Samsung B3410W Service Manual

GSM TELEPHONE

GT-B3410W

GSM TELEPHONE

CONTENTS

Safety Precautions

1.

Specification

2.

Product Function

3.

Array course control

4.

Exploded View and Parts list

5.

MAIN Electrical Parts List

6.

Block Diagrams

7.

PCB Diagrams

8.

Chart of Troubleshooting

9.

Reference data

10.

Disassembly and Assembly

11.
Instructions

Safety Precautions

1.

Repair Precaution

1-1.

Repair in Shield Box, during detailed tuning. Take specially care of tuning or test, because

―

specipicty of cellular phone is sensitive for surrounding interference(RF noise).

Be careful to useakind of magnetic object or tool, because performance of parts is damaged by

―

the influence of magnetic force.

Surely useastandard screwdriver when you disassemble this product, otherwise screw will be

―

worn away.

Useathicken twisted wire when you measure level.

―

thicken twisted wire has low resistance, therefore error of measurement is few.

A

Repair after separate Test Pack and Set because for short danger(for example an overcurrent

―

and furious flames of parts etc) when you repair board in condition of connecting Test Pack and

tuning on.

Take specially care of soldering, because Land of PCB is small and weak in heat.

―

Surely tune on/off while using AC power plug, becausearepair of battery charger is dangerous

―

when tuning ON/OFF PBA and Connector after disassembling charger.

Don't use as you pleases after change other material than replacement registered on SEC System.

―

Otherwise engineer in charge isn't charged with problem that you don't keep this rules.

1-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Safety Precautions

ESD(Electrostatically Sensitive Devices) Precaution

1-2.

Several semiconductor may be damaged easily by static electricity. Such parts are called by ESD

Electrostatically Sensitive Devices), for example IC,BGA chip etc. Read Precaution below.

(

You can prevent from ESD damage by static electricity.

Remove static electricity remained your body before you touch semiconductor or parts with

―

semiconductor. There are ways that you touch an earthed place or wear static electricity prevention

string on wrist.

Use earthed soldering steel when you connect or disconnect ESD.

―

Use soldering removing tool to break static electricity.,otherwise ESD will be damaged by static

―

electricity.

Don't unpack until you set up ESD on product. Because most of ESD are packed by box and

―

aluminum plate to have conductive power,they are prevented from static electricity.

You must maintain electric contact between ESD and place due to be set up until ESD is

―

connected completely to the proper place oracircuit board.

1-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Specification

2.

GSM General Specification

2-1.

GSM900

Phase 1

Freq.

Band[MHz]

Uplink/Downlink

ARFCN range

Tx/Rx spacing 45MHz 45MHz 95MHz 80MHz

Mod. Bit rate/

Bit Period

Time Slot

Period/Frame

Period

Modulation 0.3GMSK 0.3GMSK 0.3GMSK 0.3GMSK

MS Power 33dBm~5dBm 33dBm~5dBm 30dBm~0dBm 30dBm~0dBm

880~915
925~960

0~124 &

975~1023

270.833kbps

3.692us

576.9us

4.615ms

GSM850

Phase 1

824.2~848.8

869.2~893.8

128~251 512~885 512~810

270.833kbps

3.692us

576.9us

4.615ms

DCS1800

Phase 1

1710~1785
1805~1880

270.833kbps

3.692us

576.9us

4.615ms

PCS1900

1850~1910
1930~1990

270.833kbps

3.692us

576.9us

4.615ms

Power Class 5pcl ~ 19pcl 5pcl ~ 19pcl 0

Sensitivity -102dBm -102dBm -100dBm -100dBm

TDMAMux8888

Cell Radius 35Km 35Km 2Km -

pcl

~15

pcl

pcl

0

~15

pcl

2-1

Speclflcation

GSM Tx Power Class

2-2.

TX Power

control level

533±3

631±3

729±3

827±3

925±3

10 23±3

11 21±3

GSM
GSM900

850

dBm

dBm

dBm

dBm

dBm

dBm

dBm

TX Power

control level

030±3

128±3

226±3

324±3

422±3

520±3

618±3

DCS1800

dBm

dBm

dBm

dBm

dBm

dBm

dBm

TX Power

control level

030±3

128±3

226±3

324±3

422±3

520±3

618±3

PCS1

900

dBm

dBm

dBm

dBm

dBm

dBm

dBm

12 19±3

13 17±3

14 15±3

15 13±3

16 11±5

17 9±5

18 7±5

19 5±5

dBm

dBm

dBm

dBm

dBm

dBm

dBm

dBm

716±3

814±3

912±4

10 10±4

11 8±4

12 6±4

13 4±4

14 2±5

15 0±5

dBm

dBm

dBm

dBm

dBm

dBm

dBm

dBm

dBm

716±3

814±3

912±4

10 10±4

11 8±4

12 6±4

13 4±4

14 2±5

15 0±5

dBm

dBm

dBm

dBm

dBm

dBm

dBm

dBm

dBm

2-2

Product Function

3.

Main Function

Quad Band(850/900/1800/1900)

-

QWERTY KEY

-

-102.3ｘ52.4ｘ15.9

Mega Pixel Camera

-2

USB v2.0 High-speed, Bluetooth v2.1

-

WAP

-

MP3/AAC/AAC+/EAAC+/WMA

-

MicroSD Card Support

-

FM Radio

-

SMS/MMS/EMS(OMA v1.2)

-

2.0

Browser

mm

3-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

4.

Software Adjustments

4-1.

Test Jig(GH99

RF Test Cable(GH

-36900

39-00985

A)

A)

Test Cable(GH

Adapter(GH

39-01160

99-38251

A)

A)

4-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

Software Downloading

4-2.

4-2-1.

ㆍ
ㆍ
ㆍ
ㆍ

4-2-1.

■

Pre-requsite for Downloading

Downloader Program
GT-B3410W Mobile Phone
Data Cable
Binary files

S/W Downloader Program

Load the binary download program by executing the

1.

(Downloader V5.62)

"Downloader V5.62"

4-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

Select the

2.

BRCM2133".

"

as Control.

4-3

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

Select the Full Download.

3.

4-4

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

Load the file of Boot, Amss, Apps, Rsrc

4.

you saved the binary files.

Rsrc2, Factory FS from the folder that

1.

4-5

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

Click the

5.

Port Search

button

en the download cable is connected to PC.

wh

cf. You have to set the phone asadownload mode by pressing Volume down

Camera+End key simultaneously before connecting to PC

4-6

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

.

+

Then the down loader can search the port.

6.

Array course control

4-7

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

Click the

7.

Download

It will start to download.

button

en the Port searched.

wh

When downloading is finished successfully, there is

8.

4-8

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

All files complete"message.

a"

Exploded View and Parts List

5.

5-1.

Cellular phone Exploded View

QME03

QFU01

QVO01

QCL02

QKP02

QME02

QCR03

QVK01

QVK03

QIF01

QFR01

QCK01

QCR68

QKP01

QME01

QCK02

QMP01

QAR01

QLC01

QPC01

QFL01

QSC01

QCR72

QHI01

QCR68

QHI02

QLC02

QMI01

QSP01

QCA01

QCR96

QAN02

QRE01

QCR03

QBA01

QBC01

5-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Exploded View and Parts List

5-2.

Cellular phone Parts list

Design LOC Description SEC CODE

QAR01 AUDIO-RECEIVER

QCR03 SCREW-MACHINE

QCR03 SCREW-MACHINE

QCR72 SCREW-MACHINE

QCR68 SCREW-MACHINE

QCR96 SCREW-MACHINE

3009-001409

6001-001811

6001-001811

6001-002051

6001-002067

6001-002259

QMI01 MICROPHONE-ASSY-GT-B3410 GH30-00618A

QAN02 INTENNA-MAIN(GT-B3410W) GH42-02397A

QBA01 INNER BATTERY PACK-AB463651BU,960MAH GH43-03216A

QLC02 ASSY ETC-LCD MAIN PBA(GT-B3410) GH59-08336A

QME02 KEY FPCB-SUB KEY PBA(GT-B3410) GH59-08347A

QPC01 KEY FPCB-SLIDE FPCB ASSY(GT-B3410) GH59-08348A

QME01 DOME SHEET-TF,GT-B3410 GH59-08349A

QSP01 MODULE-SPK+MOT MODULE(B3410W) GH59-08359B

QVK03 KEY FPCB-HOLD KEY,GT-B3410 GH59-08381A

QVK01 KEY FPCB-VOL KEY,GT-B3410 GH59-08382A

QCK02 KEY FPCB-CAM KEY,GT-B3410 GH59-08388A

QME03 TOUCH/PANEL-TSP,B3410W(BLK) GH59-08996A

QVO01 PMO KEY-VOL GH72-56591D

QCK01 PMO KEY-CAMERA GH72-56592D

QCL02 PMO KEY-SIDE GH72-56595D

QKP01 RMO KEY-QWERTY_SPAIN GH73-13578D

QSC01 TAPE-SCREW CAP GH74-46962D

QMP01 A/S ASSY-PBA MAIN(COMM)GT-B3410W GH82-04693A

QLC01 ASSY LCD-2.6" TFT(GT-B3410) GH96-04098A

QCA01 ASSY CAMERA-MODULE,GT-B3410W(2M) GH96-04341A

QKP02 ASSY KEYPAD-SUB GH98-15082A

QBC01 ASSY COVER-BATT GH98-15453C

QFU01 ASSY CASE-SLIDE UPPER GH98-16043A

QRE01 ASSY CASE-REAR GH98-16044A

QFR01 ASSY CASE-FRONT GH98-15068D

QIF01 PMO COVER-IF GH72-56587D

QFL01 ASSY CASE-SLIDE LOWER GH98-15071D

QCR68 SCREW-MACHINE

QHI01 ASSY HINGE-SLIDE

QHI02 ASSY HINGE-SLIDE

L

R

6001-002067

GH98-15072D

GH98-15073D

5-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

MAIN Electrical Parts List

6.

SEC CODE Design LOC DESCRIPTION

0403-001688

0404-001504

0406-001267

0406-001267

0406-001281

0406-001286

0406-001286

0601-002048

0601-002048

0801-003026

0801-003130

1001-001447

1001-001547

1001-001581

1001-001607

1009-001036

1108-000296

1201-002675

1201-002933

1203-004983

1203-006176

1205-003656

1205-003809

1205-003839

1205-003868

1404-001221

2007-000143

2007-000144

2007-000144

2007-000162

2007-000172

2007-000172

2007-001291

2007-001341

2007-003001

2007-003018

ZD300

ZD100,ZD101

ZD301,ZD302,ZD303

ZD304,ZD407

ZD305,ZD403,ZD404

ZD400,ZD401,ZD405

ZD406

LED400,LED401,LED402 SSC-SWTS907

LED403 SSC-SWTS907

U300 IC

U200 IC

U302 IC

U400 IC

U100 IC

U103 IC

U303 IC

UME200 MEMORY

U301 IC

PAM100 IC

U304 IC

PM300 IC

UCP200 IC

U305 IC

U101 IC

U102 IC

VR200

R200

R209,R217,R218,R219

R220

R101,R102,R224

R318,R415,R416,R417

R418

R305,R306

R404

R313

R116,R117

DIODE
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE

THERMISTOR
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP

6-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE Design LOC DESCRIPTION

2007-007014

2007-007132

2007-007156

2007-007312

2007-007315

2007-007981

2007-008045

2007-008045

2007-008052

2007-008055

2007-008055

2007-008055

2007-008211

2007-008275

2007-008401

2007-008486

2007-008516

2007-008517

2007-008531

2007-008531

2007-008548

2007-008588

2007-008588

2007-008806

2007-008806

2203-000233

2203-000233

2203-000254

2203-000254

2203-000278

2203-000359

2203-000386

2203-000386

2203-000425

2203-000438

2203-000585

R303,R304

R109,R110

R228

R221

R225

R201,R202

R100,R215,R300,R322

R405

R316,R317

R106,R107,R111,R113

R114,R314,R400,R409

R410,R420

R312

R308

R205

R212

R213

R206

R319,R324,R408,R421

R426

R222,R223

R203,R204,R407,R413

R414,R425

R310,R311,R320,R321

R406,R422

C133,C137,C140,C141

C145,C237,C241,C404

C116,C224,C240,C316

C408

C104,C115

L120,L124

C310,C311,C357,C358

C416,C418,C419

C221

C232,C402,C403

C242

R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP

6-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE Design LOC DESCRIPTION

2203-000627

2203-000696

2203-000812

2203-000854

2203-000995

2203-001072

2203-001101

2203-002668

2203-002677

2203-003054

2203-005056

2203-005057

2203-005234

2203-005383

2203-005450

2203-005682

2203-006048

2203-006048

2203-006048

2203-006048

2203-006048

2203-006120

2203-006194

2203-006260

2203-006348

2203-006399

2203-006399

2203-006423

2203-006423

2203-006556

2203-006562

2203-006611

2203-006668

2203-006681

2203-006681

2203-006824

C305,C307

C149

C144,C146

C201,C231

C218,C411,C420

C124,C132,C138

C225

L121

C143,L113

C129

C121

C131

C134

C233,C234

C125

C348

C117,C118,C205,C210

C212,C213,C214,C215

C219,C308,C324,C326

C347,C410,C412,C414

C415

C361,C400,C407

C103

C130

C300,C322,C351

C107,C127,C200,C202

C306,C325,C335,C346

C152,C220,C314,C315

C327,C349,C350,C406

C230

C303,C352

C229

C301,C323

C216,C217,C227,C228

C401

C101

C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP

6-3

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE Design LOC DESCRIPTION

2203-006825

2203-006838

2203-006839

2203-006841

2203-006872

2203-006872

2203-006872

2203-006872

2203-006890

2203-007133

2203-007210

2203-007270

2203-007279

2203-007317

2203-007317

2203-007369

2203-007369

2203-007369

2203-007369

2203-007369

2203-007369

2203-007391

2404-001377

2404-001430

2409-001172

2703-001726

2703-001729

2703-002203

2703-002205

2703-002207

2703-002208

2703-002268

2703-002269

2703-002281

2703-002308

2703-002367

C345

C100

C105,C106,C108,C128

C109

C113,C114,C126,C207

C208,C222,C223,C226

C332,C333,C341,C342

C343,C344

C318,C319

C413

C111,C112

C147

C302

C102,C110,C119,C120

C203,C204

C206,C209,C211,C236

C238,C304,C320,C328

C329,C330,C331,C334

C336,C337,C338,C339

C340,C353,C354,C355

C356,C359

C122,C123,C317,C321

TA401

TA300

BAT300

L127,L128,L201

L115,L118

L107,L111

L106,L112

L119

L108,L109,L116,L117

L126

L110

L122,L123,L125,L129

L402,L407

L114

C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-CERAMIC,CHIP
C-TA,CHIP
C-TA,CHIP
CAPACITOR
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD

6-4

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE Design LOC DESCRIPTION

2703-003002

2703-003260

2703-003698

2801-004373

2801-004787

2801-004815

2901-001435

2901-001469

2901-001544

2904-001935

2904-001937

2909-001324

3301-001438

3301-001534

3301-001659

3301-001729

3301-001778

3301-001885

3301-001946

3705-001503

3708-002015

3709-001447

3709-001591

3710-002683

3711-006228

3711-006843

3711-006919

3722-003001

GH70-03276A SC100,SC101

GH71-08426A ANT103

L304

L302,L303

L104

OSC300

OSC200

OSC100

F301,F302

F300

F400

F101

F100

F102

L105

L100,L101

L102,L103,L200,L202

L410,L415

R323,R427,R428

L400,L401,L405,L406

L403,L404

RFS100

HDC400

SIM200

SD200

IFC400

BTC300

SOC300

SOC301

EAR400

INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
CRYSTAL-UNIT
CRYSTAL-UNIT
CRYSTAL-UNIT
FILTER-EMI
FILTER-EMI
FILTER-EMI
FILTER-SAW
FILTER-SAW
FILTER-DUPLEXER
CORE-FERRITE
CORE-FERRITE
CORE-FERRITE
CORE-FERRITE
CORE-FERRITE
CORE-FERRITE
CORE-FERRITE
CONNECTOR-COAXIAL
CONNECTOR-FPC/FFC/PIC
CONNECTOR-CARD
CONNECTOR-CARD
CONNECTOR-SOCKET
CONNECTOR-HEADER
CONNECTOR-HEADER
CONNECTOR-HEADER
JACK-PHONE
ONBOARD-CLIP
NPR-CONTACT

Please consult the GSPN website(Samsung Portal) for the most recent version of the product's part list.

6-5

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization