Schneider Electric MA4D-хххх-ххх, F4D-хххх-ххх, S4D-хххх-ххх Installation Instructions
Installation Instructions
Specifications
Actuator Inputs
Control Signal
Power Input
Connections
Actuator Outputs
Electrical
Position Feedback Voltage
(proportional or floating only)
Mechanical
Timing
Travel
Manual Override
See Table-1 thru 4 for actuator mod-
els and control types.
See Table-1 thru 4. All 24 Vac circuits
are Class 2. All circuits 30 Vac and
above are Class 1.
3 ft (91 cm) appliance or plenum ca-
bles, enclosure accepts 1/2” (13 mm)
conduit connector. For M20 Metric
conduit, use AM-756 adaptor.
For voltage ranges, the feedback
signal is the same range as the input
signal. The 4 to 20 mA current range
and floating actuators have a 2 to 10
Vdc feedback signal. The feedback
signal can supply up to 0.5 mA to
operate up to four additional slave
actuators.
See Figure-1 to Figure-4.
93° nominal.
Allows positioning of damper or valve
using manual crank.
Environment
Ambient Temperature Limits
Shipping & Storage
Operating
Humidity
Location
Agency Listings
UL 873
CUL
European Community
Australia
-40 to 160°F (-40 to 71°C).
-22 to 140°F (-30 to 60°C).
15 to 95% RH, non-condensing.
NEMA 1. NEMA 2, UL Type 2 (IEC
IP54) with customer supplied water
tight conduit connectors. Enclosure is
air plenum rated.
Underwriters Laboratories (File
#E9429 Category Temperature-Indi-
cating and Regulating Equipment).
UL Listed for use in Canada by
Underwriters Laboratories. Canadian
Standards C22.2 No. 24-93.
EMC Directive (89/336/EEC). Low
Voltage Directive (72/23/EEC). This
product fits in Installation Category
(Overvoltage Category) II per EN
61010-1.
This product meets requirements to
bear the RCM according to the terms
specified by the Communications
Authority under the Radiocommuni-
cations Act 1992.
RA/DA Jumper
Permits reverse acting/direct acting
control (MS4D models only).
Table 1. 30 in-lb (3.4 N-m) Spring Return CCW Actuators (Viewed from cover side)
Part Number Control Signal Voltage Wiring System
50/60 Hz
VA W W
MA4D-7033-000
MA4D-7033-100 Plenum Cable
2
MA4D-7030-000
Position
SPST
MA4D-7031-000
24 VAC
+/-20%
or 20-30
Vdc
120 Vac ±
10%
50/60 Hz
230 Va ±
10%
Appliance Wire
5.1 3.6 0.14 1.3
7.8 5.0 — 2.5
Appliance Wire
7.2 5.2 — 2.4
50/60 Hz
MF4D-7033-000
MF4D-7033-100 Plenum Cable
MS4D-7033-000
MS4D-7033-100 Plenum Cable
MS4D-7033-020
MS4D-7033-120 Plenum Cable
MS4D-7033-030
MS4D-7033-130 Plenum Cable
MS4D-7033-050
MS4D-7033-150 Plenum Cable
MS4D-7033-060
MS4D-7033-160 Plenum Cable
a Timing was measured with no load applied to actuator.
b 4 to 20 mAdc with field-installed 500 ohm resistor.
Floating
2 to 10 Vdcb
Proportional
0 to 3 Vdc
Proportional
6 to 9 Vdc
Proportional
0 to 10 Vdc
Proportional
4 to 20 mAdc
Proportional
24 Vac
+/-20%
or 20-30
Vdc
Appliance Wire
Appliance Wire
Appliance Wire
Appliance Wire
Appliance Wire
Appliance Wire
6.8 4.2 0.15 1.9
6.1 3.4 0.12 1.4
Actuator Power Input
Running Holding
DC
50/60 Hz
Amps
Approximate Timinga in
Sec. @ 70 °F (21 °C)
Pow-
ered
Spring Return
(CCW)
56 23
85 21
November, 2018 tc © 2018 Schneider Elect ric. All r ights res erved. A ll trade marks are o wned by Schneider Ele ctric Ind ustries S AS or its af filiat ed companies.
Document Number: F-27170-7
Table 2. 30 in-lb (3.4 N-m) Spring Return CW Actuators (Viewed from cover side)
Part Number
Control
Signal
Voltage Wiring System
50/60 Hz
VA W W
MA4D-8033-000
MA4D-8033-100 Plenum Cable
MA4D-8030-000
2
Position
SPST
MA4D-8031-000
MF4D-8033-000
MF4D-8033-100 Plenum Cable
MS4D-8033-000
MS4D-8033-100 Plenum Cable
MS4D-8033-020
MS4D-8033-120 Plenum Cable
MS4D-8033-030
MS4D-8033-130 Plenum Cable
MS4D-8033-050
MS4D-8033-150 Plenum Cable
MS4D-8033-060
MS4D-8033-160 Plenum Cable
a Timing was measured with no load applied to actuator.
b 4 to 20 mAdc with field-installed 500 ohm resistor.
Floating
2 to 10 Vdcb
Proportional
0 to 3 Vdc
Proportional
6 to 9 Vdc
Proportional
0 to 10 Vdc
Proportional
4 to 20 mAdc
Proportional
24 VAC +/-20%
or 20-30 Vdc
120 Vac ± 10%
50/60 Hz
230 Va ± 10%
50/60 Hz
24 Vac +/-20%
or 20-30 Vdc
Appliance Wire
Appliance Wire
Appliance Wire
Appliance Wire
Appliance Wire
Appliance Wire
Appliance Wire
Appliance Wire
5.1 3.6 0.14 1.3
7.8 5.0 — 2.5
7.2 5.2 — 2.4
6.8 4.2 0.15 1.9
6.1 3.4 0.12 1.4
Actuator Power Input Approximate Timing
Running Holding
DC
50/60
Hz
Amps
in Sec. @ 70 °F (21
°C)
Pow-
ered
Spring Re-
turn (CW)
56 23
85 21
Installation Instructions
a
Table 3. Non-Spring Return 35 in-lb (4 N-m) Actuators.
Part Number
MF4D-6043-000
MF4D-6043-100 Plenum Cable
MS4D-6043-000
MS4D-6043-100 Plenum Cable
MS4D-6043-020
MS4D-6043-120 Plenum Cable
MS4D-6043-030
MS4D-6043-130 Plenum Cable
MS4D-6043-050
MS4D-6043-150 Plenum Cable
MS4D-6043-060
MS4D-6043-160 Plenum Cable
a Timing was measured with no load applied to actuator.
b 4 to 20 mAdc with field-installed 500 ohm resistor.
Control
Signal
Floating
2 to 10 Vdcb
Proportional
0 to 3 Vdc
Proportional
6 to 9 Vdc
Proportional
0 to 10 Vdc
Proportional
4 to 20 mAdc
Proportional
Voltage Wiring System
Appliance Wire
Appliance Wire
Appliance Wire
24 Vac +/-20%
or 20-30 Vdc
Appliance Wire
Appliance Wire
Appliance Wire
Actuator Power Input
Running Holding
50/60 Hz
VA W W
DC
Amps
4.4 2.7 0.1 1.7
4.2 2.2 0.08 1.2
50/60
Hz
Approximate Timinga
in Sec. @ 70 °F (21
°C)
85
© 2018 Schneider Elect ric. All r ights res erved. A ll trade marks are o wned by Schneider Ele ctric Ind ustries SAS or its af filiat ed companies. Novemb er, 2018 tc
Docume nt Number : F-27170-7
Installation Instructions
Table 4. Non-Spring Return 70 in-lb (8 N-m) Actuators.
Part Number
MF4D-6083-000
MF4D-6083-100 Plenum Cable
MS4D-6083-000
MS4D-6083-100 Plenum Cable
MS4D-6083-020
MS4D-6083-120 Plenum Cable
MS4D-6083-030
MS4D-6083-130 Plenum Cable
MS4D-6083-050
MS4D-6083-150 Plenum Cable
MS4D-6083-060
MS4D-6083-160 Plenum Cable
a Timing was measured with no load applied to actuator.
b 4 to 20 mAdc with field-installed 500 ohm resistor.
Control
Signal
Floating
2 to 10 Vdcb
Proportional
0 to 3 Vdc
Proportional
6 to 9 Vdc
Proportional
0 to 10 Vdc
Proportional
4 to 20 mAdc
Proportional
Voltage Wiring System
Appliance Wire
Appliance Wire
Appliance Wire
24 Vac +/-20%
or 20-30 Vdc
Appliance Wire
Appliance Wire
Appliance Wire
Actuator Power Input
Running Holding
50/60 Hz
VA W W
5.9 3.6 0.13 1.6
5.2 2.7 0.10 1.4
DC
Amps
50/60
Hz
Approximate Timing
in Sec. @ 70 °F (21
°C)
85
a
Ball Valve Close-Off Pressures: For close-off pressure ratings on Schneider Electric VB2000 ball valves, consult Schneider Electric VB2000 Ball Valve Assemblies Ball Valve Body/Linkage Selection Guide F-27086.
Accessories
AM-763 1/8” Hexcrank for manual override
AM-756 Metric Conduit Adapter M20 x 1.5 to 1/2” NPT
AM-771 Crank Arm and bracket kit
AM-772 Bracket for reverse mounting
AM-714 Weathershield Kit
MS4D-xxx3-xxx
AM-703 Input rescaling module, adjust signals to 2-10 Vac, zero and span adjust
AM-704 Interface, pulse width modulation (PWM)
AM-705 Positioner (NEMA 4 housing)
AM-706 Min and/or manual positioner for flush panel mount
AM-708 500 Ω resistor for 4 to 20 mA control signal
November, 2018 tc © 2018 Schneider Elect ric. All r ights res erved. A ll trade marks are o wned by Schneider Ele ctric Ind ustries S AS or its af filiat ed companies.
Document Number: F-27170-7
Loading...