13405,13501

MODEL SERIES

UNDERCOUNTER

MOUNTING BRACKETS

KEY-KNOB AND LOCK

CLOSED DRAWER

INTERLOCK SWITCH

MODEL AND SERIAL

NUMBER LABEL

DRAWER PULL

and

CLOSED DRAWER

INTERLOCK SWITCH

BAG-AWAY

BAG CADDY

(13501 and 13505

MODEL SERIES)
LEVELING LEGS

13505

SOLID AIR

FRESHENER

COMPARTMENT

(13405 MODEL SERIES)

ROLLERS

'NOTE:

REVERSIBLE COLOR PANEL

BAG RETAINER

DRAWER SIDE LATCH

LEVELING LEGS

13305
MODEL

SERIES

FLEXIBLE TOE PLATE

The compactor is for use on a 120-volt, 60 Hz, AC only 15 ampere fused and properly grounded
circuit and is equipped with a grounding plug as shown

above.

For your personal safety, the com­pactor must be grounded. In the event of an electrical short circuit, grounding reduces the risk of
electric shock by providing an escape wire for the electric current. This appliance is equipped with
a polarized

3-prong

grounding

plug.

It must be plugged into a correctly polarized mating

3-prong
grounding type outlet, properly installed and grounded in accordance with the National Efectrical
Code and local codes and ordinances. No adapter should be used with this appliance

You can

STOP

YOUR
COMPACTOR
TIME WHILE

AT

THE

ANY

RAM
IS MOVING DOWN
by turning the key-knob
to

REMOVE.

After a
moment, turn the key-knob
briefly

to

START

and

the

ram

will return
nnost position
open

the

POLARIZED
3-PRONG
GROUNDING
TYPE OUTLET

to

i!s top-

so you

drawer.

POWER SUPPLY
CORD

can

How the compactor compacts

Compactor ram
in lowest
position

This trash will
compact later

A ram inside the compactor forces trash
down to about one-fourth its original size
by using pressure The ram does not go
to the bottom of the drawer. Because of
this you will not see compacting the
first few times you run the compactor.

However, this trash will be compacted
later

The container must be at least one-third
full of loose trash before you notice any
compacting.

IMPORTANT:

E>

Glass bottles, jars, and other
glass containers will sometimes
break with a loud noise. This is
normal.

Because other trash
cushions some glass
tainers, all bottles may not

break.

con-

By the time the trash bag is
compacted to about one-fourth of its
original bulk.

full,

trash is

How to operate compactor

%

y

In

1.

Open drawer.

•

13501

and 13505 Model Series

use the STEP-ON drawer opener or the

drawer handle

m

2.

Load trash.

1

»

Load any trash, wet or dry, into the
compactor

»

Spray cans and containers that contain
poisonous or explosive chemicals should not
be loaded in the compactor. (See page 11)

•Wrap really messy trash.
»

Load cans and bottles on their sides in
center of compactor (as illustrated) so drawer
will not pop open If these containers are not
loaded properly, the trash will not be

compacted.

• Odor causing items such as raw meat,
grapefruit rinds, personal hygiene items, and
diapers should not be loaded in the

compactor.

K

fish,

3. Close drawer COMPLETELY and turn key­knob momentarily to START.

5. When bag is

full,

remove it and install new bag (See next page for complete instructions.

4.

The ram will go down, then back up and shut

off automatically. Remember — the first few
items in each bag won't be crushed until later.

Removing full compactor bag

fi

f

L

^^"yl

1.

Unfold bag cuffs.

•V R^l^a?'-'' drawer side latch.

Installing new pre-cuffed bag

p

2.

Fold ends in. Handle care-

fully when bag contains
broken glass.

5. Tilt side of drawer open to
make full bag easier to
remove.

1

3 Bring side flaps together and

fold down to close bag.

6. Lift out bag and Ci:rr7 b,
BAG-AWAY handles.

RELOCK THE DRAWER
SIDE LATCH.

1.

Put BAG-AWAY bag caddy

into drawer. Tuck rope
handles behind bag retainers.

4.

Spread rear bag corners and

slide the cuff over the rear
left corner. Tuck cuff of bag
behind bag retainer. (Cuffs
cover BAG-AWAY handles.)

2.

Put unopened bag into

drawer as shown The bag
is pre-cuffed for easy
installation.

Press bag against drawer
bottom,

sides, and corners

for smooth fit.

3. Spread front bag corners
and slide the cuff over the
front right corner.

KENMORE COMPACTOR

BAGS

• Designed to fit

• Easy to install

• Tough and leak
resistant

Buy Compactor bags
in the Appliance Dept­at your Sears store or

from the Sears catalog.

Extra Pac Cycle

13501 and 13505 Model Series

The EXTRA PAC Cycle is a convenience feature that allows
you to use fewer bags or extend the use of a bag until trash
pick up day EXTRA PAC Cycle puts constant pressure on
trash to keep it from springing back Regular use of this feature
can increase bag capacity up to 20%

To use EXTRA PAC Cycle

• Push cycle control to EXTRA PAC.

•

Turn

the key-knob to START and release

• The ram will stay in the down position for extra compacting.

Remember the drawer cannot be opened.

<>

On models

o

For best results use EXTRA PAC for at least one half hour or overnight.

o

To raise the ram, turn the key-knob to START or push the cycle control back to NORMAL.

- On models 13501 and 13505 EXTRA PAC Light goes out.

NOTE:

Fully compacted trash bags will be heavier than normal Handle with care.

goes on

13501

and 13505 the EXTRA PAC Light

More Features

Automatic Liquid

Deodorizer System

13501 and 13505

This deodorizer system helps control odors
automatically A small amount of deodorizer is

released every time the drawer is closed To

control strong odors, open and close the drawer

several times

To install deodorizer can:

• Put deodorizer nozzle into plastic holder

• Push can into place.
Because the deodorizer is liquid, it is subject to

freezing It will not dispense at temperatures
below 320F {0oC).

Use Sears Compactor Deodorizing Liquid
available at Sears stores and through the
Sears catalog.

CAUTION:

can Items behind spray can could cause
compactor to jam.

Model

Series

Do not store anything behind spray

Solid Air Freshener
System

13405

Model Series

The solid air freshener system is designed to help
control odors that might develop from the trash.

Use disc-shaped or any of a number of solid air
fresheners available from your grocer. Follow air
freshener package instructions.

Check the air freshener occasionally It should

last about 4 to 6 weeks.

To install solid air freshener:

• Raise the door.

• Put in solid air freshener

• Set dial to NORMAL

• Move to MAXimum or MINimum if needed

This solid air freshener is used more rapidly
when (1) fully

(3) air is very dry

Compartment is easily removed for cleaning —

simply pull forward at top edge.

exposed,

(2) temperature is

high,

or

Bag Away Bag Caddy

13501

and 13505

Fits right inside the compactor drawer Helps make
removing and carrying full compactor bag a simple

task

Model

Series

n

Tilt Open Drawer

Release the drawer side latch and the right side of
the compactor drawer tilts out. This relieves bag
pressure and permits easy, convenient slide-out
removal of full bag.

REMOVE

Key-knob control can be removed
when in REMOVE position.
This is a safety feature intended to
prevent small children from

oper-

ating the compactor.
NOTE-

Your compactor comes with

an extra key for your convenience.

ROLLERS

LEVELING LEGS

13305 Model Series

Rear rollers make the compactor

easier to put into position. Front level-

ing legs make it easier to level the
compactor. Remember, the compac­tor must be level to operate properly.

The textured steel top resists
smudges and fingerprints. Helps
keep your freestanding compactor
looking clean and smart.

There are two switches that are
engaged when the drawer is
completely closed. One switch
is located at the front of the
compactor, the other on the
back

wall.

Both switches must
be engaged or the ram will not
go down. This prevents the
compactor from operating
unless the drawer is completely
and properly closed.

13501

and 13505 Model Series

Provides convenient, no hands
drawer opening. Just press
down on the full-width Step-On

Drawer Opener and the drawer
slides open

13305,13501 and 13505 Model Series

Change front panel color
anytime to match kitchen
decor.

Or create a custom
look to match cabinets, etc.
See next page for full details.

ront Pane! Color

During installation, or in the future, you may want to change the compactor's
front panel color. Your compactor has a reversible color panel which is easily

changed to match your kitchen decor.

COLOR PANEL

CARDBOARD SPACER

DRAWER TRIM

1.

Open the drawer.

2,

Remove handle by removing the screws at the

lop inside of the drawer,

3. Select the color you want, then switch panel
so that this color is showing.

4.

Replace color panel and spacer.

5. Remount handle and close drawer.

10

WARNING- REPLACE HANDLE BEFORE
OPERATING COMPACTOR TO AVOID INJURY
FROM MOVING PARTS.

In place of the color panel, you may want
to use a 1/4" (.63 cm) thick x 14%" (37.1 cm) wide
x 2215/i8" (58.2 cm) long wooden panel (not
included) to match your cabinets or use other
suitable decorative material you choose.

See Installation Instructions for further details.

1.

DON'T let small children

use or piay with the
compactor. Turn key-knob to
OFF and remove it to
prevent compactor
operation.

SSflJgr

2.

DON'T push trash into the

compactor with your hands
or feet. You may be cut by
sharp objects.

3. DON'T compact containers
or rags containing paint,

paint thinner, oil or any

flammable or explosive

material.
a fire hazard.

These could cause

4. DON'T compact SPRAY
cans or other containers
which may contain
poisonous or explosive
chemicals. Dangerous
materials may be released.

5. But, you may compact spray
cans which contain cheese
spread,
shaving cream, etc.

whipped cream,

6. Carry full bag carefully.
Broken glass may cut

through the bag.

11

Service Checks

Problems and Answers

CHECK THESE ITEMS BEFORE YOU CALL FOR SERVICE.

Compactor doesn't operate?

OFF ON

SVxRl

Electric cord plugged in?
Using an extension cord? DO NOT

USE.

An extension cord could
reduce voltage, create a fire
hazard,

and is potentially unsafe.

The compactor will not
operate if voltage is too low.

Is odor a problem?

Fuse blown?
Breaker switch ON?

At temperatures below 20oF (-70C), the motor may temporarily not start. When

"the Compactor is warmer than 20oF {-70C), it

Drawer shut ALL the way? Trash
caught behind the drawer?

Door closed securely?

Have you turned key-knob momen­tarily ALL the way to START (don't
force.)

"will

operate"

normally.

Check to see if deodorizer is
releasing
Series). Replace if empty.

12

{13501

and 13505 Model

Replace solid air freshener
(13405 Model Series)

Clean compactor (see page 14).

L^. •" ^

•

I

Check to be sure compactor is
level front to rear. Adjust front
leveling legs if necessary.

Is flexible toe plate trimmed
properly? (See Installation
Instructions)

Drawer side COMPLETELY
closed and latched?

Remember, compactor must be one-third full before

you notice any compacting.

To release Extra Pac, press Normal Cycle or turn
Start knob Light will go out

The compactor has an anti-jam feature. If the

ram encounters an improperly loaded item on the

way down it will reverse automatically and go

back up without jamming. Reload the compactor

as shown on page 5.

13

When your compactor needs cleaning-care

CAUTION:

Watch out for broken glass or other sharp objects that may be present when

cleaning compactor.

xV —

*• .r'r -"- —•

1

1

T

i

Clean the outside with warm
water and detergent, rinse,
wipe dry. Wipe spills promptly.

^

-il

-*

i

Clean the inside occasionally

by using a vacuum cleaner,
warm water and detergent,
sponge, dry cloth, paper
towels, etc. Wear household
(rubber) gloves since particles
of glass may be inside the
drawer.

To clean the inside, remove
trash bag. Then, hold drawer
latch all the way open to
remove drawer side. Lift out,
wash,

rinse, and dry inside
drawer surfaces. Put drawer
side back in place. Be sure
that notches on lower drawer
panel match those on the
drawer side. Relock the drawer
side latch.

Remove drawer. Raise front of

drawer to clear drawer stops.

Lift drawer out. Keep the
drawer bottom clean to prevent
sticking.

If You'll Be Away For A Few Days

•Remove and discard the Compactor bag so odors won't build up.

•Lock the Compactor and remove the key-knob to prevenl lampf-nng with (he iin't.

14

Vacuum inside of cabinet and

drawer to keep drawer sliding
freely.

To clean ram, wear household
gloves and wipe bottom of ram
with sponge. Be careful, there

may be glass particles.
Replace drawer in cabinet.