Samsung M2513 Service Manual

GSM TELEPHONE

GT-M2513

GSM TELEPHONE

CONTENTS

Safety Precautions

1.

Specification

2.

Product Function

3.

Array course control

4.

Exploded View and Parts list

5.

MAIN Electrical Parts List

6.

Block Diagrams

7.

PCB Diagrams

8.

Chart of Troubleshooting

9.

Reference data

10.

Disassembly and Assembly

11. Instructions

Safety Precautions

1.

Repair Precaution

1-1.

Repair in Shield Box, during detailed tuning.

●

Take specially care of tuning or test,

because specipicty of cellular phone is sensitive for surrounding interference(RF noise).

Be careful to useakind of magnetic object or tool,

●

because performance of parts is damaged by the influence of manetic force.

Surely useastandard screwdriver when you disassemble this product,

●

otherwise screw will be worn away.

Useathicken twisted wire when you measure level.

●

thicken twisted wire has low resistance, therefore error of measurement is few.

A

Repair after separate Test Pack and Set because for short danger(for example an

●

overcurrent and furious flames of parts etc) when you repair board in condition of

connecting Test Pack and tuning on.

Take specially care of soldering, because Land of PCB is small and weak in heat.

●

Surely tune on/off while using AC power plug, becausearepair of battery charger is

●

dangerous when tuning ON/OFF PBA and Connector after disassembing charger.

Don't use as you pleases after change other material than replacement registered on SEC

●

System.

Otherwise engineer in charge isn't charged with problem that you don't keep this rules.

1-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Safety Precautions

ESD(Electrostatically Sensitive Devices) Precaution

1-2.

Several semiconductor may be damaged easilly by static electricity. Such parts are called by

ESD(Electrostatically Sensitive Devices), for example IC,BGA chip etc. Read Precaution below.

You can prevent from ESD damage by static electricity.

Remove static electricity remained your body before you touch semiconductor or parts with

●

semiconductor. There are ways that you touch an earthed place or wear static electricity

prevention string on wrist.

Use earthed soldering steel when you connect or disconnect ESD.

●

Use soldering removing tool to break static electricity.,otherwise ESD will be damaged by

●

static electricity.

Don't unpack until you set up ESD on product. Because most of ESD are packed by box

●

and aluminum plate to have conductive power,they are prevented from static electricity.

You must maintain electric contact between ESD and place due to be set up until ESD is

●

connected completely to the proper place oracircuit board.

1-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Specification

2.

GSM General Specification

2-1.

GSM850 EGSM900 DCS1800 PCS1900

Freq.

Band[MHz]

Uplink/Downlin

824~849 869~894

k

880~915 925~960

1710~1785 1805~1880

1850~1910 1930~1990

ARFCN range 128~251

0~124 &

975~1023

512~885 512~810

Tx/Rx spacing 45MHz 45MHz 95MHz 80MHz

Mod. Bit rate/

Bit Period

Time Slot

Period/Frame

Period

270.833kbps

3.692us

576.9us

4.615ms

270.833kbps

3.692us

576.9us

4.615ms

270.833kbps

3.692us

576.9us

4.615ms

270.833kbps

3.692us

576.9us

4.615ms

Modulation 0.3GMSK 0.3GMSK 0.3GMSK 0.3GMSK

MS Power 33dBm~5dBm 33dBm~-5dBm 30dBm~0dBm 30dBm~0dBm

Power Class 5pcl ~ 19pcl 0

pcl

~15

pcl

0

pcl

~15

pcl

0

pcl

~15

Sensitivity -102dBm -102dBm -100dBm -100dBm

TDMA Mux 8 8 8 8

pcl

Cell Radius 35Km 35Km 2Km 2Km

2-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

GSM Tx Power Class

2-2.

Specification

TX Power

control

level

5 33±2

6 31±2

7 29±2

8 27±2

9 25±2

10 23±2

11 21±2

GSM

850

GSM900

dBm

TX Power

control

level

0 30±3

1 28±3

2 26±3

3 24±3

4 22±3

5 20±3

6 18±3

DCS1800

dBm

TX Power

control

level

0 30±3

1 28±3

2 26±3

3 24±3

4 22±3

5 20±3

6 18±3

PCS1800

dBm

12 19±2

13 17±2

14 15±2

15 13±2

16 11±3

17 9±3

18 7±3

19 5±3

dBm

7 16±3

8 14±3

9 12±4

10 10±4

11 8±4

12 6±4

13 4±4

14 2±5

15 0±5

dBm

7 16±3

8 14±3

9 12±4

10 10±4

11 8±4

12 6±4

13 4±4

14 2±5

15 0±5

dBm

2-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Product Function

3.

Main Function

EDGE/GPRS Function Supporting slide phone for Music

-

Mega Pixel, Digital zoom(x2) Camera

-1.3

- 262K

Internal memory:15MB, External memory: up to8GB

-

Bluetooth v2.0, USB v2.0 FS

-

-3.5Ø4

FM radio with RDS

-

Built in Large Speaker(Mono,17

-

Music Library, DISC UI,Find Music, DNSe

-

Color QCIF TFT LCD

Pin Earjack

Ø)

3-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

4.

Software Adjustments

4-1.

Test Jig(GH

Test Cable(GH39-

99-36900

01290

A)

A) RF Test Cable(GH39-00985A)

RF Test Cable(GH99-38251A)

4-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

Software Downloading

4-2.

4-2-1.

•

4-2-2.

•

Downloading Binary Files

binary files for downloading M2510

2

CODE_M251

.

CSC_M251

.

3JVIE3.s3

3JVIE3.csc

Pre-requsite for Downloading

Downloader Program:(Optimay Flash v4.17 for optiflash.exe

GT- M251

JIG BOX

Test Cable

Serial Cable

Binary files

3Mobile Phone

)

4-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

4-2-3.

1

2.

S/W Downloader Program

Before downloading program, insert into micro usb in the phone with pressing

button

*

Load the binary download program by executing the“Optimay Flash v4.17 for optiflash.exe

”.

4-3

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

Select the Specify Hardware Platfom and flash option(recommand default), Baud Rate and

3.

Mode.and choice Com port number that finded in the Microsoft Management Console.Check

buttom writting'Earse all unused Regions'

4-4

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Selectthecodefileswhat you want to download

4.

Array course control

4-5

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

Select the csc fileswhat you want to download

5.

4-6

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

press the Flash button and than write"yes" in the box and press ok button

6.

Array course control

.

4-7

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

When downloading is complete,

7.

Can see text " All is well"

4-8

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Exploded View and Parts List

5.

5-1.

QFU01

QMO01

QLC01

Cellular phone Exploded View

QMW01

QCR97

QCR67

QMP01

QKP02

QME02

QSP01

QCA01

QFR01

QKP01

QME01

QSH01

QAN02

QPC01

QFL01

QCR03

QSC01

QHI02

QHI01

QVO01 QRF06

QCK01

QRE01

QCR67

QBA01

QBA00

5-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Exploded View and Parts List

5-2.

Cellular phone Parts list

Design LOC Description SEC CODE

QAN02 INTENNA-GT_M2510 GH42-01997A

QBA00 ASSY COVER-BATTERY GH98-12472A

QBA01 INNER BATTERY PACK-800MAH,BLK,UNI,MAIN GH43-03257A

QCA01 ASSY CAMERA-GT_M2510

QCR03 SCREW-MACHINE

QCR67 SCREW-MACHINE

QCR97 SCREW-MACHINE

1.3M

GH96-03776A

6001-001811

6001-002083

6001-002262

QFR01 ASSY CASE-SLIDE FRONT GH98-12470A

QKP01 ASSY KEYPAD-MAIN(IB/XEN) GH98-12477A

QKP02 ASSY KEYPAD-SUB(IB/XEN) GH98-12476A

QME01 DOME SHEET-GT_M2510 MAIN GH59-07319A

QMO01 MODULE-GT_M2510 RCV+MOT GH59-07478A

QMP01 ASSY PBA MAIN-GT-M2513 GH92-05848A

QPC01 ASSY ETC-GT_M2510 SLIDE FPCB GH59-07321A

QSC01 TAPE-SCREW CAP GH74-44759A

QSH01 ASSY COVER-SHIELD BRACKET GH98-13676A

QSP01 MODULE-GT_M2510 SPK GH59-07289A

QFU01 ASSY CASE-SLIDE UPPER GH98-12469A

QMW01 ASSY COVER-MAIN WINDOW GH98-12473A

QFL01 ASSY CASE-SLIDE LOWER GH98-12474A

QHI01 ASSY HINGE-BASE GH98-12475A

QHI02 ASSY HINGE-BAND SPRING GH98-13243A

QLC01 ELA MODULE-GT_M2510 GH96-03783A

QME02 DOME SHEET-GT_M2510 SUB GH59-07320A

QRE01 ASSY CASE-REAR GH98-12471A

QRF06 PMO COVER-MIC USB GH72-53129A

QVO01 PMO KEY-VOLUME GH72-53130A

QCK01 PMO KEY-CAMERA GH72-53131A

5-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

MAIN Electrical Parts List

6.

Design LOC SEC CODE Discription

ZD505

ZD601,ZD603

ZD500

ZD607,ZD608

ZD504,ZD600,ZD602

ZD501

LED600,LED601,LED602

LED603,LED604,LED605

U301

U201

U502

U501

U302

U401

PAM100

U402,U405

U600

U404

U300

U403

U200

U100

RFT100

UCD300

UCP200

TH300

V600,VR200,VR201

R416,R417

R207,R306,R418,R427

R429,R509,R605,R614

R615,R616

R100,R203

R613

R426,R600,R602

R202,R505,R506

R307

R208,R209

R301,R309,R503

R104,R211,R218,R310

R315

R308

R311,R415,R428,R507

R510

0403-001547

0406-001241

0406-001256

0406-001267

0406-001288

0406-001369

0601-002652

0801-002995

0801-003024

0801-003065

1001-001585

1009-001035

1201-002864

1201-002896

1202-001068

1203-004291

1203-005298

1203-005658

1204-002924

1205-003409

1205-003517

1205-003563

1205-003650

1205-003749

1404-001165

1405-001082

2007-000137

2007-000138

2007-000139

2007-000140

2007-000141

2007-000143

2007-000144

2007-000147

2007-000148

2007-000157

2007-000159

2007-000162

DIODE-ZENER

DIODE-TVS

LED

IC

THERMISTOR

VARISTOR

R-CHIP

6-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

Design LOC SEC CODE Discription

R412

R604

R424,R425,R432,R434

R607,R608,R609,R610

R611,R612

R224,R409

R228,R229

R206

R410

R400,R401

R226,R227

R406,R407

R102,R200

R305

R419

R300

R302

R508

R420

R433

R212,R213,R214,R215

R216,R217,R219,R221

R222,R223,R225,R431

R422

R101

R603

C110,C115,C418

C126,C131,C210,C305

C323,C324,C325

C327,C328

C125,C408,C423,C427

C600

C306

C102,C400,C401,C425

C500,C501,C503,C605

C604

C101,C334,C607

C310

C426,C429

C117

C124

2007-000165

2007-000168

2007-000170

2007-000172

2007-000242

2007-000758

2007-000775

2007-001119

2007-001284

2007-001292

2007-002965

2007-003015

2007-007148

2007-007155

2007-007308

2007-007314

2007-007480

2007-007592

2007-007943

2007-008045

2007-008486

2007-008516

2007-008811

2203-000233

2203-000254

2203-000278

2203-000386

2203-000425

2203-000438

2203-000812

2203-000940

2203-000995

2203-001124

2203-001153

2203-002668

2203-002709

R-CHIP

C-CERAMIC,CHIP

R108

2203-005053

C-CERAMIC,CHIP

6-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Design LOC SEC CODE Discription

C133

C104

C132

C118,C134,C135

C301,C302,C303,C308

C315,C336,C421,C504

C406,C424

C119,C120,C122,C123

C121

C410,C411

C100,C200,C201,C203

C204,C205,C206,C208

C209,C215,C217,C218

C304,C330,C337,C416

C417

C321,C428

C111,C404,C405,C419

C420

C307

C116,C326,C329,C338

C340,C341,C342,C343

C413,C422,C505,C507

C608,C609

C312,C314,C316,C320

C414,C415,C602,C610

C332

C344,C412

C112

C109,C127,C128,C212

C309,C339,C611,C612

C502

C333

C319

C113,C402

C322

TA400

TA501

TA500

TA502

L503

L109,L112,L114,L116

2203-005057

2203-005234

2203-005281

2203-005288

2203-005482

2203-005483

2203-005682

2203-005736

2203-006047

2203-006048

2203-006257

2203-006260

2203-006348

2203-006399

2203-006562

2203-006824

2203-006838

2203-006839

2203-006872

2203-006901

2203-007133

2203-007147

2203-007279

2203-007317

2404-001377

2404-001381

2404-001474

2404-001496

2703-001513

2703-001734

Main Electrical Parts List

C-CERAMIC,CHIP

C-TA,CHIP

INDUCTOR-SMD

L101

2703-001737

INDUCTOR-SMD

6-3

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

Design LOC SEC CODE Discription

L111,L113

L119

L115

L105,L106

L103,L104,L110,L118

L117

L107,L108

L301

OSC300

OSC100

F603,F604

F600,F601

F100

F101

F102

MIC400

L302,L604

L504

L402,L403

L406,L606

L300

L407

L408,L500,L501,L502

TAC600,TAC601,TAC602

RFS100

CD600

SIM600

HDC601

HDC600

BTC500

IFC500

EAR500

BAT300

Please consult the GSPN website (Samsung Portal) for the most recent version of the

2703-001749

2703-001990

2703-002200

2703-002203

2703-002204

2703-002268

2703-002369

2703-003297

2801-004339

2801-004683

2901-001469

2901-001547

2904-001862

2904-001863

2909-001283

3003-001136

3301-001342

3301-001534

3301-001729

3301-001812

3301-001879

3301-001912

3301-001917

3404-001152

3705-001503

3709-001394

3709-001447

3711-005345

3711-006028

3711-006808

3722-002871

3722-002913

4302-001130

INDUCTOR-SMD

CRYSTAL-UNIT

FILTER-EMI SMD

FILTER-SAW

FILTER-DUPLEXER

MIC-CONDENSOR

CORE-FERRITE BEAD

SWITCH-TACT

CONNECTOR-COAXIAL

CONNECTOR-CARD EDGE

CONNECTOR-HEADER

JACK-PHONE

BATTERY

product's part list.

6-4

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Block Diagrams

7.

7-1.

Block Diagram

Bluetooth

Filter

PLL

DSP

Core

OCTL

Frame

Scheduler

A5

Cipher

DigRF

Serial Data

Interface

SIU

DSIUC

26MHz

RF Transceiver

(PMB6271)

Analog

Compatibility

Block(SCU)

DSIU

Crystal

TX Module

(SKY77531)

Power

Ramping

Control

DIGU

AFC

Audio

Mxing

Routing &

conversion

Audio AMP

Memory

USB

Charger IC

Key Pad

LCD

Camera

Other

Blocks

ARM7

Subsystem

Reference

clock

Swtch

1.26V

ASIU

Power

Sequence

Logic

RTC

SIM Logic Level

Translation

9-Channel ADC

Battery

Charger

Ringer Driver

Vibrator Driver

LED Driver

Accessory Supply

LDOs

Thermal Protection

& UVLO

-32KHz Ring Oscillator

FM Radio

SIM Card

7-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization