How it Works
Sea Ray
Loading...
200 Sundeck
Owner's Manual
27 pgs2.56 Mb0
Specific Information Manual
22 pgs3.66 Mb0

Sea Ray 200 Sundeck Specific Information Manual

Download
Specific
Information
Manual
200 Sundeck
Manual Part Number: MRP 1902268
200 Sundeck i
200 SUNDECK SPECIFIC INFORMATION MANUAL
TABLE OF CONTENTS
1. Load Capacity ..........................................................1
2. Passenger Locations ...............................................1
3. Safety Label Locations ............................................ 2
4. Basic Boat Dimensions and Clearances ................. 4
5. Function and Location of Through-Hull Cutouts ......5
6. Helm, Gauge & Switch Layout ................................. 6
7. Deck Layout ............................................................. 7
8. Cleats .......................................................................8
9. Navigation and Anchor Lights .................................. 8
10. Bilge Layout ........................................................... 8
11. Fuel System ...........................................................8
12. Entertainment System ........................................... 9
13. Canvas ...................................................................9
14. Transom Trailer Trim Switch (Optional) ................... 9
15. Water Sports Tower .............................................. 10
16. Electrical Schematic ............................................ 10
Information in this publication is based upon the latest product specifications available at printing. Sea Ray
®
Boats, Inc. reserves the right to make changes at any time, without notice, in the colors, equipment, specifications,
materials and prices of all models, or to discontinue models. Should changes in production models be made, Sea
Ray
®
is not obligated to make similar changes or modifications to models sold prior to the date of such changes.
Owner’s Manual
200 Sundeck
Printed in the U.S.A. April 2007
©3EA2AY"OATS)NCs!"RUNSWICK#OMPANY
Sea Ray Boats, Inc. 2600 Sea Ray Blvd., Knoxville, TN 37914
For information call 1-800-SRBOATS or fax 1-314-213-7878
(International 1-314-216-3333)
Internet Address: http://www.searay.com
Note: Not all accessories shown in pictures or described herein are
standard equipment or even available as options.
Options and features are subject to change without notice.
The following are registered trademarks of the Brunswick Corporation: Sea Ray® & The SR Wave Logo
200 Sundeck i
200 SUNDECK SPECIFIC INFORMATION MANUAL
TABLE OF CONTENTS
1. Load Capacity ..........................................................1
2. Passenger Locations ...............................................1
3. Safety Label Locations ............................................ 2
4. Basic Boat Dimensions and Clearances ................. 4
5. Function and Location of Through-Hull Cutouts ......5
6. Helm, Gauge & Switch Layout ................................. 6
7. Deck Layout ............................................................. 7
8. Cleats .......................................................................8
9. Navigation and Anchor Lights .................................. 8
10. Bilge Layout ........................................................... 8
11. Fuel System ...........................................................8
12. Entertainment System ........................................... 9
13. Canvas ...................................................................9
14. Transom Trailer Trim Switch (Optional) ................... 9
15. Water Sports Tower .............................................. 10
16. Electrical Schematic ............................................ 10
Information in this publication is based upon the latest product specifications available at printing. Sea Ray
®
Boats, Inc. reserves the right to make changes at any time, without notice, in the colors, equipment, specifications,
materials and prices of all models, or to discontinue models. Should changes in production models be made, Sea
Ray
®
is not obligated to make similar changes or modifications to models sold prior to the date of such changes.
Owner’s Manual
200 Sundeck
Printed in the U.S.A. April 2007
©3EA2AY"OATS)NCs!"RUNSWICK#OMPANY
Sea Ray Boats, Inc. 2600 Sea Ray Blvd., Knoxville, TN 37914
For information call 1-800-SRBOATS or fax 1-314-213-7878
(International 1-314-216-3333)
Internet Address: http://www.searay.com
Note: Not all accessories shown in pictures or described herein are
standard equipment or even available as options.
Options and features are subject to change without notice.
The following are registered trademarks of the Brunswick Corporation: Sea Ray® & The SR Wave Logo
1
200 SUNDECK OWNERS MANUAL
200 Sundeck
1. LOAD CAPACITY
Refer to the General Information Manual for a detailed explanation of Load Capacity.
Never carry more weight or passengers than indicated on the certification plate, regardless of weather or water conditions.
The boat can capsize, swamp or sink.
! DANGER
Rotating propellers can injure or kill you.
Shut off engine when persons are in water near boat, or on swim platform or ladder.
! DANGER
Rear facing transom seats MUST NOT be used while engine is running or boat is moving.
! WARNING
2. PASSENGER LOCATIONS
Refer to the General Information Manual for a detailed explanation of Passenger Locations.
Boat motion can be erratic.
You can fall overboard or be injured by hitting something in or on the boat.
All persons must be in cockpit area or cabin and be prepared for sudden boat movement.
Use front or bow deck area only during anchoring, mooring or emergencies.
! WARNING
Wet decks are slippery.
You can be seriously injured if you slip and fall.
Wear slip resistant footwear secured to your feet and hold on to rails or boat structure.
! WARNING
BUILDER’S PLATE (DOMESTIC)
MAXIMUM CAPACITIES
8 PERSONS OR 1100 LBS.
1200 POUNDS, PERSONS, GEAR
LOAD AND CAPACITY • COMPARTMENT VENTILATION
STEERING, FUEL AND ELECTRICAL SYSTEMS
INTERNATIONAL LIGHTS • BASIC FLOATATION
MANEUVERABILITY
THIS BOAT COMPLIES WITH U.S. COAST GUARD SAFETY STANDARDS IN EFFECT ON THE DATE OF CERTIFICATION
MODEL: 200SD
DESIGN COMPLIANCE WITH NMMA REQUIREMENTS BELOW IS
VERIFIED. MFR. RESPONSIBLE FOR PRODUCTION CONTROL
NATIONAL MARINE MANUFACTURERS ASSN.
MANUFACTURER: SEA RAY BOATS, INC.
VONORE, TN
Certified
NMMA
(FIG. 1.2)
MAXIMUM
0609
IMCI
F
I
N
T
E
R
N
A
T
I
O
N
A
L
C
E
R
T
I
I
C
A
T
I
O
N
Sea8Ray
200 SD
Boats
635
kg
BUILDER’S PLATE (INTERNATIONAL)
BOAT MANUFACTURER
MFR’S MODEL DESIGN ATION
MAXIMUM NUMBER
OF PASSENGERS
MAXIMUM LOAD
CAPACITY
(FIG. 1.1)
P
ASSENGER LOCATIONS
(FIG. 1.3)
ACCOMMODATION DECK (DECK AREA INTENDED FOR OCCUPAT ION DURING NORMAL OPERAT ION)
200 Sundeckii
THIS PAGE INTENTIONALLY LEFT BLANK
1
200 SUNDECK OWNERS MANUAL
200 Sundeck
1. LOAD CAPACITY
Refer to the General Information Manual for a detailed explanation of Load Capacity.
Never carry more weight or passengers than indicated on the certification plate, regardless of weather or water conditions.
The boat can capsize, swamp or sink.
! DANGER
Rotating propellers can injure or kill you.
Shut off engine when persons are in water near boat, or on swim platform or ladder.
! DANGER
Rear facing transom seats MUST NOT be used while engine is running or boat is moving.
! WARNING
2. PASSENGER LOCATIONS
Refer to the General Information Manual for a detailed explanation of Passenger Locations.
Boat motion can be erratic.
You can fall overboard or be injured by hitting something in or on the boat.
All persons must be in cockpit area or cabin and be prepared for sudden boat movement.
Use front or bow deck area only during anchoring, mooring or emergencies.
! WARNING
Wet decks are slippery.
You can be seriously injured if you slip and fall.
Wear slip resistant footwear secured to your feet and hold on to rails or boat structure.
! WARNING
BUILDER’S PLATE (DOMESTIC)
MAXIMUM CAPACITIES
8 PERSONS OR 1100 LBS.
1200 POUNDS, PERSONS, GEAR
LOAD AND CAPACITY • COMPARTMENT VENTILATION
STEERING, FUEL AND ELECTRICAL SYSTEMS
INTERNATIONAL LIGHTS • BASIC FLOATATION
MANEUVERABILITY
THIS BOAT COMPLIES WITH U.S. COAST GUARD SAFETY STANDARDS IN EFFECT ON THE DATE OF CERTIFICATION
MODEL: 200SD
DESIGN COMPLIANCE WITH NMMA REQUIREMENTS BELOW IS
VERIFIED. MFR. RESPONSIBLE FOR PRODUCTION CONTROL
NATIONAL MARINE MANUFACTURERS ASSN.
MANUFACTURER: SEA RAY BOATS, INC.
VONORE, TN
Certified
NMMA
(FIG. 1.2)
MAXIMUM
0609
IMCI
F
I
N
T
E
R
N
A
T
I
O
N
A
L
C
E
R
T
I
I
C
A
T
I
O
N
Sea8Ray
200 SD
Boats
635
kg
BUILDER’S PLATE (INTERNATIONAL)
BOAT MANUFACTURER
MFR’S MODEL DESIGN ATION
MAXIMUM NUMBER
OF PASSENGERS
MAXIMUM LOAD
CAPACITY
(FIG. 1.1)
P
ASSENGER LOCATIONS
(FIG. 1.3)
ACCOMMODATION DECK (DECK AREA INTENDED FOR OCCUPAT ION DURING NORMAL OPERAT ION)
3
200 SUNDECK OWNERS MANUAL
200 Sundeck
SAFETY LABEL LOCATIONS (CONTINUED)
SAFETY LABEL LOCATIONS (FIG. 3.1)
PLASTIC-Includes, but is not limited to: plastic bags, styrofoam cups and lids, six pack holders, stirrers, straws,
milk jugs, egg cartons, synthetic fishing nets,
ropes, lines, and bio or photo degradeable
plastics. GARBAGE-Means paper, rags, glass, metal, crockery, (generated in
living spaces aboard the vessel that we normally call trash), and all kinds of food, maintenance and cargo- associated waste. “Garbage” does not include fresh fish or fish parts, dishwasher and
gray water.
INSIDE 3 MILES
3 TO 12 MILES
(and in U.S. Lakes, Rivers,
bays and Sounds)
PLASTICS
DUNNAGE, LINING AND PACKING
MATERIALS THAT FLOAT
ANY GARBAGE EXCEPT DISHWATER/
GRAYWATER/FRESH FISH PARTS
PLASTICS
DUNNAGE, LINING AND PACKING
MATERIALS THAT FLOAT
ANY GARBAGE NOT GROUND TO
LESS THAN ONE SQUARE INCH
12 TO 25 MILES
PLASTICS
DUNNAGE, LINING AND PACKING
MATERIALS THAT FLOAT
OUTSIDE 25 MILES
PLASTICS
It is illegal to dump plastic trash anywhereinto the ocean or navigable waters
of the United States. Violation of these requirements may result in civil penalty
up to $25,000 and fine of $50,000 and imprisonment up to five years.
Regional, state and local restrictions on garbage, discharge amy also apply.
S O
ave
DUNNAGE- Material
used to block and brace
cargo, and is considered
a cargo associated
waste.
DISHWATER-Means the
liquid residue from the
manual or automatic
washing of dishes and
cooking utensils which,
have been pre-cleaned to
the extent that any food
particles adhering to them
would not normally
interfere with the
operation of automatic
dishwashers.
GRAYWATER-Means
drainage from a
dishwasher, shower,
laundry, bath, and
washbasin, and does not
include drainage from
toilets, urinals, hospitals
and cargo spaces.
S
easur
LOCATED INSIDE
PORT STORAGE
COMPARTMENT DOOR.
2
200 SUNDECK OWNERS MANUAL
200 Sundeck
3. SAFETY LABEL LOCATIONS
SAFETY LABEL LOCATIONS (FIG. 2.1)
GASOLINE VAPORS CAN EXPLODE
RESULTING IN INJURY OR DEATH.
BEFORE STARTING ENGINE: CHECK ENGINE
COMPARTMENT BILGE FOR GASOLINE OR VAPORS, OPERATE BLOWER
FOR FOUR MINUTES,
AND VERIFY BLOWER OPERATION. RUN BLOWER WHEN VESSEL
IS OPERATING BELOW CRUISING SPEED.
MRP 852525 SR-111
WARNING
MRP 852533 SR-119A
DANGER
MAXIMUM CAPACITIES
8 PERSONS OR 1100 LBS.
1200 POUNDS, PERSONS, GEAR
LOAD AND CAPACITY * COMPARTMENT VENTILATION
STEERING, FUEL AND ELECTRICAL SYSTEMS
INTERNATIONAL LIGHTS * BASIC FLOATION
MANEUVERABILITY
THIS BOAT COMPLIES WITH U.S. COAST
GUARD SAFETY STANDARDS IN EFFECT ON
THE DATE OF CERTIFICATION
MRP 722041 SR-87
12VDC-15A MAX
MRP 551689 SR-66
DO NOT STAND OR WALK ON
THIS AR EA SERI OUS IN JURY
COULD RESULT.
MRP # 113562 SR-216
DANGER
!
MRP 811000 SR-102
DANGER
!
TRANSOM DOOR MUST BE
CLOSED AND SECURE WHEN
ENGINE IS RUNNING
UNDER AFT SEAT ON ENGINE BOX BULKHEAD
MRP # 324756 SR-47
(INSIDE SIDE PANEL STORAGE)
MODEL: 200SD
DESIGN COMPLIANCE WITH NMMA REQUIREMENTS BELOW IS
VERIFIED. MFR. RESPONSIBLE FOR PRODUCTION CONTROL
NATIONAL MARINE MANUFACTURERS ASSN.
MANUFACTURER: SEA RAY BOATS, INC.
Certified
NMMA
!
LEAKING FUEL IS A FIRE AND EXPLOSION
HAZARD, INSPECT SYSTEM REGULARY.
EXAMINE FUEL TANKS FOR LEAKS OR
CORROSION AT LEAST ANNUALLY.
STAY CLEAR OF MOVING PARTS
WHILE ENGINE IS RUNNING.
SEE OWNER’S MANUAL FOR ADDITIONAL INFORMATION
AVOID SERIOUS INJURY OR DEATH FROM CARBON MONOXIDE
EXHAUST FUMES FROM ENGINES CONTAIN CARBON MONOXIDE GAS
AND MAY COLLECT IN ENCLOSED AREAS
KEEP COCKPIT CABIN AND CABIN AREAS WELL VENTILATED. DO NOT
USE CANVAS, SIDE CURTAINS AND FORWARD VISOR WITHOUT
PROPER VENTILATION.
CO SIDKNESS SYMPTIONS INCLUDE HEADACHE, NAUSEA, AND DIZZINESS.
DO NOT MISTAKE FOR SEASICKNESS.
MRP 1369743 SR-246
DANGER
!
!
SEE OWNER’S MANUAL FOR ADDITIONAL INFORMATION
MRP 852624 SR-149
DANGER
NEXT TO BATTERY SWITCH
IF SWIT CH IS TURN ED OFF WH ILE
ENGINE IS RUNNING ALTERNA TOR
WILL BE DAMAGED.
MRP # 921767 SR-167
CAUTION
!
!
MRP 852632 SR-151
WARNING
!
NO SMOKING
GASOLINE VAPORS ARE EXPLOXIVE
NOTICE
GASOLINE RECOMMENDATION
Minimum octane rating of 87 AKI.
Refer to the engine owner’s manual for
additional information.
MRP 111287 SR-214
DANGER
!
TO AVOID RISK OF SERIOUS INJURY OR DEATH
SHUT OFF ENGINE WHEN NEAR SWIMMERS
OR PRIOR TO USING SWIM PLATFORM AND
BOARDING LADDER.
CAUTION
- TO AVOID INJURY, GLASS DOOR MUST BE SECURED IN A CLOSED
AND LOCKED POSITION WHEN BOAT IS UNDER WAY. USE BOTH
TURN LOCKS TO SECURE DOOR.
ON UNDERSIDE OF WINDSHIELD FRAME (PART NUMBER PROVIDED BY VENDOR)
!
USE CAUTION WITH SKIER IN TOW
AS TOW ROPE MAY BACKLASH INTO
COCKPIT WHEN RELEASED
INSIDE ENGINE BOX AT HINGE LOCATION
STAINLESS STEEL SLIDING SWIM LADDERS
SUGGESTED CARE & MAINTENANCE
MRP 1573112 SR-505
AFTER EACH USE:
Fully extend ladder and thoroughly rinse all ladder and slide surfaces
with fresh water. Pay special attention to flushing any debris and salt
water from the slide areas.
MONTHLY:
Examine the ladder slide grooves and remove any foreign particles
lodged within the grooves.
Wash entire ladder, uning ONLY a clean, soft cloth, and mild soap solution.
Rinse thoroughly with fresh water. To prevent damage NEVER USE
ABRASIVES or ABRASIVE CLEANERS!
Allow ladder to dry after washing. Apply a light coating of spray lubricant or
clear silicone grease to the slide areas ONLY. Work ladder back and forth
to assure distribution of lubricant and ease of operation.
CAUTION - TO PREVENT THE POSSIBILITY OF PERSONAL INJURY,
ENSURE THAT ANY LUBRICANT IS CLEANED FROM LADDER RUNGS
AND STILES PRIOR TO USE.
Inspect the ladder for damage and check the security of all fasteners.
Repair damage and/or tighten any hardware that may have become
loose prior to use.
UNDER SWIM LADDER COVER
THIS TAG REPLACES DOMESTIC
CERTIFICATION TAG (BELOW)
WHEN BOAT IS ORDERED WITH
INTERNATIONAL (CE) OPTION.
MRP 111287 SR-214
DANGER
!
TO AVOID RISK OF SERIOUS INJURY OR DEATH
SHUT OFF ENGINE WHEN NEAR SWIMMERS
OR PRIOR TO USING SWIM PLATFORM AND
BOARDING LADDER.
ALSO LOCATED ON BOW FILLER BOARDS
(W/ BOW FILLER CUSION OPTION)
!
WARNING
MAXIMUM
0609
IMCI
Sea
8
Ray
200 SUNDECK
Boats
635
kg
! DANGER
! WARNING
CARBON MONOXIDE CAN BE FATAL In all gasoline powered boats, engine exhaust systems
produce colorless, odorless carbon monoxide gas (’CO’) Direct prolonged exposure can result in
CO poisoning which may be harmful or fatal. to prevent excess exposure and reduce the possibility of
accumulations of CO in the boat, the operator should include adequate ventilation through utilization of cabin
hatches and walk-through windshields to increase air movement through the boat. The following conditions tend
to increase the accumulation of CO in and about the boat and require the operator’s particular attention:
INDICATIONS OF EXCESSIVE EXPOSURE TO ‘CO’ CONCENTRATIONS MAY INCLUDE NAUSEA, DIZZINESS, HEADACHE AND DROWSINESS.
Operation at slow speeds or dead in water. Utilization of canvas tops, side curtains or back curtains.
Any blockage of hull exhaust outlets.
Operation with a high bow angle attitude. Operation of engines and/or generator in confined spaces or at dockside.
Contributing climatic conditions, such as headwind.
AVOID RISK OF INJURY OR DEATH. SHUTOFF ENGINE NEAR SWIMMERS OR PRIOR TO USING SWIM PLATFORM, SUNPAD OR BOARDING LADDER.
USE CAUTION WITH SKIER IN TOW AS ROPE MAY BACKLASH INTO COCKPIT WHEN RELEASED
AVOID COLLISIONS - Maintain lookout as required by “Rules of the Road”. Visibility can be limited
by high boat trim angles, persons and gear. Such issues are considered under the control of the operator.
NOTICE: It is recommended that all occupants wear approved Personal Flotation Devices (PFD’s).
WARNING
3
200 SUNDECK OWNERS MANUAL
200 Sundeck
SAFETY LABEL LOCATIONS (CONTINUED)
SAFETY LABEL LOCATIONS (FIG. 3.1)
PLASTIC-Includes, but is not limited to: plastic bags, styrofoam cups and lids, six pack holders, stirrers, straws,
milk jugs, egg cartons, synthetic fishing nets,
ropes, lines, and bio or photo degradeable
plastics. GARBAGE-Means paper, rags, glass, metal, crockery, (generated in
living spaces aboard the vessel that we normally call trash), and all kinds of food, maintenance and cargo­associated waste. “Garbage” does not include fresh fish or fish parts, dishwasher and
gray water.
INSIDE 3 MILES
3 TO 12 MILES
(and in U.S. Lakes, Rivers,
bays and Sounds)
PLASTICS
DUNNAGE, LINING AND PACKING
MATERIALS THAT FLOAT
ANY GARBAGE EXCEPT DISHWATER/
GRAYWATER/FRESH FISH PARTS
PLASTICS
DUNNAGE, LINING AND PACKING
MATERIALS THAT FLOAT
ANY GARBAGE NOT GROUND TO
LESS THAN ONE SQUARE INCH
12 TO 25 MILES
PLASTICS
DUNNAGE, LINING AND PACKING
MATERIALS THAT FLOAT
OUTSIDE 25 MILES
PLASTICS
It is illegal to dump plastic trash anywhereinto the ocean or navigable waters
of the United States. Violation of these requirements may result in civil penalty
up to $25,000 and fine of $50,000 and imprisonment up to five years.
Regional, state and local restrictions on garbage, discharge amy also apply.
S O
ave
DUNNAGE- Material
used to block and brace
cargo, and is considered
a cargo associated
waste.
DISHWATER-Means the
liquid residue from the
manual or automatic
washing of dishes and
cooking utensils which,
have been pre-cleaned to
the extent that any food
particles adhering to them
would not normally
interfere with the
operation of automatic
dishwashers.
GRAYWATER-Means
drainage from a
dishwasher, shower,
laundry, bath, and
washbasin, and does not
include drainage from
toilets, urinals, hospitals
and cargo spaces.
S
easur
LOCATED INSIDE
PORT STORAGE
COMPARTMENT DOOR.
5
200 SUNDECK OWNERS MANUAL
200 Sundeck
5. FUNCTION AND LOCATION OF THROUGH-HULL CUTOUTS
PORT THROUGH-HULL CUTOUTS (FIG.5.1)
BILGE THROUGH-HULL CUTOUTS (FIG. 5.2)
BILGE PUMP
OUTLET
DEPTH SOUNDER
TRANSDUCER
GARBOARD DRAIN (FIG. 5.3)
4
200 SUNDECK OWNERS MANUAL
200 Sundeck
4. BASIC BOAT DIMENSIONS AND CLEARANCES
BOAT DIMENSIONS AND CLEARANCES (FIG. 4.1)
(A) 21’ 0” (6.40 m)
(A) Overall Length ......................... 21ft. 0in. 6.40m
(B) Beam (Width) ........................... 8ft. 4in. 2.54m
(C) Draft (Stern Drive Down) ......... 36”* 91.4cm*
*MINIMUM WATER DEPTH TO PREVENT RUNNING AGROUND
(Stern Drive Up)............... 20” 50.8cm
Dry Weight ..................................... 3,550 lbs. 1,610.3 kg.
Fuel Capacity ................................. 40 gal. 151.4 liters
Useable Fuel ................................. 38 gal. 143.8 liters
Dead Rise ...................................... 20
o
FULL LOAD WATER LINE
(E) 5’ 10” (1.77m)
200 SUNDECK SPECIFICATIONS HEIGHT DIMENSIONS
(D) Waterline to Top of Windshield ......... 4ft. 4in. 1.32 m
(E) Keel to Top of Windshield ................. 5ft. 10in. 1.77 m
STERN DRIVE
WATER LINE
(C) DRAFT (DN)
36” (91.4 cm)
(B) BEAM
8’ 4” (2.54m)
(D) 4’ 4” (1.32m)
NOTE: DIMENSIONS CAN VARY DEPENDING ON LOAD
AND RUNNING CONDITIONS.
5
200 SUNDECK OWNERS MANUAL
200 Sundeck
5. FUNCTION AND LOCATION OF THROUGH-HULL CUTOUTS
PORT THROUGH-HULL CUTOUTS (FIG.5.1)
BILGE THROUGH-HULL CUTOUTS (FIG. 5.2)
BILGE PUMP
OUTLET
DEPTH SOUNDER
TRANSDUCER
GARBOARD DRAIN (FIG. 5.3)
7
200 SUNDECK OWNERS MANUAL
200 Sundeck
7. DECK LAYOUT
GENERAL LAY OUT (FIG. 7.1)
BOW NAVIGATION
LIGHTS
ANCHOR STORAGE LOCKER
HORN
STA RBOARD BOW RIDER LOUNGER
WITH STORAGE BELOW
CONTROL STATION
COMPASS (OPTION)
HELM SEAT WITH FLIP UP THIGH
RISE BOLSTER
ACCESS PLATE TO FUEL TANK
(OPTIONAL TABLE BASE . REMOVE
FOR ACCESS TOFUEL TANK)
ENGINE BOX (UNDER SEAT)
TRANSOM DOOR
STERN LIGHT HOLDER
FOLDING SWIM LADDER
SWIM PLATFORM
SKI TOW
TRANSOM STEREO REMOTE
TRANSOM STERN DRIVE TILT
CONTROL
AFT PORT
CLEAT
L-SHAPED LOUNGER -
CONVERTS TO FORWARD
FAC ING SEAT W/SKI &
KNEEBOARD STORAGE BELOW
FLIP DOWN BACK REST
WALK-THROUGH
WINDSHIELD
DOOR TO STARBOARD
STORAGE
(STEREO & FUSE BOX)
DOOR TO PORT
STORAGE
PORT BOW RIDER LOUNGER
WITH STORAGE BELOW
ACCESS PLATE TO FUEL TANK
SENDING UNIT
FUEL FILL
AFT STA RBOARD
CLEAT
FORWARD PORT
CLEAT
FORWARD STARBOARD
CLEAT
PORT AMIDSHIP
CLEAT
STA RBOARD AMIDSHIP
CLEAT
6
200 SUNDECK OWNERS MANUAL
200 Sundeck
6. HELM, GAUGE & SWITCH LAYOUT
GAUGE PANEL
FUEL
GAUGE
SPEEDOMETER
SYSTEM
TACHOMETER
OIL
PRESSURE
WATER
TEMPERATURE
STERN DRIVE
TRIM GAUGE
ACCY
THRU-HULL
EXHAUST
WATER
PUMP
LIGHTS
ANCHOR COCKPITNAV
LIGHT ON - UNIT CHARGED LIGHT OFF - UNIT DISCHARGED IF SYSTEM DISCHARGES, SHUTDOWN ENGINE, BLOWER AND ELECTRICAL SYSTEM
AUTOMATIC EXTINGUISHING SYSTEM
CLARION STEREO REMOTE
S TARBOARD SWITCH PANELPORT SWITCH PANEL
WARNING
GASOLINE VAPORS CAN EXPLODE RESULTING IN INJURY OR DEATH
!
BEFORE STARTING ENGINE, CHECK ENGINE COMPARTMENT BILGE FOR GASOLINE OR VAPORS. OPERATE BLOWER FOR FOUR MINUTES, AND VERIFY BLOWER OPERATION. RUN BLOWER WHEN VESSEL IS OPERATING BELOW CRUISING SPEED.
HORN WIPER BILGE
PUMP
BILGE
BLOWER
HELM, GAUGE & SWITCH LAY OUT (FIG. 6.1)
7
200 SUNDECK OWNERS MANUAL
200 Sundeck
7. DECK LAYOUT
GENERAL LAY OUT (FIG. 7.1)
BOW NAVIGATION
LIGHTS
ANCHOR STORAGE LOCKER
HORN
STA RBOARD BOW RIDER LOUNGER
WITH STORAGE BELOW
CONTROL STATION
COMPASS (OPTION)
HELM SEAT WITH FLIP UP THIGH
RISE BOLSTER
ACCESS PLATE TO FUEL TANK
(OPTIONAL TABLE BASE . REMOVE
FOR ACCESS TOFUEL TANK)
ENGINE BOX (UNDER SEAT)
TRANSOM DOOR
STERN LIGHT HOLDER
FOLDING SWIM LADDER
SWIM PLATFORM
SKI TOW
TRANSOM STEREO REMOTE
TRANSOM STERN DRIVE TILT
CONTROL
AFT PORT
CLEAT
L-SHAPED LOUNGER -
CONVERTS TO FORWARD
FAC ING SEAT W/SKI &
KNEEBOARD STORAGE BELOW
FLIP DOWN BACK REST
WALK-THROUGH
WINDSHIELD
DOOR TO STARBOARD
STORAGE
(STEREO & FUSE BOX)
DOOR TO PORT
STORAGE
PORT BOW RIDER LOUNGER
WITH STORAGE BELOW
ACCESS PLATE TO FUEL TANK
SENDING UNIT
FUEL FILL
AFT STA RBOARD
CLEAT
FORWARD PORT
CLEAT
FORWARD STARBOARD
CLEAT
PORT AMIDSHIP
CLEAT
STA RBOARD AMIDSHIP
CLEAT
9
200 SUNDECK OWNERS MANUAL
200 Sundeck
13. CANVAS
The standard canvas set for the 200SD consists of a bimini top with boot.
The following canvas options are available.
Bimini Aft Curtain Side Curtains Canvas Storage Bag Front Curtains Cockpit Cover Tonneau Cover
! DANGER
Exhaust fumes from engines contain deadly carbon monoxide gas (CO). Boats enclosed with canvas or with poor ventilation are most likely to collect fumes.
CO sickness symptoms include headache, nausea and dizziness. Do not mistake these symptoms for sea sickness.
Ventilate boat. See Section 1.4, Carbon Monoxide, for more details.
Do not use the rear (aft) curtain while engine is running or boat is moving.
12. ENTERTAINMENT SYSTEM
The 12 volt AM/FM radio single CD stereo is located in the port glove box.
The system includes two (2) water proof speakers. The Premier Stereo upgrade includes an amplifier, power antenna, four (4) speakers, a digital remote control located at the control station, (Fig. 6.3.2), an MP3 device port and is satellite radio ready.
STEREO SYSTEM (12 VOLT AM/FM RADIO & CD)
STEREO REMOTE
AM/FM RADIO, SINGLE CD UNIT, (LOC AT ED IN THE PORT GLOVEBOX)
STEREO REMOTE (LOCATED ON THE DASH)
(FIG. 9.1)
(F
IG. 9.2)
14. TRANSOM TRAILER TRIM SWITCH (OPTIONAL)
A transom-mounted power trim switch is available for the convenience of raising the drive unit to the TRAILERING position while at the rear of the boat.
Use transom-mounted power trim switch to tilt for trailering only. Tilting drive unit into trailering zone while underway can damage the drive unit or engine.
! CAUTION
TRANSOM TRAILER TRIM SWITCH (OPTIONAL) (FIG. 9.3)
8
200 SUNDECK OWNERS MANUAL
200 Sundeck
8. CLEATS
Cleats must not be used for lifting the boat; they are intended for docking or mooring use only.
CLEAT LOCATIONS (FIG. 8.1)
9. NAVIGATION AND ANCHOR LIGHTS
See General Information Manual for a detailed explanation of the anchor lights.
10. BILGE LAYOUT
BILGE LAY OUT (FIG. 8.3)
CLEAT
CLEAT
CLEAT
CLEAT
CLEAT
CLEAT
NAVIGATION AND ANCHOR LIGHTS
(FIG.8.2)
STERN NAV. /
ANCHOR LIGHT
BULB REPLACEMENT
FUSE TYPE BULB
#12V10WPERKO
BULB REPLACEMENT
BULB# GE2641L
12V R 10W
STBD NAVIGATION
LIGHT
RED SIDE
LIGHT
(VISIBLE 2-
NAUTICAL MILES)
GREEN SIDE
LIGHT
(VISIBLE 2-
NAUTICAL MILES)
360
0
WHITE
LIGHT
(VISIBLE 2-
NAUTICAL MILES)
BULB REPLACEMENT
BULB# GE2641L
12V R 10W
PORT NAVIGAT ION
LIGHT
A B C D
F
E
G
H
I
BILGE PUMP
FLOAT SWITCH
DEPTH TRANDUCER
FUEL TANK
FUEL VALVE, (ELECTRIC)
BLOWER
POWER TRIM PUMP
AUTOMAT IC FIRE EXTINGUISHER, (OPT.)
BATTERY
A
B
C
E
F
G
D
H
I
11. FUEL SYSTEM
The 200 Sundeck standard gasoline fuel system consists of a 40 gallon (151 liter) fuel tank, fuel tank vent, anti-siphon valve, engine fuel supply line and fuel fill.
The fuel tank vent serves as a pressure/vacuum release and safety overflow. The fuel vent is located inside the fuel cap on the port aft deck. Periodically check the vent to ensure that it is not clogged. The fuel pickup at the fuel tank has an anti-siphon valve to prevent fuel from siphoning out in the event of fuel line failure.
200 Su n d e c k Ow n e r S Ma n u a l
12. En t E r t a i n m E n t sy s t E m
The 12 volt AM/FM radio single CD stereo is located in the port glove box.
The system includes two (2) water proof speakers. The Premier Stereo upgrade includes an amplifier, power antenna, four (4) speakers, a digital remote control located at the control station, an MP3 device port and is satellite radio ready.
St e r e O Sy S t e M (12 VO l t aM/FM ra d i O & cd)
(Fi g . 9.1)
AM/FM RADIO, SINGLE CD UNIT, (LOCATED IN THE PORT GLOVEBOX)
St e r e O re M O t e (lO c a t e d O n t h e d a S h ) (Fi g . 9.2)
! DANGER
Exhaust fumes from engines contain deadly carbon monoxide gas (CO). Boats enclosed with canvas or with poor ventilation are most likely to collect fumes.
CO sickness symptoms include headache, nausea and dizziness. Do not mistake these symptoms for sea sickness.
Ventilate boat. See Section 1.4, Carbon Monoxide, for more details.
Do not use the rear (aft) curtain while engine is running or boat is moving.
14. tr a n s o m tr a i l E r tr i m sw i t C h (op t i o n a l )
A transom-mounted power trim switch is available for the convenience of raising the drive unit to the TRAILERING position while at the rear of the boat.
! CAUTION
Use transom-mounted power trim switch to tilt for trailering only. Tilting drive unit into trailering zone while underway can damage the drive unit or engine.
STEREO
REMOTE
13. Ca n v a s
The standard canvas set for the 200SD consists of a bimini top with boot.
The following canvas options are available.
Bimini Aft Curtain Side Curtains Canvas Storage Bag Front Curtains Cockpit Cover Tonneau Cover
tr a n S O M tr a i l e r tr i M Sw i t c h (Op t i O n a l ) (Fi g . 9.3)
200 Sundeck
Manual Part Number: MRP 1902268
9
200 Sundeck 11
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
DC WIRING DIAGRAM (1 OF 2)
DRAWING NO. 09-603 (1 OF 2)
1. ELECTRICAL SCHEMATICS, 200 SUNDECK
(FIG. 11.1)
10
200 SUNDECK OWNERS MANUAL
200 Sundeck
16. ELECTRICAL SCHEMATICS
This owner's manual contains electrical schematics and wiring harness illustrations for your boat. These electrical schematics were generated by electrical CAD designers at the engineering division for technical reference and service technicians. Sea Ray® does not recommend that you attempt to work on the boat’s electrical system yourself. Instead, we recommend that you take your boat to your authorized Sea Ray® dealer for service. Sea Ray® reserves the right to change or update the electrical system on any model at any time without notice to the consumer and is NOT obligated to make any updates to units built prior to changes.
15. WATER SPORTS TOWER
If equipped, the water sports tower provides a raised attach point (ski tow pylon) for the ski rope. The high attach point enables the skier to perform a wide variety of skills not capable with the lower transom attach point.
The tower attach point is intended for use only when towing a single skier. If you are towing multiple skiers or water toys carrying more than one person use only the transom attach point. The tower attach point is NOT intented for towing inflatables.
DO NOT USE TOWER FOR PULLING INFLATABLES. Use water sports tower for single skier/wakeboarder only. Use ski tow or stern eyes on transom for all other tow behind sports. Heavy loads could collapse tower causing personal injury.
! WARNING
DO NOT USE WATER SPORTS TOWER FOR TOWING ANOTHER BOAT OR BEING TOWED. TOWER COULD COLLAPSE AND CAUSE INJURY. SEE OWNER'S MANUAL FOR INSTRUCTIONS ON TOWING.
! WARNING
WATER SPORT S TOWER (OPTIONAL) (F
IG. 10.1)
200 Sundeck 11
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
DC WIRING DIAGRAM (1 OF 2)
DRAWING NO. 09-603 (1 OF 2)
1. ELECTRICAL SCHEMATICS, 200 SUNDECK
(FIG. 11.1)
200 Sundeck 13
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
ELECTRICAL SCHEMATICS, 200 SUNDECK (CONTINUED)
(FIG. 13.1)
SATELLITE STEREO DIAGRAM
DRAWING NO. 09-615
200 Sundeck12
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
ELECTRICAL SCHEMATICS, 200 SUNDECK (CONTINUED)
DC WIRING DIAGRAM (2 OF 2)
DRAWING NO. 09-603
(FIG. 12.1)
200 Sundeck 13
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
ELECTRICAL SCHEMATICS, 200 SUNDECK (CONTINUED)
(FIG. 13.1)
SATELLITE STEREO DIAGRAM
DRAWING NO. 09-615
200 Sundeck 15
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
WIRING HARNESS INSTALLATION, (1 OF 3)
DRAWING NO. 09-875
(FIG. 15.1)
ELECTRICAL SCHEMATICS, 200 SUNDECK (CONTINUED)
WIRING HARNESS INSTALLATION, (2 OF 3)
DRAWING NO. 09-875
(FIG. 15.2)
200 Sundeck14
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
SMARTCRAFT SYSTEMS DIAGRAM
DRAWING NO. 09-710
(FIG. 14.1)
ELECTRICAL SCHEMATICS, 200 SUNDECK (CONTINUED)
200 Sundeck 15
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
WIRING HARNESS INSTALLATION, (1 OF 3)
DRAWING NO. 09-875
(FIG. 15.1)
ELECTRICAL SCHEMATICS, 200 SUNDECK (CONTINUED)
WIRING HARNESS INSTALLATION, (2 OF 3)
DRAWING NO. 09-875
(FIG. 15.2)
Index i
200 Sundeck
INDEX
A
Anchor Lights ...............................................................8
C
Canvas.........................................................................9
Clearances ..................................................................4
Cleats ..........................................................................8
D
Deck Layout .................................................................7
Dimensions .................................................................. 4
E
Electrical Schematics ................................................10
F
Fuel System .................................................................8
G
Gauge Layout ..............................................................6
H
Helm Layout.................................................................6
N
Navigation Lights .........................................................8
P
Passenger Locations ...................................................1
S
Safety Label Locations ................................................ 2
Switch Layout .............................................................. 6
T
Through-Hull Cutouts ..................................................5
Trailer Trim Switch ........................................................ 9
W
Water Sports Tower ................................................... 10
200 Sundeck16
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
WIRE HARNESS INSTALLATION, (3 OF 3)
DRAWING NO. 09-875
(FIG. 16.1)
ELECTRICAL SCHEMATICS, 200 SUNDECK (CONTINUED)
Index i
200 Sundeck
INDEX
A
Anchor Lights ...............................................................8
C
Canvas.........................................................................9
Clearances ..................................................................4
Cleats ..........................................................................8
D
Deck Layout .................................................................7
Dimensions .................................................................. 4
E
Electrical Schematics ................................................10
F
Fuel System .................................................................8
G
Gauge Layout ..............................................................6
H
Helm Layout.................................................................6
N
Navigation Lights .........................................................8
P
Passenger Locations ...................................................1
S
Safety Label Locations ................................................ 2
Switch Layout .............................................................. 6
T
Through-Hull Cutouts ..................................................5
Trailer Trim Switch ........................................................ 9
W
Water Sports Tower ................................................... 10
THIS PAGE LEFT INTENTIONALLY BLANK
Manual Part Number: MRP 1902268
Loading...
Buy Points How it Works FAQ Contact Us Questions and Suggestions Privacy Policy Cookie Policy Terms of Use