Salton GP200RED User Manual

OWNER’S MANUAL

For Model: GP200RED

GEORGE FOREMAN

™

TM

Portable Propane Grill

FOR YOUR SAFETY

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open Lid.

4. If odor continues, immediately call your gas supplier or your
fire department.

FOR YOUR SAFETY

1. Do not store or use gasoline or other flammable vapors and
liquids in the vicinity of this or any other appliance.

2. An LP cylinder not connected for use shall not be stored in
the vicinity of this or any other appliance.

WARNING

1. Do not store spare LP cylinder within 10 feet (3 m) of this
appliance.

2. Do not store or use gasoline or other flammable liquids or
vapors within 25 feet (8 m) of this appliance.

2

IMPORTANT SAFEGUARDS

READ AND SAVE THESE INSTRUCTIONS

WARNING: A risk of fire or explosion exists in all propane grills.
Read this manual before use. Failure to follow all instructions
may result in serious personal injury, property damage, or death.

When using propane grills, basic safety precautions should always be
followed to reduce the risk of fire and injury to persons, including the
following:

1. Read all instructions before using the grill.

2. Do not touch hot surfaces. Use handles or knobs and oven mitts or
pot holders.

3. Keep children and pets away from the grill at all times.

4. This grill is not for use by children.

5. Do not leave this grill unattended while in use.

6. Do not move the grill when in use. Allow to cool before moving,
putting on or taking off parts, and before cleaning and storing the
grill.

7. To disconnect, turn Temperature Control Knob to LOCK/OFF.

8. Do not operate any grill after the grill malfunctions, or has been
dropped or damaged in any manner. Contact Consumer Service for
return authorization, examination, repair or adjustment.

9. The use of accessory attachments not recommended by the grill
manufacturer may cause injuries.

10. This grill is for outdoor use only. NEVER operate grill in enclosed
areas, as this could lead to gas accumulating from a leak, causing
an explosion or a carbon monoxide buildup which could result in
injury or death. DO NOT USE in garages, sheds or any enclosed
areas.

11. Do not use grill for other than intended use.

12. Extreme caution must be used when moving a grill containing hot oil
or other hot liquids. Allow liquid to cool before removing and empty­ing Drip Tray. Do not remove Grill from Base until Grill is cool.

13. Do not attempt to dislodge food or clean the grill when it is hot.

14. Fuel, such as charcoal briquettes, is not to be used with this grill.

SAVE THESE INSTRUCTIONS

THIS GRILL IS NOT FOR COMMERCIAL USE.

FOR OUTDOOR USE ONLY.

3

Additional Important Safeguards

1. CAUTION: This grill generates heat and escaping steam during use.

Proper precautions must be taken to prevent the risk of burns, fires or
other damage to persons or property. Use of protective oven mitts or
gloves is recommended.

2. All users of this grill must read and understand this Owner's Manual before
operating or cleaning this grill.

3. When using this grill, provide adequate air space above and on all sides for
air circulation. Do not allow this grill to touch clothing, dish towels or other
flammable materials during use.

4. IMPORTANT: Minimum clearance of 16 inches around all sides of the grill
should always be maintained and the appliance shall not be located under
overhead unprotected combustible construction.

5. If this grill begins to malfunction during use, immediately turn the
Temperature Control Knob to LOCK/OFF. Do not use or attempt to repair the
malfunctioning grill.

6. This outdoor cooking gas grill is not intended for use in or on recreational
vehicles and/or boats.

7. The use of alcohol, prescription or non-prescription drugs may impair the
consumer’s ability to properly assemble or safely operate the grill.

8. When cooking with oil/grease, fire extinguishing materials shall be readily
accessible. In the event of an oil/grease fire do not attempt to extinguish
with water. Use Type BC dry chemical fire extinguisher or smother fire with
dirt, sand or baking soda.

9. In the event of rain while cooking with oil/grease, turn off the grill burner
and gas supply, and immediately cover the Grill Plate. Do not attempt to
move the grill or Grill Plate.

10. When cooking, the grill must be on a level and stable surface in an area
clear of combustible materials. An asphalt surface (blacktop) may not be
acceptable for this purpose.

11. Make sure the grill is in the LOCK/OFF position when placing the Grill Plate
into position.

12. The grill is not intended for and should never be used as a heater.

13. Keep grill area clear and free from combustible materials, gasoline and
other flammable vapors and liquids.

14. Do not obstruct the flow of combustion and ventilation air.

15. Always remove lid before lighting your grill.

16. Do not attempt to disconnect the regulator or any gas fitting while the unit
is in operation.

17. Do not wear clothing with loose flowing sleeves while lighting or using the
grill.

18. Use barbecue tools with long, heat-resistant handles.

19. The grill should never face directly into the wind.

20. Do not operate Grill in a high-traffic area.

21. After use, allow Grill to cool completely before cleaning.

22. We recommend storing Grill indoors or, if unable to store indoors, always
cover Grill with protective cover. Always keep out of the reach of children.

4

Special Instructions for the Use of Regulator

.550 Min

(13.96mm)

.850 - .935

(21.58 - 23.75mm)

.666 - .750

(16.92 - 19.05mm)

and LP (Propane) Cylinders

• The propane grill is equipped with a regulator
having a CGA No. 600 cylinder connection

CGA No. 600

device which is for connecting to a one pound
PROPANE cylinder ONLY. See Illustration.

• Grill installation must conform with local
codes, or in the absence of local codes, with
the National Fuel Gas Code, ANSI Z223.1,
Storage and Handling of Liquefied Petroleum
Gases, ANSI/NFPA 58 or CSA B149.1, Natural
Gas and Propane Installation Code.

• Use grill only with LP (propane) gas. Use grill only with the regulator/valve
assembly supplied.

• Never use charcoal briquettes or lighter fluid in a gas grill.

•Discard used and empty fuel cylinder in a safe place.

• Store spare fuel canisters in a well-ventilated area away from the grill.

• Do not puncture or burn fuel canister.

• Do not operate the grill if there is a gas leak present.

• Do not enlarge orifice or burner ports when cleaning the regulator and burner.

• If you smell gas, turn Temperature Control Knob to LOCK/OFF to shut off gas to
the grill. Extinguish any open flame and open Lid. If odor continues, immedi­ately call your gas supplier or your fire department.

• Do not store or use gasoline or other flammable vapors and liquids in the
vicinity of this or any other grill.

• An LP cylinder not connected for use shall not be stored in the vicinity of this
or any other appliance.

• The LP-gas supply cylinder to be used must be constructed and marked in
accordance with the specifications for LP-gas cylinders of the U.S.
Department of Transportation (DOT) CFR 49 or the National Standard of
Canada, CAN/CSA-B339, Cylinders, Spheres and Tubes for the Transportation
of Dangerous Goods.

• If the grill is not in use, the Temperature Control Knob must be turned to
LOCK/OFF to shut off the gas cylinder. Storage of a grill indoors is permissible
only if the cylinder is disconnected and removed from the grill. Cylinders must
be stored outdoors out of the reach of children and must not be stored in a
building, garage or any other enclosed area.

• The regulator may make a humming or whistling noise during operation. This
will not affect safety or use of grill.

• Save cylinder cap and reinstall when not in use.

• Cylinder supply system must be arranged for vapor withdrawal. The gas cylin­der must be upright in use. Do not block the pressure relief valve during use
or storage.

• Always remove one pound cylinder from grill when transporting and when not
in use.

5

Getting To Know Your GP200RED Propane Grill

1

2

}

3

24

4

5

6

7

8

9

10

11

12

13

1. Lid Handle/Vent (P/N 21659)

2. Lid Assembly (P/N 21680)

3. Screw/Washer (P/N 21661)

4. Ignitor Assembly (P/N 21648)

5. Ignitor Button

6. Temperature Control Knob (P/N 21647)

7. Regulator (P/N 21663)

8. Side Tray, Left (P/N 21688)

9. Flame Viewing Hole

10. Match Holder (P/N 21656)

11. Transport Handle (P/N 21684)

12. Wheel/Leg Frame (P/N 21681)

13. Wheel (2) (P/N 21687)

23

22

21

20

19

18

17

16

14

14. Securing Rod (P/N 21686)

15. Apron

16. Storage Arm (2) (P/N 21682)

17. Storage/Leg Frame (P/N 21685)

18. Base Plate (P/N 21683)

19. Burner Assembly

20. Side Tray, Right (P/N 21689)

21. Grill Base

22. Side Tray Support Tube/Locking Clip
(P/N 21690)

23. Drip Tray (P/N 21646)

24. Grill Plate (P/N 21645)

6

15

Before First Use

1. Remove the Grill and any packaging materials.

2. Place the Base Frame on a flat, level surface.

3. Lift off the Side Trays and set them to the side. Disconnect the Storage
Arms from the Wheel/Leg Frame to allow access to the Grill Assembly.

4. Remove the Grill Plate, Grill Base, Lid and Drip Tray. Wipe the Grill Base and
Lid with a damp cloth to remove any dust. Wash the Grill Plate and Drip
Tray in warm, soapy water. Rinse
and dry thoroughly.

5. The Handle/Vent and mounting
hardware, (Screw/Washer) are
shipped in an inverted fashion,
requiring minor assembly.
Remove the Handle/Vent from
the inside of the Lid by unscrew­ing the Screw/Washer. Remove
all parts, then properly position
the Handle/Vent on the top of the
Lid. Make sure the Handle/Vent stop pin enters the Vent slot in the Lid. From
the inside of the Lid, place the Screw/Washer through the hole in the Lid
and Handle/Vent. Securely fasten with a Phillips head screw driver. See
Figure 1.

6. Slide the Drip Tray into the slots in the Grill Base.

7. See "Grilling Positions" on the following pages and place the Grill Base on
the Base Frame.

8. Place the Grill Plate on the Grill Base and place the Lid over the Grill Plate.

Figure 1

Handle/Vent

Vent Slot

Lid

Screw/Washer

Grill Positions

The Wheel-It and Grill-It™Portable
Propane Grill is compact enough to
transport to any grilling location.
Wheel-It from the storage shed to the
patio, to a picnic in the park, or off on
a camping trip. The Portable Propane
Grill easily transforms from storage to
transport and to high or low Grill-It
positions.

Storage Position: This position
makes the Grill compact enough for
space saving storage. The Side Trays
are stored on the Leg Assemblies and
the Transport Handle slides into the
top of the Frame.

Figure 2

7

Grill Positions (Cont.)

Transport Position: To

transform the Grill from
the Storage Position to
the Transport Position,
slide out the Transport
Handle from the closed
position

and roll away

Low Grilling Position:

Using the Grill in the
Low Position is great
for beach barbeques,
camping sites, tail-gate
parties or picnics in the
park.

Transport
Handle

.

Figure 3

To transform the Grill
from the Transport Position to
the Low Grilling Position, slide
the Transport Handle into the
Frame, remove both Side
Trays, then lay the GP200RED
down.

Disconnect the Storage Arms
from the Leg Assemblies. Lift
the Grill Assembly from the
Base Frame and set it to the
side, then reconnect the
Storage Arms.

Slots For
Drip Tray

Locator Pegs

Figure 4

8