Samsung C3510 Service Manual

GSM TELEPHONE

GT-C3510

GSM TELEPHONE

CONTENTS

Safety Precautions

1.

Specification

2.

Product Function

3.

Array course control

4.

Exploded View and Parts list

5.

MAIN Electrical Parts List

6.

Block Diagrams

7.

PCB Diagrams

8.

Chart of Troubleshooting

9.

Reference data

10.

Disassembly and Assembly

11. Instructions

Safety Precautions

1.

Repair Precaution

1-1.

Repair in Shield Box, during detailed tuning. Take specially care of tuning or test, because

―

specipicty of cellular phone is sensitive for surrounding interference(RF noise).

Be careful to useakind of magnetic object or tool, because performance of parts is damaged by

―

the influence of magnetic force.

Surely useastandard screwdriver when you disassemble this product, otherwise screw will be

―

worn away.

Useathicken twisted wire when you measure level.

―

thicken twisted wire has low resistance, therefore error of measurement is few.

A

Repair after separate Test Pack and Set because for short danger(for example an overcurrent

―

and furious flames of parts etc) when you repair board in condition of connecting Test Pack and

tuning on.

Take specially care of soldering, because Land of PCB is small and weak in heat.

―

Surely tune on/off while using AC power plug, becausearepair of battery charger is dangerous

―

when tuning ON/OFF PBA and Connector after disassembling charger.

Don't use as you pleases after change other material than replacement registered on SEC System.

―

Otherwise engineer in charge isn't charged with problem that you don't keep this rules.

1-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Safety Precautions

ESD(Electrostatically Sensitive Devices) Precaution

1-2.

Several semiconductor may be damaged easily by static electricity. Such parts are called by ESD

Electrostatically Sensitive Devices), for example IC,BGA chip etc. Read Precaution below.

(

You can prevent from ESD damage by static electricity.

Remove static electricity remained your body before you touch semiconductor or parts with

―

semiconductor. There are ways that you touch an earthed place or wear static electricity prevention

string on wrist.

Use earthed soldering steel when you connect or disconnect ESD.

―

Use soldering removing tool to break static electricity.,otherwise ESD will be damaged by static

―

electricity.

Don't unpack until you set up ESD on product. Because most of ESD are packed by box and

―

aluminum plate to have conductive power,they are prevented from static electricity.

You must maintain electric contact between ESD and place due to be set up until ESD is

―

connected completely to the proper place oracircuit board.

1-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Specification

2.

GSM General Specification

2-1.

GSM850 GSM900 DCS1800 PCS1900

Freq.

Band[MHz]

Uplink/Downlink

ARFCN range 128~251

Tx/Rx spacing 45MHz 45MHz 95MHz 80MHz

Mod. Bit rate/

Bit Period

Time Slot

Period/Frame

Period

Modulation 0.3GMSK 0.3GMSK 0.3GMSK 0.3GMSK

MS Power 33dBm~5dBm 33dBm~5dBm 30dBm~0dBm 30dBm~0dBm

Power Class

824~849 869~894

270.833kbps

3.692us

576.9us

4.615ms

4

(max +33dBm)4(max +33dBm)1(max +30dBm)1(max +30dBm)

880~915 925~960

0~124 &

975~1023

270.833kbps

3.692us

576.9us

4.615ms

1710~1785 1805~1880

512~885 512~810

270.833kbps

3.692us

576.9us

4.615ms

1850~1910 1930~1990

270.833kbps

3.692us

576.9us

4.615ms

Sensitivity -102dBm -102dBm -100dBm - 100dBm

TDMAMux8888

Cell Radius 35Km 35Km 2Km 2Km

2-1

Speclflcation

GSM Tx Power Class

2-2.

TX Power

control level

533±3

631±3

729±3

827±3

925±3

10 23±3

11 21±3

GSM GSM900

850

dBm

TX Power

control level

030±3

128±3

226±3

324±3

422±3

520±3

618±3

DCS1800

dBm

TX Power

control level

030±3

128±3

226±3

324±3

422±3

520±3

618±3

PCS1

900

dBm

12 19±3

13 17±3

14 15±3

15 13±3

16 11±5

17 9±5

18 7±5

19 5±5

dBm

716±3

814±3

912±4

10 10±4

11 8±4

12 6±4

13 4±4

14 2±5

15 0±5

dBm

716±3

814±3

912±4

10 10±4

11 8±4

12 6±4

13 4±4

14 2±5

15 0±5

dBm

2-2

GSM EDGE TX power class

2-3.

Speclflcation

Only in Master

TX Power

control level

827±3

925±3

10 23±3

11 21±3

12 19±3

13 17±3

14 15±3

GSM900 GSM850

dBm

TX Power

control level

226±3

324±3

422±3

520±3

618±3

716±3

812±3

DCS1800

dBm

TX Power

control level

226±3

324±3

422±3

520±3

618±3

716±3

812±3

PCS1900

dBm

15 13±3

16 11±5

17 9±5

18 7±5

19 5±5

dBm

910±3

10 14±3

11 12±4

12 10±4

13 8±4

14 6±4

15 4±4

2-3

dBm

910±3

10 14±3

11 12±4

12 10±4

13 8±4

14 6±4

15 4±4

dBm

Operation Instruction and Installation

3.

Main Function

Mega Pixel Camera

-1.3

QVGA

-

SMS/MMS/EMS(OMA v1.2

-

WAP

-

MP3/AMR/AAC/AAC+/e-AAC+/WMA/i-melody

-

Quad Band(EGSM900/DCS,PCS,EDGE)

-

MicroSD Card Support

-

External Memory

-

USB v2.0 High-speed, Bluetooth v2.1

-

FM Radio Support,Radio Data System

-

2.8

2.0

inch TSP

)

Browser

3-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

4.

Software Adjustments

4-1.

Test Jig(GH99

RF Test Cable(GH

-36900

39-00985

A)

Test Cable(GH

Adapter(GH

39-01313

99-38251

A)

4-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

Software Downloading

4-2.

4-2-1.

4-2-2.

■

Pre-requsite for Downloading

Downloader Program(

•

GT-C3510 Mobile Phone

•

Data Cable

•

Binary file, TFS file, CSC file

•

PNX6517 OneNAND Downloader v0.1 for GT-B3410(Delphi))

S/W Downloader Program

 the binary download program by executing the

PNX6517 OneNAND Downloader v0.1 for GT-B3410(Delphi).exe"

"

Select the connected serial port and the rate of speed

.

1

Select the check box, the mode you want to download.

.

2

if only binary file update is needed, check"BIN"

-

if only tfs file update is needed, check"TFS"

-

4-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

.

if only csc file update is needed, check"Common CSC ONLY"

-

if all file updates are needed, check both"BIN+TFS" and"with Common CSC"

-

Click the corresponding button to select the file(s) that you want to download.

.

3

Choose each binary/tfs/csc file, then click open button.

.

4/5

Array course control

After all necessary binary/tfs/csc file(s) are selected, check"AutoDownLoader" and click"START"

6/7.

button. Then, connectaphone with test cable at the designated serial port. If connection is

successful, the downloader will start with pre-downloading and continue to main downloading.

4-3

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

Memory Full Reset

4-3.

After download has completed, follow the below procedure for full memory reset.

Full Reset

:

*2767*3855#

4-4

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Exploded View and Parts List

5.

5-1.

Cellular phone Exploded View

QME03

QFR01

QLC01

QLB01

QCR72

QAR01

QMP01

QKP01

QME01

QMI01

QSP01

QCA01

QMO01

QRE01

QCR101

QBA01

QBC00

QVO01

QIF01

QCW01

QSH01

QAN02

QCK02

QCK01

QSD01

5-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Exploded View and Parts List

5-2.

Cellular phone Parts list

Design LOC Description SEC CODE

QAR01 AUDIO-RECEIVER

QCR101 SCREW-MACHINE

QCR72 SCREW-MACHINE

3009-001428

6001-002005

6001-002051

QMI01 MICROPHONE-ASSY-GT-C3510 GH30-00627A

QMO01 MOTOR LINEAR VIBRATION-GT_S7330 GH31-00449A

QAN02 INTENNA-MAIN(GT-C3510) GH42-02300A

QBA01 INNER BATTERY PACK-AB463651BU,960MAH GH43-03216A

QME01 DOME SHEET-GT-C3510(MAIN) GH59-08590A

QME03 TOUCH/PANEL-GT-C3510(BLK) GH59-08654A

QSP01 MODULE-SPK_CARRIER ASSY(GT-C3510) GH59-08765A

QCA01 CAMERA MODULE-GT-C3510 GH59-08802A

QMP01 A/S ASSY-PBA MAIN,ECC,GT-C3510(SVC) GH82-04359A

QLC01 ELA MODULE-LCD MODULE(GT-C3510) GH96-04197A

QFR01 ASSY CASE-FRONT GH98-15114A

QKP01 ASSY KEYPAD-(OPEN/BLUE) GH98-15117A

QLB01 ASSY BRACKET-LCD GH98-15118A

QSH01 ASSY BRACKET-SHIELD CAN GH98-15122A

QBC00 ASSY COVER-BATT GH98-15844A

QRE01 ASSY CASE-REAR GH98-15116A

QCW01 PCT WINDOW-CAMERA GH72-56746A

QIF01 PMO COVER-IF V3 GH72-57720A

QCK01 PMO KEY-CAMERA V3 GH72-57721A

QCK02 PMO KEY-HOLD V3 GH72-57722A

QSD01 PMO COVER-SD V2 GH72-57724A

QVO01 PMO KEY-VOLUME V2 GH72-57725A

5-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

MAIN Electrical Parts List

6.

SEC CODE DESIGN LOC DESCRIPTION

0403-001547

0406-001286

0406-001293

0406-001329

0406-001361

0505-001325

1003-002047

1108-000297

1201-002933

1203-005728

1203-005770

1203-006077

1205-003310

1205-003874

1205-003883

1404-001221

2007-000140

2007-000141

2007-000143

2007-000148

2007-000149

2007-000152

ZD301 DIODE-ZENER

ZD405 DIODE-TVS

ZD406 DIODE-TVS

ZD400 DIODE-TVS

ZD402 DIODE-TVS

ZD500 DIODE-TVS

ZD501 DIODE-TVS

ZD502 DIODE-TVS

ZD503 DIODE-TVS

D400 DIODE-TVS

ZD300 DIODE-TVS

Q400 FET-SILICON

U400 IC-MOTOR DRIVER

UME200 IC-MCP

PAM100 IC-POWER AMP

U302 IC-POWER SUPERVISOR

U300 IC-MULTI REG

U301 IC-BACKLIGHT DRIVER

U103 IC-TRANSCEIVER

UCP200 IC-MODEM

U100 IC-BLUETOOTH

VR200 THERMISTOR-NTC

R207 R-CHIP

R303 R-CHIP

R401 R-CHIP

R409 R-CHIP

R416 R-CHIP

R420 R-CHIP

R309 R-CHIP

R402 R-CHIP

R417 R-CHIP

R104 R-CHIP

R105 R-CHIP

R315 R-CHIP

R206 R-CHIP

R314 R-CHIP

R318 R-CHIP

6-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE DESIGN LOC DESCRIPTION

2007-000152

2007-000157

2007-000159

2007-000160

2007-000165

2007-000166

2007-000170

2007-000173

2007-000566

2007-001292

2007-001319

2007-001333

2007-001339

2007-002970

2007-007573

2007-007875

2007-008354

2203-000233

R319 R-CHIP

R427 R-CHIP

R107 R-CHIP

R108 R-CHIP

R313 R-CHIP

R310 R-CHIP

R311 R-CHIP

R312 R-CHIP

R316 R-CHIP

R100 R-CHIP

R200 R-CHIP

R425 R-CHIP

R317 R-CHIP

R407 R-CHIP

R415 R-CHIP

R426 R-CHIP

R320 R-CHIP

R201 R-CHIP

R300 R-CHIP

R301 R-CHIP

R202 R-CHIP

R203 R-CHIP

R204 R-CHIP

U401 R-CHIP

R304 R-CHIP

R306 R-CHIP

R429 R-CHIP

R440 R-CHIP

R307 R-CHIP

R102 R-CHIP

R103 R-CHIP

R302 R-CHIP

R308 R-CHIP

R305 R-CHIP

C106 C-CER,CHIP

C400 C-CER,CHIP

C509 C-CER,CHIP

6-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE DESIGN LOC DESCRIPTION

2203-000254

2203-000311

2203-000386

2203-000438

2203-000585

2203-000679

2203-000725

2203-000812

2203-000854

2203-000995

2203-002709

2203-005050

2203-005053

2203-005234

2203-005281

2203-005288

C108 C-CER,CHIP

C111 C-CER,CHIP

C203 C-CER,CHIP

C340 C-CER,CHIP

C335 C-CER,CHIP

C338 C-CER,CHIP

C401 C-CER,CHIP

C402 C-CER,CHIP

C410 C-CER,CHIP

C411 C-CER,CHIP

C431 C-CER,CHIP

C432 C-CER,CHIP

C209 C-CER,CHIP

C437 C-CER,CHIP

C438 C-CER,CHIP

C428 C-CER,CHIP

C433 C-CER,CHIP

C434 C-CER,CHIP

C117 C-CER,CHIP

C423 C-CER,CHIP

C103 C-CER,CHIP

C105 C-CER,CHIP

C144 C-CER,CHIP

C148 C-CER,CHIP

C348 C-CER,CHIP

C349 C-CER,CHIP

C405 C-CER,CHIP

C414 C-CER,CHIP

C134 C-CER,CHIP

C429 C-CER,CHIP

C430 C-CER,CHIP

C114 C-CER,CHIP

C121 C-CER,CHIP

C147 C-CER,CHIP

C123 C-CER,CHIP

C128 C-CER,CHIP

C101 C-CER,CHIP

6-3

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE DESIGN LOC DESCRIPTION

2203-005288

2203-005395

2203-005450

2203-005480

2203-005483

2203-006048

2203-006190

2203-006201

2203-006257

2203-006260

2203-006348

C120 C-CER,CHIP

C122 C-CER,CHIP

C100 C-CER,CHIP

C202 C-CER,CHIP

C207 C-CER,CHIP

C320 C-CER,CHIP

C322 C-CER,CHIP

C215 C-CER,CHIP

C107 C-CER,CHIP

C130 C-CER,CHIP

C133 C-CER,CHIP

C201 C-CER,CHIP

C204 C-CER,CHIP

C206 C-CER,CHIP

C208 C-CER,CHIP

C210 C-CER,CHIP

C211 C-CER,CHIP

C316 C-CER,CHIP

C326 C-CER,CHIP

C336 C-CER,CHIP

C347 C-CER,CHIP

C351 C-CER,CHIP

C353 C-CER,CHIP

C403 C-CER,CHIP

C406 C-CER,CHIP

C412 C-CER,CHIP

C415 C-CER,CHIP

C124 C-CER,CHIP

C125 C-CER,CHIP

C314 C-CER,CHIP

C315 C-CER,CHIP

C307 C-CER,CHIP

C113 C-CER,CHIP

C313 C-CER,CHIP

C323 C-CER,CHIP

C325 C-CER,CHIP

C301 C-CER,CHIP

6-4

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE DESIGN LOC DESCRIPTION

2203-006399

2203-006562

2203-006824

2203-006838

2203-006872

2203-006890

C200 C-CER,CHIP

C212 C-CER,CHIP

C213 C-CER,CHIP

C300 C-CER,CHIP

C302 C-CER,CHIP

C303 C-CER,CHIP

C304 C-CER,CHIP

C305 C-CER,CHIP

C308 C-CER,CHIP

C309 C-CER,CHIP

C310 C-CER,CHIP

C311 C-CER,CHIP

C312 C-CER,CHIP

C321 C-CER,CHIP

C328 C-CER,CHIP

C339 C-CER,CHIP

C350 C-CER,CHIP

C421 C-CER,CHIP

C500 C-CER,CHIP

C501 C-CER,CHIP

C502 C-CER,CHIP

C503 C-CER,CHIP

C504 C-CER,CHIP

C317 C-CER,CHIP

C324 C-CER,CHIP

C327 C-CER,CHIP

C343 C-CER,CHIP

C344 C-CER,CHIP

C205 C-CER,CHIP

C214 C-CER,CHIP

C306 C-CER,CHIP

C109 C-CER,CHIP

C110 C-CER,CHIP

C112 C-CER,CHIP

C115 C-CER,CHIP

C217 C-CER,CHIP

C318 C-CER,CHIP

6-5

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE DESIGN LOC DESCRIPTION

2203-006890

2203-007279

2203-007317

2203-007425

2404-001377

2404-001496

2409-001172

2703-002170

2703-002202

2703-002203

2703-002207

2703-002208

2703-002268

2703-002269

2703-002313

2703-002368

2703-003121

2703-003260

2703-003476

2801-004339

2801-004893

2901-001576

C330 C-CER,CHIP

C104 C-CER,CHIP

C341 C-CER,CHIP

C342 C-CER,CHIP

C352 C-CER,CHIP

C418 C-CER,CHIP

C345 C-CER,CHIP

C337 C-CER,CHIP

C439 C-CER,CHIP

C319 C-TA,CHIP

TA400 C-TA,CHIP

TA300 C-TA,CHIP

BAT300 C-

ETC

L110 INDUCTOR-SMD

L113 INDUCTOR-SMD

L111 INDUCTOR-SMD

L112 INDUCTOR-SMD

L115 INDUCTOR-SMD

L109 INDUCTOR-SMD

L102 INDUCTOR-SMD

L120 INDUCTOR-SMD

L116 INDUCTOR-SMD

L121 INDUCTOR-SMD

L101 INDUCTOR-SMD

L103 INDUCTOR-SMD

L100 INDUCTOR-SMD

L106 INDUCTOR-SMD

L107 INDUCTOR-SMD

L406 INDUCTOR-SMD

L407 INDUCTOR-SMD

L118 INDUCTOR-SMD

L412 INDUCTOR-SMD

L300 INDUCTOR-SMD

L400 INDUCTOR-SMD

OSC300 CRYSTAL-SMD

OSC100 CRYSTAL-SMD

F500 FILTER-EMI/ESD

6-6

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE DESIGN LOC DESCRIPTION

2901-001576

2904-001889

2904-001920

2909-001312

3301-001659

3301-001729

3404-001152

3705-001503

3708-002015

3709-001447

3709-001575

3710-002683

3711-005296

3711-005793

3711-006808

3722-003003

4202-001463

F501 FILTER-EMI/ESD

F502 FILTER-EMI/ESD

F503 FILTER-EMI/ESD

F504 FILTER-EMI/ESD

F102 FILTER-SAW

F101 FILTER-SAW

F100 FILTER-LC

L415 BEAD-SMD

L416 BEAD-SMD

L419 BEAD-SMD

L420 BEAD-SMD

L401 BEAD-SMD

L402 BEAD-SMD

L421 BEAD-SMD

L422 BEAD-SMD

TAC_CAM SWITCH-TACT

TAC_DN SWITCH-TACT

TAC_HOLD SWITCH-TACT

TAC_UP SWITCH-TACT

RFS100 CONNECTOR-COAXIAL

HDC500 CONNECTOR-FPC/FFC/PIC

SIM300 CONNECTOR-CARD EDGE

CD300 CONNECTOR-CARD EDGE

IFC400 SOCKET-INTERFACE

HDC503 HEADER-BOARD TO BOARD

HDC501 HEADER-BOARD TO BOARD

BTC300 HEADER-BATTERY

EAR400 JACK-EAR PHONE

ANT102 ANTENNA-CHIP

GH70-04132A SC100 ICT SHIELD-CAN CLIP

GH80-03320A R109 SHORT PAD

GH80-03320A R208 SHORT PAD

GH80-03320A R428 SHORT PAD

Please consult the GSPN website(Samsung Portal) for the most recent version of the product's part list.

6-7

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Block Diagrams

7.

7-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Block Diagrams

Y]to¡ j

7-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Block Diagrams

OY]to¡

OZYo¡

P

7-3

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

PCB Diagrams

8.

Top

8-1.

8-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization