Salton GP300 User Manual

OWNER’S MANUAL

For Model: GP300

GEORGE FOREMAN

™

TM

Portable Propane Grill

IMPORTANT SAFEGUARDS

READ AND SAVE THESE INSTRUCTIONS

WARNING: A risk of fire or explosion exists in all propane grills.
Read this manual before use. Failure to follow all instructions may
result in serious personal injury, property damage, or death.

When using propane grills, basic safety precautions should always be fol­lowed to reduce the risk of fire and injury to persons, including the follow­ing:

1. Read all instructions before using the grill.

2. Do not touch hot surfaces. Use handles or knobs and oven mitts or
pot holders.

3. Keep children and pets away from the grill at all times.

4. This grill is not for use by children.

5. Do not leave this grill unattended while in use.

6. Do not move the grill when in use. Allow to cool before moving,
putting on or taking off parts, and before cleaning and storing the
grill.

7. To disconnect, turn Temperature Control Knob to LOCK/OFF.

8. Do not operate any grill after the grill malfunctions, or has been
dropped or damaged in any manner. Contact Consumer Service for
return authorization, examination, repair or adjustment.

9. The use of accessory attachments not recommended by the grill
manufacturer may cause injuries.

10. This grill is for outdoor use only. NEVER operate grill in enclosed
areas, as this could lead to gas accumulating from a leak, causing an
explosion or a carbon monoxide buildup which could result in injury
or death. DO NOT USE in garages, sheds or any enclosed areas.

11. Do not use grill for other than intended use.

12. Extreme caution must be used when moving a grill containing hot oil
or other hot liquids. Allow liquid to cool before removing and empty­ing Drip Container. Do not remove Grill Plate from Grill Body until Grill
is cool.

13. Do not attempt to dislodge food or clean the grill when it is hot.

14. Fuel, such as charcoal briquettes, is not to be used with this grill.

SAVE THESE INSTRUCTIONS

THIS GRILL IS NOT FOR COMMERCIAL USE.

FOR OUTDOOR USE ONLY.

322

Additional Important Safeguards

1. CAUTION: This grill generates heat and escaping steam during use.

Proper precautions must be taken to prevent the risk of burns, fires or
other damage to persons or property. Use of protective oven mitts or
gloves is recommended.

2. All users of this grill must read and understand this Owner's Manual before
operating or cleaning this grill.

3. When using this grill, provide adequate air space above and on all sides for
air circulation. Do not allow this grill to touch clothing, dish towels or other
flammable materials during use.

4. IMPORTANT: Minimum clearance of 16 inches around all sides of the grill
should always be maintained and the appliance shall not be located under
overhead unprotected combustible construction.

5. If this grill begins to malfunction during use, immediately turn the
Temperature Control Knob to LOCK/OFF. Do not use or attempt to repair the
malfunctioning grill.

6. This outdoor cooking gas grill is not intended for use in or on recreational
vehicles and/or boats.

7. The use of alcohol, prescription or non-prescription drugs may impair the
consumer’s ability to properly assemble or safely operate the grill.

8. When cooking with oil/grease, fire extinguishing materials shall be readily
accessible. In the event of an oil/grease fire do not attempt to extinguish
with water. Use Type BC dry chemical fire extinguisher or smother fire with
dirt, sand or baking soda.

9. In the event of rain while cooking with oil/grease, cover the cooking plate
immediately and turn off the grill burner and gas supply. Do not attempt to
move the grill or Grill Plate.

10. When cooking, the grill must be on a level and stable surface in an area
clear of combustible materials. An asphalt surface (blacktop) may not be
acceptable for this purpose.

11. Make sure the Temperature Control Knob is in the LOCK/OFF position when
placing the Grill Plate into position.

12. The grill is not intended for and should never be used as a heater.

13. Keep grill area clear and free from combustible materials, gasoline and
other flammable vapors and liquids.

14. Do not obstruct the flow of combustion and ventilation air.

15. Always open Cover before lighting your grill.

16. Do not attempt to disconnect the regulator or any gas fitting while the unit
is in operation.

17. Do not wear clothing with loose flowing sleeves while lighting or using the
grill.

18. Use barbecue tools with long, heat-resistant handles.

19. The grill should never face directly into the wind.

20. Do not operate grill in a high-traffic area.

21. After use, allow grill to cool completely before cleaning.

22. We recommend storing grill indoors or, if unable to store indoors, always
cover grill with protective cover. Always keep out of the reach of children.

4

Special Instructions for the Use of Regulator

and LP (Propane) Cylinders

• The propane grill is equipped with a regula­tor having a CGA No. 600 cylinder connec­tion device which is for connecting to a one
pound PROPANE cylinder ONLY. See
Illustration.

• Grill installation must conform with local
codes, or in the absence of local codes, with
the National Fuel Gas Code, ANSI
Z223.1/NFPA 54, Storage and Handling of
Liquefied Petroleum Gases, ANSI/NFPA 58 or CSA B149.1, Natural Gas and
Propane Installation Code.

• Use grill only with LP (propane) gas. Use grill only with the regulator/valve
assembly supplied.

• Never use charcoal briquettes or lighter fluid in a gas grill.

• Discard used and empty fuel cylinder in a safe place.

• Store spare fuel canisters in a well-ventilated area away from the grill.

• Do not puncture or burn fuel canister.

• Do not operate the grill if there is a gas leak present.

• Do not enlarge orifice or burner ports when cleaning the regulator and burner.

• If you smell gas, turn Temperature Control Knob to LOCK/OFF to shut off gas to
the grill. Extinguish any open flame and open Cover. If odor continues, immedi­ately call your gas supplier or your fire department.

• Do not store or use gasoline or other flammable vapors and liquids in the
vicinity of this or any other grill.

• An LP cylinder not connected for use shall not be stored in the vicinity of this
or any other appliance.

• The LP-gas supply cylinder to be used must be constructed and marked in
accordance with the specifications for LP-gas cylinders of the U.S.
Department of Transportation (DOT) or the National Standard of Canada,
CAN/CSA-B339, Cylinders, Spheres and Tubes for the Transportation of
Dangerous Goods.

• If the grill is not in use, the Temperature Control Knob must be turned to
LOCK/OFF to shut off the gas cylinder. Storage of a grill indoors is permissible
only if the cylinder is disconnected and removed from the grill. Cylinders must
be stored outdoors out of the reach of children and must not be stored in a
building, garage or any other enclosed area.

• The regulator may make a humming or whistling noise during operation. This
will not affect safety or use of grill.

• Save cylinder cap and reinstall when not in use.

• Cylinder supply system must be arranged for vapor withdrawal. The gas cylin­der must be upright in use. Do not block the pressure relief valve during use
or storage.

• Always remove one pound cylinder from grill when transporting and when not
in use.

CGA No. 600

520

Getting To Know Your GP300 Propane Grill

13

12

11

10

9

14

15

16

17

18

8

7

6

SIDE VIEW - BASE ASSEMBLY

5

4

4

3
2

20

19

21

22

23

24

1

1. Base Support Ring (P/N 22156)

2. Front Support Foot (P/N 22157)

3. Storage Case/Stand (P/N 22162)

4. Latch (4) (P/N 22161)

5. Transport Handle/Drip Container
Holder

6. Match Holder (P/N 21656)

7. Flame Viewing Hole

8. Burner Guard

9. Side Tray, Left, with Utensil Rack
(P/N 22163L)

10. Reflector

11. Grill Cover (P/N 22165)

12 Handle (P/N 22166)

13. Grill Plate (P/N 22167)

14. Grill Body

15. Burner Assembly

16. Temperature Control Knob
(P/N 21647)

17. Regulator (P/N 22185)

18. Side Tray, Right (P/N 22163R)

19. Ignitor Button

20. Ignitor Assembly (P/N 22186)

21. Drip Container with Lid (P/N 22168)

22. Rear Support Leg (P/N 22159)

23. Wheel (2) (P/N 22160)

24 Securing Rod (P/N 22171)

6

Before First Use

1. Remove the grill and any packaging materials from the shipping carton.

2. Place the Storage Case/Stand on a flat, level surface.

3. Unlatch the Storage Case/Stand and raise the Storage Case/Stand cover.
Remove the Base Support Ring and the grill assembly.

4. Open the Grill Cover, remove the Drip Container and swing both Side Trays
out to the side to remove the Grill Plate.

5. Wipe the Storage Case/Stand, Grill Body and Side Trays with a damp cloth
to remove any dust. Wash the Grill Plate and Drip Container in warm, soapy
water. Rinse and dry thoroughly.

6. The Handle Assembly and
mounting hardware are pack­aged separately in a plastic
bag. Remove all parts, then
properly position the Handle on
the front of the Grill Cover with
the screws in the Handle facing
down. From the inside of the
Grill Cover, place one of the
Screws and Washers through
the hole in one side of the Cover
and into the Handle. Repeat with
the other side of the Handle. Securely fasten both Screws with a Phillips
head screw driver. See Figure 1.

7. See "Grill Positions" and "Assembly Instructions" on the following pages.

Figure 1

Handle

Screw/
Washer

Cover

Grill Positions

The Wheel-It and Grill-It™Portable
Propane Grill is compact enough to trans­port to any grilling location. Wheel-It from
the storage shed to the patio, to a picnic
in the park, or off on a camping trip. The
Portable Propane Grill easily transforms
from storage to transport and to the
Grill-It position.

Storage Position: This position makes the
grill compact enough for space saving
storage. The Side Trays fold inside the grill
allowing the entire grill assembly to be
stored neatly and securely in the Storage
Case/Stand. See "Storing Your Propane
Grill" on page 17.

7

Figure 2

Grill Positions (Cont.)

Transport Position: To

transform the grill from the
Storage Position to the
Transport Position, lift the
Transport Handle/Drip
Container Holder out from
the closed position
roll away

Grilling Position: This
position is ideal for patio
use, beach barbeques,
camping sites, tail-gate
parties or picnics in the
park. See "Assembly
Instructions" on page 9.

.

and

Transport Handle/Drip Container
Holder

Figure 3

WARNING: DO NOT
MOVE THE GRILL WHILE
THE GRILL IS IN USE.

Figure 4