Page 1
1. Locate the monitor on the table
with face down.
2. Loose the snaps of Hinge cap
through the slot of Cover Rear.
3. Remove the hinge cap.
CONFIDENTIAL
MO15E* 3-1
3 Disassembly and Reassembly
This section of the service manual describes the disassembly and reassembly procedures for the
MO15E* monitors.
WARNING: This monitor contains electrostatically sensitive devices. Use caution when handling
these components.
3-1 Disassembly
Cautions:1. Disconnect the monitor from the power source before disassembly.
2. Follow these directions carefully; never use metal instruments to pry apart the cabinet.
3-1-1 Main Body Disassembly
Page 2
3 Disassembly and Reassembly
3-2 MO15E*
CONFIDENTIAL
4. Remove 2 flat head screws on
the hinge mounting.
Do not remove the screw for
cable clamp.
5. Disconnect the stand cable from
socket and remove stand
assembly.
6. Remove 2 screws of Cover Rear.
7. Turn the monitor for front-side
up.
8. Remove the Cover Front by
fulling the center area of bezel
and side area in sequence.
If the side area is not loosed
easily, open the snap using ‘-’
driver at the corner of slot of
Cover Rear.
Page 3
3 Disassembly and Reassembly
MO15E* 3-3
CONFIDENTIAL
9. Remove the 4 screws of panel.
10. Turn the monitor for face down
and open the Cover Rear from
top area.
11. Disconnect the function cable
from the connector of main
board.
12. Remove the 3 screws of shield.
Page 4
CONFIDENTIAL
3 Disassembly and Reassembly
3-4 MO15E*
1. After confirm there is nothing
on the disk
Turn the LCD module over
and put it on a flat desk set to
the ground.
3-2 Replacement Order of Lamp Assemblies
2. Remove the screw and slide
the lamp unit.
3. Please take out the lamp
unit from the LCD
module.
Page 5
CONFIDENTIAL
3 Disassembly and Reassembly
MO15E* 3-5
4. Please fix the new lamp
units on the LCD module :
opposite process 2 and 3
* Replacement of lamp unit should be done at the power off state and recommanded clean
bench condition.
3-3 Reassembly
Reassembly procedures are in the reverse order of Disassembly procedures.
Page 6
CONFIDENTIAL
Memo
3 Disassembly and Reassembly
3-6 MO15E*
Loading...