Page 1
OWNER'S INSTRUCTIONS
MODEL:
RL22FC**
RL24FC**
ENGLISH
English
DA68-01530M
Please read all the safety precautions included in this manual prior to use
and retain this manual properly for future reference.
Please read through this manual before connecting to power and keep it
for future reference.
Any change relating to this manual will result in no additional notice due to
continuous improvement made on our products.
Register your product at www.samsung.com/global/register
www.samsung.com/global/register
,
Page 2
224/219
83/80
141/139
204/199
68/65
136/134
CONTENTS
PARTS DESCRIPTION......................................................2
SAFETY NOTES...............................................................3
PREPARATIONS BEFORE USE........................................4
INSTALLATION&SETUP...................................................5
STORING FOODS............................................................7
MAINTENANCE & CLEANING...........................................8
DISASSEMBLY OF ACCESSORIES...................................9
TROUBLE SHOOTING.....................................................11
TECHNICAL PARAMETERS & CIRCUITS DIAGRAM.........12
12
BRN
BLU
GRY
Y/GRN/
EARTH
BLK/WHT
GRY
Y/GRN/
THERMOSTAT
RED
HEATER SWITCH
SWITCH DOOR
GRY
LAMP
BLK/WHT
HEATER
O/L PROTECTOR/
RED
1
COMPRESSOR
SKY BLU
CAPACITOR
YEL YEL
2
3
PTC RELAY
Y/GRN/
This instruction includes three similar models of RL22FC**
and RL24FC**, where RL24FC** is dominated by this description.
* Representative Color:
S- Silver , W- White
Please read this manual and use it as instructed. The messages marked with
"Warning" and "Notes" were about safety and of high importance.
Please read it carefully and repeatedly.
WARNING
Which means it is possible to cause potential and severe damage
about dangerous issues if the instructions not followed.
NOTES
Which means it may cause slight damage or performance
failure if certain cases not avoided.
1
Page 3
PARTS DESCRIPTION
Product features
Mechanical control:the built-in temperature sensor controls the inside temperature more precisely.
Fi-free environmental protection: this appliance is the green product.
Reliable performance: seamless high efficient compactor of famous brand is used in this product
with excellent performance and high reliability.
Reasonable structure:the layout of reefer up and freezer down can reduce the cooling energy
and power loss. The frequently used upper reefer can facilitate the access. The reefer shelf
is position adjustable with the volume.
Odour reservation: the freezer is drawer-structured to ease food storage and protect from odour mixing.
Flat back:the built-in condenser is easy to clean.
Attachment
TROUBLE SHOOTING
The front frame and side plate get hot
- The de-dew pipe is built in the frame to avoid dews condensing
on the frame. It will get hot when the appliance is running.
- The cooling assembly(condensor) is installed on both sides
of the frame.
Ice cracks are heard
- It is not a fault. When the appliance is initiated or closed,
poop will be heard due to sharp change of temperature which
cause uneven heat imposed on the interior parts
Name
Model
RL24FC**
RL22FC**
DRAWER-F
TRAY-VEG
COVER-VEG
GUARD-BOTTLE
3 1 1 2 1 1 2 1
3 1 1 2 1 1 2 1
Parts description (RL24FC** for example)
LAMP COVER
SHELF-R
COVER-VEG
TRAY-VEG
DRAWER-F
SHELF-R
TRAY- ICE
GUARD-EGG
LAMP SWITCH
TRAY-EGG
GUARD-BOTTLE
TRAY-ICETRAY-EGG GUARD-EGG
Frost or ice is found on the back
- The cooling pipes in the back will be under 0 when the appliance
is running. Frost or ice will be found on the back due to dense moisture.
- When the appliance is off, the frost will disappear automatically.
- Suggest to clean the appliance once per month.
- Foods and food container shall not lean closely against the back.
Streaming is heard
- It is not a fault. The sound is heard when the refrigerant flows.
Dews are condensed on the mid-ridge and the frame
- When the environmental humidity exceeds standard.
- Please wipe with the soft cloth.
Dews condensed in the vegetable compartment.
- When the door is left open for long time or
- The fluid food are not properly sealed.
Should your problems falls out of the above, please visit the designated
service center with the WARRANTY CERTIFICATE or contact Sumsung Technical
2
Help Center.
11
Page 4
TROUBLE SHOOTING
SAFETY NOTES
The appliance does not work.
- The Plug is not well connected.
- No power supply.
- Resart the appliance within 5 minutes
after power-off.
Nonstop working is incurred to the appliance.
- When the room temperature is high, or the
appliance is near heat or exposed in the sun.
- The door is opened frequently or well closed.
- The room has poor ventilation.
- The food is over stuffed, resulting in bad cooling.
The food in the refrigerator is frozen
-
The thermostat setting is too low.
- The foods contact the cooling source
in the back wall.
Noise is heard
- The appliance is not steadily placed.
- The appliance is too close to the wall.
- The exterior cooling pipes clash with
each other or with fridge wall.
- Something unexpected is behind or under.
- The motor will give out buzz when running.
- Items stored are not steadily placed.
WARNING
If the supply cord is damaged, it must be replaced by the
manufacturer or their service agent or a similar qualified
person in order to avoid any hazard.
The power supply should not be reconnected within 5
minutes to prevent the compressor being damaged.
Do not use combustible sprays,such as spray-paint or dopes, which will
probably give rise t o explosion.
Note: Do not expose the appliance in the outdoor and rain.
Don't let children play with or hang on the unit as this
will damage the unit or hurt children.
Keep the appliance back out of water to avoid impairing insulation.
A lump input of hot items or frequent or long-lasting opening will
raise the inside temperature, it is generally recover in 24 hours;
Poor door closing or a lump input of hot items or frequent or
long-lasting opening may result in temperature indicator flash,
poor cooling effect or long work;
10
The freezer generates poor effect.
- The door is not well closed.
- The door gasket is damaged or distored or
poorly sealed.
- The appliance is near heat or exposed in
Sun.
- The appliance is not well aired.
The defrost water outflows inside.
- The water outlet is block.
- Please get rid of the block with a
plug or similar tools.
Do not store inflammable or explosive hazardous items and strong acid
or alkaline corrosives chemicals, such as butane,aether,benzene,
vitriol,gasoline,alcohol etc. Do not put the bottled fluid foods in
the freezer as that will cause bottle cracks.
Do not continue using the malfunctional or damaged appliance.
Please cut off the power and call the local service center.
The appliance must be installation that the plug should be easily
accessible after installation.
WARNING
If there is gas leaking, please shut the gas valve and
change the room air before pulling out the power plug
because unplugging will accompany sparks that will
probably give rise to accidents.
3
Page 5
SAFETY NOTES
DISASSEMBLY OF ACCESSORIES
NOTES
Please refer to the model and serial number to compare the products;
Before connecting to power, please verify the power supply voltage and the rated voltage of the
appliance.The rated voltage allowance is 220-240V. For safety purpose, the wires which can
bear over 10A current must be used.
After using the freezer, do close the drawer before you shut the freezer door.
During the hot weather in Summer, the appliance will run a longer time, the ice will
be found in the back wall and the freezer temperature is low. The above is normal.
Alert
The refrigarant leaked from the pipe may catch fire or hurt your eyes. If refrigerant leakage occurs,
please keep away the fire or potential fire source, and keep the room aired for several minutes.
- To avoid the combustible gas composed of the refrigerant leaked from the cooling circuit and the air,
please select the room size to accommodate t he appliance according to the refrigerant quantity.
The room size shall be calculated as per the criterion of 8g R600a per square metres.
For details of the refrigerant quantity, please refer to the manual.
- Do not start the appliance that has any damage. If any problems, please contact the dealer or
service centre.
The cooling effects originates from refrigerant that is filled through
special process. Please ensure the pipes in the rear are intact.
This appliance adopts R600a refrigerant which is combustible.
During transportation and installation, please handle the appliance carefully
to protect the cooling system from damage.
PREPARATIONS BEFORE USE
Basic preparations
1. In the initial use, please remove 2 tapes from both sides of the
glass shelf and embed two side tubers into the recess of the
inner gallbladder.
2. Clean the appliance with the wet wiper(add a few detergents
into the warm water).
Disassembly of accessories
Shelf-R
You may adjust the shelf position as per the container height.
Drawer-F
You may pull the drawer to the stopper and take it out tipsily.
Tray and COVER-VEG
Draw out the tray-veg and take it out when the cover is lifted.
Warning: During disassembling, do not force out the tray to
avoid the damage of the appliance.
TRAY-EGG & GUARD-BOTTLE
Lift and take out them.
TRAY-VEG.
The tray-veg can reserve the water and freshness of
fruits and vegetables because it is sealed to avoid
direct contact between cold air and vegetables.
Applicable to storage of vegetables and fruits.
TRAY COVER-VEG
TRAY-VEG
3. Place the appliance steadily and connect to the power in 1 hour.
4. After 2-3 hours cooling, you may store the foods to regulate the
appliance working.
* Suggest to put in the foods after 2-3 hours cooling.
Temperature control
The inside temperature is adjusted by the thermostat whose arrow points to the silk screen
of the temperature controller ("HIGH\MID\LOW"-indicates the inside temperature), where
stronger the thermostat shows, the inside temperature is lower. "OFF" means shut-down.
The user may switch the thermostat,which may point to"MID" normally as necessary.
You may switch the thermostat between"MID" and "LOW" in hot weather and between "MID"
and "HIGH" in cold weather. If a few foods need storing, you may switch to "LOW".
When the room temperature is under 10 ,please open the season switch.
4
TRAY-ICE
- Distribute the cold water or beverage into the clean tray-ice
and put them into the freezer.
- When getting the ice piece, just turn the ice tray but do not
turn it up and down.
WARNING
1.The glass partition is movable and heavy.Children are not allowed to move it.
2.The unsteadiness of the appliance will cause noise.
3.The first start needs a long time of about 3 hours as the room temperature
will fall to the setup temperature. The appliance will resume after shutdown.
4.For the foods or fluids that is absorbable, transferrable or odoriferous,
please use a seamless container to store.
9
Page 6
MAINTENANCE & CLEANING
Change the lamp
Interior parts
Dismantle all shelfs, door frames, trays, covers and drawers
and clean with a soft cloth that is soaked with water or medium
detergent (for bowl or chopstick wash).If detergent is used,
please clean with water first,then wipe with a piece of dry cloth.
Door gasket
If the door gasket contacts the oil or sauce etc.,it will be
impaired after a long time, especially for the gasket of the
door up and down.Make sure to cleanthe gasket carefully.
The recess shall be cleaned by the chopstick shrouded by
cotton piece.When embed the gasket, fit four corners first
and embed the gaskets section by section.
Defrost method
When the frost layer gets thick, it may impair the cooling effect. You may take out and pack
the foods. Pull out the power plug and wipe off the water with soft cloth when the frost layer
vanishes. Then connect to the power and restart the appliance to setup the temperature.
Generally once or twice defrost is required per year.
NOTES
1.Plug off the power first, then clean the freezer after defrost;
2.The best time to defrost is when the freezer is empty or half empty;
3.Do not use metal or sharp tools for defrost to prevent damage;
4.No electric heater is allowed for defrost;
Cleaning precautions
Pull out the plug from the socket before cleaning, the interval between
plug in and out shall be over 5 minutes;
No water is allowed in the lamp and PCB cover during cleaning;
Wipe with soft towel dipped over water or medium detergent, then clean
with dry cloth;
Do not use the detergent with abrasive(e.g. Toothpaste),acid,chemical
solvent(e.g.alochol) or putty agent.
NOTES
The following checks shall be made after maintenance:
Any chaps or scars are found on the power cord.
Plug in the socket reliably
The power plug gets hot or other accidents.
Plug out the power cord.
Screw off the lamp cover, then hold the cover and pull left to remove the cover.
Turn off the bulb counterclockwise.
Turn on the bulb clockwise.
Push the right side of the lamp cover into the left recess of the temperature
controller, then turn on the screws.
Bulb parameters: ~220V-240V,25W,E14
INSTALLATION & SETUP
Place the refrigerator
1.Remove the foot cushion prior to use.
2.If the appliance is placed unsteadily, you may adjust the front leg in the bottom to stablize
the appliance (lift by turning left).There is a adjust hole in the front leg.You may adjust it
with a crosshead screwdriver (see right figure).
3.The ground under the appliance shall be flat and solid.
Otherwise noise and oscillation will arise.
The noise will grow stronger if the
appliance is put on the soft ground;
Please put a solid plate on the blanket,
to avoid miscolor or heat blocking;
To stablize the appliance, please leave
the foot contacting the ground closely and
keep the appliance leaning back for easy closing of the door.;
Packaging & handling
1.Unpacking, repacking and handling
Do remember where the packages are during unpacking and examining.
The products can not be transported until they are repacked after examining.
2.Do not hold the door during transportation.
3.Avoid clash or acute shaking during handling.
WARNING
8
- Keep ventilation openings, in the appliance enclosure or in the build-in structure,
clear of obstruction.
- Do not use mechanical devices or other means to accelerate the defrosting process,
other than those recommended by the manufacturer.
- Do not damage the refrigerant circuit.
- Do not use electrical appliances inside the food storage compartments of the
appliance, unless they are of the type recommended by the manufacturer.
4.Vertical handling to avoid clash
Do not position the appliance reversely or horizontally.
If tilting is required, the tilting angle shall be less than45
Please handle the appliance as per the instructions to
prevent from noise or some other problems.
45
5
Page 7
INSTALLATION & SETUP
300mm above
STORING FOODS
55mm above
55mm above
Leave 55~100mm between the appliance back and the wall.
At least 300mm shall be left empty over the appliance.
The appliance shall not be place where there is moisture
to avoid mental rust and insulation impairment;
If the appliance is placed near the pool or in the basement,
a overload protector is required except for the earth wire.
If the appliance is soaked due to the natural disaster
(such as rainstorm or accidents), please have it repaired
by Sumsung service center before use.
The appliance shall be far away from heat source and direct
sunlight.
A separate socket for earth wire with 3 cores shall be used
and shall not be shared with other apparatus. For safety
purpose,please connect the earth wire that is in place on
the earthing pole of the socket.The wire shall not be
connected to the water pipe, gas pipeline, telephone line
and lightning rod etc.
Make sure not to press the power cord.
No appliances such as microwave, electric cooker and
transformer are allowed on the top of the appliance.
The foods shall be packed with the freshness reservation bag
(film) or put in the sealed container to avoid air-dry
or mix-odour.
Hot foods or beverages shall be cooled to the room temperature
to save power consumption.
The cooked and raw foods shall be placed separately.
The foods shall be kept loose to leave enough space for air cycle.
Note: 1. Do not put the foods near the sensor.
2. The foods and containers shall not lean against the
back wall.
Store foods in smaller portions.
Better clean the washable foods,such as fruits and vegetables
before storage.
NOTES
6
Before you discard the appliance, please scrap the gasket.
The scraped items shall be properly treated or disposed
of by professionals. Do not discard the scraps anywhere
to avoid damages to the environment or other risks.
1.Keep the appliance out of water because it will get rusty and problem.
Please wipe the electric parts such as switch with dry cloth.
2.Do not use wash powder,alkaline detergent,brush,gas,thinner,alochol,
coal oil, acid and boiled water that may hurt the face or plastic items.
3.Do not use chemical wiper that may hurt the face or plastic items.
4.The oiled plastics items is easy to get aged, wipe off the oil soon.
The fruits and vegetables shall be stored in the vegetable
compartment to reserve the water and freshness.
WARNING
The tropic fruits such as banana and pineapple are not suitable.
Do not store the items that has strict storage standard, such as
blood serum, bacterin and academic materials.
Recommendation: If you need a large quantity of foods to be stored,
ice making or fast cooling, please take out the freezer drawer and
freeze the foods directly on the evaporator partition.
NOTES
Do not touch the freezer evaporator with wet hands to avoid the water ices
on your hands.
7
Loading...