Samsung CA17K, CA17J Service manual
COLOR MONITOR
CA17K*
CA17J*
Manual
SERVICE
COLOR MONITOR CONTENTS
1. Precautions
2. Product Specifications
3. Disassembly & Reassembly
4. Alignment & Adjustments
5. Troubleshooting
6. Exploded View & Parts List
7. Electrical Parts List
8. Block Diagram
9. Wiring Diagram
10. Schematic Diagrams
CONFIDENTIAL
CA17K*/CA17J* 1-1
WARNINGS
1. For continued safety, do not attempt to modify the
circuit board.
2. Disconnect the AC power before servicing.
3. When the chassis is operating, semiconductor
heatsinks are potential shock hazards.
1-1-1 Servicing the High Voltage and CRT :
WARNING:A high voltage adjusted to the wrong
value may cause excessive X-ray
emissions.
1. When servicing the high voltage system, remove
the static charge by connecting a 10 kohm resistor
in series with an insulated wire (such as a test
probe) between the chassis and the anode lead.
2. When troubleshooting a monitor with excessively
HV, avoid being unnecessarily close to the monitor.
Do not operate the monitor for longer than is
necessary to locate the cause of excessive voltage.
3. High voltage should always be kept at the rated
value, no higher. Only when high voltage is
excessive are X-rays capable of penetrating the shell
of the CRT, including the lead in glass material.
Operation at high voltages may also cause failure of
the CRT or high voltage circuitry.
4. When the HV regulator is operating properly, there
is no possibility of an X-ray problem. Make sure the
HV does not exceed its specified value and that it is
regulating correctly.
5. The CRT is especially designed to prohibit
X-ray emissions. To ensure continued X-ray
protection, replace the CRT only with one that is
the same or equivalent type as the original.
6. Handle the CRT only when wearing shatterproof
goggles and after completely discharging the high
voltage anode.
7. Do not lift the CRT by the neck.
1-1-2 Fire and Shock Hazard :
Before returning the monitor to the user, perform the
following safety checks:
1. Inspect each lead dress to make certain that the
leads are not pinched or that hardware is not
lodged between the chassis and other metal parts in
the monitor.
2. Inspect all protective devices such as nonmetallic
control knobs, insulating materials, cabinet backs,
adjustment and compartment covers or shields,
isolation resistor-capacitor networks, mechanical
insulators, etc.
3. Leakage Current Hot Check (Figure 1-1):
WARNING: Do not use an isolation transformer during
this test.
Use a leakage current tester or a metering system
that complies with American National Standards
Institute (ANSI C101.1, Leakage Current for
Appliances), and Underwriters Laboratories (UL
Publication UL1410, 59.7).
4. With the unit completely reassembled, plug the AC
line cord directly into a 120V AC outlet. With the
unit’s AC switch first in the ON position and then
OFF, measure the current between a known earth
ground (metal water pipe, conduit, etc.) and all
exposed metal parts, including: metal cabinets,
screwheads and control shafts. The current
measured should not exceed 0.5 milliamp. Reverse
the power-plug prongs in the AC outlet and repeat
the test.
Figure 1-1. Leakage Current Test Circuit
1-1-3 Product Safety Notices
Some electrical and mechanical parts have special
safety-related characteristics which are often not
evident from visual inspection. The protection they give
may not be obtained by replacing them with
components rated for higher voltage, wattage, etc. Parts
that have special safety characteristics are identified by
on schematics and parts lists. A substitute
replacement that does not have the same safety
characteristics as the recommended replacement part
might create shock, fire and / or other hazards. Product
safety is under review continuously and new
instructions are issued whenever appropriate.
Components identified by on schematics and parts
lists must be sealed by a soldering iron after
replacement and adjustment.
CONFIDENTIAL
1 Precautio
ns
1-1 Safety Precautions
!
DEVICE
UNDER
TEST
TEST ALL
EXPOSED METAL
SURFACES
(READING SHOULD
NOT BE ABOVE 0.5mA)
LEAKAGE
CURRENT
TESTER
2-WIRE CORD
ALSO TEST WITH
PLUG REVERSED
(USING AC ADAPTER
PLUG AS REQUIRED)
EARTH
GROUND
CONFIDENTIAL
2 Product Specifications
2-1 Specifications
Picture Tube 17-Inch (43 cm): 16-inch (40.6 cm) viewable,
Flat-face, 90˚ Deflection, 0.20 mm (Horizontal) Dot pitch,
Silica coated with anti-electrostatic properties (TCO: Multilayer coating),
Medium-short persistence phosphor
Scanning Frequency Horizontal : 30 kHz ~ 70 kHz 30 kHz ~ 85 kHz
Vertical : 50 Hz ~ 160 Hz 50 Hz ~ 160 Hz
Display Colors Unlimited colors
Maximum Resolution Horizontal : 1280 Dots 1600 Dots
Vertical : 1024 Lines 1200 Lines
Input Video Signal Analog, 0.7 Vp-p positive at 75 Ω, internally terminated
Input Sync Signal Separate Sync: TTL level, positive/negative
Maximum Pixel Clock rate 110 MHz 185 MHz
Active Display Horizontal : 312 mm ± 4 mm, Vertical : 234 mm ± 4 mm
Input Voltage AC 90 ~ 264 Volts, 60 Hz or 50 Hz ± 3 Hz
Power Consumption 90 Watt (max) 100 Watt (max)
Dimensions (W x D x H) Unit ; 15.7 x 16.2 x 15.7 Inches (398 x 412 x 400 mm)
Carton ; 20.4 x 22.8 x 18.42 Inches (517 x 580 x 468 mm)
Weight (Net/Gross) 35.1 lbs (15.9kg) / 41.2 lbs (18.68kg)
Environmental Considerations Operating Temperature : 32°F ~ 104°F (0°C ~ 40°C)
Humidity : 10 % ~ 80 %
Storage Temperature : -4°F ~ 113°F (-20°C ~ 45°C)
Humidity : 5 % ~ 95 %
• Above models comply with SWEDAC (MPR II) recommendations for reduced electromagnetic fields.
• Designs and specifications are subject to change without prior notice.
Item
CA17K*/CA17J* 2-1
Description
CA17K* CA17J*
3-1-1 Before making Disassembly
1. Disconnect or power cord from the monitor.
2. With a pad beneath it, stand the monitor on its
front with the screen facing downward and
the base close to you.
3-1-2 Cabinet Disassembly
1. Remove the Stand from the monitor.
(Refer to Stand manual)
2. Remove 2 screws on the Rear cover.
3. Incline the monitor by lifting the rear of the
monitor.
4. Push the Opening jig each groove along the
Side of the monitor till it makes a “ttak”
sound. (2 grooves : Left and Right, Make sure
each snap is disengaged.)
5. Pull the Rear Cover up off the monitor.
CA17K*/CA17J* 3-1
CONFIDENTIAL
3 Disassembly and Reassembly
This section of the service manual describes the disassembly and reassembly procedures for the
CA17K*/CA17J* monitor.
WARNING: This monitor contains electrostatically sensitive devices. Use with caution when
handling these components.
3-1 Disassembly
Cautions:1. Disconnect the monitor from the power source before disassembly.
2. To remove the Rear Cover, you must use the special opening jig tool.
Figure 1
Figure 2
Figure 3
Figure 4
4-1-1 Before Making Adjustments
4-1-1 (a) ORIENTATION
When servicing, always face the monitor to the
east.
4-1-1 (b) WARM-UP TIME
The monitor must be on for 30 minutes before
starting alignment. Warm-up time is especially
critical in color temperature and white balance
adjustments.
4-1-1 (c) SIGNAL
Analog, 0.7 Vp-p positive at 75 ohm, internal
termination
Sync: Separate
(TTL level negative/positive)
4-1-1 (d) SCANNING FREQUENCY
Horizontal : 30 kHz to 70 kHz (Automatic)
CA17K*
: 30 kHz to 85 kHz (Automatic) CA17J*
Vertical : 50 Hz to 160 Hz (Automatic)
Unless otherwise specified, adjust at the
1024 x 768 mode (68 kHz/85 Hz),
Refer to Table 2-1 on page 2-3.
4-1-2 Required Equipment
The following equipment may be necessary for
adjustment procedures:
4-1-2 (a) DISPLAY CONTROL ADJUSTMENT
1. Non-metallic (–) screwdriver:
1.5, 2.5, 3 mm
2. Non-metallic (+) screwdriver:
1.5, 2.5, 3 mm
3. Digital Multimeter (DMM), or
Digital Voltmeter
4. Signal generator, or
DM200 software
5. Personal computer
4-1-2 (b) COLOR ADJUSTMENTS
1. All equipment listed in 4-1-2 (a), above
2. Color analyzer, or any luminance
measurement equipment
CA17K*/CA17J* 4-1
4 Alignment and Adjustments
This section of the service manual explains how to make permanent adjustments to the monitor. Directions
are given for adjustments using the monitor Interface Board Ver. 2.0 and software (Softjig).
4-1 Adjustment Conditions
Caution: Changes made without the Softjig are saved only to the user mode settings. As such, the
settings are not permanently stored and may be inadvertently deleted by the user.
CONFIDENTIAL
CONFIDENTIAL
CA17K*/CA17J* 5-1
5 Troubleshooting
5-1 Parts Level Troubleshooting
Notes: Check the following circuits.
• No raster appears: Power circuit, Horizontal output circuit.
• High voltage develops but no raster appears: Video output circuits.
• High voltage does not develop: Horizontal output circuits.
5-1-1 No Power Supply
Chirping noise exists?
Check and replace IC601.
Check and replace D601 and FH1
Done.
No
Yes
Repeating start?
Check and replace D606.
No
Yes
IC601 Pin 1 waveform is right?
Check and replace D614, IC601,
Q602, and ZD601.
Yes
No
C622 Voltage is 13 V ± 0.5V?
Check and replace IC201, IC301,
IC401, Q402, and Q404.
Yes
Yes
No
Operate normally?
Replace Main board.
Verify voltages.
No
WAVEFORMS
1
1
100 V (IC601, #1)
CH1 P-P = 100 V CH1 RMS = 350.2 V
CONFIDENTIAL
CA17K*/CA17J* 6-1
6 Exploded View and Parts List
- BH94-00704B ASSY PCB MAIN CA17JS SNA
C409 2306-000147 C-FILM,MPPF 1uF,5%,250V,BK,26x24x15,22.5mm
C430 2306-000249 C-FILM,MPPF 680nF,5%,250V,TP,26x20.5x12,20
C506 2201-000154 C-CERAMIC,DISC 10nF,+80-20%,2kV,Y5P,TP,20x5,10
C601 2301-001195 C-FILM,MPPF 150nF,10%,275VAC,BK,26x16.5x7,
C602 2301-001195 C-FILM,MPPF 150nF,10%,275VAC,BK,26x16.5x7,
C608 2401-003391 C-AL 220uF,20%,450V,GP,BK,25x50,10
CIS 3301-000233 CORE-FERRITE ZZ,18x9.5x28mm,-,- SNA
CIS BH39-00191A CBF-HARNESS
TC17LO,8*0.16TA*16,-,-,120MM,-,-,35068-9822,-,-,-,-,-,-,-,CRT-GND ASS’Y
CIS BH68-00001A LABEL/MARK-CDT ART-PAPER 100G,-,WHT,BLK,-,ALL,CDT SNA
CIS BH71-00110A SHIELD BOTTOM PN15VT,SECC ,T1.0,-,-,- SNA
CIS BH72-00025A GUIDE-POWER CDA4507,ABS+PC,5V,IV16,-,- SNA
CIS BH72-00026A SHAFT-POWER CDA4507,ABS+PC,5V,IV16,-,- SNA
CIS BH72-00261A SHEET-LMF IB10LO,AL+PET,-,-,-,-,-,- SNA
CIS BH73-60304C RUBBER-SUPPORT DP15LT,CR V0,GRAY,-,14*7*10,-,- SNA
CN201 3711-003895 CONNECTOR-HEADER BOX,13P,1R,2mm,STRAIGHT,SN
CN202 3711-003873 CONNECTOR-HEADER BOX,7P,1R,2mm,STRAIGHT,SN SNA
CN205 3711-004379 CONNECTOR-HEADER BOX,4P,1R,2MM,STRAIGHT,SN SNA
CN403 3711-003989 CONNECTOR-HEADER NOWALL,4P,1R,8mm,STRAIGHT,SN SNA
CN501 BH39-00232A CBF-HARNESS
DP17MO,UL1032,UL/CSA,1P,290MM,RED,AWG22,YHF800-1,-,-,-,-,-,-,-,CBF-CONN ASS’Y
CN601 3721-001028 PLUG-AC POWER 3P,-,-,NI
D406 0402-001313 DIODE-RECTIFIER ERD07-15AL,1.7VK,1.5A,-,BK
D601 0402-001407 DIODE-BRIDGE G2SB60,600V,1.5A,SIP-4,BK
D609 0402-000005 DIODE-RECTIFIER 31DF4,400V,3A,DO-201AD,BK
FBT+H/S 6003-000122 SCREW-TAPTITE BH,+,B,M4,L12,ZPC(YEL),SWRCH18 SNA
FUSE 3601-000004 FUSE-CARTRIDGE 250V,3.15A,SLOW-BLOW,CERAMIC,5x20mm
HS501_CLAMP 6502-000001 CABLE CLAMP DAWH-5NB,D15,L35,NYLON66,NTR SNA
IC201_SOCK 3704-001071 SOCKET-IC 42P,DIP,SN,1.778mm
IC401 1204-001611 IC-DEF. PROCESSOR
TDA4856,SDIP,32P,400MIL,PLASTIC,16V,-,-20to+70C,ST,H/V DEF. PROCESSOR
IC602 1203-000165 IC-POSI.ADJUST REG.
78R12,TO-220,4P,-,PLASTIC,11.7/12.3V,1.5W,-20TO+80C,1A,-,ST
IC604 1203-000001 IC-POSI.FIXED REG. 7805,TO-220,3P,-,PLASTIC,4.8/5
JW2 BH39-40306D CBF-HARNESS ,80MM,BLK,1015,AWG22,-,-,-,-,L401 BH27-00005A COIL-CHOKE
CH-0630,120uH,10%,AR-06*30,-,PHENAL,-,-,0.20,37.0*16.2,-,-,BULK
L402 BH27-00022A COIL-CHOKE
CH-1523S,100uH,+/-10%,DR1523(C:9.8),-,PHELOLIC,-,-,0.16ohm MAX,32*17.3,-,-,BK
L403 BH27-20342U COIL-CHOKE -,8.2MH(250KHz),10%,DR8*11,-,-,-,-,10.5OHM,-,-,-,BULK
L601 BH27-00061A COIL FILTER -,33.0mH,0.1ohm,72Ts,28.*28,-,BK,SQE-2828,3A,-,OP201 0601-001147 LED ROUND,GRN,4.75mm,565nm SNA
R428 2003-000653 R-METAL OXIDE(S) 330ohm,5%,3W,AA,TP,6x16mm
RL601 3501-001111 RELAY-POWER 12Vdc,250mW,5A,1FormA,15mS,5mS
SH/BTM+M/PCB 6003-000010 SCREW-TAPTITE BWH,+,B,M3,L10,ZPC(YEL),SWRCH1 SNA
SH/BTM+SH/LMF
6003-000010 SCREW-TAPTITE BWH,+,B,M3,L10,ZPC(YEL),SWRCH1 SNA
SIGNAL BH39-00145A CBF SIGNAL ATT,1500MM,15P/6P,7P,IVORY(IV01),-,D-SUB/MALE
SW401 3406-000002 SWITCH-ROTARY 36Vdc,200mA,SP3T,SW601 3403-001116 SWITCH-PUSH 30VDC,0.1A,2C2P,SELF LOCK,T401 BH26-00090A TRANS HORIZ.DRIVE
EI-1916,AQ17HS,6P,35.0mH,-,-,73.0uH,-,-,7.5ohm/0.04ohm,-,PL-3,DMR30,J2A-1,EI1916
T402 BH27-00103A COIL LINEARITY
HL-1527C,4.5uH/50mH,DR15*27.5,3.7*11.0,17*15.5*47,15*8T,5P,BK,10%,19.5ohm/0.04,0
T501 BH26-00109A TRANS FBT
LC-13,CF1781,PN17L,1.12mH,HV45,FUR3556,375.0mohm,71.0Vdc,14P,-10 ~60,BK,27.0KV
T502 BH26-00137A TRANS-FOCUS
EE-1916,AP17JS,8P,1.0MH MIN,-,-,450MH MIN,-,-,0.70OHM/450OHM,-,PL3,DMR30,PM2A,EE
T601 BH26-00135A TRANS SWITCHING
EER3541(16P),DF(85KHZ),-,90~264V,PL3,DMR30,-,EER3541,-,-,390UH,-,110UH,-,80V,-
T602 BH26-30302S TRANS-SYNC.
-,-,-,-,-,3-1(250UH),4-6(250UH,-,-,-,0.13OHM,-,SB-5S,UU1116,-,-,-,B,TH601 1404-000002 THERMISTOR-PTC 9ohm,20%,-,-,TR,RECT,TH602 1404-001020 THERMISTOR-NTC 8ohm,15%,-,17mW/C,BK
- BH97-00202K ASSY MICOM CA17KS,-,-,-,-,-,-,-,- SNA
!!!
CA17K*/CA17J* 7-1
Loc. No. Code No. Description Specification Remarks
CONFIDENTIAL
7 Electrical Parts List
7-1 Main PCB Parts
8 Block Diagrams
CA17K*/CA17J* 8-1
CONFIDENTIAL
CONFIDENTIAL
CA17K*/CA17J* 9-1
1
2
3
4
CN403
12AC
AC
12AC
AC
1
2
3
GND
AC INPUT
AC INPUT
TILT
CN1
9
10
11
12
13
1
2
3
4
5
6
7
8
FBT
DEGAUSSING COIL
AC INPUT
CRT SOCKET
G2
CN603
IS601
MAIN PCB
CRT SOCKET PCB
FOCUS
(WHT)
123
123
NC
GND_RED
TILT +
NC
GND
1
2
3
4
TILT+(BLK)
80 V
IICCLK
HS_OUT(CLAMP)
OSD 5 V
HS_OUT (CLAMP)
OSD 5 V
GND
GND
6.3 V
G1
12 V
V-SYNC
ACL
IICDATA
AFC
9
10
11
12
13
14
1
2
3
4
5
6
7
8
H+
H–
V+
V–
H+
H–
V+
V–
YELLOW
BROWN
RED
BLUE
YELLOW
BROWN
RED
BLUE
FOCUS1 (WHT)
FOCUS2 (RED)
CN304
1
2
1
2
GND
KEY
GND
KEY
BLUE BLUE
WHITE WHITE
CN204
CN501
CN201
GND
HS-IN
DDC CLK
DDC 5V
S-RASTER
DDC DATA
VS-IN
12345
6
7
CN202
CONTROL PCB
SIGNAL CABLE
GND
HS-IN
DDC CLK
DDC 5V
S-RASTER
DDC DATA
VS-IN
12345
6
7
80 V
GND
6.3 V
IICCLK
GND
G1
12 V
V-SYNC (V_BLK)
ACL
IICDATA
AFC
BLANK
12345
6
CN101
R
GND
GND
G
GND
B
12345
6
SIGNAL CABLE
R_IN
GND_R
GND_G
G_IN
GND_B
B_IN
2 x 3p DY2 x 3p DY
CN102
3
4
GND
KEY
WHITE
WHITE
3
4
GND
KEY
WHITE
WHITE
15 PIN
D-SUB
refer to pin
assignment
of
product spec.
9 Wiring Diagram
CONFIDENTIAL
CA17K*/CA17J* 10-1
AP17JS:DEL
AP17KS:2.2K
VSMOD
CN602 : JP64(JUMPER)
FUSE : T3.15A OR T4.0A
FOCUS
c432(ks):15nf
NC
JS(85K):R219JS/KS(70K):JP125KS=JUMPER
JP125KS
1.2UH
VCAP
C427(KS): 180NF
100UH
XSEL
TILT
IICCLK
BIN
NC
HSMOD
V_MUTE
AP17KS:DELETE
C516 delete
DEGAUSS
C421(KS) 4nF 630V
1.2UH
BSENSE
T401(jS):00090A
HCAP
S3
0.68 3W
VREF
LED
1.2UH
IIC_CLK
NC
Q404(KS):FJAF6910
1.2UH
VSYNC_OUT
1.2UH
IICDATA
G2
HUNLOCK
FOCUS
OFF_MODE
TEST
MODEL-SEL
LATCH
HSYNC_OUT
1.6KV
BDRV
VSYNC_IN
C430(KS): 470NF
DDCCLK
REG
EWDRV
D-COIL
HFLB
G2-ADJ
HDRV
S4
X-IN
HBUF
C457(JS):DELETE
HSYNC
SELFRASTER
PGND
VAGC
GND
AC INPUT
2.2nF
AC90V~AC264V
JS:4.5uH
C408 DELETE
120uH
BD404 TO R401
MODE SELETE
VCC
X-OUT
AP17JS(85Khz)ONLY
c432(js):18nf 250v
jp138 delete(ic201#19~26)
KEY2
CLAMP
HV-ADJ
HREF
HPLL2
GND
R531(KS)130K
DDCDATA
SIZE-ADJ
8MHz
BH62-00047A
Q410(ks)IRF630
R557 DELETE
jp72ks
PP
T401(KS):00027A
CLBL
R510(ks):150k
KEY3
(8.2mH)
VOUT1
Q411(KS):IRF630
Q410(KS):IRF630
S2
HPLL1
VOUT2
---------
ASCOR
R428(KS):270
ACL
SCREEN
KS:5.2uH
HSYNC_IN
5V
V-H/S WING TYPE
IIC_DATA
XRAY
C457(KS):5.6NF
H-DY
H/V
SGND
R431(KS):0.6 2W
AVREF
C419(ks) 2.5nF 1.6kv
Q402(KS):IRF634A
L401:120uH
S1
POWER_KEY
H_LIN
BOP
RESET
C431(KS): 200NF
1.2UH
VSYNC
KEY1
1
2
3
4
7
6
5
50V
EI-1916
T401
R222
1/6W
2.7K
R221
50V
1uF
C612
1/6W
2.7K
R506
270K
1/4W MF
1
1/4W
3.3K
R622
R230
1/8W
1K
EYE1.5
EY508
D516
1N4148
R602
1/4W
47
1/8W
1K
R408
210V
1K
1/8W
R618
RGP02-16E
D521
$P
C-FILM,MPPF
470nF,5,250V,TP,18x16x8,7.5
RADIAL
R532
R443
150
3W
CC
1/2W
3.3M
1/6W
4.7M
R444
MO
8
13V_1
slcon1p
CN409
1
13V_1
IC202
1
2
3456
7
TVR10G
D614
KS24C081C
50V
1uF
C503
R641
56
2W
MO
R614
220
1/2W
C220
D502
RGP02-12(T)
R316
100
1/6W
16V
100uF
R436
2.2K
1/8W
R457
1/6W
47K
100uF
C201
16V
1/6W
5.6K
1K
1/8W
R213
R312
CN408
slcon1p
1
C558
100PF
1KV
C513
1nF
500V
SNAME
EY403
1
1/8W56R200
S-23(1KV),5MM
SK501
IRF640A
D
G
S
56
1/8W
R225
Q410
7V
250V
MPS
C430_1
680nF
1
Q415
KSP42
B
C
E
EY606
KSP44
B
C
E
ZD600
MTZJ27D-T-72
heat_sink
HS409
12V
12V
Q551
IRF630
Q409
D
G
S
240K
1/4W
R551
E
R455
2.2K
1/8W
D412
2N5551C-Y
Q407
B
C
TP501
1
TVR10G
C443
10nF
630V
PP
1
Q607
2N3906
B
C
E
2
3
EY510
EYE2.2
1/6W
slcon3p
CN603
1
0.56
1/2W
R413
R202
10K
16V
KSA733-Y
Q406
B
C
E
C214
100uF
R232
1/6W
100
Q0 Q1
CC
1/2W
30M
R534
P
100V
8.2nF
80V
X201
R417
C401
1uF
C429
1/6W
12K
EYE1.5
EY607
1
50V
slcon4p
CN403
1234
EY501
EYE2.2
1
12V
160V
2.20UF
C521
2.7
0.39
1/2W
R617
MF
R315
BD301
B
R630
1/6W
47K
4.70NF
250V
C604
100V
56NF
C411
P
1/6W
12K
R525
B
C
E
R501
1/6W
2.7K
R301
KSC945-Y
Q610
D413
TVR10G
56 1/8W
R309
MF
2.7
1N4007GP
D403
Vout
2
C450
1uF
63V
MP
PQ12RD11
IC602
GND3Vc
4
Vin
1
P
100V
22nF
C501
1/6W
100
100nF
C416
P
100V
R600
330K
1/2W
R218
Q601
KSC945-Y
B
C
E
R619
2W
10
MO
2
3
EYE1.5
EY506
1
100
CN602
slcon3p
1
82
2W
MO
1/6W
R220
EY609
EYE1.5
1
R445
1K
R233
1/8W
47K
1/6W
50V
470nF
C414
R524
R439
1
Q0
3
Q1
2
Q2
4
VCC
VSS
11
1/8W
10K
C413
3.3UF
50V
IC603-1
LM324N
35V
C306
500V
10nF
C531
220uF
C511
3.3nF
100V
P
500V
1nF
C615
13V_1
1/6W
47K
R214
C456
5.6nF
250V
MP
R451
C457
5.6nF
250V
MP
10K
R212
1.2K
1/8W
R628
EY503
EYE2.2
1
1/8W33K
1
C432
22nF
250V
MP
EY302
1
2
3
4
5
6
7
TVR10G
D411
2.2uF
CN202
slcon7p
500V
1nF
C530
C509
250V
1/2W
330K
R560
R440
1/8W
10K
C225
4.7uF
50V
1/6W
100
R229
13V_1
68nF
400V
P
C442
R311
1/6W
6.8K
1/4W
240K
R513
MF
2.7K
1/4W
MF
R404
R206
10K
1/6W
10K
R453
HS401
EYE1.5
EY505
1
C616
2.2nF
125V
500V
10nF
C635
R409
5.6K
1/6W
3.9K
1/6W
12V
1/2W
330K
R601
R556
B
C
E
13V
2N3906
Q413
82
1/6W
R422
C623
16V
1000uF
MP
63V
100nF
C402
ZD208
UZ6.2BSB
1uF
63V
MP
D201DDC
SB020
1/2W
R446
15
C307
C204
4.7uF
50V
750
1/4W
MF
R403
1KV
120pF
C624
1N4148
D501
R610
CC
1/2W
180K
150nF
C601
1/2W
1
R642
275VAC
5V
MO
50V
100nF
C607
50V
D508
1N4148
B
C
E
ZD606
MTZ7.5C
MF
KSA733-Y
Q503
180K
1/4W
MF
R552
20K
1/4W
R420
C
E
BD403
B
D414
1N4148
FUSE
Q302
2N3906
B
T602
1
2
354
R219JS
1/8W
10K
BH26-30302S
R510
100K1/8W
7V
IRFU210A
Q403
D
G
S
10K
1/8W
R236
EYE1.5
1
MP
250V
10nF
C433
100pF
C211
50V
EY610
47K
1/6W
R515
UZ6.2BSB
6.3V
12V
C441
1uF
50V
ZD202
10K
1/8W
R603
IRF740
Q422
D
G
S
100V
P
C313
100nF
12K
1/2W
R518
D407
UF1G
BD401
B
1N4007GP
D404
12V
-140V
KSD1616-Y
Q604
B
C
E
Q421
IRF630
D
G
S
1.2
1/2W
R307
1/4W
MF
R507
10K
250V
4.70NF
FH1
12V
C603
1/2W
22
R458
15
1/6W
P6KE200ATA
ZD603
R433
R611
50V
1uF
C426
680
3W
MO
EY605
1
C210
4.7uF
50V
R324
HS501
BH62-00015A
C510
27nF
1/6W
6.2K
P
630V
3.3nF
C421
100V
P
1/6W
2.7K
D514
1N4148
6.3V
R210
11
R454
MO
2W
330
IC603-3
LM324N
8
Q0
10
Q1
9
Q2
4
VCC
VSS
R519
1/6W
150K
UZ6.2BSB
ZD201
R207 56 1/8W
2SC5583
Q404
B
C
E
MO
3W
COIL_5V
R428
330
IRF740A
Q402
D
G
S
C212
1nF
50V
16V
1000uF
C618
C630
47uF
35V
C438
100uF
16V
1N4148
D513
EY603
1
C309
4.7nF
50V
MO
C458
8.2nF
100V
P
EYE2.2
1/4W
270
R223
UF4004
D612
MPS
250V
220nF
C431
R427
3.3K
1/8W
5
6
Q2
VCC
4
VSS
11
4.7K
1/8W
R605
IC603-2
LM324N
7
Q0
Q1
HS402
heat_sink
ZD204
UZ6.2BSB
1/8W
10K
R320
P
100V
2.2nF
C404
R430
15K
1/2W
13V_2
Vcc
3
100
R217
1/6W
IC601
DP104C
DRAIN1F_B
4
GND
2
SYNC
5
G
S
1/8W
2.2K
R205
IRF640A
Q411
D
D609
C447
330pF
500V
MP
63V
220nF
C302
321DF4
UZ6.2BSB
ZD207
14
C514
470nF
50V
12V
4
5
6
7
8
9
10
11
12
13
T501
1
2
3
D420
1N4148
EYE1.5
1
R407
470
1/2W
EYE1.5
EY511
1
EY512
Q301
2N3904
B
C
E
50V
4.7uF
C207
R604
D511
1N4148
R526
1/8W
560
C611
1/8W
18K
UZ6.2BSB
ZD209
1uF
50V
C602
150nF
275VAC
Q401
B
C
E
EY502
EYE2.2
1
R450
2N3904
MF
R310
22K
1/6W
RGP02-16E
D503
6.8K
1/4W
C620
63V
150uF
123
50V
C215
100pF
R231
slcon3p
CN502
R621
1/6W
100
R308
1/2W
470
820K
1/6W
KSA733-Y
Q405
B
C
E
5V
R452
10K
C312
10uF
16V
C507
D604
UF4007
1nF
500V
B
RGP02-12(T)
D506
G2SB60L-5700
12
3
4
BD405
1.2UH,3.5*5.7MM
MP
250V
47NF
C408
D601
ZD205
UZ6.2BSB
C203
EY401
1
22pF
50V
1/8W
56
R208
100V
680nF
C557
KSP42
Q416
B
C
E
BH62-00003A
HS301
D421
1N4148
C626
270nF
250V
MPS
C427
7
8
9
10
11
12
13
16V
100UF
CN201
1
2
3
4
5
6
EY604
EYE2.2
1
80V
slcon13p
UG2D
D408
DTV56F
D611
R419
200K
1/6W
C631
100nF
50V
MO
GT603
1
50V
1uF
C423
7
8
Q501
2N6520
B
C
E
KPJ-2S1BB
SW601
123
456
EY507
EYE1.5
1
EY601
EYE2.2
1
50V
B
MO2W
56K
R612
R511
2.7
BD603
Q412
2N3904
B
C
E
1/4W
1
2
3
6
5
4
R438
T402
HL-1425
1/4W
MF
R302
1/8W
2.2K
24K
1/6W
22K
1/2W
1K
R615
R529
500V
330pF
C619
KSC945-Y
Q417
B
C
E
56 1/8WR402
CN205
slcon4p
1
2
3
4
1/6W
6.8K
R304
R201
1M
1/6W
R405
3.3K
1/8W
P100V3.3nF
C504
10uF
C551
16V
D431
TVR10G
220nF
C505
MP
5V
12V
63V
47K
1/6W
D505
1N4148
UF4004
D401
R514
16V
470uF
C305
MO
50V
100nF
C217
22
10K
1/8W
R530
1/6WR216
R432
1/2W
10K
1/8W
100
R508
R412
1N4148
1/2W
330K
47K
1/6W
D416
500V
10nF
C614
R437
R426
10
1/4W
Q408
KTD2058-Y
B
C
E
1K
1/2W
R555
22K
1/6W
R406
R209 1/8W4.7K
1
C502
5.60NF
100V
P
10NF
500V
EY301
C301
C445
1.5K
1/4W
MP
63V
100NF
1M
1/6W
12V
R410
BH62-00004A
HS601
R500
EYE1.5
EY608
1
UZ4.7BSA
ZD501
1N4148
D519
D406
ERD07-15AL
B
1N4148
D512
BD402
R424
12K
1/4W
MF
125V
2.2nF
C617
KSA733-Y
Q423
B
C
E
2N3904
Q602
B
C
E
-10V
PP
630V
10nF
C444
C420
MPS
250V
150nF
C202
22pF
50V
ZD401
UZ5.1BSB
C425
1/8W
10K
R441
C516G1
1nF
1KV
68K
R531
1/6W
1/8W
2.2K
R434
R215 1/6W100
COIL_5V
500V
.15NF
C435
TH602
31DF6
D409
5V
-10V
SCK-083
R431
0.68
3W
WW
C608
220uF
450V
B
C
E
C407
KSC945-Y
Q502
1N4007GP
D402
150uF
63V
C410
100UF
16V
OT
1.6KV
2.2NF
C419
10K
1/8W
12V
5V
16V
470uF
C627
R613
R502
47K
1/4W
MF
7.1MH
BH27-20342U
L403
1
1/6W
6.8K
R303
EY612
EYE1.5
1
EYE1.5
EY404
HS403
EYE1.5
EY611
1
D507
1N4148
R414
1/2W
0.56
1N4148
D518
1/2W
330K
R509
C455
5.6nF
250V
MP
1
4
865
C609
22uF
50V
UF4007
T502
EE-1916
BH26-00137A
D605
KIA7805P
IC604
GND
INOUT
UZ24BSC
ZD604
4
VSS
11
ZD206
UZ6.2BSB
IC603-4
LM324N
14
Q0
12
Q1
13
Q2
VCC
R609
180K
1/2W
CC
Vcc_L
10
Vin+
1
Vin-
1/2W
10K
R570
KA2142
IC301
3784
F.G5GND
VCC_H9VOUTPUT
62
UZ6.2BSB
D210
L401
50V
1N4148
D515
47uF
50V
C621
SHL
R632
1/8W
10K
13V
210V
D301
UF4004
5.6K
R306
1/4W
MF
BD602
1.2UH
B
100V
4.7uF
C415
C512
1nF
500V
1N4148
D615
1/8W
10K
R442
C625
220nF
63V
MP
MF
1/4W
15K
R505
C308
4.7nF
100V P
MPS
250V
C409
1uF
100V
C412
3.3nF
P
MO
2W
1.5K
R421
R425
R553
330K
1/2W
EK-04
D405
1/4W
680
13
122321
14
2
9
28
15
17
7
18
19
25
22
24
10
4
16
11
32
31
27
29
8
1
26
30
IC401
TDA4856
20
6
5
3
1
R627
5.6K
1/6W
EY402
SNAME
1
GT604
L601
12
34
34
1.8K
1/4W
MF
R423
SW401
JRS-1301
1
2
16V
CC
1/2W
15M
R533
50V
100nF
C515
C622
1000uF
UZ6.2BSB
ZD601
R224
1/8W
56
13V_1
1/2W
47K
R512
UZ6.2BSB
ZD203
G5PA-1
RL601
1
2
3
4
TH601
1.2UH,3.5_5.7MM
EYE2.2
EY602
1
2.2
1/2W
R401
1N4148
D415
15K 1/6W
240K
1/2W
CC
R554
TVR10G
R504
16V
10uF
C434
D606
slcon3p
CN304
1
2
3
13V_2
1/6W
10K
R456
13V_2
820PF
C436
MO
3W
10K
R607
500V
R429
1/2W
3.3K
1.2K
1/4W
R418
13
12
11
10
50V
270pF
C459
5
6
7
8
9
18
17
16
15
14
BH26-00135A
ER-3541
T601
1
2
3
4
1/2W
47K
R210
26
500V
1nF
C508
42
17
18
19
20
21
22
23
24
25
12
38
13
39
14
40
15
41
16
7
33
8
34
9
35
10
36
11
37
2
28
3
29
4
30
5
31
6
32
EYE1.5
EY5041
IC201
1
27
RGP02-12(T)
D517
R631
1/2W
1K
R435
47K
1/6W
MO
3W
5.6
R460
L402
1/6W
100
R608
10uF
C213
12V
D610
100V
UG2D
D608
UF4007(T)
C613
100pF
1KV
TVR10G
D410
C
E
D430
1N4007GP
UZ4.7BSA
ZD602
KTA1281-Y
Q609
B
P
100V
4.7nF
C406
1N4148
D602
R239 10K 1/8W
3
COIL_5V
1/6W
68K
R527
slcon3p
CN601
1
2
Q608
KSD1616-Y
B
C
E
C506
10NF
2KV
4.7K
1/8W
KSP42
Q414
B
C
E
R203
Q420
KSP42
B
C
E
1uF
50V
C205
1SS244
D422
P100V
47nF
C610
13V_2
OP201
LTL-10233W
C446
68pF
500V
C403
10NF
100V
PP
BD601
B
1/8W
4.7K
R204
R416
150K
1/2W
P
100V
3.3nF
C310
A
B
SIZE_ADJ
V_REF
L_SENSE
V_MUTE
OFF_MODE
C
G1
HV_ADJ
SIZE_REG
V_MUTE
AFC
KEY1
KEY3
DDC5V
L_SENSE
TILT
H_LIN
AFC_SENSE
AFC_SENSE
V_OUT
FBT
A
C
B
VERT1
V_BLK
H_OUT
SIZE_REG
D_F
EW_OUT
V_REG
DDC5V
ACL
KEY1
OFF_MODE
OFF_MODE
HS_IN
S4
KEY3
REG
REG
V_REG_1
FBT
VERT2
D_F
HV_ADJ
G1
OFF_MODE
S4
DEGAUSS
S3
S2
S1
HS_OUT
VS_OUT
VERT2
VS_OUT
SIZE_ADJ
AFC
VS_IN
S_RASTER
DDCDATA
DDCCLK
VERT1
IICDATA
IICCLK
AFC
IICDATA
IICCLK
S1
S3 S2
V_REG_1
VS_OUT
HS_OUT
V_BLK
V_REG
V_OUT
V_REF
VS_IN
HS_IN
S_RASTER
ACL
IICDATA
IICCLK
HS_OUT
EW_OUT
TILT
H_LIN
H_OUT
IICDATA
IICCLK
DEGAUSS
DDCDATA
DDCCLK
10
25
9
1
2
12
3
4
8
7
21
5
6
14
13
11
10 Schematic Diagrams
10-1 Main Part Schematic Diagram
Copyright
© 2002 by Samsung Electronics Co., Ltd.
All rights reserved.
This manual may not, in whole or in part, be
copied, photocopied, reproduced, translated, or
converted to any electronic or machine readable
form without prior written permission of
Samsung Electronics Co., Ltd.
CA17K*/CA17J* Service Manual
First edition January 2002.
Printed in Korea.
Trademarks
Samsung is the registered trademark of Samsung
Electronics Co., Ltd.
CA17K*/CA17J* and MacMaster Cable Adapter
are trademarks of Samsung Electronics Co., Ltd.
Macintosh, Centris, Quadra, Duo Douk, and
Power Macintosh are trademarks of Apple
Computer, Inc.
All other trademarks are the property of their
respective owners.
ii CA17K*/CA17J*
CONFIDENTIAL
CONFIDENTIAL
10 Schematic Diagrams
10-2 CA17K*/CA17J*
1
100 V (IC601, #1)
CH1 P-P = 100 V CH1 RMS = 350.2 V
2
100 V (IC601, #1)
CH1 P-P = 100 V CH1 RMS = 325.8 V
3
2.00 V (IC401, #6)
CH1 P-P = 2.00V CH1 RMS = 5.868V
4
2.00V (IC401, #8)
CH1 P-P = 2.00V CH1 RMS = 5.868V
5
20.0 V (Q403, Collector)
CH1 P-P = 20.0 V CH1 RMS = 46.80V
6
200 V (Q404, Collector)
CH1 P-P = 200V CH1 RMS = 387.2V
7
1.00 V (IC401, #11)
CH1 P-P = 1.00V CH1 RMS = 3.008 V
8
500 V (IC401, #12)
CH1 P-P = 500 V CH1 RMS = 1.425 V
9
10.0 V (IC301, #6)
CH1 P-P = 10.0 V CH1 RMS = 5.06 V
10
2.00 V (Q402, Gate)
CH1 P-P = 2.00 V CH1 RMS = 7.692V
13
50.0 V (T502, #6)
CH1 P-P = 50.0V CH1 RMS = 75.6V
14
100 V (T502, #1)
CH1 P-P = 100V CH1 RMS = 124.0V
21
1.00 V (IC201, #13, 14)
CH1 P-P = 1.00 V CH1 RMS = 2.108V
25
5.00V (Q501, Emitter)
CH1 P-P = 5.00V CH1 RMS = 28.33V
11
50.0 V (Q402, Drain)
CH1 P-P = 50.0 V CH1 RMS = 73.7V
12
2.00 V (IC401, #32)
CH1 P-P = 2.00V CH1 RMS = 6.124V
CONFIDENTIAL
CA17K*/CA17J* 10-3
10 Schematic Diagrams
4.7uH
M41QCJ761X174(T4)
ROSD
ABL
GND
BCLP
GND
KA2518
AP17KS(70K)
G_OUT
OSD-SW
BIN
*Note : Pedestal Level :06H
AP17JS(85K)
OSD SMD IC
Cutoff IC
80V
VDDOUT
BH03-00024T
GOSD
RIN
SCL
GND
gnd1
GCT
BH03-00024U
VCC2
12V
ACL
SDA
V_BLK
SDA
GIN
6.3V
CLAMP
GIN
GND2
G1
AFC
5V
B_OUT
130uH SDI DF CDT180uH SDI DF CDT
BCT
RIN
VCC2
BOSD
SCL
G_CLP
R_OUT
R_CLP
CLAMP
H_BLK
RCT
INT
BIN
VCC1
NC
C131
220UF
16V
UZ6.2BSB
ZD102
RB02
1/8W
8.2K
R115
CN_GND
1
1/10W
22
75
1/10W
RG01
B
C
E
4.7uH
L102
KSD1616-Y
Q103
390
1/10W
L111
1.5uH
1SS244
12V
6.3V
RG05
2N3904
Q101
B
C
E
DB04
G1
DR05
DG04
1SS244
0.22uH
LG11
1N4148
1/10W
6.8K
100
R112
1/10W
R130
RG10
220
1/10W
EY6
1
EY8
SNAME
1
12V
1/4W
RB09
SNAME
EY5
SNAME
1
330K
MO
50V
10nF
C128
33
1/10W
C119
10nF
500V
1N4148
D102
R106
12V
1KV
1NF
C140
G2
910
G3G4
11
2
GK
4
HH256IC1IC2
7
RK
1
C116
SK101
j_c11p
BK
3
8
G1
100V
10uF
1/10W330R140
MO
25V
100nF
CB02
RR12
RG12
39
1/2W
1/10W
R133
1/2W
39
15PF
CG10
1K
C129
MO
50V
100PF
MO
50V
1SS244
DG03
UZ6.2BSB
ZD103
WSP-401M
SK104
LB11
0.22uH
M41QCJ761X173(T4)
CRT1
5
F
6
G
7
H
8
L101
0.47uH
IC104
LM2480NA
A
1
B
2
C
3
D4E
R122
1/10W
10K
6
ZD101
BZX79C5V6
CN101
slcon6p
1
2
3
4
5
1/2W
470
RR11
12V
DMS-200D
SKG01
100
1/10W
R116
12V
1/10W
220
RB10
2KV
C125
2.7nF
CG05
P
100V
100nF
CR05
100nF
100V
P
13 18
14 17
15 16
1N4148
DB05
823
922
10 21
11 20
12 19
29
328
427
526
625
724
IC102
S1D2518X01
130
2
MO
50V
390pF
C138
80V
CN_GTP1
1
50V
100nF
C102
BD115
B
CR02
100nF
25V
MO
180NH
1.2UH,3.5*5.7MM
75
RR01
LR11
50V
4.7uF
1/10W
1/10W
1K
R124
C137
C113
8.2nF
100V
P
2.2K
1/10W
R121
50V
4.7uF
C120
DMS-200D
SKB01
C108
22PF
50V
MO
100V
470nF
CB06
MP
390
RR05
1/10W
SK108
SSG-102B2
330 1/10WR139
C105
4.7uF
50V
RB01
75
1/10W
VOUT2
5
VOUT3
12V_A
CG02
100nF
25V
MO
IC105
7
GND
2
GND1
4
GND2
VBB
10
VCC
6
11
VIN1
9
VIN2
8
VIN3
1
VOUT1
3
DMS-200D
SKR01
LM2413T
100V
470nF
CR06
MP
DR03
1SS244
RR08
1/10W
22
RR07
1/10W
18K
B
C130
MO
50V
100PF
BD106
1.2UH,3.5*5.7MM
R143
330K
1/4W
RR09
R123
1/10W
1.5K
220
1/10W
1K
1/2W
50V
MO
RG11
16V
100uF
C122
+5V
CR10
15PF
L104
100uH
50V
MO
1/10W
1.2UH,3.5*5.7MM
BD104
B
CB10
15PF
B
12V
1K
R132
1SS244
BD103
1/10W
18K
DB03
EY7
SNAME
1
RG07
CB01
MO
25V
100nF
MO
25V
100nF
CG01
6.3V
1/10W
390
RB05
17
2M
16
2N
15
C117
10nF
500V
14
2E
24
2F
23
2G
22
2H
21
2I
20
2J
19
2K
18
2L
1G
7
1H
8
1I
9
1J
10
1K
11
1L121M
13
1N
IC103
S5D2509X09-S0
1A
1
1B
2
1C
3
1D
4
1E
5
1F
6
100
1/10WR118
heat_sink
HS103
80V
12V
1/10W
12K
R129
MO
25V
100nF
C106
470nF
100V
MP
CG06
+5V
C127
1.8nF
1KV
1SS244
R128
1/10W
5.6K
9
1011121314
DR04
CN102
slcon14p
1234567
8
DR02
1N4148
DG02
1N4148
2N3904
B
C
E
LB10
0.47UH
C107
Q102
100V
MO
50V
10nF
22
1/10W
RB06
C118
10uF
BD112
1.2UH,3.5*5.7MM
B
1/10W
18K
RB07
C112
220uF
16V
1
0.47UH
LG10
EY1
1
80V
EY2
100UF
16V
C146
43K
1/6WRG03
CN_G2
1
LR10
0.47UH
MO
25V
100nF
C139
1K
RB11
1/2W
39
RB12
1/2W
1/10W
10K
R113
DG01
1N4148
RR06
1/10W
DR01
1N4148
330K
RG09
1/4W
22
1/10W
3.9K
R144
22
MO
CR01
100nF
25V
22
1/10W
RG08
RG06
1/10W
R117
1/10W
220
RR10
UZ6.2BSB
ZD104
1/10W100
C126
100nF
50V
+5V
R141
330
1/10W
P
CB05
100nF
100V
1/2W
390
R151
C121
100uF
16V
1/10W
R114
1/6W
12K
22
22
RR02
DB01
1N4148
1/10W
RG02
DB02
1N4148
R119
1/10W
100
C104
470uF
16V
R142
1N4148
DG05
+5V
1/10W330
RB08
25V
100nF
C134
MO
1/10W
22
43K 1/6W
16V
100UF
C135
1.5uH
L103
RB03
43K 1/6WRR03
SDA
INT
H_FLB1
V_BLK
ACL
ACL
H_FLB1
H_FLB2
H_FLB2
ROSD
BOSD
OSDSW
BOSD
GOSD
ROSD
OSDSW
CLAMP
INT
G_OUT
R_OUT
B_OUT
FOCUS
AFC
SCL
ACL_ADJ
SCL
SDA
G1
ACL_ADJ
V_BLK
GOSD
15
16
17
24
26
22
23
10-2 CA17K* Video Part Schematic Diagram
CONFIDENTIAL
10 Schematic Diagrams
10-4 CA17K*/CA17J*
15
1.00 V (IC102,#5, 8, 10)
16
1.00 V (IC102, #25,28,30)1720.0 V (IC105, #1, 3, 5)
23
1.00 V (IC103, #20, 21, 22)
22
1.00 V (IC103, #5, 24)
CH1 P-P = 1.00V CH1 RMS = 4.516V
24
10.0 V (R,G,B, Video)
CH1 P-P = 10.0V CH1 RMS = 17.02V
26
20.00V (CRT Socket, G1)
CH1 P-P = 20.0V CH1 RMS = 66.68V
CA17K*/CA17J* 10-5
10 Schematic Diagrams
CONFIDENTIAL
15
2M
16
2L
17
2K
18
2J
2G
22
2F
23
2E
24
1N
14
1M
IC103
S5D2509X09-S0
2N
1L
12
1K
11
1J
10
1I
9
1H
8
1G
19
2I
20
2H
21
7
1F
6
1E
5
1D
4
1C
3
6.3V
C117
10nF
500V
1B
GND
BOUT
TEST
GIN
GND
KA2518
GOUT
VCC
GND
2
1A
1
13
M41QCJ761X174(T4)
BIN
VDDA
GIN
SCL
VSSA
G_OUT
SDA
G1
AFC
5V
OSD-SW
FBLK
SCL
VCOIN
SDA
V_BLK
VFLB
GIN
6.3V
CLAMP
GND
SDA
S1D2520
GND
ABL
RIN
VCC2
VICTL
BOSD
HFLB
VDD
G_CLP
SCL
RIN
4.7uH
BH03-00024T
GOSD
BH03-00024U
VCC
CLP
R_OUT
R_CLP
ROSD
RIN
ROUT
gnd1
GCT
VSS
BCLP
B_OUT
VREF
AP17KS(70K)
CLAMP
H_BLK
130uH SDI DF CDT180uH SDI DF CDT
BCT
BIN
*Note : Pedestal Level :06H
AP17JS(85K)
OSD SMD IC
Cutoff IC
80V
VDDOUT
VCC2
12V
ACL
RCT
INT
BIN
VCC1
NC
GND2
1
1/10W330R142
1N4148
D102
12V
EY8
SNAME
DMS-200D
SKG01
12V
C130
MO
50V
100PF
BD106
1.2UH,3.5*5.7MM
B
470
1/10W
330K
1/4W
RR09
RR04
100
1/10W
R116
L105
1.5uH
1/10W
220
RB10
1/10WR110 100
100
R112
1/10W
12V
RG10
220
1/10W
DB05
MO
50V
6.8nF
C145
12 19
13 18
14 17
15 16
1N4148
724
823
922
10 21
11 20
30
229
328
427
526
625
80V
IC102
S1D2518X01
1
MO
50V
390pF
C138
R106
33
1/10W
12V
1KV
1NF
C140
CG02
100nF
25V
MO
UZ6.2BSB
ZD104
M41QCJ761X173(T4)
CRT1
C126
100nF
50V
R107 1/10W100
MO
50V
2.2uF
C120
DMS-200D
SKB01
C108
22PF
50V
100V
470nF
CB06
MP
C129
MO
50V
100PF
1SS244
DG03
RB01
75
1/10W
L108
1.5uH
MO
CG04
100nF
25V
8
L101
0.47uH
LM2480NA
A
1
B
2
C
3
D4E
5
F
6
G
7
H
R122
1/10W
10K
IC104
470
1/10W
RR07
1/10W
18K
1
RB04
EY1
R105
1/10W
330
LB10
0.47UH
Q102
2N3904
B
C
E
MO
50V
10nF
C107
6
ZD101
BZX79C5V6
CN101
slcon6p
1
2
3
4
5
1/2W
470
RR11
C112
220uF
16V
0.47UH
LG10
6.8K
R103
1/10W
80V
100UF
16V
C146
+5V
L106
1.5uH
100uH
16V
100uF
C122
MMBD4148SE
12
3
L104
19
2K
18
2L
17
2M
16
2N
15
DR01
12
1M
13
1N
14
2E
24
2F
23
2G
22
21
2H
2I
20
2J
4
1E
5
1F
6
1G
7
1H
8
1I
9
10
1J
1K
11
1L
1201-001791
IC101
1A
1
1B
2
1C
3
1D
25V
100nF
C134
MO
+5V
1/10W
22
RB08
16V
100UF
C135
RB03 43K 1/6W
1.5uH
L103
1/6W
RG03
43K 1/6WRR03
43K
CN_G2
1
LR10
0.47UH
1/10W
heat_sink
HS103
+5V
RG09
1/4W
22
RR06
R144
330K
MO
CR01
100nF
25V
1/10W
3.9K
R141
330
1/10W
R101
1/10W
6.8K
+5V
P
CB05
100nF
100V
50V
MO
1K
1/2W
CR10
15PF
16V
100UF
RG11
C125
2.7nF
C148
CG05
P
100V
100nF
2KV
CR05
100nF
100V
P
MO
CB04
100nF
25V
B
CB10
15PF
50V
MO
1/10W
1.2UH,3.5*5.7MM
BD104
CN_GTP1
1
1K
R132
L107
1.5uH
50V
100nF
C102
B
CR02
100nF
25V
MO
1.2UH,3.5*5.7MM
BD115
100
1/10W
R104
LR11
180NH
RG08
RG06
1/10W
22
22
1/10W
1/10W
220
RR10
1SS244
1/10W100R117
BD103
B
DB03
DG04
1SS244
0.22uH
LG11
1N4148
DR05
6.8K
SNAME
EY6
1
R130
1/10W
1
330K
1/4W
RB09
50V
10nF
C128
EY5
SNAME
C119
10nF
500V
MO
1N4148
D101
12V
C118
10uF
100V
1.2UH,3.5*5.7MM
B
22
1/10W
RB06
1/10W
18K
RB07
BD112
RG07
1/10W
18K
EY7
SNAME
1
RG04
C113
8.2nF
100V
P
R121
1/10W
470
C131
220UF
16V
2.2K
1/10W
910
G3G4
11
2GK
4
HH256IC1IC2
7
RK
1
C116
SK101
j_c11p
BK
3
8
G1G2
100V
10uF
1/10W
75
RR01
C137
50V
4.7uF
1/10W
1K
R124
MO
C149
100uF
16V
1/2W
39
RR12
CR04
100nF
25V
1K
1/10W
R133
MO
50V
15PF
CG10
UZ6.2BSB
ZD102 ZD103
UZ6.2BSB
LB11
0.22uH
C
E
DB04
1SS244
DMS-200D
SKR01
2N3904
Q101
B
DR03
1SS244
C121
100uF
16V
1/10W
12K
R129
3
MO
25V
100nF
C106
12
3
MMBD4148SE
DG01
12
100 1/10W
DB01
MMBD4148SE
R108
RR02
1/10W
R114
1/6W
12K
1/10W
RG02
22
22
GND2
VBB
10
VCC
6
11
VIN1
9
VIN2
8
VIN3
1
VOUT1
3
VOUT2
5
VOUT3
12V_A
+5V
LM2413T
IC105
7
GND
2
GND1
4
100V
470nF
CR06
MP
22
0.100W
11M
R145
RR08
1/10W
1/10W
100
C104
470uF
16V
C147
R119
MO
25V
100nF
R143
1N4148
DG05
R123
1/10W
1.5K
220
1/10W
MO
25V
100nF
C139
R109 1/10W100
RB11
1/2W
39
RB12
1/2W
1K
1/10W
10K
R113
1
1/10W
22
RB02
RG01
CN_GND
4.7uH
L102
75
1/10W
Q103
B
C
E
L111
1.5uH
KSD1616-Y
1/10W
330R140
MO
25V
100nF
CB02
RG12
39
1/2W
11M
0.100W
R111
R151
390
1/2W
1
R115
8.2K
1/8W
G1
1011121314
EY2
123456789
MP
CG06
CN102
slcon14p
R128
1/10W
5.6K
470nF
100V
1/10W
390
RB05
MO
25V
100nF
CG01
80V
12V
100
1/10WR118
390
RR05
1/10W
330 1/10WR139
SK108
SSG-102B2
C105
4.7uF
50V
L109
1.5uH
C127
1.8nF
1KV
1SS244
CB01
MO
25V
100nF
12K
R102
DR04
390
1/10W
1/10W
6.3V
WSP-401M
SK104
RG05
CLAMP
SDA
INT
H_FLB1
V_BLK
ACL
ACL
12V
H_FLB2
H_FLB2
SCL
SDA
V_BLK
CLAMP
INT
OSDSW
H_FLB1
V_BLK
GOSD
ROSD
BOSD
OSDSW
BOSD
GOSD
ROSD
OSDSW
CLAMP
G_OUT
R_OUT
B_OUT
FOCUS
AFC
SCL
ACL_ADJ
SCL
SDA
G1
ACL_ADJ
17
24
26
23
22
18
20
16
15
19
10-3 CA17J* Video Part Schematic Diagram
10 Schematic Diagrams
10-6 CA17K*/CA17J*
CONFIDENTIAL
15
1.00 V (IC102,#5, 8, 10)
16
1.00 V (IC102, #25,28,30)1720.0 V (IC105, #1, 3, 5)
18
1.00 V (IC101, #20, 22, 24)
23
1.00 V (IC103, #20, 21, 22)
19
1.00 V (IC101, #14)
20
1.00 V (IC101, #15)
22
1.00 V (IC103, #5, 24)
CH1 P-P = 1.00V CH1 RMS = 4.516V
24
10.0 V (R,G,B, Video)
CH1 P-P = 10.0V CH1 RMS = 17.02V
26
20.00V (CRT Socket, G1)
CH1 P-P = 20.0V CH1 RMS = 66.68V
9 PCB Diagrams
9-2 CA17K*/CA17J*
CONFIDENTIAL
Memo
CONFIDENTIAL
Memo
8 Block Diagrams
8-2 CA17K*/CA17J*
IC201 0903-001194 IC-MICROCONTROLLER
3P863,8Bit,SDIP,42P,600MIL,12MHz,ST,CMOS,PLASTIC,5V,-,-40to+85C,1040BYTE,48KBYTE
SNA
CIS BH46-00005K MICOM-S/W CA17KS,-,-,-,-,-,- SNA
- BH97-00234B ASSY AUTO-MAIN CA17JS SNA
BD301 3301-000011 CORE-FERRITE BEAD AA,3.5x1.0x5.7mm,1500,2375G
BD401 3301-000011 CORE-FERRITE BEAD AA,3.5x1.0x5.7mm,1500,2375G
BD402 3301-000011 CORE-FERRITE BEAD AA,3.5x1.0x5.7mm,1500,2375G
BD403 3301-000011 CORE-FERRITE BEAD AA,3.5x1.0x5.7mm,1500,2375G
BD405 3301-000011 CORE-FERRITE BEAD AA,3.5x1.0x5.7mm,1500,2375G
BD601 3301-000011 CORE-FERRITE BEAD AA,3.5x1.0x5.7mm,1500,2375G
BD602 3301-000011 CORE-FERRITE BEAD AA,3.5x1.0x5.7mm,1500,2375G
BD603 3301-000011 CORE-FERRITE BEAD AA,3.5x1.0x5.7mm,1500,2375G
C201 2401-000025 C-AL 100uF,20%,16V,GP,TP,6.3x11,5
C202 2201-000389 C-CERAMIC,DISC 0.022nF,5%,50V,NP0,TP,5x3,5
C203 2201-000389 C-CERAMIC,DISC 0.022nF,5%,50V,NP0,TP,5x3,5
C204 2401-002075 C-AL 4.7uF,20%,50V,GP,TP,5x11,5
C205 2401-000603 C-AL 1uF,20%,50V,GP,TP,5x11,5
C207 2401-002075 C-AL 4.7uF,20%,50V,GP,TP,5x11,5
C210 2401-002075 C-AL 4.7uF,20%,50V,GP,TP,5x11,5
C211 2201-000146 C-CERAMIC,DISC 0.1nF,5%,50V,SL,TP,5x3.5,5
C212 2201-000017 C-CERAMIC,DISC 1nF,10%,50V,Y5P,TP,5x3.5,5
C213 2401-000029 C-AL 10uF,20%,100V,GP,TP,6.3x11,5
C214 2401-000025 C-AL 100uF,20%,16V,GP,TP,6.3x11,5
C215 2201-000146 C-CERAMIC,DISC 0.1nF,5%,50V,SL,TP,5x3.5,5
C217 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,TP,2.3X3
C220 2401-000025 C-AL 100uF,20%,16V,GP,TP,6.3x11,5
C225 2401-002075 C-AL 4.7uF,20%,50V,GP,TP,5x11,5
C301 2305-000665 C-FILM,MPEF 100nF,5%,63V,TP,7.5x4.0x5.0mm,
C302 2305-001041 C-FILM,MPEF 220nF,5%,63V,TP,7.5x4.5x13.5,5
C305 2401-000037 C-AL 470uF,20%,16V,GP,TP,8x11.5,5
C306 2401-002274 C-AL 220uF,20%,35V,WT,TP,10x12.5,5
C307 2305-000237 C-FILM,MPEF 1uF,5%,63V,TP,7.5x15.5mm,5mm
C308 2301-000013 C-FILM,PEF 4.7nF,5%,100V,TP,10.5x12.5x6.5
C309 2202-000252 C-CERAMIC,MLC-AXIAL 4.7nF,10%,50V,X7R,TP,2.5x4.3,C310 2301-000519 C-FILM,PEF 3.3nF,5%,100V,TP,5.8x3x12.5,5m
C312 2401-000050 C-AL 10uF,20%,16V,GP,TP,5x11,2.5
C313 2301-000010 C-FILM,PEF 100nF,5%,100V,TP,11.5x12.5mm,5
C401 2301-000312 C-FILM,PEF 8.2nF,5%,100V,TP,6x12.5mm,5mm
C402 2305-000665 C-FILM,MPEF 100nF,5%,63V,TP,7.5x4.0x5.0mm,
C403 2303-000119 C-FILM,PPF 10nF,5%,100V,TP,7x10x4.5,5
C404 2301-000004 C-FILM,PEF 2.2nF,5%,100V,TP,5.5X10X2.9,5m
C406 2301-000013 C-FILM,PEF 4.7nF,5%,100V,TP,10.5x12.5x6.5
C407 2401-000540 C-AL 150uF,20%,63V,LZ,TP,10x25,5
C408 2305-000428 C-FILM,MPEF 47nF,5%,250V,TP,11x9x4.5,5mm
C410 2401-000025 C-AL 100uF,20%,16V,GP,TP,6.3x11,5
C411 2301-000294 C-FILM,PEF 56nF,5%,100V,TP,9.5x12.5mm,5mm
C412 2301-000519 C-FILM,PEF 3.3nF,5%,100V,TP,5.8x3x12.5,5m
C413 2401-001012 C-AL 3.3UF,20%,50V,BP,TP,16X25,7.5
C414 2401-001334 C-AL 470nF,20%,50V,GP,TP,5x11,2.5
C415 2401-001218 C-AL 4.7uF,20%,100V,WT,TP,5x11,5
C416 2301-000010 C-FILM,PEF 100nF,5%,100V,TP,11.5x12.5mm,5
C419 2309-000106 C-FILM,MPE-PPF 2.2nF,5%,1.6KV,TP,23x16x9,7.5m
C420 2309-000106 C-FILM,MPE-PPF 2.2nF,5%,1.6KV,TP,23x16x9,7.5m
C421 2301-001341 C-FILM,PPF 3.3nF,5%,630V,TP,17.4x10x5.4mm,7.5
C423 2401-000603 C-AL 1uF,20%,50V,GP,TP,5x11,5
C425 2306-000131 C-FILM,MPPF 150nF,5%,250V,TP,19x16x7.5,7.5
!
!
7 Electrical Parts List
7-2 CA17K*/CA17J*
Loc. No. Code No. Description Specification Remarks
CONFIDENTIAL
C426 2401-000603 C-AL 1uF,20%,50V,GP,TP,5x11,5
C427 2306-000171 C-FILM,MPPF 270nF,5%,250V,TP,21.5x12.5mm,7
C429 2401-000603 C-AL 1uF,20%,50V,GP,TP,5x11,5
C431 2306-000164 C-FILM,MPPF 220nF,5%,250V,TP,19x22x10,7.5m
C432 2305-000207 C-FILM,MPEF 18nF,5%,250V,TP,13*9*4.5,5mm
C433 2305-001003 C-FILM,MPEF 10nF,5%,250V,TP,13x4.5x9mm,7.5
C434 2401-000050 C-AL 10uF,20%,16V,GP,TP,5x11,2.5
C435 2201-002079 C-CERAMIC,DISC 0.15nF,10%,500V,Y5P,TP,6.3x4mm,5
C436 2201-000672 C-CERAMIC,DISC 0.82nF,10%,500V,Y5P,TP,6.5x3,5
C438 2401-000025 C-AL 100uF,20%,16V,GP,TP,6.3x11,5
C441 2401-000603 C-AL 1uF,20%,50V,GP,TP,5x11,5
C442 2301-001249 C-FILM,MPPF 68nF,5%,400V,TP,19x7x15mm,7.5
C443 2303-000122 PEF CAPACITOR 10nF,5%,630V,TP,19x12.5mm,7.5m
C444 2303-000122 PEF CAPACITOR 10nF,5%,630V,TP,19x12.5mm,7.5m
C445 2201-000019 C-CERAMIC,DISC 10nF,+80-20%,500V,Y5V,TP,13.5x4mm,5
C446 2201-000647 C-CERAMIC,DISC 0.068nF,5%,500V,NP0,TP,8x3.5mm,5
C447 2201-000469 C-CERAMIC,DISC 0.33nF,10%,500V,Y5P,TP,5.5x3,5
C450 2305-000237 C-FILM,MPEF 1uF,5%,63V,TP,7.5x15.5mm,5mm
C455 2305-000012 C-FILM,MPEF 5.6NF,10%,250V,TP,14.5X9.0X6.0MM,7.5
C456 2305-000012 C-FILM,MPEF 5.6NF,10%,250V,TP,14.5X9.0X6.0MM,7.5
C458 2301-000312 C-FILM,PEF 8.2nF,5%,100V,TP,6x12.5mm,5mm
C459 2201-000411 C-CERAMIC,DISC 0.27nF,10%,50V,Y5P,TP,4x3.5,5
C501 2301-000016 C-FILM,PEF 22nF,5%,100V,TP,7.2x4.5x9.0mm,
C502 2301-000287 C-FILM,PEF 5.6nF,5%,100V,TP,10.5x12.5x6.5
C503 2401-000603 C-AL 1uF,20%,50V,GP,TP,5x11,5
C504 2301-000519 C-FILM,PEF 3.3nF,5%,100V,TP,5.8x3x12.5,5m
C505 2305-001041 C-FILM,MPEF 220nF,5%,63V,TP,7.5x4.5x13.5,5
C507 2201-000291 C-CERAMIC,DISC 1nF,10%,500V,Y5P,TP,7.5x3.5,5
C508 2201-000291 C-CERAMIC,DISC 1nF,10%,500V,Y5P,TP,7.5x3.5,5
C509 2401-002267 C-AL 2.2uF,20%,250V,GP,TP,8x11.5,5
C510 2301-000020 C-FILM,PEF 27nF,5%,100V,TP,7.3x4x12.5mm,5
C511 2301-000519 C-FILM,PEF 3.3nF,5%,100V,TP,5.8x3x12.5,5m
C512 2201-000291 C-CERAMIC,DISC 1nF,10%,500V,Y5P,TP,7.5x3.5,5
C513 2201-000291 C-CERAMIC,DISC 1nF,10%,500V,Y5P,TP,7.5x3.5,5
C514 2401-001334 C-AL 470nF,20%,50V,GP,TP,5x11,2.5
C515 2201-000119 C-CERAMIC,DISC 100nF,+80-20%,50V,Y5V,TP,8x3,5
C521 2401-002267 C-AL 2.2uF,20%,250V,GP,TP,8x11.5,5
C530 2201-000291 C-CERAMIC,DISC 1nF,10%,500V,Y5P,TP,7.5x3.5,5
C531 2201-000019 C-CERAMIC,DISC 10nF,+80-20%,500V,Y5V,TP,13.5x4mm,5
C551 2401-000050 C-AL 10uF,20%,16V,GP,TP,5x11,2.5
C557 2401-001643 C-AL 0.68uF,20%,50V,GP,TP,5x11mm,5
C558 2201-000129 C-CERAMIC,DISC 0.1nF,10%,1kV,Y5P,TP,7x4,5
C603 2201-000024 C-CERAMIC,DISC 4.7nF,20%,250VAC,Y5U,TP,16x7,7
C604 2201-000024 C-CERAMIC,DISC 4.7nF,20%,250VAC,Y5U,TP,16x7,7
C607 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,TP,2.3X3
C609 2401-000970 C-AL 22uF,20%,50V,WT,TP,5x11,5
C610 2301-000284 C-FILM,PEF 47nF,5%,100V,TP,8.5x12.5mm,5mm
C611 2401-000613 C-AL 1uF,20%,50V,WT,TP,5x11,5
C612 2401-000613 C-AL 1uF,20%,50V,WT,TP,5x11,5
C613 2201-000129 C-CERAMIC,DISC 0.1nF,10%,1kV,Y5P,TP,7x4,5
C614 2201-000019 C-CERAMIC,DISC 10nF,+80-20%,500V,Y5V,TP,13.5x4mm,5
C615 2201-000291 C-CERAMIC,DISC 1nF,10%,500V,Y5P,TP,7.5x3.5,5
C616 2201-000023 C-CERAMIC,DISC 2.2nF,20%,125V,Y5U,TP,11x7,5
C617 2201-000023 C-CERAMIC,DISC 2.2nF,20%,125V,Y5U,TP,11x7,5
C618 2401-000039 C-AL 1000uF,20%,16V,GP,TP,10x16,5
7 Electrical Parts List
CA17K*/CA17J* 7-3
Loc. No. Code No. Description Specification Remarks
CONFIDENTIAL
Loading...