Sakrete Concrete Mortar Dissolver
Safety Data Sheet
according to the Hazard Communication
Date of issue
Product name
:
Sakrete Concrete Mortar Dissolver
Product code
Not available
Use of the substance/mixture
:
Various
Emergency number
:
CHEMTREC (800) 424-9300
CHEMTREC International +1 (703) 527-3887 24 hr
Skin C orrosion 1B
Serious Eye Damage 1
Hazard pictograms (GHS-US)
:
Signal word (GHS-US)
:
Danger
Hazard statements (GHS-US)
:
Causes severe skin burns and eye damage
Precautionary statements (GHS-US)
:
Do not breathe dusts or mists. Wash hands thoroughly after handling. Wear protective
gloves/protective clothing/eye protection/face protect i on. If swallowed: Ri nse mouth. Do NOT
induce vomiting. Immediately call a poison center/doctor. If on skin (or hair): Take off
immediately all contaminated clothing. Rinse skin with water/shower.
clothing before reuse. Immediately call a poison center/doctor. If inhaled: Remove person to
fresh air and keep comfortable for breathing. Immediately call a poison center/doctor. If in eyes:
Rinse cautiously with water for several minute
do. Continue rinsing. Immediately call a poison center/doctor. Store locked up. Dispose of
contents and container in accordance with all local, regional, national and international
regulations.
Standard (CFR29 1910.1200) HazCom 2012
SECTION 1: Identification of the substance/mixture and of the company/undertaking
1.1. Product identifier
1.2. Relevant identified uses of the substance or mixture and uses advised against
1.3. Details of the supplier of the safety data sheet
Sakrete of North America
8201 Arrowridge Blvd.
Charlotte, NC 28273
T 866-725-7383
1.4. Emergency telephone number
SECTION 2: Hazards identification
2.1. Classification of the substance or mixture GHS-US classification
2.2. Label elements GHS-US labelling
: 04/08/2015 Revision date: 04/08/2015 Version: 1.0
2.3. Other hazards
GHS05
No additional information available.
2.4. Unknown acute toxicity (GHS US)
Not applicable.
SECTION 3: Composition/information on ingredients
3.1. Substance
Not applicable.
04/08/2015 EN (English)
Wash contaminated
s. Remove contact lenses, if present and easy to
Page 1
Sakrete Concrete Mortar Dissolver
Safety Data Sheet
according to the Hazard Communication
Name
Product identifier
%
GHS-US classification
Glycolic acid
(CAS No) 79-14-1
10 - 30
Acute Tox. 4 (Oral)
Skin Corr. 1B
Lauryldimethylamine oxide
1643-20-5
1 - 5
Skin Irrit. 2
Eye Dam. 1
First-aid measures after inhalation
:
If inhaled, remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult,
give oxygen. Get medical attention immediately.
First-aid measures after skin contact
:
In case of contact, immediately flush skin with plenty of water. Remove contaminated clothing
and shoes. Wash clothing before reuse. Get medical attention
First-aid measures after eye contact
:
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes. If easy to
do, remove contact lenses, if worn. Get medical attention immediately.
First-aid measures after ingestion
:
If swallowed, do NOT induce vomiting unless directed to do so by medical personnel. Never
give anything by mouth to an unconscious person. Get medical attention immediately.
Symptoms/i nj uri es after i nhal ation
:
May be harmful if inhaled. May cause burns.
Symptoms/injuries after skin contact
:
Causes severe skin burns. Symptoms may include redness, pain, blisters.
Symptoms/injuries after eye contact
:
Causes serious eye damage. Symptoms may include discomfort or pain, excess blinking and
tear production, with marked redness and swelling of the conjunctiva. May cause burns.
Symptoms/injuries after ingestion
:
May be harmful if swallowed. May cause stomach distress, nausea or vomiting. May cause burns.
Suitable extinguishing media
:
Treat for surrounding material.
Unsuitable extinguishing media
:
None known.
Fire hazard
:
Products of combustion may include, and are not limited to: oxides of carbon.
Protection during firefighting
:
Keep upwind of fire. Wear full fire fighting turn-out gear (full Bunker gear) and respiratory
protection (SCBA).
General measures
:
Use personal protection recommended in Section 8. Isolate the hazard area and deny entry to
unnecessary and unprotected personnel. Avoid cont
For containment
:
Contain spill and neutralize with sodium bicarbonate and flush with water. Do not wash unneutralized product into sewers or waterways. If on site neutral
spill with inert material (e.g. sand, vermiculite), then place in a suitable container.
Methods for cleaning up
:
Scoop up material and place in a disposal container. Provide vent i l ation.
Precautions for safe handling
:
Do not get in eyes, on skin, or on clothing. Do not swallow. Do not breathe gas/mist/vapors/
spray.
Hygiene measures
:
Wash hands before eating, drinking, or smoking. Launder contaminated clothing before reuse.
3.2. Mixture
* The exact percentage (concentration) of composition has been withheld as a trade secret in accordance with paragraph (i) of §1910.1200.
SECTION 4: First aid measures
4.1. Description of first aid measures
Standard (CFR29 1910.1200) HazCom 2012
Acute Tox. 4 (Inhalation)
(CAS No)
immediately.
4.2. Most important symptoms and effects, both acute and delayed
4.3. Indication of any immediate medical attention and special treatment needed
Symptoms may not appear immediately. In case of accident or if you feel unwell, seek medical advice immediately (show the label or SDS where possible).
SECTION 5: Firefighting measures
5.1. Extinguishing media
5.2. Special hazards arising from the substance or mixture
5.3. Advice for firefighters
SECTION 6: Accidental release measures
6.1. Personal precautions, protective equipment and emergency procedures
6.2. Methods and material for containment and cleaning up
act with skin and eyes.
6.3. Reference to other sections
See section 8 for further information on protective clothing and equipment and section 13 for advice on waste disposal.
SECTION 7: Handling and storage
7.1. Precautions for safe handling
Handle and open container with care. When using do not eat, drink or smoke.
04/08/2015 EN (English)
ization is not possible, absorb
2/5
Sakrete Concrete Mortar Dissolver
Safety Data Sheet
according to the Hazard Communication
Storage conditions
:
Keep out of the reach of children. Keep container tightly closed. Store in a well-ventilated place.
Keep cool.
Glycolic acid (79-14-1)
ACGIH
Not applicable
OSHA
Not applicable
Lauryldimethylamine oxide (1643-20-5)
ACGIH
Not applicable
OSHA
Not applicable
Appropriate engineering controls
:
Use ventilation adequate to keep exposures (airborne levels of dust, fume, vapor, etc.) below
recommended exposure limits.
Hand protection
:
Wear chemically resistant protective gloves.
Eye protection
:
Wear approved eye protection (properly fitted dust- or splash-proof chemical safety goggles)
and face protection (face shield).
Skin and body protection
:
Wear suitable protective clothing.
Respiratory protection
:
In case of insufficient ventilation, wear suitable respiratory equipment. Respirator selection
must be based on known or anticipated exposure levels, the hazards of the product and the
safe working limits of the selected respirator.
Environmental exposure controls
:
Maintain levels below Community environmental protection thresholds.
Other information
:
Do not eat, smoke or drink where material is handled, processed or stored. Wash hands carefully
before eating or smoking. Handle according to established industrial hygiene and safety practices.
Physical state
:
Liquid
Appearance
No data available
Colour
:
Green
Odour
:
Low odor
Odour threshold
:
No data available
pH : 1.3
Melting point
:
No data available
Freezing point
:
10 °C (50 °F)
Boiling point
:
93.3 °C (200 °F)
Flash point
:
No data available
Relative evaporation rate (butylacetate=1)
:
< 1 Flammability (solid, gas)
:
Not flammable
Explosive limits
:
No data available
Explosive properties
:
No data available
Oxidising properties
:
No data available
Vapour pressure
:
No data available
Relative density
:
1.25 - 1.29 @ 15.6 °C (60 °F)
Relative vapour density at 20 °C
:
No data available
Solubility
:
Partially soluble
Partition coefficient: n-octanol/water
:
No data available
Log Kow
:
No data available
Auto-ignition temperature
:
No data available
Decomposition temperature
:
No data available
7.2. Conditions for safe storage, including any incompatibilities
Standard (CFR29 1910.1200) HazCom 2012
7.3. Specific end use(s)
Not available.
SECTION 8: Exposure controls/personal protection
8.1. Control parameters
8.2. Exposure controls
SECTION 9: Physical and chemical properties
9.1. Information on basic physical and chemical properties
04/08/2015 EN (English)
3/5
Sakrete Concrete Mortar Dissolver
Safety Data Sheet
according to the Hazard Communication
Viscosity
:
No data available
Viscosity, kinematic
:
No data available
Viscosity, dynamic
:
No data available
Acute toxicity
:
Not classified.
Sakrete Concrete Mortar Dissolver
LD50 oral rat
> 2000 mg/kg
LD50 dermal rabbit
> 2000 mg/kg
LC50 inhalation rat
> 20 mg/l/4h
Glycolic acid (79-14-1)
LD50 oral rat
1950 mg/kg
Lauryldimethylamine oxide (1643-20-5)
LD50 oral mouse
2700 mg/kg
Skin corrosion/irritation
:
Causes severe skin burns.
Serious eye damage/irritation
:
Causes serious eye damage.
Respiratory or skin sensitisation
:
Based on available data, the classification criteria are not met.
Germ cell mutagenicity
:
Based on available data, the classification criteria are not met.
Carcinogenicity
:
Based on available data, the classification criteria are not met.
Reproductive toxicity
:
Based on available data, the classification criteria are not met.
Specific target organ toxicity (single exposure)
:
Based on available data, the classification criteria are not met.
Specific target organ toxicity (repeated exposure)
:
Based on available data, the classification criteria are not met.
Aspiration hazard
:
Based on available data, the classification criteria are not met.
Symptoms/injuries after inhalation
:
May be harmful if inhaled. May cause burns.
Symptoms/injuries after skin contact
:
Causes severe skin burns. Symptoms may include redness, pain, blisters.
Symptoms/injuries after eye contact
:
Causes serious eye damage. Symptoms may include discomfort or pain, excess blinking and
tear production, with marked redness and swelling of the conjunctiva. May cause burns.
Symptoms/injuries after ingestion
:
May be harmful if swallowed. May cause stomach distress, nausea or vomiting. May cause burns.
Ecology - general
:
May cause long-term adverse effects in the aquatic environment.
9.2. Other information
No additional information available.
SECTION 10: Stability and reactivity
10.1. Reactivity
No dangerous reaction known under conditions of normal use.
10.2. Chemical stability
Stable under normal storage conditions.
10.3. Possibility of hazardous reactions
No dangerous reaction known under conditions of normal use.
10.4. Conditions to avoid
Heat. Incompatible materials.
10.5. Incompatible ma terials
Bases. Oxidizing agents. Reducing agents.
10.6. Hazardous decomposition products
May include, and are not limited to: oxides of carbon.
SECTION 11: Toxicological information
11.1. Information on toxicological effects
Standard (CFR29 1910.1200) HazCom 2012
SECTION 12: Ecological information
12.1. Toxicity
04/08/2015 EN (English)
4/5
Sakrete Concrete Mortar Dissolver
Safety Data Sheet
according to the Hazard Communication
Sakrete Concrete Mortar Dissolver
Persistence and degradability
Not established.
Sakrete Concrete Mortar Dissolver
Bioaccumulative potential
Not established.
Effect on the global warming
:
No known ecological damage caused by this product.
Waste disposal recommendations
:
This material must be disposed of in accordance with all local, state, provincial, and federal
regulations. The generation of waste should be avoided or minimized wherever possible.
UN-No.(DOT)
:
UN1760
Department of Transportation (DOT) Hazard Classes
8
Proper Shipping Name (DOT)
:
Corrosive liquids, n.o.s. (Glycolic acid)
Hazard labels (DOT)
:
Packing group (DOT)
:
II
Other information
:
No supplementary information available.
Special transport precautions
:
Do not handle until all safety precautions have been read and understood.
All components of this product are listed, or excluded from listing, on the United States Environmental Protection Agency Toxic Substances
Control Act (TSCA) inventory.
Sakrete Concrete Mortar Dissolver
State or local regulations
This product does not contain a chemical known to the State of California to cause cancer,
Date of issue
:
04/08/2015
Other information
:
None.
12.2. Persistence and degradability
12.3. Bioaccumulative potential
12.4. Mobility in soil
No additional information available.
12.5. Other adverse effects
SECTION 13: Disposal considerations
13.1. Waste treatment methods
SECTION 14: Transport information
Department of Transportation (DOT)
In accordance with DOT
Standard (CFR29 1910.1200) HazCom 2012
Additional information
SECTION 15: Regulatory information
15.1. US Federal regulations
15.2. US State regulations
SECTION 16: Other information
birth defects or other reproductive harm.
Disclaimer: We believe the statements, technical information and recommendations contained herein are reliable, but they are given without warranty or guarantee of any kind. The information contained
in this document applies to this specific material as supplied. It may not be valid for this material if it is used in combination with any other materials. It is the user’s responsibility to satisfy oneself as to the
suitability and completeness of this information for the user’s own particular use.
04/08/2015 EN (English)
5/5
Loading...